2004 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,697 owner complaints filed for this model year. This is the highest complaint count among 26 Malibu model years with reports.
Of the 2004 reports, 81 involved a crash and 15 involved a fire. 55 people were injured.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 19, 2004
SOME OF THESE PASSENGER VEHICLES HAVE AN ELECTRONIC CONTROL UNIT (ECU) THAT MAY CALCULATE A HIGHER THAN ACTUAL VEHICLE SPEED BECAUSE OF AN ERRATIC REAR-WHEEL SPEED SENSOR SIGNAL, AND CAUSE ABS ACTIVATION WHERE IT IS NOT NEEDED OR NEEDED ABS ACTIVATION TO BE EXTENDED DURING BRAKING AS THE VEHICLE SPEED DROPS TO ABOUT 3 MPH.
UNEXPECTED ABS ACTIVIATION COULD INCREASE STOPPING DISTANCE UP TO ABOUT 11 FEET DPENDING ON THE GRADE OF THE ROAD, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPROGRAM THE ABS CONTROLLER. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V190000 on NHTSA.gov
Seat belts, front, anchorageApr 16, 2004
ON CERTAIN PASSENGER VEHICLES, ANALYSIS OF AN A SIDE IMPACT CRASH TEST CONDUCTED BY THE NHTSA;S NEW CAR ASSESSMENT PROGRAM (NCAP) INDICATED THAT THE OUTBOARD ANCHORAGE OF THE DRIVER'S SEAT BELT COULD DISCONNECT BECAUSE OF CONTACT BETWEEN THE SEAT TRIM AND THE ANCHORAGE CONNECTOR WHEN THE SEAT WAS ADJUSTED TO ITS LOWEST POSITION.
IF THIS OCCURRED IN A CRASH, THE DRIVER COULD RECEIVE GREATER INJURIES.
DEALERS WILL INSERT A RETAINER ON BOTH THE DRIVER'S AND PASSENGER'S BELT ANCHORAGES. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V188000 on NHTSA.gov
Equipment, other, labelsFeb 24, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES THAT WERE NOT EQUIPPED WITH AN ADVANCED OCCUPANT RESTRAINT SYSTEM (AORS) HAVE DRIVER AND PASSENGER SIDE SUN VISORS WITH AORS LABELS. THE AORS LABELS DO NOT INCLUDE STATEMENTS AND THE ILLUSTRATION REQUIRED BY FMVSS NO. 208 FOR VEHICLES WITHOUT AORS.
OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V094000 on NHTSA.gov
Representative owner complaints: steering
1,073 reports, newest first. Show all
Steering, May 14, 2014
TL*T HE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT STATED WHILE DRIVING 35 MPH, THE POWER STEERING MALFUNCTIONED CAUSING THE STEERING WHEEL TO BECOME VERY HARD TO MANEUVER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE STEERING WHEEL TORQUE AND SENSOR FAILED. AS A RESULT, THE POWER STEERING COLUMN UNIT NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 36,327. THE CURRENT MILEAGE WAS 44,258. UPDATED 08/11/14*LJ THE CONSUMER STATED THE TECHNICIAN FOUND THE FAULT CODE C0545 (STEERING WHEEL TORQUE IN THE PAST SENSOR FAILURE). THE STEERING WHEEL COLUMN UNIT WAS REPLACED. UPDATED 08/13/2014 *JS
Steering, May 14, 2014
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE POWER STEERING ASSIST FAILED AND THE STEERING WHEEL WAS HARD TO TURN. THE FAILURE RECURRED INTERMITTENTLY OVER A PERIOD OF SIX MONTHS. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE STEERING COLUMN AND TORQUE ANGLE SENSOR. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
Steering, May 12, 2014
TL-THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE POWER STEERING WOULD INTERMITTENTLY FAIL WITHOUT WARNING. THE VEHICLE WOULD BECOME INCREASINGLY DIFFICULT TO CONTROL. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND CURRENT MILEAGE WAS 140,000. ML
Steering, May 10, 2014
AFTER STARTING THE CAR LATE AT NIGHT LEAVING A FRIENDS HOUSE, WAS IN THE ACT OF PULLING OUT INTO THE STREET WHEN THE STEERING BECAME VERY DIFFICULT TO TURN, AND THE WARNING LIGHT CAME ON. I WAS STUCK OUT INTO THE MIDDLE OF THE ROAD UNTIL I TURNED OFF THE CAR AND TURNED IT BACK ON TO REST THE SYSTEMS. IF IT WAS EARLIER IN THE DAY I VERY MUCH BELIEVE WE COULD HAVE BEEN INJURED BY ANOTHER CAR. I HAVE HAD IT DO IT TO ME BEFORE FOR JUST A COUPLE OF SECONDS THE IT WAS FINE. IM GETTING VERY CONCERNED ABOUT THIS PROBLEM. *TR
Steering, May 7, 2014
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT WHILE TRAVELING 35 MPH, THE POWER STEERING WARNING LIGHT ILLUMINATED AS THE VEHICLE BECAME DIFFICULT TO STEER. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 102,000 AND THE CURRENT MILEAGE WAS 106,000. UPDATED 6/26/14*CN THE CONSUMER STATED THE PART NEEDED TO REPAIR THE VEHICLE HAD NOT BECOME AVAILABLE. UPDATED 07/08/2014 *JS
Steering, May 7, 2014
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE POWER STEERING COLUMN FAILED AND WAS REPLACED IN 2004 HOWEVER, THE PARTS WERE FOUND TO BE DEFECTIVE AND WERE REPLACED BY THE MANUFACTURER. THE FAILURE RECURRED IN 2011 AND THE POWER STEERING COLUMN WAS REPLACED AGAIN. THE CONTACT WAS CONCERNED THAT THE PART WAS DEFECTIVE DUE TO THE EXACT RECURRING FAILURE. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE APPROXIMATE FAILURE MILEAGE WAS 3000. UPDATED 6/24/14*CN UPDATED 06/26/2014 *JS
Steering, Suspension, May 6, 2014
STEERING IS LOOSE AND RATTLING . DOES NOT SOUND SAFE. *TR
Steering, May 5, 2014
TODAY AFTER DROPPING MY SON OFF AT SCHOOL, MY 2004 CHEVROLET MALIBU 3.5 V6 BECAME NEARLY IMPOSSIBLE TO STEER. IT FELT LIKE THE CAR HAD 2 FLAT TIRES IN THE FRONT. WITH GREAT STRUGGLE I WAS ABLE TO GET THE CAR OFF THE ROAD AND AVOID CRASHING. HAD I NOT BEEN STRONG ENOUGH TO TURN THE CAR OTHERS COULD HAVE BEEN KILLED. THIS WAS A NEAR MISS. AFTER HAVING THE PROBLEM THIS MORNING, I DISCOVERED THAT GM ISSUED A RECALL FOR THIS PROBLEM. THE RECALL ID IS 102634. GM HAS NOT IMPLEMENTED THE RECALL EVEN THOUGH THEY ISSUED A PRESS RELEASE ON THE PROBLEM ON 3-31-14. I HAVE SPENT THE LAST 5 HOURS ON THE PHONE WITH 2 CHEVROLET DEALERS AND GM TRYING TO FIND A SOLUTION SINCE "THEY ARE AWARE OF THE PROBLEM BUT HAVE NOT LOADED MY VIN INTO THEIR SYSTEM." PEOPLE ARE BEING INJURED AND LIKELY DYING BECAUSE OF THIS ISSUE. *TR
Steering, May 5, 2014
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE STEERING WHEEL MADE A LOUD NOISE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO STATED THAT THE POWER STEERING NEEDED TO BE REPLACED. THE CONTACT WAS ALSO INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 14V153000 (STEERING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 98,517. THE VIN WAS NOT AVAILABLE.
Steering, Fuel system, Gasoline, Electrical system, Engine, May 1, 2014
MY BATTERY LIGHT CAME ON THIS MORNING AND I CAME HOME FROM LUNCH TRIED MAKING A LEFT TURN ONTO A STREET AND MY STEERING WHEEL LOCKED ON ME. I COULDN'T TURN MY CAR, NOW MY CAR WON'T EVEN START. I BARELY MADE IT HOME, THANK GOD BECAUSE I ALMOST CRASHED INTO MY NEIGHBORS HOUSE FROM MY STEERING WHEEL LOCKING. *TR
Steering, Electrical system, May 1, 2014
WHILE DRIVING MY BATTERY LIGHT WILL FLASH ON AND CHIRP AND MY STEERING WHEEL SORT OF LOCKS UP, THE DISPLAY ON MY RADIO SAYS POWER STEERING AND THE WRENCH LIGHT LIGHTS UP ON THE PANEL. IT IS QUITE SCARY CONSIDERING I HAVE YOUNG CHILDREN IN MY CAR ABOUT 95% OF THE TIME. I HAVE BEEN VERY CLOSE TO CRASHING INTO OTHER CARS MORE THAN ONCE. I WOULD LOVE TO GET RID OF THIS CAR BUT AM AFRAID THIS WILL HAPPEN TO THE NEXT PERSON AND IT COULD BE FATAL. *TR
Steering, Apr 30, 2014
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THE WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT ABLE TO BE RESTARTED. THE CONTACT ALSO STATED THAT THE POWER STEERING ASSIST WOULD SPORADICALLY FAIL. THE VEHICLE WAS TAKEN TO A DEALER WHO RE-CALIBRATED THE ELECTRICAL STEERING, HOWEVER THE FAILURE PERSISTED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 14V153000 (STEERING). HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE VEHICLE WAS NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.
Steering, Apr 29, 2014
I HAVE A LOT OF PLAY IN MY STEERING WHEEL THERE IS A LIGHT THAT KEEPS COMING ON WITH A WRENCH IN THE MIDDLE OF CAR? WHILE DRIVING THE VEHICLE IT SEEMS AS IF THE STEERING WHEEL IS GOING TO COME A PART FROM DASHBOARD HAVE TO DRIVE WITH 2 HANDS CAUSE IT SHAKES SOME WHAT . I AM UNABLE TO DRIVE ON FREEWAY MUCH AFRAID AT THIS POINT .. IF U COULD CHECK TO SEE IF THERE IS A RECALL ON THIS I WOULD APPRECIATE IT ... DONT WANT AN ACCIDENT . NOTIFIED BROWN & BROWN CHEVY , MESA,AZ THEY SAID THERE WAS A RECALL ON THIS ? MY CAR IS A 2004 CHEVY MALIBU. *JS
Steering, Apr 24, 2014
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE POWER STEERING ASSIST SUDDENLY FAILED. THE CONTACT ALSO MENTIONED THAT THE FAILURE WAS EXPERIENCED MULTIPLE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 14V153000 (STEERING). THE FAILURE MILEAGE WAS 86,000.
Steering, Apr 24, 2014
VEHICLE STEERING WHEEL WAS TWITCHING TO THE RIGHT AT ALL SPEEDS AND WHILE STOPPED I HAD ALSO LOST POWER ASSIST A COUPLE TIMES. I TOOK THE 2004 MALIBU TO THE DEALERSHIP WHERE I HAD PURCHASED THE VEHICLE ON 14 FEBRUARY 2004. THEY REPLACED THE STEERING COLUMN AT A COST TO ME OF $594.20 ON 17 FEBRUARY 2010. *TR
Steering, Apr 24, 2014
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE STEERING WHEEL BECAME EXTREMELY DIFFICULT TO MANEUVER AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR A DIAGNOSTIC. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE 44,000. THE VIN WAS NOT AVAILABLE.
Steering, Vehicle speed control, Engine, Apr 23, 2014
SINCE 1/2012, INTERMITTENT MALFUNCTION OF POWER STEERING AND ENGINE OPERATION AT HIGHWAY/STREET SPEEDS OCCURS. VEHICLE SINCE HAS BEEN INSPECTED FOR INCIDENTS BY CERTIFIED DEALERS/AUTO REPAIR SHOPS. PROBLEM CONTINUES FORCING THE DRIVER TO VEER OFF THE ROAD WITHOUT STEERING AND/OR POWER, PUTTING THE DRIVER AND ANYONE IN THE PATH AT RISK OF INJURY/DEATH. MY RESEARCH DUE TO THE MOST CURRENT INCIDENT LED ME TO INFORMATION RELEASED FROM THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION DATED APRIL 1, 2014 STATING THAT 1,340,447 CARS AFFECTED WITH THIS PROBLEM. NHTSA CAMPAIGN # 14V153000, GM RECALL #:N140115. GM KNEW THIS INFORMATION. ON 4/23/14 I SUBMITTED A COMPLAINT TO THE NHTSA, AND GM. 2 GM EMPLOYEES DENIED THE RECALL/SERVICES, YET EVENTUALLY ADMITTED THAT THEY KNEW ABOUT THE RECALL WHICH WOULD BE MADE PUBLIC 4/28/14, YET NOTICES TO VEHICLE OWNERS WILL GO OUT AFTER 4/28/14. GM CONTINUES THE PRACTICE OF NOT INFORMING THE PUBLIC. *TR
Steering, Apr 23, 2014
THE POWER STEERING WOULD JUST STOP WORKING. I HAD TO PAY $563.14 FOR A HAZARDOUS RECALL THAT WAS REPAIRED ONE PREVIOUS TIME, AND THAT G.M. WOULD NO LONGER HONOR. *TR
Steering, Apr 22, 2014
HAD DRIVEN CAR WITH NO ISSUES PREVIOUS. HAD PARKED CAR IN PARKING LOT. ABOUT 30 MINUTES LATER WENT TO START THE CAR AND IMMEDIATELY THE SERVICE WRENCH LIGHT CAME ON AND NOTICED THE POWER STEERING WAS NOT WORKING. AFTER A MINUTE OR SO, TURNED THE CAR OFF, THEN TURNED IT BACK ON. WRENCH LIGHT WAS OFF AND THE POWER STEERING WAS WORKING, BUT NOW WHEN APPLYING A SLIGHT RIGHT TURN MOTION ON THE STEERING WHEEL, THE WHEEL SHAKES/CHATTERS/BOUNCES. THIS HAPPENS EITHER IN GEAR OR NOT. IT DOES NOT DO THIS WHEN TURNING THE WHEEL LEFT OR WHEN APPLYING INCREASED PRESSURE TURNING RIGHT. IT SEEMS TO BE GETTING WORSE AND WONDERING IF THIS HAS SOMETHING TO DO WITH THE UPCOMING POWER STEERING RECALL. *TR
Steering, Apr 21, 2014
WHILE THE CAR WAS TURNING OUT OF A DRIVEWAY SOMETHING BROKE INSIDE THE RACK AND PINION. THIS LEFT THE CAR WITH NO STEERING. I THINK IF THIS IS A COMMON PROBLEM WITH THESE CARS THERE SHOULD BE A RECALL. IF THIS HAPPENED AT HIGHWAY SPEEDS, PEOPLE COULD GET HURT OR WORSE. *TR
Steering, Electrical system, Apr 19, 2014
AS I WAS DRIVING DOWN THE HIGHWAY ALL OF A SUDDEN MY STEERING WHEEL LOCKED. THEN MY POWER STEERING LIGHT CAME ON. SO LUCKY I WAS ON A STRAIGHT AWAY. I PULLED OVER AND SHUT THE CAR OFF AND TURNED IT BACK ON AND WAS BACK TO NORMAL. *TR
Steering, Apr 16, 2014
AT FIRST THE WARNING LIGHT WOULD COME ON THEN THE CAR BEGAN TO LOSE THE POWER STEERING, THEN IT FINALLY WENT OUT COMPLETELY. I HAD THE CAR REPAIRED, THEN MY DAUGHTER AND SON IN LAW FOUND OUT THE CAR HAD BEEN RECALLED. I WOULD JUST LIKE TO BE REIMBURSED FOR THE COST OF THE REPAIR. I HAVE CALLED TOM BANNAN CHEVROLET IN MADISON TENNESSEE. WHO DOES NOT RETURN MY CALL. THANK YOU *TT
Steering, Apr 14, 2014
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE POWER STEERING ASSIST FAILED SPORADICALLY. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000 AND THE CURRENT MILEAGE WAS 143,932.
Steering, Apr 10, 2014
THE POWER STEERING WENT OUT VERY HARD TO STEER. HAPPENED A COUPLE OF TIMES DO NOT KNOW DATES, THEN FINALLY WOULD GO OUT EACH TIME IT WAS DRIVEN. WAS REPLACED BY A MECHANIC. I DO NOT SEE THE LT LISTED, IS IT IN THE RECALL? *TR
Steering, Suspension, Exterior lighting, Apr 9, 2014
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS THE POWER STEERING WOULD SUDDENLY MALFUNCTION MAKING THE STEERING WHEEL VERY DIFFICULT TO TURN. WHEN THE FAILURE OCCURRED THE CHECK ENGINE, ABS AND TC (TRACTION CONTROL) SENSOR LIGHTS ILLUMINATED. THE FAILURE WAS NOT DIAGNOSED NOR WAS THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOTIFIED AND NO SOLUTION WAS OFFERED. THE CONTACT ALSO INDICATED THAT WHILE DRIVING VARIOUS SPEEDS THE VEHICLE WOULD DRIFT FROM SIDE TO SIDE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE CONTROL ARMS WERE FAULTY. THE CONTROL ARMS WERE REPLACED BUT THE DEFECT WAS NOT REMEDIED. WHILE DRIVING THE HEADLIGHTS, TURN SIGNAL LIGHTS AND REAR LIGHTS WOULD INTERMITTENTLY SHUT ON AND OFF. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE DEFECT WAS CAUSED BY AN ELECTRICAL SHORT. THE DEFECT WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 17,000.