2000 Chevrolet Malibu
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 944 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Malibu model years with reports.
Of the 2000 reports, 47 involved a crash and 7 involved a fire. 37 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Exterior lighting, hazard flashing warning lights, switchAug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Campaign 03V327000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, filler pipe and capOct 29, 1999
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN THE TANK IS MORE THAN HALF FULL.
IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.
DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.
Campaign 99V302000 on NHTSA.gov
Representative owner complaints: gasoline
56 reports, newest first. Show all
Fuel system, Gasoline, Jun 10, 2004
I HAVE A 2000 MALIBU WITH 16.000 MILES ON IT. THE FUEL PUMP JUST WENT. THE MECHANICS I SPOKE WITH FELT THIS TO BE HIGHLY UNUSUAL. HE FELT THAT THERE MOST LIKELY WAS A MANUFACTURER'S DEFECT. *AK
Fuel system, Gasoline, May 21, 2004
GOING TO WORK CAR JUST DIES. WAITED FOR A TOW TRUCK. TOOK TO MY MECHANIC. HE REPLACED THE FUEL PUMP. MY CAR IS A 2000 MAILBU WHICH ONLY HAS 15,000 MILES ON IT . CANNOT BELIVE THAT THIS PART WOULD FAIL THAT SOON. THIS REPAIR COST ME 500.00 THE PART ALONE WAS OF COURSE A DEALER ONLY PART. WAS 350.00 PLUS A FILTER. OUTRAGEOUS. ARE THESE THINGS MADE OUT OF GOLD. *AK
Fuel system, Gasoline, Exterior lighting, May 10, 2004
DEALERSHIP REPLACED THE HAZARD WARNING SWITCH AT THE OWNER'S EXPENSE. THE CONSUMER ALSO HAD PROBLEMS WITH THE FUEL FITTING WHICH WAS LEAKING GAS. PLEASE PROVIDE FURTHER INFORMATION. *JB
Engine and engine cooling, Fuel system, Gasoline, Exterior lighting, May 3, 2004
MY CAR HAS HAD THE SIGNAL LIGHTS REPLACED, THE FUEL PUMP REPLACED, & THE INTAKE MANIFOLD GASKET REPLACED ALL PROBLEMS W/ MY CAR BEFORE I HAD REPLACED WERE VERY DANGEROUS FOR ME & MY 2 CHILDREN. I WILL NEVER BUY OR REFER ANYONE TO BUY A CHEVORLET MALIBU . *AK
Fuel system, Gasoline, Apr 20, 2004
WHILE DRIVING 50-55 MPH ON THE HIGHWAY, THE ENGINE STALLED WITHOUT WARNING. THE CONSUMER COASTED TO THE SIDE OF THE ROAD AND SAT FOR SEVERAL MINUTES. SHE THEN ATTEMPTED TO RESTART THE VEHICLE AND THE ENGINE STALLED THREE MORE TIMES. ONCE THE VEHICLE WAS SERVICED, THE TECHNICIAN INFORMED THE CONSUMER THAT THE FUEL PUMP SENDER ASSEMBLY, FUEL HARNESS AND FUEL FILTER NEEDED REPLACEMENT. *JB *LA
Steering, Fuel system, Gasoline, Power train, Apr 18, 2004
TRANSMISSION FAILURE, POWER STEERING FAILURE, FUEL PUMP FAILURE. *JB
Fuel system, Gasoline, Apr 4, 2004
MY 2000 MALIBU/4DR SEDAN WOULD STOP RUNNING WHILE DRIVING DOWN THE ROAD. THERE WOULD BE NO WARNING IT WOULD JUST STOP. THIS CAUSE ALL THE POWER TO STOP WORKING(STEERING,BRAKES). TAKING THE CAR TO A GM DEALER SHOP FOR REPAIR, THEY CONNECTED THE TEST EQUIPMENT UP AND SAID THEY FOUND NO CODES. I INSTRUCTED THEM TO TAKE THE CAR ON A ROAD TEST, WHEN THEY DID THIS THE CAR STOPPED ON THEM ALSO. AFTER RESEARCHING THIS PROBLEM THEY FOUND A TECH BULLETIN(REF:REPLACEMENT OF FUEL PICKUP SCREEN AND FILTER). AFTER THIS REPAIR THE CAR NOW RUNS FINE. IT HAS 45725 MILES AT THE TIME OF TROUBLE. *NM
Fuel system, Gasoline, Electrical system, Feb 17, 2004
VEHICLE LOST POWER AND QUIT WHILE DRIVING ON THE INTERSTATE HIGHWAY. *JB
Fuel system, Gasoline, Electrical system, Feb 10, 2004
WHILE DRIVING AND/OR ATTEMPTING TO USE THE TURN SIGNAL, A SHORT IN THE FLASHER SWITCH MADE THE TURN SIGNAL INOPERATIVE AND MADE OTHER ELECTRICAL COMPONENTS INOPERATIVE (EX. GAUGES, RADIO AND A/C FAN). THE ELECTRICAL PROBLEM ALSO CAUSED THE ENGINE TO STALL. WHEN THE CONSUMER PUSHED THE FLASHER SWITCH REPEATEDLY THE ELECTRICAL COMPONENTS WOULD WORK TEMPORARILY. THE FUEL PUMP WAS REPLACED TO ALLEVIATE THE STALLING CONDITION. THE TECHNICIAN HAS IDENTIFIED A PROBLEM IN THE FLASHER SWITCH BUT HAS NOT REPLACED IT. A RECALL ON THE SWITCH IS SCHEDULED TO START LATER IN 2004 HOWEVER THE CONSUMER'S VEHICLE IS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK *NM
Fuel system, Gasoline, Dec 10, 2003
WHILE DRIVING AT ANY SPEED THE VEHICLE WILL SUDDENLY STALL WITHOUT ANY WARNING. IT HAD TAKEN THE VEHICLE A WHILE TO RESTART AND WHEN IT DID RESTART IT NEEDED CONSTANT REFUELING. UPON INSPECTION OF THE VEHICLE BY A LOCAL MECHANIC HE INDICATED THAT THE PROBLEM COULD BE CAUSED BY THE FUEL PUMP. *AK *SCC *JB
Fuel system, Gasoline, Sep 8, 2003
ENGINE STALLED 3 TIMES. DEALER FOUND A LEAK IN THE GAS TANK AND REPLACED IT. THE VEHICLE EXPERIENCED A CONDITION IN WHICH IT WOULD EITHER NOT START OR ONCE STARTED IT WOULD HESITATE OR STALL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY REPLACED THE FUEL TANK AND FUEL PUMP. THE VEHICLE CONTINUED TO EXPERIENCE PROBLEMS AND WAS RETURNED TO THE DEALER. THE DEALER COULD NOT FIND THE PROBLEM AND INDICATED THAT THE PROBLEM WAS PROBABLY FROM VANDALISM OR SOMETHING IN THE TANK. THESE CONDITIONS WERE NOT COVERED BY THE VEHICLE'S WARRANTY THEREFORE THE CONSUMER HAD TO PAY FOR THE ENTIRE SERVICE ASSESSMENT. A GM BULLETIN WAS LOCATED WHICH RECOMMENDED THAT THE TECHNICIAN REPLACE THE EXISTING FUEL SENDER STRAINER AS A POTENTIAL CAUSE OF THE ENGINE SYMPTOMS. *NLM
Fuel system, Gasoline, Sep 6, 2003
FUEL PUMP DEFECT CAUSING VEHICLE TO STOP UNEXPECTEDLY/SUDDNELY. REPAIR SHOP ALSO INDICATED THAT FUEL GAUGE/SENSOR DEFECT CAUSING GAUGE TO INACCURATELY SHOW AMOUNT OF FUEL - GAUGE FAILED TO REGISTER WHEN FUEL IS LOW.*AK
Fuel system, Gasoline, Aug 29, 2003
PROBLEMS WITH VEHICLE STALLING AND STARTING UP. *MR THE VEHICLE EXPERIENCED A CONDITION IN WHICH IT WOULD EITHER NOT START OR ONCE STARTED IT WOULD HESITATE OR STALL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY REPLACED THE FUEL TANK AND FUEL PUMP. THE VEHICLE CONTINUED TO EXPERIENCE PROBLEMS AND WAS RETURNED TO THE DEALER. THE DEALER COULD NOT FIND THE PROBLEM AND INDICATED THAT THE PROBLEM WAS PROBABLY FROM VANDALISM OR SOMETHING IN THE TANK. THESE CONDITIONS WERE NOT COVERED BY THE VEHICLE'S WARRANTY THEREFORE THE CONSUMER HAD TO PAY FOR THE ENTIRE SERVICE ASSESSMENT. A GM BULLETIN WAS LOCATED WHICH RECOMMENDED THAT THE TECHNICIAN REPLACE THE EXISTING FUEL SENDER STRAINER AS A POTENTIAL CAUSE OF THE ENGINE SYMPTOMS. *NLM *JB
Fuel system, Gasoline, Aug 1, 2003
CONSUMER STATED THE VEHICLE STALLED WITHOUT WARNING FOR 2 YEARS. THE WIRES POWERING THE FUEL PUMP MOTOR IN THE FUEL TANK MODULE WERE REPLACED. THE FUEL TANK WAS REPLACED WITH A NEW TANK AND SO FAR NO STALLING HAD OCCURRED. *AK *CB THERE WERE 5 ATTEMPTS TO REMEDY THE PROBLEM. THE CONSUMER REQUESTED REIMBURSEMENT AND EXPECTED GM TO DISCUSS THE PROBLEM AND THE FUEL TANK MODULE DESIGN IMPROVEMENT. *SCC *JB
Fuel system, Gasoline, Jun 20, 2003
VEHICLE STALLS INTERMITTENTLY WHILE DRIVING. BELIEVES PROBLEM IS DUE TO FUEL FILLER RECALL 99V302000, BUT CONSUMER'S VEHICLE NOT INCLUDED DUE TO VIN. *AK
Fuel system, Gasoline, Apr 10, 2003
NAR 04/10/2003 IT APPEARS TO THE CONSUMER THAT THERE IS A DESIGN PROBLEM WITH THE #5 FUEL INJECTOR, IT ALSO INSIGNIFICANT THAT A FUEL INJECTOR NEEDS TO BE REPLACED EVERY 28,000 MILES. A FUEL INJECTOR IS NOT A MAINTENANCE PROBLEM. PLEASE LOOK INTO WHETHER IT IS A DESIGN FLAW AND IF CHEVROLET WILL CORRECT PROBLEM. *CB
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Electrical system, Tires, Apr 4, 2003
FRONT/REAR SUSPENSION-SQUAWKING NOISE -GM WELL AWARE OF THIS ISSUE HAZARD LIGHTS - HAVE GONE OUT TWICE. FUEL INTEGRITY - ERRATIC FUEL READING - SHOWS 1/4 TANK - WHEN IN REALITY THERE IS NO GAS. I HAVE RAN OUT OF GAS APPROXIMATELY 7 TIMES - SEVERAL TIMES LATE AT NIGHT. NO CRUISE CONTROL - GM WOULD NOT REPAIR. BRAKES PADS/ROTORS - HAVE REPLACED 3 TIMES. MY LOCAL DEALER ROTOLO CHEVROLET AND GM CUSTOMER SERVICE WOULD DO NOTHING. IT WAS EXPENSIVE. PREMATURE TIRE WEAR - TWO SETS OF TIRES. CARS RUNS HOT - WOULD NEVER GO ON A TRIP - BECAUSE IT WOULD GET TOO NEAR OVERHEATING. I WAS AFRAID OF GETTING STRANDED IN THE MIDDLE OF THE DESERT. ENGINE TICKING NOISE - LOCAL DEALER SAID THIS WAS NORMAL. NOW, I FIND NONE OF THESE THINGS WERE NORMAL AND MANY, MANY MORE CAR OWNERS HAVE EXPERIENCED THE SAME TYPE OF PROBLEMS. ALSO, I HAD A BATTERY THAT EXPLODED WHILE CAR WAS UNDER WARRANTY. IT WAS MY PROBLEM. DEALERSHIP WOULD NOT REPLACE BATTERY. I FINALLY HAD ENOUGH AND TURNED THIS AUTOMOBILE BACK TO GMAC. IS IT GOING TO TAKE PEOPLE GETTING KILLED TO MAKE GM RESPONSIBLE FOR THESE ISSUES WITH THE 2000 MALIBU. ALL OF THESE PROBLEMS WERE REPORTED TO THE DEALER, BUT SINCE NOTHING COULD BE DUPLICATED, EVEN THOUGH GM WAS AWARE OF THESE ISSUES, THEY WOULD DO NOTHING. AFTER THE CAR WAS OUT OF WARRANTY, THE DEALERSHIP WAS MORE THAN WILLING TO CORRECT THESE ISSUES. THE PROBLEM I HAVE IS THE DECEPTION.....GM IS AWARE OF THESE ISSUES AND HAVE BEEN FOR SOME TIME. SOMEONE NEEDS TO HOLD THEN ACCOUNTABLE. *JB
Fuel system, Gasoline, Mar 31, 2003
#5 FUEL INJECTOR HAS HAD TO BE REPLACED AT 27,963 MILES AND AT 58,736 MILES. REPAIR SHOP STATED THAT #5 FUEL INJECTOR IS LOCATED CLOSE TO THE EGR VALVE WHICH PUTS OFF A LOT OF HEAT AND MAY BE CONTRIBUTING TO THE PREMATURE FAILURE. *NLM
Fuel system, Gasoline, Mar 6, 2003
MY CAR KEPT DYING WHILE DRIVING DOWN THE ROAD. MY MECHANIC TOLD ME TO CONSIDER 1/4 TANK EMPTY, BECAUSE WHEN THE CAR GOT DOWN TO EMPTY, ALL THE GAS WAS IN THE LINES AND IT RUINED THE FUEL PUMP. IT HAS NOT HAPPENED SINCE I GOT A NEW FUEL PUMP. 8JB
Fuel system, Gasoline, Nov 30, 2002
I HAVE HAD PROBLEMS WITH THIS CAR EVERY SINCE I GOT IT. IT STARTED WITH THE BRAKES I HAD TO HAVE NEW BRAKES AND A MONTH LATER I HAD TO HAVE NEW ROWTERS BECAUSE THAT HAD A DEFECT. AND STILL HAVING PROBLEMS WITH THE NEW ROWTERS. THE ENGINE LIGHT WOULD COME ON AND THEY FINAL REPLACE THE FUEL TANK. BUT WHEN I TOOK IT IN BEFORE THE WARRANTY WENT OUT THEY SAID THEY COULD NOT FIND NOTHING WRONG WITH IT NOW THE WARRANTY WENT OUT MY GAS GAGE WOULD GO TO EMPTY WHEN WE ARE SITTING STILL AND WOULD GO BACK UP WHEN WE TAKE OFF. IT SHUT DOWN ON ME GOING DOWN THE FREEWAY. DT
Service brakes, Hydraulic, Fuel system, Gasoline, Tires, Aug 14, 2002
FRONT DISC BRAKE ROTORS ARE WARPING AGAIN AFTER BEING REPLACED AT 12000 MILES. WHEN BRAKES ARE APPLIED STEERING WHEEL VIBRATES EXCESSIVELY. DEALERSHIP IS DENYING ANY RESPONSIBILITY OF REPAIR. *AK THE FUEL PUMP FAILED AND WAS FIXED AT THE CONSUMER?S EXPENSE. THE TIRES BECAME WORN OUT AND WERE REPLACED. THE FRONT ROTORS WERE TURNED. *YH
Fuel system, Gasoline, Feb 28, 2002
WHILE DRIVING AND WITHOUT WARNING VEHICLE STALLS. TOOK VEHICLE TO DEALER,AND DEALER REPLACED INTAKE GASKET AND FUEL PUMP, BUT PROBLEM STILL EXISTS. *AK
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Visibility, Structure, Oct 28, 2001
BOUGHT MY CAR NEW OFF SHOW ROOM FLOOR AND HAVE HAD NUMEROUS PROBLEMS SINCE HAD IT IN FOR STARTING PROBLEMS BATTERY PROBLEMS FUEL PROBLEMS WINDOW PROBLEMS DOOR LOCK PROBLEMS ENGINE NOISE ENGINE OIL LEAKS VIBRATION PROBLEMS BRAKE PROBLEMS DYING PROBLEMS POPPING NOISES IN FRONT END STRUTS BOTTOMING OUT ROUGH RIDE AND STEERING PROBLEMS AND SO ON TOO MANY TO LIST ALL HAVE HAD FRONT END REALIGNED STUTS CHECKED AND REPALCED BRAKES CHECKED AND REPLACED WHEEL STUDS REPLACED FUEL PUMP AND FLOAT REPLACED PISTONS REPLACED BATTERY REPLACED REMOTE START SYSTEM REPLACED ALARM SYSTEM REPLACED WINDOW REGULATOR REPLACED FRONT CRANK SEAL REPLACED ALT CHECKED AND TESTED STARTED CHECKED STILL HAVING FUEL PROBLEMS BRAKE PROBLEMS VIBRATION ECT HAD IN THIS LAST WEEK FO 6 DAYS AND WHEN RETURNED STILL HAVING ENGINE NOISE STEERING PROBLEMS RADIO PROBLEMS FUEL PROBLEMS AND FOUND IMPACT MARK ON L/FRONT OF BUMPER ONE OF DEALERS TECH'S HIT SOMETHING AND NOW WANDERS TO LEFT LEFT HEAD LIGHT OUT OF LINE AND PUSHED BACK UNDER FENDER HOOD OUT OF LINE FENDERS BUMPERS DRIVING LIGHTS AND NUMEROUS OTHER PROBLEMS AND DAMAGE POSSIBLE THAT I AM UNABLE TO DETECT AT THIS TIME HAVE CONTACTED CHEVY AND COMPLAINED HAVE TALKED WITH DEALER AND STILL NO RESPONSIBILITY TAKEN AND STATEMENTS OF WE MIGHT HAVE BRUISED IT IT HAS BEEN WRECKED NOW I AMD PAYING GOOD MONEY FOR JUNK AND WANT REFUND OF ALL COSTS TO ME AND THE CAR TAKEN BACK ENGINES SHOULD NOT NEED TO BE OVERHAULED AT 14000 MILES THE CAR IS 2 YAERS OLD AND ACTS LIKE ITS 20 NEED RESPONESE AND INFO TO HELP RESOLVE PROBLEMS TRYING TO HAVE RETURNED UNDER LEMON LAW UNIFORM CONFORMITY ACT AND MAGNUSON-MOSS ACT CAR HAS BECOME INSTRUMENT THAT IS SUBSTANTIALLY IMPAIRED AND WHOSE OPPERATION IS FROUGHT WITH APPREHENSION SINCERLY UNHAPPY AND HURT CONSUMER IS THE HIGHWAY SAFTY DEVISION INTERESTED AND GOING TO DO ANYTHING FOR ALL OF US WHO ARE HAVING PROBLEMS OR ARE WE OUT OF LUCK ????????? RESPONSE REQUESTED
Service brakes, Hydraulic, Fuel system, Gasoline, Electrical system, Equipment, Oct 20, 2001
3 MONTHS AFTER I BOUGHT MALIBU IN JULY, 2000 I WAS DRIVING AT 65 MPH WHEN MY CARE LOST ALL POWER. DEALER TOLD ME THAT THERE WAS SOMETHING WRONG WITH THE FUEL INDICATOR WIRING AND WAS FALSELY READING THE AMOUNT OF GAS I HAD WHICH RESULTED IN MY RUNNING OUT OF GAS AT 65MPH. PROBLEM HAS NOT REPEATED ITSELF. AT 21,000 MILES MY SIGNAL INDICATOR LIGHTS FAILED AND MY HAZARD SWITCH HAD TO BE REPLACED. AT 23,000 MILES MY EVAPORATOR VENT VALVE HAD TO BE REPLACE (ENGINE LIGHT REMAINED ON CONSTANTLY). AT 20,000 MILES MY CAR WAS VIBRATING WHENEVER MY BRAKES WERE APPLIED. DEALOR SAID FRONT BRAKES WORN OUT AND ROTORS OUT OF ROUND AND THEY REPLACED THE FRONT BRAKES AND REFACED THE ROTORS. AT 33,000 MILES, CARE AGAIN VITRATED WHENVER BRAKES APPLIED AND DEALER TOLD ME AGAIN THAT IT WAS NOT UNDER WARRANTY AND WAS HAPPENING BECAUSE OF "HOT SPOTS" AND THAT MY ROTORS NEEDED TO BE CUT EVEN THOUGH THEY HAD JUST BEEN FIXED AT 20,000 MILES. WAS NEVER TOLD THAT MANUFACTURER WAS HAVING A PROBLEM WITH MALIBU BRAKES AND WAS TOLD IT WOULD COST APPROXIAMTELY $700.00 TO FIX ROTORS AND IT WAS MY RESPONSIBILITY. MY SEVICE FOR THE BRAKES WAS DONE AT FUTURE CHEVROLET IN OLD BRIDGE, NJ. *AK
Service brakes, Hydraulic, Fuel system, Gasoline, Aug 16, 2001
WHEN APPLYING BRAKES AT 40 MPH VEHICLE SHAKES. DEALER REPLACED FRONT ROTORS AT 3000 MILES. HOWEVER, PROBLEMS PERSISTED, DEALER DID NOT REPLACE ROTORS AGAIN. LAST VISIT TO DEALER CONSUMER WAS ESCORTED OFF THE LOT. DEALER REFUSED TO LOOK AT VEHICLE. *AK CONSUMER ALSO STATES THERE IS A FULE SYSTEMS PROBLEM, THE FUEL WILL SPLASH BACK AT CONSUMER WHEN FILLING UP TANK, AND A LOT OF FUEL SPILLS ON THE GROUND, ALSO THE REAR BRAKES IN WET WEATHER, HOWL WHEN ACCELERATING.*JB