2004 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,697 owner complaints filed for this model year. This is the highest complaint count among 26 Malibu model years with reports.
Of the 2004 reports, 81 involved a crash and 15 involved a fire. 55 people were injured.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 19, 2004
SOME OF THESE PASSENGER VEHICLES HAVE AN ELECTRONIC CONTROL UNIT (ECU) THAT MAY CALCULATE A HIGHER THAN ACTUAL VEHICLE SPEED BECAUSE OF AN ERRATIC REAR-WHEEL SPEED SENSOR SIGNAL, AND CAUSE ABS ACTIVATION WHERE IT IS NOT NEEDED OR NEEDED ABS ACTIVATION TO BE EXTENDED DURING BRAKING AS THE VEHICLE SPEED DROPS TO ABOUT 3 MPH.
UNEXPECTED ABS ACTIVIATION COULD INCREASE STOPPING DISTANCE UP TO ABOUT 11 FEET DPENDING ON THE GRADE OF THE ROAD, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPROGRAM THE ABS CONTROLLER. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V190000 on NHTSA.gov
Seat belts, front, anchorageApr 16, 2004
ON CERTAIN PASSENGER VEHICLES, ANALYSIS OF AN A SIDE IMPACT CRASH TEST CONDUCTED BY THE NHTSA;S NEW CAR ASSESSMENT PROGRAM (NCAP) INDICATED THAT THE OUTBOARD ANCHORAGE OF THE DRIVER'S SEAT BELT COULD DISCONNECT BECAUSE OF CONTACT BETWEEN THE SEAT TRIM AND THE ANCHORAGE CONNECTOR WHEN THE SEAT WAS ADJUSTED TO ITS LOWEST POSITION.
IF THIS OCCURRED IN A CRASH, THE DRIVER COULD RECEIVE GREATER INJURIES.
DEALERS WILL INSERT A RETAINER ON BOTH THE DRIVER'S AND PASSENGER'S BELT ANCHORAGES. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V188000 on NHTSA.gov
Equipment, other, labelsFeb 24, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES THAT WERE NOT EQUIPPED WITH AN ADVANCED OCCUPANT RESTRAINT SYSTEM (AORS) HAVE DRIVER AND PASSENGER SIDE SUN VISORS WITH AORS LABELS. THE AORS LABELS DO NOT INCLUDE STATEMENTS AND THE ILLUSTRATION REQUIRED BY FMVSS NO. 208 FOR VEHICLES WITHOUT AORS.
OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V094000 on NHTSA.gov
Representative owner complaints: steering
1,073 reports, newest first. Show all
Steering, Apr 1, 2019
CONTINUED LOSS OF POWER STEERING WHILE DRIVING AND PARKED POSITIONS ON HIGHWAY, TOWN AND DRIVEWAY. RECALL WAS SAID TO HAVE BEEN DONE. PROBLEMS CONSIST ERROR MESSAGE ON RADIO, DASH, ERRATIC SHAKING OF STEERING COLOMN, LOSS OF POWER STEERING.
Steering, Mar 12, 2019
ELECTRIC POWER STEERING STOPPED WORKING WHILE I WAS ON THE HIGHWAY GOING 75MPH. TURNED CAR OFF THEN BACK ON AND IT DIDN'T HAVE AN ISSUE. THEN CUT OUT AGAIN WHILE I WAS DRIVING. ELECTRIC POWER STEERING HAS COMPLETELY FAILED
Steering, Air bags, Jan 29, 2019
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. WHILE TURNING THE STEERING WHEEL IN EITHER DIRECTION, A POPPING NOISE WAS PRESENT AND THE STEERING ABILITY SEIZED. UPON INSPECTION, IT WAS DISCOVERED THAT THE STEERING SHAFT PULLED OUT OF THE RACK. THE AIR BAG WARNING INDICATOR ILLUMINATED AFTER THE FAILURE. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. ELM CHEVROLET (301 E. CHURCH ST, ELMIRA, NY) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 157,000.
Steering, Jan 15, 2019
THE ELECTRONIC STEERING ASSIST WOULD FAIL WHILE DRIVING DOWN THE ROAD CAUSING THE VEHICLE TO LOOSE STEERING AND HAVE TO COME TO A STOP AND TURN VEHICLE OFF TO AVOID A CRASH. IT IS SCAREY AND DANGEROUS. MINE ISN'T THE ONLY MALIBU MAXX THAT HAS HAD THIS DANGEROUS PROBLEM.
Steering, Jan 11, 2019
THE STEERING ASSIST STOPS WORKING INTERMITTENTLY WITHOUT WARNING. I AM AN ELDERLY PERSON AND IT MAKES IT ALMOST IMPOSSIBLE TO STEER AT TIMES. IT DOESN'T NORMALLY DO IT WHEN GOING OVER 35 MPH. WHEN IT IS COLD OUTSIDE IT SEEMS TO DO IT MORE. I MAY JUST NOTICE IT MORE IN THE COLD BECAUSE I DRIVE SLOWER IN THE BAD WEATHER.
Steering, Jan 8, 2019
I PURCHASED MY USED 2004 CHEVROLET MALIBU NOVEMBER 23, 2016, THE DAY BEFORE CHRISTMAS. I WAS IN MOTION MERGING INTO PHILADELPHIA'S SCHUYKILL EXP WHEN MY STEERING WHEEL LOCKED IN PLACE FOR 2-3 SECONDS AS I WAS GOING OVER 55 MPH ON A SLIGHT TURN. I REMEMBER THE WRENCH LIGHTING UP IN THE TOP LEFT CORNER OF THE DASHBOARD AND READING 'POWER STEERING' MESSAGE ON MY THE SCREEN. THE STEERING WHEEL STIFFENS AS IF YOU HAVE THAT CAR THAT RUNS OUT OF STEERING FLUID. ANOTHER INCIDENT HAPPENED AGAIN WHILE IN MOTION, WHEN I WAS COMING DOWN PHILADELPHIA PIKE MERGING ON THE I-95 SOUTH. AGAIN, THE STEERING WHEEL LOCKS FOR A FEW SECONDS, READS POWER STEERING ON THE SCREEN WITH THE ORANGE WRENCH IN THE BOTTOM LEFT CORNER OF THE DASHBOARD. IT'S FRIGHTENING BECAUSE MY CAR COULD GO IN ANOTHER LANE AND HIT AN INCOMING CAR, OR VICE VERSA. THE FIRST TIME I COULDN'T PULL OVER TO RECOOPERATE BECAUSE THERE ARE NO SHOULDER LANES. I'M STILL HAVING THIS ISSUE AND IT HAS BEEN TWO YEARS. EVEN WHEN I AM PARALLEL PARKED SOMETIMES, MY STEERING WHEEL TIGHTENS AND I CAN'T FULLY TURN THE WHEEL. WHEN I CALLED CHEVROLET THE FIRST TIME, THE REPRESENTATIVE ASSURED ME THAT THERE WERE NO RECALLS SHOWN FOR MY VIN NUMBER. I WAS DIRECTED TO GO TO CHEVY AND TOLD ME IT WAS A STEERING COLUMN ISSUE. THE COST AND LABOR ITSELF IS STEEP. I CALL TO FOLLLOW UP AND THEY BASICALLY TOLD ME THEY COULD NOT DO ANYTHING ABOUT THE PROBLEM BECAUSE IT WAS OUT OF THE TIME FRAME FOR THE WARRANTY WHICH DOESN'T MAKE SENSE BECAUSE NO MANUFACTURER EXPECTS TO RECALL TO HAPPEN.. AND PAYING FOR THAT REPAIR IS NOT EVEN A GUARANTEE THAT IT WILL FIX THE ISSUE BASED ON THE OTHER COMPLAINTS.
Steering, Jan 5, 2019
STEERING WHEEL SHAKES AND POWER STEERING WON'T WORK
Steering, Vehicle speed control, Electronic stability control (ESC), Dec 17, 2018
WHEN DRIVING MY STEERING WHEEL WOULD BECOME HARD TO TURN AS IF I DON'T HAVE ANY POWER STEERING FLUID WHILE DRIVING THE CAR... AND THE ODOMETER WILL STOP WORKING AND THEN GO UP AND DOWN MY DRIVE CONTROL LIGHTS WILL STOP WORKING AND BELOW WHERE THE ODOMETER IS THE NUMBERS WILL TURN INTO SAYING ERROR THEN MY CAR WILL NOT CRANK PLEASE HELP ME WITH THIS PROBLEM
Steering, Nov 21, 2018
THERE WAS A RECALL AN THEY CLAIM IT WAS FIXED BUT EXACT THING ACCURSED AGAIN AN WE HAD PAY SEVEN HUNDRED AN SOME DOLLARS THE WOULDN'T COVER IT FOR POWER STERN
Steering, Nov 18, 2018
WAS TURNING INTO PARKING LOT LOST STEERING SYMBOL CAME ON DASH FOUND OUT FROM SOME ONE THAT WAS HELPING YOU CANT ADD FLUID IT IS ELECTRONIC POWER STEERING ASSIST SYSTEM SOMETHING IS WRONG I LOOKED UP IT SAID THERE WAS A RECALL AT ONE TIME FOR THIS BUT WHEN I CHECKED MY VIN IT DID NOT HAVE A RECALL THIS IS DANGEROUS I CANT BE IN TRAFFIC AND THIS HAPPEN MY PHONE NUMBER IS ([XXX]) I NEED THIS FIXED SO I CAN DRIVE I HAVE READ A LOT ABOUT THIS PROBLEM ON LINE MINE NEEDS TO BE FIXED I CANT AFFORD AN ACCIDENT OR THE REPAIRS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC *TR
Steering, Nov 4, 2018
POWER STEERING WARNING LIGHT. WHILE IN PARK.
Steering, Nov 2, 2018
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE POWER STEERING WARNING INDICATOR ILLUMINATED EVERY TIME THE VEHICLE WAS STARTED. THE CONTACT STATED THAT THE FAILURE STARTED TWO DAYS AGO. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 177,389. *TT CONSUMER STATED CHECK ENGINE LIGHT COMES ON WHEN THERE IS NO STEERING PUMP ON TOP.*JB
Steering, Engine, Oct 23, 2018
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. WHEN THE VEHICLE WAS STARTED, THE CHECK ENGINE AND POWER STEERING WARNING INDICATORS ILLUMINATED. ONCE THE VEHICLE WAS RESTARTED, THE INDICATORS WENT AWAY. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 27,972. *DT CONSUMER STATED MANUFACTURER NOTIFIED AND REPAIRS MADE. UPDATED 12/04/18*JB
Steering, Air bags, Oct 19, 2018, crash
TL* THE CONTACT OWNED A 2004 CHEVROLET MALIBU MAXX. WHILE DRIVING APPROXIMATELY 30 MPH, THE STEERING LOST POWER. IN AN ATTEMPT TO MAKE A LEFT TURN, ANOTHER VEHICLE CRASHED INTO THE FRONT DRIVER'S SIDE OF THE CONTACT'S VEHICLE. THE FRONT DRIVER'S AIR BAG EXPLODED AND STRUCK THE DRIVER IN THE FACE. THE DRIVER SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED TO A TOW YARD. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 104,000.
Steering, Power train, Other or unspecified, Aug 1, 2018
I RECEIVED AN EMAIL THIS MORNING 8/1/2018 STATING MY CAR MAY HAVE RECALLS ON IT. WHEN I CLICK THE LINK, I SEE THERE ARE 10 RECALLS ON THE 2004 CHEVY MALIBU. 10! OUT OF THOSE 10, I RECEIVED A NOTICE FOR ONLY TWO! I RECEIVED A NOTICE ABOUT MY POWER STEERING WHICH CAME AFTER MY WHEEL LOCKED UP ON MY WHILE I WAS DRIVING ON THE HIGHWAY! I CHECK THE LIST TODAY, AND MY CAR HAS HAD SEVERAL ISSUE THAT WERE LISTED: IGNITION, TRANSMISSION, BRAKES, ETC. I WAS NEVER NOTIFIED ABOUT THESE ISSUES. THESE NOTICES HAVE BEEN OUT SINCE 2014 AND I NEVER RECEIVED A NOTICE ABOUT THEM.
Steering, Jul 30, 2018
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING VARIOUS SPEEDS, THE STEERING WHEEL SEIZED. THE VEHICLE WAS TAKEN TO CHAPMAN CHEVROLET (6925 ESSINGTON AVE, PHILADELPHIA, PA); HOWEVER, THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE STEERING WHEEL FAILURE WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.
Steering, Jul 27, 2018
MY STEERING WHEEL LOCKS UP AS IF THE POWER STEERING IS EMPTY WHEN I MAKE FULL WIDE TURNS. I HAVE TO TURN THE CAR OFF AND BACK ON TO GET FULL ACCESSIBILITY TO THE STEERING WHEEL.
Steering, Jul 12, 2018
POWER STEERING KEEPS GOING OUT EVEN AFTER IT GOT FIXED DURING THE FIRST RECALL
Steering, Apr 17, 2018
MY MALIBU WOULD LOSE POWER STEERING WHILE DRIVING. IF I SHUT OFF THE CAR AND STARTED IT BACK UP, THE POWER STEERING WOULD BE BACK. I THEN GOT A RECALL NOTICE ABOUT THE ISSUE SO I TOOK IT IN. THE POWER STEERING WORKED FOR A COUPLE YEARS THEN SUDDENLY WENT OUT COMPLETELY. I CAN NOW NO LONGER GET THE ISSUE FIXED. IT'S WORSE THAN IT WAS. I DON'T KNOW WHAT OPTIONS I HAVE.
Steering, Apr 12, 2018
I LOSE POWER STEERING ASSIST WHEN I'M DRIVING. USUALLY HAPPENS WHEN THE CAR IS PARKED OR RANDOMLY WHILE I AM DRIVING.
Steering, Feb 13, 2018
THE PROBLEM STARTED AS THE STEERING WHEEL WOULD CONTINUOUSLY BOUNCE TO THE LEFT AND TO THE RIGHT, ALSO COULD BE DESCRIBED AS A WOBBLE WHEN THE CAR WOULD BE SITTING STILL. IF AND WHEN THIS WOULD HAPPEN WHILE DRIVING, IT WOULD PULL THE CAR TO THE LEFT OR TO THE RIGHT. ON TOP OF THIS "WOBBLE" THE POWER STEERING ONLY WORKS WHEN IT WANTS TO AND WILL QUIT WHILE DRIVING OR NOT BE WORKING WHEN YOU START THE CAR. THE VEHICLE WAS TAKEN TO THE DEALERSHIP ON THE PRETENCE THAT THE CAR SHOULD FALL UNDER RECALL 14V153000 RELEASED IN 2014. HOWEVER THE DEALER AND GM DISAGREES, EVEN THOUGH THE DEALER HAS CONFIRMED THE EPS IN THE STEERING COLUMN HAS GONE BAD AND THE POWER STEERING MOTOR/MODULE IS ALSO BAD AND NEEDS REPLACED.
Steering, Jan 26, 2018
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE ATTEMPTING TO PARK THE VEHICLE AT APPROXIMATELY 2 MPH, THE STEERING ABILITY SEIZED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN NEEDED REPLACEMENT. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Steering, Jan 22, 2018
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING 30 MPH, THE SERVICE ENGINE SOON WARNING INDICATOR ILLUMINATED AND THE POWER STEERING FAILED. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.
Steering, Dec 18, 2017
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 15 MPH, THE STEERING WHEEL BECAME LOOSE AND MADE A CLUNKING AND RATTLING NOISE. WHILE DRIVING OVER A BUMP AND MAKING TURNS, THE STEERING WHEEL RATTLED AND FELT VERY LOOSE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE RACK AND PINION AND INTERMEDIATE SHAFT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO A GM DEALER. NO FURTHER ASSISTANCE WAS OFFERED. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.
Steering, Dec 17, 2017
ELECTRONIC STEERING FAILURE ON RECAL REPLACEMENT PART, IN 2014 REPLACED UNDER RECALL STEERING COLUMN AND MODULE. 3 YEARS LATER FAILED AGAIN. REPLACEMENT PARTS APPEAR DEFECTIVE NOT TO FIX THE PROBLEM. REPLACED AT DEALERSHIP INDICATED RECAL REPLACED ONCE, NOW IS OWNERS RESPONSIBILTY TO REPLACE DEFECTIVE PARTS.