2001 Chevrolet Malibu
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 739 owner complaints filed for this model year. This is the 13th highest complaint count among 26 Malibu model years with reports.
Of the 2001 reports, 37 involved a crash and 1 involved a fire. 29 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Exterior lighting, hazard flashing warning lights, switchAug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Campaign 03V327000 on NHTSA.gov
Representative owner complaints: exterior lighting
111 reports, newest first. Show all
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Electrical system, Exterior lighting, Latches/locks/linkages, Equipment, May 12, 2003
1) LEAKING COOLANT FROM INTAKE MANIFOLD INTO ENGINE, REQUIRED GASKET REPLACEMENT AND COOLANT / OIL CHANGE 2) TURN SIGNALS WORK INTERMITTENTLY, HAD TO REPLACE TURN SIGNAL SWITCH 3) A/C DOES NOT WORK, BLOWS HOT AIR, DEALER UNABLE TO REPAIR 4) BRAKES WEAK, VIBRATE. REPLACED WITH AFTER MARKET COMPONENTS (POWERSLOT ROTORS AND PERFORMANCE FRICTION CARBON METALLIC PADS) 5) AUTOMATIC DOOR LOCKS INOPERATIVE, DEALER UNABLE TO REPAIR 6) POOR FUEL MILEAGE, BEST IS 28 MPG HIGHWAY (CAFE VIOLATION??) 7) STARTER FAILED, REPLACED WITH REBUILT UNIT. *NLM
Exterior lighting, Feb 11, 2003
LEFT TURN SIGNAL STAYED ON CAUSING STOP LAMP ELECTRICAL WIRES TO BURN. CONSUMER HAD TO REPLACE FUSE BOX. *JB *TS
Exterior lighting, Oct 2, 2002
CONSUMER NOTICE TURN SIGNAL WOULD WORK INTIMATELY AFTER REPEATED USE. DEALER HAS BEEN CONTACTED. NLM
Exterior lighting, Sep 30, 2002
THE TURN SIGNALS FAIL ON VEHICLE. YOU WILL GO TO CHANGE LANES , THEY WILL BE WORKING THEN THEY STOP WORKING. I CONTACTED MILLER CHEVROLET WHO SAID THEY WERE UNAWARE OF ANY PROBLEMS. I THEN CONTACTED PHALEN CHEVROLET WHO STATED THERE HAVE BEEN MULTIPLE HAZARD SWITCH FAILURES CAUSING THIS PROBLEM BUT NO ONE KNEW WHY. THIS IS A VERY DANGEROUS CONDITION FOR A LOT OF CARS ON THE STREET TO HAVE , AND MAY BE A ITEM THAT SHOULD BE REPAIRED UNDER RECALL BEFORE THERE ARE SOME DEATHS. MR
Exterior lighting, Aug 13, 2002
TURN SIGNALS WORK INTERMITTENTLY. VEHICLE CHECKED BY DEALER, WHO COULD NOT FIND THE CAUSE.*AK
Exterior lighting, Jun 12, 2002
ALL TURN SIGNALS STOP WORKING INTERMITTENTLY. TO GET THEM TO WORK CONSUMER HAS TO TURN ON HAZARD LIGHTS 4-5 TIMES TO GET TURN SIGNALS TO COME ON. DEALER CANNOT DUPLICATE PROBLEM.*AK
Exterior lighting, May 28, 2002
FLASHER TURN SIGNALS WORK INTERMITTENTLY WHEN DRIVING. *AK *TT
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Exterior lighting, Mar 5, 2002
WHILE DRIVING, VEHICLE SHAKES ERRATICALLY. IT VIBRATES FROM INSIDE. ALSO, HAD NEW STRUTS PUT ON REAR. *AK CONSUMER STATED THAT DRIVER SIDE HEAD LAMP OUT OF ADJUSTMENT, FRONT BRAKE PADS MAKE NOISE, ENGINE MAKES TAPPING NOISE WHEN FIRST STARTING, THERE WAS A SHIMMY IN VEHICLE WHILE DRIVING DUE TO STRUTS LEAK. *YH
Engine and engine cooling, Exterior lighting, Visibility, Structure, Dec 26, 2001
TURN SIGNAL LIGHTS FAILED DURING NORMAL OPERATION. DEALERSHIP EXAMINED VEHICLE AND DETERMINED THAT HAZARD LIGHT SWITCH WAS THE CAUSE OF PROBLEM. *AK DEALER REPLACED HAZARD WARNING SWITCH. WEATHERSTRIP AROUND BOTH REAR SIDE WINDOWS DEFORMED, AS WELL AS BOTH DOOR PANELS, DEALER REPLACED WEATHERSTRIP AND DOOR PANELS, EXPERIENCING TICKING AND WHINNING NOISE FROM ENGINE, DEALER STATES THIS WAS NORMAL. *TT
Exterior lighting, Dec 6, 2001
TURN SINGALS WORK INTERMITTENTLY. AT TIMES, TURN SIGNALS GO COMPLETELY OUT.*AK
Exterior lighting, Oct 3, 2001
TURN SIGNALS WORK INTERMITTENLY. AT TIMES, TURN SIGNALS GO COMPLETELY OUT. CONTACTED DEALER, AND DEALER STATED IF TURN SIGNALS WORK IN SHOP THEY CAN'T FIX PROBLEM.*AK