2005 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,393 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 Malibu model years with reports.
Of the 2005 reports, 65 involved a crash and 45 involved a fire. 69 people were injured and 3 people died.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Representative owner complaints
1,393 reports, newest first.
Power train, Engine, Dec 26, 2017
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. ON SEVERAL OCCASIONS, WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO FLEMINGTON BUICK GMC CADILLAC AT (908) 751-4316 (211 US-202, FLEMINGTON, NJ 08822) WHERE NO DIAGNOSTIC FAILURE CODES WERE FOUND AND THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CATALYTIC CONVERTER AND O2 SENSORS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 246,000. THE VIN WAS UNAVAILABLE.
Steering, Dec 20, 2017
VEHICLE LOOSES STEERING AT LOW SPEEDS. PREVIOUSLY HAD A EXTENDED SERVICE CAMPAIGN THAT THEY NEVER HAD PARTS FOR. EXPIRED NOW BUT A RECALL ON OTHER SAME MAKE AND MODEL OF THE SAME YEAR. THIS IS A SERIOUS SAFETY ISSUE AND NEEDS REEXAMINED. CALLED GM AND THEY ARE NOT CONCERNED ABOUT LOSS OF STEERING. WAS DRIVING AND HAD TO MAKE A TURN AT 5 MPH LOST POWER STEERING AND SIGNAL CHIMED. WAS UNABLE TO COMPLETE TURN ALMOST CAUSED ACCIDENT ON CITY STREET.
Steering, Electrical system, Dec 18, 2017
WHILE I WAS DRIVING ON THE INTERSTATE MY POWER STEERING WENT OUT VERY DIFFICULT TO DRIVE CAR OR EVEN MAKE TURNS AND PARALLLEL PARK ALSO ELECTRICAL SYSTEM COMES AND GOES WHEN IT PLEASES I
Steering, Air bags, Engine, Dec 12, 2017
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE DRIVING 60 MPH, THE STEERING WHEEL BECAME INOPERABLE. ALSO, THE AIR BAG AND CHECK ENGINE INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER ADVISED THE CONTACT TO TAKE THE VEHICLE FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS APPROXIMATELY 175,000.
Steering, Dec 12, 2017
THE CAR WAS UNDER RECALL FOR A COUPLE ISSUES WHICH THEY FIXED EXCEPT FOR THE ELECTRONIC POWER STEERING TORQE SENSOR, THEY INSTALLED THE PART BUT SAID THEY COULD NOT PROGRAM THE PART DUE TO ANOTHER PROBLEM. SO I COULDNT AFFORD FOR THEM TO DIAGNOSE IT PLUS PAY TO FIX IT SO I CHECKED IT OUT AND DISCOVERED THAT JUST A FUSE HAD BLOWN. I REPLACED IT AND HEADED BACK TO THE DEALERSHIP, DROPPED CAR OFF AND THEN WAS CONTACTED HOURS LATER SAYING THAT THEY WERE NOT GOING TO FINISH PROGRAMMING THE RECALL BECAUSE THEY ALREADY TRIED ONCE AND I WOULD HAVE TO PAY NOW? IN MY MIND A RECALL IS A RECALL TILL IT IS FIXED! THE VEHICLE IS STILL UNSAFE AND I FEEL THEY SHOULD STILL BE RESPONSIBLE!
Power train, Electrical system, Exterior lighting, Dec 8, 2017
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V252000 (SERVICE BRAKES, HYDRAULIC, ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL). THE VEHICLE WAS TAKEN TO SMITH CHEVROLET CADILLAC AT (209) 632-3946 (1601 AUTO MALL DR, TURLOCK, CA 95380) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION SHIFT CABLE AND THE BRAKE LIGHTING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. LATER, WHILE PULLING IN THE DRIVEWAY, THE TRANSMISSION SHIFT CABLE FRACTURED WITHOUT WARNING AND THE BRAKE LIGHTS FAILED. THE VEHICLE WAS TAKEN BACK TO SMITH CHEVROLET CADILLAC, BUT THE DEALER REFUSED TO SERVICE THE VEHICLE. THE CONTACT STATED THAT THE REMEDY FAILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.
Air bags, Nov 26, 2017, crash
TAKATA RECALL ON 01/10/2012 , I WAS IN A CRASH ,, INVOLVING A AIR BAG DEPOLYMENT IN WHICH , THE AIR BAR DEPLOYED DURRING A CRASH , , I REAR ENDED A CAR AFTER IT HAD STOPPED SUDDENDLY AFTER A PEDIESTRAIN HAD CROSSED THE STREET , UNEXPECTALLY , ,, AFTER THE SUDDEN DEPLOYMENT OF THE AIR BAG , SO MUCH MATERAIL HAD BLOWEN OUT OF THE AIR BAG , HITTING MY HAND , MOST OF THE INJURY WAS ON MY FACE AREA MOUTH WAS BLEEDING AS THE MATERAIL HAD STRUCK MY MOUTH AREA , ,, I THOUGHT THE CAR WAS ON FIRE , FROM THE SMOKE AND MATERAIL EXPLOIDED OUT OF IT , I HAD A HARD TIME SLEEPING AND WAS VERY DISTRUBED BY IT , THE CAR WAS TOWED TO THE JUNK YARD , AS THE INSURANCE COMPANY TOOK THE CAR , AS IT WAS JUNKED , CAN PROVIDE POLICE REPORT AND INSURANCE DOCUMENTS , JUST NEED SOME TIME TO RETRIVE THEM ,
Steering, Power train, Engine, Nov 11, 2017
I WAS DRIVING TO WORK ON THE FREEWAY AND I ACCELERATED TO MERGE INTO TRAFFIC I SLIGHTLY TURNED THE WHEEL TO THE LEFT AND IT WENT TO THE RIGHT AND THE FASTER I TRIED TO GO IT WAS GOING ALL OVER THE ROAD FROM LEFT TO RIGHT.I DIDNT HAVE MUCH CONTROL SO I DECIDED TO GET OFF THE FREEWAY AND GO BACK HOME.
Electrical system, Exterior lighting, Air bags, Nov 7, 2017
IGNITION STAYING STUCK ALOWING STARTER TO CONTINUE TO TURN, DAY TIME NO BREAK LIGHTS , NIGHT TIME BREAK LIGHTS STAY LIT UP OR FLASH ON AND OFF , FUEL GAUGE DROPS TO EMPTY EVEN WHEN FULL BOUNCES BACK AND FORTH EMPTY FULL , SERVICE AIR BAG AND CHECK ENGINE LIGHTS KEEP COMING ON EVEN AFTER THEY HAVE BEEN RESET, CRUISE CONTROL WILL NOT ENGAGE , HARD TIME TO TAKE CAR OUT OF PARK EVEN WITH BRAKE DEPRESSED, LOWER GEARS ON TRANSMISSION WILL NOT ENGAGE INTO 3,2,1 SPEED, DRIVER SEAT BRACKET BROKE IN WELD CAUSING SEAT TO BE UNSTABLE, FAULTY IGNITION SWITCH AND MORE THIS CAR HAS LESS THAN 150 K ON IT 148 AND SOME CHANGE,,, AIR BAG SERVICE LIGHT KEEPS COMING ON AS WELL AS CHECK ENGINE LIGHT, THIS CAR WILL NOT PASS ANY STATE INSPECTION , AND EVEN STATES WITH OUT INSPECTION WOULD ADVISE THAT THE CAR BE RECALLED
Steering, Electronic stability control (ESC), Nov 2, 2017
I'M STATIONARY POSITION MY STEERING WHEEL AUTOMATICALLY TURNS 90 DEGREES TO THE RIGHT AND VIBRATES BACK AND FORTH. IF I TURN IT TO THE LEFT AND LET GO, IT AUTOMATICALLY TURNS RIGHT. WHEN I'M DRIVING, IT DOES THE SAME THING BUT NOT AS BAD. IF I LET GO OF THE STEERING WHEEL WHILE DRIVING DOWN THE HIGHWAY IT WILL TURN RIGHT THEN TURN STRAIGHT ALMOST LIKE A ZIGZAG PATTERN. EVENTUALLY POWER STEERING WILL GO OUT AND I HAVE TO PULL OVER, SHUT MY CAR OFF AND START IT BACK UP TO REATTAIN POWER STEERING . I CONTACTED CHEVY CUSTOMER CARE AND THEY SAID THEY CAN'T FIX THE RECALLED PROBLEM BECAUSE THE SERVICE WAS ALREADY PERFORMED EARLIER IN THE CAR. (FIGURED THEY WOULD HAVE A WARRANTY ON THEIR OWN PART)THEY REFUSED TO HELP WITH ANY CASH ASSISTANCE AND DUE TO HAVING 200K MILES ON IT THEY WILL NOT FIX IT IN ANY WAY. IT'S A KNOWN ISSUE IN MY YEAR OF CAR.
Steering, Oct 25, 2017
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU CLASSIC. WHILE DRIVING 30 MPH AND TURNING THE STEERING WHEEL TO THE LEFT, THE VEHICLE FAILED TO TURN. THE CONTACT STATED THAT THE STEERING WHEEL HAD TO BE TURNED SEVERAL TIMES IN ORDER FOR THE VEHICLE TO TURN. THERE WERE NO WARNING INDICATORS ILLUMINATED. WHILE DRIVING TO AN INDEPENDENT MECHANIC, THE POWER STEERING COMPLETELY FAILED. THE INDEPENDENT MECHANIC DISCOVERED THAT THE RACK AND PINION WAS RUSTED AND DETACHED FROM THE FRAME. THE CONTACT STATED THAT THE FRAME WAS REPLACED BY THE INDEPENDENT MECHANIC. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA SINCE THE VEHICLE WAS OUT OF WARRANTY. THE FAILURE MILEAGE WAS APPROXIMATELY 153,000. *TT UPDATED 9/12/18*JB
Other or unspecified, Sep 25, 2017
SINCE 2010, WITH CAR ONLY BEING 5 YEARS OLD, THE KEY BEGAN HARDLY WORKING IN THE IGNITION. WE HAD TO KEEP JIGGLING AND RE-TRYING UNTIL WOULD WORK. THE RECALL ONLY COVERED NOTIFYING OWNERS NOT TO PUT EXTRA KEYS ON THEIR KEY CHAIN BUT WOULD NOT COVER THE FACT THAT THE IGNITION LOCK CYLINDER WAS FAULTY. CONTINUED TO LIVE WITH THIS PROBLEM, THEN THE THEFT DETERRANT LIGHT STARTED GOING ON BECAUSE OF THE NECESSARY JIGGLING -- WHERE THE CAR WON'T START AND YOU HAVE TO TURN TO ACC AND WAIT 10 MINUTES. ONCE AGAIN, DEALER REFUSED TO COVER. STATIONARY PROBLEM, BUT FOR MY ELDERLY FATHER, NOT GOOD FOR THE KEY NOT TO WORK FOR A WHILE, OR WILL NOT START FOR AT LEAST 10 MINUTES DUE TO THEFT SYSTEM BEING ACTIVIATED
Steering, Sep 20, 2017
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. WHILE DRIVING VARIOUS SPEEDS, THE STEERING WHEEL SEIZED AND PULLED TO THE LEFT. BILL CRISPIN CHEVROLET IN SALINE, MICHIGAN WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000.
Steering, Electronic stability control (ESC), Sep 20, 2017
WHEN ACCELERATING TO FOR EXAMPLE MARS ONTO THE INTERSTATE, THE STEERING LOCKS UP AND POST LEFT WHILE IT ALL WARNING LIGHTS FLASH IN THE SYSTEM CHIMES THREE TIMES. AFTER LETTING OFF THE GAS AND THE STEERING COMES BACK IN THE VEHICLE IS ONCE AGAIN CONTROL. BUT UNTIL THEN IT WILL PULL YOU DIRECTLY INTO ONCOMING TRAFFIC
Electrical system, Air bags, Engine, Sep 20, 2017, crash
MY VEHICLE STALLED ON RAIROAD TRACK-WHEN IT HIT THE JARRING --BETWEEN THE PAVEMENT AND THE TRACKS---THE TRAIN WAS AT A GREAT DISTANCE---SO THE ENGINEER STATED---WHEN THEY WERE 2078 FEET FROM MY CHEVROLET MALIBU -2005---THEY STARTED TO BLOW WHISTLE----WHEN I SAW TGHE TRAIN AT A GREAT DISTANCE -AND YES I DID HAVE HEAVY THINGS ON MY KEYCHAIN--BUT GM FAILED TO NOTIFY -I HAVE A MAILBOX AND A TELEPHONE--I WAS HITTING THE GAS PEDAL OVER AND OVER AGAIN AND WHEN I WAS DOING THAT I REMEMBER HITTING THE IGNITION SWITCH BUT THE CAR WAS ALREADY DEAD-I WAS IMPACTED AND ALMOST LOST MY LIFE---IT TOOK ME 3 YEARS TO RECOPERATE----I DID NOT KNOW ABOUT THE RECALL--AND THEY STARTED THE RECALL IN 2014--COVER UP GM--YOU SHOULD HAVE STARTEDIT IN 2010!!!!!!!!!!!!!!! THERE ARE 26 PHOTOS -BUT NOT IN MY POSESSION I WILL ATTEMPT TO OBTAIN THEM----
Service brakes, Sep 12, 2017
I HAVE HAD TO REPLACE THE BREAKS ON MY CAR SIX TIMES IN TWO YEARS. I REPLACED EVERYTHING I CAN THINK OF AND THE BRAKES ARE WEARING OUT ONLY ON THE DRIVER SIDE FRONT.
Steering, Aug 30, 2017
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE ATTEMPTING TO PARK, THE POWER STEERING MESSAGE ILLUMINATED AND THE STEERING BECAME HARDER. THE VEHICLE WAS TURNED OFF AND THEN BACK ON. THE VEHICLE STARTED NORMALLY. THE CONTACT ALSO STATED THAT THE SAME FAILURE OCCURRED TWICE BEFORE BUT EVERY TIME THE VEHICLE WAS TURNED OFF AND RESTARTED, THE VEHICLE RESUMED TO NORMAL. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR A DIAGNOSIS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT THE VIN WAS NOT PART OF THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.
Other or unspecified, Aug 28, 2017, crash
MY VEHICLE STOPPED ON THE RAILROAD TRACKS-THE TRAIN WAS APPROXIMATELY 1 MILE -OR SO AWAY- THE CAR JUST STOPPED-I THEN KEPT HITTING ON THE GAS PELTAL WITH NO MOVEMENT-SO I TOOK MY SEATBELT OFF AND OPENED MY DOOR -TO RUN AWAY FROM THE SCENE OF THE ACCIDENT- BUT IT WAS TOO LATE THE TRAIN STRUCK IN FRONT OF MY PASSENGER DOOR-I WAS SUPPOSE TO DIE THAT NIGHT-THEY REACHED OUT TO MY FAMILY-BUT BY THE GRACE OF GOD I AM STILL ALIVE-STILL LIVE WITH THE INJURIES THAT WERE SUSTAINED----
Air bags, Aug 16, 2017
I WAS DRIVING HOME FROM WORK ONE MORNING 8/10/17 7:30AM . I STARTED TO SMELL SMOKE FROM THE STEERING WHEEL THEN I SEEN ON THE RADIO SERVICE AIR BAG I RUSHED HOME BUT BEFORE I GOT HOME MY AIR BAG DEPLOYED INCHES AWAY FROM MY CHEST . I MADE IT HOME SAFE I AM JUST AM STILL DAZED AT THE WHOLE EXPERIENCE.
Steering, Aug 7, 2017
BULLETIN #08-02-32-005A FIXED ON 8/4/2017 $484.34 RECALL ON CHEVROLET TRUCKS ISSUED 08/05/2017 FOR SAME THING
Steering, Aug 4, 2017
TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE ATTEMPTING TO TURN OUT OF A PARKING SPOT, THE STEERING WHEEL BECAME EXTREMELY DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO JIM TAYLOR CHEVROLET (139 GRIMSHAW ST, RAYVILLE, LA 71269) WHERE IT WAS DIAGNOSED THAT THE POWER STEERING CONTROL MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND TRANSFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 161,900.
Exterior lighting, Vehicle speed control, Jul 31, 2017
HEADLIGHTS AND FRONT BLINKERS QUIT WORKING. WHEN I WENT TO CHANGE THENERGY-SAVING LIGHTS THE CONNECTORS WERE MELTED AND WIRES WERE EXPOSED. THE ORANGE LENSE ON THE DRIVERS SIDE HAS MELTED AND IS DISCONNECTED FROM THE FIXTURE AND IS LYING INSIDE THE LIGHT INCLOSURE. THE LIGHTS AND BLINKERS QUIT WORKING AS I WAS DRIVING THE VEHICLE. I CANNOT DRIVE THE VEHICLE AT NIGHT BECAUSE I AM AFRAID TO HAVE THE LIGHTS ON FOR FEAR OF POSSIBLE FIRST HAZARD. THE CRUISE CONTROL STOPPED WORKING AROUND THE END 2016
Other or unspecified, Jul 8, 2017
AS I WAS DRIVING UP THE HIGHWAY AT AROUND 50 MPH, WITH MY THREE KIDS INSIDE, MY 2005 MALIBU LS JUST DECIDES TO START LOSING SPEED (I USED HAZARD LIGHTS) AND JUST GRADUALLY STOPS!! A NEIGHBOR HELPED ME GET MY CAR DOWN THE HIGHWAY AND TO OUR APARTMENTS. I TRIED ABOUT TWENTY MINUTES LATER TO START MY CAR .IT COULD NOT HAVE BEEN THE BATTERY OR THE FUEL PUMP BECAUSE ALL THE ELECTRICAL LIGHTS IN THE CAR STILL CAME ON AND THE GAS NEEDLE MOVED WHEN MY KEY WAS TURNED TO THE ON POSITION. HOWEVER MY CAR DID NOT EVEN CRANK. IT STILL DOESN'T WANT TO START. I LIVE OUTSIDE OF CITY LIMITS AND I OWN MY CAR BUT THIS RANDOM INCIDENT CAN CAUSE ME TO LOSE MY JOB AND APARTMENT. I PURCHASED THIS VEHICLE LESS THAN A YEAR AGO AND HAD NO PRIOR PROBLEMS. I COULD HAVE BEEN KILLED ALONG WITH MY KIDS THIS IS VERY UNSAFE. THERE IS RECALL #11E009000 NOT SURE IF IT IS WHY THIS CAR ALMOST KILLED US BUT GM DEFINITELY OWES AN EXPLANATION FOR THESE FAULTY KILLER CARS ON THE ROAD.
Fuel/propulsion system, Jul 6, 2017
THESE ARE THE PHOTOS TAKE OF THE FUEL PUMP AFTER IT WAS REMOVED BY MATHIS AUTO SERVICE (SEE THE ATTACHED INVOICE). AS YOU CAN SEE THE TAG HAS ONLY A SMALL PART OF A BAR CODE, I DIDN'T KNOW WHETHER OR NOT THIS WAS THE PART NUMBER OR NOT, BUT IT SEEM THERE WAS NO NUMBER. THE TOP OF THE PUMP WAS VERY DIRTY AND WET FROM GASOLINE. I HAD THE FUEL PUMP REPLACE AFTER I WAS TRANSPORTING A CLIENT AND THE CAR STARTED SPUTTERING AND LOST POWER FROM 45-MILES-PER HOUR TO ABOUT 10-MILES PER HOUR, BEFORE I WAS ABLE TO TURN INTO A PARKING LOT. THIS SCARED THE CLIENT AND LEAD THEM TO REPORT TO LYFT ABOUT THE INCIDENT. I ALSO REPORTED THE ISSUE TO LYFT RIDE SHARE AND THEY SHUT DOWN MY VEHICLE FOR SAFETY REASONS BY DEACTIVATING MY ACCOUNT. SINCE THEN I HAVE HAD THE CHEVROLET DEALERSHIP TO COMPLETE 4 RECALLS, WHICH DID NOT CLEAR UP THE PROBLEM. OR CORRECT THE FUEL PUMP FROM SEIZING UP AND STALLING OUT. I PAID FOR THE REPLACEMENT PART OF A NEW FUEL PUMP AND EVERYTHING HAS BEEN WORKING PROPERLY. AND MY ACCOUNT HAS BEEN REACTIVATED WITH LYFT. I SPOKE TO TI AUTOMOTIVE CEO, ABOUT THEIR RECALL ON THEIR FUEL PUMP SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION. I WAS TOLD THESE ISSUE WAS ONLY IN 2010 MODELS AND THEY WILL NOT REPAIR OR ACKNOWLEDGE THE DEFECTS IN EARLIER MODELS OF CHEVY MALIBU. BUT THERE ARE ISSUES WITH OTHER YEARS MODELS STALLING OUT IN TRAFFIC.
Other or unspecified, Jun 21, 2017
IGNITION SWITCH SOMETIMES WILL NOT START CAR IN PARK (AN OCCASIONAL PROBLEM ON THIS VEHICLE IS FAILURE OF THE IGNITION LOCK CYLINDER.FAILURE OF THE IGNITION LOCK CYLINDER MAY PREVENT THE VEHICLE FROM STARTING )