2005 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,393 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 Malibu model years with reports.
Of the 2005 reports, 65 involved a crash and 45 involved a fire. 69 people were injured and 3 people died.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Representative owner complaints: steering
711 reports, newest first. Show all
Steering, Suspension, Latches/locks/linkages, Seats, Feb 23, 2015
FIRST I HAVE HAD NOTHING BUT STEERING ISSUES AND HAVE HAD PARTS REPLACED PREVIOUSLY ON THIS VEHICLE. NOW I HAVE TO REPLACE STRUTS, AXLES AND NEEDLESS TO SAY NEW TIRES BECAUSE OF THE WEAR ON THEM DUE TO THE STEERING ISSUES. HOWEVER, I HAVE A RECALLED SHIFT CABLE AND HAVE BEEN WAITING SINCE LAST YEAR IN AUGUST OR SEPTEMBER. I ASKED ISN'T THIS A SAFETY ISSUE AND THEY STATED , THEY ALL ARE. SO I AM STILL WAITING FOR THE CALL THAT THEY HAVE THIS SHIFT CABLE AND CAN ONLY PRAY NOTHING HAPPENS, LIKE A BAD ACCIDENT. IF SOMETHING WERE IT PROBABLY WOULDN'T BE GOOD FOR YOU ALL. ANYWAY WHEN WILL THIS PART BE IN SO I CAN GET IT TAKEN CARE OF. WENT TO [XXX] IN KANSAS CITY KS. BOUGHT THE VEHICLE FROM THEM AND HAVE HAD NOTHING BUT ISSUES WITH THE CAR. PLEASE ADVISE. BY THE WAY THE SEAT BROKE, THE AUTOMATIC LOCKS STOPPED WORKING AND I'M NOT REAL HAPPY. OF COURSE ITS PAID FOR NOW AND NOT UNDER A WARRANTY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Steering, Feb 10, 2015
SLACK IN THE INTERMEDIATE STEERING SHAFT, FELT THE KNOCKING NOISE IN THE STEERING GEAR AND THE INTERMEDIATE SHAFT. NOISE WAS NOTICEABLE IN THE STEERING SHAFT, REPLACED IMMEDIATE STEERING SHAFT. *TR
Steering, Feb 10, 2015
KNOCKING IN STEERING CAN BE FELT WHEN TURN LEFT OR RIGHT REPLACED INTERMEDIATE STEERING SHAFT. *TR
Steering, Feb 10, 2015
I HAVE HAD PROBLEMS WITH THE POWER STEERING IN MY CAR. I TRIED TO DEAL WITH GM AS THERE IS A RECALL FOR MY MODEL YEAR FOR POWER STEERING PROBLEMS. MY VIN IS NOT INCLUDED IN THE RECALL. I HAD TO HAVE A MECHANIC REPLACE THE TORQUE SENSOR WHICH IS THE EXACT PART RECALLED BY GM. MY VIN SHOULD PROBABLY BE INCLUDED IN THE RECALL. *TR
Steering, Jan 29, 2015
2005 CHEVROLET MALIBU MAXX. CONSUMERS STATED THAT THEY TRIED TO GET CAR FIX DUE TO STEERING RECALL, BUT COULDN'T BECAUSE THE DEALER WANTED TO CHARGE THEM FOR LABOR. *TA THE DEALER STATED THERE WOULD BE A CHARGE OF $393.00 TO REPLACE A CONNECTING SHAFT, BETWEEN THE STEERING COLUMN AND THE RACK AND PINION. *JB
Steering, Jan 28, 2015, crash
TL-THE CONTACT OWN A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 15 MPH, THE STEERING WHEEL SEIZED CAUSING THE CONTACT TO CRASH INTO A WALL. IN ADDITION, THE ENGINE WARNING LIGHT ILLUMINATED. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000. DJR
Steering, Service brakes, Hydraulic, Jan 28, 2015
2005 CHEVY MALIBU MASS MASTER BRAKE CYLINDER WAS DEFECTIVE AND CAUSED THE BRAKES TO WEAR VERY QUICKLY. *MW ALSO, THE POWER STEERING FAILED. THE CONSUMER NO LONGER OWNS THE VEHICLE, AS IT WAS TOTALED IN AN ACCIDENT. *JB
Steering, Jan 21, 2015
I USED MY SCANNER TOOL AND I GOT THE CODE P0826 WHICH IS DUE TO A PROBLEM WITH THE SHIFTER, THE SHIFT CABLE MUST BE BROKEN. AM I ENTITLED TO TAKE MY CAR TO GET FIXED IN A DEALER BEFORE AN ACCIDENT OCCURS OR SOMEBODY DIES? *TR
Steering, Jan 19, 2015, crash
I WAS LEAVING A ABOVE GROUND PARKING STRUCTURE GOING ABOUT 5 MPH WHEN I ATTEMPTED TO MAKE A LEFT TURN STEERING ASSIST FAILED AGAIN WAS JUST REPAIRED ABOUT 2 MOS. AGO TWICE IN ONE REPAIR VISIT NOW AGAIN I HIT A LATE MODEL CHEVY TRUCK DENTED THE REAR BUMPER AND MOVEMENT FROM IMPACT PUSHED INTO A CONCRETE PILLAR DAMAGING FENDER I NEVER LOOKED AT THE FRONT OF TRUCK I WAS TOLD BY SECURITY ON THE PHONE. I KNEW IT WAS ALL RECORDED BY THE HUNDREDS OF CAMERAS THEY HAVE ON EACH FLOOR I LEFT MY INS CARD WITH PHONE # ON WINDSHIELD IT CAUSED OVER $5000.00 IN DAMAGE TO MY CAR BECAUSE LIFTED TRUCK AND THE TRAILER HITCH OR I PANICKED AND HIT GAS INSTEAD OF BRAKE NOT SURE BUT MY CAR IS VERY MESSED UP I HAVE FULL COVERAGE THRU AAA SINCE 1991 I CALLED MY AGENT SHE SAID CALL CHEVY AND GAVE ME THE # CHEVY PAID TO HAVE IT TOWED T TO LOCAL DEALER FOR DIAGNOSTICS. WHEN I HAD A EST. WRITTEN BY CHEVY DEALER I SHOWED THE MANAGER THE STIFF STEERING HE AGREED YES IT IS NOT WORKING NO POWER STEERING ASSIST I GUESS IT IS ALL ELECTRIC AND SOME SENSOR WENT BAD AGAIN IT GOES OUT THEN I TURN OFF CAR AND RE START THEN IT RE SETS AND WORKS AGAIN I ALSO CHECKED AND FOUND OUT THAT THERE HAS BEEN 300 DEATHS IN THE U.S. AND 1 IN CANADA FROM THIS I WAS NEVER NOTIFIED ABOUT THE RECALL THAT HAS BEEN OUT SINCE APRIL OF 2014 I FOUND OUT ABOUT IT WHEN IT WENT OUT THE FIRST TIME AND WAS ADVISED THERE IS A RECALL ON THE POWER STEERING ASSIST I WORKED FOR G.M. FOR OVER 30 YEARS AND WORKED AT THE REPAIRING DEALER FOR OVER 20 YEARS BUT I AM RETIRED NOW IT IS NOT THE DEALERSHIPS FAULT JUST DEFECTIVE PARTS OR DESIGN .I JUST AM BLESSED NO ONE WAS AROUND TO GET HURT OR KILLED BY THE STEERING FAILING ON A TURN THERE COULD HAVE BEEN PEOPLE WALKING BEHIND THIS TRUCK OR KIDS THANK GOD THERE WAS NO FOOT TRAFFIC THAT EARLY IN THE MORNING . *TR
Steering, Jan 16, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE DRIVING 35 MPH, THE POWER STEERING SEIZED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE STEERING RACK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.
Steering, Jan 15, 2015
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT MENTIONED THAT VEHICLE WAS EXHIBITING THE SAME FAILURES MENTIONED IN NHTSA CAMPAIGN NUMBER: 14E044000 (STEERING). THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE U-JOINT BEARING, RACK AND PINION, AND THE INTERMEDIATE SHAFT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 205,000.
Steering, Jan 14, 2015
THERE WAS NO ACCIDENT, BUT THIS IS A COMPLAINT AGAINST GM FOR FAILING TO REPLACE ALL NECESSARY COMPONENTS FOR A RECALL. ON 3/31/14, GM ISSUED A RECALL NOTICE, #14V153000 FOR 1.3 MILLION CARS UNDER 4 SEPARATE BULLETINS & THIS INCLUDED MY 05 MALIBU FOR STEERING: ELECTRIC POWER ASSIST - THERE MAY BE A SUDDEN LOSS OF ELECTRIC POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME (BULLETIN 14116). UNDER BULLETIN 14116, GM WOULD REPLACE ONLY THE TORQUE SENSOR ASSEMBLY (NOT THE STEERING MOTOR) FOR CERTAIN GM CARS INCLUDING MY CAR AND THE GM DEALER DID SO ON 10/21/14. SUBSEQUENTLY ON 1/10/15, THE POWER STEERING FAILED AND ON 1/14/15, I TOOK THIS CAR TO THE DEALER AND THEY STATED THE STEERING MOTOR MODULE 6.605 WAS DEFECTIVE AND REPLACED IT ON THE SAME DAY. I HAD TO PAY FOR THIS SINCE IT WAS NOT COVERED UNDER THE BULLETIN THIS PART SEEMS TO BE THE SAME PART THAT WOULD BE REPLACED UNDER THE OTHER 3 GM BULLETINS, # 14115, 14117 & 14118 FOR THE SAME/SIMILAR STEERING PROBLEM. MY CONCERN IS THE STEERING MOTOR MODULE WAS NOT INITIALLY DEEMED TO BE A HAZARD FOR GM CARS COVERED UNDER THE 14116 BULLETIN (AND MY 05 MALIBU). THUS, OTHER MALIBU OWNERS UNDER THE 14116 BULLETIN MAY HAVE HAD THE SAME PROBLEM WITH THE MOTOR AND ANOTHER RECALL MAY BE NECESSARY. *TR
Steering, Jan 14, 2015, crash
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE MAKING A RIGHT TURN, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. IN ADDITION, THE CONTACT STATED THAT WHILE DRIVING 50 MPH DURING INCLEMENT WEATHER, THE VEHICLE VEERED TO THE RIGHT INDEPENDENTLY. THE CONTACT TURNED THE STEERING WHEEL TO THE LEFT TO CORRECT THE VEER. THEN THE VEHICLE VEERED TO THE LEFT INDEPENDENTLY. AS A RESULT, THE CONTACT CRASHED INTO A GUARD RAIL. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND NO INJURIES WERE SUSTAINED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS ADVISED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE FAILURE MILEAGE WAS 140,000.
Steering, Fuel/propulsion system, Jan 12, 2015
MY POWER STEERING KEEPS LOCKING UP ON ME AND WILL NOT ALLOW ME TO TURN. IT LOCKS UP WHILE IM DRIVING ON THE HIGHWAY AND IT LOCKS UP SOME TIME WHEN I START THE CAR UP. ALSO MY FUEL PUMP FAILED. IT DOES NOT READ TELLING ME HOW MUCH FUEL I HAVE IN MY TANK. *TR
Steering, Electrical system, Jan 4, 2015
REPLACED A STEERING ROD AT 34000 & 73000 & 105,000 THAT WAS MADE OF METAL LN 05. GM WENT BACK TO PLASTIC THE NEXT YEAR AS THIS DID NOT HOLD UP. SECOND IS THE REMOTE START PROBLEM. I HAD IT REPAIRED TWO DIFFERENT TIMES AT GM AND DOES NOT WORK AS OF NOW. WAS TOLD IT WAS A BCM PROBLEM EACH TIME.AS IT WAS AN EXPENSIVE FIX TEMPORARY THAT IS.AS MANY OTHER PEOPLE HAVE THE SAME PROBLEM WITH THIS CAR! *TR
Steering, Dec 17, 2014
I HAD THE RECALL OF THE SENSOR ON THE ELECTRIC POWER STEERING ACCOMPLISHED IN OCTOBER. I HAVE HAD THE LOSS OF PS THREE TIMES SINCE UPON ACCELERATION AND THE PROBLEM IS WORSE NOW THAN BEFORE THE RECALL. THE DEALER INDICATES THE PROBLEM NOW IS THE VOLTAGE SPIKES PER TSB 08-02-32-005. THIS TSB INDICATES A DEFECTIVE COIL CAUSES VOLTAGE SPIKES IN THE ELECTRICAL SYSTEM THEREBY DAMAGING THE ELECTRIC PS MOTOR/MODULE. THE CODES C0900, B1325, AND C0176 WERE SET. I SPOKE WITH GM WITH NO AVAIL. THERE IS A TSB 10183 WHICH EXTENDS THE WARRANTY TO 10 YEARS AND 100,000 MILES. THIS IS WITH A LOSS OF SIGNAL FROM THE STEERING COLUMN. MY VIN IS NOT COVERED BY THIS TSB. MY CONTENTION IS A LOSS OF PS BY ANY CAUSE IS A SAFETY ISSUE AND GM SHOULD RECALL AND FIX IT. THE TSB ADMITS THE COIL IS DEFECTIVE AS THE TSB REQUIRES A REPLACEMENT WITH A NEW ENHANCED COIL AND A GROUND STRAP ADDED TO THE COIL. THIS IS A MANUFACTURE DEFECT AND SHOULD BE CORRECTED BY GM. ANY VEHICLE WITH THIS DEFECTIVE COIL CAN HAVE THE ELECTRIC PS DAMAGED AT ANY MOMENT WITHOUT KNOWING THAT THE FAILURE HAS OCCURRED. AGAIN, I BELIEVE THIS IS A SAFETY ISSUE. WHAT IS THE POINT OF GM REPLACING THE SENSOR BECAUSE OF A SAFETY ISSUE AND WILL NOT CORRECT OTHER ISSUES THAT CAUSE THE SAME SAFETY ISSUE. WHY WOULD ONE FAULT BE MORE OF AN ISSUE THAN ANOTHER CAUSING THE SAME SAFETY ISSUE? I HAVE ORDERED THE NEW COIL AND RELATED PARTS TO CORRECT THE VOLTAGE SPIKES WHICH COULD DAMAGE OTHER PARTS. THAT STILL LEAVES THE MOTOR/MODULE WHICH THE DEALER INDICATES NEEDS TO BE REPLACED. *TR
Steering, Dec 15, 2014
2005 CHEVROLET MALIBU. STEERING WHEEL FROZE WHILE DRIVING. *TA THE CONSUMER STATED WHEN THE STEERING FROZE, SHE PANICKED AND HIT THE SIDE OF A CURB, WITH THE UNDERCARRIAGE AND THE SHE HIT A POLE. THE STEERING MALFUNCTION OCCURRED SEVERAL TIMES THROUGHOUT THE YEAR. THE DEALER WAS UNABLE TO DIAGNOSE THE PROBLEM *JB
Steering, Fuel system, Gasoline, Dec 10, 2014
I HAVE HAD MY ENGINE STALL DUE TO LACK OF FUEL MULTIPLE TIMES WHICH SEEMS DANGEROUS, I TRAVEL ON THE EXPRESSWAY EVERY DAY. WHAT IF IT HAPPENS AT AN FAST SPEED. I ALSO HAVE HAD MULTIPLE ISSUES WHILE STEERING MY CAR. THERE IS AN LOUD POPPING, COMING FROM A STEERING SHAFT, WHICH HAS JUST GOTTEN WORSE I AM AFRAID THE STEERING SHAFT IS GOING TO BREAK! BOTH OF THESE ISSUES HAVE BEEN AN RECALL FOR 2005 MALIBU. AS I AM CLEARLY HAVING THESE ISSUES MY CAR IS NOT PART OF THE RECALL? WHY NOT? IF SOMETHING HAPPENS AND I END UP IN AN ACCIDENT I SEE A LAWSUIT. NOT TO MENTION I HAVE A 4 MONTH CHILD! *TR
Steering, Service brakes, Dec 2, 2014, crash
TL* THE CONTACT OWNED A 2005 CHEVROLET MALIBU MAXX. WHILE DRIVING DOWNHILL AT APPROXIMATELY 35 MPH WITH THE BRAKE PEDAL DEPRESSED, THE ABS WAS ACTIVATED AND THE STEERING WHEEL SUDDENLY BECAME VERY DIFFICULT TO TURN. THE DRIVER WAS UNABLE TO CONTROL THE STEERING AND THE BRAKES WOULD NOT STOP THE VEHICLE. THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A TREE. THE VEHICLE WAS DESTROYED. NO INJURIES WERE REPORTED AND NO POLICE REPORT WAS FILED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN PROVIDED WAS INCORRECT. THE FAILURE MILEAGE WAS 140,000.
Steering, Dec 1, 2014
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. AFTER STARTING THE VEHICLE, THE STEERING SHAFT AND COLUMN DETACHED FROM THE RACK AND PINION STEERING GEAR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Steering, Fuel system, Gasoline, Power train, Nov 26, 2014
ON 11/21, I TOOK MY 2005 MALIBU TO THE GM DEALERSHIP FOR A RECALL ON THE "STEERING" TO REPLACE THE TORQUE SENSOR ASSEMBLY. NHTSA CAMPAIGN NUMBER: 14V153000. WHEN I LEFT THE DEALERSHIP AND DRIVING FOR AWHILE, I NOTICED MY CAR WOULD PARTIALLY STALL AT TRAFFIC LIGHTS OR STOP SIGNS. I CALLED THE DEALERSHIP WHEN I GOT HOME AND THEY TOLD ME TO BRING IT BACK THE NEXT DAY, BUT I HAD TO WORK. TODAY, 11/26 I TOOK MY CAR TO THE GM DEALERSHIP BECAUSE THE CAR CONTINUES TO PARTIALLY STALL AT TRAFFIC LIGHTS OR STOP SIGNS. I INFORMED ONE OF THE REPS WHAT WAS HAPPENING AND THAT I HAD NO SIGNS OF THIS ISSUE BEFORE THE RECALL REPLACEMENT. I WAS TOLD THEY NEVER WENT UNDER THE HOOD OF MY CAR DURING THE RECALL REPLACEMENT. IT WAS ALL DONE AT THE STEERING COLUMN; THAT THIS ISSUE IS SOMETHING THAT JUST HAPPENS WITHOUT ANY WARNING AT ALL. HE INFORMED ME THAT OTHER FOLKS HAVE COME IN WITH THE SAME ISSUE...NOT SURE IF THIS WAS AFTER THEY ALSO HAD THE RECALL DONE. I TRIED TELLING THE SERVICE DEPT., I HAD NO OTHER ISSUES BEFORE BRINGING MY CAR TO THEM FOR THE RECALL, BUT INSTEAD WAS TOLD THIS WAS NOT THEIR FAULT AND I WOULD HAVE TO PAY FOR WHATEVER IS WRONG WITH THE CAR. I DIDN'T LET THEM TOUCH IT AGAIN. I WILL TAKE IT TO MY MECHANIC, WHO I NEVER HAD AN ISSUE WITH AFTER WORKING ON MY CAR. I NOTICED THERE WAS A RECALL IN 2011 FOR COMPONENT(S): FUEL SYSTEM, GASOLINE; NHTSA CAMPAIGN NUMBER: 11E009000 AND NEVER RECEIVED THIS RECALL. I BOUGHT THIS CAR FROM CAR MAX IN 2011. JUST SPECULATING IF THIS MAY BE MY PROBLEM. I ALSO NEVER RECEIVED THE RECALL FOR NHTSA CAMPAIGN NUMBER: 14V224000 COMPONENT(S): POWER TRAIN. MORE WORK TO DO TO FIND THE ANSWERS. *TR
Steering, Nov 19, 2014
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU CLASSIC. THE CONTACT DID NOT RECEIVE A RECALL NOTIFICATION. WHILE DRIVING APPROXIMATELY 5 MPH THE STEERING ABILITY SEIZED. NO WARNING LIGHTS ILLUMINATED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.
Steering, Nov 17, 2014
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE POWER STEERING FAILED INTERMITTENTLY ON SEVERAL OCCASIONS. THE CONTACT MENTIONED THAT THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER DUE TO BEING TOO LOOSE OR TIGHT. THE CONTACT HAD TO APPLY FORCE TO THE STEERING WHEEL DUE TO THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INDICATED THAT THE POWER STEERING MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14E044000 (STEERING) AND NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 108,233. UPDATED 01/12/15*LJ
Steering, Power train, Electrical system, Nov 17, 2014
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT RECEIVED NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING), AND NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN). HOWEVER, THE PARTS NEEDED TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Steering, Power train, Visibility, Nov 6, 2014
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), BUT THE FAILURE WAS NOT CORRECTED. THE VEHICLE EXPERIENCED SEVERAL FAILURES AFTER THE REPAIR. THE STEERING WHEEL LOCKED, THE WINDOWS DID NOT OPEN OR CLOSE, AND THE VEHICLE JERKED WHILE DRIVING AND WHEN CHANGING GEARS INTO DRIVE OR REVERSE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 32,600.