2004 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,697 owner complaints filed for this model year. This is the highest complaint count among 26 Malibu model years with reports.
Of the 2004 reports, 81 involved a crash and 15 involved a fire. 55 people were injured.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 19, 2004
SOME OF THESE PASSENGER VEHICLES HAVE AN ELECTRONIC CONTROL UNIT (ECU) THAT MAY CALCULATE A HIGHER THAN ACTUAL VEHICLE SPEED BECAUSE OF AN ERRATIC REAR-WHEEL SPEED SENSOR SIGNAL, AND CAUSE ABS ACTIVATION WHERE IT IS NOT NEEDED OR NEEDED ABS ACTIVATION TO BE EXTENDED DURING BRAKING AS THE VEHICLE SPEED DROPS TO ABOUT 3 MPH.
UNEXPECTED ABS ACTIVIATION COULD INCREASE STOPPING DISTANCE UP TO ABOUT 11 FEET DPENDING ON THE GRADE OF THE ROAD, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPROGRAM THE ABS CONTROLLER. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V190000 on NHTSA.gov
Seat belts, front, anchorageApr 16, 2004
ON CERTAIN PASSENGER VEHICLES, ANALYSIS OF AN A SIDE IMPACT CRASH TEST CONDUCTED BY THE NHTSA;S NEW CAR ASSESSMENT PROGRAM (NCAP) INDICATED THAT THE OUTBOARD ANCHORAGE OF THE DRIVER'S SEAT BELT COULD DISCONNECT BECAUSE OF CONTACT BETWEEN THE SEAT TRIM AND THE ANCHORAGE CONNECTOR WHEN THE SEAT WAS ADJUSTED TO ITS LOWEST POSITION.
IF THIS OCCURRED IN A CRASH, THE DRIVER COULD RECEIVE GREATER INJURIES.
DEALERS WILL INSERT A RETAINER ON BOTH THE DRIVER'S AND PASSENGER'S BELT ANCHORAGES. OWNER NOTIFICATION BEGAN ON JUNE 16, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V188000 on NHTSA.gov
Equipment, other, labelsFeb 24, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES THAT WERE NOT EQUIPPED WITH AN ADVANCED OCCUPANT RESTRAINT SYSTEM (AORS) HAVE DRIVER AND PASSENGER SIDE SUN VISORS WITH AORS LABELS. THE AORS LABELS DO NOT INCLUDE STATEMENTS AND THE ILLUSTRATION REQUIRED BY FMVSS NO. 208 FOR VEHICLES WITHOUT AORS.
OWNERS WILL BE SENT REPLACEMENT LABELS WITH INSTRUCTIONS ON HOW TO INSTALL THEM. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 04V094000 on NHTSA.gov
Representative owner complaints
1,697 reports, newest first.
Steering, Electrical system, Sep 9, 2012
IN JULY 2011 THE POWER STEERING WENT OUT. ABOUT A WEEK LATER IT STARTED GOING OUT WHILE DRIVING. HAD THE STEERING COLUMN, AND RACKET AND PINION REPLACED, AND THE THEN THE RADIO STOPPED PLAYING CDS, AND THE SEAT BELT LIGHT CONSTANTLY STAYS ON EVEN IF YOU HAVE THE SEAT BELT ON. *TR
Seats, Sep 8, 2012
DRIVER'S SEAT WELD FAILED AND SEAT SHIFTED DOWN AND DROPPED TO THE RIGHT. ALSO EFFECTED SEAT ADJUSTMENT. ROCKED BACK AND FORTH ON THE FRAME. SEAT HAD TO BE REPLACED, COULD NOT BE REPAIRED. *TR
Steering, Sep 4, 2012
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE POWER STEERING WARNING LIGHT ILLUMINATED AS THE STEERING BECAME HARD TO TURN. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC, WHICH LOCATED THE FAILURE AT THE STEERING COLUMN. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 86,200.
Electrical system, Aug 26, 2012
MY 2004 CHEVY MALIBU KEEP SHUTTING OF AT VARIOUS TIMES .THE ALARM KEEP ENGAGING AND DISABLES THE CAR .THIS HAS HAPPENED 5 TIMES IN THE LAST 2 MONTHS .I HAVE BEEN READING AND EVEN ON THE COMPLAIN SITE IT SEEMS TO BE A PROBLEM .THIS IS VERY DANGEROUS BECAUSE I HAVE READ THAT THIS COULD HAPPEN WHILE THE CAR IS IN MOTION .I HAVE LOOKED AN THIS IS A VERY EXPENSIVE TASK . LIKE I SAID I AM NOT THE ONLY ONE WHO IS HAVING THIS PROBLEM .I ALSO ASKED CHEVY AND THEY SAY THERE IS NOTHING TO BE DOME IT IS ALL WEAR AND TEAR THE CAR .I HOPE YOU CAN HELP ME AND THE OTHERS OUT THERE WITH THE SAME PROBLEM . THANKS *TR
Steering, Aug 16, 2012
AS MY SON WAS DRIVING, THE POWER STEERING WENT OUT AND IT WAS VERY DIFFICULT TO STEER. AFTER TURNING OFF THE CAR AND RESTARTING, THE POWER STEERING CAME BACK ON. THIS HAS HAPPENED TWICE. *TR
Steering, Aug 7, 2012
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AS THE FAILED POWER STEERING MESSAGE APPEARED ON THE STEREO DISPLAY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THERE WAS A VOLUNTARY RECALL FOR THE FAILURE BUT STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
Seats, Jul 31, 2012
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE DRIVER SEAT LEANED TO THE SIDE WHEN THE DRIVING. THE CONTACT STATED THAT THE BRACKET THAT HELD THE SEAT TO THE FRAME WAS FRACTURED AND CAUSED THE SEAT TO LEAN. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER OR CALL THE MANUFACTURER. THE FAILURE MILEAGE WAS 151,000.
Electrical system, Jul 29, 2012
I WAS DRIVING ABOUT 45 MILES WHEN THE CAR CUT OFF WITH NO WARNING,WHEN THE CAR CAME TO A COMPLETE STOP I WAS ABLE TO RESTART THE CAR .THIS HAS HAPPENED 7 DIFFERENT TIMES . MY SON THOUGHT I NEEDED A TUNE UP, I TOOK THE CAR TO THE DEALER,I WAS TOLD IT WAS ELECTRICAL BUT DIDN'T KNOW WHAT WAS CAUSING IT. *JS
Steering, Jul 25, 2012
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE POWER STEERING WARNING LIGHT ILLUMINATED AND THE STEERING WHEEL BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO A MECHANIC WHO RESET THE STEERING AND CORRECTED THE FAILURE FOR THREE WEEKS BEFORE RECURRING. THE DEALER WAS NOTIFIED WHO ADVISED THAT THERE WERE NO RECALLS FOR THE VEHICLE FOR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 67,356.
Steering, Jul 22, 2012
STEERING ON VEHICLE BECAME DIFFICULT TO TURN TO THE RIGHT, BUT A LOT OF PLAY IN THE WHEEL WHEN TURNING LEFT. SAME SITUATION HAPPENED OFF AND ON FOR APPROXIMATELY ONE WEEK. ON 7/21/12 WHILE DRIVING THE VEHICLE, THE CONSOLE MADE A "DINGING" SOUND AND INDICATED THAT THERE WAS A PROBLEM WITH THE POWER STEERING AND SIMULTANEOUSLY IT LOST ALL EASE OF STEERING. IT HAD ABSOLUTELY NO POWER STEERING CAPABILITY. IT WAS VERY FRIGHTENING TO NOT HAVE CONTROL OF THE VEHICLE AND HAVING TO STRUGGLE TO GET THE CAR TO A SAFE PLACE OUT OF THE ROAD THAT I WAS DRIVING ON. *TR
Seats, Jul 20, 2012
FRONT DRIVER'S SEAT IS COMPLETELY LOOSE ON RIGHT SIDE. NOT SECURED DOWN, CANNOT ADJUST AND TILTS WHEN YOU MAKE A TURN OR GO AROUND A CURVE. HAVE TO DRIVE WITH SEAT ALL THE WAY DOWN WHICH IS HARD BECAUSE I AM A SHORT PERSON. WHEN I GET OUT OF THE CAR THE WHOLE SEAT ACTS LIKE IT IS JUST CONNECTED ON LEFT SIDE AND COMES UP ON RIGHT SIDE. I HAD SOMEONE LIFT THE SEAT WHILE I LOOKED UNDERNEATH. SOMETHING IS BROKE. BRACKET WILL NOT HOLD SEAT UP, JUST FALLS BACK DOWN AND SEAT WILL NOT STAY IN PLACE. ALSO A SAFETY ISSUE WITH SEAT MOVING AND NOT SECURE. IN READING OTHER COMPLAINTS, I FEEL THAT I HAVE THE SAME ISSUE OF A BROKEN FRAME WHICH IS A DEFINITE DEFECT. I AM NOT REAL HEAVY AND THAT SEAT SHOULD NOT HAVE BROKE. I HAVE HAD THIS CAR FOR OVER THREE YEARS AND THIS HAS BEEN MY PERSONAL VEHICLE. HOWEVER, I DO NOT FEEL IT IS SAFE TO DRIVE LIKE THIS, BUT HAVE NO CHOICE! OH! THESE ARE POWER SEATS. THANK YOU. *TR
Visibility, Structure, Jul 20, 2012
REAR WINDOW OF VEHICLE APPARENTLY BROKEN BY TRUNK LID OPENING TOO FAR. TRUNK LID OPENED TOO FAR DUE TO TWO RUBBER TRUNK LID STOPS HAD BOTH PREVIOUSLY FALLEN FROM THEIR DESIGNED LOCATION. CHEVROLET DEALER STATES THESE PARTS WERE A PROBLEM AND ARE NO LONGER AVAILABLE-NEW PARTS HAVE BEEN DESIGNED AND WILL COST APPROXIMATELY $100 IF PURCHASED. *TR
Seats, Jul 13, 2012
SAFETY ISSUE WITH DRIVER'S SEAT. TILTS AND LEANS, BROKEN WELD. THIS IS A SAFETY WARRANTY AND SHOULD BE FIXED BY THE MANUFACTURER. *TR
Steering, Jul 13, 2012
POWER STEERING GOES OUT DURING SUMMER MONTHS; PAID TO REPAIR 8/2011; WORKS OK DURING WINTER, BUT POWER STEERING GOES OUT IN SUMMER MONTHS. THIS IS DANGEROUS. ALMOST HAD SEVERAL ACCIDENTS. *TR
Exterior lighting, Seats, Service brakes, Jul 12, 2012
THE DRIVER SEAT ON THIS CAR HAS COME OFF THE RAILS ON RIGHT SIDE CAUSING IT TO TILT. IF THE SEAT IS NOT MOVED TO THE LOWEST SETTING THE TILTS WITH THE MOVEMENT OF THE CAR. I HAD THE SEAT REPAIRED ONCE; IT FAILED AGAIN AFTER ABOUT 6 MONTHS. AT THE SAME TIME I HAD THE EMERGENCY BRAKE REPAIRED. WHEN SETTING THE BRAKE, I HEARD A LOUD BANG. THE REPAIR FAILED ABOUT 2 MONTHS AGO FOR THE SECOND TIME. I AM ALSO GOING THROUGH NEW BRAKES ON THIS CAR AT AN ALARMING RATE - THREE BRAKE REPLACEMENTS ALREADY AND THE CAR HAS 90,000 MILES. THE CAR IS AGAIN BEGINNING TO SHIMMY/SHUDDER WHEN GOING DOWN STEEP HILLS AND THE BRAKES ARE APPLIED. THE CAR SEEMS NOT TO SLOW DOWN AT ALL (I.E. SHIFTING GEARS) WHEN GOING DOWN HILL OTHER THAN BY THE BRAKES - IT FEELS LIKE A FREE FALL. THE SIGNALS, HEADLIGHTS, TAILLIGHTS AND BRAKE LIGHTS ALSO NEED FREQUENT REPLACEMENT. I TYPICALLY HAVE TO REPLACE AT LEAST ONE OF THESE AT EACH OIL CHANGE AND HAVE ON SEVERAL OCCASIONS NEEDED TO MAKE REPLACEMENTS BETWEEN OIL CHANGES. I WOULD ESTIMATE THE HEADLIGHTS/BLINKERS HAVE BEEN REPLACED AT LEAST A DOZEN TIMES. THE REAR LIGHTS HAVE BEEN REPLACED PERHAPS TEN TIMES. CURRENTLY THE THIRD BRAKE LIGHT IS OUT AND CANNOT BE REPAIRED WITHOUT TAKING OFF THE INTERIOR COVER OF THE CAR TO ACCESS THE WIRING - THE BULB IS NOT THE PROBLEM. *TR
Seats, Jul 12, 2012
WHILE ADJUSTING THE SEAT UP, IT SUDDENLY DROPPED AND LEANED TO THE RIGHT. AFTER INSPECTING UNDER THE SEAT, I FOUND THAT THE WELDS ON THE FRONT FRAME BAR BROKE LOOSE ALSO TWISTING THE FRAME BAR. THIS COULD HAVE BEEN VERY DANGEROUS WHILE DRIVING AS THE SEAT REALLY LEANED OVER VIOLENTLY. ALSO, IT APEARS THE SEAT BELTS ARE ATTACHED TO THESE SUPPORT BARS. THIS ISSUE STILL HAS NOT BEEN REPAIRED AS THE COST IS OVER $1000. SHOULD WE BE INVOLVED IN AN ACCIDENT, THE SEAT WILL VERY EASILY TEAR AWAY FROM THE REMAINING WELDS POSSIBLY EJECTING THE DRIVER ALONG WITH THE SEAT. THE SEAT SHIFTS AND TILTS DRASTICALLY WHEN TURNING VEHICLE. AFTER RESEARCHING THIS ISSUE ONLINE, I FIND THAT SEVERAL MALIBU MAXX OWNERS FROM SEVERAL DIFFERENT YEARS ARE HAVING THE EXACT SAME ISSUE. THIS SHOULD BE A SAFETY RECALL ISSUE AS THE SEAT WILL COME LOOSE ALONG WITH THE SEAT BELTS SHOULD VEHICLE BE INVOLVED IN AN ACCIDENT. *TR
Vehicle speed control, Jul 10, 2012
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE ACCELERATED ON ITS OWN. THE CONTACT HAD TO IMMEDIATELY APPLY THE BRAKES TO STOP THE VEHICLE. THE VEHICLE HAD NOT BEEN TAKEN TO THE DEALER FOR A DIAGNOSIS. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 122,000.
Steering, Jul 8, 2012
THE POWER STEERING WARNING LIGHT HAS BEEN COMING ON FOR SOME TIME NOW, BUT 3 DIFFERENT TIMES THE POWER STEERING HAS FAILED WHEN LEAVING FROM BEING PARKED. TURNING OFF THE CAR AND RESTARTING FIXES IT BUT FOR HOW LONG WILL THAT CONTINUE TO WORK. *TR
Exterior lighting, Jul 1, 2012
THIS HAS BEEN AN ONGOING INCIDENT WITH ONE OR BOTH TURN SIGNALS LAMPS FOR MORE THAN TWO YEARS. THE TURN SIGNAL LAMPS THEMSELVES DO NOT APPEAR BURNED OUT BUT THE LAMP SOCKET WIRE MELTS THE PLASTIC HOUSING FROM EXCESSIVE HEAT AND CAUSES A BREAK IN THE ELECTRICAL CIRCUIT. I HAVE MADE MULTIPLE BULB REPLACEMENTS OVER THE TWO PLUS YEARS ONLY TO HAVE THE TURN SIGNAL SOCKET PLASTIC HOUSING FAIL REPEATEDLY. THIS SITUATION MAY BE A SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS LAMPS BECOME INTERMITTENT OR INOPERATIVE. CONSEQUENCES: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH. *TR
Steering, Jun 29, 2012
AS I DROVE MY WIFE WHO WAS IN LABOR TO THE HOSPITAL, THE POWER STEERING FAILED AS I BEGAN TO TURN INTO AN INTERSECTION. SIMULTANEOUS TO THIS, THE CHECK ENGINE LIGHT CAME ON. BARELY MADE THE TURN WITHOUT GOING INTO ONCOMING TRAFFIC. POWER STEERING STAYED OFF THE REST OF THE TRIP. ARRIVED AT HOSPITAL AND TURNED CAR OFF. POWER STEERING CAME BACK ON. POWER STEERING THEN FAILED ON WAY HOME FROM THE HOSPITAL. *TR
Steering, Jun 28, 2012
THE POWER STEERING LOCKS UP FOR APPROXIMATELY 5 TO 10 SECONDS. IT OCCURS AT SLOW SPEEDS ON SURFACE STREETS, HIGH SPEEDS ON THE INTERSTATE, GOING FORWARD AND EVEN WHEN I'M IN THE MIDST OF A TURN. THE CHECK ENGINE LIGHT WILL FLASH, THE LIGHTS FLASH ON AND OFF AND THE NOTICE BELL RINGS "DING, DING, DING." WHEN IT FINALLY STOPS THE, IF ITS SUMMER THE AC WILL STOP FUNCTIONING UNTIL I STOP AND RESTART THE CAR. IT IS A VERY SCARY 5 TO 10 SECONDS AND I'M VERY FORTUNATE TO HAVE NOT CAUSED AN ACCIDENT AS OF YET. THIS HAS ALSO COMPROMISED THE EASE OF THE POWER STEERING WHEN IT HAS NOT LOCKED UP. PARKING IS VERY DIFFICULT AS THE TURNING RADIUS AND NOT GOOD AND ITS JUST DIFFICULT TO MANEUVER THE CARS STEERING. *TR
Steering, Jun 26, 2012
I WAS DRIVING AND I HEARD A DING,I LOOKED DOWN AT MY GAUGES AND THE STEERING LIGHT WAS ON. AFTER THAT I NOTICED THE POWER STEERING WAS NOT THERE. I THEN SHUT OFF MY CAR AND LET IT SIT AND THEN STARTED IT. THE STEERING WAS BACK ON BUT I DON'T WANT MY LIFE OR ANY OTHERS LIVES AT RISK. UPDATED 07/05/12 *JB
Steering, Jun 26, 2012
WHEN STARTING MY CAR, THERE WAS A WARNING CHIME AND THE MESSAGE "POWER STEERING" APPEARED ON MY DRIVER'S INFORMATION CENTER. WHEN I PUT MY VEHICLE IN GEAR THERE WAS A LOSS OF POWER STEERING CAPABILITIES AND IT WAS VERY DIFFICULT TO DRIVE WITHOUT THE POWER STEERING ENABLED. *JB
Fuel/propulsion system, Jun 21, 2012
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE VEHICLE EMITTED A STRONG GASOLINE FUEL ODOR. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE FUEL NECK ONLY HAD ONE HOSE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 59,198 AND THE CURRENT MILEAGE WAS 69,000.
Seats, Jun 17, 2012
FOR THE SECOND TIME MY DRIVERS SEAT HAS BROKEN ON THE RIGHT HAND SIDE AT A WELD JOINT ON THE FRONT CROSS ROD. THE FIRST TIME IT FAILED AROUND 30,000 MILES AND THE SECOND TIME AROUND 71,000 MILES. THIS IS A COMMON PROBLEM, A SAFETY ISSUE AND NEEDS A RECALL. NOT ONLY IS CHEVROLET GETTING AWAY WITH THIS, BUT THE FIX IS COMPLETE SEAT FRAME REPLACEMENT THAT COST THE CONSUMER ABOUT $1000. CHEVY WINS AGAIN AS THEY GET TO SELL A DEFECTIVE PART AT A PROFIT. A GREAT DEAL FOR CHEVY UNTIL I BUY MY NEXT CAR. TIME TO DO THE RIGHT THING AND DO A RECALL. *TR