2000 Chevrolet Malibu
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 944 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Malibu model years with reports.
Of the 2000 reports, 47 involved a crash and 7 involved a fire. 37 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Exterior lighting, hazard flashing warning lights, switchAug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Campaign 03V327000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, filler pipe and capOct 29, 1999
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN THE TANK IS MORE THAN HALF FULL.
IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.
DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.
Campaign 99V302000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
174 reports, newest first. Show all
Engine and engine cooling, Equipment, Other or unspecified, Jan 15, 2004
I BOUGHT MY CAR ON 7/21/01, IT HAS BEEN IN FOR REPAIRS 10/3/01, 7/12/02,12/11/02, 6/23/03 AND 6/24/03. THE PROBLEM IS ELECTRICAL AND THE ENGINE AS WELL. CHEVROLET HAS RUN DIAGNOSTICS MANY TIMES BUT IS NOT ABLE TO FIX THE PROBLEM FOR GOOD. EVERYTIME I TAKE MY CAR IN, I AM TOLD IT'S NOW SOMETHING DIFFERENT THAT HAS BROKEN. MY CAR WILL BREAK DOWN AND SOMETIMES IF I ALLOW IT TO SIT FOR 10 - 20 MINUTES IT WILL START RIGHT BACK UP. FOR AS MANY TIMES AS MY CAR HAS BEEN REPAIRED, IT HAS BROKEN DOWN AT LEAST THREE TIMES BEFORE I TAKE IT IN. MY DISPUTE WITH CHEVY IS MY CAR IS A LEMON. THEY CANNOT DETERMINE WHAT IS WRONG WITH IT BECAUSE DIAGNOSTICS IS UNABLE TO DUPLICATE THE PROBLEM. CHEVY INFORMED ME THAT DOES NOT MEAN THERE ISN'T A PROBLEM IT JUST MEANS THE COMPUTER CANNOT DETECT IT. I HAVE FILED WITH THE BBB AUTO LINE BUT BECAUSE MY CAR HAS MORE THAN 24,000 MILES THEY SAY I AM OUT OF LUCK. CHEVY IS UNWILLING TO DO ANYTHING ABOUT THE PROBLEMS I AM HAVING WITH MY CAR. MY DISPUTE IS SHOULD A CAR BREAK DOWN AT LEAST 5-10 TIMES A YEAR?
Engine and engine cooling, Equipment, Other or unspecified, Jan 15, 2004
THE PAINT ON HOOD STARTED CHIPPING @ OR ABOUT 30K DEALER SAID NOT WARRANTY PROBLEM. BEGINNING APR 2002 CAR INTERMITANTLY HAS HAD A "SURGING" IMMEDIATELY AFTER STARTING & PUTTING IN GEAR. AT FIRST JUST 1 OR 2 TIMES IN 3 OR 4 MOS. NOW THE LAST 8-9 WEEKS IT HAS HAPPENED MORE & MORE FREQUENTLY, THEN 2 WEEKS AGO THE CRUISE CONTROL BECAME ERRATIC IN ACTIVATION & NOW WON'T WORK AT ALL.
Engine and engine cooling, Jan 15, 2004
THE LOWER INTAKE IS LEAKING COOLANT, CAUSING LOSS OF COOLANT OVER A SHORT PERIOD OF TIME CAUSING IT TO OVERHEAT. WITH THE EXTENDED WARRANTY IT WOULD NOT COVER IT UNLESS THE LOSS OF COOLANT CAUSED A HEAD GASKET TO BLOW OR ANOTHER TYPE OF MAJOR DAMAGE. I WORK WITH 2 OTHER PEOPLE THAT HAVE MALIBU'S AND THEY HAD THE SAME PROBLEM.
Service brakes, Hydraulic, Engine and engine cooling, Jan 15, 2004
A/C TURNS OFF OR GOES ON AND OFF (LIGHT FLASHES). DEALER STATES CAUSE AS FAILED CONTROL HEAD. BRAKES HAVE BEEN CHRONIC PULSING THAT CAUSES THE CAR TO SHUDDER, ESP. WHEN APPLYING BRAKES FROM SPEEDS OF 30+ MPH. AT VARIOUS REPAIR ATTEMPTS ROTORS HAVE BEEN TURNED, REPLACED (AT 22K MILES), NEW HUB ASSEMBLY INSTALLED. SIX ATTEMPTS WERE MADE TO REPAIR UNDER WARRANTY. JUST HAD NEW BRAKES AND SHIM KIT INSTALLED BUT DON'T TRUST THAT THIS WILL FIX PROBLEM BASED ON PAST EXPERIENCE.
Engine and engine cooling, Jan 15, 2004
VEHICLE OVER-HEATED, TAKEN TO DEALER WHICH HAD BEEN SERVICING THE VEHICLE SINCE NEW. DEALER REPLACED INTAKE MANIFOLD GASKETS AND WATER PUMP CHARGING $1400.00 THE VEHICLE ONLY HAD 24000 MILES ON IT AND WAS LESS THEN SIX MONTHS OUT OF WARRANTY. DEALER WOULD NOT WORK WITH ME AS A GOODWILL GESTURE. *CB
Service brakes, Hydraulic, Engine and engine cooling, Jan 2, 2004
2000 CHEVROLET MALIBU WITH PERSISTENT BRAKE PROBLEMS. HAVE TO REPLACE MAJOR BRAKE COMPONENTS EVERY APPROXIMATELY 20,000 MILES. ALSO, DEXCOOL COOLENT LEAK FROM THE INTAKE MANIFOLD AFTER ONLY (APPROX) 50,000 MILES. DEXCOOL COOLANT BREAKDOWN AND SUBSEQUENT FAILURE OF COOLING SYSTEM. *AK
Engine and engine cooling, Dec 18, 2003
LEAKING COOLANT FROM AROUND ENGINE BLOCK. DEALER DIAGNOSIS: LOWER INTAKE MANIFOLD GASKET LEAK. MILEAGE 30,000. PREVIOUS REPAIR COMPLETED ON WATER PUMP FOR BAD BEARINGS AT 28,800 MILES. MANUFACTURER SHOULD BE HELD ACCOUNTABLE FOR A DEFECTIVE COMPONENT USED IN THE BUILDING OF THESE MOTORS.*AK
Engine and engine cooling, Dec 17, 2003
THE ENGINE COOLANT CONSTANLY RUNS LOW OR EMPTY. I HAVE TO REFILL IT ALL THE TIME. NOW I FIND OUT I MIGHT HAVE A LEAK FROM THE COOLANT THAT IS RUNNING IN MY OIL. CAR ALSO HARD TO START SOMETIMES. I HAVE A FRIEND WHO HAS THE SAME PROBLEM WITH HAVING TO FILL UP THE ENGINE COOLANT CONSTANLY. SHE HAS A 2002 MODEL. HAVING TO FILL IT UP THAT OFTEN IS NOT NORMAL. *AK
Engine and engine cooling, Equipment, Dec 4, 2003
INDEPENDENT SHOP REPLACED THE INTAKE MANIFOLD AT OWNER EXPENSE OF $800. DOLLARS AND HAS HAD PROBLEMS WITH THE AIR CONDITIONER. DEALER NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. *PH
Engine and engine cooling, Nov 13, 2003
WHILE DRIVING AT 80 MPH VEHICLE STALLED. CONSUMER RESTARTED THE VEHICLE, AND WAS ABLE TO PULL OVER TO THE SHOULDER. CONSUMER HAD VEHICLE TOWED TO THE DEALER FOR ANALYSIS, BUT DEALER COULD NOT RESOLVE THE PROBLEM. *AK
Engine and engine cooling, Nov 12, 2003
MY 2000 CHEVROLET MALIBU (36,000 MILES) RECENTLY STALLED 4 TIMES WHILE I WAS DRIVING AT HIGH SPEEDS ON THE HIGHWAY. ON FRIDAY 10/7 I WAS GOING APPROXIMATELY 80 MPH WHEN THE CAR SUDDENLY TURNED OFF. I COASTED TO A STOP ON THE SHOULDER. IN ABOUT 5 MINUTES I WAS ABLE TO CUT THE CAR BACK ON. AT WHICH TIME IT RESUMED DRIVING NORMALLY FOR ABOUT 10 MILES. THEN IT STALLED AGAIN. I TOWED THE CAR INTO TOWN AND DROVE IT TO A REPAIR SHOP. (YES, THE CAR DROVE NORMALLY AROUND TOWN). THE REPAIR SHOP TESTED IT AND WAS UNABLE TO FIND ANYTHING WRONG. WHEN I PICKED THE CAR UP I DROVE ABOUT 40 MILES (AGAIN AT GREATER THAN 75 MPH) AND THE CAR STALLED AGAIN. IT STARTED BACK UP IN 2-3 MINUTES. THEN 30 MILES LATER STALLED AGAIN. THIS TIME ON A PART OF THE HIGHWAY WHERE THERE WAS NO SHOULDER! I COASTED THE CAR UNTIL THE SHOULDER REAPPEARED, PULLED ON TO IT AND RE-STARTED THE CAR. THE CAR DOES NOT SHOW ANY SYMPTOMS OF THE PROBLEM IN MY DAY-TO-DAY DRIVING AROUND TOWN. HOWEVER, IT IS NOT SUITABLE TO DRIVE FOR LONG DISTANCES OR AT HIGH SPEEDS DUE TO THIS CONDITION. *LA
Steering, Service brakes, Air, Engine and engine cooling, Fuel system, Other, Nov 8, 2003
I PUCHASED THIS CAR WITH 20000 MILES ON IT. I HAD IT FOR A LITTLE OVER 5 MONTHS AND I AM REPLACING A FUEL PUMP THAT WILL COST $650. THE POWER STEERING HAS CORROSION, SO THE POWER STEERING HAS TO BE FLUSHED. REPLACEMENT OF THE FUEL FILTER, A CRACKED FAN BELT, AND THROTTLE BODY SERVICE. I HAVE THE GM EXTENDED WARRANTY, BUT IT ONLY COVERS THE COST TO REPLACE THE FUEL PUMP. EVERYTHING ELSE IS OUT OF POCKET EXPENSES BECAUSE IT IS CONSIDERED "REGULAR MAINTENANCE". THE BRAKES ALSO GRIND AND SEEM TO TAKE TOO LONG FOR THE CAR TO STOP. SO I THINK BRAKES AREN'T FAR BEHIND TO BE REPLACED. I AM HOPING I WILL NOT NEED ROTORS TOO. I HAVE READ SO MANY COMPLAINTS ABOUT THE BRAKES ON THE 2000 CHEVY MALIBU. I TRY TO BUY AMERICAN BECAUSE I AM A PROUD ONE. BUT THE QUALITY SEEM TO BE SUBSTANDARD COMPARED TO JAPANESE CARS. MY NEXT CAR WILL BE FOREIGN. US CAR MAKERS NEED TO "STEP IT UP", AS FAR AS QUALITY WITH THESE CARS.*AK
Engine and engine cooling, Oct 25, 2003
COOLANT LOSS CAUSING VEHICLE TO OVERHEAT. CAR TOWED TO GARAGE. HAD TO REMOVE AND REPLACE INTATKE MANIFOLD GASKET, REPLACE THERMOSTAT, AND REVERSE FLUSH COOLING SYSTEM. TOTAL COST $664.31 WAS ADVISED TO FILE COMPLAINT AS GARAGE HAS HAD AN AVERAGE OF ONE REPAIR LIKE THIS A MONTH ON MAILBUS AND IMPALAS. *LA
Engine and engine cooling, Oct 21, 2003
WHILE DRIVING AT HIGHWAY SPEED VEHICLE WILL SUDDENLY STALL WITHOUT WARNING. AS A RESULT VEHICLE LOOSES POWER. WHEN THIS OCCURS CONSUMER HAS TO COAST VEHICLE TO A STOP.*AK
Engine and engine cooling, Oct 12, 2003
2000 MALIBU HAS DIED 7 TIMES WHILE DRIVING DEALER HAS REPLACED FUEL FILTER AND PUMP,RADAR CAP ,IGNITION MODULAR, IGNITION SWITCH,MAIN COMPUTER AND IT STILL DYING. I HAVE JUST LOOK AT ALL THE COMPLAINT THAT PEOPLE HAVE AND CHEVROLET TELLS ME THEY KNOW NOTHING ABOUT THEM.I WILL NEVER BUY OTHER ONE. *LA
Engine and engine cooling, Electrical system, Oct 6, 2003
I BOUGHT THIS CAR BRAND NEW (HAD 4 MILES ON IT) IN AUGUST OF 2000. WITHIN A MONTH, THE A/C MOTOR HAD TO BE REPLACED. WITHIN 6 MONTHS THE ENGINE BEGAN TO SURGE, AND FELT LIKE IT WAS GOING TO STALL WHENEVER AT A STOP. DURING THIS SAME PERIOD OF TIME, THE BRAKES BEGAN PULSATING, AND I REPLACED THEM ON MY OWN. I HAVE NOT HAD AN ISSUE WITH THEM SINCE. THEN THIS YEAR, 2003, IT COMPLETELY DIED ON ME WHILE DOING 70 IN RUSH HOUR TRAFFIC ON THE FREEWAY IN SAN DIEGO. MY WHOLE FAMILY WAS IN THE CAR, AND WE COULD HAVE BEEN KILLED. I COULDN'T EVEN TURN ON THE FLASHERS TO LET OTHER DRIVERS KNOW WE WERE IN TROUBLE. OBVIOUSLY, THE POWER STEERING WENT OUT, AND WE HAD TO CROSS THREE LANES OF TRAFFIC, SOLELY PROPELLED BY OUR EXISTING MOMENTUM, WITHOUT THE ABILITY TO STEER. I AM BEGINNING THE PROCESS OF TRYING TO ASSESS WHAT THE ISSUE IS, THOUGH I AM SURE IT IS THE ALTERNATOR. THE BATTERY WAS TESTED, AND DIAGNOSED AS PERFECT, OTHER THAN NEEDING A FULL RECHARGING (IT WAS DRAINED BY ANOTHER COMPONENT). ONCE I DETERMINE WHAT IS WRONG, I INTEND TO GO TO CHEVY, AND HARASS THEM UNTIL THEY FIX IT. THEN, I AM GOING TO TRY AND ENTER INTO ARBITRATION, AND HOPEFULLY GET RID OF THE CAR ALTOGETHER. IF ANYONE HAS THE "SOLUTION" TO THE STALLING PROBLEM, PLEASE EMAIL ME ! MJARAMILLO @ EXCITE . COM *JB
Engine and engine cooling, Fuel system, Other, Sep 9, 2003
FUEL GAUGE WILL NOT REGISTER A HALF TANK OR LESS. VEHICLE HAS TO HAVE A FULL FUEL TANK. ALSO, WITHOUT WARNING OR CAUSE VEHICLE WILL SHUT DOWN, AND WILL NOT RESTART. DEALERSHIP MECHANIC WAS BAFFLED BECAUSE HE COULD NOT DUPLICATE THE PROBLEM. *AK
Service brakes, Hydraulic, Engine and engine cooling, Exterior lighting, Visibility, Equipment, Aug 16, 2003
AIR CONDITIONER SWITCH TURNS ON AND OFF. VIBRATION IN FRONT END WHEN BRAKING. TURN SIGNALS WORK INTERMITENTLY. TICKING NOISE IN ENGINE UNTIL WARM. WINDOWS FOG EXCESSIVELY. SHAME ON CHEVROLET. *AK
Engine and engine cooling, Exterior lighting, Equipment, Aug 11, 2003
ENGINE OVERHEATING, ALSO THE TURN SIGNALS ARE ERRATIC, WHEN THEY DO NOT WORK I HAVE TO TURN MY EMERGENCY FLASHERS ON, THEN OFF, AND THE TURN SIGNALS WORK THEN. AS FAR AS THE OVERHEATING GOES, I TOOK IT IN FOR REPAIR (OVER $350.00) THEY SAID THEY FOUND WATER IN THE OIL AND REPLACED HEAD GASKET. IT STILL IS NOT FIXED. THIS CAR HAS 45,000 MILES.
Service brakes, Hydraulic, Engine and engine cooling, Tires, Equipment, Jul 27, 2003
MAY 02 MY VEHICLE WAS TAKEN IN FOR BRAKES AND FRONT END NOISE, THE BRAKES WERE REPLACED AND WAS TOLD THAT THE DEALERSHIP DID NOT HAVE TIME TO CORRECT THE FRONT END PROBLEM (WHICH THEY NOTED WAS COVERED BY MY WARRANTY) AND TO RESCHEDULE FOR THAT PROBLEM. I DID SO IN JULY 02 AND AT THAT TIME, THEY CHARGED ME FOR THE WORK AND TRIED TO BLAME ME FOR THE PROBLEM SO I PAID $281.75 FOR THIS WORK WHICH WAS PREVIOUSLY NOTED THAT WOULD BE COVERED BY MY WARRANTY. MY BATTERY HAS BEEN REPLACED 3 TIMES. THE VEHICLE WAS OVERHEATING SEVERAL TIMES: IN OCTOBER 3, 2002, OCTOBER 29, 2002, AND IN DECEMBER 2002. I WAS FORCED TO PAY FOR AT A COST OF $280.52 FOR THE DEC. 2002 PROBLEM. IN MARCH 2003 THE VEHICLE WAS TAKEN IN TO THE DEALERSHIP AGAIN FOR FRONT SUSPENSION NOISE, AND IT WAS DETERMINED THAT A RIGHT UPPER STRUT MOUNT HAD CALLAPSED. IN MAY 2003 THE VEHICLE HAS AGAIN OVERHEATED AND THEY COULD NOT EXPLAIN WHY THE PROBLEM CONTINUES. THE YOUNG MAN THAT I SPOKE WITH WHEN I ARRIVED INDICATED THAT THEY (THE DEALERSHIP) WAS UNSURE AS TO WHY THE VEHICLE WAS OVERHEATING AND TO JUST DRIVE IT BECAUSE HIS TRUCK DOES IT ALL THE TIME ON THE HIGHWAY AND THEY HAD NO EXPLANATION AS TO WHY THE BATTERIES THAT THEY WERE REPLACING KEPT CRACKING AND LEAKING. WHEN I EXPRESSED MY CONCERN REGARDING THE PROBLEM AND MY SAFETY CONCERNS, HE JUST BLEW ME OFF AS IF I WAS JUST COMPLAINING. ONCE AGAIN, IT IS NOW JULY 2003 AND FOR THE 4TH TIME, MY VEHICLE IS OVERHEATING AND OVERHEATING. IN ADDITION ON SERVERAL OCCASIONS I ALSO INDICATED TO THE DEALERSHIP, THAT THERE WAS A VIBRATING AND SHIMBLING WHEN MY BRAKES ARE APPLIED AND IT MAKES IT HARD TO CONTROLL THE VEHICLE, NOT ONCE WOULD THEY ADDRESS THE ISSUE WITH ME NOR HAVE I BEEN NOTIFIED OR ANY DEFECTS OR RECALLS WITH THE BRAKE SYSTEM FOR THE 2000 CHEVY MALIBU. I AM VERY CONCERNED WITH MY SAFETY. IN ADDITION, MY TIRES CONTINUOUSLY LOOSE AIR AND THE TREAD IS SEPARATION FROM MY LEFT REAR TIRE.*AK
Engine and engine cooling, Jul 16, 2003
MY CHEVROLET 2000 MALIBU LEAKED A WHOLE LOT OF DEXCOOL COOLENT ONTO THE GROUND...SO FAR, IT'S COST $900 TO FIX THAT AND A WATER PUMP. I'M NOT SURE THIS IS A SAFETY ISSUE, BUT IT SEEMS LIKE IT COULD BE CONSTRUED AS ONE. THE CAR HAS 5600 MILES ON IT.*AK
Engine and engine cooling, Jul 14, 2003
WE OWN A 2000 CHEVY MALIBU. THE HEAT/AIR REGULATOR DOES NOT WORK UNTIL IT IS MOVED TO THREE, FOUR OR FIVE. IT DOES NOT WORK ON ONE OR TWO. MY BROTHER OWNS 97 MALIBU WITH THE SAME PROBLEM AND MY SISTER HAS A 98 MALIBU WITH THE SAME PROBLEM.*AK
Engine and engine cooling, Electrical system, Jul 10, 2003
MY CAR IS ONLY 3 1/2 YRS. OLD, BUT, I'M HAVING PROBLEMS WITH IT THAT I SHOULDN'T BE HAVING. LAST SUMMER, I HAD TO HAVE MY BATTERY AND SURROUNDING WIRES & HOSES REPLACED DUE TO A CORRODED CABLE WHICH HAD LEAKED ACID EVERYWHERE--LUCKILY UNDER WARRANTY. NOW, MY INTAKE VALVE GASKET IS RUINED, SO ANTIFREEZE LEAKS OUT CONSTANTLY AND THE CAR IS PERPETUALLY ON THE VERGE OF RUNNING HOT. I HAVE TO CONSTANTLY ADD ANTIFREEZE AND WATER TO KEEP IT FROM OVERHEATING, ALTHOUGH, IT STILL SMELLS OVERHEATED ALL THE TIME. IT WILL COST ME BETWEEN $900-$1100 TO REPAIR THE PROBLEM, EVEN THOUGH THE PART ONLY COSTS $150 DUE TO THE LABOR INVOLVED IN REMOVING THE TOP OF THE ENGINE TO GET TO THE GASKET. SINCE THE WARRANTY HAS ALREADY RUN OUT, I'LL HAVE TO FOOT THE BILL MYSELF. I DON'T APPRECIATE THIS BECAUSE I SHOULDN'T BE HAVING THIS PROBLEM WITH THIS CAR AT THIS TIME, NOR DO I FEEL THAT IT IS MY RESPONSIBILITY TO FIX IT. THE DEALER OR MANUFACTURER SHOULD FOOT THE BILL SINCE THE CAR IS SO YOUNG AND THERE IS NO WAY THAT I CAUSED THIS PROBLEM. *AK
Suspension, Engine and engine cooling, Electrical system, Structure, Jun 23, 2003
I HAVE ENCOUNTERED THE FOLLOWING PROBLEMS IN THE YEAR SINCE I PURCHASED SAID VEHICLE: -SIGNAL &/OR HAZARD LIGHTS WORK PERIODICALLY -RADIO & LIGHTER SHORT OUT/BLOW FUSES -A/C NOT WORKING -A/C CUTS ON AUTOMATICALLY W/ RECIRCULATION BUTTON -VENT ONLY WORKS ON LEVEL 3 OR HIGHER -WATER PRESENT IN TRUNK -UNEVEN TIRE WEAR -ERRATIC GAS GAUGE READINGS -COOLANT RAN COMPLETELY OUT W/OUT REASON. *JB
Engine and engine cooling, Electrical system, Jun 16, 2003
I BOUGHT THIS CHEVROLET MALIBU LS IN 2000 AND ALREADY I HAVE THE FOLLOWING PROBLEMS: ALTERNATOR IS OUT, AIR COMPRESSER OUT, BLOWER MOTOR IS OUT, BATTERY IS OUT THEY ARE STILL CHECKING ON THE OIL LEAKAGE. *NLM