2000 Chevrolet Malibu
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 944 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Malibu model years with reports.
Of the 2000 reports, 47 involved a crash and 7 involved a fire. 37 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Exterior lighting, hazard flashing warning lights, switchAug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Campaign 03V327000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, filler pipe and capOct 29, 1999
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN THE TANK IS MORE THAN HALF FULL.
IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.
DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.
Campaign 99V302000 on NHTSA.gov
Representative owner complaints
944 reports, newest first.
Electrical system, Jun 12, 2007
I HAVE A 2000 CHEVY MALIBU THAT HAS HAD A NUMBER OF PROBLEMS WITH TURN SIGNALS AND GENERAL OTHER SAFETY RELATED CONCERNS. NOW ON MULTIPLE OCCURANCES THE CAR WILL NOT START WITH THE OEM KEY AND WIRELESS CONTROLLER. THE "THEFT SYSTEM" LIGHT TURNS ON SPORADICALLY LEAVING ME UNABLE TO START THE CAR... THE CAR CRANKS BUT THE THEFT SYSTEM DISABLES THE CAR FROM TURNING OVER OR FULLY STARTING. I HAVE SENT THE CAR INTO THE SHOP SEVERAL TIMES WHERE THEY WERE UNABLE TO REPLICATE THE PROBLEM. NOW THEY FINALLY "PINNED DOWN" THE ISSUE AND ARE REQUESTING OVER $800 TO REPLACE THE INGITION MODULE. I HAVE READ ENOUGH ABOUT THIS ISSUE ON FORUMS AND THE AUTO REPAIR (NON-DEALERSHIP) HAS ADMITTED TO "FIXING" THIS PROBLEM ON MANY MAILBU'S PRIOR TO MINE. I HAVE BEEN STRANDED SEVERAL TIMES, INCURRED OVER $375 IN TOWING AND AUTO SHOP EXPENSES...
Electrical system, May 23, 2007
THE CAR BEGAN LOCKING UP WITH THE THEFT SYSTEM" LIGHT BLINKING. THE CAR WILL NOT CRANK UNTIL YOU WAITED 10 MINUTES FOR IT TO STOP BLINKING. THIS CAN HAPPEN TWO OR THREE TIMES IN A ROW, AT LEAST ONCE A DAY. I HAVE BEEN TOLD THERE IS NO WAY TO FIX IT.*AK
Electrical system, May 3, 2007
UPON STARTING THE 2000 CHEVY MALIBU, THE POWER WINDOWS WOULDN'T WORK, THE FUEL GAUGE READ AS EMPTY, THE GEAR INDICATOR DIDN'T LIGHT UP. THIS PROBLEM CONTINUED FOR UP TO 2 MINUTES, THEN EVERYTHING WOULD COME ON. THE "SERVICE VEHICLE SOON" LIGHT WOULD COME ON INTERMITTENTLY AND EVENTUALLY THE "CHECK ENGINE" LIGHT CAME ON. WE TOOK IT TO A CERTIFIED MECHANIC WHO DETERMINED THAT A FAULTY IGNITION SWITCH WAS THE CAUSE OF THE PROBLEM. *TR
Engine and engine cooling, May 1, 2007
MY ENGINE STALLS AT LEAST 2 TO 3 TIMES A MONTH, NOTHING HAS BEEN DONE BECAUSE IT IS AN EXPENSIVE PROBLEM... AND IT IS A MANUFACTURERS DEFECT.... *TR
Electrical system, Apr 25, 2007
CAR ACT AS IF ITS GOING TO START BUT CUTS OFF. I HAVE HAD TO SIT FOR 15 TO 20 MINUTES FOR THE CAR TO START. THE THEFT LOCK SYSTEM LIGHT FLASHES ON AND OFF DURING THIS TIME ONCE IT STOP THE CAR SEEMS TO START AFTER THE FLASHING STOPS. THIS CAUSES ME TO BE LATE TO PLACES ALSO TO BLOCK GAS PUMPS AND THINGS . *JB
Service brakes, Hydraulic, Structure, Apr 18, 2007
2000 CHEVROLET MALIBU SEDAN WITH RUSTED LEFT AND RIGHT BRACKETS THAT ARE WELDED TO THE K FRAME AND HOLD THE STEERING ARM**CC THE CONSUMER HAD PERSISTENT PROBLEMS WITH THE BRAKES. *JB
Electrical system, Exterior lighting, Apr 9, 2007
TL*THE CONTACT OWNS A 2000 CHEVROLET MALIBU. WHILE DRIVING 70 MPH THE VEHICLE DECELERATED TO 50 MPH AND THEN SHUTS OFF COMPLETELY. THE CONTACT WAS FORCED TO MERGE ONTO THE MEDIAN IN ORDER TO AVOID THE BUSY INTERSECTION. THE TECHNICIAN STATED THAT THE FAILURE COULD HAVE BEEN CAUSED BY THE SIGNAL LIGHT. THE CONTACT STATED THAT NO OTHER FAILURES OCCURRED SINCE THE VEHICLE LEFT THE SHOP. THE CURRENT AND FAILURE MILEAGE WERE 50,000.*AK
Engine and engine cooling, Mar 15, 2007
2000 CHEVY MALIBU INTAKE MANIFOLD GASKET FAILURE, 800.00 TO FIX. REPLACED GASKET AT DEALER, TOLD CAR WAS A FIXED AND THEN THE HEAD GASKET FAILS, WITHIN HOURS OF LEAVING REPAIR SHOP. *JB
Exterior lighting, Jan 14, 2007
TURN SIGNAL DOES NOT WORK INTERMITTENTLY. WHEN THE TURN SIGNAL DOES NOT WORK, I TURN ON THE HAZARD FLASHERS, THEN THE TURN SIGNAL WORKS. MY 1980 CHEVROLET MALIBU WAS MANUFACTURED OCTOBER 1999, SO I DID NOT RECEIVE A RECALL PURSUANT TO NHTSA #03V327000. WHEN I CONTACTED DEALER, I WAS TOLD THEY COULD NOT DIAGNOSE THE PROBLEM UNLESS I BROUGHT IT IN WHEN THE SIGNAL WAS NOT WORKING. SINCE IT IS INTERMITTENT, THAT IS IMPOSSIBLE UNTIL IT FAILS ALTOGETHER. I ASSUME THE DEALER WAS AWARE OF THE RECALL ON MODELS WITH A DIFFERENT MANUFACTURE DATE. *NM
Exterior lighting, Jan 10, 2007
TURN SIGNALS STOP WORKING WITH OUT WARNING. *JB
Engine and engine cooling, Dec 20, 2006
WHILE DRIVING MY CAR ALONG THE FREEWAY AND WITHOUT ANY NOTICE THE CAR WENT FROM HAVING A NORMAL TEMP TO RED LINING ON THE TEMPERATURE. I IMMEDIATELY SLOWED THE VEHICLE DOWN AND TURNED ON THE HEAT. AT THIS POINT NO HEAT CAME OUT AND SOON AFTERWARDS THE VEHICLE OVERHEATED AND DIED. I CRUISED IT OFF THE FREEWAY AND ONTO A SIDE ROAD. I WAS IN THE MIDDLE OF NOWHERE AND A PASSERBY WAS NICE ENOUGH TO STOP. I ENDED UP REFILLING THE COOLANT AND WAS ABLE TO DRIVE TO WHERE I NEED TO GO AND RETURN HOME. I HAD REFILL THE FLUID LEVEL MULTIPLE TIMES. I TOOK IT TO A RADIATOR SHOP THAT STATED THAT THE SEALS ON MY ENGINE WERE LEAKING EXHAUST INTO THE FLUIDS WHICH CAUSED THE VEHICLE TO OVERHEAT. THEY STATED THAT CHEVY WAS HAVING TROUBLE WITH THE DEXACOOL COOLANT IN THE VEHICLES AND THAT IT WAS EATING AWAY THE SEAL IN THE ENGINE. *JB
Engine and engine cooling, Equipment, Dec 12, 2006
2000 MALIBU ENGINE GASKETS HAD TO BE REPLACED. *TS THE AIR CONDITION CONTROL HEAD WAS REPLACED. *JB
Service brakes, Hydraulic, Electrical system, Dec 6, 2006
I HAVE A 2000 CHEVY MALIBU. AS MANY MALIBU OWNERS MY CAR HAS THE SAME ISSUES. BLOWER FAN DOESN'T WORK ON SETTING 1 AND 2, REAR SPEAKERS DON'T WORK IN COLD WEATHER, REAR TAIL LIGHTS DON'T ALWAYS WORK, WEIRD BRAKING ISSUES IN THE COLD, AND AIR CIRCULATION BUTTON CHANGES FROM CLOSED TO OPEN AUTOMATICALLY. THESE ARE JUST SOME ELECTRICAL ISSUES WITH THE CAR AND I THINK I FOUND THE ROOT CAUSE. THE WINDSHIELD RUBBER SEAL ON MY CAR WAS UNATTACHED FROM THE WINDOW OUTSIDE AT THE BOTTOM ON THE PASSENGER SIDE. I FOUND OUT BECAUSE AFTER A HEAVY RAIN A LOT OF WATER WAS SHOWING ON THE FLOOR OF THE PASSENGER SIDE. THE WATER DAMAGES HAS BEEN HAPPENING FOR YEARS. I FOUND WATER SITTING IN THE PLASTIC MOLDING RIGHT UNDER THE BLOWER FAN. WATER CORRODING THE ELECTRICAL CABLES ON THE FLOOR. WATER TRACKS OVER THE COMPUTER BOARD LOCATED UNDER THE GLOVE BOX. I'VE INFORMED CHEVROLET AND ASK FOR THEM TO CREATE A TSB BUT THEY DENIED MY REQUEST.*JB
Electrical system, Nov 13, 2006
HAZARD AND TURN SIGNAL WORKS INTERMITTENTLY, I FOUND THAT A RECALL ON MY MAKE OF CAR WAS ISSUED IN 2003, PARTS NO AVAILABLE TILL 2004, DUE TO LOSING MY HOME IN HURRICANE IVAN MY MAIL WAS MESSED UP FOR QUITE SOME TIME, I AM HAVING THIS PROBLEM AND WOULD LIKE TO KNOW IF IT WOULD BE COVERED. WE REPLACED BULBS AND FUSES BUT PROBLEM STILL THERE, I CAN TAP OR HOLD THE HAZARD BUTTON AND TURN SIGNALS WILL WORK FOR A MOMENT. THIS IS A 2000 MALIBU WITH APPR. 74,000 MILES. ALL WARRANTY WORK AND OIL CHANGES HAS ALWAYS BEEN KEPT UP, I WOULD LIKE TO KNOW IF MY CAR FALLS IN THE RECALL. *NM
Exterior lighting, Nov 4, 2006
TURN SIGNALS WON'T WORK AT TIMES AND SOME TIMES WHEN I USE MY FOUR WAYS, THEY WON'T EITHER AND WHEN I DO USE MY TURN SIGNALS THE FOUR WAYS COME ON. *JB
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Oct 25, 2006
LOWER INTAKE MANIFOLD GASKET LEAK; BALL JOINT & FUEL PUMP; BRAKE PADS REPLACED 4 TIMES IN LESS THAN 3 YRS. *NM
Engine and engine cooling, Oct 20, 2006
DT*: THE CONTACT STATED WHILE PARKED IN THE DRIVEWAY, A LEAK WAS NOTICED UNDER THE VEHICLE. IT WAS DRIVEN TO THE DEALER WHO DETERMINED THE INTAKE GASKET NEEDED TO BE REPLACED.
Engine and engine cooling, Oct 15, 2006
COOLENT LEAKS AND OVERHEATING,WHAT THE HELL GM WAITING FOR,WE NEED TO GET THIS INFORMATION OUT TO THE BUYING PUBLIC TO STOP BUYING GM PRODUCT THAT THEY WILL NOT STAND-BY. FIX YOUR PROBLEM. YOUR COOLANT CALLS FOR REPLACING 100,000 TO 150,000 MILES, NOT EVERY COUPLE OF DAYS. THE JAPANESE AUTO MAKERS WOULD HAVE SOLVED THIS PROBLEM A LONG TIME AGO AT NO CHARGE TO THE OWNERS. CLASS ACTION LAWSUIT IS IN ORDER.STOP-F----- YOUR MALIBU OWNER
Air bags, Oct 2, 2006, crash
HAD A SPIN OUT ACCIDENT TRAVELING 55 MPH - 60 MPH, HIT A GUARD RAIL FRONT ENDED, SPUN AND HIT THE REAR END OF CAR ON THE SAME GUARD RAIL, AIR BAGS DID NOT DEPLOY. *NM
Electrical system, Sep 25, 2006
1. EBCM FAILURE 2. HAZARD LIGHT FAILURE. *NM
Service brakes, Hydraulic, Sep 5, 2006, crash
DT*: THE CONTACT STATED WHILE COMING TO A STOP FROM 35 MPH, THE BRAKE PEDAL WAS DEPRESSED AND DID NOT RESPOND. THE VEHICLE'S FRONT PASSENGER SIDE COLLIDED WITH ANOTHER VEHICLE. A POLICE REPORT WAS TAKEN AT THE SCENE. THE VEHICLE OCCUPANTS RECEIVED MINOR INJURIES, ALTHOUGH THE SEATBELTS WERE WORN. THE VEHICLE WAS TOWED TO AN AUTO BODY AND DEEMED A TOTAL LOSS. THE VEHICLE WAS NOT INSPECTED TO DETERMINE THE CAUSE OF THE BRAKE FAILURE.
Electrical system, Aug 14, 2006
2000 CHEVY MALIBU PASSLOCK ANTI THEFT SYSTEM- CONTINUES TO ACTIVATE WITH ORIGINAL KEYS WILL NOT ALLOW THE CAR TO BE STARTED FOR 10 MINUTES SOMETIMES LONGER. HAPPENS 5-6 TIMES A MONTH. *JB
Fuel system, Gasoline, Electrical system, Aug 12, 2006
I HAVE BEEN HAVING PROBLEMS WITH MY HAZARD LIGHTS AS WELL AS TURNING SIGNALS. THEY HAVE BEEN REPLACED SINCE THE LAST RECALL, BUT HAVE WENT OUT AGAIN. I ALSO HAVE BEEN HAVING PROBLEMS WITH MY FUEL LINE, SUCH AS MY VEHICLE NOT WANTING TO ACCELERATE, IT SEEMS THAT IT IDLES AT A INTERSECTION LIGHT WITH THE RPM'S GOING UP TO THE 2 OR 3 THEN ACTING AS IF IT WANTS TO SHUT OFF. I HAD THE FUEL LINE REPLACED NOT EVEN THIRTY DAYS AFTER PURCHASING THE VEHICLE. I PURCHASED THE VEHICLE JAN OF 2000, AND I DID SEE SOME INVESTIGATION CONCERNING THE FUEL LINE MONTHS PRIOR TO THE PURCHASE. MY VEHICLE STOPPED ON THE SIDE OF THE HIGHWAY, AND MY VEHICLE WAS TOWED TO A CHEVORLET DEALER OUTSIDE OF LANSING NEAR LAKE ODESSA. I AT THAT TIME WAS NOT CHARGED FOR THIS FUEL PUMP WHICH THEY DID TRY TO CHARGE BUT BECAUSE IT HAPPENED WITHIN THE THIRTY DAYS THEY REPLACED THE FUEL PUMP AT NO CHARGE. I DO SEE ON THIS SITE THAT THIS VEHICLE A 2000 CHEVY MALIBU HAS BEEN INVESTIGATED DUE TO FUEL PROBLEMS SO I HOPING THIS WAS LOOKED INTO PROPERLY AND BROUGHT TO THE SURFACE ONCE AGAIN BECAUSE MY PUMP WAS CHANGED IN 2000 AND HAS BEEN GIVING ME PROBLEM SINCE 2002. I HAVE HAD TUNE-UPS, TRANSMISSION CHANGED, ROUTINE OIL CHANGES, FUEL LINE CLEANED, DIAGNOSIS RAN, AND THE RESULTS ARE NOTHING I'M HOPING TO GET TO THE BOTTOM OF THIS BEFORE TAKING ANY DOCUMENTATION TO A LAWYER CONCERNING A MATTER THAT HAS BEEN BROUGHT TO THE SURFACE BUT NOTHING DONE ABOUT IT. ALSO I'VE TOOK THIS VEHICLE BACK TO THE DEALER WHERE IT WAS PURCHASED AND THEY CAN'T FIND ANYTHING WRONG WITH IT. THE QUESTION THEY ASK IS WHETHER THE CHECK ENGINE LIGHT HAS COME ON OR NOT. I HAVE ALL SENSORS CHECKED OUT AND THAT NOT THE PROBLEM, BUT MY GAS LEAVES FAST AND I HAVE A HARD TIME ACCELERATING ON THE RESIDENTIAL STREETS AS WELL AS THE HIGH WAY. I ALSO HAVE BEEN HAVING TO CHANGE THE FUSES IN ORDER FOR MY HORN AND CIGARETTE LIGHTER TO WORK. SO SOMEONE PLEASE LOOK INTO THIS BECAUSE IT'S GETTING WORSE. THANKS FOR YOUR TIME AND CONSIDERATION. *NM
Exterior lighting, Aug 11, 2006
DT*: THE CONTACT STATED THE TURN SIGNALS WORKED INTERMITTENTLY. THERE WAS A NHTSA RECALL, # 03V327000, REGARDING THE EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH . THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. UPDATED 9/15/2006 - *NM
Engine and engine cooling, Aug 7, 2006
WE LOST ALL OF OUR ANTI-FREEZE THINKING WE LOST A HOSE. UPON TAKING IT IN TO A CERTIFIED MECHANIC HE HAD TO REPLACE THE MANIFOLD INTAKE GASKETS FOR THE 2ND TIME. UPON SHOWING THE MANIFOLD TO A MECHANIC FOR GM HE FOUND A BUBBLE IN THE MANIFOLD WHEN IT WAS MOLDED. *JB