2004 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,697 owner complaints filed for this model year. This is the highest complaint count among 26 Malibu model years with reports.
Of the 2004 reports, 81 involved a crash and 15 involved a fire. 55 people were injured.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 19, 2004
SOME OF THESE PASSENGER VEHICLES HAVE AN ELECTRONIC CONTROL UNIT (ECU) THAT MAY CALCULATE A HIGHER THAN ACTUAL VEHICLE SPEED BECAUSE OF AN ERRATIC REAR-WHEEL SPEED SENSOR SIGNAL, AND CAUSE ABS ACTIVATION WHERE IT IS NOT NEEDED OR NEEDED ABS ACTIVATION TO BE EXTENDED DURING BRAKING AS THE VEHICLE SPEED DROPS TO ABOUT 3 MPH.
UNEXPECTED ABS ACTIVIATION COULD INCREASE STOPPING DISTANCE UP TO ABOUT 11 FEET DPENDING ON THE GRADE OF THE ROAD, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPROGRAM THE ABS CONTROLLER. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V190000 on NHTSA.gov
Seat belts, front, anchorageApr 16, 2004
ON CERTAIN PASSENGER VEHICLES, ANALYSIS OF AN A SIDE IMPACT CRASH TEST CONDUCTED BY THE NHTSA;S NEW CAR ASSESSMENT PROGRAM (NCAP) INDICATED THAT THE OUTBOARD ANCHORAGE OF THE DRIVER'S SEAT BELT COULD DISCONNECT BECAUSE OF CONTACT BETWEEN THE SEAT TRIM AND THE ANCHORAGE CONNECTOR WHEN THE SEAT WAS ADJUSTED TO ITS LOWEST POSITION.
IF THIS OCCURRED IN A CRASH, THE DRIVER COULD RECEIVE GREATER INJURIES.
DEALERS WILL INSERT A RETAINER ON BOTH THE DRIVER'S AND PASSENGER'S BELT ANCHORAGES. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V188000 on NHTSA.gov
Equipment, other, labelsFeb 24, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES THAT WERE NOT EQUIPPED WITH AN ADVANCED OCCUPANT RESTRAINT SYSTEM (AORS) HAVE DRIVER AND PASSENGER SIDE SUN VISORS WITH AORS LABELS. THE AORS LABELS DO NOT INCLUDE STATEMENTS AND THE ILLUSTRATION REQUIRED BY FMVSS NO. 208 FOR VEHICLES WITHOUT AORS.
OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V094000 on NHTSA.gov
Representative owner complaints: steering
1,073 reports, newest first. Show all
Steering, May 20, 2005
I HAVE A 2004 CHEVY MALIBU LS, IT IS NOT YET 18 MONTHS OLD AND I HAVE TO BRING IT IN FOR THE 2ND STEERING COLUMN REPLACEMENT THIS MONDAY. I HAVE DONE SOME RESEARCH AND HAVE FOUND OUT THAT HUNDREDS OF PEOPLE HAVE HAD SIMILAR/WORSE PROBLEMS WITH STERRING. SOME EXAMPLES INCLUDE COMPLETE LOSS OF STEERING, LOSS OF POWER STEERING, A LOUD THUDDING SOUND WHEN TURNING TH WHEEL DURING RIGHT TURNS (THIS IS WHAT MY CAR HAS BEEN DOING), I HAD MY 2ND STEERING COLUMN PUT IN MY CAR IN NOV 04, WHEN MY CAR WAS 10 MONTHS OLD, I NOW AM HAVING THE SAME PROBLEM/SOUND AGAIN AND NEED TO BRING IT IN FOR A 3RD STEERING COLUMN, MEANING IT CAME WITH A DEFECTIVE ONE, WAS EVIDENTLY REPAIRED WITH A DEFECTIVE ONE AND WHO KNOWS WHAT WILL HAPPEN 6 MONTHS FROM NOW. I AM VERY CONCERNED ABOUT THIS. I HAVE SPOKEN TO MY DEALERSHIP, FILED A COMPLAINT WITH CHEVY AND WAS TOLD BY BOTH THAT HAVE ONLY ISSUED "BULLETINS" FOR MECHANICS. I FEEL A RECALL SHOULD BE CONSIDERED AS THIS IS A VERY SERIOUS PROBLEM, LOSS OF STEERING CONTROL SHOULD NOT BE TAKEN LIGHTLY. SO, TO WRAP THIS UP, I HAD MY CAR FOR 10 MONTHS AND NEEDED A NEW STEERING COLUMN (11/04) NOW 6 MONTHS LATER I WILL BE GETTING ANOTHER. PLEASE LOOK INTO THIS DANGEROUSE DEFECT AND FEEL FREE CONTACT ME IF I CAN ASSIST ANY FURTHER.
Steering, Apr 29, 2005
SLOWED DOWN TO ABOUT 5 MPH TO MAKE A RIGHT TURN INTO PARKING LOT. COMPLETED 90 DEGREE TURN INTO PARKING LOT AND STARTED TO SLOW DOWN TO COME TO A STOP WHEN SHE FELT THE WHEEL STIFFEN (STEERING ' FELT OFF'); STARTED UP TO MAKE A 90 DEGREE RIGHT TURN (NEEDED TO MAKE A 90 DEGREE RIGHT TURN FOLLOWED BY A QUICK 90 DEGREE LEFT TURN). AS SHE TRIED TO TURN WHEEL, SHE COULD ONLY MOVE THE WHEEL FROM 12-1 O'CLOCK SO SHE JUST COASTED INTO A PARKING AREA (CAR COVERED A COUPLE OF PARKING SPOTS). STEPPED ON BRAKES AS SHE COASTED TO A STOP SINCE SHE FELT AS THOUGH SHE HAD NO STEERING. TOWED TO DEALER, WHO REPLACED STEERING SOLUMN AGAIN.
Steering, Apr 29, 2005
STEERING WHEEL OSCILLATED BACK AND FORTH WHILE VEHICLE WAS ON, BUT STOPPED; HAPPENED AGAIN WHILE BACKING OUT OF PARKING SPACE; ABOUT 5 MINUTES INTO 15 MINUTE DRIVE HOME (GOING 10 MPH); VEHICLE FELT LIKE IT WAS PULLING LEFT SO IT TOOK MORE STEERING EFFORT TO TURN WHEEL RIGHT; HAD STEERING COLUMN REPLACED AUGUST 19, 2004.
Steering, Apr 29, 2005
NOISY, GRINDING SOUND + STIFFNESS IN STEERING. HAVE HAD TO DEALER (JOHN KENNEDY CHEVROLET, SOUTHAMPTON, PA) 3 TIMES BEGINNING 2/15. 1ST DIAGNOSIS: UNDERINFLATED TIRES. RESULT: NO CHANGE. 2ND DIAGNOSIS: WORN STEERING COLUMN. ACTION: REPLACED COLUMN. RESULT: NO CHANGE. 3RD DIAGNOSIS: PROBLEM WITH STEERING RACK. ACTION: REPLACE RACK. RESULT: NO CHANGE. THIS PROBLEM ONLY HAPPENS WHEN THE AIR TEMPERATURE IS WARM (WON'T HAPPEN ON A COOL MORNING, BUT IS PRESENT AFTER SITTING IN THE SUN ALL DAY). IT SEEMS THAT WHEN THE METAL HEATS UP, IT EXPANDS & CAUSES BINDING. *AK
Steering, Air bags, Apr 6, 2005, crash
PROBLEMS WITH POWER STEERING AND AIR BAGS ON 2004 CHEVROLET MALIBU.***NO ANSWER REQUIRED***. *MR THE CONSUMER WAS INVOLVED IN AN ACCIDENT IN WHICH THE AIR BAGS DID NOT DEPLOY. WHILE DRIVING THE POWER STEERING STOPPED WORKING. *NM
Steering, Apr 6, 2005
THE STEERING COLUMN WAS REPLACED ON MY CAR TWICE SINCE I PURCHASED IT IN NOVEMBER OF 2003. I LOSE ALL ABILITY TO STEER AT 60 MPH AND HAVE TO STOP IMMEDIATELY. *AK
Steering, Equipment, Mar 25, 2005
OCCURENCE #1: WITH LESS THAN 2000 MI ON VEHICLE, IT LOST POWER STEERING WHILE DRIVING. THE MESSAGE CAME ON THE CONSOLE. TOWED TO DEALER WHO REPLACED STEERING COLUMN. OCCURRENCE #2: WITH APPROX. 5000 MI ON VEHICLE LOST POWER STEERING WHEN IN REVERSE EXITING PARKING SPACE. DASH LIGHT WENT ON AS WELL AS CONSOLE MESSAGE. TOWED TO DEALER. *AK
Steering, Mar 17, 2005
THE POWER STEERING LOCKS AND CAUSES THE VEHICLE TO PULL TO THE LEFT, MAKING IT DIFFICULT TO CONTROL THE VEHICLE. MANUFACTURER WAS CONTACTED FOR REPAIR, BUT THEY FAIL TO CORRECT THE PROBLEM.*AK
Steering, Air bags, Mar 14, 2005, crash
WHILE DRIVING ON AN ICY ROADWAY ON A DOWNHILL LEFT CRUVE I FELT THE STEERING UNEXPECTEDLY STIFFEN UP AS IF THE CAR HAD STALLED. BY THE TIME I APPLIED ENOUGH PRESSURE TO COMPENSATE THE CAR STARTED TO VEER TO THE LEFT, AND WOULD NOT RECOVER. IT CRASHED AND ROLLED OVER. ALSO, THE AIR BAGS DID NOT DEPLOY UNTIL WE WERE HANGING UPSIDE DOWN, EVEN THOUGH THE CAR HIT HARD IN THE FRONT. ALSO ONLY THE TWO FRONT AIR BAGS DEPLOYED NOT THE SIDE OR CURTAIN BAGS. THE CAR WAS A TOTAL LOSS. *AK
Steering, Mar 8, 2005
WHILE DRIVING AT LOW SPEEDS ELECTRIC STEERING FAILED THREE TIMES. AS A RESULT, THERE WAS A THUMPING NOISE WHEN ATTEMPTING TO TURN IN EITHER DIRECTION. *AK *TT
Steering, Feb 17, 2005
AS MY FAMILY AND I WERE DRIVING DOWN THE ROAD IN OUR NEW MALIBU MAXX THE CHECK ENGINE LIGHT CAME ON AND THE RADIO STATED POWER STEERING. I TRIED TO STEER THE MAXX BUT IT HAD NO POWER STEERING. I STOPPED TURNED THE CAR OFF AND RESTARTED IT AND IT STARTED WORKING. I CALLED THE DEALER AND THEY SAID THAT THEY WERE HAVING MAJOR TROUBLE WITH THE NEW MALIBU'S ELECTRIC ASSIST STEERING. THEY REPLACED THE COLUMN AND MOTOR. THAT LASTED ABOUT THREE MONTHS. I WAS DRIVING DOWN A MAJOR INTERSTATE EARLY ON A SUNDAY MORNING WHEN THE POWER STEERING WENT OUT AGAIN. THIS TIME SEVERELY JERKING THE STEERING WHEEL TO THE LEFT PUSHING ME INTO THE LEFT LANE OF TRAFFIC. HAD THIS BEEN MY WIFE ON HER WAY TO WORK MONDAY MORNING IN HEAVY TRAFFIC ON THIS INTERSTATE THERE WOULD HAVE BEEN A TERRIBLE ACCIDENT. WE ARE NOW ON THE THIRD STEERING COLUMN, NOW THE HEATING AND DEFROST CONTROL UNIT IS BAD, LEAVING US WITH NO HEAT OR DEFROST. NOT TO MENTION THE REAR SEATBELT GOT STUCK AND WOULDN'T MOVE. ALL BUT THE HEATING CONTROL HAVE BEEN FIXED (AT DEALER NOW) BUT WHERE WILL IT STOP???? MY FAMILY WORKS FOR GM AND I THINK I WILL BUY A FORD!!!!!!!! GM BETTER STAND UP AND ADMIT THERE IS A PROBLEM! EA04018_CAT *JB
Steering, Feb 10, 2005
THE STEERING ON THIS CAR IS SUBJECT TO REPEATED OSCILLATION AT IDLE, SLOW AND MODERATE SPEEDS. THE LONGER THE CAR IS DRIVEN ON ONE TRIP THE WORSE THE PROBLEM BECOMES. THIS HAS BEEN OCCURRING OVER A PERIOD OF TIME, BUT IT IS TO THE POINT THAT THE CAR IS NOT DRIVABLE. CHEVROLET HAS A SERVICE BULLETIN FOR THEIR SERVICE DEPARTMENTS, BUT NO CUSTOMER NOTIFIATIONS. THE SERVICE WRITER AT MY SERVICE DEALERSHIP, DAVE MCDERMOTT CHEVROLET, EAST HAVEN, CT, HAS SAME CAR, SAME PROBLEM AND REPLACED THE STEERING COMPONENTS BECAUSE SHE KNOWS OF THE PROBLEM. THE FAILURE TODAY (01/11) AND YESTERDAY (01/10) CAUSED THE STEERING TO LOCK UP AND A "WRENCH" IDIOT LIGHT DISPLAYED ON THE DASHBOARD. THAT WAS CORRECTED BY STOPPING THE CAR, PLACING IT IN PARK, TURNING THE IGNITION OFF AND THEN RESTARTING THE CAR. *AK ELECTRONIC POWER STEERING FAILURE. *SC
Steering, Engine and engine cooling, Feb 7, 2005
POWER STEERING WENT OUT WHILE DRIVING. CONSUMER TOOK VEHICLE TO THE DEALER ON 5 OCCASIONS, BUT DEALER WAS UNABLE TO RESOLVE THE PROBLEM. *AK THE SERVICE ENGINE SOON LIGHT ILLUMINATED. *TC *JB
Steering, Feb 3, 2005
WHILE DRIVING 25 MPH, THE VEHICLE LOST POWER STEERING. THE CONSUMER MANAGED TO DRIVE TO A AUTO SHOP. THE PROBLEM WAS REPAIRED. THE DEALERSHIP WAS NOTIFIED. PLEASE PROVIDE MORE INFORMATION. *JB
Steering, Jan 25, 2005
ON OR ABOUT 01/15/05 THE POWER STEERING GAME OUT WHILE DRIVING. THE ENGINE LIGHT CAME ON, CAR WAS TAKEN TO DEALER ON 01/17/05. DEALER CHANGED THE STEERING WHEEL COLUMN, VEHICLE WAS PICKED UP A DAY LATER. ON 01/21/05 STEERING GAVE OUT AS BACKING OUT OF THE DRIVE WAY AND ENGINE LIGHT CAME ON. CAR WAS TURNED OFF AND ON AND POWER STEERING WORKED AGAIN. CAR WAS TURNED BACK IN TO DEALERSHIP WHERE AFTER 3-4 DAY I WAS INFORMED THAT THERE WAS NO RECORD OF ANY DEFECTS. *NM
Steering, Seat belts, Jan 25, 2005
THE VEHICLE LOST POWER STEERING CONTROL WHILE DRIVING 25 MPH. THE VEHICLE WAS TOWED TO THE DEALER. THE DEALER INFORMED THE CONSUMER THAT THE POWER STEERING MODULE NEEDED TO BE REPLACED. *JB THE ADJUSTER ASSEMBLY ON THE PASSENGER SEAT BELT WAS REPLACED.
Steering, Jan 22, 2005
CAR HAD LEFT PULLING PROBLEM AT DELIVERY. SELLER SUGGESTED CAR HAVE 1000+ MILES BEFORE ATTEMPTING ALIGNMENT. CAR "REPAIRED" AT ANOTHER IN-TOWN DEALER UNDER WARRANTY. WITHIN 6-8 MOS., PROBLEM SET IN AGAIN, ESPECIALLY NOTICEABLE SIMPLY CRUISING FOR HOURS AT HIGHWAY SPEED. (NO "TORQUE STEER" OR "COUNTRY CROWN ROADS.") AFTER 3 HOUR DRIVE, COMPLAINED TO SELLING DEALER WHO REPLACED SENSOR (WHICH REQUIRED NEW COLUMN AND REPROGRAMMING SEVERAL MICROPROCESSORS ACCORDING TO MOST RECENT BULLETINS.) CAR SEEMED FINE FOR 1-2 MONTHS. AGAIN, STEERING SEEMS NOT TO CENTER ACCURATELY, AND GENERALLY PULLS LEFT. TIRES BEEN ROTATED, BALANCED, W/GOOD PRESSURE, ETC. SINCE I DRIVE TYPICALLY LEFT LANE WITH LEFT HAD (RIGHT HAND ON CELL PHONE OR MATERIALS) I NOW SUFFER "TENNIS ELBOW" AND HAVE HAD TO FAVOR MY LEFT--BEEN WEARING SPLINTS/ELBOW BRACES FOR 3 WEEKS. USED GM SATISFACTION PROCEDURE TO TALK TO ZONE REP. DEALER OPS MGR CALLS ME AND BECAUSE I ALLUDED TO DISCOMFORT AND MENTIONED KEEPING A PAPER TRAIL FOR MY ATTORNEY, THE ZONE REP REFUSES TO SPEAK OR ACT UPON THE MATTER "UNTIL WE HAVE INITIATED OUR LEGAL ACTION!" I JUST ASKED THEM TO FIX OR REPLACE THE CAR, WHICH I USE DAILY FOR BUSINESS. NOW I'VE BEEN CHALLENGED TO A LEGAL TUSSLE, AND THE CAR ISN'T RIGHT. *JB
Steering, Jan 20, 2005
THE ELECTRONIC STEERING IN MY 2004 MALIBU FAILED WHILE THE CAR WAS IN OPERATION. IT HAD BEEN JERKING WHILE I WAS DRIVING ON THE HIGHWAY. I TOOK IT IN AND THEY SAID IT WAS PROBABLY WATER/DAMPNESS CAUSING THE JERKING. THEN IT FAILED WHILE I WAS DRIVING AND THEY REPLACED THE PARTS UNDER WARRANTY. *JB
Steering, Suspension, Jan 18, 2005
2004 CHEVROLET MALIBU EXPERIENCED PROBLEMS WITH THE STEERING.***NO ANSWER REQUIRED***. *MR THE CONSUMER STATED THE VEHICLE PULLED TO THE LEFT WHEN HE WOULD TAKE OFF FROM A STOP AND IT WOULD DRIFT TO THE LEFT WHILE DRIVING. *JB
Steering, Jan 18, 2005
2004 CHEVROLET MALIBU SUFFERED POWER STEERING FAILURE.***NO ANSWER REQUIRED***. *MR *JB
Steering, Service brakes, Hydraulic, Jan 16, 2005
I OWN A 2004 CHEVROLET MALIBU. AT PRESENT TIME, I HAVE HAD TO HAVE THE STEERING COLUMN REPLACED TWICE, DUE TO INTERMITTENT POWER STEERING FAILURE AND A CONSTANT PULL TO THE LEFT. THE FIRST TIME WAS AT APPROXIMATELY 8800 MILES, THE SECOND TIME AT 17700 MILES. I HAVE ALSO HAD TO HAVE THE BRAKE ROTORS AND PADS REPLACED TWICE. THE BRAKES STILL MAKE A RUBBING NOISE IN THE RIGHT FRONT, HOWEVER THE DEALERS TELLS ME THEY CANNOT FIX THAT. THE CAR CURRENTLY HAS 18000 MILES ON IT. I STILL HAVE STEERING ISSUES, SUCH AS TWITCHES IN THE STEERING WHEEL AND THUNKS AND CLUNKS WHEN DRIVING. I AM VERY UNCOMFORTABLE DRIVING THE CAR BECAUSE I AM AFRAID THE STEERING WILL GO OUT AGAIN. *NM
Steering, Jan 15, 2005
MY WIFE WAS DRIVING WITH MY DAUGHTER ON BOARD,TRAVELING AT APPROXIMATELY 25 MPH PREPARING TO STOP AT APPROACHING TRAFFIC LIGHT,ALL OF A SUDDEN THE STEERING WHEEL "FROZE" AND WOULD NOT MOVE. WHEN SHE FINALLY STOPPED THE CAR,SHE TURNED THE ENGINE OFF. NEEDLESS TO SAY SHE WAS TERRIBLY FRIGHTENED. AFTER A FEW MINUTES SHE RESTARTED THE CAR AND THE STEERING WAS OK. I HATE TO THINK WHAT MIGHT HAVE HAPPENED IF SHE HAD BEEN ON THE EXPRESS SWAY AT THE TIME. NOW SHE IS AFRAID TO DRIVE HER OWN CAR. THE CAR IS A 2004 MALIBU. *NM
Steering, Jan 14, 2005
I WAS DRIVING IN TRAFFIC WHEN SUDDENLY WITHOUT WARNING A WARNING CAM ACROSS THE MESSAGE SCREEN SAYING POWER STEERING AND THE SERVICE LIGHT TURNED ON. I HAD LOST ALL POWER STEERING. I WAS ABLE TO MANUALLY FORCE THE VEHICLE OVER TO THE SIDE. I TURNED OFF THE CAR AND RESTARTED IT. WHEN I RESTARTED THE VEHICLE THE WARNINGS DISAPPEARED AND POWER STARING WORKING FINE UNTIL ABOUT 5-10 MINUTES LATER, ABOUT LESS THAN A 1/4 MILE TRAVELED POWER STEERING WENT OUT AGAIN. I CONTACTED MY DEALERS SERVICE DEPARTMENT AND THE SERVICE PERSON THERE NEW INSTANTLY WHAT IT WAS AND HE SAID THAT THE STEERING COLUMN HAD TO BE REPLACED. *JB
Steering, Jan 14, 2005
I WAS TURNING RIGHT ONTO A STREET AND THE CAR DIED. I TURNED IT BACK ON AND EVERYTHING SEEMED FINE. I THEN TURNED INTO MY OFFICE PARKING GARAGE AND AS I WAS GOING DOWN ONE OF THE LEVELS I NOTICED THE STEERING ACTING STRANGE. IT FELT LIKE IT WAS LOOSE OR NOT CATCHING. I WENT A LITTLE FURTHER AND THE POWER STEERING WENT COMPLETELY OUT. I HAD AN EXTREMELY HARD TIME GETTING INTO A PARKING SPACE BUT I DID. LATER IN THE MORNING WHEN A TOW TRUCK CAME TO PICK UP THE CAR, I GOT IN AND STARTED THE CAR AND THE POWER STEERING WAS WORKING. I LET THE TOW TRUCK TAKE THE CAR TO THE DEALERSHIP SINCE I WAS CONCERNED ABOUT THE POWER STEERING GOING OUT AND THE CAR DYING. IT IS AS THE DEALERSHIP AT THIS TIME. *JB
Steering, Jan 12, 2005
WHILE DRIVING AT ANY SPEED THE VEHICLE WOULD LOSE POWER STEERING INTERMITTENTLY, MAKING IT HARD TO STEER. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM.*AK