2004 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,697 owner complaints filed for this model year. This is the highest complaint count among 26 Malibu model years with reports.
Of the 2004 reports, 81 involved a crash and 15 involved a fire. 55 people were injured.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 19, 2004
SOME OF THESE PASSENGER VEHICLES HAVE AN ELECTRONIC CONTROL UNIT (ECU) THAT MAY CALCULATE A HIGHER THAN ACTUAL VEHICLE SPEED BECAUSE OF AN ERRATIC REAR-WHEEL SPEED SENSOR SIGNAL, AND CAUSE ABS ACTIVATION WHERE IT IS NOT NEEDED OR NEEDED ABS ACTIVATION TO BE EXTENDED DURING BRAKING AS THE VEHICLE SPEED DROPS TO ABOUT 3 MPH.
UNEXPECTED ABS ACTIVIATION COULD INCREASE STOPPING DISTANCE UP TO ABOUT 11 FEET DPENDING ON THE GRADE OF THE ROAD, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPROGRAM THE ABS CONTROLLER. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V190000 on NHTSA.gov
Seat belts, front, anchorageApr 16, 2004
ON CERTAIN PASSENGER VEHICLES, ANALYSIS OF AN A SIDE IMPACT CRASH TEST CONDUCTED BY THE NHTSA;S NEW CAR ASSESSMENT PROGRAM (NCAP) INDICATED THAT THE OUTBOARD ANCHORAGE OF THE DRIVER'S SEAT BELT COULD DISCONNECT BECAUSE OF CONTACT BETWEEN THE SEAT TRIM AND THE ANCHORAGE CONNECTOR WHEN THE SEAT WAS ADJUSTED TO ITS LOWEST POSITION.
IF THIS OCCURRED IN A CRASH, THE DRIVER COULD RECEIVE GREATER INJURIES.
DEALERS WILL INSERT A RETAINER ON BOTH THE DRIVER'S AND PASSENGER'S BELT ANCHORAGES. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V188000 on NHTSA.gov
Equipment, other, labelsFeb 24, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES THAT WERE NOT EQUIPPED WITH AN ADVANCED OCCUPANT RESTRAINT SYSTEM (AORS) HAVE DRIVER AND PASSENGER SIDE SUN VISORS WITH AORS LABELS. THE AORS LABELS DO NOT INCLUDE STATEMENTS AND THE ILLUSTRATION REQUIRED BY FMVSS NO. 208 FOR VEHICLES WITHOUT AORS.
OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V094000 on NHTSA.gov
Representative owner complaints: steering
1,073 reports, newest first. Show all
Steering, Oct 25, 2010
TL*THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING 2 MPH, THE STEERING WHEEL SUDDENLY LOCKED. THE CONTACT TURNED THE VEHICLE OFF AND RESTARTED IT; IT PERFORMED NORMALLY AFTER. THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE IT WAS REPLACED (REPAIR DETAILS WERE NOT GIVEN). THE FAILURE MILEAGE WAS APPROXIMATELY 6,000 AND THE CURRENT MILEAGE WAS 7,730.
Steering, Oct 22, 2010
2004 MALIBU MAXX POWER STEERING CUTS OUT WHILE DRIVING. MUST PUT CAR IN PARK TURN IT OFF AND RESTART. HAPPENS IN THE WINTER. FOUND ON INTERNET THAT OTHER PEOPLE HAVE HAD THE SAME PROBLEM. HAPPENED NUMEROUS TIMES LAST WINTER. *TR
Steering, Electronic stability control (ESC), Oct 13, 2010
2004 CHEVY MALIBU LT 74,000 MILES. I HAVE HAD PROBLEMS WITH THE REMOTE START NOT WORKING. THE CRUISE WILL NOT WORK ALL THE TIME, BEARINGS IN STEERING COLUMN, CHECK GAS CAP AND ANTI THEFT LIGHT. IT ALSO WILL NOT START UNLESS I GIVE IT GAS. AND WHEN I TAKE IT IN THEY FIND NOTHING. FUEL PUMP HAS BEEN REPLACED AND THAT IS NOT THE PROBLEM. I DID SOME RESEARCH AND FOUND HUNDREDS OF PEOPLE WITH THE SAME COMPLAINTS. THERE NEEDS TO BE A RECALL SAME YR OF CARS ALL WITH THE SAME ISSUE SOMETHING IS NOT RIGHT. *TR
Steering, Oct 8, 2010
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH WHEN THE STEERING WHEEL LOCKED WITHOUT WARNING. THE SPEED RATE WAS REDUCED AND THE ENGINE WAS TURNED OFF. THE CONTACT RESTARTED THE VEHICLE AND AFTER THREE ATTEMPTS, THE STEERING WHEEL RESET INDEPENDENTLY. THE VEHICLE RESUMED NORMAL OPERATION YET THE FAILURE RECURRED FOUR SEPARATE TIMES. THE CONTACT WAS IN THE PROCESS OF TAKING THE VEHICLE TO THE DEALER FOR DIAGNOSIS. THERE WAS CONCERN OF THE POTENTIAL SAFETY HAZARD INVOLVED WITH THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 44,000.
Steering, Oct 6, 2010
TL*THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 55-60 MPH, THERE WAS A COMPLETE LOSS OF THE POWER STEERING. THE CHECK ENGINE AND WRENCH SYMBOL WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD. THE ENGINE WAS TURNED OFF AND RESTARTED. THE CONTACT RESUMED CAUTIOUSLY WITH A PERMANENT LOSS OF POWER STEERING. THE CONTACT DISCOVERED THAT THERE WAS A RELATED DEFECT ASSOCIATED WITH THE NHTSA CAMPAIGN ID NUMBER 10V073000 (STEERING: ELECTRIC POWER ASSIST SYSTEM). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 136,000. THE VIN WAS UNAVAILABLE. UPDATED 05/04/11 *BF UPDATED 06/06/11
Steering, Oct 2, 2010
2004 MALIBU HAS INTERMITTENT POWER STEERING FAILURE. IT GOES OUT IN THE MIDDLE OF A TURN AND ALMOST MAKE YOU WRECK. DEALER SAYS THERE IS NOT PROBLEM. COMES AND GOES AT WILL. SOMETIME TURNING THE KEY OFF THEN BACK ON FIXES IT BUT NOT ALWAYS. *TR
Steering, Sep 30, 2010
TL*THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT ON SEVERAL OCCASIONS, THE POWER STEERING WOULD SUDDENLY FAIL AND HE WAS UNABLE TO STEER OR TURN. THE VEHICLE WAS ABLE TO BE MANEUVERED TO THE SIDE OF THE ROAD WITH MUCH DIFFICULTY. THE POWER STEERING LIGHT WOULD ILLUMINATE IMMEDIATELY AFTER THE FAILURE. AT TIMES, HE WOULD TURN THE VEHICLE OFF AND RESTART IT WHICH WOULD REMEDY THE PROBLEM TEMPORARILY. MOST RECENTLY, THE STEERING WAS UNABLE TO BE RESET BY RESTARTING AND HAD TO BE TOWED. IT WAS REPAIRED UNDER WARRANTY THREE TIMES. HOWEVER, THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AFTER THE WARRANTY EXPIRED AND THE CONTACT PAID FOR REPAIRS AT HIS EXPENSE. HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT MILEAGE WAS APPROXIMATELY 55,000. THE FAILURE MILEAGE WAS 4,206.
Steering, Sep 29, 2010
TL*THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 30 MPH, THE POWER STEERING SUDDENLY FAILED. THE CHECK ENGINE LIGHT AND THE POWER STEERING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT PULLED AND NOTICED THAT THE STEERING WHEEL WAS DIFFICULT TO TURN. THE CONTACT TURNED THE VEHICLE OFF AND RESTARTED IT; THE FAILURE CONTINUED. THE CONTACT DROVE HOME. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 143,264 AND THE CURRENT MILEAGE WAS 143,266.
Steering, Sep 28, 2010
I HAVE A 2004 CHEVY MALIBU MAXX THAT I BOUGHT IN MAY, 2006. ABOUT A YEAR AGO, WHILE DRIVING, THE POWER STEERING WENT OUT. I SEARCHED FOR RECALLS AND CALLED A CHEVROLET DEALER. IN MY RESEARCH I HAVE FOUND THAT I AM NOT THE ONLY ONE WITH THIS PROBLEM. NOT LONG AFTER THIS, GM RECALLED THE CHEVY COBALT AND SOME PONTIAC MODELS FOR THE SAME THING. EVERYTHING THAT I HAVE READ SAYS THAT YOU CAN STILL STEER AT THE SPEED CONSISTENT WITH BEING ON THE INTERSTATE. MY PROBLEM IS, I LIVE AND WORK IN A SMALL TOWN. IT HAS NOW DONE THIS ON ME SEVERAL TIMES AND AT THE SLOW SPEEDS FOR A SMALL TOWN, I HAVE TROUBLE STEERING. TWO OF THESE TIMES THAT THE POWER STEERING WENT OUT I WAS AT AN INTERSECTION. TRYING TO TAKE OFF AND CROSS THE INTERSECTION WHEN THIS HAPPENS IS VERY DIFFICULT. THIS IS GOING TO CAUSE AN ACCIDENT. I WANT TO KNOW WHAT GM IS GOING TO DO ABOUT THIS PROBLEM. *TR
Steering, Sep 28, 2010
POWER STEERING WARNING LIGHT COMES ON INTERMITTENTLY. GOES OFF AFTER RESTART. POWER STEERING UNIT REPLACED ONCE UNDER FACTORY WARRANTY. *TR
Steering, Sep 28, 2010
MY STEERING HAD GONE IN MY 2004 CHEVY MALIBU 2 MONTHS AGO. THE COLUMN HAS BEEN REPLACED 2 TIMES NOW AND IS STILL NOT FIXED. I AM ALSO BEING TOLD THAT THERE ARE NO STEERING COLUMNS LEFT IN MY AREA. MY CAR IS A DANGER TO EVERYONE ON A ROAD INCLUDING MYSELF AND I HAVE NO IDEA WHY CHEVY HASN'T RECALLED THESE. *TR
Steering, Electrical system, Vehicle speed control, Sep 24, 2010
FAILURE OF POWER STEERING WHILE ACCELERATING VEHICLE. STEERING DIRECTION BECOMES IMPOSSIBLE TO CHANGE UNTIL ACCELERATION CEASES. THIS HAS SUPPOSEDLY BEEN FIXED BY THE DEALERSHIP TWO TIMES PREVIOUS TO TODAY. THE LAST TIME IT WAS FIXED WAS ONLY TWO WEEKS AGO AND WHILE I WAS DRIVING THE KIDS INTO SCHOOL THIS MORNING, THE STEERING LOCKED UP, THE DINGING SOUND TURNED ON, AND THE MESSAGE BOARD READ POWER STEERING ALONG WITH A TOOL THAT LIT UP ON THE DASHBOARD. *TR
Steering, Sep 19, 2010, crash
I WAS DRIVING BACK HOME AT NIGHT AFTER WORK A HOUR AWAY TO BOWIE TX I WORK IN FORT WORTH. GOING ON HWY 287 WHICH IS A BIG HWY FOR TRAVELING RIGS, I WAS GOING 65 MPH AND I CAME TO A TURNING THE HWY AND MY POWER STEERING JUST GOES OUT WITH ANY WARNING. I SLAMMED ON MY BRAKES TAPPING THE WALL IN THE MEDIAN. LOOKED ON THE INFORMATION BOARD AND IT SAID POWER STEERING. THE NEXT MORNING I LOOKED ON THE INTERNET AND FOUND AROUND 10 TO 15 WEBSITES THAT HAD THIS COMPLAINT WITH THE CHEVROLET MALIBU MAXX. I CALLED GM CHEVROLET IN NORTH RICHLAND HILLS AND THE ON IN DECATUR AND THEY BOTH TOLD ME THAT THE KNOW THIS IS A BIG DEAL THE KNOW ABOUT IT BUT AT THIS TIME THERE IS NOTHING THEY CAN DO FOR ME. THIS IS MY WIFE'S CAR AND LUCKY THIS DAY I TOOK IT INSTEAD FOR HER AND MY 3 YEAR OLD SON. *TR
Steering, Sep 14, 2010, crash
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT WAS DRIVING 25 MPH WHEN THE STEERING WHEEL FROZE AND WOULD NOT RESPOND. THE CONTACT WAS UNABLE TO CONTROL THE VEHICLE AS IT ABNORMALLY PULLED TO THE LEFT ACROSS SEVERAL LANES AND CRASHED INTO A DITCH. THE CONTACT SUSTAINED BRUISING ON THE SHOULDER AND NECK FROM THE SEAT BELT. A POLICE REPORT WAS AVAILABLE. THE VEHICLE WAS TOWED TO A LOCAL AUTO BODY REPAIR FACILITY WHERE THE STEERING COLUMN WAS RULED AS THE CAUSE OF THE CRASH. THE STEERING COLUMN WAS REPLACED. THE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 122,000. UPDATED 12/09/10 *BF ACCORDING TO THE POLICE REPORT, THE CONSUMER STATED THE POWER STEERING FAILED. UPDATED 12/13/10*JB UPDATED 4/29/14*CN UPDATED 05/15/14
Steering, Sep 13, 2010
2004 MALIBU MAX POWER STEERING FAILS WITH NO WARNING! IT HASN'T HAPPENED JUST ONCE, BUT MANY TIMES IN THE PAST FEW MONTHS. TOOK CAR TO THE DEALER, THEY CAN ONLY FIND 1 OF THE COMPONENTS TO DO THE REPAIR. SAID IT COULD TAKE UP TO 3 MONTHS TO GET THE PART. THEN THE REPAIR IS GOING TO COST A TOTAL OF $1200.00. I HAVE READ HUNDREDS COMPLAINTS ABOUT THE SAME THING HAPPENING. WHEN ARE THEY GOING TO DO A RECALL? HOW MANY PEOPLE HAVE TO DIE FIRST? I DON'T WANT TO BE ONE OF THEM. WHEN IS SOMEONE GOING TO DO SOMETHING ABOUT THIS. I SEE THAT THE NHTSA CLOSED THE INVESTIGATION OF THE MATTER IN 2004. WHAT'S THAT? OPEN IT UP AGAIN. *TR
Steering, Sep 7, 2010
MY 2004 MALIBU HAS A POWER STEERING PROBLEM. I TOOK IT IN TODAY TO SEE ABOUT REPAIR AND IT IS GOING TO COST ALMOST $700 TO FIX. THE POWER STEERING JUST STOPS WORKING SOMETIMES. IT HAS BEEN DOING IT FOR A WHILE NOW. IT IS PROGRESSIVELY GETTING WORSE. IT SOMEHOW RESETS WHEN YOU TURN THE CAR OFF AND TURN IT BACK ON SOMETIMES. I STARTED HAVING PROBLEMS WITH THIS WHEN THE VEHICLE HAD 50,000 MILES ON IT. I NOW HAVE 70,000 MILES ON IT AND IT IS TO THE POINT WHERE IT HAS TO BE FIXED. I DON'T UNDERSTAND HOW IT IS NOT A RECALL SITUATION KNOWING HOW IMPORTANT THE POWER STEERING IS ON A VEHICLE. THIS SITUATION COMES AFTER HAVING TO HAVE THE STEREO REPLACED IN THE VEHICLE 3 TIMES AND NOW IT IS NOT WORKING AGAIN. I AM VERY DISAPPOINTED IN GM FOR NOT TAKING CARE OF EITHER OF THESE PROBLEMS SATISFACTORILY. *TR
Steering, Sep 2, 2010
THE POWER STEERING ALARM AND THE SERVICE ENGINE SIGN IN THE DASHBOARD OF MY 2004 CHEVROLET MALIBU LS HAS BEEN GOING OFF EVERY TIME I TURN ON THE CAR. THIS HAS BEEN HAPPENING FOR 3 WEEKS NOW. MY BROTHERS ARE HAVING THE SAME ISSUE WITH THEIR 2005 AND 2007 CHEVROLET CARS. HOWEVER, SINCE I DID NOT GET A RECALL NOTICE, MY DEALER WANTS TO CHARGE ME AN UPWARDS OF $150 TO JUST LOOK AT THE ISSUE I AM BEING TOLD THAT THE 2004 MALIBU'S ARE NOT ON THE RECALL LIST, HENCE I HAVE TO PAY FOR THE DIAGNOSTICS. I AM SCARED OF THE SAFETY OF DRIVING MY CAR TO AND FROM WORK BUT I AM LEFT WITH NO CHOICE BUT TO TAKE A CHANCE AND USE MY CAR WITH THE ALARM GOING OFF. I CANNOT AFFORD THE PRICE THE DEALERSHIP IS WANTING TO CHARGE ME, ESPECIALLY IF IT IS A KNOWN ISSUE WITHIN THE CHEVROLET MODELS. PLEASE, PLEASE, PLEASE... ASK THE DEALERS TO FIX THIS ISSUE WITH CHEVROLET CARS BEFORE SOMEONE GETS HURT. *TR
Steering, Sep 2, 2010
2004 CHEVY MALIBU "ELECTRIC STEERING" REPEATED FAILURE OF THE STEERING UNIT AND STEERING COLUMN. STEERING WHEEL CLUNKS AND BECOMES LOOSE. CHEVY FIXED IT TWICE OR SO BUT NOW SAYS ITS UP TO ME. I EXPECT THE STEERING ASSY OF ANY CAR TO BE BULLET PROOF AND NOT HAVE SAFETY PROBLEMS. *TR
Steering, Electrical system, Latches/locks/linkages, Equipment, Electronic stability control (ESC), Sep 1, 2010
THE ELECTRIC POWER STEERING IN MY VEHICLE IS FAULTY. THE STEERING WHEEL WILL MOVE BY ITS SELF WHILE DRIVING OR IN PARK. ALSO MY POWER STEERING WILL GO OUT WITHOUT WARNING WHILE DRIVING AT ANY SPEED. WHEN THE STEERING WHEEL LOCKS UP DUE TO POWER STEERING I HAVE A VERY HARD TIME TURNING AND CONTROLLING CAR. I HAVE BARELY AVOID SEVERAL ACCIDENTS BECAUSE OF THIS ISSUE. I HAVE TAKEN CAR TO DEALERSHIP TO SEE IF CAN BE FIXED BECAUSE WHEN I CALLED GM I WAS NOT ELIGIBLE FOR THE WARRANTY THAT WOULD HAVE FIXED ISSUE BUT BECAUSE IT WAS PAST THEIR RECALL TIME THEY WOULD NOT ASSIST ME AND THE DEALER WANTS 800.00 TO FIX AND THEY SAY THAT EVEN FIXING THE STEERING COLUMN AND OR THE ASSIST MOTOR THAT I WILL MORE THEN LIKELY HAVE THE SAME ISSUES! MY CAR IS A 2004 WITH ONLY 44,462 MILES ON IT. I GOT THE CAR USED FEBRUARY OF THIS YEAR (2010) AND DIDN'T KNOW THAT IT WOULD BE A NIGHTMARE AND A DEATH TRAP FOR MY FAMILY! I HAVE VIDEO OF THE WHEEL MOVING BY ITS SELF AS WELL AS VIDEO SHOWING THAT WHEN I LOSS POWER STEERING THE CAR IS HAZARDOUS. I AM REALLY AFRAID THAT I WILL NOT BE ABLE TO KEEP UP WITH THIS ISSUE AND WILL ONE DAY LOSS COMPLETE CONTROL OF THE CAR AND HURT MYSELF AND POSSIBLY OTHERS! CHEVROLET NEEDS TO FIX THIS ISSUE FOR GOOD OR REPLACE THE CARS ALL TOGETHER BECAUSE ITS REALLY ONLY A MATTER OF TIME BEFORE THIS ISSUE BITES THEM IN THE BUTT! I REALLY LIKE MY MALIBU BUT I REALLY THINK THAT I SHOULD HAVE NEVER GOT IT BECAUSE OF ALL THE ISSUES LOSING POWER STEERING, PULLS BAD TO LEFT AND RIGHT, LOOSE SHIFTER KNOB, & THE REMOTE KEYLESS ENTRY DOESN'T WORK RIGHT. I HOPE BY FILING THIS COMPLAINT WITH YOU THAT MAYBE IT WILL BE RESOLVED. I WANT TO HAVE PIECE OF MIND WHILE DRIVING MY FAMILY IN CAR NOT WORRIED ABOUT THE CAR BEING A DEATH TRAP ON 4 WHEELS THAT WILL LOSS CONTROL WHEN IT FEELS LIKE IT AND KILL MY FAMILY AND MYSELF. I KNOW THAT I AM NOT THE ONLY ONE WITH THESE ISSUES WITH THE MALIBU AND CHEVROLET REALLY NEEDS TO STEP UP AND MAKE THESE ISSUES RIGHT FOR US THE CONSUMERS FAST! *TR
Steering, Aug 31, 2010
TL*THE CONTACT OWNS A 2004 CHEVROLET MALIBU . WHILE DRIVING 10 MPH A CHIMING SOUND ALERTED HER THAT THE POWER STEERING LIGHT ILLUMINATED AND WITHIN A FEW SECONDS THE STEERING WHEEL WAS VERY DIFFICULT TO CONTROL. THE VEHICLE WAS TURNED OFF, BACK ON AND BEGAN TO DRIVE NORMALLY. AFTER A FEW MINUTES THE FAILURE RECURRED. THE DEALER WAS NOT CONTACTED AND THE FAILURE WAS NOT DIAGNOSED. THE FAILURE AND CURRENT MILEAGES WERE 80,000.
Steering, Aug 30, 2010
ELECTRIC POWER STEERING SUDDENLY FAILS RESULTING IN LOSS OF POWER STEERING ASSISTANCE. *TR
Steering, Aug 30, 2010
I HAVE A 2004 MALIBU MAX. I HAVE HAD PROBLEMS WITH THE STEERING COLUMN FOR THE PAST 1 1/2 YEARS. THE RACK AND PINION AND STEERING COLUMN WAS REPLACED LAST YEAR AFTER THE POWER STEERING KEPT GOING OUT. A YEAR LATER AND THE RACK AND PINION AS BEEN REPLACED AGAIN! THE STEERING COLUMN IS GOING TO HAVE TO BE REPLACED AGAIN AS WELL! THE POWER STEERING GOES KEEPS GOING OUT, BUT IF I TURN THE CAR OFF AND BACK ON IT CORRECTS THE PROBLEM TEMPORARILY. THERE IS NO WARNING BEFORE IT GOES OUT. THE 2005 HAS A RECALL OUT ON IT BUT NOT THE 2004 AND IT IS THE SAME PROBLEM! *TR
Steering, Aug 30, 2010
TL*THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE TRAVELING 65 MPH THE VEHICLE LOST POWER STEERING. THE CONTACT STATED THAT AFTER REGAINING CONTROL OF THE VEHICLE AND STARTING THE VEHICLE, THE POWER STEERING BEGAN TO FUNCTION NORMALLY. THE VEHICLE WAS TAKEN TO A MECHANIC WHO STATED THAT THEY COULD NOT FIND A PROBLEM WITH THE VEHICLE. THE CONTACT STATED THAT THIS WAS THE ONLY TIME THE POWER STEERING FAILED. THE FAILURE MILEAGE WAS 100000 AND THE CURRENT MILEAGE IS 117,000. UPDATED 12/22/10 *BF UPDATED 12/29/10*JB
Steering, Aug 28, 2010
2004 CHEVY MALIBU POWER STEERING GOES OUT WITHOUT WARNING AND FREQUENTLY. WHEN TURNING THE WHEEL LOCKS UP MAKING TURNING IMPOSSIBLE TO DO. I ALMOST CAUSED A HEAD ON COLLISION DUE TO THIS. NOW WHEN I TURN THE STEERING WHEEL TIRES DO NOT MOVE AT ALL. THERE ARE HUNDREDS OF COMPLAINTS ON-LINE ABOUT THIS EXACT ISSUE AND GM WANTS TO DO NOTHING ABOUT IT. *TR
Steering, Aug 27, 2010
ALMOST DAILY, THE WRENCH LIGHT TURNS ON AND THE DISPLAY IN THE CENTER READS "POWER STEERING." OCCASIONALLY, THIS IS ACCOMPANIED BY A COMPLETE LOSS OF POWER STEERING, MAKING IT VERY DIFFICULT TO TURN AT LOW SPEEDS. TURNING OFF THE MALIBU USUALLY RESETS THE LIGHT AND ERROR MESSAGE; HOWEVER, THIS PROBLEM USUALLY RECURS SHORTLY AFTER RESTARTING THE CAR. I WAS TOLD BY A DEALERSHIP THAT THE ONLY WAY TO CORRECT THIS PROBLEM WOULD BE TO HAVE THE STEERING COLUMN REPLACED AT MY EXPENSE. *TR