2005 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,393 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 Malibu model years with reports.
Of the 2005 reports, 65 involved a crash and 45 involved a fire. 69 people were injured and 3 people died.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Representative owner complaints: steering
711 reports, newest first. Show all
Steering, Feb 16, 2009
ON A COLD (-20 C) WINTER MORNING I FOUND I COULD NOT STEER THE CAR LEFT MORE THAN 10 DEGREES. I HUNG FROM THE WHEEL AND IT SIMPLY WOULD NOT TURN FURTHER. I DROVE IT THE SHORT DISTANCE TO MY MECHANIC WHO PUT IT IN HIS SHOP TO WARM UP. AFTER IT WAS WARMED UP THE CAR TURNED JUST FINE, BUT THEY SENT IT TO A DEALER JUST IN CASE. IT TURNED OUT THERE WAS A SERVICE BULLETIN FOR THIS PROBLEM AND THEY REPLACED THE STEERING COLUMN. I HAVE NOT HAD THIS PROBLEM SINCE. ANOTHER MECHANIC FRIEND TOLD ME I SHOULD NOT HANG ONTO THE STEERING WHEEL WHEN ENTERING OR LEAVING THE VEHICLE AS DAMAGE MAY RESULT TO THE POWER STEERING. *TR
Steering, Feb 10, 2009
IN 2006 I BOUGHT AN 2005 CHEVY MALIBU. BEFORE 49600 THE POWER STEERING WENT OUT. I TOOK IT TO THE SHOP 8 TIMES BEFORE THEY COULD TELL THAT IT WAS THE STEERING COLUMN. IT GOES OUT WITHOUT WARNING. WE HAVE ALMOST WRECKED SEVERAL TIMES. IT HAS GONE OUT GOING DOWN THE INTERSTATE. I STARTED TO REPLACE IT, BUT BEFORE I DID THAT I RESEARCHED THE MATTER. IT APPEARS THAT A LOT OF PEOPLE ARE HAVING THE SAME PROBLEM THAT I AM HAVING, FROM THE 2005S TO THE 2008S, FROM THE MALIBU TO THE MALIBU MAXX. I HAVE NOT REPLACED IT BECAUSE MANY PEOPLE HAVE HAD THEM CHANGED THREE OR FOUR TIMES AND THEY KEEP BREAKING. I DON'T HAVE THAT KIND OF MONEY TO JUST THROW AWAY. I CAN'T AFFORD TO SELL IT EITHER OR TRADE IT IN. I AM THE ONE WHO DRIVES IT MOST OF THE TIME BECAUSE I AM AFRAID IT WILL GO OUT WHEN MY WIFE IS IN A CURVE, AND SHE COULD WRECK AND DIE BECAUSE SHE IS NOT STRONG ENOUGH TO CONTROL IT WHEN IT GOES OUT. *TR
Steering, Feb 5, 2009
I WAS DRIVING MY CAR IN A SCHOOL ZONE AT ABOUT 20MPH AND I STARTED TO MAKE A LEFT TURN, ABOUT MIDWAY THROUGH THE TURN MY POWER STEERING WENT OUT ON MY CAR AND IT BECAME VERY DIFFICULT TO CONTROL. BECAUSE I WAS IN THE MIDDLE OF A LEFT TURN GOING ACROSS TRAFFIC WHEN THIS HAPPENED I DRIFTED IN TO ON COMING TRAFFIC. I CAN HONESTLY SAY THAT IF I OR THE OTHER DRIVES INVOLVED HAD BEEN GOING MORE THEN 20 MPH THAT THERE WOULD HAVE BEEN A HEAD ON ACCIDENT. I HAVE TAKEN THE CAR TO A NUMBER OF LOCAL SHOPS AND I HAVE SPOKEN WITH THE LOCAL CHEVROLET DEALERSHIP BUT NOONE SEAMS TO BE ABLE TO PINPOINT THE PROBLEM. THERE HAVE BEEN NO REPAIRS ON THE CAR AS OF YET AND I AM CURRENTLY NOT DRIVING THE CAR BECAUSE OF THIS PROBLEM. THE PROBLEM HAS OCCURRED EVERYTIME I HAVE TRIED TO DRIVE THE CAR SINCE THIS HAS HAPPENED. *TR
Steering, Exterior lighting, Jan 26, 2009
TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT PREVIOUSLY EXPERIENCED FAILURE WITH THE DRIVER'S SIDE HEADLIGHT BULB CONSTANTLY BURNING OUT. SIX MONTHS LATER, THE PLASTIC HEADLIGHT COVERS BURNED. THE STEERING SHAFT HAS BEEN REPLACED THREE TIMES. THE DEALER STATED THAT THE PLASTIC COVER FAILURE WAS A FACTORY DEFECT; THEREFORE, THEY WERE UNABLE TO CORRECT THE FAILURE. THE FAILURE MILEAGE WAS 69,000 AND CURRENT MILEAGE WAS 78,400. UPDATED 02-23-09 *BF UPDATED 02/24/09. *JB
Steering, Jan 19, 2009
KNOCKING OR BANGING SOUND IN THE FRONT END LED TO THE POWER STEERING RACK BEING REPLACED ON 11/17/06 AT 27M MILES ON MY 2005 CHEVROLET MALIBU. THE SAME HAPPENED AGAIN ON 12/05/08 AT 50M MILES. BOTH REPAIRS DONE BY THE DEALER. I REPORTED TO CHEVROLET THAT THE RACK FAILS APPROXIMATELY EVERY 25M MILES. *TR
Steering, Dec 25, 2008
POWER STEERING FAILURES... HAS HAPPENED TWICE IN 2 WEEKS NOW. ONCE WHILE SITTING STILL, THE OTHER WHILE ON THE INTERSTATE! AFTER SEARCHING ONLINE, I'VE FOUND THIS IS A COMMON PROBLEM IN MALIBU'S. I THINK THERE SHOULD BE A RECALL. I THOUGHT I WAS BUYING A RELIABLE CAR AND INSTEAD GOT A BIG BURDEN. BEING A SINGLE MOM, THESE HIGH REPAIR COSTS WILL CAUSE ME TO FALL BEHIND IN EITHER MY CAR PAYMENT OR MY HOUSE PAYMENT... AND BELIEVE ME I'D RATHER LIVE IN MY HOUSE THEN MY CAR. *TR
Steering, Dec 24, 2008
TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX . WHEN DRIVING LOW SPEEDS RANGING FROM 0 TO 10MPH THERE IS A CLUNKING NOISE IN THE STEERING WHEEL COLUMN. WHEN HE MADE A LEFT AND RIGHT TURN OR DROVE IN REVERSE THE NOISE WAS PRESENT. THE MANUFACTURER INFORMED HIM TO TAKE THE VEHICLE TO THE DEALER TO DIAGNOSIS THE FAILURE AND PERFORM A POSSIBLE REPAIR. AN APPOINTMENT WAS SCHEDULED FOR THE END OF DECEMBER 2008. THE FAILURE MILEAGE WAS 43,000.
Steering, Electrical system, Dec 15, 2008
MY 2005 MALIBU MAXX LT HAS HAD A RECURRING PROBLEM BESIDES THE "ELECTRIC POWER STEERING FAILURE" WHICH HAS SO FAR NOT FAILED AGAIN (DID TWICE ONCE WHEN BRAND NEW, AND AGAIN AT ABOUT 20,000 KM. VEHICLE HAS ONLY 45,000 KM ON IT NOW! WE LIVE IN WINNIPEG WHERE WINTER TEMPERATURES OFTEN ARE BELOW FREEZING FROM MID NOVEMBER TO MID APRIL. TODAY IT IS -25 C WITH WINDCHILL OF -44 C. EVERY WINTER WE HAVE THE SAME PROBLEM.....THE IGNITION KEY WILL NOT COME OUT OF ITS SLOT...TRY WIGGLING IT AND AT THE SAME TIME WIGGLING THE SHIFT LEVER IN PARK....SOMETIMES IT WORKS SOMETIMES NOT. THE GM DEALER (VICKARS COMMUNITY CHEVROLET) WHERE WE GO FOR SERVICE HAS TRIED TO FIX IT TWICE, BUT IT ALWAYS RECURS WHEN IT IS VERY COLD. WE HAVE HAD TO REMOVE THE "REMOTE DOOR UNLOCK AND LEAVE THE KEY IN THE IGNITION AT TIMES. THIS IS NOT A GOOD THING IN THE CANADIAN CITY WITH THE HIGHEST CAR THEFT RATE! WE THINK IT HAS SOMETHING TO DO WITH THE ANTI-THEFT PASS LOCK SYSTEM. BY THE WAY ALL CARS IN MANITOBA MUST HAVE AN APPROVED ANTI-THEFT SYSTEM TO BE INSURED OR REGISTERED. THE MANITOBA PUBLIC INSURANCE CORP. DOES APPROVE THE FACTORY SYSTEM ON THE MALIBU MAXX. IT IS JUST TOO FINICKY AND INCONVENIENT. BUT AT LEAST WE WERE NOT FORCED TO PUT IN A "THIRD PARTY" FOB WHICH MANY PEOPLE HAVE FOUND CAUSES ALL KINDS OF OTHER PROBLEMS ESPECIALLY WITH "COMMAND START" SYSTEMS (MALIBU HAS A FACTORY COMMAND START.) WONDER IF OTHERS HAVE SIMILAR PROBLEM?? *TR
Steering, Dec 1, 2008
CLUNK, KNOCK OR RATTLE NOISE FROM FRONT OF VEHICLE WHILE DRIVING OR TURNING OVER BUMPS AT LOW SPEEDS. DEALER FIXED CLUNK. THE CLUNK CAME BACK. DEALER DID NOT MENTION WHAT PARTS WERE REPLACED OR FIXED. *TR
Steering, Nov 24, 2008
LEARNED OF A POWER STEERING SERVICE NOTICE AFTER THE POWER STEERING FAILED WHILE ENTERING TRAFFIC. GM AUTHORIZED THE REPAIR AND THE DEALER FAILED TO COMPLETELY REPAIR THE STEERING OR OTHER ISSUE THAT WAS DIRECTLY RELATED TO THE FAILED STEERING. THE DEALER DID NOT INFORM ME THAT THE CAR WAS NOT COMPLETELY REPAIRED. THE STEERING NOW ALTERNATES BETWEEN TOO MUCH PLAY OR PARTIAL FAILURE WHEN TURNING. I BROUGHT THE CAR BACK TO THE DEALER WHO STATED THAT GM DID NOT WANT TO COMPLETELY REPAIR THE POWER STEERING. THE STEERING IS WORSE SINCE THE REPAIR. AT LEAST BEFORE I ONLY LOST IT TWICE BUT WHEN IT WORKED IT WORKED FINE. NOW I PARTIALLY LOSE STEERING EVERY LEFT HAND TURN AND RIGHT TURNS ALTERNATE WITH A REAL LOT OF PLAY AND ALMOST NORMAL. DRIVING STRAIGHT THE CAR PULLS TO THE RIGHT. *TR
Steering, Nov 17, 2008
POWER STEERING FAILED WHILE TURNING LEFT INTO TRAFFIC. THE LED READ OUT SAID "POWER STEERING". TURNED CAR OFF. SEARCHED INTERNET AND FOUND A SERVICE BULLETIN FOR THE CAR #07126. CALLED GM AND ASKED WHY I WASN'T INFORMED OF THIS BULLETIN SINCE I COMPLAINED OF SIMILAR BUT LESS INTENSE OCCURRENCES SINCE PURCHASE. *TR
Steering, Nov 8, 2008
POWER STEERING WENT OUT, I COULD BARELY TURN THE WHEEL. STERRING COLUMN WILL COST ME ALMOST SIX HUNDRED DOLLARS TO FIX. *TR
Steering, Oct 16, 2008
TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. WHENEVER THE CONTACT TURNS THE STEERING WHEEL IN EITHER DIRECTION, HE HEARS A CLUNKING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE STEERING SHAFT NEEDED TO BE REPLACED. THE FAILURE HAS OCCURRED THREE TIMES. THE CURRENT AND FAILURE MILEAGES WERE 40,050.
Steering, Suspension, Fuel system, Gasoline, Oct 16, 2008
I OWN A 2005 MALIBU MAXX AND AFTER ONE YEAR OLD IT BEGAN MAKING CLUNKING NOISES IN THE FRONT. I TOOK IT TO THE DEALERSHIP AND THEY SAID THEY HAD TO REPLACE A PART OF THE STEERING SHAFT. THEY DID WHAT THEY DID AND THE NOISE WAS GONE. THEY ALSO REPLACED STRUTS. A FEW MONTHS LATER IT DID IT AGAIN. THIS TIME THEY REPLACED TIE ROD ENDS. BY THIS TIME MY WARRANTY HAD EXPIRED. THEN 2 MONTHS LATER IT DID IT AGAIN! THEY LUBED SOMETHING AND NOW IT HAS BEEN 8 MONTHS AND IT HAS NOT RETURNED YET. NOW MY ENGINE LIGHT IS ON AND I KEEP GETTING A MESSAGE TO CHECK MY GAS CAP. I CHECK IT AND NOTHING IS WRONG. *TR
Steering, Equipment, Oct 15, 2008
2005 MALIBU,HAVE HAD BOTH TIE ROD ENDS REPLACED,STRUTS ETC. MAKES A LOUD CLUNKING WHEN DRIVING AT LOW SPEEDS AND TURNING. SOUNDS LIKE WHEELS COMING LOOSE. SOUND,SOUNDS LIKE IT IS COMING FROM STEERING COLUMN,CHECK ENGINE LIGHT COMES ON WHEN I FILL GAS TANK AND STAYS ON UNTIL APPROX 1/2 TANK. *TR
Steering, Oct 9, 2008
UNDER WARRANTY MY 2005 MALIBU MAXX DEVELOPED A CLUNKING NOISE THAT YOU ALSO FEEL IN THE STEERING. MOSTLY TURNING LEFT. GOING FORWARD OR REVERSE. THE DEALERSHIP REPLACED THE STEERING GEAR AND IT FIXED THE PROBLEM. NOT A SOUND TURNING LEFT ,RIGHT OR WHATEVER. I WAS VERY SATISFIED BUT 10 MONTHS AND 12,500 MILES LATER GUESS WHAT ! IT'S BAAACK ! INCLUDE ME IN THE LIST ! *TR
Steering, Sep 17, 2008
2005 CHEVROLET MALIBU MAXX. THUMPING NOISE FROM FIREWALL AREA WHEN TURNING STEERING WHEEL AT LOW SPEEDS. *TR
Steering, Sep 6, 2008, crash
ON 8/25/2008 MY STEERING LOCKED UP ON MY 2005 MALIBU CLASSIC. O LOST CONTROL IF MY CAR AND CRASHED INTO 2 TELEPHONE BOXES. AFTER RESEARCHING THIS INCIDENT ON THE INTERNET I FIND THAT THERE ARE MANY COMPLAINTS ABOUT THIS ELECTRONIC STEERING PROBLEM. *TR
Steering, Suspension, Engine and engine cooling, Electrical system, Exterior lighting, Interior lighting, Equipment, Aug 21, 2008
TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. SINCE PURCHASING THE VEHICLE, THE ANTI THEFT DEVICE HAS FAILED REPEATEDLY, THE ENGINE MAKES A TICKING SOUND, THE STEERING WHEEL IS SLIPPING OR LOOSE, AND OIL LEAKS FROM THE ENGINE. WHILE DRIVING 45 MPH, THE DASHBOARD . VIBRATES. THE CONTACT HEARS A NOISE IN THE RADIO WHEN THE VEHICLE IS TURNED ON, THE ENGINE SERVICE LIGHT IS ILLUMINATED ON THE INSTRUMENT PANEL, THE INTERIOR LIGHTS FAILED, THE REMOTE START WOULD NOT START THE VEHICLE, AND THE ENGINE SHAKES ROUGHLY. THE CURRENT MILEAGE WAS 12,030 AND FAILURE MILEAGE WAS 100. UPDATED 09/24/08. *LJ THE CONSUMER STATED THERE WAS A PROBLEM WITH THE ENTIRE SUSPENSION. THE SHOCKS AND BEARINGS MADE A NOISY. THE HAZARD LIGHTS FAILED. UPDATED 09/30/08.*JB
Steering, Aug 1, 2008
HAVE HAD NUMEROUS WARRANTY WORK DONE. PURCHASED CAR 4 MONTHS AGO WITH 24,000 MILES NOW HAS 28,000. 6 WARRANTY REPLACEMENTS. AROUND 25,000 STARTED CAR AND STEERING WHEEL WAS TURNING VIOLENTLY. SHUT CAR OFF AND IT WAS FINE. LATER NOTICED STEERING WAS LOOSER AND THUMPING NOISE. CHEVY REPLACED STEERING GEAR. NOW AT CURRENT MILEAGE DID THE SAME THING HAS HAPPENED AND REPLACING ANOTHER COMPONENT IN STEERING. THIS IS VERY DANGEROUS. WHEN DRIVING AROUND TURNS IT FELT LIKE I HAD NO CONTROL OVER CAR. NOW THAT MY WARRANTY IS OUT MY WHEN I PUT MY CAR INTO D HALF THE TIME IT WILL JUMP INTO GEAR AND SOMETIMES IT GETS STUCK OR WANTS TO STOP AT R. A CAR WITH 28,000 MILES SHOULD NOT BE HAVING THIS KIND OF TROUBLE. I CAN ONLY IMAGINE WHAT IT WILL BE LIKE WITH 75,000 MILES ON IT. *TR
Steering, Jul 30, 2008
TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE STEERING COLUMN MAKES RANDOM KNOCKING NOISES. HE DISCOVERED TSB NUMBER 1973984, WHICH IS IDENTICAL TO THE FAILURE HE IS EXPERIENCING. THE VEHICLE WAS TAKEN TO THE DEALER ON THREE OCCASIONS AND THE RECOMMENDED SOLUTIONS IN THE TSB WERE HEEDED; HOWEVER, THE FAILURE PERSISTS. THE CONTACT IS CONCERNED THAT HIS STEERING COLUMN WILL EVENTUALLY FAIL COMPLETELY. THE FAILURE MILEAGE WAS 18,000 AND CURRENT MILEAGE WAS 48,000.
Steering, Jul 25, 2008
WE HAVE A 2005 CHEVY MALIBU WITH 39,000 MILES. MY WIFE DRIVES THE CAR NORMALLY BUT I DROVE THE CAR FOR A FEW WEEKS AND NOTICED A CLUNKING IN THE STEERING AT LOW SPEEDS WHEN TURNING. TAKING THE CAR INTO OUR MECHANIC IT WAS DIAGNOSED AS A ISSUE WITH THE INTERMEDIATE STEERING SHAFT WHICH HAD TO BE REPLACED. I DON'T THINK THIS PART SHOULD EVER GO OUT LET ALONE AT 39,000 MILES. IT IS A SAFETY ISSUE WITH THE CAR. THE MECHANIC TOLD US THAT CHEVY HAS HAD THIS ISSUE WITH MAY CARS AND TRUCKS AND HAS KNOWN ABOUT THE ISSUE. *TR
Steering, Jul 24, 2008
ACCORDING TO THE DEALER THIS VEHICLE HAS A DEFECTIVE RACK AND PINION THAT IS BASED UPON ENGINEERING AND COULD CAUSE A LOSS OF CONTROL STEERING WHILE DRIVING THE VEHICLE. A LOUD POPPING NOISE IS HEARD WHILE TURNING LEFT OR RIGHT AND A SNAPPING IS HEARD WHEN SLOWING DOWN AND BREAKING. A LOOSE RATTLE ALSO OCCURS IN FRONT END WHILE DRIVING ON PRIMARY OR SECONDARY ROADS. CAR JUMPS AND STEERING JERKS WHEN HITTING A BUMP ON PAVED ROADWAYS. CAR HAS BEEN TAKEN IN FOR REPAIRS THREE TIMES. *TR
Steering, Suspension, Service brakes, Hydraulic, Engine and engine cooling, Electrical system, Equipment, Jul 18, 2008
TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHEN TURNING THE STEERING WHEEL, THE CONTACT HEARD A POPPING SOUND. THE FAILURE BEGAN SIX MONTHS AGO AND NOW IT IS CAUSING THE POWER STEERING TO FAIL. THE FAILURE WAS VERY SUBTLE AT FIRST, BUT NOW THE POWER STEERING FAILS FOR DAYS AT A TIME. THE AIR CONDITIONING WOULD ACTIVATE ON AND OFF, BUT NOW IT DOES NOT WORK AT ALL. THE DEALER STATED THAT THE POWER STEERING MODULE AND AIR CONDITIONING RESISTOR NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT THE CONTROL PANEL IS WARM TO THE TOUCH AFTER DRIVING FOR SOME TIME. THE VEHICLE IS CURRENTLY WITH THE DEALER AND THE REPAIR WILL COST OVER $900. THE CURRENT MILEAGE WAS 70,000 AND FAILURE MILEAGE WAS 50,000. UPDATED 09/10/08. *LJ THE CONSUMER STATED THE SHOCKS WENT BAD, THE TIE ROD ENDS HAD TO BE REPLACED, THE CD BECAME STUCK IN THE CD PLAYER. THE REAR CALIPERS HAD TO BE REPLACED AND THE STARTER WORKED INTERMITTENTLY. UPDATED 09/12/08. *JB
Steering, Jul 10, 2008
A FRIEND OF MINE HAS A 05 CHEVY MALIBU . I SEE AN INVESTIGATION WAS DONE ON THE 04'S #PEO4031 ELECTRIC POWER ASSIST SYSTEM . I HAVE PERSONALLY HAD IT GO OUT ON ME TWICE . AND I COULD BARELY STEER THE CAR AND ALMOST GOT INTO A WRECK...... I WEIGH 190 LBS. MY GIRL FRIEND WEIGHS 130 LBS.... PEOPLE ARE GOING TO GET IN WRECKS AND DIE BECAUSE OF THE EPS SYSTEM. AND YOU ARE AWARE OF IT....... DOES THE S IN NHTSA STAND FOR SAFETY ??? THANK YOU FOR YOUR TIME . *TR