2000 Chevrolet Malibu
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 944 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Malibu model years with reports.
Of the 2000 reports, 47 involved a crash and 7 involved a fire. 37 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Exterior lighting, hazard flashing warning lights, switchAug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Campaign 03V327000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, filler pipe and capOct 29, 1999
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN THE TANK IS MORE THAN HALF FULL.
IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.
DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.
Campaign 99V302000 on NHTSA.gov
Representative owner complaints: electrical system
207 reports, newest first. Show all
Service brakes, Hydraulic, Fuel system, Gasoline, Electrical system, Equipment, Oct 20, 2001
3 MONTHS AFTER I BOUGHT MALIBU IN JULY, 2000 I WAS DRIVING AT 65 MPH WHEN MY CARE LOST ALL POWER. DEALER TOLD ME THAT THERE WAS SOMETHING WRONG WITH THE FUEL INDICATOR WIRING AND WAS FALSELY READING THE AMOUNT OF GAS I HAD WHICH RESULTED IN MY RUNNING OUT OF GAS AT 65MPH. PROBLEM HAS NOT REPEATED ITSELF. AT 21,000 MILES MY SIGNAL INDICATOR LIGHTS FAILED AND MY HAZARD SWITCH HAD TO BE REPLACED. AT 23,000 MILES MY EVAPORATOR VENT VALVE HAD TO BE REPLACE (ENGINE LIGHT REMAINED ON CONSTANTLY). AT 20,000 MILES MY CAR WAS VIBRATING WHENEVER MY BRAKES WERE APPLIED. DEALOR SAID FRONT BRAKES WORN OUT AND ROTORS OUT OF ROUND AND THEY REPLACED THE FRONT BRAKES AND REFACED THE ROTORS. AT 33,000 MILES, CARE AGAIN VITRATED WHENVER BRAKES APPLIED AND DEALER TOLD ME AGAIN THAT IT WAS NOT UNDER WARRANTY AND WAS HAPPENING BECAUSE OF "HOT SPOTS" AND THAT MY ROTORS NEEDED TO BE CUT EVEN THOUGH THEY HAD JUST BEEN FIXED AT 20,000 MILES. WAS NEVER TOLD THAT MANUFACTURER WAS HAVING A PROBLEM WITH MALIBU BRAKES AND WAS TOLD IT WOULD COST APPROXIAMTELY $700.00 TO FIX ROTORS AND IT WAS MY RESPONSIBILITY. MY SEVICE FOR THE BRAKES WAS DONE AT FUTURE CHEVROLET IN OLD BRIDGE, NJ. *AK
Service brakes, Hydraulic, Engine and engine cooling, Power train, Electrical system, Aug 26, 2001
WHILE DRIVING, VEHICLE WAS HESITANT AFTER STOPPING, TRANSMISSION WOULD BEGIN TO SHIFT EVERY 4 SECONDS, DEALER STATED THAT A PIECE OF METAL FROM THE FRONT PUMP OF THE TRANSMISSION HAD COME OFF AND SENT PIECES OF METAL CIRCULATING THROUGH THE ENTIRE TRANSMISSION, CONSUMER WAS TOLD THAT SINCE THE TRANSMISSION WAS SEALED THAT IT WAS NOT ANTICIPATED THAT THE METAL PIECES WOULD AFFECT THE OTHER SYSTEMS OF THE VEHICLE, DEALER MADE REPAIRS AND ONE MILE DOWN THE ROAD TRANSMISSION BEGAN ACTING POORLY AGAIN, CONSUMER TOOK BACK TO DEALER WHO STATED THAT TRANSMISSION WAS STUCK IN SECOND GEAR, DEALER REPLACED TRANSMISSION. OXYGEN SENSOR FAILED. ROTORS WARPED AND WERE CAUSING VIBRATION, DEALER REPLACED PADS AND ROTORS. BATTERY LEAKED ACID INTO ENGINE COMPARTMENT. COOLANT CAP WAS DEFECTIVE AND REPLACED. *SLC
Service brakes, Hydraulic, Engine and engine cooling, Electrical system, Equipment, Jul 19, 2001
TICKING SOUND AT STARTUP THAT CHEVROLET WON'T FIX. NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
Electrical system, Jul 9, 2001
ENGINE CUT OFF WHILE DRIVING ON FREEWAY 6-8 TIMES. DEALER REPLACED WIRING AND STATED THEY HAVE BEEN HAVING THAT PROBLEM. 2 WEEKS LATER HAPPENED AGAIN. *AK
Service brakes, Hydraulic, Fuel system, Other, Electrical system, Seats, Equipment, May 31, 2001
BRAKES ON VEHICLE HAVE BEEN REPLACED THREE TIMES IN PAST YEAR. CONTACTED DEALER, AND THERE WAS NOT MUCH DEALER COULD DO. *AK ALSO, GAS GUAGE FAILED TWICE. THE PASSENGER SEAT RECLINER WAS DAMAGED. THE ELECTRIC OUT LET BROKE AND A/C HEATING SYSTEM FAILED. *YH
Service brakes, Hydraulic, Engine and engine cooling, Electrical system, Exterior lighting, Equipment, May 23, 2001
I BOUGHT MY 2000 MALIBU BRAND NEW IN SEPTEMBER 1999.... MY ENGINE WAS PINGING AND MAKING ALL KINDS OF NOISE, EVEN WHEN WARM.... BRAKES ARE VERY HAZARDOUS TO PUBLIC SAFETY... I HAVE BEEN TO THE DEALER NUMERIOUS TIMES FOR ROTOR AND PAD REPLACEMENTS AND EVEN GM'S SO CALLED NEW THICKER AND IMPROVED ROTORS THEY INSTALLED ON MY CAR WAS JUST AS BAD AS ALL THE OTHER ONES ... I ALMOST LOST CONTROL OF MY CAR WHEN I WAS TRAVELING 65 MILES PER HOUR ON OUR LOCAL HIGHWAY WHEN I WAS ALMOST HAD A WRECK DUE TO COMPLETE FAILURE OF MY BRAKES... MY CAR VIBRATED SO BADLY AND DID NOT SLOW DOWN...AT ALL!!....I THOUGHT I HAD 2 FRONT TIRE BLOWOUTS... I PULLED OVER ON THE EXPRESSWAY AND MY TIRES WERE FINE IT WAS MY BRAKES...... I WENT STRAIGHT TO A LOCAL AUTOZONE AND PURCHASED NEW ROTORS AND PADS....GM NEEDS TO ISSUE A RECALL ASAP BEFORE SOMEONE GETS SERIOUSLY INJURED OR KILLED!......I HAVE CALLED GM AND MADE A COMPLAINT AND WAS TOLD NO RECALLS WERE MADE..... ANOTHER ISSUE IM HAVING IS IT TAKES 3 OR 4 TIMES TO GET MY CAR STARTED ... NOT SURE WHY MY CAR IS HAVING ALL OF THESE PROBLEMS BUT IT IS AT A LOCAL GM DEALERSHIP AS I TYPE THIS .......I HOPE THEY WILL BE ABLE TO FIX THE NOISE FROM THE ENGINE AND MY CD PLAYER THAT GOES IN AND OUT OF POWER AND SOMETIMES WONT RELEASE MY CD'S .... I HAVE GIVEN UP ON GM BRAKES. *AK
Engine and engine cooling, Electrical system, Feb 3, 2000
VEHICLE SHUT DOWN MULTIPLE TIMES WHILE DRIVING, AND OCCASIONALLY DID NOT START. CONSUMER HAS TAKEN VEHICLE TO DEALER TWICE, THE O2 SENSOR HAS BEEN REPLACED, AND THE IGNITION SWITCH, WHICH WAS CAUSING THE PROBLEM, WAS ALSO REPLACED. *AK *ML