2000 Chevrolet Malibu
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 944 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Malibu model years with reports.
Of the 2000 reports, 47 involved a crash and 7 involved a fire. 37 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Exterior lighting, hazard flashing warning lights, switchAug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Campaign 03V327000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, filler pipe and capOct 29, 1999
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN THE TANK IS MORE THAN HALF FULL.
IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.
DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.
Campaign 99V302000 on NHTSA.gov
Representative owner complaints
944 reports, newest first.
Exterior lighting, Mar 20, 2004
TURN SIGNALS WORK INTERMITTENTLY AS WELL AS FLASHERS. GM STATES MY VEHICLE IS NOT COVERED BY RECALL. *JB
Service brakes, Air, Mar 19, 2004
I HAVE 2000 CHEVY MALIBU. BREAKS (ABS) OCCATIONALLY LOOSE POWER WHILE ON A DRY DAY AND MAY LOCK ON A WET DAY WHILE CAR SKID TO STOP (A DIFFICULT TO CONTROL SITUATION). DEALER REPLACED THE HUB (FOR A BAD ABS SENSOR!) BUT IT DID NOT FIX THE PROBLEM; DEALER CONTENDS THAT SUCH OCCURANCE IS NORMAL AND RECOMMENDS CAUTION. I BELIEVE IT IS RESULT OF A MALFUNCTION OR DEFECT AND IS ONLY A MATTER OF TIME FOR AN ACCIDENT TO HAPPEN.*AK
Exterior lighting, Mar 15, 2004
I HAVE A 2000 CHEVROLET MALIBU THAT HAS THE SYMPTOMS LISTED IN THE RECALL THAT IS COVERED UNDER THE NHTSA CAMPAIGN ID NUMBER 03V327000. HOWEVER, MY VEHICLE HAS A BUILD DATE PRIOR TO THE BUILD DATE COVERED BY THIS RECALL. IT WOULD SEEM TO ME THAT THE FAULTY COMPONET WAS BEING USED EARLIER THAN ORIGINALLY THOUGHT. *AK
Engine and engine cooling, Mar 12, 2004
INTAKE MANIFOLD GASKET FAILED AT 49000 MILES. GM IS AWARE OF THE PROBLEM BUT WILL NOT TAKE ACTION ON IT. THE MOST DISCOURAGING THING ABOUT THE PROBLEM IS THE CONTEMPT THAT GM SEEMS TO HAVE FOR THEIR CONSUMERS. THEY RELEASED A TECHNICAL SERVICE BULLETIN TO THEIR DEALERS REGARDING THE PROBLEM, YET THEY DO NOTHING FOR THOSE AFFECTED BY AN OBVIOUS PRODUCT DEFECT. MY REQUEST FOR COST ASSISTANCE FROM GENERAL MOTORS WAS MET WITH A FLIPPANT ATTITUDE TOWARD THE LOSS OF MY LOYALTY AS A CUSTOMER.*AK
Exterior lighting, Mar 11, 2004, crash
THE VEHICLE EXPERIENCED PROBLEMS WITH THE TURN SIGNALS AND THE HAZARD LIGHTS. THEY BOTH WORKED INTERMITTENTLY. PROVIDE FURTHER DETAILS. *JB THE FAILURE OF TURN SIGNALS CAUSED AN ACCIDENT. TURN SIGNALS WERE ALSO REPAIRED AT NO CHARGE TO THE CONSUMER. *LA
Engine and engine cooling, Mar 5, 2004
VEHICLE DIED UNEXPECTEDLY AT HIGHWAY SPEEDS. *AK
Engine and engine cooling, Mar 4, 2004
INTAKE MANIFOLD BEGAN LEAKING AT 45000 MILES (500 DOLLARS TO REPLACE), HAVE REPLACED THE BRAKES AND ROTORS 4 TIMES IN 65,000 MILES. THE TURN SIGNALS QUIT WORKING. WHILE DRIVING DOWN THE ROAD THE ENGINE JUST DIES. IF I LET IT SIT FOR A WHILE IT WILL CRANK BACK UP. ASE MECHANIC TOLD ME IT WAS THE IGNITION MODULE, SO I PAID TO HAVE IT REPLACED AND THAT DID NOT FIX IT. I HAVE BEEN REVIEWING FORUMS ON-LINE AND HAVE DISCOVERED THAT THIS IS A WIDE SPREAD AND SEVERE PROBLEM, I UNDERSTAND NORMAL WEAR AND TEAR ON A VEHICLE BUT THIS IS RIDICULOUS. AND LAST BUT NOT LEAST, THE FAN SWITCH HAS QUIT WORKING ON POSITONS (SPEEDS) 1 AND 2...THAT HAPPENED WHEN THE CAR HAD ABOUT 37,000 MILES ON (NOT UNDER FACTORY WARRANTY) ....I ONCE WAS A DIE HARD CHEVY MAN..THANKS TO THIS CAR I WILL NOT BUY ANOTHER GM PRODUCT. *AK
Service brakes, Hydraulic, Engine and engine cooling, Mar 3, 2004
2000 CHEVROLET MALIBU BOUGHT WITH 120,000 MILES ON IT. LESS THAN A WEEK AFTER GETTING THIS CAR FOR 5500.00, WHEN RETAIL ON THE CAR WAS 8300.00, I HAD TO REPLACE THE INTAKE MANIFOLD GASKET AND THE VALVE COVER GASKETS BECAUSE THEY WERE LEAKING COOLANT. ALSO, THE BRAKES SHUDDER AND VIBRATE WHENEVER APPLIED, EVEN AT SPEEDS LESS THAN 25 MPH. HALF A WEEK LATER, THE GAS GAUGE FELL TO ZERO WHILE NORMAL DRIVING AND THE LOW GAS LIGHT CAME ON, EVEN THOUGH I HAD JUST FILLED THE CAR UP TWO DAYS PRIOR. THERE WAS PLENTY OF GAS IN THE CAR, ABOUT 3/4 OF A TANK. ALSO, THE TRANMISSION IS SLIPPING NOW WHEN I SPEED UP. WHEN I SPEED UP THE CAR DOES NOT SHIFT INTO 1ST GEAR RIGHT AWAY UNTIL 4000 RPM. WHEN IT DOES SHIFT, IT SHIFT WITH A LARGE JOLT THAT SHAKES THE ENTIRE CAR. THERE WAS NO WARNING BEFORE THE GAS LIGHT CAME ON, AND I FIND THE CAR TO ONLY NOW HAVE ALL OF THESE PROBLEMS. ALSO, THE CAR SMELLS OF GASOLINE AND LEAKS, EVEN THOUGH I HAD IT FIXED. *AK
Electrical system, Feb 27, 2004
ELECTRONIC COMPUTER MODULE MALFUNCTIONING. CHEVY MALIBU 2000 IS ONLY FOUR YEARS OLD. THIS PROBLEM SHOULD NOT BE HAPPENING. WHEN STARTING THE CAR ALL OF THE WARNING LIGHTS COME ON, FUEL GAGE DOES NOT WORK , SPEEDOMETER DOES NOT WORK, NO HEAT OR AIR CONDITIONING BLOWS, WINDOWS WILL NOT ROLL DOWN, EVENTUALLY ALL LIGHTS POP OFF EXCEPT THE CHECK ENGINE LIGHT AND EVERYTHING BEGINS TO WORK... WINDOWS, TEMPERATURE, SPEEDOMETER, FUEL GAGE, ETC...
Power train, Feb 24, 2004
TRANSMISSION PROBLEMS FOR 8 TIMES IN 2YRS I HAVE HAD IT. *AK
Steering, Feb 19, 2004
VEHICLE DEVELOPED A PROBLEM WITH THE POWER STEERING WHEN ATTEMPTING TO MAKE LEFT TURNS. *LA THE CONSUMER STATED THE STEERING VIRTUALLY LOCKED UP. THE CONSUMER STATED HIS VEHICLE HAD THE SAME PROBLEM AS STATED IN THE RECALL FOR PREVIOUS MODELS REGARDING THE STEERING RACK AND PINION. (RECALL#03V527000). *JB
Service brakes, Hydraulic, Feb 19, 2004
WHEN THE DRIVER APPLIED THE BRAKES THE VEHICLE SHOOK. THE CONSUMER STATED THAT THE VEHICLE NEEDED TO HAVE NEW BRAKE PADS AND ROTORS EVERY 6,000 MILES. *NM
Electrical system, Feb 19, 2004
WHEN THE CONSUMER ATTEMPTED TO STARTED THE VEHICLE THE ANTI THEFT LIGHTS ILLUMINATED ON THE DASHBOARD. WHEN THIS LIGHT IS ILLUMINATED THE VEHICLE WILL NOT START. THE HEATER AND SIGNAL LIGHTS ALSO FAILED TO OPERATE. THE MANUFACTURER AND THE DEALER WILL BE INFORMED OF THE PROBLEM. *NM
Service brakes, Hydraulic, Feb 19, 2004
THE CONSUMER COMPLAINED ABOUT BRAKE PROBLEMS. WHEN APPLYING BRAKES THE PEDAL GOES ALL THE WAY TO THE FLOOR, THERE WAS EXTENSIVE PULSATION, AND EXTENDED STOPPING DISTANCE. *AK THE ABS LIGHT WAS ON AND WAS INTERMITTENT. THIS MADE THE STOPPING DISTANCE LONGER ALMOST CAUSING ACCIDENTS. *SC
Electrical system, Feb 18, 2004
IGNIGTION LOCK CYLINDER HAVING DIFFICULTY TURN THE IGNITION DUE TO TUMBLERS NOT WORKING PROPERLY. HAD SEVERAL MONTHS WHERE IT TOOK 10-20 MINUTES TO START THE CAR BECAUSE THE KEY WOULD NOT TURN THE IGNIGTION OVER VARIOUS NUMBER OF DATES. *AK
Fuel system, Gasoline, Electrical system, Feb 17, 2004
VEHICLE LOST POWER AND QUIT WHILE DRIVING ON THE INTERSTATE HIGHWAY. *JB
Engine and engine cooling, Feb 13, 2004
ANTIFREEZE USED IN OUR 2000 MALIBU HAS BEEN FOUND TO FREQUENTLY CAUSE DETERIORATION AND FAILURE OF THE INTAKE MANIFOLD GASKET. THERE HVE BEEN MANY CASES SITED ON THE INTERNET WITH NAMES AND SPECIFICS AND CHEVY/GMC REFUSES TO ADMIT IT IS THE ANTIFREEZE. THEY TOLD ME LAST NIGHT IT HAS TO DO WITH THE PLANT WHERE THE CAR WAS MADE.*AK
Steering, Feb 11, 2004
RACK AND PINION STEERING FAILED. A RECALL WAS ISSUED; HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN RECALL DUE TO MODEL YEAR. *AK
Engine and engine cooling, Feb 11, 2004
AT 55000 MILES HAD TO REPLACE LOWER INTAKE MANIFOLD GASKET. LOOKS LIKE IS A COMMON PROBLEM WITH THE MALIBU.GM MUST DO SOMETHING.*AK
Fuel system, Gasoline, Electrical system, Feb 10, 2004
WHILE DRIVING AND/OR ATTEMPTING TO USE THE TURN SIGNAL, A SHORT IN THE FLASHER SWITCH MADE THE TURN SIGNAL INOPERATIVE AND MADE OTHER ELECTRICAL COMPONENTS INOPERATIVE (EX. GAUGES, RADIO AND A/C FAN). THE ELECTRICAL PROBLEM ALSO CAUSED THE ENGINE TO STALL. WHEN THE CONSUMER PUSHED THE FLASHER SWITCH REPEATEDLY THE ELECTRICAL COMPONENTS WOULD WORK TEMPORARILY. THE FUEL PUMP WAS REPLACED TO ALLEVIATE THE STALLING CONDITION. THE TECHNICIAN HAS IDENTIFIED A PROBLEM IN THE FLASHER SWITCH BUT HAS NOT REPLACED IT. A RECALL ON THE SWITCH IS SCHEDULED TO START LATER IN 2004 HOWEVER THE CONSUMER'S VEHICLE IS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK *NM
Exterior lighting, Visibility, Feb 2, 2004
THE FRONT WINDSHIELD WIPER/TURN SIGNAL WAS HARD TO ACTIVATE. THE CAUSE HAS NOT BEEN DETERMINED. *NM
Service brakes, Hydraulic, Jan 30, 2004
2000 CHEVY MALIBU SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
Engine and engine cooling, Equipment, Jan 21, 2004
ON YOUR SITE I HAVE FOUND MANY COMPLAINTS REGARDING COOLANT LEAK DUE TO POOR SEALING OF THE MANIFLOD GASKET THAT ACCORDING THE SEVICE BULLETIN ON THIS SITE, REQUIRES NEW GASKET TYPE TO REPLACE THE OLD, AND THE INTAKE MANIFOLD BOLTS CLEANED AND COATED WITH THREDLOCKER AND TORQUED TO A REVISED SPEC. THIS HAS ALREADY BEEN DONE ONCE TO MY CAR AT ABOUT 30K MILES AND FORTUNATELY COVER UNDER WARRANTY, IF NOT IT WOULD HAVE COST ME $1050, PROBLEM IS NOW THE CAR IS DOING THE SAME THING AGAIN AT 79K MILES AND IS NO LONGER UNDER WARRANTY....HOW MANY TIMES SHOULD THIS HAPPEN? WAS THE SERVICE BULLETIN PUT OUT AS A PERMAMANT SOLUTION FOR THIS PROBLEM? IF NOT HOW LONG SHOULD THIS WORK BE GUARANTEED? WHY WAS THERE NOT A RECALL ON THIS PROBLEM? DOES THERE HAVE TO BE A FATALITY TO RECALL A VECHICLE? IN ADDITION I ALSO HAVE HAD THE PROBLEM WITH THE HAZARD WARNING SWITCH THAT ALSO EFFECTED THE WIPERS, NEITHER WOULD WORK, AGAIN THIS REPAIR WAS SUBMITTED AS WARRANTY WORK. I HAVE COMPLAINED SEVERAL TIMES TO BOB BELL CHEVY ABOUT HOW HOT THE DASH INSTRUMENTS GET TO TOUCH AND HAVE ALREADY HAD TO HAVE RELATED ELECTRICAL PROBLEMS REPAIRED, TO NOTE..WHEN I FIRST COMPLAINED ABOUT THE HEAT WHEN TOUCHED TO CHANGE INTRUMENT SETTINGS I WAS TOLD "THAT'S NORMAL". GRANTED MY EXTENDED WARRANTY COVERED SOME OF THE WORK BUT I STILL HAD TO PAY A $250 DEDUCTABLE W/EACH PROBLEM. ALL THESE PROBLEMS HAVE BEEN REPORTED ON THIS NHTSA SITE BY MANY PEOPLE AND ADDITION OTHERS I KNOW PERSONALLY AND WHO I HAVE HAD MANY DISCUSSIONS WITH ALSO HAVE THE SAME YEAR MALIBU WITH ALL THE SAME PROBLEMS....WHY HASN'T THE MANUFACT. RECALLED THE CAR FOR THESES PROBLEMS, SURELY ALL CAN CAUSE FIRE SAFETY PROBLEMS. HOW ARE RECALLS DETERMINED AND WHAT CAN WE ALL DO????????????? I NEVER DREAMED CHEVROLET WOULD BE SO CHEESY. MY LAST CAR WAS 12 YEARS OLD AND OLDS CUSTOM CRUISER WAGON - NEVER GAVE ME A PROBLEM THAT WAS SO MAJOR AS THESE NOTED HERE, I SHOULD HAVE NEVER GOT RID OF IT FOR THIS MALIBU!*AK
Exterior lighting, Jan 20, 2004
TURN SIGNALS ARE WORKING INTERMITTENTLY. INDEPENDENT REPAIR SHOP INDICATED THAT HAZARD SWITCH NEEDED TO BE REPLACED. *AK
Exterior lighting, Jan 20, 2004
THE TURN SIGNALS / HAZARD FLASHERS ON MY 2000 CHEVROLET MALIBU DO NOT WORK PROPERLY. THIS IS AN IMPORTANT PROBLEM THAT COULD RESULT IN AN ACCIDENT. *AK I REACHED MY DEALER WHO WAS HELPFUL HOWEVER THEY SAID THEY COULD NOT RECTIFY THIS PROBLEM AS THE VEHICLE HAS NOT BEEN RECALLED. I ALSO SAW AN ARTICLE IN THE 12/03 EDITION OF CONSUMER REPORTS CITING THIS ISSUE. PLEASE ADVISE WHAT IS BEING DONE TO CORRECT THIS MATTER.