2005 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,393 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 Malibu model years with reports.
Of the 2005 reports, 65 involved a crash and 45 involved a fire. 69 people were injured and 3 people died.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Representative owner complaints
1,393 reports, newest first.
Steering, Apr 15, 2014
I HAVE A 2005 CHEVROLET MALIBU AND THE DEALER IN MY AREA SAID THAT MY CAR IS NOT COVERED IN THE LATEST GM RECALL. THE STEERING IN MY CAR HAS LOST POWER AND LOSING ITS FUNCTION. I AM AFRAID TO DRIVE MY CAR AND IT IS THE ONLY FORM OF TRANSPORTATION I HAVE. MY CAR SHOULD BE COVERED IN THIS LATEST RECALL. PLEASE ADVISE ME OF WHAT I SHOULD DO. THANK YOU! *TT
Exterior lighting, Apr 13, 2014
I PURCHASED THIS VEHICLE YESTERDAY AND UPON INSPECTION LAST NIGHT I REALIZED THAT THE ORANGE PLASTIC DOME THAT FITS OVER THE LAMP FOR THE PASSENGER SIDE BLINKER IS UNATTACHED, WHEN MY FATHER LOOKED FURTHER INTO IT HE BECAME AWARE THAT THE WIRES ARE MELTED AND SO IS THE PART OF THE ORANGE PIECE THAT ATTACHES, UPON FURTHER RESEARCH IT SEEMS THAT THIS IS A PROBLEM THAT MANY OWNERS OF THIS MODEL HAVE ENCOUNTERED, IS THERE A RECALL OR SOMETHING ON THIS TO HAVE IT REPLACED? *JS
Seats, Apr 11, 2014
DRIVER SEAT WELD ON TRACK ASSEMBLY BROKE. SEAT IS LOOSE. I TOOK TO DEALERSHIP AND ESTIMATE TO REPAIR IS $1000. NOT COVERED UNDER WARRANTY AND NO RECALLS. NOT SAFE TO DRIVE. *JS
Steering, Wheels, Service brakes, Apr 11, 2014, fire
I WAS DRIVING ON THE INTERSTATE ON MY WAY HOME AND MY BACK BREAKS LOCKED UP AND THE TIRES AND HUBCAPS STARTED TO BURN. I HAD NO IMMEDIATE EXIT SO I HAD TO CONTINUE TO ROLL SLOW. ONCE I EXITED THE INTERSTATE MY WHEEL WAS ON FIRE. I PUT IT OUT WITH AN EXTINGUISHER. I ASKED THE DEALER AND THEY SAID NO RECALLS. I HAD TO GET THE TOW TRUCK AND HE SAID IT WAS NOT THE FIRST FOR MY CAR MAKE AND MODEL. I REPLACED THE BREAKS, ROTORS AND TIRES AND 2 WEEKS LATER THE SAME THING HAPPENED AGAIN. ONLY THIS TIME I WAS IN A PARKING LOT OF A GROCERY STORE. SINCE THEN I HAVE HAD A TOTAL BREAK JOB AND REPLACE TIRES AND HUBCAPS. MY POWER STEERING LOCKED UP AND IT WAS VERY HARD BUT WAS ABLE TO USE MANUALLY. THE MANUAL SAID TO SHUT OFF CAR AND RESTART TO RESET THE POWER STEERING. THIS WAS NOT SAFE AND VERY SCARY. *JS
Steering, Apr 9, 2014
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH AND MAKING A RIGHT TURN, THE POWER STEERING ASSIST SUDDENLY MALFUNCTIONED AND THE STEERING WHEEL ERRONEOUSLY TURNED TO THE LEFT, CAUSING THE CONTACT TO DRIVE INTO THE WRONG LANE AND NEARLY CRASH INTO ONCOMING TRAFFIC. THE CONTACT INDICATED THAT DURING THE INCIDENT THE ABS AND POWER STEERING WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE FAILURE MILEAGE WAS 71,284.
Steering, Apr 9, 2014
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THERE WAS A SUDDEN LOSS OF POWER STEERING WITHOUT ANY WARNING. THE STEERING WHEEL WAS DIFFICULT TO TURN EVEN THOUGH FORCE WAS APPLIED CONTINUOUSLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TWICE WHERE THE ELECTRIC POWER STEERING MOTOR WAS REPLACED EACH TIME. IN ADDITION, THE POWER STEERING MOTOR WAS REPROGRAMMED BY THE DEALER. THE FAILURE RECURRED AND THE VEHICLE HAD NOT BEEN REPAIRED. THERE WAS A RECALL RELATED TO THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER 14V153000 (STEERING) HOWEVER, THE CONTACT'S VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE FAILURE MILEAGE WAS UNAVAILABLE.
Visibility, Apr 8, 2014
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED WHILE AT A COMPLETE STOP, SHE HEARD A LOUD BANG. THE CONTACT LATER DISCOVERED THAT THE SUNROOF GLASS HAD EXPLODED. THE SMALL PIECES OF GLASS SHATTERED INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
Steering, Apr 7, 2014
POWER STEERING LOCKS ESPECIALLY IN COLDER WEATHER. VERY DANGEROUS WHEN DRIVING IN AN URBAN CITY. *TR
Steering, Apr 6, 2014
WHILE DRIVING THE POWER STEERING SHUT DOWN. I WAS UNABLE TO STEER THE VEHICLE. LOST ALL CONTROL OF STEERING WHILE IN THE RUSH HOUR OF THE DAY. *TR
Steering, Apr 4, 2014
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER AS THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE EPS MOTOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000 AND THE CURRENT MILEAGE WAS 162,000.
Seats, Apr 2, 2014
THE DRIVERS SEAT HAS BROKEN WHEN SIMPLY SITTING DOWN IN THE VEHICLE AND CAN ONLY BE SAFELY USED IN IT'S LOWEST POSITION. IF YOU TRY TO RAISE THE POWER SEAT, IT TILTS TO THE EXTREME RIGHT, AND ONLY THE LEFT SIDE OF THE SEAT LIFTS. THE CAR IS VERY DIFFICULT TO DRIVE WHILE SITTING ON SUCH AN EXTREME SLANT, AND ALSO HARD TO SEE WHEN SITTING IN THE LOWEST POSITION, UNLESS YOU ARE QUITE TALL. OVERALL, THE SEAT IS NOW VERY WOBBLY AND UNSTABLE IF YOU SHIFT YOUR WEIGHT IN THE SEAT NOT THAT IT HAS BROKEN. I DON'T RECALL AT WHAT MILEAGE THIS HAPPENED - BUT I WAS GETTING INTO THE CAR IN MY DRIVEWAY AND HEARD A LOUD POP OF SOMETHING BREAKING LOOSE, AND THE SEAT FELL TO THE SIDE. FORTUNATELY IT HAPPENED IN MY DRIVEWAY AND NOT WHILE DRIVING. *TR
Electrical system, Latches/locks/linkages, Apr 2, 2014
DOOR LOCKS GO UP AND DOWN CONTINUOUSLY WHILE DRIVING THE CAR. WHEN THE CAR IS PARKED AND NOT LOCKED (INSIDE A SECURE GARAGE), THE FACTORY ALARM GOES OFF WHEN OPENING THE DOORS. THE ELECTRIC LOCK SWITCH ON THE DRIVER DOOR WILL NOT ALWAYS UNLOCK THE OTHER CAR DOORS. THE KEY-IN-IGNITION CHIME HAS STARTED CHIMING EVEN WHEN THE KEYS ARE NOT IN THE IGNITION. THIS ALL STARTED SUNDAY, MARCH 30TH, 2014. IT HAS CONTINUED DAILY FROM THEN UNTIL NOW (WEDNESDAY APRIL 2ND) AND IS STILL HAPPENING. *TR
Steering, Apr 1, 2014
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE STEERING WHEEL EMITTED A CLUCKING NOISE WHILE MAKING A TURN. THE DEALER PERFORMED A DIAGNOSTIC TEST WHICH LOCATED THE FAILURE IN THE STEERING WHEEL DRIVE SHAFT AND COLUMN. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 76, 000 AND THE CURRENT MILEAGE 78,000.
Steering, Mar 31, 2014
THE POWER STEERING FAILED AND THE VEHICLE BECAME VERY DIFFICULT TO STEER. THE VEHICLE'S COMPUTER INDICATED A POWER STEERING PROBLEM. AFTER INVESTIGATING I FOUND OUT THAT THIS IS A KNOWN PROBLEM BY GENERAL MOTORS. *TR
Seats, Mar 31, 2014
DRIVER'S SEAT RIGHT FRONT SUPPORT BRACKET WELD FAILED DURING SLOW TURN. THE CORNER OF THE SEAT DROPPED DOWN, AND NOW IT WOBBLES UP AND DOWN. THE TUBE THAT CONNECTS THE BRACKETS ON BOTH SIDES OF THE DRIVER'S SEAT FAILED AT THE WELD ON THE RIGHT SIDE. THE TUBE APPEARS TO BE TOO THIN FOR THE APPLICATION - THE WELD HAS PEELED A PIECE OF THE TUBING AWAY. THE SEAT BELT IS ATTACHED TO THE SEAT INSTEAD OF THE FRAME. SO NOW THE SAFETY OF THE DRIVER RESTRAINT SYSTEM IS IN QUESTION, BECAUSE THE SEAT IS UNSTABLE. AFTER AN INTERNET SEARCH, IT APPEARS THAT THIS IS NOT AN UNCOMMON PROBLEM, AND IS COSTLY TO REPAIR OR REPLACE THE SEAT. *TR
Electrical system, Engine, Fuel/propulsion system, Mar 28, 2014
LIKE THE CURRENT GM COBALT PROBLEMS, CAR STALLED WHILE TRAVELING ON INTERSTATE. LUCKILY WE WERE ABLE TO PULL TO SIDE OF THE ROAD AND GET TOWED. IT WAS IN THE GARAGE FOR A WEEK AND THEY COULD NOT FIND PROBLEM EVEN WITH DRIVING IT 50 MILES A DAY. LOCAL DEALER SAID THEY HAD NOT HAD PROBLEMS, BUT I COULD BRING IT IN. LOTS OF COMPLAINTS ON INTERNET ABOUT THIS, BUT NO SERVICE BULLETINS OR RECALLS. CAR HAS 35K MILES ON IT, BUT MY WIFE WILL NO LONGER DRIVE IT. *TR
Seats, Mar 22, 2014
THE DRIVERS SEAT REAR INSIDE MOUNTING BRACKET IS BROKEN. IT LOOKS LIKE THE WELD FAILED. SEAT IS VERY UNCOMFORTABLE AND UNSAFE AS IT LUNGES FORWARD WHEN BRAKES ARE APPLIED AS WELL AS FALLS BACK WHEN YOU ACCELERATE. LOOKED ONLINE FOR A FIX AND IT SEEMS THIS IS VERY COMMON AND CHEVROLET HAS NOT RECALLED IT NOR IS TAKING RESPONSIBILITY FOR THIS UNSAFE FLAW. I HAVEN'T TAKEN IT TO A MECHANIC AS I HEARD AND READ THAT IT IS VERY EXPENSIVE TO FIX OR REPLACE IT WITH A JUNK YARD PART...WHICH IS NOT AN ACCEPTABLE REMEDY. *TR
Steering, Mar 17, 2014
I BOUGHT A 2005 CHEVROLET MALIBU NEW IN 2005. SINCE THEN, WE REPEATEDLY LOST STEERING WITH THE CAR. I WAS ONLY RECENTLY MADE AWARE THAT THERE WERE ISSUES WITH THE POWER STEERING MOTOR ON THESE VEHICLES. THEY DO NOT HAVE THE CONVENTIONAL POWER STEERING PUMP, BUT HAVE AN ELECTRICAL POWER STEERING MOTOR. NO RECALL WAS ISSUED. GM KNEW. I VISITED MY LOCAL JUNKYARD THE OTHER DAY. THERE ARE MANY OF THESE CARS WITH FRONT END DAMAGE. I CAN ONLY SURMISE HOW MANY ACCIDENTS/INJURIES/FATALITIES WERE THE RESULT OF THIS STEERING FLAW. GM NEVER INFORMED ME OF THE POTENTIAL RISKS. (I DID NOT MOVE OR CHANGE ADDRESS.) I FOUND OUT VIA THE INTERNET. I NOW SEE WHERE GM IS INVOLVED IN YET ANOTHER SAFETY ISSUE, IGNITION SWITCHES. IS THERE AN INVESTIGATION ONGOING ON THESE STEERING ISSUES? SOMEONE IS GOING TO GET KILLED. *TR
Steering, Suspension, Mar 15, 2014, crash
WAS DOING 40MPH POWER STEERING FAILED SPUN OUT HIT A WALL ENDED UP FACING THE WRONG WAY ON ONE WAY HIGHWAY.. I HAVE HAD SO MANY ISSUES WITH THE 2005 MALIBU IT SHOULD BE PULLED OFF THE ROAD FOR SURE, I HAVE HAD TO REPLACE STRUTS 2 TIMES NOW AND ABOUT TO REPLACE MY 2ND FUEL PUMP, MY CAR HAS STALLED OUT ON MANY OCCASIONS, HAS LEFT ME STRANDED MANY OTHER OCCASIONS. FOR AS MUCH MONEY AS I HAVE SPENT TO BUY THE CAR USED IN 2009 WITH 22000 MILES ON IT COST US 10500$ WE HAVE EASILY SPENT OVER THAT IN REPAIRING IT, THE WORST INVESTMENT I HAVE EVER MADE.. THE LIGHTING CONSTANTLY BURNS OUT THE BLINKERS AND HEADLIGHTS FAIL CONSTANTLY, THE GAS CAP THREADS EXPAND AND OR SHRINK AND CAUSES THE CAP TO EITHER BE IMPOSSIBLE TO REMOVE OR IMPOSSIBLE TO LOCK DEPENDING ON THE WEATHER. I ALSO HAVE HAD ANTI THEFT SECURITY LOCK OUT MANY TIMES WHERE THE CAR STALLS AND LOCKS ME OUT OF USING IT. POWER STEERING FAILED, FUEL WOULD NOT PUMP PROPERLY INTO THE VEHICLE, THE FUEL GAUGE DISPLAYED IMPROPER READINGS, AND THE SPEEDOMETER WAS INOPERATIVE.MY REMOTE KEYS FAIL CONSTANTLY AS WELL, ALIGNMENT WHICH MAKES THE CAR SHAKE/VIBRATE AT SPEEDS 60+ MY CD PLAYER DOES NOT WORK EITHER I HAD DEALERSHIP REPAIR IT BEFORE WARRANTY IT WOULD LOCK THE DISC IN THE PLAYER AFTER WARRANTY PROBLEM STARTED AGAIN,, MY SEAT WARMERS GET STUCK ON IT WAS A CONSTANT PROBLEM EVEN BEFORE WARRANTY WAS DONE THE DEALERSHIP WOULD FIX IT BUT NOW NOT UNDER WARRANTY THEY WOULDN'T REPAIR IT OR THE CD PLAYER AGAIN EVEN THOUGH IT WAS AN OBVIOUS COMPLAINT BEFORE THE END OF THE WARRANTY WELL WE ARE CAR SHOPPING NOW FOR 2 NEW CARS AND I PROMISE YOU I WILL NEVER PURCHASE ANOTHER GM/CHEVY EVER AGAIN WORST CUSTOMER SERVICE WORST CARS AND TO DANGEROUS TO RECONSIDER. *TR
Structure, Mar 13, 2014
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE REMOVING SOMETHING FROM THE TRUNK, THE TRUCK DOOR FELL DOWN AND STRUCK HIM IN THE HEAD. THE CONTACT SUFFERED A CONCUSSION AS A RESULT. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 4,366.
Steering, Engine, Mar 12, 2014
THE CAR IN MENTION ABOVE HAS STALLED FOR NO APPARENT REASON, WHEN STALLED STEERING BECOMES DIFFICULT THIS HAS HAPPENED SEVERAL TIMES OVER THE PAST 5 YEARS. WHEN THE DEALER WAS CALLED THEY SAID THERE WAS NO RECALL, AND IF THERE WAS NO TROUBLE LIGHT ON, IT WOULD BE HARD TO DETECT CAUSE UNLESS IT STALLED WHILE THEY HAD IT IN THE SHOP. WHEN IT STALLS EVERYTHING JUST SHUT OFF. UPON PULLING THE CAR TO THE SIDE OF ROAD WITH HORNS BLARING PUTTING IT IN PARK IT THEN RESTARTS LIKE NOTHING EVER HAPPENED UNTIL NEXT TIME IT DECIDES TO SHUT OFF. WHAT I'M GETTING AT IS THERE A POSSIBILITY THAT GM WILL EXPAND THERE IGNITION SWITCH RECALL TO INCLUDE THE 2005 MALIBU WHICH IN MY OPINION IS EXPERIENCING THE SAME SYMPTOMS OF SUDDENLY SHUTTING OFF OR STALLING THE CAR NOW HAS 100,000 MILE RUNS GOOD OTHER THEN THE STALLING. *TR
Fuel system, Gasoline, Electrical system, Mar 6, 2014
I CONSIDER US LUCKY. WE WERE IN A WAL-MART PARKING LOT 25 MILES FROM HOME, AND THE CAR WOULDN'T START. I PLAYED WITH THE IGNITION OFF AND ON FOR HALF AN HOUR, AND A CONNECTION WAS MADE, AND THE CAR STARTED. I WAS CAREFUL TO KEEP IT RUNNING, AND MADE IT HOME. THE NEXT DAY, THE SAME PROBLEM. THE ELECTRICAL CONNECTION TO THE FUEL PUMP WAS MISSING. I HAD IT TOWED TO MY REPAIR SHOP, AND THEY REPLACED THE IGNITION SWITCH. COST $620.54. ON 2/7/2013 THE FUEL PUMP WAS REPLACED. I FEEL THAT THE INCIDENTS ARE CONNECTED. I THINK THE LOSS OF ELECTRICAL FEED TO THE FUEL PUMP HARMED THE PUMP, AND CAUSED IT TO FAIL. COST OF FUEL PUMP REPLACEMENT WAS $635.11.THIS ADDS UP TO $1255.65 REPAIR BILLS WHICH SHOULD HAVE BEEN UNNECESSARY. I FEEL THERE ARE MORE CARS OUT THERE THAT GM SHOULD BE MADE TO RECALL AND REPAIR WITH BETTER PARTS. I WAS LUCKY! OTHERS WERE NOT, AND WE DON'T NEED MORE UNNECESSARY DEATHS ON OUR HIGHWAYS. *TR
Steering, Electronic stability control (ESC), Feb 25, 2014
I WAS DRIVING AND TURNING A CORNER WHEN THE KEY TURNED OFF AND EVERYTHING LOCKED UP. DOORS LOCKED, THE STEERING WAS HARD TO TURN I HAD TO PULL IT REALLY HARD TO THE LEFT TO MISS THE CLIFF. ALMOST TOOK ME OFF THE CLIFF BUT I WAS ABLE TO STOP IT ON THE SIDE OF THE ROAD. I TRIED TO GET OUT BUT THE DOORS LOCKED ON ME. WHEN I TRIED TO TURN IT BACK ON IT LOCKED UP THE DOORS AGAIN AND WOULDN'T TURN ON. BUT I REALIZED THAT IT WAS STILL IN GEAR AND I WAS ABLE TO START IT AFTER I PUT IT IN PARK. BUT WHEN I DRIVE IT, IT SEEMS LIKE ITS RUNNING OUT OF GAS OR ABOUT TO TURN OFF WHILE I AM DRIVING. *TR
Fuel system, Gasoline, Exterior lighting, Feb 24, 2014
THE CAR STOPS WHEN DRIVING ALSO THE EXTERIOR LIGHT HAVE BURNED OUT THE CASING THAT HOLDS THE BULBS ARE MELTED. *TR
Power train, Electrical system, Feb 20, 2014
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT INDICATED THAT THE ENGINE AND ALL OF THE ELECTRONICS IN THE VEHICLE SUDDENLY SHUT OFF. THE VEHICLE WAS DIAGNOSED BY THE DEALER AND THE CONTACT WAS INFORMED THAT THE IGNITION SWITCH WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 40,600. UPDATED 4/4/14*CN THE CONSUMER STATED THE PROBLEM CONTINUED BUT THE DEALER FOUND THAT THE PCM (POWER CONTROL MODULE) FAILED, PCM WAS REPLACED. *TR