2004 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,697 owner complaints filed for this model year. This is the highest complaint count among 26 Malibu model years with reports.
Of the 2004 reports, 81 involved a crash and 15 involved a fire. 55 people were injured.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 19, 2004
SOME OF THESE PASSENGER VEHICLES HAVE AN ELECTRONIC CONTROL UNIT (ECU) THAT MAY CALCULATE A HIGHER THAN ACTUAL VEHICLE SPEED BECAUSE OF AN ERRATIC REAR-WHEEL SPEED SENSOR SIGNAL, AND CAUSE ABS ACTIVATION WHERE IT IS NOT NEEDED OR NEEDED ABS ACTIVATION TO BE EXTENDED DURING BRAKING AS THE VEHICLE SPEED DROPS TO ABOUT 3 MPH.
UNEXPECTED ABS ACTIVIATION COULD INCREASE STOPPING DISTANCE UP TO ABOUT 11 FEET DPENDING ON THE GRADE OF THE ROAD, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPROGRAM THE ABS CONTROLLER. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V190000 on NHTSA.gov
Seat belts, front, anchorageApr 16, 2004
ON CERTAIN PASSENGER VEHICLES, ANALYSIS OF AN A SIDE IMPACT CRASH TEST CONDUCTED BY THE NHTSA;S NEW CAR ASSESSMENT PROGRAM (NCAP) INDICATED THAT THE OUTBOARD ANCHORAGE OF THE DRIVER'S SEAT BELT COULD DISCONNECT BECAUSE OF CONTACT BETWEEN THE SEAT TRIM AND THE ANCHORAGE CONNECTOR WHEN THE SEAT WAS ADJUSTED TO ITS LOWEST POSITION.
IF THIS OCCURRED IN A CRASH, THE DRIVER COULD RECEIVE GREATER INJURIES.
DEALERS WILL INSERT A RETAINER ON BOTH THE DRIVER'S AND PASSENGER'S BELT ANCHORAGES. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V188000 on NHTSA.gov
Equipment, other, labelsFeb 24, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES THAT WERE NOT EQUIPPED WITH AN ADVANCED OCCUPANT RESTRAINT SYSTEM (AORS) HAVE DRIVER AND PASSENGER SIDE SUN VISORS WITH AORS LABELS. THE AORS LABELS DO NOT INCLUDE STATEMENTS AND THE ILLUSTRATION REQUIRED BY FMVSS NO. 208 FOR VEHICLES WITHOUT AORS.
OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V094000 on NHTSA.gov
Representative owner complaints: electrical system
247 reports, newest first. Show all
Steering, Electrical system, Exterior lighting, Oct 15, 2021
I was driving to work with my son and sister in the car when the steering wheel suddenly got very tight and started jerking when I attempted to make a left or right turn. I then stopped at a gas station and as soon as I came to a complete stop the vehicle shut off before I could turn it off manually. I then attempted to turn the key on and start the vehicle but it would not turn over, it would only make a clicking sound. I called a friend that was close by to come and assist me so when they arrived I asked them to jump my vehicle off via jumper cables which did get my vehicle's engine to finally start. The car sounded very weak as if it was going to shut off again once we disconnected the jumper cables but it didn't shut off. Nothing was working inside the car or outside meaning I had no radio, no interior lights and nothing on my dash was working. The speedometer wasn't working, the rims Guage wasn't working, the temp Guage wasn't working nor was anything else working on my dash. The turn signals were not working for either side and none of my headlights or taillights were working either. And I still did not safely have control of the steering. The only warning lamp, which didn't appear until my friend jumped my car off, was what looked like a symbol of a vehicle with a symbol of a locked lock in front of it. This failure just happened so I have not taken the car to a certified mechanic to inspect it but the car is available for inspection at any time. I can not afford to put my car in the shop, I work part time at a restaurant in my town and I'm also disabled and I also care for my 8 year old son who is severely autistic so I have no extra money to fix these problems. Please I need help.
Steering, Electrical system, Aug 21, 2021
The power steering went out while driving. The car was being backed out of the driveway. The car had lights go off when it happened. Once the car was restarted power steering worked again. This problem has only occurred once as far as known. The steering was incredibly hard to move when the issue occurred. It is foreseeable that if issue happens at the wrong time on the freeway it could lead to injury or death of driver, passenger, or others outside the vehicle. If it happens at high speeds during a turn any number of serous damage or injuries could occur. The vehicle was taken to a mechanic who said a dealership would have the equipment properly diagnose the problem. If the mechanic did it himself he would have to replace several parts one a time and it might not be fixed. I will have my son take it to a dealership to look at it. Lights went off during the problem, but it is UNKNOWN which ones lit up. The lights went off, but since significant force had to be used to pull the wheel even slightly the exact lights that went off are unknown.
Steering, Electrical system, Apr 23, 2021
THE SENSOR AND OR POWER STEERING ASSIST IS MALFUNCTIONING AND SENDING WARNING AND SHUTS DOWN THE ELECTRIC STEERING ASSIST. MUST TURN VEHICLE OFF AND THEN RESTART SEVERAL TO GET STEERING TO RELEASE. THERE WAS NO NOTICE GIVEN TO [XXX] WHEN THE RECALL(S) WERE ISSUED FOR 2004 CHVY MALIBU. STATIONARY THUS FAR. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Electrical system, Exterior lighting, Engine, Feb 5, 2021
WELL MY IGNITION SWITCH WENT OUT I REPLACE THAT.NOW IT'S SHORTAGES IN WIRING AND LIGHTS HEAT ON AN OFF SOMETIMES SHOCKS
Electrical system, Other or unspecified, Engine, Jan 11, 2021
AFTER STARTING ENGINE, ENGINE WILL TURN OFF AND RADIO DISPLAY SCREEN WILL READ 'ENGINE POWER REDUCED.' ENGINE WILL NOT START FOR SEVERAL MINUTES, BUT THE LIGHTS, RADIO, DASH LIGHTS AND EVERYTHING WILL STILL WORK. THIS HAS HAPPENED IN MY DRIVEWAY. THE FIRST TIME THIS EVER HAPPENED I WAS ON A BUSY MAIN ROAD AT A STOP LIGHT IN THE LEFT TURN LANE. THE CAR SHUDDERED AND THE ENGINE LOST POWER. AGAIN, THE DISPLAY SCREEN DISPLAYED THE SAME MESSAGE. THE CAR WAS ROLLING BACKWARDS AND WOULD NOT ACCELERATE. AFTER SEVERAL ATTEMPTS THE ENGINE DID START AGAIN. THANKFULLY IT WAS 6:00 AM AND I WAS ON MY WAY TO WORK SO THERE WAS VERY LIGHT TRAFFIC.
Steering, Suspension, Electrical system, Nov 16, 2020
ELECTRICAL WIRES/COMPONENTS ISSUES, INSTRUMENT CLUSTER LIGHTS NOT TURNING ON, VEHICLE WITH A WRENCH INDICATOR LIGHT COMES ON & OFF, TRACTION CONTROL WITH A SLASH ON TC INDICATOR LIGHT COMES ON & OFF (TC/), WHEN MY CAR IS RUNNING AN IDLING OR PARKED OR IDLING AT A STOP LIGHT OR DRIVING IN A CERTAIN SPEED LIMIT THE STEERING WHEEL SHACKS/SHUDDERS REPEATEDLY MOVING ON ITS OWN ONCE IN A AWHILE BUT NOW IT CONSTANTLY GETTING WORSE LASTING LONGER, ENGINE LIGHT STAYS ON EVEN AFTER I REPLACED THE PARTS OBDLL SCANNER SAY WHAT TO FIX & REPLACE, OWNED THE CAR OVER A 1 YEAR AN BUILD KNOWLEDGE ABOUT THE CAR AND GOOGLE RECALLS AFTER OWNING IT. I BELIEVE IT'S (POWER STEERING WHEEL COMPONENTS OR POWER STEERING WHEEL ASSIST MOTOR) I WAS DRIVING IN THE FREEWAY WITH MY BABIES GOING 65 SPEED LIMIT & I LITERALLY SEEN LIFE FLASHED BEFORE MY EYES WHEN THE STEERING WHEEL WON'T TURN/LOCKS UP IN A BUSY FREEWAY. IT WAS BEYOND THE WORSE EXPERIENCE OF MY LIFE BECAUSE MY BABIES IS IN THE CAR WHEN IT HAPPENED, I DON'T EVER WANT IT TO HAPPEN AGAIN EVER OR TO ANYONE ELSE. PLEASE & THANK YOU IF YOU CAN FIX IT, IT'S OUR ONLY TRANSPORTATION FOR MY SPOUSE & BABIES. AN ONE MORE OTHER THING IS "I DON'T KNOW IF IT'S A PART OF IT THE THROTTLE BODY MALFUNCTION". I HOPE THAT'S ENOUGH & ACCURATE INFORMATION ABOUT IT
Electrical system, Exterior lighting, Electronic stability control (ESC), Jul 8, 2020
HAD TO REPLACE HEAD LIGHT BULBS HAS MELTED PLASTIC COVER DASHBOARD HAS WARNING LIGHTS THAT COME ON AND STAY ON
Electrical system, Jun 3, 2020
THE ANTI THEFT GAS CUT OFF FEATURE HAS RENDERED MY VEHICLE UNABLE TO START. I HAVE TRIED MANY METHODS BUT THE PROBLEM PERSISTS. IT STARTS WHEN IT WANTS TOO, BUT NOT WHEN I DO. *TR
Steering, Electrical system, Jan 17, 2020
POWER STEERING FAILS UNDER HARD ACCELERATION. WHEN THIS OCCURS THE CHECK ENGINE LIGHT COME ON AND THE STEERING HAS NO ELECTRIC ASSIST. THIS CONTINUES UNTIL THE ACCELERATION IS REDUCED. AFTER REDUCED ACCELERATION THE CHECK ENGINE LIGHT GOES OFF THE THE POWER STEERING RETURNS TO NORMAL. THIS OCCURS INTERMITTENTLY, BUT TYPICALLY ON A FREEWAY ON RAMP WHILE GETTING UP TO SPEED AND TRYING TO MERGE WITH TRAFFIC.
Electrical system, Nov 22, 2019
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED INTERMITTENT FAILURE WITH THE IGNITION SWITCH. THE CONTACT HAD TO JIGGLE THE KEY FOR THE VEHICLE TO START. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN JIGGLED THE KEY AND THE VEHICLE WAS ABLE TO START. THE TECHNICIAN INFORMED THE CONTACT THAT THERE MAY BE AN UNKNOWN RECALL ON THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. *DT*JB
Electrical system, Apr 30, 2019
O2 SENSOR, ING FUSE KEEPS BLOWING CAUSING CAR NOT TO START
Steering, Electrical system, Electronic stability control (ESC), Apr 5, 2019
NO STEERING,STEERING TURNS AROUND AND AROUND WITHOUT STOP TURNING IN EITHER DIRECTION,RIGHT OR LEFT. SECOND TIME THIS HAPPENED,SPENT APPROXIMATELY $1200.00 BEFORE. CAR THIS TIME ENDED IN A TOW POUND YARD. TRIPLE AAA MOVED MY CAR TO A SHOP CALLED QUICK STOP WHERE I WANTED TO GET MY CAR FIXED AT ONLY TO DISCOVER THEY DIDN'T DO ELECTRICAL WORK WHICH THEY DISCOVERED WAS THE PROBLEM AMONG OTHERS. AGAIN THE TOWING COMPANY TRIPLE AAA CARRIED IT TO WEBB CHEVROLET SUGGESTED BY THIS SHOP. WEBB CHEVROLET DISCOVERED ALSO ELECTRICAL ISSUES. MY INSURANCE NOTIFIED ME AFTER I CONTACT THEM FOR A CLAIM REPORT. AN ESTIMATOR WAS SENT TO WEBB CHEVROLET ALSO THEY DISCOVERED AFTER A TEAR DOWN DIAGNOSIS THAT IT IS A RECALL ISSUES. NOW YOU ARE BEING NOTIFIED BY ME,RUBY WELLS OF THESE PROBLEMS. THIS IS WHY IM NOTIFYING YOU OF THE RECALLS FOUND ON THIS MAKE,MODEL AND YEAR 2004 VEHICLE. NOT STATIONARY,IT WAS IN MOTION WHEN HAPPENED ON CITY STREET. MY SON WAS ARRESTED FOR NO REASON $2000 BAIL TIMES 2 . COURT JUDGE THROUGH CASE OUT ON APRIL 45TH 2019 AFTER DISCOVERING BOGUS TICKETS WRITING AND ARRESTS THEY INDICATED THERE WAS NO INSURANCE ON VEHICLE AND HAD MY CAR TOWED TO POUND WITHIN HOURS. I HAD TO PAD TOWING FEES OF $1200 APPROXIMATELY TO GET MY CAR FROM POUND LESS THAN24 HOURS OF THE TOWING. MONEY HAS ALREADY BEEN SPENT UNNECESSARILY MONEY I HAD TO BORROW BECAUSE I'M RETIRED. PLEASE TAKE CARE OF THIS FOR ME ASAP. PLEASE!
Electrical system, Exterior lighting, Air bags, Dec 19, 2018
TAKATA RECALL. MY RADIO STARTED DISPLAYING A SERVICE AIR BAG MESSAGE AND MY HORN STOPPED WORKING. THE WIRING IN THE CAR HAS STOPPED WORKING. I BEGAN TO REPLACE LIGHTBULBS THINKING THEY WERE BLOWN BUT JUST WILL NOT WORK. HEARD THIS CAR WAS RECALLED FOR THESE EXACT PROBLEMS I AM HAVING BUT FOR SOME REASON MY CAR HAS NO RECALLS. MY STEERING WHEEL MAKES A KNOCKING NOISE WHEN TURNING VERY SHARP. SOUNDS LIKE A PIECE IS BROKEN KNOCKING AROUND
Suspension, Electrical system, Fuel/propulsion system, Oct 19, 2018
TAKATA INFLATORS PLEASE FIX MY CAR I WENT TO THE LOCAL AUTO PARTS STORE AND THEY CHECKED THE SYSTEM FOR ME AND ALL THESE PROBLEMS PLUS MORE HAVE POPPED UP AND THEY'RE ALL ON THE RECALL LIST
Electrical system, Jul 23, 2018
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE CONTACT HAD TO LEAVE THE KEY IN THE "ON" POSITION FOR APPROXIMATELY TEN MINUTES BEFORE ATTEMPTING TO START THE VEHICLE. THE CONTACT STATED THAT THE FAILURE OCCURRED TWICE AND THE THEFT WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.
Electrical system, Jul 18, 2018
MY THEFT SYSTEM WARNING LIGHT KEEPS COMING ON. WHEN I TURN THE KEY OFF AND TRY TO RESTART THE CAR IT WILL NOT START BACK. I HAVE TO TURN IT TO THE ON POSITION AND WAIT UNTIL THE THEFT LIGHT QUITS FLASHING WHICH IS USUALLY 10 MINUTES AND THEN RESTART THE CAR. I WAS TOLD BY A CHEVROLET DEALERSHIP MECHANIC THAT THE PROBLEM WAS THE IGNITION CYLINDER WHICH COST AROUND $180. WHY IS THERE NOT A RECALL FOR THIS.
Electrical system, Jun 15, 2018
I TURN MY KEY YO TURN OFF MY CAR IN IT WANT GO PASS THE ACC.
Electrical system, Apr 2, 2018
2004 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO IGNITION KEY FAILURE TO RE-START VEHICLE, TOWED TO DEALERSHIP FOR FAULTY IGNITION SWITCH REPAIRS AND CONSUMER SEEKS REIMBURSEMENT FOR RECALL REPAIRS. *SMD *TR
Electrical system, Other or unspecified, Jan 10, 2018
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHEN THE CONTACT REACHED HIS DESTINATION, THE VEHICLE WAS PLACED IN PARK AND ATTEMPTED TO REMOVE THE KEY FROM THE IGNITION, BUT WAS UNSUCCESSFUL. THE CONTACT HAD TO MOVE THE KEY IN AN UP AND DOWN, SIDE TO SIDE MOTION FOR SEVERAL MINUTES IN ORDER TO REMOVE IT FROM THE IGNITION. THE IGNITION FAILURE OCCURRED SEVERAL TIMES SINCE JUNE OF 2017. THE CONTACT PURCHASED A NEW KEY, WHICH WORKED FOR A FEW MONTHS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT AUTO MECHANIC AND WAS INFORMED THAT THE FAILURE WOULD HAVE TO BE REPAIRED AT THE CHEVROLET DEALER BECAUSE SPECIFIC TOOLS NEEDED TO BE USED. THE FAILURE WAS NOT REPAIRED. THE MANUFACTURER AND DEALER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 100,000.
Steering, Electrical system, Vehicle speed control, Aug 7, 2017
POWER STEERING REPEATEDLY GOES OUT WHILE DRIVING. BLINKERS ONLY WORK SOMETIMES. CRUISE CONTROL DOES NOT ENGAGE. I LOST POWER STEERING GOING DOWN A BUSY HIGHWAY.
Steering, Electrical system, Jul 27, 2017
I TOOK MY 2004 MALIBU MAX CHEVY TO.RAY CHEVROLET IN ANTIOCH ILLINOIS.WE GOT RECALLS ON THE STEERING THEY TOLD US THEY DIDN'T HAVE THE PART .THEY TOLD US THEY WOULD LET US KNOW WHEN THE PART CAME IN .ITS BEEN A YEAR.ITS REALLY DANGEROUS DRIVING IS WAY.THE STEERING WENT OUT A COUPLE OF TIMES.I NEED HELP.
Electrical system, Jul 12, 2017
DUE TO THE PASSLOCK SENSOR INSIDE THE IGNITION LOCK CYLINDER CASE FAILURE, THE VEHICLE WILL STALL AT ANY MOMENT AND ANYWHERE, WHICH MAKES MORE LIKELY TO BE INVOLVED IN A WRECK BECAUSE OF THIS. GM STATED THAT THE PROBLEM WITH THE VEHICLE STALLING WAS DUE TO THE KEY COMING OUT FROM THE IGNITION CYLINDER. GM ADDED WEIGHT TO THE PLASTIC PORTION OF THE KEY AS A SOLUTION TO THE PROBLEM BUT THE REAL PROBLEM FOR THE VEHICLE TO STALL IS NOT THAT, IT IS DUE TO THE FAILURE OF THE PASSLOCK SENSOR.
Steering, Power train, Electrical system, Jun 21, 2017
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE VEHICLE REMAINED ON AFTER THE KEY WAS REMOVED FROM THE IGNITION, THE TRANSMISSION SLIPPED OUT OF GEAR, AND THERE WAS AN ABNORMAL NOISE COMING FROM THE STEERING COLUMN. THE FAILURES OCCURRED WITHOUT WARNING. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 51,000.
Steering, Electrical system, Engine, May 10, 2017
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING 60 MPH, THE CHECK ENGINE AND POWER STEERING WARNING INDICATORS ILLUMINATED. THE STEERING WHEEL REQUIRED EXCESSIVE FORCE IN ORDER TO MAKE A TURN. WHEN THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE, IT RESUMED NORMAL OPERATION. THE FAILURE RECURRED SEVERAL OTHER TIMES. THE CONTACT ALSO STATED THAT THE BRAKE LIGHTS FAILED TO WORK. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE RECALLS WERE EXPIRED. THE VEHICLE WAS TAKEN TO ANOTHER DEALER WHERE THEY ESTIMATED THAT THE DIAGNOSTIC CHECK WOULD COST $114. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 166,000.
Steering, Suspension, Fuel system, Gasoline, Power train, Electrical system, Vehicle speed control, Seats, Electronic stability control (ESC), Jan 3, 2017
"TAKATA RECALL" MY 2004 MALIBU DOES NOT HAVE WORKING CRUISE CONTROL , MY WIRING IS BARELY WORKING AS IN MY LOCKS WON'T WORK , MY HEAT WE ONLY BLOWS COLD AIR ON DEFROST MY DEFROST BARELY CLEARS MY WINDOWS , MY T\C LIGHT IS THE ONLY LIGHT THAT STAYS ON ALL THE TIME AND I BARELY HAVE TRACTION WHILE DRIVING IF I'M TRYING TO ACCELERATE GETTING ON THE HIGHWAY MY WHEEL WILL LOCK OR BARELY MOVE AND I HAVE TO LET COMPLETELY OFF THE GAS TO FREE THE WHEEL I GET ANY ALERTS ON MY SPEEDOMETER. *TR