2000 Chevrolet Malibu
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 944 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Malibu model years with reports.
Of the 2000 reports, 47 involved a crash and 7 involved a fire. 37 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Exterior lighting, hazard flashing warning lights, switchAug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Campaign 03V327000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, filler pipe and capOct 29, 1999
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN THE TANK IS MORE THAN HALF FULL.
IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.
DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.
Campaign 99V302000 on NHTSA.gov
Representative owner complaints
944 reports, newest first.
Engine and engine cooling, Nov 15, 2005
THE INITIAL PROBLEM WAS THAT THE CAR HAD DIFFICULTY STARTING AFTER THE CAR WAS WARM. WOULD USUALLY HAVE TO GIVE THE CAR GAS TO GET THE ENGINE TO TURN OVER. TOOK THE CAR TO THE DEALER AND WAS INFORMED THAT WAS THE LEAST OF MY PROBLEMS SINCE THE INTAKE MANIFOLD GASKET WAS LEAKING COOLANT INTO THE OIL. THE COST OF REPAIRS FOR THE LEAKING GASKET WAS OVER $650 AND TOLD WAS QUITE COMMON IN 2000 MALIBUS AND IF THE PROBLEM WAS NOT FIXED COULD CAUSE THE VEHICLE TO CATCH ON FIRE OR DESTROY THE ENGINE. THE CAR HAS LESS THAN 60,000 MILES. ALSO HAD TO REPLACE WIRES, PLUGS, IGNITION COIL AND FUEL FILTER WHICH WAS AN ADDITIONAL $475. I CAN UNDERSTAND THE WIRES, PLUGS, COIL AND FUEL FILTER AS USUAL MAINTENANCE COSTS, HOWEVER, THE LEAKING INTAKE MANIFOLD GASKET WHICH IS QUITE COMMON FROM BOTH YOUR WEBSITE AND CHEVY WEBSITE SHOULD BE ADDRESSED A POTENTIAL RECALL. OR INVESTIGATE THE POSSIBILITY OF SOME FUNDING BY CHEVY TO OFFSET THE HIGH REPAIR COSTS TO MANY OWNERS OF THE MALIBU WHO HAVE HAD TO HAVE THE INTAKE MANIFOLD GASKET REPAIRED. *JB
Exterior lighting, Visibility, Nov 2, 2005
HAZARD FLASHER BEGAN WORKING INTERMITTENTLY, THEN THE TURN SIGNALS BEGAN WORKING INTERMITTENTLY. NO PATTERN, THEY WOULD BE ON THEN GO OFF. I WAS IN HEAVY FREEWAY TRAFFIC WITH NO TURN SIGNAL OR HAZARD FLASHER. I WAS ABLE TO GET OFF THE FREEWAY AND DRIVE HOME USING ARM SIGNALS AND SLOWING TO ALLOW FASTER TRAFFIC TO PASS ME. *NM THE CONSUMER WISHES TO WITHDRAWAL THE COMPLAINT HE FILED WITH NHTSA. THE MANUFACTURER HAS AGREED TO REMEDY THE VEHICLE'S PROBLEM AT NO COST TO THE CONSUMER. *NM THE CONSUMER WAS TOLD THE RECALL DID NO APPLY TO HIS VEHICLE IDENTIFICATION NUMBER. THE WASHER PUMP WAS REPLACED DUE TO A LEAK.*JB
Service brakes, Hydraulic, Oct 28, 2005
DT: THE CONTACT STATED THE BACK PLATE FAILED ON THE REAR BRAKES. THE VEHICLE WAS IN NEUTRAL WITH THE EMERGENCY BRAKE ON AND THE BRAKE FAILED. UPON INSPECTION IT WAS DISCOVERED THE BACKER PLATE RUSTED OUT, RESULTING IN THE BRAKE FAILURE. THE PARKING BRAKE SYSTEM WAS A COMBINATION OF BOTH DISC AND DRUM BRAKES. THERE WAS NO WARNING PRIOR TO THE COMPLETE FAILURE OF THE BACK PLATE. THE BACK PLATE HAS NOT BEEN REPLACED AT THIS TIME. EARLIER THERE WAS A FAILURE OF THE ENTIRE VEHICLE BRAKING SYSTEM. ALL FOUR BRAKE ROTORS RUSTED, RESULTING IN TOTAL BRAKE FAILURE. THE WHEEL CYLINDER SEPARATED FROM THE CALIPERS. THE ONLY WARNING LIGHT CAME AFTER THE COMPLETE FAILURE OF THE LEFT ROTOR. THE ROTORS WERE REPLACED AND THE CALIPERS WERE REBUILT. THE BRAKE PADS HAD LESS THAN 50 % WEAR BUT THEY WERE REPLACED AS WELL. *AK
Exterior lighting, Oct 26, 2005
A FAULTY HAZARD SWITCH CAUSES THE TURN SIGNALS TO INTERMITTENTLY STOP WORKING AT THE MOST IN OPPORTUNE TIME. ON ONE OCCASION IT ALMOST RESULTED IN A SERIOUS ACCIDENT. THE SWITCH WAS REPLACED FOR THE SAME REASON BY THE DEALERSHIP ON APRIL 15, 2002. IT IS NOW MALFUNCTIONING AGAIN ONLY MUCH MORE FREQUENTLY THAN BEFORE. I SEE THAT THERE IS A RECALL FOR THIS ISSUE ON 2000/2001 MALIBU OWNERS(ID NUMBER 03V327000) BUT THE DEALERSHIP STATES THAT MY VIN NUMBER DOES NOT SHOW UP IN THE RECALL. HE ALSO CLAIMS THAT SINCE THE PART WAS ALREADY REPLACED ONCE IT WOULD NOT BE COVERED AGAIN. I SEARCHED THE WEB AND NOTICED THAT OWNERS OF 2002 MALIBUS ARE ALSO COMPLAINING OF THE SAME PROBLEM. SO, IT IS NOT JUST AN ISOLATED ISSUE. SINCE I NEVER USE THE HAZARD SWITCH IT CAN'T POSSIBLY HAVE GONE BAD BECAUSE OF WEAR AND TEAR. NOR IS IT A PART THAT WOULD BE USED FREQUENTLY ENOUGH TO WEAR OUT. THERE IS OBVIOUSLY A SERIOUS SAFETY DEFECT WITH THE PART. *JB
Engine and engine cooling, Oct 20, 2005
I PURCHASED A 2000 CHEVY MALIBU LS IN DECEMBER OF 2002. AFTER PURCHASING THIS VEHICLE SOMEONE WORKING IN THE SERVICE DEPARTMENT OF A GM DEALERSHIP TOLD ME I HAD MADE A BIG MISTAKE. HE SAID THE ENGINE HAD A SERIOUS PROBLEM. HE TOLD ME THE LOWER INTAKE GASKET WOULD EVENTUALLY FAIL. THE ONLY WAY OF FIXING THE PROBLEM ALSO INVOLVES REMOVING THE ENTIRE ENGINE FROM THE CAR. IN SEPTEMBER OF 2005 MY CAR HAS DEVELOPED THIS PROBLEM. I THEN CONTACTED A MECHANIC TO FIND HOW COMMON A PROBLEM THIS IS FOR THE ENGINE. HE WAS UNDER THE IMPRESSION IT HAPPENED TO ALL GM V6 ENGINES. THIS FAILURE IS A MAJOR MECHANICAL EXPENSE WHICH I DO NOT HAVE THE FUNDING TO FIX. WITH LESS THAN 65,000 MILES I DO NOT FEEL A CAR SHOULD DEVELOP MAJOR MECHANICAL DEFECTS. *NM
Exterior lighting, Oct 20, 2005
DT: THE CONTACT STATED THE TURN SIGNALS WORKED INTERMITTENTLY. THIS HAS BEEN HAPPENING FOR APPROXIMATELY SIX WEEKS. THE VEHICLE HAS NOT BEEN TAKEN TO A DEALERSHIP, BUT HE CONTACT SPOKE WITH THEM. THE DEALERSHIP REFUSED TO FIX THE PROBLEM UNDER RECALL 03V327000. THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. THERE HAVE BEEN NO REPAIRS TO THE VEHICLE AT THIS TIME. HE HAS CHECKED THE FUSES AND THEY SEEM TO BE FINE. *AK UPDATED 12/27/2005 - THE CONSUMER HAS THE RECALL THAT WAS SENT FROM THE MANUFACTURER BUT THE DEALER REFUSED TO PERFORM THE RECALL WORK. *NM
Service brakes, Hydraulic, Oct 18, 2005, crash
MY 2000 CHEVY MALIBU WITH ONLY 80,000 MILES HAD A KNUCKLE IN THE FRONT BRAKE SHOWING NO WEAR AND TEAR VEERING ME OFF ROAD ,IM GOING TO KEEP THE PART AND TAKE PICTURES. IT DROVE SMOOTH SINCE I BOUGHT IT. THEN TODAY THE FRONT TIRE FOLDED UNDER. ME AND THE CERTIFIED MECHANIC COULDNT EXPLAIN IT. THE PART SHOWED NO SIGN OF WEAR TO THE AREA THAT BROKE. IVE BEEN LOOKING TO SEE IF THERE WAS A RECALL, CANNOT FIND ONE IF THERE IS LET ME KNOW... THIS IS A VERY BIG DANGER AND IS LIFE THREATENING. AND IT WILL OBVIOUSLY HAPPEN WITHOUT A WARNING. A LOT OF PEOPLE ARE MAYBE HAVING THIS HAPPEN AND DONT LIVE TO TELL ABOUT IT BEING THE REASON OR DONT EVEN KNOW TO TELL ABOUT IT. THANX. *NM
Exterior lighting, Oct 17, 2005
DT: 2000 CHEVROLET MALIBU. THE CONTACT STATED THE HAZARD WARNING SIGNALS AND TURN SIGNALS STOPPED WORKING. FIRST IT WAS INTERMITTENT, AND THEN THEY JUST STOPPED. THE CONTACT FOUND A RECALL ONLINE. BUT, THIS VEHICLE WAS NOT PART OF THIS RECALL DUE TO VIN. THIS PROBLEM STARTED TWO MONTHS AGO. THE DEALERSHIP REPLACED THE HAZARD SWITCH, THE WIRES, AND THE CONNECTOR. THIS FIXED THE PROBLEM. *AK
Engine and engine cooling, Oct 13, 2005
DEX-COOL COOLANT LEAKED INTO ENGINE OF MY 2000 CHEVY MALIBU. THIS IS AN ONGOING PROBLEM FOR MANY GM OWNERS, AND IT IS WELL KNOWN BY EVERYONE EXPECT GM. BOTH THE DEALER AND CHEVROLET SAID THERE IS NOTHING THEY CAN DO, THAT I MUST PAY TO HAVE IT FIXED, ABOUT $1500.00. CHEVY MUST ADDRESS AND FIX THIS PROBLEM .*JB
Equipment, Oct 11, 2005
THE AIR CONDITIONER STOPPED WORKING ON FAN SPEEDS 1 AND 2. AFTER PULLING OUT THE BLOWER MOTOR RESISTOR, I FOUND OUT HALF THE CIRCUIT WAS BURNED OUT. AFTER REPLACING THE RESISTOR, THE FAN WORKS ON ALL SPEEDS. I THREW OUT THE OLD PART. *JB
Exterior lighting, Oct 11, 2005
GM'S RECALL #03V327000 WHICH STATES THAT THE HAZARD LIGHT SWITCH IS DEFECTIVE AND WILL KEEP THE TURN SIGNALS FROM FLASHING. MY 2000 MALIBU IS HAVING THIS TROUBLE, BUT SINCE THE VIN IS NOT WITHIN THE BREAK POINTS, I WILL HAVE TO PAY TO HAVE IT FIXED. *JB
Electrical system, Exterior lighting, Oct 11, 2005
ON JULY 7, 2005 I PURCHASED A 2000 CHEVY MALIBU LS. THE RIGHT TWO BRAKE LIGHTS CONTINUE TO BURN OUT. NEVER AT THE SAME TIME, IT'S EITHER THE ONE ON THE OUTSIDE OR THE INNER ONE.*JB
Exterior lighting, Oct 6, 2005
DT: ABOUT TWO MONTHS AGO THERE WAS A PROBLEM WITH THE TURN SIGNALS. THE TURN SIGNALS WOULD INTERMITTENTLY WORK. THE VEHICLE WAS NOT TAKEN TO THE DEALER BUT WAS CORRECTED BY THE CONSUMER'S HUSBAND WHO DETERMINED THAT THERE WAS A PROBLEM WITH THE HAZARD TURN SIGNAL SWITCH. HE RESEARCHED THIS THROUGH A REPAIR MANUAL AND CORRECTED THE PROBLEM BY REPLACING THE SWITCH. THERE HAD BEEN NO FURTHER PROBLEMS SINCE THE REPLACEMENT. NHTSA RECALL CAMPAIGN#03V327000 WAS ISSUED INVOLVING THE TURN SIGNALS, BUT THE CONSUMER'S VEHICLE WAS NOT INCLUDED DUE TO THE VIN. *AK (11/29/05) *SC
Exterior lighting, Oct 6, 2005
DT: THE TURN SIGNALS QUIT WITHOUT WARNING, THIS HAS BEEN GOING ON FOR ABOUT TWO MONTHS . THE CONSUMER ATTEMPTED TO USE THE TURN SIGNALS AND WAS ALMOST STRUCK FROM BEHIND WHEN SHE REALIZED THE TURN SIGNALS WERE NOT WORKING. THE VEHICLE WAS HAS NOT BEEN TO A DEALER YET. THE TURN SIGNALS COME AND GO OFF, SOMETIMES THEY WORK AND SOMETIMES THEY DO NOT WORK. THE VEHICLE HAS BEEN TO AN INDEPENDENT SERVICE SHOP, WHO COULD NOT FIND ANYTHING WRONG. NO EXPLANATION GIVEN AS TO WHAT THE PROBLEM WAS. THIS STILL REMAINED A PROBLEM. NO REPAIRS OR CORRECTIONS HAVE BEEN MADE. *AK UPDATED 12/27/2005 - THE FOUR WAY FLASHER UNIT WAS REPLACED ON 10/10/2005. *NM
Electrical system, Exterior lighting, Oct 5, 2005
DT: THE CONSUMER STATES THAT THE 2000 CHEVROLET MALIBU'S SIGNAL AND HAZARD LIGHTS MALFUNCTIONED. THE LIGHTS SOMETIMES WORK AND SOMETIMES THEY DO NOT. THIS HAS BEEN HAPPENING FOR ABOUT SIX MONTHS. THE CONSUMER TOOK THE VEHICLE TO DEALER ONCE TO HAVE IT CHECKED. THE CONSUMER SAID THAT HE LOOKED AT IT HIMSELF. THE CONSUMER HAS NOT CONTACTED GENERAL MOTORS. THE CONSUMER SAID THAT THE BATTERY POLE HAD A SHORT LIFE. THE CONSUMER REPLACED THE BATTERY POLE HIMSELF. THE CONSUMER INDICATED THAT THERE WAS A DELAY IN THE SIGNALS COMING ON.*AK
Exterior lighting, Sep 27, 2005
WHILE DRIVING AT NIGHT AND WHEN I USED MY TURN SIGNAL ON FOR A LEFT TURN. IT DID NOT OPERATE. MY MECHANIC TOLD ME ABOUT A SAFETY RECALL FOR MY VEHICLE. I CONTACTED TEAM CHEVROLET HERE IN COLORADO SPRINGS,CO AND WAS TOLD THERE WAS NO RECALL FOR MY 2000 CHEVROLET MALIBU.*JB
Exterior lighting, Sep 27, 2005
DT: THE CONTACT OWNS 2000 CHEVROLET MALIBU. THE TURN SIGNALS/FOUR-WAY HAZARD LIGHTS INTERMITTENTLY GO ON/OFF, AND SOMETIMES THEY ARE COMPLETELY INOPERABLE. THE CONTACT NOTICED THIS ABOUT TWO MONTHS AGO, AND IT HAS GOTTEN PROGRESSIVELY WORSE. HE HAS NOT TAKEN VEHICLE TO A DEALER. A MECHANIC TOLD HIM THERE WAS A RECALL 03V327000. GENERAL MOTORS TOLD HIM THAT THIS VEHICLE WAS NOT COVERED UNDER THE RECALL DUE TO VIN. *AK
Electrical system, Sep 10, 2005
MY CAR WILL NOT START WHEN THE THEFT SECURITY LIGHT COMES ON. THIS IS DANGEROUS SINCE I AM A SINGLE PARENT AND BECOME STRANDED WITH MY CHILDREN INSIDE THE CAR WITH ME OR HAVE TO PICK MY CHILDREN UP AND THEY HAVE TO WAIT ALONE OUTSIDE BECAUSE I AM SO LATE. TODAY, MY CAR HAS NOT STARTED FOR OVER ONE HOUR. IT IS STILL SITTING IN THE PARKING LOT UNABLE TO START BECAUSE OF THE SECURITY THEFT SYSTEM. I WISH THIS WOULD BE RECALLED, AND HOPE THAT PEOPLE DON'T HAVE TO START DYING FOR IT TO BE RECALLED. LOOKING ONLINE ABOUT THIS PROBLEM, I HAVE NOTICED THAT THERE ARE THOUSANDS OF COMPLAINTS FILED ON FORUMS. I BELIEVE THAT IF EVERYONE KNEW THE PROPER CHANNEL TO COMPLAIN TO, THAT THIS PROBLEM WOULD NO LONGER EXIST. MY ABS LIGHT COMES ON EVERYDAY. I HAVE HAD THE SENSOR LEADS CHANGED TWICE AND IT STILL COMES ON. MY AIR CONDITIONING WAS FINE UNTIL THIS SUMMER WHEN I NEEDED IT. ARE THESE CARS NOW DESIGNED TO BREAK DOWN AND BE UNRELIABLE JUST SO THAT THE DEALERS CAN CHARGE MONEY FOR DIAGNOSTICS AND MECHANICAL REPAIR? I AM SO FRUSTRATED AND HOPE THAT YOU CAN SEE HOW DANGEROUS THIS CAN BE. I BOUGHT THIS CAR BECAUSE I WANTED A RELIABLE, DEPENDABLE VEHICLE FOR MYSELF AND CHILDREN, WHAT WILL IT TAKE TO RECALL THIS PROBLEM? WILL I RECEIVE ACKNOWLEDGEMENT OF RECEIPT OF THIS COMPLAINT. I THANK YOU IN ADVANCE FOR YOUR TIME AND CONSIDERATION TO THIS VERY URGENT MATTER. THERE WAS A RECALL ON THE HAZARD SWITCH BECAUSE IT DIDN'T ALWAYS WORK, IT DIDN'T ALWAYS ALLOW FOR THE TURN SIGNALS TO WORK EITHER. I DOUBT THAT THERE WERE ANY DEATHS FROM THIS PROBLEM, AND IT WAS RECALLED. DOES SOMEONE HAVE TO DIE IN AN ACCIDENT AS A RESULT OF A PROBLEM WITH A VEHICLE BEFORE IT WILL BE RECALLED. PLEASE SEND ME ANY ADDITIONAL INFORMATION YOU MAY HAVE ABOUT WHO TO FILE ADDITIONAL COMPLAINTS WITH SO THAT I CAN DIRECT MY CONCERNS TO OTHER STATE OR FEDERAL AGENCIES AS WELL. *JB
Service brakes, Hydraulic, Sep 9, 2005
2000 CHEVROLET MALIBU DEVELOPED PROBLEMS WITH THE BRAKES.*MR THE BRAKE HAVE HAD TO BE REPLACED THREE TIMES, 24666, 37158 AND 49592 MILES. THE FIRST TIME THE MANUFACTURER FIXED THEM UNDER WARRANTY. THE OTHER TIMES THEY CLAIMED IT WAS NORMAL WEAR AND TEAR. THE LAST TIME THE BRAKES FAILED THE FRONT DISC PADS HAD WORN INTO THE ROTORS. *NM
Exterior lighting, Sep 9, 2005
DT: CONTACT STATED THE HAZARD WARNING FLASHING SWITCH FAILED. THE FIRST TIME HE USED IT WITHIN 1 MINUTE OF TURNING THE FLASHERS ON. HE CITED RECALL #03V327000. GM TOLD HIM THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN ALTHOUGH WAS HAVING THE EXACT SAME PROBLEMS AS MENTIONED IN THE RECALL. THIS OCCURRED ABOUT SIX WEEKS AGO. HAD THE SWITCH REPLACED. THERE WERE NO OTHER PROBLEMS. *AK *JB
Service brakes, Hydraulic, Engine and engine cooling, Aug 24, 2005
2000 CHEVROLET MALIBU DEVELOPED PROBLEMS WITH THE BRAKE EQUIPMENT.*MR THE CONSUMER HAD THE BRAKES REPLACED 3 TIMES. THE FIRST BRAKE SERVICE THEY WERE REPLACED UNDER WARRANTY AFTER THAT THE CONSUMER WAS TOLD IT WAS CONSIDERED WEAR AND TEAR. THE WATER PUMP WAS LEAKING. *JB
Engine and engine cooling, Aug 23, 2005
INTAKE GASKET COOLANT LEAKING PROBLEMS WHICH RESULTS TO OVERHEATING AND ENGINE FAILURES.
Electrical system, Aug 16, 2005
LUCKILY I HAVE NOT HAD ANY ACCIDENTS WITH MY 2000 CHEVY MALIBU. ONE OF THE MOST COMMON PROBLEMS WITH THIS MAKE AND MODEL OF VEHICLE IS THAT THE IGNITION LOCK CYLINDER AND IGNITION LOCK SWITCH MALFUNCTIONS. THIS CAUSES THE CAR TO NOT WANT TO START, AND WHILE DRIVING, THE CAR WILL STOP IN THE MIDDLE OF THE ROAD. I PERSONALLY HAVE BEEN STRANDED IN THE MIDDLE OF INTERSECTIONS BECAUSE OF THIS PROBLEM. THIS IS VERY UNSAFE, AND VERY EXPENSIVE TO FIX. I TOOK MY CAR INTO THE CHEVY DEALER TO HAVE IT LOOKED AT, AND IT COST ME $553.55 TO FIX THIS ONE PROBLEM, AND NOW MY LIGHTS DO NOT WANT TO WORK. *NM
Exterior lighting, Aug 15, 2005
DT: 2000 CHEVROLET MALIBU. THE TURN SIGNALS ARE NOT WORKING. IT STARTED OUT WITH THEM WORKING PART TIME, THERE IS A RECALL ON THIS PROBLEM, BUT THIS VEHICLE IS NOT INCLUDED DUE TO VIN ALTHOUGH IT DEALS WITH THE SAME PROBLEM THAT IS MENTIONED IN THE RECALL. HAS NOT HAD CAR DIAGNOSED FOR THIS PROBLEM. *AK
Tires, Aug 8, 2005
WE HAD PURCHASED UNIROYAL TIRES IN OCTOBER 2002 FROM FARM AND FLEET IN LA CROSSE. AS OF AUGUST 4, 2005, ALL THE TIRES NEEDED TO BE REPLACED DUE TO THE TIRES CRACKING AND PEELING. WE TOOK THE CAR TO SEARS WHERE THEY TOLD US THEY WOULD NOT LET US DRIVE THE CAR DUE THE SEVERITY OF THE PEELING OF THE TIRES. DRIVING OUR CAR WITH THE TIRES IN THE POOR CONDITION COULD CAUSE AND ACCIDENT AND INJURY. I STARTED HAVING A PANIC ATTACK AFTER HEARING THIS NEWS. WE WERE TOLD THAT THIS IS NOT NORMAL FOR TIRES TO SHRED, CRACK, AND PEEL AT ONLY 40,000 MILES. I CALLED FARM AND FLEET WHERE WE BOUGHT THE TIRES AND HE TOLD ME "TOO BAD" AND HUNG UP ON ME. I CALLED UNIROYAL AND SHE SAID IT IS NOT THEIR PROBLEM IF OUR TIRES CRACKED, THAT'S WHAT TIRES DO. THESE TIRES THAT CRACKED, PEELED, AND SHREDDED HAVE A 75,000 MILES WARRANTY, NOONE WILL HONOR THIS WARRANTY AND WE HAD TO SPEND OVER $400 BUYING NEW TIRES. *NM