2003 Chevrolet Malibu
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 611 owner complaints filed for this model year. This is the 16th highest complaint count among 26 Malibu model years with reports.
Of the 2003 reports, 37 involved a crash and 4 involved a fire. 26 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Vehicle speed control, accelerator pedalNov 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IN HOT AMBIENT CONDITIONS, THE ACCELERATOR PEDAL ARM MAY STICK AT THE ATTACHMENT TO THE BRACKET AND NOT RETURN TO THE ENGINE IDLE POSITION WHEN THE OPERATOR LIFTS HIS FOOT FROM THE ACCELERATOR PEDAL.
FAILURE TO RETURN TO IDLE COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE ACCELERATOR PEDAL ARM AND REPLACE THE ACCELERATOR AND BRAKE PEDAL ASSEMBLY WITH A NEW ASSEMBLY, IF NECESSARY. THE RECALL BEGAN ON DECEMBER 20, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Campaign 04V528000 on NHTSA.gov
Representative owner complaints: engine
91 reports, newest first. Show all
Electrical system, Engine, Fuel/propulsion system, Sep 15, 2023
Multiple times, the vehicle, while driving, electrically shuts down. security light comes on, sometimes, many attempts to restart will work. These shutdowns cause me to revet to manual bakes and steering.
Vehicle speed control, Engine, Aug 8, 2019
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHEN THE ENGINE WARMED UP AND THE RPMS REACHED THEIR MAXIMUM LEVEL, THE ACCELERATOR PEDAL AUTOMATICALLY DROPPED TO THE FLOORBOARD. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE THROTTLE BODY FAILED. THE VEHICLE WAS REPAIRED. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 9-5413563462. THE MANUFACTURER ALSO PROVIDED A $100 VOUCHER. THE FAILURE MILEAGE WAS 65,000.
Electronic stability control (ESC), Engine, Fuel/propulsion system, Sep 29, 2017
TOOK CAR TO WALMART ONE NIGHT AND BEGINS TO OVERHEAT AFTER NAPA TOLD ME IT HAD NO LEAKS. CAR OVERHEATS I PULL ASIDE AND TURN IT OFF FOR A BIT I NOTICED THE CAR WOULD CRANK BUT HESITATE TO START. ONCE GOT IT TO START IT WOULD ACCELERATE BUT AT LOW RPMS. CHECK ENGINE LIGHT WENT ON AND I NOTICED CAR SHAKING AND WEIRD NOISE COMING FROM THE ENGINE. ONCE STARTED CAR SQUEAKED AND MAD TERRIBLE NOISE. CAR DID NOT TURN BACK ON AND DID NOT MAKE IT HOME. CRANKS AND RARE WHEN STARTS, CHARGED BATTERY BUT DRAINS, DOESN'T MAINTAIN CHARGE. WHITE SMOKE COMING OUT OF EXHAUST AND WHEN CAR WOULD STALL IT WOULD TURN OFF, NOW THEFT SYSTEM LIGHT IS ON. NOW CAR WONT EVEN CRANK OR TURN ON. ONCE I GOT IT TO TURN ON WITH TROUBLE IT WOULD TURN OFF ONCE PUT INTO REVERSE OR DRIVE. TURNED OFF WHILE DRIVING IT ONE NIGHT AND BRAKES DID NOT WORK. ALMOST CRASHED INTO HOME, MY CAR WAS IN MOTION AND WOULD TURN OFF AMD STEERING WHEEL GOT HARD AND BRAKES DIDN'T WORK, SCARED TO DRIVE THE VEHICLE ENGINE MAKES WIERD BOGGING SOUND AMD SQUEAKING SOUND, SMELL OF GAS. EXHAUST HAS WHITE SMOKE COMING OUT OF IT. HAS TROUBLE IDLING AT TIMES AND LOW RPMS.
Steering, Electrical system, Engine, May 31, 2017
YESTERDAY I WAS DRIVING ON A STRAIGHT ROAD WITH A FEW TURNS IN A RURAL COMMUNITY. ALL OF A SUDDEN THE THEFT SYSTEM LIGHT STARTS FLASHING, MY SPEED DROPS BY FORCE, MY STEERING WHEEL TIGHTENS, AND THE ENGINE SHUTS OFF. THANKFULLY THE DRIVER BEHIND ME WAS NOT UP TO SPEED AS HE HAD JUST TURNED ONTO THE STREET AFTER ME. OTHERWISE, HE WOULD HAVE SLAMMED INTO THE BACK OF MY CAR. I PUT THE CAR IN PARK AND STARTED MY ROUTINE OF TRYING TO GET THE IGNITION TO TURN OVER. THIS PROCESS CALLS FOR ME TO PUT THE KEY IN THE IGNTION, TURN IT TO THE RIGHT, AND WAIT FOR THE BOARD TO LIGHT UP. ONCE IT IS LIT, THE CAR USUALLY STARTS AGAIN. THIS IS THE FIRST TIME THE ENGINE WAS SHUT DOWN WHEN THE THEFT LIGHT STARTS TO BLINK. IN THE PAST I HAVE HAD TROUBLE GETTING THE CAR TO START WHEN THE LIGHT COMES ON. I HAVE HAD SEVERAL IGNITION SWITCHES REPLACED AT THE SUGGESTION OF THEIR CHEVY TECHNICIANS BUT EACH SPRING/SUMMER I CONTINUE TO HAVE THIS COSTLY PROBLEM. THE MANAGERS AND TECHNICIANS SEEM TO THINK THAT THIS IS NOT A BIG ISSUE AND THAT I WILL NEED TO CONTINUE TO REPLACE THE IGNITION SWITCHES BECAUSE THE CAR THINKS THAT I AM STEALING MY OWN CAR. THE ONLY WAY FOR ME TO GET THE CAR TO START UP AGAIN IS TO PUT THE KEY IN THE IGNITION AND TURN IT TO THE RIGHT WITHOUT ACTUALLY STARTING THE CAR. AFTER 5-10 MINUTES THE ELECTRICAL BOARD LIGHTS UP AND THEN I AM ABLE TO START THE CAR. WHILE THIS CAR IS A 2003 MODEL, I HAVE HAD THIS ISSUE SINCE THE CAR WAS NEW BUT GM REFUSES TO DO ANYTHING ABOUT IT. THE ONLY THING THEY HAVE DONE IS TO REPLACE THE KEY FOBS BUT THAT OBVIOUSLY IS NOT THE ISSUE FOR MANY OF THEIR CUSTOMERS.
Engine, Mar 21, 2017
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE EXPERIENCED A LOSS OF ENGINE POWER THE FAILURE OCCURRED WITH NO WARNING. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 88,000. UPDATED 05/31/17*LJ *AS
Engine, Oct 6, 2016
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING 40 MPH, THE CHECK OIL WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE CAMSHAFT FAILED AND CAUSED SEVERE DAMAGE TO THE ENGINE. THE CONTACT WAS INFORMED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
Vehicle speed control, Engine, Jul 6, 2016
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING AT ANY SPEED, THE VEHICLE ACCELERATED UNCONTROLLABLY AND REQUIRED THE CONTACT TO EXERT EXTRA BRAKE FORCE TO STOP THE VEHICLE, INCLUDING THE ENGAGEMENT OF THE ABS. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 04V528000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 44,500.
Engine, May 2, 2016
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS UNABLE TO RESTART AND WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Electrical system, Engine, Feb 14, 2016
EHGINE DIES WHILE DRIVING ON THE STREETS MANY TIMES. HORN HONKS AFTER TURNING ON ENGINE AND NOT DRIVE FOR ABOUT 1 MINUTE. A/C AUTOMATICALLY SWITCHED FROM FRESH TO RECYCLE AIR BUTTONS
Electrical system, Engine, Feb 3, 2016
MY MALIBU WILL START ON ITS OWN AND RUN WITHOUT THE KEY. I HAVE FOUND IT RUNNING SEVERAL TIMES OR ATTEMPTING TO START WHEN THE DOORS ARE LOCKED AND THE KEYS ARE NO WHERE NEAR THE VEHICLE. THIS IS HAPPENING WHEN THE VEHICLE IS PARKED. AND THE HORN GOES OFF RANDOMLY AND NOW IS BURNED OUT.
Electrical system, Engine, Jan 13, 2016
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE WOULD FAIL TO START IN COLD INCLEMENT WEATHER. THE CONTACT STATED THAT THE VEHICLE WOULD ONLY START DURING TEMPERATURES HIGHER THAN 40 DEGREES. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC WHO REPLACED THE BATTERY, STARTER, ALTERNATOR, NEUTRAL SAFETY SWITCH, CRANK SHIFT SENSOR, AND THE EXHAUST SYSTEM; HOWEVER, THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE AIR CONDITIONING COMPRESSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 85,600.
Engine, Dec 15, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED TO START INTERMITTENTLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Steering, Vehicle speed control, Engine, Dec 5, 2015
MY SON WAS DRIVING THE 2003 CHEVROLET MALIBU ON THE HIGHWAY WHEN THE THEFT PROTECTION SYSTEM SUDDENLY KICKED IN AN SHUT OFF THE ENGINE CAUSING HIM TO LOSE SPEED AND POWER STEERING AND FORCING HIM TO STOP ON THE HIGHWAY. THEN HE HAD TO SIT THERE 10 MINUTES WITH THE KEY TURNED ON TO RESET THE THEFT SYSTEM BEFORE HE COULD START THE CAR AGAIN AND GET OUT OF A DANGEROUS SITUATION. THE IGNITION AND KEY WAS ALREADY READY REPLACED UNDER THE RECALL TOO.
Engine, Oct 19, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING 60 MPH, THE VEHICLE LOST POWER AND THE ANTI-THEFT WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 111,000.
Power train, Vehicle speed control, Engine, Oct 14, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE FAILED TO ACCELERATE AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. IN ADDITION, AFTER STOPPING THE VEHICLE, IT STALLED. THE VEHICLE WAS RESTARTED. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED AFTER THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBERS: 14V400000 (ELECTRICAL SYSTEM) AND 04V528000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT CYLINDER TWO WAS MISFIRING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 214,000.
Electrical system, Engine, Sep 14, 2015
ON JULY 20, 2015 COULD NOT ADJUST THE FRONT DRIVER SEAT. ALSO POWER WINDOWS IN THE BACK DRIVER WINDOW WOULD NOT ROLL DOWN OR UP. JULY 23, 2015 WHEN TO GET AN OIL CHANGE AT SEARS WHICH THEY DIDN'T PEFORM DUE TO THEY NEEDED DRIVE TIME TO APPROVE. CHECKED THE OIL IT WAS VERY LOW ADDED 1 QUART ON AUGUST 10 I WAS ON THE FREEWAY GOING SPEED LIMIT CAR STARTED REDUCING ITS SPEED HEARD A LOUD NOISE PULLED OVER COULDNOT DRIVE IT SO I HAD IT TOWED HOME NEXT DAY AIN HAD TO HAVE IT TOWED TO THE SHOP WHERE DRIVETIME TOLD ME TO TAKE IT THEY HAD IT FROM 8/11/2015-8/25/2015 ON AUG 26 THEY SO CALLED PUT A NEW ENGINE IT WAS ONLY 1 DAY LATER THE CHECK ENGINE LIGHT CAME ON AND IT OVERHEATED TOOK IT BACK TO THE SHOP AND THEY SAID IT NEEDED THE CAT CONVERTER REPLACED IN WHICH IT WAS NOT COVERED AT THAT TIME ON THE 28 IT WAS APPROVED BY THE TIME I WAS INFORMED DRIVE TIME HAD MY CAR REPO DUE TO NONPAYMENT I FEEL THAT I SHOULD NOT MAKE A PAYMENT UNTIL MY CAR WAS FIXED THE RIGHT WAY.
Engine, Sep 9, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STALLED. THE VEHICLE WOULD NOT RESTART. THE ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS RECOMMENDED TO TAKE THE VEHICLE TO A DEALER FOR DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.
Steering, Service brakes, Engine, Aug 12, 2015
THIS HAS HAPPENED FIVE TIMES NOW, I AM DRIVING AND THE ENGINE JUST SHUTS OFF, I CAN NOT BRAKE I CAN NOT STEER, I STILL HAVE LIGHTS ON THE DASHBOARD. IT HAPPENS WHEN I AM GONG ABOUT 20 TO ABOUT 35 MILES PER HOUR. I AM AFRAID TO DRIVE ON THE HIGHWAY. I DO NOT KNOW IF IT WILL HAPPEN AT A HIGHER SPEED! IT DID IT THE FIRST TIME BACK IN JUNE 2015 MY DAUGHTER WAS DRIVING, THEN AGAIN LAST FRIDAY AUGUST 7TH FOUR MORE TIMES WITH IN 10MINUTES AND A FEW MILES APART. IT IS LIKE SOMEONE JUST TURNED THE CAR OFF WHILE I AM DRIVING?
Engine, May 23, 2015
WHEN DRIVING MY CAR THE THE ENGINE SHUTOFF AND THE BRAKES FAILED.
Vehicle speed control, Engine, May 19, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 5 MPH, THE ACCELERATOR PEDAL BECAME STUCK WITHOUT WARNING. THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE RPMS FAILED TO DECREASE. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. WHILE THE VEHICLE WAS PARKED WITH THE ENGINE RUNNING, THE RPMS INCREASED WITHOUT WARNING. THE VEHICLE WAS TURNED OFF AND RESTARTED SEVERAL TIMES BEFORE THE RPMS RETURNED TO NORMAL. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.
Engine, May 13, 2015
WHILE DRIVING AT STOP INTERVALS I NOTICED THAT MY TEMP GUAGE WAS REACHING THE HOT MARK, I MADE IT HOME AND MY RESERVOIR WAS BOILING. THEN I NOTICE COOLANT LEAKING FROM THE MANIFOLD HOUSING. WHEN I HAD IT CHECKED OUT, I WAS TOLD THAT MY MANIFOLD GASKETS HAD TO BE REPLACED AT A COSTLY EXPENSE. UPON FURTHER INVESTIGATIONS I FOUND OUT THAT GM KNEW THAT THIS WAS A DEFAULT ISSUE AND ONLY SENT OUT RECALLS TO CERTAIN CUSTOMERS AND I WASN'T ONE OF THEM. I BELIEVE THAT GM SHOULD BE HELD ACCOUNTABLE AND MAKE THE PROPER RECALLS TO GET THIS MATTER SOLVED. ANY HELP WOULD BE GREATLY APPRECIATED SINCE I MISSED THE RECALL. I BELIEVE THAT THE RECALL IT WAS IN 2008, AND MY PROBLEM DIDN'T OCCUR UNTIL NOW.
Electrical system, Engine, Mar 4, 2015
THE CAR WAS BEING DRIVEN AND THE ENGINE SUDDENLY SHUT OFF. FORTUNATELY THE CAR WAS BEING DRIVEN THROUGH A PARKING LOT AT THE TIME RATHER THAN ON A ROADWAY. THIS EVENING THE CAR WOULDN'T START AT ALL. MY PERSONAL MECHANIC HAS ALREADY ADVISED THAT THERE IS AN IGNITION PROBLEM. HOWEVER NEITHER GM OR THE CHEVY DEALERSHIP WILL FIX THE ISSUE. THEY INSIST ON CHARGING FOR A SECOND DIAGNOSTIC EVEN THOUGH WE'VE ALREADY PD SOMEONE ELSE FOR A DIAGNOSIS. *TR
Steering, Service brakes, Engine, Feb 25, 2015
CAR WILL NOT START. SOLID "THEFT" LIGHT COMES ON DASHBOARD AND CAR WILL NOT TURN OVER, OR IF IT TURNS OVER, WILL CUT OUT SHORTLY AFTER. THIS ANTI-THEFT ISSUE CAUSES THE POWER STEERING AND BRAKES TO DISABLE, AND AM NOT ABLE TO TURN THE STEERING WHEEL. HAVE ALSO HAD CAR STALL OUT IN TRAFFIC AND LOSE ALL POWER. HAD TO HAVE CAR TOWED SEVERAL TIMES DUE TO THE ISSUE. I HAVE TRIED SEVERAL FIXES AND MECHANICAL REPAIRS, BUT THIS ISSUE CONTINUES TO GET WORSE. NO MATTER WHAT I TRY AND DO, AT RANDOM TIMES, MY CAR WILL NOT START, WHILE THE "THEFT" LIGHT COMES ON AND COMPLETELY DISABLES MY VEHICLE. AND SOMETIMES WHILE DRIVING, THE CAR JUST SHUTS OFF. I AM THE ORIGINAL OWNER OF THE VEHICLE, AND AM USING AN ORIGINAL KEY TO START THE CAR. I DO NOT HAVE ANY TYPE OF SECURITY SYSTEM INSTALLED IN MY CAR. THERE IS NO REASON FOR THE "THEFT" LIGHT TO COME ON WHEN I AM JUST TRYING TO START MY VEHICLE, NOT STEAL IT. THE IGNITION RECALL FOR MY SPECIFIC VEHICLE ONLY INVOLVES REPLACING THE KEYS, BUT THIS ANTI-THEFT ISSUE, WHICH I AND OTHER CHEVROLET MALIBU OWNERS ARE EXPERIENCING, IS A SERIOUS SAFETY ISSUE THAT COULD CAUSE A CRASH OR OTHER ACCIDENT TO OCCUR IF IT CAUSES THE CAR TO CUT OUT (LOSE POWER) FOR NO REASON WHILE DRIVING, AND AT THE SAME TIME DISABLING THE STEERING AND BRAKING SYSTEMS. THIS SHOULD DEFINITELY BE A SAFETY RECALL. *JS
Electrical system, Engine, Feb 6, 2015
TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE SERVICE ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE CONTACT MENTIONED THAT THE CRUISE CONTROL FUNCTIONED INTERMITTENTLY AS THE INSTRUMENT PANEL GAUGES AND SENSORS FLASHED SEVERAL TIMES. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 79,000.
Suspension, Engine, Jan 4, 2015
WE HAD TO HAVE THE INTAKE MANIFOLD REPLACED, AT 55,000 MILES, WHICH DIDN'T OCCUR UNTIL 2012, BECAUSE I DON'T PUT A LARGE AMOUNT OF MILES ON MY CAR ANNUALLY. I COULD NOT GET ANY MONEY FROM THE RECALL, BECAUSE THE CLASS ACTION SUIT PAYOUT ENDED IN 2008, AND I WAS NEVER MADE AWARE. BOTH THE FRONT AND REAR STRUTS ARE LEAKING FLUID. I WAS TOLD ALL FOUR NEED, REPLACEMENT, AND THE MOUNTS AS WELL. . THE MECHANICS SAID NORMALLY THESE SHOULDN'T NEED REPLACEMENT UNTIL 75,000-80,000 MILES MINIMUM, AND SHOULD HAVE LASTED UNTIL 100,000 WHICH IS NORMAL. I'M A GENTLE DRIVER WHO DOESN'T LEND MY CAR OUT. I DRIVE OVER SPEED BUMPS VERY SLOWLY IN OUR TOWN, BECAUSE I DIDN'T WANT SUSPENSION ISSUES. OUR TOWN'S SPEED LIMIT IS 15 MPH OVER THE SPEED BUMPS, AND I DO 7MPH OVER THEN. OTHERS WITH A 1999-2003 MALIBU, HAVE TOLD ME THEIR STRUTS HAVE WORN OUT JUST AS FAST ALSO.(AT 50,000 MILES OR SO). *TR