2005 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,393 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 Malibu model years with reports.
Of the 2005 reports, 65 involved a crash and 45 involved a fire. 69 people were injured and 3 people died.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Representative owner complaints: steering
711 reports, newest first. Show all
Steering, Service brakes, Hydraulic, Oct 15, 2007
AFTER THE FIRST 200 MILES ON THE ODOMETER, THE CAR HAD FRONT ROTOR PROBLEMS. THE DEALER TRIED TO FIX IT 2 TIMES BY TURNING THE ROTORS, ONLY TO RETURN IN LESS THAN 2,000 MILES EACH TIME. THEY FINALLY CHANGED OUT THE ROTORS FOR BRAND NEW ONES AFTER I COMPLAINED TO THE DEALER OWNER AND MANAGEMENT ABOUT THE PROBLEM. THE SECOND ISSUE WAS LOSS OF POWER STEERING WHILE ON THE HIGHWAY, MAKING IT IMPOSSIBLE TO TURN. THIS WAS CAUSED BY A FAULTY ELECTRICAL CONNECTION AT THE FUSE BOX, WHICH I TOOK IT UPON MYSELF TO REPAIR AND THE PROBLEM NEVER RETURNED. THE THIRD PROBLEM STARTED IN JANUARY 2007, JUST ONE AND A HALF YEARS OF OWNING THE CAR. STEERING ASSEMBLY NOISES IDENTICAL TO ALL PREVIOUS REPORTS WAS CORRECTED BY A RACK AND PINION ASSEMBLY REPLACEMENT. IN JULY 2007 (JUST 6 MONTHS LATER) IT WAS CHANGED AGAIN. NOW IN OCTOBER (3 MONTHS LATER) IT IS SCHEDULED TO RETURN TO THE DEALER FOR YET ANOTHER REPLACEMENT, MAKING THIS THE 4TH RACK AND PINION ASSEMBLY TO DATE (INCLUDING THE ORIGINAL). THIS IS COMPLETELY UNACCEPTABLE FOR A VEHICLE OF THIS PRICE RANGE... AND THE ONLY SOLUTION TO DATE IS TO CONTINUE TO CHANGE OUT THE ASSEMBLY. *TR
Steering, Oct 12, 2007
PURCHASED VEHICLE IN OCT, 2006 AT WHICH TIME WE FOUND THE STEERING RACK NEEDED REPLACEMENT, THE REPLACEMENT LASTED UNTIL JUNE OF 2007. AT WHICH TIME IT WAS REPLACED AGAIN. NOW IT IS OCTOBER 2007 AND THE RACK IS BAD AGAIN AND NEEDS TO BE REPLACED . I WANT TO KNOW WHAT CHEVROLET IS GOING TO DO ABOUT THIS PROBLEM? *JB
Steering, Sep 24, 2007
I BOUGHT A 2005 CHEVROLET MALIBU APRIL 6, 2006 WITH 17,000 MILES. IN OCTOBER OF 2006 WITH 31,500 MILES THE STEERING WAS MAKING TERRIBLE POPPING NOISES. THE DEALER REPLACED THE STEERING RACK AND THE PROBLEM WENT AWAY FOR A FEW MONTHS. AT 41,000 MILES I AGAIN HAD TO HAVE THE STEERING RACK REPLACED, THIS TIME GM COVERED IT AS A "GOODWILL" GESTURE. NOW, AT 54,000 MILES, THE STEERING IS MAKING THE SAME NOISE AGAIN. IT CAN'T BE SAFE TO DRIVE. THREE STEERING RACKS IN 20,000 MILES IS PRETTY EXCESSIVE. *JB
Steering, Sep 24, 2007, crash
TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 40 MPH IN THE RAIN, THE POWER STEERING FAILED. THE INSTRUMENT PANEL DISPLAYED "POWER STEERING", BUT THE SERVICE ENGINE LIGHT NEVER ILLUMINATED. SHE WAS DRIVING ON THE LEFT SIDE OF A THREE LANE ROAD WHEN THE FAILURE OCCURRED. THE VEHICLE CONTINUED TO VEER TO THE RIGHT AS SHE DEPRESSED THE BRAKE PEDAL. AS A RESULT, SHE STRUCK THE RIGHT GUARDRAIL, WHICH CAUSED AXLE FAILURE, BODY WORK, AND DAMAGE TO THE PASSENGER SIDE TIRE. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE DEALER, WHERE IT CURRENTLY REMAINS. THE CURRENT AND FAILURE MILEAGES WERE 55,000.
Steering, Sep 8, 2007
POWER STEERING WILL LOCK AND CAR IS HARD TO TURN. *TR
Steering, Aug 22, 2007
POWER STEERING FAILURE. *TR
Steering, Aug 17, 2007
I HAVE A 2005 CHEVROLET MALIBU AND HAVE HAD NUMEROUS ISSUES WITH IT. THE LATEST HAS BEEN THAT AT 47,000 MILES I DEVELOPED A CLUNKING NOISE FOLLOWED BY SERIOUS DIFFICULTY WHEN MAKING LEFT TURNS. AFTER TAKING IT TO AN AC DELCO REPAIR SHOP IT WAS DETERMINED THAT THE INTERNAL SHAFT IN THE STEERING COLUMN HAD GONE OUT. FORTUNATELY I WAS ABLE TO RECGONIZE A PROBLEM AND HAVE IT REPAIRED BEFORE ANY SERIOUS INCIDENT OCCURRED. UNFORTUNATELY IT COST ME $600 OF COURSE NOT COVERED BY GM. *TR
Steering, Aug 15, 2007
2005 CHEVY MALIBU LT I HAVE HAD NUMEROUS PROBLEMS WITH THE STEERING. THERE HAS BEEN A THUMPING NOISE FROM THE FRONT END WHEN TURNING LEFT OR RIGHT. NOISE CAN BE PLAINLY HEARD AT LOW SPEEDS. THE STEERING RACK HAS BEEN REPLACED 3 TIMES AND THE STEERING SHAFT ONCE. *JB
Steering, Aug 10, 2007
TL*THE CONTACT OWNS A 2005 CHEVY MALIBU. WHILE DRIVING 25 MPH SHE HEARD A CLUNKING NOISE COMING FROM THE LEFT WHEEL WHEN SHE MADE A LEFT TURN. THE MECHANIC STATED THAT THE POWER STEERING RACK AND PINION NEEDED TO BE REPLACED. APPROXIMATELY SIX MONTHS AFTER THE REPAIR, THE FAILURE OCCURRED AGAIN. AS OF AUGUST 10, 2007, THE MECHANIC HAS NOT REPAIRED THE VEHICLE. THE CURRENT MILEAGE WAS 45,484 AND THE FAILURE MILEAGE WAS 33,653.
Steering, Service brakes, Hydraulic, Power train, Tires, Aug 7, 2007
2005 CHEVROLET MALIBU RECALL CUSTOMER STATES THAT THE RACK AND PINION WAS REPLACED AND IT SHOULD HAVE BEEN COVERED UNDER THE BUMPER TO BUMPER WARRANTY**CC THE CONSUMER STATED THE SECOND GEAR WAS SLOW TO ENGAGE, THERE WAS A NOISE COMING FROM THE REAR OF THE VEHICLE AND THE BRAKES MADE A NOISE WHEN THEY WERE APPLIED. THE DEALER CLEANED THE FRONT BRAKES AND APPLIED TREATMENT TO THEM. THE CONSUMER WAS INFORMED THE TIRES WERE CUPPED. *JB
Steering, Jul 27, 2007
2005 CHEVY MALIBU 3.5 L V6 STEERING LOCKS UP ON LEFT TURNS EVERY ONCE IN A WHILE. COULD BE VERY DANGEROUS. *JB
Steering, Jul 3, 2007
I HAVE A 2005 MALIBU WITH 50000 MILES ON IT AND THE POWER STEERING RANDOMLY SHUTS OFF. THE CAR IS EQUIPPED WITH ELECTRONIC POWER STEERING AND SOMETIMES THE STEERING IS REAL TIGHT AND SOMETIMES ITS REALLY LOOSE. IT BECOMES VERY DANGEROUS WHEN THIS HAPPENS AND THE CHEVY DEALERSHIP I BROUGHT IT TO DOESN'T KNOW WHAT IS WRONG. I KNOW WHAT IS WRONG - MY STEERING DOESN'T WORK 100% OF THE TIME. I HAVE A SAFE DRIVING RECORD AND DRIVE RESPOSIBLY AND DO NOT BEAT ON MY CARS. I KNOW IT IS NOT MY DRIVING STLYE, RATHER IT IS A FLAW IN DESIGN AND CONSTRUCTION OF THE POWER STEERING.
Steering, Suspension, Jun 2, 2007
MY HUSBAND AND I PURCHASED A USED CERTIFIED 2005 MALIBU MAXX IN JULY OF 2006, BY THE TIME THE WEATHER GOT COLD, I NOTICED A CLUNKING NOISE IN THE FRONT END. IT WAS TAKEN IN TO THE DEALERSHIP AND THEY REPLACED THE STEERING BOX. THE SECOND TIME WAS IN MARCH 07, THEY COULD NOT VERIFY THE NOISE, THEN AGAIN IN APRIL I TOOK THE CAR BACK AND THEY REPLACED A FRONT SWAY BAR LINK. THE NOISE IS STILL THERE. IT GETS SO MUCH WORSE IN COLD WEATHER IT CAN BE REALLY SCARY ON THE HIGHWAY, IT ALSO HAS A INCONSISTENT PULL TO THE LEFT AND HAS BEEN ALIGNED, AND TIRES ROTATED TO NO AVAIL. WHY CAN'T THEY FIX THIS PROBLEM? I AM LOSING MY FAITH IN GM AFTER NEARLY 20 YEARS OF BEING A FAITHFUL GM OWNER. *TR
Steering, May 15, 2007
2005 CHEVROLET MALIBU MAX, POWER STEERING FAILURE - TOTAL LOSS, LOCKED UP OF STEERING CONTROL AT LOW SPEED. DURING LOW SPEED TURN DRIVER COULD NOT TURN WHEEL AND LOST ALL STEERING CONTROL OF VEHICLE. THIS FAILURE WAS ACCOMPANIED BY A POWER STEERING WARNING ON THE CAR'S INFORMATION PANEL. VEHICLE WAS STOPPED SUCCESSFULLY WITH OUT ACCIDENT. DRIVER TURN OFF IGNITION, RESTARTED, AND STEERING CONTROL RETURNED BUT SEEMED HESITANT. ALTHOUGH THIS WAS BEING REPORTED AS OF THIS DATE 5/15/0) IT ALSO OCCURRED A WEEK EARLIER BUT RETURNED TO NORMAL OPERATION. PREVIOUSLY THIS CAR HAD WARRANTY SERVICE ON A STEERING SYSTEM "NOISE" COVERED UNDER A TSB AND HAD BEEN WORKING NORMALLY UNTIL THIS ISSUE OCCURRED. VEHICLE WILL BE TAKEN TO CHEVROLET DEALER SERVICE TODAY. *AK
Steering, May 14, 2007
LAST FEBUARY I BOUGHT THIS CAR "CERTIFIED USED" FROM A CHEVY DEALERSHIP. LESS THAN A WEEK LATER THE POWER STEERING FAILED WHILE I WAS DRIVING ON THE HIGHWAY AT 65 MPH. SOME HOW I MANAGED TO PULL OVER WITHOUT WRECKING THE CAR. I TURNED IT OF AND BACK ON AGAIN AND IT SEEMED FINE. THEN IT HAPPED AGAIN AND AGAIN SO WE TOOK IT TO THE DEALERSHIP. AT FIRST I REALLY REGRETTED BUYING THE CAR BUT THEY FIXED IT AND IT SEEMED OKAY. NOW A YEAR LATER AND AFTER THE WARRENTY HAS EXPIRED THERE IS A CLICKING AND THUMPING NOISE COMING FROM THE STEERING AND I'M SURE THAT I WILL HAVE TO PAY PLENTY TO GET THAT FIXED LUCKY FOR THEM THE WARRENTY IS GONE. MEANWHILE I'M WITHOUT A CAR. I WILL NEVER BUY ANIOTHER CAR FROM GM AGAIN. THIS CAR WAS A HUGE MISTAKE!
Steering, May 5, 2007
CHEVROLET MALIBU 2005. DRIVING ON A LOCAL STREET, I MADE A RIGHT ONTO ANOTHER STREET AND THE STEERING BECAME STIFF, HARD TO MAKE A SHARP TURN AND I HAD TO PULL THE STEERING WHEEL HARD AND USE AN EXTREME AMOUNT OF EFFORT TO COMPLETER A TURN, A BELL WENT OFF. I WAS UNABLE TO STEER TO THE LEFT OR THE RIGHT. THE CAR WAS STILL RUNNING. I TURNED THE CAR OFF AND THEN RESTARTED THE CAR AND THEN I WAS ABLE TO TURN THE WHEEL FREELY FOR ABOUT 15 SECONDS THEN THE WHEEL BECAME STIFF AGAIN. IF I HAD REACHED THE HIGHWAY TO GET TO MY DESTINATION DRIVING 50 MPH AND I HAD TO SUDDENLY QUICKLY STEER TO THE LEFT OR RIGHT TO AVOID AN POTENTIAL PROBLEM, I MAY HAVE GOTTEN INTO A POTENTIALLY SERIOUS ACCIDENT INJURING MYSELF & OTHERS. I PURCHASED THE CAR USED & ONLY HAD IT 10 MONTHS. I AM FINANCING THE CAR. I AM VERY CONCERNED ABOUT THE SAFETY OF THIS VEHICLE NOW BECAUSE IT'S ONLY A 2005, ONLY 2 YEARS OLD WITH A POSSIBLE MAJOR SAFETY PROBLEM. I WANT TO KNOW IF THERE ARE OTHER 2005 CHEVY MALIBU'S WITH THE SAME PROBLEM WHO HAVE SERVICED THE VEHICLE AND IF THEY CONTINUE TO HAVE THE PROBLEM AND IF THERE ARE MORE OWNERS WITH THIS COMPLAINT. I AM TAKING THIS CAR TO THE DEALER WHERE I BOUGHT IT, HAVE THEM INSPECT IT A GET MORE INFORMATION ABOUT THIS PROBLEM. *JB
Steering, Suspension, Apr 22, 2007
BACK IN JANUARY 2007, I WAS HAVING A POPPING SOUND THAT WAS MADE WHENEVER I MADE A LEFT OR RIGHT TURN. I TOOK IT TO THE DEALER. THEY CHANGED THE STEERING COLUMN AND RIGHT STRUT. I AM NOW HAVING THE SAME PROBLEM ON THE LEFT SIDE AND WILL BE GOING IN AGAIN SOMETIME THIS WEEK. I'VE ONLY HAD THE CAR FOR 4 MONTHS WITH 24,000 MILES AT THE TIME THIS FIRST HAPPENED. I NOW HAVE 27,000 MILES ON MY VEHICLE. *TR
Steering, Suspension, Service brakes, Hydraulic, Exterior lighting, Apr 2, 2007
PULLS TO THE LEFT, BROKEN STRUTS, BROKEN BRAKE CALIPERS, REAR TURN SIGNAL BROKE! ANYTIME I MESS WITH TIRES OR BRAKES THE CAR PULLS MORE AND MORE TO THE LEFT, HAVEN'T HAD STEERING CHECKED BUT ITS DRIVING ME NUTS. I THOUGHT IT WAS FROM THE FRONT RIGHT STRUT BEING CRACKED AND BROKEN BUT THE DEALERSHIP SAYS IT SHOULDN'T EFFECT THE PULL TO THE LEFT. GOT NEW TIRES LAST WEEK AND NEW BRAKES, STILL PULLS. TAIL LIGHT QUIT WORKING, CHANGED BULBS THEN QUIT AGAIN. CAR IS DRIVING ME NUTS, WORRIED ABOUT DRIVING IT ACROSS COUNTRY THIS SUMMER! RECALL IT SOON - PLEASE!!! *JB
Steering, Mar 26, 2007
THUMPING SOUND IN FRONT WHEELS WHEN TURNING STEERING WHEEL ALL THE WAY IN BOTH DIRECTIONS. PROBLEM REPAIRED UNDER EXTENDED WARRANTY PLAN, REPAIR TECHNICIAN STATED THAT THIS PROBLEM WAS COMMON FOR BOTH 2004 AND 2005 CHEVROLET MALIBU. STEERING GEAR REPLACED AND TOE WAS RESET. E9740 GEAR ASSEMBLY, POWER STEERING REPLACED 124CEXWV, 1 15858368 GEAR. EXTENDED WARRANTY PLAN REQUIRED $200 DEDUCTABLE, I WOULD LIKE TO GET THIS BACK IF MANUFACTURER WAS RESPONSLIBLE.*AK
Steering, Mar 22, 2007
2005 MALIBU MAXX STEERING--RACK AND PINION MAKING A THUMPING SOUND DURING SHARP TURNS AND AS YOU DRIVE OVER BUMPS. A SECOND SOUND IS HEARD DURING THE TURNING OF THE WHEELS WHILE PARKING--SOUNDS LIKE A SPRING BEING STRECHED.
Steering, Feb 26, 2007
BOUGHT THE CAR USED IN JANUARY 2006 WITH 30,000 MILES. WITHIN A MONTH, IT STARTED MAKING CLUNKING NOISES WHEN I MADE TIGHT TURNS. THE DEALERSHIP FIRST SAID THEY COULD FIND NOTHING WRONG. MY HUSBAND TOOK IT BACK, AND THE DEALERSHIP ADMITTED HAVING STEERING PROBLEMS WITH THIS YEAR OF MALIBU, AND REPLACED THE STEERING KNUCKLE. THE PROBLEM WAS FIXED FOR ABOUT 6 WEEKS, THEN THE NOISE RETURNED. THIS TIME THE DEALER REPLACED THE STEERING RACK. THIS TIME, THE PROBLEM WAS FIXED FOR ABOUT 6-8 WEEKS, AND THE NOISE RETURNED. DEALERSHIP REPLACED THE STEERING COLUMN, AND, SO FAR THE PROBLEM HAS NOT RETURNED.*JB
Steering, Feb 12, 2007
THE VEHICLE HAS A DISTRICT CLUNKING NOISE WHEN STEERING TO THE LEFT OR RIGHT AND IS PRONOUNED WHEN GOING OVER BUMPS. I AM VERY CONCERNED ABOUT THE SAFETY OF THE VEHICLE AND HAVE RESEARCHED THE PROBLEM ON THE INTERNET AND IT APPEARS TO COMMON TO THE 2005 CHEVROLET MALIBU. *NM
Steering, Feb 3, 2007
STEERING RACK HAS BEEN REPLACED 3 TIMES ON MY 2005 CHEVROLET MALIBU MAXX. THE STEERING WAS ACTING ERRATIC AND "THUNKING" WHEN STEERING. 3 TIMES THE POWER STEERING HAS QUIT ON ME. THE CAR BECOMES EXTREMELY HARD TO STEER. I KNOW MY WIFE AND DAUGHTER WOULD NOT BE ABLE TO STEER THE VEHICLE IN THIS CONDITION. THE FIRST TIME THE POWER STEERING FAILED, I DROVE IT DIRECTLY TO THE DEALER. WHEN I TOOK THE SERVICE ADVISOR OUT, THE SYSTEM HAD RESET ITSELF AND THE STEERING WAS FINE. THE NEXT 2 TIMES, I PULLED OVER AND SHUT THE VEHICLE OFF FOR A SHORT TIME AND RESTARTED IT AND THE SYSTEM RESET ITSELF AGAIN. AS MENTIONED, THE DEALER HAS REPLACED THE STEERING RACK 3 TIMES, EACH TIME SAYING THIS IS AN IMPROVED PART, AND WON'T HAPPEN AGAIN. BUT IT DOES. *NM
Steering, Feb 1, 2007
TL*- THE CONTACT STATED THAT WHILE DRIVING HER 2005 CHEVROLET MALIBU ON THE HIGHWAY OR IN THE CITY THE POWER STEERING DID NOT FUNCTION CORRECTLY. THE STEERING GOT ROUGH ,AND WHEN TURNING THE STEERING WHEEL SHE HEARD A CLUNKING NOISE, BUT NOT SURE IF IT WAS FROM THE WHEEL OR THE ENGINE. THE CONTACT TOOK THE VEHICLE TO THE DEALERSHIP IN SEPTEMBER 2006 AND THEY REPLACED THE RACK AND PINION STEERING. ALSO, THE CONTACT TOOK THE VEHICLE TO THE DEALER IN NOVEMBER 2006 FOR THE SAME FAILURE ,AND THEY STATED THAT THEY COULDN'T FIND THE FAILURE ON THE VEHICLE. *AK
Steering, Jan 25, 2007, crash
2005 MALIBU MAXX WAS SENT TO THE DEALERSHIP FOR SOME WARRENTY SERVICE WORK ON PROBLEMS WITH FRONT END NOISES. THE CAR WAS RETURNED 30 MINUTES AFTER BEING DROPPED OFF. THE DEALER SAID THE CAR HAD A BAD STEERING RACK AND SHAFT. THE PARTS WERE ORDERED AND THE CAR RETURNED FOR DRIVING UNTIL THE PARTS WERE RECIEVED. LESS THAN 100 MILES LATER THE CAR LOST STEERING CONTROL AND SLAMMED INTO A SEMI TRUCK ON A MAJOR FREEWAY. THE CAR IS A TOTAL LOSS. I DID AN INTERNET SEARCH AND THIS SEEMS TO BE A PROBLEM OTHERS HAVE EXPECIENCED. *NM