2004 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,697 owner complaints filed for this model year. This is the highest complaint count among 26 Malibu model years with reports.
Of the 2004 reports, 81 involved a crash and 15 involved a fire. 55 people were injured.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 19, 2004
SOME OF THESE PASSENGER VEHICLES HAVE AN ELECTRONIC CONTROL UNIT (ECU) THAT MAY CALCULATE A HIGHER THAN ACTUAL VEHICLE SPEED BECAUSE OF AN ERRATIC REAR-WHEEL SPEED SENSOR SIGNAL, AND CAUSE ABS ACTIVATION WHERE IT IS NOT NEEDED OR NEEDED ABS ACTIVATION TO BE EXTENDED DURING BRAKING AS THE VEHICLE SPEED DROPS TO ABOUT 3 MPH.
UNEXPECTED ABS ACTIVIATION COULD INCREASE STOPPING DISTANCE UP TO ABOUT 11 FEET DPENDING ON THE GRADE OF THE ROAD, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPROGRAM THE ABS CONTROLLER. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V190000 on NHTSA.gov
Seat belts, front, anchorageApr 16, 2004
ON CERTAIN PASSENGER VEHICLES, ANALYSIS OF AN A SIDE IMPACT CRASH TEST CONDUCTED BY THE NHTSA;S NEW CAR ASSESSMENT PROGRAM (NCAP) INDICATED THAT THE OUTBOARD ANCHORAGE OF THE DRIVER'S SEAT BELT COULD DISCONNECT BECAUSE OF CONTACT BETWEEN THE SEAT TRIM AND THE ANCHORAGE CONNECTOR WHEN THE SEAT WAS ADJUSTED TO ITS LOWEST POSITION.
IF THIS OCCURRED IN A CRASH, THE DRIVER COULD RECEIVE GREATER INJURIES.
DEALERS WILL INSERT A RETAINER ON BOTH THE DRIVER'S AND PASSENGER'S BELT ANCHORAGES. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V188000 on NHTSA.gov
Equipment, other, labelsFeb 24, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES THAT WERE NOT EQUIPPED WITH AN ADVANCED OCCUPANT RESTRAINT SYSTEM (AORS) HAVE DRIVER AND PASSENGER SIDE SUN VISORS WITH AORS LABELS. THE AORS LABELS DO NOT INCLUDE STATEMENTS AND THE ILLUSTRATION REQUIRED BY FMVSS NO. 208 FOR VEHICLES WITHOUT AORS.
OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V094000 on NHTSA.gov
Representative owner complaints: power train
89 reports, newest first. Show all
Power train, Jun 17, 2020
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT WHILE MAKING A LEFT TURN THE VEHICLE SHIFTED INTO NEUTRAL INDEPENDENTLY WITHOUT WARNING. THE CONTACT DEPRESSED THE BRAKE PEDAL TO STOP THE VEHICLE. THE CONTACT ATTEMPTED TO MANUALLY SHIFT THE VEHICLE INTO PARK HOWEVER, THE TRANSMISSION FAILED TO ENGAGE. THE CONTACT PUSHED THE VEHICLE OVER TO THE SIDE OF THE ROADWAY. THE VEHICLE WAS TOWED TO MIDWAY CHEVROLET (2323 W BELL RD, PHOENIX, AZ) WHERE IT WAS DIAGNOSED AND DETERMINED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN) AS A POSSIBLE SOLUTION TO THE FAILURE, HOWEVER THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS CONTACTED HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Steering, Power train, Feb 24, 2020
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE STEERING WHEEL INDEPENDENTLY TURNED TO THE LEFT WITHOUT WARNING. THE VEHICLE WAS TURNED OFF AND BACK ON BUT FAILED TO FIX THE ISSUE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE RACK AND PINION DETACHED FROM THE SUBFRAME AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT ONLY THE BUSHING WAS REPLACED AND NOT THE RACK AND PINION. IN ADDITION, THE CONTACT STATED ON ANOTHER OCCASION THE VEHICLE FAILED TO SHIFT TO REVERSE OR GO INTO FORWARD GEAR WHILE IN THE MIDDLE OF THE ROAD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE SHIFT CABLE WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 157,000.
Power train, Jul 11, 2019
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE THE CONTACT'S SON WAS PARKING THE VEHICLE, HE WAS UNABLE TO SHIFT THE GEAR OUT OF REVERSE AND TURN OFF THE ENGINE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. AN INDEPENDENT MECHANIC ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 218,381.
Steering, Power train, Other or unspecified, Apr 8, 2019
FIRST STEERING WHEEL TURNED ALL THE WAY AROUND AND SECONDLY THEN CAR NOR GOING BACKWARD AND FORWARD DID NOT MOVE
Power train, Engine, Jan 15, 2019
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE GEAR SHIFTER FAILED TO MOVE INTO GEAR WHEN ATTEMPTING TO DRIVE OR REVERSE. ALSO, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT CALLED TRACY CHEVROLET AT (209) 835-4500 (LOCATED AT 3400 AUTO PLAZA WAY, TRACY, CA 95304) AND WAS INFORMED TO SCHEDULE AN APPOINTMENT. THE VEHICLE WAS NOT TAKEN TO THE DEALER DUE TO THE DIAGNOSTIC AND REPAIR FEES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT TO TAKE THE VEHICLE TO A DEALER. NO FURTHER ASSISTANCE WAS OFFERED. THE APPROXIMATE FAILURE MILEAGE WAS 295,000.
Power train, Aug 21, 2018
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. AFTER REVERSING AND ATTEMPTING TO PLACE THE VEHICLE IN PARK, THE TRANSMISSION GEAR SELECTION DID NOT MATCH THE INDICATED GEAR. THE VEHICLE WAS TAKEN TO AN UNKNOWN LOCAL DEALER WHERE IT WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT STATED THAT THE GEAR SHIFTER STILL FAILED AFTER THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 129,000.
Steering, Power train, Other or unspecified, Aug 1, 2018
I RECEIVED AN EMAIL THIS MORNING 8/1/2018 STATING MY CAR MAY HAVE RECALLS ON IT. WHEN I CLICK THE LINK, I SEE THERE ARE 10 RECALLS ON THE 2004 CHEVY MALIBU. 10! OUT OF THOSE 10, I RECEIVED A NOTICE FOR ONLY TWO! I RECEIVED A NOTICE ABOUT MY POWER STEERING WHICH CAME AFTER MY WHEEL LOCKED UP ON MY WHILE I WAS DRIVING ON THE HIGHWAY! I CHECK THE LIST TODAY, AND MY CAR HAS HAD SEVERAL ISSUE THAT WERE LISTED: IGNITION, TRANSMISSION, BRAKES, ETC. I WAS NEVER NOTIFIED ABOUT THESE ISSUES. THESE NOTICES HAVE BEEN OUT SINCE 2014 AND I NEVER RECEIVED A NOTICE ABOUT THEM.
Steering, Power train, Electrical system, Jun 21, 2017
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE VEHICLE REMAINED ON AFTER THE KEY WAS REMOVED FROM THE IGNITION, THE TRANSMISSION SLIPPED OUT OF GEAR, AND THERE WAS AN ABNORMAL NOISE COMING FROM THE STEERING COLUMN. THE FAILURES OCCURRED WITHOUT WARNING. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 51,000.
Power train, May 10, 2017
I TURN MY CAR ON DRIVE GO TO GET OUT THE KEY WON'T COME OUT SOMETIMES IT DOES AND MOST TIME IS DOESN'T. I TRY TURN THE CAR BACK ON PUTTING THE CAR IN DRIVE THEN PARK AND TURNING THE KEY TO OFF POSITION AND THE CAR STILL DOESN'T GO INTO THE PARK POSITION SO THE KEY DOESN'T GO INTO OFF POSITION TO TAKE KEY OUT. THE CAR STAYS ON WITHOUT THE IGNITION BEING ON. THE CAR IS STATIONARY BUT THE CAR WON'T GO INTO PARK TO TURN THE CAR COMPLETELY OFF. SPOKE TO GM PROBLEM WITH TRANSMISSION SHIFT CABLE BUT THEY WON'T HELP ME. THE KEEP SAYING THERE IS NO RECALL FOR MY CAR. THERE WAS A RECALL FOR THIS GM'S RECALL 14152. PLEASE HELP. THANK YOU!
Power train, Vehicle speed control, Engine, Apr 25, 2017
THE VEHICLE CONTINUALLY GOES INTO "ENGINE LOW POWER MODE" WHILE ON THE HIGHWAYS. THIS IS NOW OCCURRING DAILY. I'VE TRIED TO GET IT FIXED BUT NO ONE SEEMS TO KNOW WHAT IT IS. I AM VERY FORTUNATE THAT NO ONE HAS HIT ME WHEN THE VEHICLE GOES FROM HIGH SPEEDS DOWN TO 20 MILES PER HOUR WITH NO RESPONSE BY PRESSING THE GAS PEDAL. THERE HAVE BEEN MULTIPLE THINGS FAILING ON THIS CAR: PASSENGER SIDE WINDOW NO LONGER OPENS, CRUISE CONTROL WILL NOT WORK, 2 OF THE 3 CHARGERS IN THE CAR DO NOT WORK (AFTER FIXING THOSE FUSES, THEY JUST BLEW IMMEDIATELY) POWER LOCKS WENT FROM BARELY WORKING TO NOT WORKING AT ALL, THE LATEST BEING THE LOW POWER MODE AND TRACTION CONTROL BEING ACTIVATED IN THE HEAT OF A TENNESSEE SPRING (ALREADY 80 DEGREES) - IT'S NOT A WATER ISSUE. THE FIRST FEW MONTHS I HAD THIS CAR IT WAS IN THE SHOP ALMOST EVERY WEEKEND. I'VE GOTTEN ALL THE RECALLS FIXED WHEN THEY REQUIRED IT AND I KEEP UP WITH MAINTENANCE ON THIS CAR. IT HAS THE USUAL BREAK DOWNS BUT THIS IS THE LEAST SAFE CAR I HAVE EVER DRIVEN (AND I HAVE DRIVEN AROUND TWENTY LONG TERM, TEN MORE SHORT TERM).
Steering, Suspension, Fuel system, Gasoline, Power train, Electrical system, Vehicle speed control, Seats, Electronic stability control (ESC), Jan 3, 2017
"TAKATA RECALL" MY 2004 MALIBU DOES NOT HAVE WORKING CRUISE CONTROL , MY WIRING IS BARELY WORKING AS IN MY LOCKS WON'T WORK , MY HEAT WE ONLY BLOWS COLD AIR ON DEFROST MY DEFROST BARELY CLEARS MY WINDOWS , MY T\C LIGHT IS THE ONLY LIGHT THAT STAYS ON ALL THE TIME AND I BARELY HAVE TRACTION WHILE DRIVING IF I'M TRYING TO ACCELERATE GETTING ON THE HIGHWAY MY WHEEL WILL LOCK OR BARELY MOVE AND I HAVE TO LET COMPLETELY OFF THE GAS TO FREE THE WHEEL I GET ANY ALERTS ON MY SPEEDOMETER. *TR
Steering, Power train, Air bags, Nov 21, 2016
INFLATED.
Power train, Aug 26, 2016
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. PRIOR TO THE CONTACT OWNING THE VEHICLE, THE DEALER INDICATED THAT A RECALL REPAIR WAS COMPLETED FOR THE TRANSMISSION SHIFT CABLE. UPON DRIVING THE VEHICLE, THE GEAR FAILED TO PROPERLY SHIFT INTO PARK AND OTHER GEARS. AS A RESULT, THE CONTACT COULD ONLY SHIFT INTO THE DRIVE LOW GEAR AT AN EXTREMELY LOW RATE OF SPEED. THE DEALER REPLACED THE TRANSMISSION SHIFT CABLE TWICE AFTER THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
Power train, Feb 12, 2016
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE GEAR LEVER FAILED TO SHIFT FROM REVERSE INTO DRIVE. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SHIFT CABLE FRACTURED. IN 2015, THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN); HOWEVER, THERE WAS NO FAILURE. RECENTLY, A FAILURE OCCURRED AND THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 173,000.
Power train, Air bags, Dec 30, 2015, crash
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 15 MPH, THE TRANSMISSION SHIFT CABLE FAILED. AS A RESULT, THE CONTACT LOST BRAKING AND STEERING FUNCTIONS. THE FAILURE RESULTED IN A FRONT END COLLISION. THE AIR BAGS DID NOT DEPLOY. PRIOR TO THIS FAILURE, THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN). A POLICE REPORT WAS FILED. THERE WERE NO INJURIES SUSTAINED THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED BUT IT WAS UNKNOWN IF IT WAS DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 315,000.
Steering, Power train, Wheels, Dec 27, 2015
AIRBAG LIGHT CONTINUES TO COME ON. I'VE HAD THIS CAR SINCE 1/31/2014.USED. NO ACCIDENTS. POWER STEERING WENT OUT. TOOK TO GMC FOR RECALL. 2/2014 CLAIMED IT WAS FIXED. 11/2014 STEERING WHEEL HARD TO TURN..NOW THE TIRES WON'T TURN TO THE RIGHT. LOUD CLONKING NOISE WHEN I TURN THE STEERING. TIRES WON'T TURN..NEAR ACCIDENT. HAD CAR SINCE 1/2014 .TOOK FOR RECALLS 2/2014 7/2014 TRANSMISSION DIED. 1000+ IN REPAIRS. THIS CAR IS A SAFETY HAZARD AND I AM STILL PAYING FOR THIS CAR. SOMETHING NEEDS TO BE DONE SO THAT I DON'T HAVE TO CONTINUE TO COME OUT OF POCKET AND WASTE MY MONEY.
Power train, Dec 7, 2015
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT MENTIONED THAT WHEN THE GEAR SHIFTER STICK WAS CHANGED FROM PARK TO DRIVE AND WHILE DRIVING AT VARIOUS SPEEDS OR COMING TO A STOP, THE VEHICLE JERKED. IN ADDITION, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 144,067. UPDATED 02/05/16*LJ; UPDATED 05/04/18*JB
Power train, Sep 3, 2015
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE REVERSING AT 5 MPH, THE VEHICLE FAILED TO SHIFT GEARS. THE CONTACT STATED THAT THE EMERGENCY BRAKE HAD TO BE APPLIED IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND WAS INFORMED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER A MANUFACTURER RECALL RELATED TO THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 161,000.
Power train, Jun 18, 2015
WHILE DRIVING MY CAR THROUGH AN INTERSECTION, THE TRANSMISSION COMPLETELY GAVE OUT AND I LOST ALL POWER TO THE ENGINE AND HAD TO SWERVE. HAVING SUDDENLY LOST ALL POWER TO THE ENGINE I MANEUVERED TO THE SIDE OF THE ROAD AND NARROWLY AVOIDED A COLLISION. THE CAR IS PERFECTLY MAINTAINED AND THE SERVICE REPRESENTATIVES AT THE CHEVROLET DEALERSHIP (BUNNIN CHEVY) CONCLUDED THIS WAS A MANUFACTURER ERROR.
Power train, Jun 15, 2015
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE WENT INTO REVERSE INSTEAD OF NEUTRAL AND THERE WAS A LOUD GRINDING NOISE. THE CONTACT MERGED TO THE SIDE OF THE ROAD, WHERE THE TRANSITION FAILED. THE FAILURE RECURRED ONCE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 167,000.
Power train, Electrical system, May 27, 2015
2004 CHEVROLET MALIBU MAXX. CONSUMER WRITES IN REGARDS TO TRANSMISSION SHIFT CABLE RECALL NOTICE AND IGNITION KEY ISSUES. *SMD THE CONSUMER STATED THE DEALER WAS SUPPOSED TO FIX THE CABLE THAT CHANGED THE GEARS AND TO GET THE KEY OUT OF THE IGNITION. WHEN SHE PICKED UP THE VEHICLE, SHE ONLY HAD ONE LOW GEAR, BUT THERE WAS SUPPOSSED TO BE THREE LOW HEARS AND THE KEY WAS STILL STUCK IN THE IGNITION. *JB
Power train, Electrical system, Seats, May 17, 2015
REPORTING MULTIPLE ISSUES. INCREASED PROBLEMS AFTER RECALL WORK PERFORMED..ITEMS 2 AND 3. ITEM 1 FROM THE ORIGINAL PURCHASE AND NO GM SOLUTION ON WHAT HAS BEEN A WIDE SPREAD PART QUALITY PROBLEM DOCUMENTED. DRIVERS SIDE SEAT EARLY ON FROM PURCHASE DEALER WELDED BREAK ONCE. BROKE AGAIN DRIVING WITH BROKEN SEAT NOW LEG NERVE BACK PROBLEMS. CONCERN ON SAFETY IF IN ACCIDENT A..NO RECALL WHY NO OPTION TO GET REPLACEMENT PARTS OR SEAT WHY????? WHILE DRIVING VEHICLE POWER STEERING WENT OUT REDUCED ACCELERATION DASHBOARD VARYING LIGHTS RANDOM VARIES OFF AND ON ABLE TO COAST OUT OF TRAFFIC. NO ABILITY TO RESTART. TOWED DEALER INDICATED NEED TO REPLACE GENERATOR AND BATTERY BOTH PERFORMED VEHICLE DRAINS UNABLE TO START JUMP START RUNS FAILS AGAIN LATER - NO SOLUTION PROBLEM STARTED AFTER DEALERSHIP RECALL WORK DONE ON IGNITION SWITCH RELATED TO RECALL WORK???? SITTING IN DRIVEWAY - DO WE TOW BACK TO DEALERSHIP THAT HAD US REPLACE THE GENERATOR AS AN UNNECESSARY EXPENSE??? SELECTOR MALFUNCTION NOT WORKING SERVICED NOW NO ABILITY TO USE LOW GEAR SELECTION PUSH BUTTON. STAYS ON 3 WHY AGAIN RELATED TO RECALL WORK PERFORMED??? SOME SENSATIONS OF SLIPPAGE BETWEEN GEARS AS WELL. WHY?? LIKE THE VEHICLE AND WANT IT TO BE SAFE TO DRIVE AND KEEP IN SERVICE. LOYAL GM FAMILY MEMBER THAT IS CONSIDERING CHANGING MANUFACTURERS. SATURN OWNER - NO LONGER AVAILABLE PONTIAC OWNER GRAND AM NO LONER AVAILABLE PONTIAC VIBE OWNER CHEVROLET BLAZER OWNER CHEVROLET CAMERO. CHEVROLET IMPALA OUR FAMILY LIST GOES ON. MORE DIFFICULT TO KEEP THE FAMILY LOYAL DROP DOWN BOX ON VEHICLE NEVER DISPLAYED.
Power train, Apr 29, 2015
2004 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO TRANSMISSION RECALL NOTICE. *SMD THE PARTS WERE NOT AVAILABLE *JB
Power train, Apr 5, 2015
VEHICLE IS UNABLE TO SMOOTHLY SHIFT INTO PARK POSITION TO ALLOW THE KEY TO BE TURNED OFF. CERTIFIED MECHANIC STATED THE SHIFTER CABLE IS MOST LIKELY THE DEFECT. MANY MODELS HAVE ALREADY BEEN RECALLED. THE CAR IN NOT ABLE TO SHIFT INTO PARK TO ALLOW TURNING OF THE KEY IGNITION SWITCH TO THE OFF POSITION SO THAT THE CAR BATTERY TURNS OFF. SIFTER CABLE COULD POSSIBLY MALFUNCTION DURING NORMAL DRIVING/OPERATION, STARTING/STOPPING. *TR
Power train, Mar 13, 2015
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN) HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.