2000 Chevrolet Malibu
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 944 owner complaints filed for this model year. This is the 9th highest complaint count among 26 Malibu model years with reports.
Of the 2000 reports, 47 involved a crash and 7 involved a fire. 37 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Exterior lighting, hazard flashing warning lights, switchAug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Campaign 03V327000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, filler pipe and capOct 29, 1999
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN THE TANK IS MORE THAN HALF FULL.
IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.
DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.
Campaign 99V302000 on NHTSA.gov
Representative owner complaints
944 reports, newest first.
Electrical system, Nov 11, 2003
VEHICLE PASSLOCK THEFT DEVICE IS DEFECTIVE. AT LEAST A COUPLE TIMES PER WEEK THE PASSLOCK SYSTEM ENGAGES MAKING THE VEHICLE INOPERATIVE. *AK
Steering, Service brakes, Air, Engine and engine cooling, Fuel system, Other, Nov 8, 2003
I PUCHASED THIS CAR WITH 20000 MILES ON IT. I HAD IT FOR A LITTLE OVER 5 MONTHS AND I AM REPLACING A FUEL PUMP THAT WILL COST $650. THE POWER STEERING HAS CORROSION, SO THE POWER STEERING HAS TO BE FLUSHED. REPLACEMENT OF THE FUEL FILTER, A CRACKED FAN BELT, AND THROTTLE BODY SERVICE. I HAVE THE GM EXTENDED WARRANTY, BUT IT ONLY COVERS THE COST TO REPLACE THE FUEL PUMP. EVERYTHING ELSE IS OUT OF POCKET EXPENSES BECAUSE IT IS CONSIDERED "REGULAR MAINTENANCE". THE BRAKES ALSO GRIND AND SEEM TO TAKE TOO LONG FOR THE CAR TO STOP. SO I THINK BRAKES AREN'T FAR BEHIND TO BE REPLACED. I AM HOPING I WILL NOT NEED ROTORS TOO. I HAVE READ SO MANY COMPLAINTS ABOUT THE BRAKES ON THE 2000 CHEVY MALIBU. I TRY TO BUY AMERICAN BECAUSE I AM A PROUD ONE. BUT THE QUALITY SEEM TO BE SUBSTANDARD COMPARED TO JAPANESE CARS. MY NEXT CAR WILL BE FOREIGN. US CAR MAKERS NEED TO "STEP IT UP", AS FAR AS QUALITY WITH THESE CARS.*AK
Engine and engine cooling, Oct 25, 2003
COOLANT LOSS CAUSING VEHICLE TO OVERHEAT. CAR TOWED TO GARAGE. HAD TO REMOVE AND REPLACE INTATKE MANIFOLD GASKET, REPLACE THERMOSTAT, AND REVERSE FLUSH COOLING SYSTEM. TOTAL COST $664.31 WAS ADVISED TO FILE COMPLAINT AS GARAGE HAS HAD AN AVERAGE OF ONE REPAIR LIKE THIS A MONTH ON MAILBUS AND IMPALAS. *LA
Exterior lighting, Oct 24, 2003
FAILURE OF BLINKERS. SUDDENLY WHEN DRIVING DOWN THE ROAD, I TURNED ON MY TURN SIGNAL AND IT WOULD NOT WORK. IT IS STILL NOT WORKING. ALL IT DOES IS PRODUCE A HIGH PITCHED BUZZ INSIDE OF MY AUTOMOBILE. LUCKILY I LIVE IN A LOW TRAFFIC AREA AND WAS NOT STRUCK. *LA
Engine and engine cooling, Oct 21, 2003
WHILE DRIVING AT HIGHWAY SPEED VEHICLE WILL SUDDENLY STALL WITHOUT WARNING. AS A RESULT VEHICLE LOOSES POWER. WHEN THIS OCCURS CONSUMER HAS TO COAST VEHICLE TO A STOP.*AK
Exterior lighting, Oct 17, 2003
VEHICLE IS EXPERIENCING A PROBLEM WITH THE TURN SIGNALS OPERATING POORELY. THERE IS A RECALL ON TURN SIGNAL; HOWEVER, THIS VEHICLE IS NOT INCLUDED UNDER THE RECALL BECAUSE IT FAILS TO MEET THE MANUFACTURING DATE BY 5 MONTHS ALTHOUGH IT IS EXPERIENCING THE SAME PROBLEMS. *AK
Service brakes, Hydraulic, Oct 17, 2003
MY 2000 CHEVROLET MALIBU HAS ONLY 77,749 MILES ON IT. I AM THE ORIGINAL OWNER AND PURCHASED THE CAR NEW. SINCE THE PURCHASE I HAVE REPLACED ROTORS AND BRAKE PADS 4 TIMES. THIS IS ABSOLUTELY ABSURD. THERE MUST BE SOME KIND OF A DEFECT IN THE VEHICLE FOR A PERSON TO HAVE TO REPLACE ROTORS AND PADS 4 TIMES WITHIN THE AMOUNT OF MILEAGE I HAVE PLACED ON MY CAR. NEVER IN MY LIFE HAVE I HAD TO DO THIS ON ANY OTHER CAR I HAVE OWNED. I HAVE ALL THE PAPERWORK WHERE THESE ROTORS HAVE BEEN REPLACED. 3 TIMES AT THE DEALERSHIP AND THE 4TH TIME AT A PRIVATE AUTO REPAIR SHOP. I WASN'T SURE IF THE DEALERSHIP WAS DOING THEIR JOB CORRECTLY BECAUSE OF THE AMOUNT OF TIMES I HAVE THIS DONE I DECIDED TO GO TO A PRIVATE AUTO REPAIR SHOP. *LA
Service brakes, Air, Oct 16, 2003
BRAKING SYSTEM FAILS. HAVE THE CAR REPAIRED 3 TIMES FOR SAME PROBLEM. JUST BOUGHT THE CAR ONE WEEK AGO. SPOKE TO OTHER MALIBU OWNERS AND THEY HAVE HAD THE SAME PROBLEMS. *LA
Exterior lighting, Oct 14, 2003
THE TURN SIGNALS AND HAZARD FLASHERS ON MY 2000 CHEVY MALIBU ONLY WORK INTERMITTENTLY. OFTEN TIMES THEY WILL NOT WORK AT ALL, OR THEY WILL STOP WORKING IN THE MIDDLE OF A TURN. THEY WILL FLASH ONCE OR TWICE AND QUIT WORKING; IN ADDITION, THEY WILL WORK FOR A MOMENT THEN QUIT WORKING THEN BEGIN WORKING AGAIN. ALSO, RAREST OF ALL, THEY WILL WORK FINE. THERE IS A RECALL ON THE TURN SIGNALS AND HAZARD FLASHERS FOR THE SAME MAKE, MODEL, AND YEAR; HOWEVER, GM HAS TOLD ME THAT IT DOES NOT COVER MY VEHICLE. OBVIOUSLY, THE PROBLEM THAT I AM EXPERIENCING IS THE SAME OR SIMILAR TO THE PROBLEMS EXPERIENCED IN COVERED VEHICLES (IF, IN FACT, MINE IS NOT A COVERED VEHICLE). THIS HAS BEEN HAPPENING FOR SEVERAL MONTHS WITHOUT AN OBVIOUS CAUSE. THERE ARE NO CONDITIONS WHICH MADE MY CAR IMMUNE FROM THIS PROBLEM, BUT IT HAPPENS LESS WHEN I RUN THE AIR CONDITIONER. *LA
Engine and engine cooling, Oct 12, 2003
2000 MALIBU HAS DIED 7 TIMES WHILE DRIVING DEALER HAS REPLACED FUEL FILTER AND PUMP,RADAR CAP ,IGNITION MODULAR, IGNITION SWITCH,MAIN COMPUTER AND IT STILL DYING. I HAVE JUST LOOK AT ALL THE COMPLAINT THAT PEOPLE HAVE AND CHEVROLET TELLS ME THEY KNOW NOTHING ABOUT THEM.I WILL NEVER BUY OTHER ONE. *LA
Engine and engine cooling, Electrical system, Oct 6, 2003
I BOUGHT THIS CAR BRAND NEW (HAD 4 MILES ON IT) IN AUGUST OF 2000. WITHIN A MONTH, THE A/C MOTOR HAD TO BE REPLACED. WITHIN 6 MONTHS THE ENGINE BEGAN TO SURGE, AND FELT LIKE IT WAS GOING TO STALL WHENEVER AT A STOP. DURING THIS SAME PERIOD OF TIME, THE BRAKES BEGAN PULSATING, AND I REPLACED THEM ON MY OWN. I HAVE NOT HAD AN ISSUE WITH THEM SINCE. THEN THIS YEAR, 2003, IT COMPLETELY DIED ON ME WHILE DOING 70 IN RUSH HOUR TRAFFIC ON THE FREEWAY IN SAN DIEGO. MY WHOLE FAMILY WAS IN THE CAR, AND WE COULD HAVE BEEN KILLED. I COULDN'T EVEN TURN ON THE FLASHERS TO LET OTHER DRIVERS KNOW WE WERE IN TROUBLE. OBVIOUSLY, THE POWER STEERING WENT OUT, AND WE HAD TO CROSS THREE LANES OF TRAFFIC, SOLELY PROPELLED BY OUR EXISTING MOMENTUM, WITHOUT THE ABILITY TO STEER. I AM BEGINNING THE PROCESS OF TRYING TO ASSESS WHAT THE ISSUE IS, THOUGH I AM SURE IT IS THE ALTERNATOR. THE BATTERY WAS TESTED, AND DIAGNOSED AS PERFECT, OTHER THAN NEEDING A FULL RECHARGING (IT WAS DRAINED BY ANOTHER COMPONENT). ONCE I DETERMINE WHAT IS WRONG, I INTEND TO GO TO CHEVY, AND HARASS THEM UNTIL THEY FIX IT. THEN, I AM GOING TO TRY AND ENTER INTO ARBITRATION, AND HOPEFULLY GET RID OF THE CAR ALTOGETHER. IF ANYONE HAS THE "SOLUTION" TO THE STALLING PROBLEM, PLEASE EMAIL ME ! MJARAMILLO @ EXCITE . COM *JB
Electrical system, Oct 4, 2003
2000 CHEVROLET MALIBU , ENGINE SHUT DOWN AT NORMAL DRIVING SPEED 4 TIMES ALTHOUGH PLENTY OF FUEL IN TANK. *LA
Electrical system, Oct 1, 2003
A MAJOR ELECTRICAL PROBLEM IN 2000 CHEV. MALIBU. WHICH OCCURS IN AN OCCASIONAL BASIS. THE TURN INDICATORS WORK INCONSISTENTLY, DOESN'T WORK WHEN IT IS DAMPED OR RAINING. THE ELECTRIC/POWER WINDOW OF THE DRIVER SIDE AND REAR RIGHT SIDE WOULDN'T GO DOWN, AND THE FLICKER SWITCH FROM THE DASH LIGHTS DOESN'T WORK FROM TIME TO TIME. CONSUMER HAS DISCONNECTED AND RECONNECTED THE BATTERY ONCE FOR WHICH RESTORED ELECTRICITY TO THE TWO WINDOWS (THE OTHER WINDOWS WORKED FINE); HOWEVER, I STILL EXPERIENCE PROBLEMS WITH ITS TURN INDICATORS, WHICH WORK INCONSISTENTLY. I'M ASKING IF THIS PROBLEM HAS ANY CONNECTION(S) TO THE RECALL OF THE EMERGENCY FLASHER SWITCH? *LA
Suspension, Sep 30, 2003
CONSUMER HEARD WHILE TRAVELING A CLICKING SOUND FROM FRONT END OF VEHICLE AND STEERING WHEEL. *AK
Exterior lighting, Sep 26, 2003
CONSUMER NOTICED TURN SIGNAL FLASHER FROZE, CAUSING A BUZZING SOUND. *AK
Electrical system, Sep 25, 2003
THE 4 WAY FLASHER FAILED TO WORK PROPERLY AFTER BEING TURNED ON. THE TURN SIGNALS WORKED ONLY INTERMITTENTLY WHEN IN USE. PLEASE PROVIDE FURTHER INFORMATION. *NLM
Tires, Sep 23, 2003
WHILE DRIVING APPROXIMATELY 35 MPH REAR RIGHT TIRE HAD BLOWN. MANAGED TO PULL VEHICLE TO THE SIDE OF ROAD, STOPPED, AND CHECKED TIRES OUT. NOTICED RIGHT REAR TIRE HAD SEPARATED IN THREE DIFFERENT PIECES. CONTACTED THE MANUFACTURER. HAD NOT BEEN TO DEALERSHIP FOR REPAIRS. SIZE 215/60R15.
Exterior lighting, Sep 15, 2003
THE TURN SIGNALS DON'T WORK SOMETIMES. *AK THE TURN SIGNALS ALSO FAILED IN (DECEMBER 01) WHEN THE VEHICLE HAD LESS THAN 36K MILES. THE DEALER REPAIRED THE PROBLEM, HOWEVER, THE PROBLEM REMAINED. THE SECOND TIME THE PROBLEM OCCURRED THE DEALER WOULD NOT AGREE TO REPAIR THE PROBLEM. *SCC *JB
Other or unspecified, Sep 14, 2003
I PURCHASED MY VEHICLE AT MAJOR AUTOMOTIVE GROUP AND SINCE I HAVE PURCHASED MY CAR I HAVE HAD MANY PROBLEMS WITH IT. WHEN I WENT BACK TO THE DEALERSHIP AND ASKED TO EXCHANGE THE CAR FOR ANOTHER ONE, I WAS INFORMED THAT I COULD NOT UNTIL MY TITLE WAS RECEIVED. I HAVE HAD THE VEHICLE SINCE JULY 5, 2003 AND STILL HAVE NOT RECEIVED A TITLE AS OF YET. I HAVE BEEN BACK AND FORTH FOR MANY REPAIRS AND STILL HAVE NOT SEEN ANY DIFFERENCE. THE CAR STILL REMAINS THE SAME AND I ONLY HAVE ONE MORE MONTH LEFT OF MY WARRANTY. I REALLY FEEL AS THOUGH THEY ARE WAITING FOR THE WARRANTY TO BE UP SO THAT SOME ACTION COULD BE DONE. *PH
Electrical system, Sep 12, 2003
VEHICLE SHUTS COMPLETELY DOWN AT WHEN GOING OVER A BUMP OR POTHOLE IN THE ROAD. DOES NOT HAPPEN EVERY TIME A BUMP IS HIT, BUT HAS HAPPENED OVER 10 TIMES AND YOU NEVER KNOW WHEN IT MIGHT HAPPEN. *PH
Engine and engine cooling, Fuel system, Other, Sep 9, 2003
FUEL GAUGE WILL NOT REGISTER A HALF TANK OR LESS. VEHICLE HAS TO HAVE A FULL FUEL TANK. ALSO, WITHOUT WARNING OR CAUSE VEHICLE WILL SHUT DOWN, AND WILL NOT RESTART. DEALERSHIP MECHANIC WAS BAFFLED BECAUSE HE COULD NOT DUPLICATE THE PROBLEM. *AK
Service brakes, Hydraulic, Sep 9, 2003, crash
I WAS INVOLVED IN AN MVA BACK IN 2002 BECAUSE OF TURN SIGNAL FAILURE. THE DEALERSHIP TOLD ME THAT A RECALL HAD BEEN MADE BUT NOBODY EVER NOTIFIED ME! ALSO MY WHEN DRIVING ON THE HIGHWAY MY VEHICLE STEERING WHEEL VIBRATES ESPECIALLY WHEN I APPLY THE BRAKES. I HAVE BEEN CLOSE TO LOOSING CONTROL OF MY VEHICLE ON TWO OCCASIONS WHEN THERE IS WATER ON THE ROADS. I REPLACED MY ROTORS TWICE! I BELEIVE THIS IS A SAFETY ISSUE THAT SHOULD BE LOOKED AT.AND ONE MORE THING MY AC CONTROL SWITCH KEEPS TURNING ON AND OFF THE COMPRESSOR I DONT BELIEVE THIS COULD BE GOOD FOR THE COMPRESSOR!. *AK
Fuel system, Gasoline, Sep 8, 2003
ENGINE STALLED 3 TIMES. DEALER FOUND A LEAK IN THE GAS TANK AND REPLACED IT. THE VEHICLE EXPERIENCED A CONDITION IN WHICH IT WOULD EITHER NOT START OR ONCE STARTED IT WOULD HESITATE OR STALL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY REPLACED THE FUEL TANK AND FUEL PUMP. THE VEHICLE CONTINUED TO EXPERIENCE PROBLEMS AND WAS RETURNED TO THE DEALER. THE DEALER COULD NOT FIND THE PROBLEM AND INDICATED THAT THE PROBLEM WAS PROBABLY FROM VANDALISM OR SOMETHING IN THE TANK. THESE CONDITIONS WERE NOT COVERED BY THE VEHICLE'S WARRANTY THEREFORE THE CONSUMER HAD TO PAY FOR THE ENTIRE SERVICE ASSESSMENT. A GM BULLETIN WAS LOCATED WHICH RECOMMENDED THAT THE TECHNICIAN REPLACE THE EXISTING FUEL SENDER STRAINER AS A POTENTIAL CAUSE OF THE ENGINE SYMPTOMS. *NLM
Exterior lighting, Sep 8, 2003
VEHICLE HAS THE SAME HAZARD WARNING SWITCH DEFECT AS STATED IN RECALL 03 V 327 000. THE MANUFACTURER'S NOTIFICATION IS DUE TO BEGIN IN 2004.*AK
Exterior lighting, Sep 8, 2003
HAZZARD LIGHTS AND TURN SIGNALS WORK INTERMINTENTLY BASED ON CLIMATE. *AK