2000 Chevrolet Malibu
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 944 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Malibu model years with reports.
Of the 2000 reports, 47 involved a crash and 7 involved a fire. 37 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Exterior lighting, hazard flashing warning lights, switchAug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Campaign 03V327000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, filler pipe and capOct 29, 1999
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN THE TANK IS MORE THAN HALF FULL.
IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.
DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.
Campaign 99V302000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
174 reports, newest first. Show all
Engine and engine cooling, Fuel system, Gasoline, Sep 5, 2004
I AM THE OWNER OF A CHEVROLET MALIBU. THIS CAR IS VERY DANGEROUS AND SHOULD BE RECALLED. THE CAR WILL SHUT OFF WHEN DRIVING SPEEDS OF 55 OR MORE. I HAVE HAD NOTHING BUT PROBLEMS SINCE I PURCHASED THIS CAR. FIRST, IT WAS THE INTAKE MANIFOLD GASKET. SECOND, IT WAS SOMETHING WRONG WITH THE FUEL SYSTEM. THIRD, THE CAR QUIT ON ME AND MY DAUGHTER WHEN WE WERE DRIVING ON THE EXPRESS WAY GOING 60 MILES PER HOUR. WE COULD HAVE KILLED OURSELVES AND SOMEONE ELSE. *JB
Engine and engine cooling, Fuel system, Gasoline, Power train, Exterior lighting, Jul 20, 2004
AS READING OVER THE WEBSITE I NOTICE THE 2000 MALIBU IS PRETTY MUCH A LEMON. I HAVE HAD TO REPLACE THE RADIO, PRETTY MUCH EVERY GASKET IN THE ENGINE, THE FUEL PUMP, BRAKES FRONT AND REAR, NOW MY TURN SIGNALS DON'T WORK, JUST FOUND OUT ABOUT THE RECALL I HAVE TO CHECK TO SEE IF I QUALIFY, MY ENGINE KNOCKS ON COLD STARTS, AND IT PRACTICALLY LOSSES ALL POWER WHEN I GO TO ACCELERATE . . AND TOP IT OFF MY TRANSMISION SLIPS. . THIS VEHICLE NEEDS TO BE LOOKED INTO . . AND SOMETHING NEEDS TO BE DONE ABOUT IT. *JB
Engine and engine cooling, Jul 18, 2004
OIL LEAKED INTO COOLANT SYSTEM OF OUR 2000 CHEVROLET MALIBU REQUIRING REPLACEMENT OF THE INTAKE MANIFOLD GASKET AND FLUSHING OUT OF THE ENGINE. THIS ENGINE ONLY HAD 40,900 MILES ON IT. RESEARCH HAS SHOWN NUMEROUS COMPLAINTS FOR THIS PROBLEM ON THIS PARTICULAR GM ENGINE (3.1 LITER).
Engine and engine cooling, Jul 14, 2004
RECENTLY PURCHASED A 2000 CHEVROLET MALIBU WITH 61K MILES. DISCOVERED MULTIPLE PROBLEMS AS OTHERS HAVE DESCRIBED AND COVERED UNDER RECALLS, BUT SOME WHICH ARE NOT. WORST PROBLEM IS INTAKE GASKET IS LEAKING RESULTING IN COOLANT LEAK AND COOLANT MIXING WITH OIL. GM DEALER STATES THERE ARE NO CAMPAINS OR RECALLS ON THIS ITEM, ALTHOUGH I HAVE SEEN NUMEROUS COMPLAINTS OF THE SAME PROBLEM ON DOZENS OF WEBSITES.*AK
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Power train, Electrical system, Exterior lighting, Equipment, Jul 6, 2004
WE UNFORTUNATELY OWN A 2000 CHEVY MALIBU. WE HAVE ALREADY REPLACED THE ROTORS SEVERAL TIMES FOR GOING OUT OF ROUND. WE HAVE ALSO REPLACED THE FUEL PUMP AT LESS THEN 50,000 MILES AT THE COST OF $728.00. THE AIR CONDITIONER POPS ON AND OFF ON ITS OWN NOT COOLING FOR THE MOST PART. THE TURN SIGNALS ARE NONFUNCTIONAL AND OUR VIN NUMBER IS NOT INCLUDED IN THE RECALL ALTHOUGH IT SHOULD BE. THEN THERE IS THE TRANSMISSION SLIPPING AND THE COOLANT LEAKING AND THE CAR OVERHEATING WE ARE TOLD THIS IS A MANIFOLD INTAKE GASKET AND WILL COST AROUND 800.00 TO FIX. THE NEWEST PROBLEM IS THE FACTORY INSTALLED RADIO TUNER IS BURNED OUT AND NOW WE HAVE TO REPLACE THE RADIO COSTING YET ANOTHER $100.00 DOLLARS OR SO THIS CAR HAS NICKEL AND DIMED US TOO MUCH. AFTER LOOKING OVER YOUR SITE I FOUND THESE TO BE NUMEROUS COMPLAINTS ON THE SAME YEAR AND MODEL. I FEEL THIS CAR WAS A LEMON ACROSS THE BOARD NOT JUST OURS BUT, ALL 2000 MALIBU'S. PLEASE LOOK INTO THESE CARS ON A WHOLE THEY WERE VERY BADLY MANUFACTURED AND WE ALL DESERVE SOME COMPENSATION FOR IT. *JB
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Electrical system, Equipment, Jul 6, 2004
INTERMITTENTLY WHEN THE BRAKE PEDAL WAS APPLIED, THE BRAKES GRABBED SO HARD THAT THE ENTIRE VEHICLE VIBRATED SEVERELY. WHEN THIS OCCURRED, THE VEHICLE FAILED TO STOP IMMEDIATELY. THIS RESULTED IN EXTENDED STOPPING DISTANCE. THE BRAKE ROTORS WARPED. ON ONE OCCASION THIS FAILURE CAUSED LOST OF CONTROL, IN WHICH THE CONSUMER ALMOST CRASHED INTO AN 18 WHEELER, BUT WAS ABLE TO PULL OVER TO THE MEDIUM. THE DEALERSHIP HAS ACKNOWLEDGED THAT THERE WAS A PROBLEM WITH THE BRAKING SYSTEM, BUT WAS UNABLE TO CORRECT THE PROBLEM, AND WAS NOW REFUSING TO WORK ON THE VEHICLE. *AK THERE WAS A RATTLE UNDER THE HOOD AT THE FIREWALL AREA WHILE THE VEHICLE WAS IN MOTION, THE HOSE ASSEMBLY WAS FOUND RUBBING UNDER THE VEHICLE, BOTH FRONT ROTORS HAD WORE THIN, THE FUEL PUMP SENDER DID NOT HOLD THE CORRECT AMOUNT OF FUEL PRESSURE, THERE WAS AN OPEN CIRCUIT IN THE 24X CRANK SENSOR, THERE WAS A RATTLE IN THE FRONT SUSPENSION DUE TO WEAK FRONT LOWER CONTROL ARMS WHICH WERE NOISY (THE RIGHT LOWER CONTROL ARM WAS REPLACED), THE COOLANT LEVEL SENSOR SHORTED, THE WATER PUMP ASSEMBLY LEAKED COOLANT, THERE WAS A VIBRATION AT HIGHWAY SPEEDS, HARDWARE WAS BAD AND WAS LOOSE IN THE CALIPER, ROTOR PULSATION WHICH WAS REPLACED PER BULLETIN, THE TURN SIGNAL WAS INOPERATIVE, AND THE A/C HAD INTERNAL DAMAGE AND WOULD CUT ON AND OFF. *SC
Engine and engine cooling, Jul 1, 2004
AFTER STOPPING FOR AN ERRAND AND SEEING A PUDDLE OF COOLANT ON THE GROUND, THE VEHICLE WAS TAKEN TO THE LOCAL REPAIR SHOP TO HAVE THE LEAK CHECKED ON. THE REPAIR SHOP FOUND A LEAK IN THE LOWER INTAKE GASKET. THE SHOP ADVISED THAT THIS REPAIR WAS COMMON AND POSSIBLY CAUSED BY THE TYPE OF COOLANT USED AND POSSIBLY DEFECTS WITH THE GASKETS OR INTAKE MANIFOLD. THEY PROVIDED AND ESTIMATE FOR REPAIRS BETWEEN $600.00 AND $800.00 DEPENDING IF ANY FURTHER PROBLEMS WERE FOUND. THE DEALER WHERE THE CAR WAS PURCHASED (POLAR CHEV IN WHITE BEAR LAKE, MN) WAS CONTACTED ABOUT THE REPAIR AND REFUSED TO OFFER ANY ASSISTANCE IN REPAIRING THE VEHICLE. THE DEALER STATED THEY DO A LOT OF THESE REPAIRS ON THE MALIBU AND IMPALA BUT THE REPAIR IS NOT A WARRANTY ISSUE. THEIR CUSTOMER SERVICE WAS CONTACTED ALSO. THEY SAID NO SPECIAL CONSIDERATION OR BULLETINS ISSUED ABOUT COOLANT LEAKS ON THE 200 CHEV MALIBU. FROM RESEARCH ON THE ISSUE IT APPEARS TO BE A LARGE PROBLEM WITH THE VEHICLES AND CHEV REFUSES TO PROVIDE ANY ASSISTANCE. *JB
Engine and engine cooling, Jun 15, 2004
LIGHT FOR LOW WATER WOULD COME ON. ABOUT 3-4 TIMES EVERY 6 MONTHS STARTING 2002. THEN ALL OF A SUDDEN EVERY TIME THE CAR WAS DRIVEN, EVEN JUST A FEW BLOCKS. AT THAT POINT, THE CAR HAD TO BE TOWED TO THE DEALER FOR REPAIR. FORTUNATELY, I WAS NOT FAR FROM HOME WHEN THE MAJOR TROUBLE STARTED. THE REPAIR REPORT READS "LOW COOLANT LIGHT IS ON AND THE OIL APPEARS TO HAVE WATER MIXED... ADVISE... LOWER INTAKE MANIFOLD GASKETS LEAKING -REPLACED LOWER INTAKE MANIFOLD GASKETS. ALL RELATED GASKET/SEALS. 6 HOURS OF LABOR IN CARY, NC. TOTAL BILL $768. + $50 FOR TOWING. THE CAR ONLY HAS 36,000 MILES. THIS SEEMS A LOT FOR A RELATIVELY "YOUNG" CAR. THANK GOODNESS THE LOW WATER LIGHT WORKED -- BUT NO EXCUSE FOR THE PROBLEM. *AK
Engine and engine cooling, Equipment, Jun 8, 2004
MY 2000 MALIBU WHICH CURRENTLY HAS 50,000 MILES ON IT STARTED LOSING COOLANT AT ABOUT 48,000 MILES. I HAVE SPENT CLOSE TO $1,000 DOLLARS TRYING TO GET IT TO STOP LOSING FLUIDS. THE LAST REPAIR WAS A NEW GASKET SET PER SERVICE BULLITIN #03-06-01-010 DATED MARCH OF 2003. IS THERE ANY OTHER COURSE OF ACTION THAT I CAN TAKE. I CANNOT AFFORD ANY MORE EXPENSES ON IT. ALSO THE TURN SIGNALS SEEM TO FAIL WHEN MY CAR HEATER DOES NOT HEAT UP, THEY COME BACK IF I TURN MY EMERGENCY FLASERS ON AND THEN OFF. *AK
Engine and engine cooling, Fuel system, Gasoline, Exterior lighting, May 3, 2004
MY CAR HAS HAD THE SIGNAL LIGHTS REPLACED, THE FUEL PUMP REPLACED, & THE INTAKE MANIFOLD GASKET REPLACED ALL PROBLEMS W/ MY CAR BEFORE I HAD REPLACED WERE VERY DANGEROUS FOR ME & MY 2 CHILDREN. I WILL NEVER BUY OR REFER ANYONE TO BUY A CHEVORLET MALIBU . *AK
Suspension, Engine and engine cooling, Power train, Electrical system, Apr 18, 2004
I HAD THE CAR FOR 3 1/2 YEARS AND IT HAS GIVEN ME SO MANY PROBLEMS WITH MISFIRE SENSORS, CLICKING NOISE IN THE ENGINE, NOISE WHILE DRIVING OVER A BUMP OR HOLE, THIS IS BESIDES OTHER PROBLEMS LIKE WATER PUMP, FUEL PUMP, TRANSMISSION, CHECK ENGINE LIGHT ON THE DASHBOARD AND MUCH MORE. *JB
Engine and engine cooling, Exterior lighting, Apr 18, 2004
WATER PUMP FAILURE, TURNING LIGHTS FAILURE. *JB
Engine and engine cooling, Apr 13, 2004
INTAKE GASKET HAD TO BE REPLACED
Engine and engine cooling, Apr 8, 2004
HAD TO REPLACE THE INTAKE MANIFOLD AND GASKET ON MY 2000 CHEVY MALIBU. *AK
Engine and engine cooling, Mar 29, 2004
WHILE DRIVING TEMPERATURE GAUGE FAILED. THIS MADE IT IMPOSSIBLE FOR THE CONSUMER TO KNOW IF THE VEHICLE OVERHEATED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
Engine and engine cooling, Mar 24, 2004
VEHICLE : 2000 MALIBU VIN : [XXX] I'VE READ THAT THERE ARE TECHNICIAN NOTES, SENT BY GM CORP., ABOUT A DESIGN PROBLEM WITH THE 2000/2001 MALIBU V6 3.1 ENGINE FOR INTAKE MANIFOLD GASKET LEAKING AND FOR PISTONS,VALVE GUIDES AND LIFTERS WITH VALVES 1,2,3,4 AND GM'S REMEDY WITH UPDATED PARTS LIST TO REMEDY THE DESIGN PROBLEMS. MY VEHICLE IS ONE OF THESE WITH THE APPROPRIATE VIN #. I HAVE CONTACTED GM ASSISTANCE BUT HAVE ONLY RECEIVED A PERSON THAT TRANSMITS BUT DOES NOT RECEIVE IN THE CONVERSATION. I HAVE ALL THE MAINTENANCE RECORDS FOR OIL CHANGES, AIR & FUEL FILTERS ETC. SINCE I HAVE OWNED THE CAR. I ALSO HAVE COPIES OF GM CORPORATE BULLETINS TO THE TECHNICIANS ACKNOWLEDGING THE DESIGN FLAWS AND THE CORRECTIONS AND PARTS LIST TO REMEDY THE DESIGN FLAWS. I PURCHASED THIS VEHICLE USED, ONE YEAR OLD WITH 26,879 MILES. I HAVE ALSO TALKED TO 3 DIFFERENT TECHNICIANS WHO HAVE STATED THIS IS A DESIGN PROBLEM THAT GM HAS KNOWN ABOUT AND IS AN ONGOING PROBLEM. I PRESENTLY HAVE THE VEHICLE AT DON'S BROOKLYN CHEVROLET WHERE THEY ARE REPAIRING THE INTAKE MANIFOLD GASKET AND DIAGNOSING FURTHER PROBLEM WITH THE PISTONS AND LIFTERS. ROBBY STATES THE PISTONS NEED REPLACING TO ELIMNATE THE PROBLEM. I AM A LOYAL CHEVROLET CUSTOMER FOR OVER 30YRS AND CURRENTLY OWN A 1993 CHEVY LUMINA EUROSPORT, PURCHASED NEW, 2000 CHEVY MALIBU, PURCHASED USED 1 YR OLD, AND A 2002 CHEVY IMPALA LS, PURCHASED NEW, BEING A LOYAL CUSTOMER AND NEVER HAD A NEED BEFORE, I NEED ASSISTANCE AS THIS HAS BEEN A DESIGN FLAW THAT GM KNEW ABOUT, I DON'T FEEL I SHOULD HAVE TO PAY FOR GM'S PROBLEM. GM SHOULD REPAIR THE PROBLEMS NOW BEFORE AND ENGINE BLOWS ON THE FREEWAY OR ANYWHERE ELSE AND SOMEONE IS EITHER INJURED OR KILLED. PLEASE GIVE ME A CALL AT [XXX]. *JB UPDATED 07/30/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine and engine cooling, Mar 12, 2004
INTAKE MANIFOLD GASKET FAILED AT 49000 MILES. GM IS AWARE OF THE PROBLEM BUT WILL NOT TAKE ACTION ON IT. THE MOST DISCOURAGING THING ABOUT THE PROBLEM IS THE CONTEMPT THAT GM SEEMS TO HAVE FOR THEIR CONSUMERS. THEY RELEASED A TECHNICAL SERVICE BULLETIN TO THEIR DEALERS REGARDING THE PROBLEM, YET THEY DO NOTHING FOR THOSE AFFECTED BY AN OBVIOUS PRODUCT DEFECT. MY REQUEST FOR COST ASSISTANCE FROM GENERAL MOTORS WAS MET WITH A FLIPPANT ATTITUDE TOWARD THE LOSS OF MY LOYALTY AS A CUSTOMER.*AK
Engine and engine cooling, Mar 5, 2004
VEHICLE DIED UNEXPECTEDLY AT HIGHWAY SPEEDS. *AK
Engine and engine cooling, Mar 4, 2004
INTAKE MANIFOLD BEGAN LEAKING AT 45000 MILES (500 DOLLARS TO REPLACE), HAVE REPLACED THE BRAKES AND ROTORS 4 TIMES IN 65,000 MILES. THE TURN SIGNALS QUIT WORKING. WHILE DRIVING DOWN THE ROAD THE ENGINE JUST DIES. IF I LET IT SIT FOR A WHILE IT WILL CRANK BACK UP. ASE MECHANIC TOLD ME IT WAS THE IGNITION MODULE, SO I PAID TO HAVE IT REPLACED AND THAT DID NOT FIX IT. I HAVE BEEN REVIEWING FORUMS ON-LINE AND HAVE DISCOVERED THAT THIS IS A WIDE SPREAD AND SEVERE PROBLEM, I UNDERSTAND NORMAL WEAR AND TEAR ON A VEHICLE BUT THIS IS RIDICULOUS. AND LAST BUT NOT LEAST, THE FAN SWITCH HAS QUIT WORKING ON POSITONS (SPEEDS) 1 AND 2...THAT HAPPENED WHEN THE CAR HAD ABOUT 37,000 MILES ON (NOT UNDER FACTORY WARRANTY) ....I ONCE WAS A DIE HARD CHEVY MAN..THANKS TO THIS CAR I WILL NOT BUY ANOTHER GM PRODUCT. *AK
Service brakes, Hydraulic, Engine and engine cooling, Mar 3, 2004
2000 CHEVROLET MALIBU BOUGHT WITH 120,000 MILES ON IT. LESS THAN A WEEK AFTER GETTING THIS CAR FOR 5500.00, WHEN RETAIL ON THE CAR WAS 8300.00, I HAD TO REPLACE THE INTAKE MANIFOLD GASKET AND THE VALVE COVER GASKETS BECAUSE THEY WERE LEAKING COOLANT. ALSO, THE BRAKES SHUDDER AND VIBRATE WHENEVER APPLIED, EVEN AT SPEEDS LESS THAN 25 MPH. HALF A WEEK LATER, THE GAS GAUGE FELL TO ZERO WHILE NORMAL DRIVING AND THE LOW GAS LIGHT CAME ON, EVEN THOUGH I HAD JUST FILLED THE CAR UP TWO DAYS PRIOR. THERE WAS PLENTY OF GAS IN THE CAR, ABOUT 3/4 OF A TANK. ALSO, THE TRANMISSION IS SLIPPING NOW WHEN I SPEED UP. WHEN I SPEED UP THE CAR DOES NOT SHIFT INTO 1ST GEAR RIGHT AWAY UNTIL 4000 RPM. WHEN IT DOES SHIFT, IT SHIFT WITH A LARGE JOLT THAT SHAKES THE ENTIRE CAR. THERE WAS NO WARNING BEFORE THE GAS LIGHT CAME ON, AND I FIND THE CAR TO ONLY NOW HAVE ALL OF THESE PROBLEMS. ALSO, THE CAR SMELLS OF GASOLINE AND LEAKS, EVEN THOUGH I HAD IT FIXED. *AK
Engine and engine cooling, Feb 13, 2004
ANTIFREEZE USED IN OUR 2000 MALIBU HAS BEEN FOUND TO FREQUENTLY CAUSE DETERIORATION AND FAILURE OF THE INTAKE MANIFOLD GASKET. THERE HVE BEEN MANY CASES SITED ON THE INTERNET WITH NAMES AND SPECIFICS AND CHEVY/GMC REFUSES TO ADMIT IT IS THE ANTIFREEZE. THEY TOLD ME LAST NIGHT IT HAS TO DO WITH THE PLANT WHERE THE CAR WAS MADE.*AK
Engine and engine cooling, Feb 11, 2004
AT 55000 MILES HAD TO REPLACE LOWER INTAKE MANIFOLD GASKET. LOOKS LIKE IS A COMMON PROBLEM WITH THE MALIBU.GM MUST DO SOMETHING.*AK
Engine and engine cooling, Equipment, Jan 21, 2004
ON YOUR SITE I HAVE FOUND MANY COMPLAINTS REGARDING COOLANT LEAK DUE TO POOR SEALING OF THE MANIFLOD GASKET THAT ACCORDING THE SEVICE BULLETIN ON THIS SITE, REQUIRES NEW GASKET TYPE TO REPLACE THE OLD, AND THE INTAKE MANIFOLD BOLTS CLEANED AND COATED WITH THREDLOCKER AND TORQUED TO A REVISED SPEC. THIS HAS ALREADY BEEN DONE ONCE TO MY CAR AT ABOUT 30K MILES AND FORTUNATELY COVER UNDER WARRANTY, IF NOT IT WOULD HAVE COST ME $1050, PROBLEM IS NOW THE CAR IS DOING THE SAME THING AGAIN AT 79K MILES AND IS NO LONGER UNDER WARRANTY....HOW MANY TIMES SHOULD THIS HAPPEN? WAS THE SERVICE BULLETIN PUT OUT AS A PERMAMANT SOLUTION FOR THIS PROBLEM? IF NOT HOW LONG SHOULD THIS WORK BE GUARANTEED? WHY WAS THERE NOT A RECALL ON THIS PROBLEM? DOES THERE HAVE TO BE A FATALITY TO RECALL A VECHICLE? IN ADDITION I ALSO HAVE HAD THE PROBLEM WITH THE HAZARD WARNING SWITCH THAT ALSO EFFECTED THE WIPERS, NEITHER WOULD WORK, AGAIN THIS REPAIR WAS SUBMITTED AS WARRANTY WORK. I HAVE COMPLAINED SEVERAL TIMES TO BOB BELL CHEVY ABOUT HOW HOT THE DASH INSTRUMENTS GET TO TOUCH AND HAVE ALREADY HAD TO HAVE RELATED ELECTRICAL PROBLEMS REPAIRED, TO NOTE..WHEN I FIRST COMPLAINED ABOUT THE HEAT WHEN TOUCHED TO CHANGE INTRUMENT SETTINGS I WAS TOLD "THAT'S NORMAL". GRANTED MY EXTENDED WARRANTY COVERED SOME OF THE WORK BUT I STILL HAD TO PAY A $250 DEDUCTABLE W/EACH PROBLEM. ALL THESE PROBLEMS HAVE BEEN REPORTED ON THIS NHTSA SITE BY MANY PEOPLE AND ADDITION OTHERS I KNOW PERSONALLY AND WHO I HAVE HAD MANY DISCUSSIONS WITH ALSO HAVE THE SAME YEAR MALIBU WITH ALL THE SAME PROBLEMS....WHY HASN'T THE MANUFACT. RECALLED THE CAR FOR THESES PROBLEMS, SURELY ALL CAN CAUSE FIRE SAFETY PROBLEMS. HOW ARE RECALLS DETERMINED AND WHAT CAN WE ALL DO????????????? I NEVER DREAMED CHEVROLET WOULD BE SO CHEESY. MY LAST CAR WAS 12 YEARS OLD AND OLDS CUSTOM CRUISER WAGON - NEVER GAVE ME A PROBLEM THAT WAS SO MAJOR AS THESE NOTED HERE, I SHOULD HAVE NEVER GOT RID OF IT FOR THIS MALIBU!*AK
Service brakes, Air, Engine and engine cooling, Jan 16, 2004
VEHICLE EXPERIENCED A "TICKING NOISE IN THE ENGINE." *PH THE CONSUMER LEFT FRONT CALIPER BOLT IS STRIPPED CAUSING A VIBRATING/ GRINDING NOISE THAT RADIATES FROM THE LEFT FRONT WHEEL UNDER THE DRIVER SIDE WHEN THE VEHICLE COMES TO A COMPLETE STOP. WHEN THE DEALER WAS CONTACTED THEY STATED THAT THEY COULD NOT DUPLICATE THE PROBLEM. AND THE CONSUMER IS TRYING TO OBTAIN AN OVER ALL INSPECTION OF THE MECHANICAL DEFECTS OF THE VEHICLE SO GM CAN BE HELD RESPONSIBLE FOR THE FAULTY AUTOMOBILE. *CB
Service brakes, Hydraulic, Engine and engine cooling, Power train, Jan 15, 2004
THIS CAR HAS BEEN ONE PROBLEM AFTER ANOTHER. THE DAY AFTER WE LEASED THE CAR IT WAS IN THE SHOP FOR THE BRAKES, THE CAR HAS HAD 2 ENGINES IN IT. THE TRANSMISSION HAS BEEN REBUILT. THE BRAKES ARE STILL NOT CORRECT. TRANSMISSION IS SLIPPING AGAIN AND THE 3 YEAR WARRANTY IS UP. WE COMPLAINED TO CHEVROLET AND THE BBB. TO NO AVAIL THEY SEEMED TO BE ON CHEVROLET'S SIDE IN THE CASE. WE WERE TO THE POINT THAT WE WERE JUST GOING TO LET THE CAR GO BACK BUT THAT WOULD ONLY HURT MY HUSBAND'S CREDIT MORE THEN IT WAS ALREADY. WE HAD TO KEEP THE CAR THROUGH THE LEASE. THIS LEFT A REALLY BAD TAST IN MY MOUTH FOR PURCHASING NEW VEHICLES BECAUSE YOU ARE STUCK WITH IT FOR THE DURATION OF THE LEASE OR PURCHASE.