2000 Chevrolet Malibu
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 944 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Malibu model years with reports.
Of the 2000 reports, 47 involved a crash and 7 involved a fire. 37 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Exterior lighting, hazard flashing warning lights, switchAug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Campaign 03V327000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, filler pipe and capOct 29, 1999
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN THE TANK IS MORE THAN HALF FULL.
IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.
DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.
Campaign 99V302000 on NHTSA.gov
Representative owner complaints: fuel system
67 reports, newest first. Show all
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Electrical system, Tires, Apr 4, 2003
FRONT/REAR SUSPENSION-SQUAWKING NOISE -GM WELL AWARE OF THIS ISSUE HAZARD LIGHTS - HAVE GONE OUT TWICE. FUEL INTEGRITY - ERRATIC FUEL READING - SHOWS 1/4 TANK - WHEN IN REALITY THERE IS NO GAS. I HAVE RAN OUT OF GAS APPROXIMATELY 7 TIMES - SEVERAL TIMES LATE AT NIGHT. NO CRUISE CONTROL - GM WOULD NOT REPAIR. BRAKES PADS/ROTORS - HAVE REPLACED 3 TIMES. MY LOCAL DEALER ROTOLO CHEVROLET AND GM CUSTOMER SERVICE WOULD DO NOTHING. IT WAS EXPENSIVE. PREMATURE TIRE WEAR - TWO SETS OF TIRES. CARS RUNS HOT - WOULD NEVER GO ON A TRIP - BECAUSE IT WOULD GET TOO NEAR OVERHEATING. I WAS AFRAID OF GETTING STRANDED IN THE MIDDLE OF THE DESERT. ENGINE TICKING NOISE - LOCAL DEALER SAID THIS WAS NORMAL. NOW, I FIND NONE OF THESE THINGS WERE NORMAL AND MANY, MANY MORE CAR OWNERS HAVE EXPERIENCED THE SAME TYPE OF PROBLEMS. ALSO, I HAD A BATTERY THAT EXPLODED WHILE CAR WAS UNDER WARRANTY. IT WAS MY PROBLEM. DEALERSHIP WOULD NOT REPLACE BATTERY. I FINALLY HAD ENOUGH AND TURNED THIS AUTOMOBILE BACK TO GMAC. IS IT GOING TO TAKE PEOPLE GETTING KILLED TO MAKE GM RESPONSIBLE FOR THESE ISSUES WITH THE 2000 MALIBU. ALL OF THESE PROBLEMS WERE REPORTED TO THE DEALER, BUT SINCE NOTHING COULD BE DUPLICATED, EVEN THOUGH GM WAS AWARE OF THESE ISSUES, THEY WOULD DO NOTHING. AFTER THE CAR WAS OUT OF WARRANTY, THE DEALERSHIP WAS MORE THAN WILLING TO CORRECT THESE ISSUES. THE PROBLEM I HAVE IS THE DECEPTION.....GM IS AWARE OF THESE ISSUES AND HAVE BEEN FOR SOME TIME. SOMEONE NEEDS TO HOLD THEN ACCOUNTABLE. *JB
Fuel system, Gasoline, Mar 31, 2003
#5 FUEL INJECTOR HAS HAD TO BE REPLACED AT 27,963 MILES AND AT 58,736 MILES. REPAIR SHOP STATED THAT #5 FUEL INJECTOR IS LOCATED CLOSE TO THE EGR VALVE WHICH PUTS OFF A LOT OF HEAT AND MAY BE CONTRIBUTING TO THE PREMATURE FAILURE. *NLM
Fuel system, Gasoline, Mar 6, 2003
MY CAR KEPT DYING WHILE DRIVING DOWN THE ROAD. MY MECHANIC TOLD ME TO CONSIDER 1/4 TANK EMPTY, BECAUSE WHEN THE CAR GOT DOWN TO EMPTY, ALL THE GAS WAS IN THE LINES AND IT RUINED THE FUEL PUMP. IT HAS NOT HAPPENED SINCE I GOT A NEW FUEL PUMP. 8JB
Fuel system, Gasoline, Nov 30, 2002
I HAVE HAD PROBLEMS WITH THIS CAR EVERY SINCE I GOT IT. IT STARTED WITH THE BRAKES I HAD TO HAVE NEW BRAKES AND A MONTH LATER I HAD TO HAVE NEW ROWTERS BECAUSE THAT HAD A DEFECT. AND STILL HAVING PROBLEMS WITH THE NEW ROWTERS. THE ENGINE LIGHT WOULD COME ON AND THEY FINAL REPLACE THE FUEL TANK. BUT WHEN I TOOK IT IN BEFORE THE WARRANTY WENT OUT THEY SAID THEY COULD NOT FIND NOTHING WRONG WITH IT NOW THE WARRANTY WENT OUT MY GAS GAGE WOULD GO TO EMPTY WHEN WE ARE SITTING STILL AND WOULD GO BACK UP WHEN WE TAKE OFF. IT SHUT DOWN ON ME GOING DOWN THE FREEWAY. DT
Service brakes, Hydraulic, Fuel system, Gasoline, Tires, Aug 14, 2002
FRONT DISC BRAKE ROTORS ARE WARPING AGAIN AFTER BEING REPLACED AT 12000 MILES. WHEN BRAKES ARE APPLIED STEERING WHEEL VIBRATES EXCESSIVELY. DEALERSHIP IS DENYING ANY RESPONSIBILITY OF REPAIR. *AK THE FUEL PUMP FAILED AND WAS FIXED AT THE CONSUMER?S EXPENSE. THE TIRES BECAME WORN OUT AND WERE REPLACED. THE FRONT ROTORS WERE TURNED. *YH
Fuel system, Gasoline, Feb 28, 2002
WHILE DRIVING AND WITHOUT WARNING VEHICLE STALLS. TOOK VEHICLE TO DEALER,AND DEALER REPLACED INTAKE GASKET AND FUEL PUMP, BUT PROBLEM STILL EXISTS. *AK
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Visibility, Structure, Oct 28, 2001
BOUGHT MY CAR NEW OFF SHOW ROOM FLOOR AND HAVE HAD NUMEROUS PROBLEMS SINCE HAD IT IN FOR STARTING PROBLEMS BATTERY PROBLEMS FUEL PROBLEMS WINDOW PROBLEMS DOOR LOCK PROBLEMS ENGINE NOISE ENGINE OIL LEAKS VIBRATION PROBLEMS BRAKE PROBLEMS DYING PROBLEMS POPPING NOISES IN FRONT END STRUTS BOTTOMING OUT ROUGH RIDE AND STEERING PROBLEMS AND SO ON TOO MANY TO LIST ALL HAVE HAD FRONT END REALIGNED STUTS CHECKED AND REPALCED BRAKES CHECKED AND REPLACED WHEEL STUDS REPLACED FUEL PUMP AND FLOAT REPLACED PISTONS REPLACED BATTERY REPLACED REMOTE START SYSTEM REPLACED ALARM SYSTEM REPLACED WINDOW REGULATOR REPLACED FRONT CRANK SEAL REPLACED ALT CHECKED AND TESTED STARTED CHECKED STILL HAVING FUEL PROBLEMS BRAKE PROBLEMS VIBRATION ECT HAD IN THIS LAST WEEK FO 6 DAYS AND WHEN RETURNED STILL HAVING ENGINE NOISE STEERING PROBLEMS RADIO PROBLEMS FUEL PROBLEMS AND FOUND IMPACT MARK ON L/FRONT OF BUMPER ONE OF DEALERS TECH'S HIT SOMETHING AND NOW WANDERS TO LEFT LEFT HEAD LIGHT OUT OF LINE AND PUSHED BACK UNDER FENDER HOOD OUT OF LINE FENDERS BUMPERS DRIVING LIGHTS AND NUMEROUS OTHER PROBLEMS AND DAMAGE POSSIBLE THAT I AM UNABLE TO DETECT AT THIS TIME HAVE CONTACTED CHEVY AND COMPLAINED HAVE TALKED WITH DEALER AND STILL NO RESPONSIBILITY TAKEN AND STATEMENTS OF WE MIGHT HAVE BRUISED IT IT HAS BEEN WRECKED NOW I AMD PAYING GOOD MONEY FOR JUNK AND WANT REFUND OF ALL COSTS TO ME AND THE CAR TAKEN BACK ENGINES SHOULD NOT NEED TO BE OVERHAULED AT 14000 MILES THE CAR IS 2 YAERS OLD AND ACTS LIKE ITS 20 NEED RESPONESE AND INFO TO HELP RESOLVE PROBLEMS TRYING TO HAVE RETURNED UNDER LEMON LAW UNIFORM CONFORMITY ACT AND MAGNUSON-MOSS ACT CAR HAS BECOME INSTRUMENT THAT IS SUBSTANTIALLY IMPAIRED AND WHOSE OPPERATION IS FROUGHT WITH APPREHENSION SINCERLY UNHAPPY AND HURT CONSUMER IS THE HIGHWAY SAFTY DEVISION INTERESTED AND GOING TO DO ANYTHING FOR ALL OF US WHO ARE HAVING PROBLEMS OR ARE WE OUT OF LUCK ????????? RESPONSE REQUESTED
Service brakes, Hydraulic, Fuel system, Gasoline, Electrical system, Equipment, Oct 20, 2001
3 MONTHS AFTER I BOUGHT MALIBU IN JULY, 2000 I WAS DRIVING AT 65 MPH WHEN MY CARE LOST ALL POWER. DEALER TOLD ME THAT THERE WAS SOMETHING WRONG WITH THE FUEL INDICATOR WIRING AND WAS FALSELY READING THE AMOUNT OF GAS I HAD WHICH RESULTED IN MY RUNNING OUT OF GAS AT 65MPH. PROBLEM HAS NOT REPEATED ITSELF. AT 21,000 MILES MY SIGNAL INDICATOR LIGHTS FAILED AND MY HAZARD SWITCH HAD TO BE REPLACED. AT 23,000 MILES MY EVAPORATOR VENT VALVE HAD TO BE REPLACE (ENGINE LIGHT REMAINED ON CONSTANTLY). AT 20,000 MILES MY CAR WAS VIBRATING WHENEVER MY BRAKES WERE APPLIED. DEALOR SAID FRONT BRAKES WORN OUT AND ROTORS OUT OF ROUND AND THEY REPLACED THE FRONT BRAKES AND REFACED THE ROTORS. AT 33,000 MILES, CARE AGAIN VITRATED WHENVER BRAKES APPLIED AND DEALER TOLD ME AGAIN THAT IT WAS NOT UNDER WARRANTY AND WAS HAPPENING BECAUSE OF "HOT SPOTS" AND THAT MY ROTORS NEEDED TO BE CUT EVEN THOUGH THEY HAD JUST BEEN FIXED AT 20,000 MILES. WAS NEVER TOLD THAT MANUFACTURER WAS HAVING A PROBLEM WITH MALIBU BRAKES AND WAS TOLD IT WOULD COST APPROXIAMTELY $700.00 TO FIX ROTORS AND IT WAS MY RESPONSIBILITY. MY SEVICE FOR THE BRAKES WAS DONE AT FUTURE CHEVROLET IN OLD BRIDGE, NJ. *AK
Service brakes, Hydraulic, Fuel system, Gasoline, Aug 16, 2001
WHEN APPLYING BRAKES AT 40 MPH VEHICLE SHAKES. DEALER REPLACED FRONT ROTORS AT 3000 MILES. HOWEVER, PROBLEMS PERSISTED, DEALER DID NOT REPLACE ROTORS AGAIN. LAST VISIT TO DEALER CONSUMER WAS ESCORTED OFF THE LOT. DEALER REFUSED TO LOOK AT VEHICLE. *AK CONSUMER ALSO STATES THERE IS A FULE SYSTEMS PROBLEM, THE FUEL WILL SPLASH BACK AT CONSUMER WHEN FILLING UP TANK, AND A LOT OF FUEL SPILLS ON THE GROUND, ALSO THE REAR BRAKES IN WET WEATHER, HOWL WHEN ACCELERATING.*JB
Service brakes, Hydraulic, Fuel system, Other, Electrical system, Seats, Equipment, May 31, 2001
BRAKES ON VEHICLE HAVE BEEN REPLACED THREE TIMES IN PAST YEAR. CONTACTED DEALER, AND THERE WAS NOT MUCH DEALER COULD DO. *AK ALSO, GAS GUAGE FAILED TWICE. THE PASSENGER SEAT RECLINER WAS DAMAGED. THE ELECTRIC OUT LET BROKE AND A/C HEATING SYSTEM FAILED. *YH
Fuel system, Gasoline, Apr 11, 2001
WHILE DRIVING, MY CAR SUDDENLY LOST COMPLETE POWER. IT TOOK 3 TIMES TO A DEALER TO REPLACE A PART IN MY FUEL SYSTEM, ONLY TO BE TOLD THEY WEREN'T SURE IF THAT WAS THE PROBLEM. IT DID'NT DO IT AGAIN FOR 6 MONTHS, THEN IT DID IT AGAIN.*AK
Service brakes, Hydraulic, Fuel system, Gasoline, Mar 21, 2001
PROBLEM WITH FRONT ROTORS ARE WELL DOCUMENTED,IN MY CASE ABOUT EVERY 8500 MILE,I DONT AGREE ON CHEVROLETS STATEMENT ,WHICH IS WEAR AND TEAR.THE MANUFACTURER NEW CAR WARRANTY ON BRAKES IS 12.000.I TRIED MY BEST TO CUMMUNICATE WITH OUT ANY POSITIVE RESULTS.THIS PRODUCT WHICH IS MY CAR DEVELOPED A MAJOR SAFETY ISSUE,WHICH TO STALL AT HIGH SPEED ,NO POWER BRAKES OR STEERING AND WILL NOT START UP AGAIN .COULD CAUSE A PILE UP .WAS IN SHOP 4 TIMES AND DEALER SAID NOTHING IS WRONG ,TOLD US TO REMOVE CAR FROM LOT 18 MILES DOWN THE ROAD IT TIED ,AND IT TOOK 20 DAYS TO FINNALLY FIX IT,DEALER RECEIVED TBS FUEL STRAINER HAS PRODUCTION FLAWS.I HOPE THAT PERSONS DONT HAVE TO DIE,JUST TO LOOK IN TO THE ROTOR ISSUE ,I DID WROTE BEFORE AND WAS NEVER CONTACTED,PERHAPS IT WAS INGNORED.I HOPE THIS WILL NOT .IT BE A SAD SITUATION ,NOT TO HEAR A CRY FOR EVERYBODY WHO HAS TO PAY FOR BRAKES.THANK YOU IN ADVANCE. *AK
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Other, Mar 5, 2001
REPLACED ROTORS AND PADS10/26/2000 AND02/09/2001.REPLACED FUEL TANK SENDING UNIT 03/02/2001 REPLACING PISTONS IN ENGINE 03/05/2001
Fuel system, Gasoline, Feb 12, 2001
FUEL PUMP FAILED TO OPERATE WHILE DRIVING AT 45 MPH. VEHICLE TOWED TO DEALER FOR REPAIRS. PLEASE FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER. *AK
Fuel system, Gasoline, Aug 16, 2000, fire
WHILE TRAVELING ON HIGHWAY VEHICLE STARTED SLOWING DOWN. APPROACHING THE SHOULDER IT STARTED TO SMOKE. THEY GOT OUT OF VEHICLE. CAR EXPLODED AND BURNED TO A CRISP. FIRE DEPARTMENT WAS NOTIFIED. THERE WERE NO INJURIES. *AK
Engine and engine cooling, Fuel system, Gasoline, Jul 28, 2000
VEHICLE WOULD STALL OUT WITHOUT ANY PRIOR WARNING WHILE DRIVING. THIS PROBLEM HAS HAPPENED AT LEAST 3 TIMES. TOOK TO DEALER & MECHANIC COULD NOT LOCATE PROBLEM OF STALLING. HAD REPLACED THE FUEL MODULATOR & THE FUEL PUMP 3 TIMES. BUT, STALLING PROBLEM STILL EXISTS. *AK
Fuel system, Gasoline, Dec 23, 1999
WHILE DRIVING 65 MPH ON THE HIGHWAY ENGINE COMPLETELY SHIUT DOWN WITHOUT WARNING DUE TO A DEFECTIVE FUEL PUMP. PLEASE GIVE ANY FURTHER DETAILS. *AK