2004 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,697 owner complaints filed for this model year. This is the highest complaint count among 26 Malibu model years with reports.
Of the 2004 reports, 81 involved a crash and 15 involved a fire. 55 people were injured.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 19, 2004
SOME OF THESE PASSENGER VEHICLES HAVE AN ELECTRONIC CONTROL UNIT (ECU) THAT MAY CALCULATE A HIGHER THAN ACTUAL VEHICLE SPEED BECAUSE OF AN ERRATIC REAR-WHEEL SPEED SENSOR SIGNAL, AND CAUSE ABS ACTIVATION WHERE IT IS NOT NEEDED OR NEEDED ABS ACTIVATION TO BE EXTENDED DURING BRAKING AS THE VEHICLE SPEED DROPS TO ABOUT 3 MPH.
UNEXPECTED ABS ACTIVIATION COULD INCREASE STOPPING DISTANCE UP TO ABOUT 11 FEET DPENDING ON THE GRADE OF THE ROAD, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPROGRAM THE ABS CONTROLLER. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V190000 on NHTSA.gov
Seat belts, front, anchorageApr 16, 2004
ON CERTAIN PASSENGER VEHICLES, ANALYSIS OF AN A SIDE IMPACT CRASH TEST CONDUCTED BY THE NHTSA;S NEW CAR ASSESSMENT PROGRAM (NCAP) INDICATED THAT THE OUTBOARD ANCHORAGE OF THE DRIVER'S SEAT BELT COULD DISCONNECT BECAUSE OF CONTACT BETWEEN THE SEAT TRIM AND THE ANCHORAGE CONNECTOR WHEN THE SEAT WAS ADJUSTED TO ITS LOWEST POSITION.
IF THIS OCCURRED IN A CRASH, THE DRIVER COULD RECEIVE GREATER INJURIES.
DEALERS WILL INSERT A RETAINER ON BOTH THE DRIVER'S AND PASSENGER'S BELT ANCHORAGES. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V188000 on NHTSA.gov
Equipment, other, labelsFeb 24, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES THAT WERE NOT EQUIPPED WITH AN ADVANCED OCCUPANT RESTRAINT SYSTEM (AORS) HAVE DRIVER AND PASSENGER SIDE SUN VISORS WITH AORS LABELS. THE AORS LABELS DO NOT INCLUDE STATEMENTS AND THE ILLUSTRATION REQUIRED BY FMVSS NO. 208 FOR VEHICLES WITHOUT AORS.
OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V094000 on NHTSA.gov
Representative owner complaints
1,697 reports, newest first.
Other or unspecified, Mar 8, 2021, crash
I WAS DRIVING MY 2004 MALIBU CLASSIC , WHEN ALL THE VEHICLE , TURNED OFF ,CAUSING ME TO HIT THE VEHICLE IN FRONT OF ME AND THAT VEHICLE HITTING ANOTHER CAR , THERE WHERE 3 VEHICLE INVOLVED WITH INJURY'S, MY VEHICLE WAS TOLLED AND WAS SENT TO A TOW YARD , AT THE TIME OF THE INCIDENT I WAS WORKING AS A MAINTENANCE WORKER AND WOULD CARRY MY WORK KEYS WITH MY VEHICLE KEYS , NEVER WOULD HAVE THOUGHT IT WOULD HAVE TURNED THE IGNITION
Steering, Mar 5, 2021
RECALL # 14E044000, VIN# [XXX]. THE VEHICLE EXHIBITS STEERING ISSUES AS DESCRIBED IN 14E044000 AND DIAGNOSED BY A MECHANIC. BROUGHT VEHICLE TO THE CHEVROLET DEALER AND THEY STATE THERE ARE NO RECALLS BASED ON VIN. HOW TO DETERMINE SPECIFIC VINS THAT ARE IMPACTED? WAS DRVING ON 3/1/21 AND STEERING BECAME ERRATIC. TOOK VEHICLE TO MECHANIC IMMEDIATELY WHERE IT WAS DIAGNOSED. MECHANIC STATED THERE WAS A RECALL AND TO CONTACT CHEVROLET. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Steering, Feb 22, 2021
STEERING MECHANISM IS OUT CAN'T CONTROL CAR HAVE TO TURN IT OFF AND ON AND CONTINUES TO GO OUT WHILE DRIVING THE VEHICLE
Electrical system, Exterior lighting, Engine, Feb 5, 2021
WELL MY IGNITION SWITCH WENT OUT I REPLACE THAT.NOW IT'S SHORTAGES IN WIRING AND LIGHTS HEAT ON AN OFF SOMETIMES SHOCKS
Steering, Jan 30, 2021
DRIVING ON CITY STREETS AT APPROXIMATELY 35 MPH WHEN SUDDENLY THE POWER (ASSIST) STEERING GOES OUT...THE CHECK ENGINE LIGHT IS ILLUMINATING...THE RADIO SCREEN STATES 'POWER STEERING' AS AN AUDIBLE CHIME WAS HEARD.
Steering, Exterior lighting, Jan 20, 2021
FIRST, THE CAR ROUTINELY BURNS OUT TURN SIGNALS, AND OVERHEATS THE TURN SIGNAL TO THE POINT THAT IT MELTS THE HOUSING THTA THE LIGHT BULB SNAPS INTO. I HAVE HAD TO REPLACE THE HEADLIGHT HOUSING/LAMP WIRINGS HARNESS MULTIPLE TIMES ALONG WITH MANY LIGHT BULBS. SECOND, THERE IS A RECALL FOR THE ELECTRONIC POWER STEERING. MY PARTICULAR VIN WAS RECALLED FOR AN ELECTRONIC POWER STEERING SENSOR. THE POWER STEERING HAS GONE OUT ON ME WHILE DRIVING TWICE, SO I BROUGHT IT TO THE DEALER. THEY INDICATED THE ELECTRONIC POWER STEERING MOTOR NEEDS TO BE REPLACED,AND IS NOT COVERED UNDER AND RECALLS. THERE APPEARS TOBE NUMEROUS RECALLS ON GM VEHICLES RELATED TO THE ELECTRONIC POWER STEERING, AND REPLACING MOTORS FOR THAT MATTER, BUT THE DEALER HAS INDICATED THERE IS NO SUCH RECALL RELATED TO MY PARTICULAR VEHICLE/VIN. THIS SEEMS RATHER SUSPECT WITH THE NUMBER OF RECALLS RELATED TO THESE VEHICLES, AND FOR ME TO HAVE THE STEERING GO OUT, BUT MY PARTICULAR VEHICLE DOES NOT QUALIFY. I WAS DRIVING ON A CITY STREET WHEN IT WENT OUT ONCE. I MADE IT HOME SAFELY, ALBEIT VERY HARD TO TURN THE WHEEL, AND THEN THE POWER STEERING WORKED AFTER TURNING OFF THE VEHICLE AND BACK ON AGAIN. IT WENT OUT AGAIN IN THE PARKING LOT OF THE CAR DEALER WHEN DROPPING IT OFF THE BE LOOKED AT.
Electrical system, Other or unspecified, Engine, Jan 11, 2021
AFTER STARTING ENGINE, ENGINE WILL TURN OFF AND RADIO DISPLAY SCREEN WILL READ 'ENGINE POWER REDUCED.' ENGINE WILL NOT START FOR SEVERAL MINUTES, BUT THE LIGHTS, RADIO, DASH LIGHTS AND EVERYTHING WILL STILL WORK. THIS HAS HAPPENED IN MY DRIVEWAY. THE FIRST TIME THIS EVER HAPPENED I WAS ON A BUSY MAIN ROAD AT A STOP LIGHT IN THE LEFT TURN LANE. THE CAR SHUDDERED AND THE ENGINE LOST POWER. AGAIN, THE DISPLAY SCREEN DISPLAYED THE SAME MESSAGE. THE CAR WAS ROLLING BACKWARDS AND WOULD NOT ACCELERATE. AFTER SEVERAL ATTEMPTS THE ENGINE DID START AGAIN. THANKFULLY IT WAS 6:00 AM AND I WAS ON MY WAY TO WORK SO THERE WAS VERY LIGHT TRAFFIC.
Steering, Engine, Dec 16, 2020
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING AT LOW SPEEDS, THE STEERING WHEEL WAS LOOSE. THE CHECK ENGINE AND POWER STEERING WARNING LIGHTS WERE ILLUMINATED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE VEHICLE WAS TAKEN TO SERRA CHEVROLET 7850 US-64, MEMPHIS, TN 38133, (901) 328-9262) WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS IN BAD CONDITION. THE DEALER DECLINED TO COMPLETE THE RECALL REPAIR. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 225,000.
Steering, Suspension, Electrical system, Nov 16, 2020
ELECTRICAL WIRES/COMPONENTS ISSUES, INSTRUMENT CLUSTER LIGHTS NOT TURNING ON, VEHICLE WITH A WRENCH INDICATOR LIGHT COMES ON & OFF, TRACTION CONTROL WITH A SLASH ON TC INDICATOR LIGHT COMES ON & OFF (TC/), WHEN MY CAR IS RUNNING AN IDLING OR PARKED OR IDLING AT A STOP LIGHT OR DRIVING IN A CERTAIN SPEED LIMIT THE STEERING WHEEL SHACKS/SHUDDERS REPEATEDLY MOVING ON ITS OWN ONCE IN A AWHILE BUT NOW IT CONSTANTLY GETTING WORSE LASTING LONGER, ENGINE LIGHT STAYS ON EVEN AFTER I REPLACED THE PARTS OBDLL SCANNER SAY WHAT TO FIX & REPLACE, OWNED THE CAR OVER A 1 YEAR AN BUILD KNOWLEDGE ABOUT THE CAR AND GOOGLE RECALLS AFTER OWNING IT. I BELIEVE IT'S (POWER STEERING WHEEL COMPONENTS OR POWER STEERING WHEEL ASSIST MOTOR) I WAS DRIVING IN THE FREEWAY WITH MY BABIES GOING 65 SPEED LIMIT & I LITERALLY SEEN LIFE FLASHED BEFORE MY EYES WHEN THE STEERING WHEEL WON'T TURN/LOCKS UP IN A BUSY FREEWAY. IT WAS BEYOND THE WORSE EXPERIENCE OF MY LIFE BECAUSE MY BABIES IS IN THE CAR WHEN IT HAPPENED, I DON'T EVER WANT IT TO HAPPEN AGAIN EVER OR TO ANYONE ELSE. PLEASE & THANK YOU IF YOU CAN FIX IT, IT'S OUR ONLY TRANSPORTATION FOR MY SPOUSE & BABIES. AN ONE MORE OTHER THING IS "I DON'T KNOW IF IT'S A PART OF IT THE THROTTLE BODY MALFUNCTION". I HOPE THAT'S ENOUGH & ACCURATE INFORMATION ABOUT IT
Other or unspecified, Oct 17, 2020, crash
ON 01/14/2012 I WAS DRIVING A 2004 MALIBU CLASSIC IN WHICH I ENDED UP IN A CRASH INVOLVING 3 VEHICLES, I WAS DRIVING ON A STREET ABOUT 30 MILES PER HOUR WHEN MY MALIBU HAD SUDDENLY TURNED OFF WITHOUT POWER STEERING AND BREAKS I HIT THE CAR IN FRONT OF ME, THEN THAT CAR HIT THE CAR IN FRONT OF HIM, MY 2004 MALIBU WAS TOTALED, THE INSURANCE COMPANY, WAS A TOTAL LOSS, AT THE TIME I WAS TICKETED FOR FOLLOWING TOO CLOSELY, HOWEVER I KNEW THAT THIS MALIBU HAD LOSS POWER CAUSING THE ACCIDENT
Steering, Sep 20, 2020
IT FEELS AS THOUGH THE STEERING IS LOOSENING. ALIGNMENT IS OFF AS WELL. BOTH ISSUES BEGAN ABOUT THE SAME TIME. A DULL CLUNKING SOUND CAN BE HEARD WHEN TURNING RIGHT. THIS CAR APPEARS TO HAVE ALREADY HAD THE STEERING REPLACED FROM THE 2014 RECALL BUT I BELIEVE THE REPLACEMENT PARTS ARE ALSO DEFUNCT AND SHOULD AND WILL BE RECALLED AGAIN. IT IS NOT SEEMINGLY DEPENDENT ON SET RPM OR MPH TO MAKE THE NOISE OR FEEL LOOSE IN MY HANDS. IT IS INTERMITTENT AND UNPREDICTABLE. CRUISE CONTROL STILL WORKING, EPS LIGHT NOT LIT. STRUTS ARE GOING SO MAY BE THE ISSUE. JUST IN CASE IT IS THE POWER STEERING HAVING NOT PROPERLY BEEN REPAIRED AFTER THE RECALL, OR REPAIRED WITH SHODDY PARTS, I THOUGHT IT BEST TO REPORT THE ISSUE. LIVES WERE LOST TO THE IGNITION SWITCH FAILURES FROM CHEVY, LUCKILY I PULLED INTO A SHOP IMMEDIATELY AFTER MY CAR SHUT OFF THE FIRST TIME AND GOT IT REPAIRED. MONTHS LATER PEOPLE WERE DYING. FRIENDS OF MINE. NOT ME. I TRUSTED MY GUT. I KNEW THAT WAS DANGEROUS AND I HAVE THE SAME INCLINATION NOW WITH THIS ISSUE.
Steering, Wheels, Electronic stability control (ESC), Sep 4, 2020
WHILE DRIVING CAR STEERING WHEEL STARTED TO MAKE A CLICKING SOUND BOTH LEFT AND RIGHT THEN WHEN I STOPED CAR BATTERY NEEDED TO BE JUMPED STARTED BECOME HARD TO CONTROL CAR AND IT SEEMED AS IF CAR WANTED TO LOSE POWER I WAS ON WATERMAN AND BASELINE. ON THE STREET WHEN IT BEGAN..07/15/2020 I HAD RECALL N140226 14116 WITH A CHEVY MANUFACTURER MALIBU DEALERSHIP
Exterior lighting, Sep 3, 2020
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE PEDAL WAS DEPRESSED HOWEVER, THE BRAKE LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE MECHANIC DETERMINED THAT THE BRAKE MODULE NEEDED TO BE REPLACED. PORTER CHEVROLET (414 E CLEVELAND AVE, NEWARK, DE 19711) WAS CONTACTED AND INFORMED THAT THE FAILURE NEEDED TO BE REPAIRED OUT OF POCKET. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V252000 (SERVICE BRAKES, HYDRAULIC, ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT SUBJECTED TO ANY RECALLS. THE FAILURE MILEAGE WAS APPROXIMATELY 169,000.
Steering, Aug 14, 2020
THERE HAS ALREADY BEEN A RECALL THAT THEY SAY WAS FIXED. HOWEVER IT IS DOING THE EXACT SAME THING NOW.I HAVE PAID TO FIX IT AND IT HAD A RECALL. WHAT HAPPENS IS YOU R JUST DRIVING AND ALL OF A SUDDEN THE POWER STEERING GOES OUT. YOU CAN BARELY STEER THE CAR TO GET IT OFF THE ROAD. I DO NOT HAVE THE MONEY TO KEEP FIXING THE SAME PROBLEM OVER AND OVER. IT IS DOING IT NOW.. THIS WILL HAPPEN ANYWHERE CITY, HIGHWAY. LITERALLY ANYWHERE YOU MIGHT BE. IT HAS HAPPENED NUMEROUS TIMES BUT I PUT THE LAST DATE IT HAPPENED. I HAVE PRETTY MUCH HAD TO STOP DRIVING THE CAR.
Seat belts, Seats, Jul 30, 2020
THE DRIVER SIDE SEAT THAT IS WELDED TO THE FRAME OF THE CAR HAS BROKE. THE RIGHT SIDE OF MY DRIVERS SIDE SEAT NOW COLLAPSES WHEN DRIVING WHICH IS EXTREMELY DANGEROUS NOT TO MENTION THE SEATBELT IS ATTACHED TO THE RIGHT SIDE OF THE SEAT AND BUCKLED INTO IT WHICH IS NOW COLLAPSED WHICH COULD CAUSE A MAJOR ISSUE IF I WAS TO EVER GET INTO AN ACCIDENT. I HAVE DONE SOME REASEARCH ONLINE AND THIS APPEARS TO BE A COMMON ISSUE AMONGSTS MOST 2004 MALIBU OWNERS. I AM THE SECOND OWNER AND I GET THE CAR IS CLOSE TO BEING 20 YEARS OLD BUT MINE ONLY HAS 60K MILES THE DRIVERS SEAT WELD SHOULD NOT JUST DETACH AND COLLAPSE WHILE DRIVING ON A PRACTICALLY BRAND NEW CAR. NOT TO MENTION I AM AN AVERAGE SIZED MAN 200 LBS 5 FOOT 7 ON TOP OF THAT I ENQUIRED TO FIX IT AT MY LOCAL CHEVROLET DEALER AND IT WILL COST WELL OVER 1000 DOLLARS BASED ON A VERBAL ESTIMATE. I CAN JERRY RIG THE SEAT TO NOT COLLAPSE BUT THAT DOESNT STOP THE FACT THAT GOD FORBID IM IN AN ACCIDENT MY DRIVERS SEAT COULD POTENTIALLY BECOME DETACHED HURLING MYSELF AND THE SEAT INTO THE WINDOW CAUSING SEVERE BODLY HARM OR WORSE DEATH. PLEASE LOOK INTO THIS AS IM SURE MANY OTHER PEOPLE HAVE THIS SAME PROBLEM IT IS A FAULTY WELD IN THE DRIVERS SEAT AND NEEDS TO BE ADRESSED BY THE MANUFACTURER CHEVROLET
Electrical system, Exterior lighting, Electronic stability control (ESC), Jul 8, 2020
HAD TO REPLACE HEAD LIGHT BULBS HAS MELTED PLASTIC COVER DASHBOARD HAS WARNING LIGHTS THAT COME ON AND STAY ON
Steering, Suspension, Electronic stability control (ESC), Jul 8, 2020
THE DASH HAS ABS, TCH AND SECURITY LIGHT COMES SHORTLY AFTER CAR HAS BEEN STARTED WITH IN SCOUND COMES A BEEPING SOUND WERE ALL THREE LIGHTS STAY ON UNTIL ENGINE IS CUT OFF. THE LIGHT BULBS HAS MELTED PLASTIC COVER ON THE FRONT TURN SIGNAL/PARK LAMP DRL. WHEN SPEED IS INCREASING ON HIGH WAY FREE WAY CAR TENDS TO PULL LEFT ON ITS OWN
Power train, Jun 17, 2020
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT WHILE MAKING A LEFT TURN THE VEHICLE SHIFTED INTO NEUTRAL INDEPENDENTLY WITHOUT WARNING. THE CONTACT DEPRESSED THE BRAKE PEDAL TO STOP THE VEHICLE. THE CONTACT ATTEMPTED TO MANUALLY SHIFT THE VEHICLE INTO PARK HOWEVER, THE TRANSMISSION FAILED TO ENGAGE. THE CONTACT PUSHED THE VEHICLE OVER TO THE SIDE OF THE ROADWAY. THE VEHICLE WAS TOWED TO MIDWAY CHEVROLET (2323 W BELL RD, PHOENIX, AZ) WHERE IT WAS DIAGNOSED AND DETERMINED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN) AS A POSSIBLE SOLUTION TO THE FAILURE, HOWEVER THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS CONTACTED HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Electrical system, Jun 3, 2020
THE ANTI THEFT GAS CUT OFF FEATURE HAS RENDERED MY VEHICLE UNABLE TO START. I HAVE TRIED MANY METHODS BUT THE PROBLEM PERSISTS. IT STARTS WHEN IT WANTS TOO, BUT NOT WHEN I DO. *TR
Steering, May 28, 2020
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE REVERSING OUT OF A PARKING LOT, THERE WAS AN ABNORMAL SOUND COMING FROM THE STEERING. THE VEHICLE WAS TAKEN TO JOHN AMATO (8301 N 76TH ST, MILWAUKEE, WI 53223) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE STEERING SHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14E044000 (STEERING) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 56,245. INVALID VIN.
Steering, Mar 11, 2020
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE ATTEMPTING TO MAKE TURNS THERE WAS RESISTANCE IN THE STEERING WHEEL. THE CONTACT STATED THAT THE STEERING WHEEL WOULD RETURN TO THE INITIAL POSITION. PHIL LONG FORD OF MOTOR CITY LOCATED AT (1212 MOTOR CITY DR, COLORADO SPRINGS, CO 80905 (844)237-2169, STATED THAT THE VEHICLE WAS NOT SUBJECTED TO A RECALL. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER AN UNKNOWN RECALL BY THE FORMER OWNER OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 148,000.
Steering, Power train, Feb 24, 2020
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE STEERING WHEEL INDEPENDENTLY TURNED TO THE LEFT WITHOUT WARNING. THE VEHICLE WAS TURNED OFF AND BACK ON BUT FAILED TO FIX THE ISSUE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE RACK AND PINION DETACHED FROM THE SUBFRAME AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT ONLY THE BUSHING WAS REPLACED AND NOT THE RACK AND PINION. IN ADDITION, THE CONTACT STATED ON ANOTHER OCCASION THE VEHICLE FAILED TO SHIFT TO REVERSE OR GO INTO FORWARD GEAR WHILE IN THE MIDDLE OF THE ROAD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE SHIFT CABLE WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 157,000.
Steering, Jan 24, 2020
WHEN I ACCELERATE TO GET ONTO THE FREEWAY AND PUSH ON THE GAS THE CHECK LIGHT WITH THE TOOL WILL COME ON AND I AM UNABLE TO STEER MY CAR AND THE STEERING LOCKS. IT ISN'T UNTIL I EASE UP OFF THE GAS PEDAL DOES IT STOP. THIS HAS ALMOST CAUSED AN ACCIDENT AS I WAS UNABLE TO CONTROL MY CAR.
Steering, Electrical system, Jan 17, 2020
POWER STEERING FAILS UNDER HARD ACCELERATION. WHEN THIS OCCURS THE CHECK ENGINE LIGHT COME ON AND THE STEERING HAS NO ELECTRIC ASSIST. THIS CONTINUES UNTIL THE ACCELERATION IS REDUCED. AFTER REDUCED ACCELERATION THE CHECK ENGINE LIGHT GOES OFF THE THE POWER STEERING RETURNS TO NORMAL. THIS OCCURS INTERMITTENTLY, BUT TYPICALLY ON A FREEWAY ON RAMP WHILE GETTING UP TO SPEED AND TRYING TO MERGE WITH TRAFFIC.
Other or unspecified, Jan 5, 2020
MY THEFT LIGHT CAME ON A MONTH AFTER THE IGNITION WAS REPAIRED DUE TO RECALL. IT IS ALWAYS ON NOW. I HAVE REPLACED THE FUEL PUMP, SPARK PLUGS, AND TIMING CHAIN. MY CAR STILL WONT START AFTER ALL OF THAT AND THE THEFT LIGHT IS STILL ON. I HAVE BEEN WITHOUT A CAR FOR 2 MONTHS NOW DUE TO IT NOT STARTING. IT WILL ROLL OVER BUT NOTHING MORE HAPPENS.WHEN ALL OF THIS HAPPENED IT WAS STATIONARY AND IT WAS PARKED IN A PARKING LOT WHERE I WORK.