2006 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,385 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Malibu model years with reports.
Of the 2006 reports, 53 involved a crash and 7 involved a fire. 31 people were injured.
What owners report most often
Recalls and investigations
Steering, electric power assist systemFeb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Campaign 15V064000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Air bags, frontalOct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Campaign 06V417000 on NHTSA.gov
Equipment, other, labelsOct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 05V486000 on NHTSA.gov
Representative owner complaints: electrical system
170 reports, newest first. Show all
Steering, Electrical system, Fuel/propulsion system, Jan 13, 2019
YESTERDAY, WHEN TRYING TO PARK, I HEARD A CHIME AND THE MESSAGE "POWER STEERING" POPPED UP ON THE INFO SCREEN. THE CAR BECAME INCREDIBLY HARD TO STEER, SO I'M THINKING THE POWER STEERING HAD SHUT OFF. I TURNED MY CAR OFF, THEN BACK ON, AND THE POWER STEERING CAME BACK ON, SO I WAS ABLE TO PARK THE CAR CORRECTLY. WHEN WE WERE ABOUT TO HEAD HOME, AS SOON AS I TURN ON A BUSY STREET, JUST BEFORE GETTING ON THE HIGHWAY, THE CHIME GOES OFF, THE MESSAGE POPS UP, AND MY POWER STEERING SHUTS OFF AGAIN. I TURNED (WITH ALL MY MIGHT) INTO AN EMPTY PARKING LOT AND TURNED THE CAR OFF FOR A LITTLE BIT. MY FAMILY AND I WERE LOOKING UNDER THE HOOD, BUT WE WEREN'T SURE WHAT TO CHECK FOR. WE EVENTUALLY GOT BACK IN THE CAR AND WENT HOME. THANKFULLY, THE POWER STEERING STAYED ON AND WE GOT HOME SAFELY (17 MILES ON THE HIGHWAY). I'M JUST WORRIED THAT IT WILL EVENTUALLY TURN OFF ON ITS OWN AGAIN. IF I HAVE TO SCHEDULE A SERVICE APPOINTMENT, I WOULD LIKE TO GO IN PREPARED THIS TIME. A FEW MONTHS AGO, WHEN I HAD A BRAKE LIGHT ISSUE, ONE PARTICULAR SERVICE DEPARTMENT TRIED CHARGING ME $500+ FOR A PART. THE STEERING WHEEL SHIMMIED ON IT'S OWN ONLY ABOVE 50 MPH, I TRIED IT OUT AND I'LL TELL YOU, IT'S A TWO HANDED FIGHT TO KEEP THE CAR UNDER CONTROL.
Electrical system, Engine, Fuel/propulsion system, Oct 19, 2018
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS SPEEDS, IT STALLED WITHOUT WARNING ON SEVERAL OCCASIONS. ON EACH OCCASION, THE CONTACT IMMEDIATELY ACTIVATED THE HAZARD LIGHTS AND COASTED THE VEHICLE TO THE SIDE OF THE ROAD. THE CONTACT STATED THAT THE ANTI-LOCK BRAKE WARNING INDICATOR ILLUMINATED AND THE VEHICLE STALLED AND WOULD NOT RESTART AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. AN INDEPENDENT MECHANIC REPLACED THE ALTERNATOR, IGNITION SWITCH, STARTER, FUEL TANK, AND THE BATTERY; HOWEVER, THE FAILURES RECURRED. VANDERGRIFF CHEVROLET (1200 WEST INTERSTATE 20, ARLINGTON, TEXAS 76017, (682) 323-2486) WAS MADE AWARE OF THE FAILURES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED BY THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 180,000.
Electrical system, Oct 18, 2018
MY 2006 CHEVY HAS BEEN HAVING SOME SORT OF ELECTRICAL ISSUE. THE POWER LOCK DOOR WILL NOT UNLOCK BY PRESSING THE BUTTON AND INSTEAD WILL ON THEIR OWN LOCK AND UNLOCK THEMSELVES WITHOUT THE BUTTONS OR CAR RUNNING FOR SOME INSTANCES OF 1 MINUTE UP TO 5 MINUTES. WE HAVE HAD TO PRY A WINDOW OPEN TO GET INSIDE THE VEHICLE TO TURN THE VEHICLE OFF. HOWEVER SOMETIMES YOU ARE UNABLE TO GET THE DOORS TO UNLOCK WITHOUT TURNING THE KEYS IN THE MANUAL CAR LOCK LOCATED ON THE DRIVER'S SIDE DOOR. THE LOCK PULSE WHEN SITTING STILL OR DRIVING THE CAR.
Electrical system, Exterior lighting, Service brakes, Sep 24, 2018
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING VARIOUS SPEEDS, THE BRAKE LIGHTS ILLUMINATED WITHOUT DEPRESSING THE BRAKE PEDAL. THE VEHICLE WAS TAKEN TO JAMES MARTIN CHEVROLET (6250 WOODWARD AVE, DETROIT, MI 48202, (313) 444-8226) TO BE SERVICED PER NHTSA CAMPAIGN NUMBER: 14V252000 (SERVICE BRAKES, HYDRAULIC, ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRICAL STABILITY CONTROL), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER WHERE IT WAS DETERMINED THAT THE WARRANTY WAS EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.
Electrical system, Electronic stability control (ESC), Aug 12, 2018
TAKATA RECALL THE SECURITY SYSTEM LOCKED UP AND THE INGNITION WON'T TURN OVER SO THE CAR REFUSES TO START. THIS ALL HAPPENED WHEN I PUT IT IN NEUTRAL AND IT JUST SHUTOFF. THEN REFUSES TO START.THE CAR WAS TECHNICALLY STATIONARY, MY FOOT WAS IN THE BRAKE WHILE IT WAS IN NEUTRAL. WE WERE ABOUT TO TURN INTO A CHURCH PARKING LOT WHEN IT STALLED OUT AND WOULD NOT COME BACK ON.
Steering, Electrical system, May 28, 2018
14V153 RECALL WAS DONE AND PROBLEM CAME BACK WAS TOLD I NEEDED TO PAY FOR INSPECTION / DIAGNOSTIC. COMPUTER SCAN SHOWS SAME FAIL OF SHAFT TORQUE SENSOR
Electrical system, Oct 12, 2017
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT HAD NOT EXPERIENCED ANY FAILURES UNTIL THE VEHICLE WAS TAKEN TO CHEVROLET OF HOMEWOOD (18033 HALSTED ST, HOMEWOOD, IL 60430, (708) 799-2000) FOR THREE MANUFACTURER RECALLS. WEEKS AFTER THE REPAIR, THERE WAS A LOSS OF POWER AND THE VEHICLE WAS UNABLE TO START. THE CONTACT REPLACED THE BATTERY, THE VEHICLE WOULD NOT START WHEN THE KEY WAS INSERTED IN THE IGNITION. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE DEALER AND MANUFACTURER WERE NOTIFIED. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.
Steering, Electrical system, Aug 7, 2017
WHEN ACCELERATING AROUND 2500-3500 RPM YOU WILL HEAR A CHIMING SOUND IN THE CAR ALL INFORMATIONAL DASH LIGHTS (BRAKES,CHECK ENGINE, LOW TIRE PRESSURE.) WILL SHOW UP ALONG WITH A POWER STEERING ISSUE IN THE DIC (DRIVER INFORMATION CENTER.) WITH POSSIBLE LOSS OF POWER STEERING AFTERWARDS. THE SAME ISSUE ON PREVIOUS YEAR AND SOME 2006 MODELS HAVE A RECALL REGARDING THIS EXACT ISSUE, BUT NOT ALL 2006 MODELS THUS CAUSING A SERIOUS SAFETY CONCERN FOR THOSE THAT ARE EFFECTED BY THE POWER STEERING ISSUE, BUT NOT UNDER THE RECALL.
Electrical system, Engine, Jul 24, 2017
ENGINE GOES INTO ENGINE POWER REDUCED MODE WHILE GOING 55 ON A HIGHWAY AND SOON THE ENGINE BECOMES DISABLED WHICH DISABLES THE STEERING AND THE BRAKES. NO INJURIES AS I WAS SMART ENOUGH TO HANDLE THE SITUATION, BUT THIS HAS OCCURRED MORE THAN ONCE AND MY CAR READS NO CODES FOR THE SITUATION.
Electrical system, Jun 16, 2017
MY CAR SHUTS OFF WHILE DRIVING. THE LOW RPMS WILL FLUCTUATE AND THE POWER WILL TURN OFF.
Electrical system, Latches/locks/linkages, Apr 18, 2017
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 25 MPH, THE BATTERY WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BCM WAS CONTROLLING THE CHARGING OF THE ALTERNATOR, WHICH DAMAGED THE BEARINGS AND ALTERNATOR. THE BEARINGS AND ALTERNATOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. AFTER THE REPLACEMENT OF THE ALTERNATOR, THE POWER STEERING, HEADLIGHTS, AND ALL THE INSTRUMENT PANEL WARNING INDICATORS INTERMITTENTLY ILLUMINATED. ALSO, WHEN THE CONTACT EXITED THE VEHICLE, THE DOORS INDEPENDENTLY LOCKED WHILE THE ENGINE WAS RUNNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V224000 (POWER TRAIN), 14V153000 (STEERING), AND 14V252000 (SERVICE BRAKES, HYDRAULIC, ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 199,000.
Steering, Electrical system, Electronic stability control (ESC), Feb 8, 2017
I WAS TOLD THAT THERE WAS A POWER STEERING ISSUE WITH MANY 2006 CHEVROLET MALIBU'S AND MINE WAS NOT ONE OF THEM. I HAVE HAD ISSUES WITH MY POWER STEERING FOR THE PAST 5 YEARS AND EVERY YEAR IT GOES OUT BETWEEN THE WINTER MONTHS OF JANUARY-MARCH. AND EVERY YEAR I AM TOLD THAT MY CAR IS NOT ONE OF THE RECALLED VEHICLES. I HAVE HAD LIGHTING ISSUES, ELECTRICAL ISSUES, AND POWER STEERING ISSUES BACK TO BACK. THIS IS A HAZARD BECAUSE THEY ALL SEEM TO MALFUNCTION ALL AT THE SAME TIME AND/OR WHILE I'M DRIVING OR PARKED. I HAVE CHILDREN BUT I'M SCARED TO HAVE THEM IN MY CAR. PLEASE HELP ME, I KNOW THAT THIS IS APART OF THE RECALL THIS CAR IS A SAFETY HAZARD. I WILL ATTACH A PHOTO BUT I ALSO HAVE VIDEO.
Steering, Electrical system, Jan 30, 2017
PERIODICALLY POWER STEERING LIGHT COMES ON WHILE DRIVING AND POWER STEERING QUITS WORKING. THIS WOULD OCCUR ON MEDIUM TO HIGHWAY SPEEDS. DEALER STATED SL-N-SENSOR NEEDED REPLACED. REPLACEMENT KIT WAS 06552-PC. *TR
Steering, Electrical system, Exterior lighting, Dec 2, 2016
I HAVE BEEN COMPLAINING ABOUT THESE PROBLEMS FOR YEARS TO MY DEALERSHIP AND HAVEN'T RECEIVED THE PROPER HELP TO GET THESE PROBLEMS TAKEN CARE OF. I HAVE BEEN HAVING PROBLEMS DEALING WITH SUDDEN LOSS OF ELECTRIC POWER STEERING. MY CAR STEERING WHEEL WILL LOCK UP AS SOON AS I TURN THE CAR ON OR EVEN IN THE MIDDLE OF DRIVING ON THE HIGHWAY. THIS IS A HAZARD AND LIFE THREATENING. I BROUGHT MY CAR TO THE DEALERSHIP, BUT THEY INFORMED ME THAT MY CAR DID NOT HAVE A POWER STEERING PROBLEM. BUT MY CAR WAS NOTIFYING ME ON THE SCREEN THAT IT WAS MY POWER STEERING AND THE WHEEL LOCKS UP AS WELL AS CONTINUES TO SHAKE. IT IS STILL CURRENTLY HAPPENING AND GETTING WORSE. MY STEERING SHAFT MAKES A LOT OF NOISE AND I CAN FEEL IT IN THE STEERING WHEEL WHEN I DRIVE. MY BREAK LIGHTS AS WELL AS HEAD LIGHT BULBS ARE ALWAYS GOING OUT AND KEEP HAVING TO BUY NEW ONES. I KNOW THEY WILL G OUT SOMETIMES, BUT HOW OFTEN MINES GOES OUT IS NOT NORMAL. THE AIRBAG ICON ON MY DASHBOARD AS WELL AS THE READING ON MY SCREEN SHOWS THAT SOMETHING IS WRONG WITH MY AIRBAG. I'M AFRAID THAT ONE DAY IT WILL JUST EXPLODE IN MY FACE. I ALSO HAVE ELECTRICAL PROBLEMS WITH MY WINDOWS AND LIGHTS IN MY CAR. THE WINDOWS GET STUCK AND ONLY ONE LIGHT IN MY CAR WORKS (ONE OF THE OVERHEAD LIGHTS). I HAD MY TRANSMISSION CHECKED OUT AND THEY INFORMED ME THERE WAS NO PROBLEM (BUT THEY TOLD ME THAT ABOUT ME POWER STEERING) AND I END UP PAYING TO GET MY SOLENOIDS REPLACED, BUT I WAS NOT REIMBURSED WHEN I BROUGHT IT IN FOR THE TRANSMISSION RECALL. LIKE I'VE SAID, I HAVE BEEN TRYING TO GET ASSISTANCE FROM THE CHEVROLET DEALERSHIP FOR YEARS WITH THESE PROBLEMS, BUT THEY KEEP TELLING ME I DON'T HAVE ANY PROBLEMS. I REALLY FEEL MY LIFE IS IN DANGER WITH ALL THE PROBLEMS I AM HAVING WITH THIS CAR AND I DO NOT FEEL I AM GETTING THE NECESSARY HELP I NEED. CAN SOMEONE JUST PLEASE ASSIST ME AND HELP GET THESE PROBLEMS TAKEN CARE OF. *TR
Steering, Electrical system, Sep 12, 2016
TAKATA RECALL/ I HAVE A 2006 CHEVY MALIBU AND IN THE PAST MONTH EVERY TIME I CHANGE THE TURN SIGNALS AND BRAKE LIGHT BULBS THEY ARE ALWAYS BLOWING FOR NO REASON. AND MY CAR IS STARTING TO GET A LOUD SOUND WHEN I DRIVE IT AND STEERING IS GETTING HARD SOMETIME. I'VE LOOKED FOR POWER STEERING TO CHECK FLUID BUT EVERYONE SAYS MINE IS ELECTRIC SO I TOOK IT TO AUTO ZONE AND THEY SAID IT WAS ELECTRIC AND I NEEDED TO FIX THE TORQUE SENSOR ASSEMBLY IN MY STEERING. I PRETTY SURE THERE IS A RECALL ON THAT PART. AND ALSO I THINK THERE A RECALL ON A PART ON MY TRANSMUTATION. I'M TRYING TO FIND OUT ABOUT RECALLS ON MY CAR. CAN SOMEONE HELP ME CAUSE I'VE GOT MY KIDS AND GRANDKIDS THAT RIDE IN IT EVERY DAY. PLEASE HELP ME.
Electrical system, Engine, Aug 25, 2016
WHILE DRIVING THE TRACTION CONTROL LIGHT COMES ON AND THE ENGINE TURNS OFF COMPLETELY. WHEN BROUGHT IN TO BE LOOKED AT THE SYSTEM SAID THAT THERE WAS NEVER A PROBLEM IN THE FIRST PLACE. WE CANT USE HEATER OR A/C WITHOUT THE CAR DYING 100% OF THE TIME.
Electrical system, Fuel/propulsion system, Jul 9, 2016
FUEL PUMP PROBLEM, EMISSIONS VAPOR LEAK, GAS CAP, IGNITION SWITCH, AND GAS TANK SENSOR PROBLEM. MY CAR IS A 2006 CHEVY MALIBU V6. MY CAR HAS ALL OF THESE PROBLEMS WITH IT AND I HAVE SEEN MANY OTHERS WITH THE SAME PROBLEMS FOR THIS CAR . I BELIEVE THERE SHOULD BE SOMETHING DONE ABOUT IT . IT IS SHOWING UP THOSE CODES. IT ALSO HAS ELECTRICAL PROBLEMS WITH THE POWER MIRRORS AND WINDOWS AND TRUNK . STATIONARY
Steering, Electrical system, Jun 13, 2016
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT UNKNOWN SPEEDS, THE STEERING WHEEL BECAME EXTREMELY DIFFICULT TO MANEUVER AS THE POWER STEERING WARNING LIGHT ILLUMINATED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 15V064000 (STEERING). HOWEVER, THE FAILURE RECURRED IMMEDIATELY AFTER LEAVING THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 113,000. UPDATED 08/17/16*LJ THE CONSUMER STATED ALL THE LIGHTS ON THE DASHBOARD FLASHED AND BELLS WENT OFF, WHILE LOSING POWER STEERING. UPON ACCELERATING. UPDATED 10/25/16.*JB
Electrical system, Jun 3, 2016
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. AFTER THE IGNITION KEY WAS TURNED TO THE ON POSITION, THE VEHICLE FAILED TO START. THE VEHICLE WAS ABLE TO BE STARTED AFTER APPROXIMATELY TWENTY MINUTES. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STARTER FAILED. THE STARTER WAS REPLACED FIVE TIMES, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 157,000.
Electrical system, Air bags, Fuel/propulsion system, Apr 18, 2016
IT STARTED SINCE 2013 AND NEW THINGS ARE JUST HAPPENED WHAT PART OF YOUR CAR WAS AFFECTED? ENGINE ELEC. STABILITY CONTROL SEAT BELTS UNKNOWN OR OTHER
Steering, Electrical system, Mar 25, 2016
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 30 MPH, THE VEHICLE STALLED AND ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT CLUSTER. IN ADDITION, WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL SEIZED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE CONTACT WAS UNSURE ABOUT WHAT PART NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.
Electrical system, Vehicle speed control, Engine, Mar 4, 2016
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING AT 30 MPH, THE SPEEDOMETER GAUGE ON THE INSTRUMENT PANEL FAILED TO INDICATE THE ACTUAL SPEED OF THE VEHICLE. THE CHECK ENGINE WARNING LIGHT ILLUMINATED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Electrical system, Other or unspecified, Feb 1, 2016
THE SOMETIMES WILL NOT START. IT'S LIKE IT'S NOT READING THE KEY. I HAD THE CAR FOR A MONTH AND BOUGHT 6 KEYS AND THAT DID NOT FIX THE PROBLEM.
Steering, Electrical system, Other or unspecified, Dec 15, 2015
I BOUGHT THIS VEHICLE USED FROM PAUL CONTE CHEVROLET IN FREEPORT, NY AND IT HAD 3 RECALLS THAT WERE NOT FIXED BEFORE SELLING IT TO ME. NOW MY POWER STEERING SYSTEM MALFUNCTIONED TO THE POINT WHERE THE STEERING WHEEL WOULD TWITCH UNCONTROLLABLY AND THEN BECOME STIFF, MAKING IT VERY DIFFICULT AND DANGEROUS TO STEER. I ENDED UP PAYING FOR THE REPAIRS TO THE TUNE OF ALMOST $1700.00 TO REPLACE THE STEERING COLUMN AND STEERING MOTOR. AFTER DOING SOME RESEARCH, I FOUND THAT GM RECALLED MANY VEHICLES OF THE SAME YEAR, MAKE, AND MODEL AS MY CAR BUT FOR MY SPECIFIC VIN ONLY THE STEERING TORQUE SENSOR WAS RECALLED. I DID GET THE STEERING TORQUE SENSOR RECALL FIXED BUT MY STEERING WAS STILL MESSED UP. THIS RECALL DID NOT FIX MY VERY SERIOUS AND POTENTIALLY DANGEROUS ISSUE. IT WAS ONLY AFTER I AUTHORIZED THE STEERING COLUMN AND MOTOR REPAIRS THAT THE ISSUE WAS RESOLVED. GM CUSTOMER SERVICE IS SAYING THAT EVEN THOUGH I HAD THE SAME EXACT ISSUE AS THE GM RECALL FOR OTHER MALIBU'S, BECAUSE MY SPECIFIC VIN DID NOT FALL UNDER THE RECALL, I WILL NOT BE GETTING REIMBURSED. IT IS NOT RIGHT THAT GM BE ABLE TO GET AWAY WITH THIS. THIS SERIOUS STEERING ISSUE COULD HAVE CAUSED ME TO CRASH. I WOULD LIKE TO FILE A COMPLAINT AGAINST GM FOR FAILURE TO RECALL ALL VEHICLES THAT WERE AFFECTED BY THIS POWER STEERING ISSUE AND ALSO REQUEST THAT THEY REIMBURSE ME FOR FIXING AN ISSUE THAT SHOULD HAVE BEEN TAKEN CARE OF BEFORE I EVEN BOUGHT THE CAR. THE LINK BELOW WILL TAKE YOU TO THE OFFICIAL GM STATEMENT ON THIS POWER STEERING ISSUE. HTTP://MEDIA.GM.COM/MEDIA/US/EN/GM/VEHICLES.DETAIL.HTML/CONTENT/PAGES/NEWS/US/EN/2014/MAR/0331-POWER-STEERING.HTML
Power train, Electrical system, Nov 16, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER LAST YEAR FOR THREE MANUFACTURER RECALL REPAIRS, WHICH DID NOT REMEDY THE FAILURE. MONTHS AFTER THE VEHICLE WAS TAKEN TO THE DEALER, IT WOULD NOT SHIFT GEARS PROPERLY AND THE VEHICLE SHOOK AND VIBRATED RANDOMLY WITHOUT WARNING. THE CONTACT HAD TO APPLY FORCE TO THE BRAKE PEDAL AND, IF IT WERE RELEASED, THE VEHICLE WOULD RANDOMLY STALL. THE VEHICLE WAS TO BE TAKEN BACK TO THE DEALER FOR FURTHER INSPECTION AND DIAGNOSTIC TESTING TO DETERMINE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 1/19/16 LN *CN