2006 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,385 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Malibu model years with reports.
Of the 2006 reports, 53 involved a crash and 7 involved a fire. 31 people were injured.
What owners report most often
Recalls and investigations
Steering, electric power assist systemFeb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Campaign 15V064000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Air bags, frontalOct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Campaign 06V417000 on NHTSA.gov
Equipment, other, labelsOct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 05V486000 on NHTSA.gov
Representative owner complaints: electrical system
170 reports, newest first. Show all
Electrical system, Nov 12, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHEN ATTEMPTING TO START THE VEHICLE, THE KEY WOULD REMAIN IN THE START POSITION WHILE STILL IN THE IGNITION SWITCH. THE CONTACT STATED THAT IN ORDER TO RESUME NORMAL OPERATION THE VEHICLE HAD TO BE SHUT DOWN AND RESTARTED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Electrical system, Exterior lighting, Nov 6, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE ROADSIDE ASSISTANCE DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE CONTACT STATED THAT THE BRAKE LIGHTS FAILED TO OPERATE. THE VEHICLE HAD NOT BEEN TOWED TO THE DEALER FOR REPAIRS. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL) THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 81,000.
Service brakes, Hydraulic, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Oct 8, 2014
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO RECALL NOTICES. *TGW THE CONSUMER STATED TWO DAYS AFTER THE FIRST RECALL REPAIR, BECAUSE THE REPAIR WAS NOT FULLY COMPLETED, DUE TO LACK OF PARTS, SHE EXPERIENCED TWO EPISODES WHICH SHE DEEMED UNSAFE. WHILE SITTING WITH HER FOOT ON THE BRAKE, AND THE VEHICLE IN DRIVE, SHE SUDDENLY FELT A SLIGHT SHIFT, AS IF THE VEHICLE WAS TRYING TO MOVE FORWARD, WHICH IT DID, WITHOUT ANY WARNING. THE VEHICLE BUMPED A CAR IN FRONT OF HER. THE CONSUMER REFERENCED RECALL # 14V252000. *JB
Service brakes, Hydraulic, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Oct 2, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR THE RECALL REPAIR AND WAS LATER INFORMED THAT THE PART WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 11/20/14*LJ UPDATED 8/12/2015 *JS
Electrical system, Oct 1, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY SHUT OFF WITHOUT WARNING. THE FAILURE OCCURRED ON MULTIPLE OCCASIONS. AFTER RESTARTING THE ENGINE, THE VEHICLE RESUMED NORMAL OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 160,000.
Service brakes, Hydraulic, Power train, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Oct 1, 2014
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO TORQUE SENSOR ASSEMBLY; WIRING HARNESS TO THE BCM OR MAG BEAM AND TRANSMISSION SHIFT CABLE THAT MAY FRACTURE AT ANY TIME. *TGW THE CONSUMER WAS INFORMED, THE PARTS WERE NOT AVAILABLE. *JB
Power train, Electrical system, Vehicle speed control, Sep 17, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). HOWEVER, THE PARTS WERE UNAVAILABLE TO SERVICE THE VEHICLE UNDER THE RECALL. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Electrical system, Sep 15, 2014
TOTAL LOSS OF ELECTRICAL, POWER, STEERING, ETC. THE CAR JUST TURNED OFF. PULLED OVER HIGHWAY TO RESTART ENGINE. IGNITION JUST SHUTOFF WITHOUT WARNING. *TR
Steering, Service brakes, Hydraulic, Power train, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Sep 11, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED RECALL NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBERS: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), 14V153000 (STEERING), AND 14V224000 (POWER TRAIN). THE PARTS NEEDED TO PERFORM THE RECALL REPAIRS WERE UNAVAILABLE. THE DEALER WAS UNCERTAIN WHEN THE PARTS WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Service brakes, Hydraulic, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Sep 8, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL); HOWEVER, THE PARTS NEEDED TO REPAIR THE VEHICLE WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Steering, Fuel system, Gasoline, Electrical system, Vehicle speed control, Seats, Electronic stability control (ESC), Service brakes, Sep 5, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE LIGHTS WOULD WORK INTERMITTENTLY. THE CONTACT REPLACED THE BRAKE LIGHTS ON NUMEROUS OCCASIONS. THE INDEPENDENT MECHANIC REPAIRED THE WIRING HARNESS BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE BCM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED UNDER CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM , ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL) THE REMEDY FAILED TO RECTIFY THE FAILURE. ADDITIONALLY, THE CONTACT ALSO STATED THAT THE HEATED SEAT FUNCTION FAILED AND THE POWER STEERING SEIZED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE APPROXIMATE FAILURE MILEAGE WAS 60,000...UPDATED 10/01/14 *BF THE CONSUMER STATED THE FUEL TANK WOULD SHOW 1/8 OF A TANK, BUT IN ACTUALITY THE TANK WAS EMPTY.
Electrical system, Aug 18, 2014
ABOUT TWO YEARS AGO (2012) MY VEHICLE WOULD HAVE TROUBLE STARTING. WHEN MY CAR WOULD NOT START I WOULD WAIT FOR A MINUTE AND THEN TRY TO TURN VEHICLE ON AGAIN. SOMETIMES THIS 'WAITING' TECHNIQUE WOULD WORK, OTHER TIMES IT WOULD NOT. WHEN IT WOULD NOT WORK I WOULD HAVE TO HAVE MY CAR JUMPED AND ONLY THEN WOULD MY VEHICLE TURN ON. AFTER GOING TO COUNTLESS MECHANICS, INCLUDING THE CHEVROLET DEALERSHIP, I HAD MY IGNITION KEYHOLE REPLACED A FEW MONTHS AFTER THIS INCIDENT BEGAN. THE MECHANIC WHO REPLACED THE KEYHOLE ONLY DID SO BECAUSE HE-LIKE EVERY OTHER MECHANIC WHO LOOKED AT MY CAR- COULD NOT FIND ANY OTHER PROBLEMS THAT WOULD CAUSE MY CAR NOT TO START. HOWEVER, ONLY A COUPLE OF MONTHS AFTER THE KEYHOLE WAS REPLACED THE PROBLEM RE-APPEARED AND HAS PERSISTED EVER SINCE. THE MOST TROUBLE I HAVE HAD WAS IN NOVEMBER OF 2013 WHEN MY CAR HAD TO BE JUMPED 3 TIMES BECAUSE IT WOULD NOT START NO MATTER HOW MUCH TIME I LET THE CAR REST. I HAVE HAD MY BATTERY CHECKED TO SEE IF THAT WAS THE PROBLEM, BUT IT NEVER WAS. I FEEL LIKE MY CAR HAS THE MOST TROUBLE STARTING IN EXTREME WEATHER CONDITIONS (EXTREMELY HOT,COLD OR HUMID). THESE INCIDENTS HAPPEN AT LEAST ONCE A MONTH WITH THE MOST RECENT INCIDENT BEING JUST LAST WEEK. *TR
Electrical system, Aug 15, 2014
MY HUSBAND WAS DRIVING TO WORK AND THE ELECTRICAL SYSTEM COMPLETELY SHUT DOWN. NO POWER TO ANYTHING. *TR
Fuel system, Gasoline, Electrical system, Service brakes, Aug 11, 2014
ON 5/07/2014 I GOT IN MY CAR THAT MORNING TO TAKE MY 4 CHILDREN TO SCHOOL THE CAR STARTED AND DIED 3 TIMES. WHEN IT FINALLY DID START I COULDN'T GET IT OUT OF PARK! WHILE ON THE WAY TO SCHOOL I WAS NEARLY HIT FROM BEHIND BECAUSE MY BRAKES LIGHTS FAILED TO FUNCTION! THE PROBLEMS HAVE GOTTEN WORSE DAILY SINCE THEN. WHEN I WOULD DRIVE THE CAR IT WOULD TAKE OFF ON ITS ON, THE CRUISE CONTROL NO LONGER FUNCTIONS, I HAVE TO TRY AT THE MINIMUM OF 7 TIMES TO GET IT TO CRANK!! NOW IT IS VERY UNSAFE FOR ME TO DRIVE I CAN'T EVEN TAKE MY CHILDREN TO SCHOOL MY NEIGHBOR HAS TO TAKE THEM AND PICK THEM UP! I WAS FINALLY SENT A RECALL LETTER THE LAST DAY OF JULY 2014. IN THIS RECALL ARE ALL THE PROBLEMS I AM HAVING. THEY SAY WHEN CALLED THAT THEY DO NOT KNOW WHEN THE PARTS TO FIX IT WILL BECOME AVAILABLE. WHAT AM I TO DO? I HAVE A CAR I AM PAYING FOR AND CAN NOT DRIVE!! I CAN'T AFFORD TO GO BUY A DIFFERENT CAR. I TOLD THEM SINCE THEY HAD NO IDEA WHEN PARTS WOULD BE IN TO JUST REPLACE MY CAR AND THE ANSWER WAS NO!! THEY ALSO WANT ME TO PAY TO HAVE IT INSPECTED. THIS IS THEIR FAULT NOT MINE I SHOULD NOT HAVE TO PAY FOR ANYTHING!!! *TR
Steering, Electrical system, Jul 29, 2014
AROUND MARCH 2013, I FIRST BEGAN TO ENCOUNTER PROBLEMS WITH MY POWER STEERING. IT BEGAN AT A LOW SPEED WITH A CHIME, A MESSAGE DISPLAY SAYING TO CHECK THE POWER STEERING, AND MY WHEEL LOCKING UP (POWER STEERING FAIL). AT THE TIME, I DID NOT THINK MUCH OF IT BECAUSE AFTER RESTARTING THE CAR, THE POWER STEERING SEEMED FINE. AFTER THIS INCIDENT, THERE WERE MANY TIMES WHEN THE CHIME WOULD SOUND AND THE MESSAGE WOULD FLASH BUT THE POWER STEERING STILL SEEMED TO WORK. I TOOK MY CAR IN FOR OTHER ISSUES AND HAD THIS CHECKED OUT AT THE SAME TIME. THE TROUBLE CODE IN THE SYSTEM WAS C0545 FOR TORQUE SENSOR INPUT FAILURE. MY MECHANIC EXPLAINED THAT THIS WAS A COMMON PROBLEM AND EVEN CHECKED FOR A RECALL AT THAT TIME. I LEFT WITH MY CAR THAT DAY DUE TO HAVING TO WAIT FOR PARTS. TWO DAYS LATER WHILE DRIVING 45MPH, THE POWER STEERING ENTIRELY FAILED. IT FELT AS IF MY WHEEL LOCKED ENTIRELY. LUCKILY THERE WERE NOT MANY CARS ON THE ROAD AND I WAS ABLE TO DIRECT IT INTO A PARKING LOT. MY CAR WAS TAKEN BACK IN IMMEDIATELY AND THEY HAD TO REPLACE THE ENTIRE STEERING COLUMN. THIS REPAIR COST AROUND $500. IN JULY 2014, IT WAS BROUGHT TO MY ATTENTION THAT GM FINALLY ISSUED A RECALL FOR THIS PROBLEM. SO, I CALLED GM TO TO SUBMIT MY INFORMATION TO BE REIMBURSED. I WAS TOLD THAT ONLY SOME 2006 MALIBUS WERE BEING RECALLED FOR THIS ISSUE AND THAT MY 2006 MALIBU WAS NOT ONE OF THEM...EVEN THOUGH MY 2006 MALIBU HAD THE PROBLEM THEY WERE RECALLING FOR! COME TO FIND OUT, THIS HAS HAPPENED TO MANY OTHER 2006 MALIBU OWNERS. NEEDLESS TO SAY, GM HAS DONE A TERRIBLE JOB CORRECTING A SERIOUS MISTAKE. *JS
Steering, Electrical system, Jul 28, 2014
TL- THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED WHILE TRAVELING TO APPROACH A STOP OR WHEN A TURN WAS MADE THE STEERING WHEEL WAS EXTREMELY HARD TO TURN. THE ELECTRIC POWER STEERING FAILED INTERMITTENTLY. THE CONTACT HAD TO APPLY FORCE TO TURN THE WHEEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO REPLACED THE STEERING COLUMN AND THE IGNITION SWITCH. THE FAILURE RECURRED AND THE CONTACT WAS NOT ABLE TO TURN THE KEY TO START THE IGNITION ALONG WITH THE VEHICLE STALLING INTERMITTENTLY. THE ANTI-THEFT SENSOR ILLUMINATED, SERVICE ENGINE SENSOR AND A LOCK SYMBOL ON THE RADIO CONTINUED TO ILLUMINATE. THE RADIO WAS NOT WORKING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 14V153000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000. DYD
Steering, Electrical system, Jul 23, 2014
AS THE POWER STEERING IS SHOWING SIGNS OF FAILURE AND THE DEALERSHIP HAS NOT YET RECEIVED THE PARTS FOR MY BULLETIN FOR THE ISSUED RECALL, THE MECHANIC HAS NOW TOLD ME THE TORQUE FAILURE OF THE POWER STEERING ISSUE IS LEADING TO THE FAILURE OF THE AC CONDENSER AS THEY ARE BOTH RUNNING OFF THE LINKED PULLEYS. I WOULD LIKE TO HAVE THIS LOOKED AT BY THE INVESTIGATIVE COMMITTEE. *TR
Electrical system, Vehicle speed control, Service brakes, Jul 22, 2014
BOUGHT CAR NEW 2/06. ONCE HOME AND DRIVING I NOTICED AN ELECTRICAL ISSUES CONSISTING OF RADIO INTERFERENCE WHEN USING ANY ELECTRICAL BUTTONS IN CAR, SUCH AS WINDOWS, AND MY CHARGING OUTLETS IN THE CAR BLOW FUSES WHEN USED. WHEN I TURN MY AIR OR HEAT ON MY BRAKE PEDAL DROPS DOWN AT LEAST 2 IF SITTING AT LIGHT. IF DRIVING AND I TURN ON MY AIR, THE CAR LUNGES FORWARD. THIS IS AT A CRITICAL LEVEL NOW. I TOOK INTO THEIR DEALERSHIP FROM THE FIRST MONTH I PURCHASED THE CAR UNTIL MARCH OF 2007. NO ONE COULD FIX THE ELECTRICAL ISSUE AND DEALERSHIP COULD NOT SUPPLY ME WITH EVEN THE PAPERWORK TO SHOW ME WHAT THEY RESEARCHED WHILE IT SAT THERE FOR OVER 4 DAYS. PROBLEM IS NOW DEADLY AND I NEED THIS ELECTRICAL ISSUE FIXED. I RECEIVED NOTICE OF RECALL 13036 BUT NOTHING CONCERNING THE PROBLEM WITH THE BRAKE PETAL AND ACCELERATION I HAVE HAD SINCE PURCHASE. CONTACTED DEALERSHIP TO GET (LEMON) REPLACED AND THEY SAID, TOUGH LUCK. PURCHASED AS IS... *TR
Steering, Electrical system, Electronic stability control (ESC), Jul 15, 2014
DRIVING AT 40 MPH, ALL POWERED FUNCTIONS SHUT OFF - NO POWER STEERING, HARD TO BRAKE, AND ENGINE JUST QUITS. ALL "IDIOT" LIGHTS COME ON: FUEL, OIL, STABILITY TRACTION CONTROL... JUST LIKE BEFORE YOU IMMEDIATELY START THE CAR, WHERE ALL LIGHTS FLASH ON. AFTER TWO MINUTES OF REST - I TRY THE CAR AGAIN AND IT STARTS. TODAY, (7/15), THIS INCIDENT HAPPENED WITHIN 10 MINUTES OF EACH OTHER. THE FIST INCIDENT WAS EXACTLY A WEEK FROM TODAY ON 7/08, SAME SPEED, SAME ROAD. THE CART JUST QUITS. I AM USING THIS CAR FOR THIS SUMMER WHERE IT IS ACTUALLY OWNED BY MOTHER. THE CAR WAS PURCHASED FROM JIM O'BRIEN CHEVROLET IN WILLOUGHBY HILLS, OH. *TR
Power train, Electrical system, Vehicle speed control, Service brakes, Jul 10, 2014
WHILE DRIVING AT NIGHT, ANOTHER DRIVER STOPPED TO LET ME KNOW THAT MY BRAKE LIGHTS WERE NOT WORKING. AROUND THIS TIME I ALSO NOTICED THAT MY CRUISE CONTROL WOULD STOP WORKING OR NOT WORK AT ALL. ON SEVERAL OCCASIONS AFTER I FIRST LEARNED OF THE PROBLEM PEOPLE FOLLOWING ME WOULD TELL ME THAT IT LOOKED LIKE I WAS RIDING MY BRAKES WHEN I WAS NOT TOUCHING THE BRAKE PEDAL. WHEN I WOULD PRESS THE BRAKES THEY WOULD GO OFF. I TESTED THIS BY BACKING UP TO MY GARAGE DOOR AND PRESSING THE BRAKES. THEY COME ON WHEN I LIFT MY FOOT OFF THE BRAKE BUT GO OUT WHEN I PRESS THE PEDAL. AROUND THIS TIME I ALSO NOTICED THAT THE GEAR SHIFTER WOULD SOMETIMES STICK/NOT MOVE EVEN THOUGH I HAD MY FOOT ON THE BRAKE PEDAL. MY LOCAL DEALER REPLACED A COMPUTER MODULE AND THAT SEEMED TO CORRECT THE PROBLEM FOR A WHILE BUT THE PROBLEM HAS SINCE COME BACK. *TR
Electrical system, Service brakes, Jul 7, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE WAS EXPERIENCING TRANSMISSION AND BAS SENSOR FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER:14V252000 (ELECTRICAL SYSTEM , ELECTRONIC STABILITY CONTROL , EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC , VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS 80,000 AND CURRENT MILEAGE WAS 97,000.
Steering, Electrical system, Jun 30, 2014
HEARS A CLICKING NOISE FROM CAR THEN IT WILL LOOSE STEERING AND SHUT OFF, NO ACCELERATION, STEERING WHEEL LOCKS UP, NO LIGHTS. ALL TURNS OFF, HAS HAPPEN ABOUT 8 TIMES. NEXT TIME, PUT FOOT ON BRAKE IT JUMPS, ALL SHUTS OFF, IT SOME TIMES TAKE 3 OR 4 TIMES FOR THE CAR TO START BACK UP. CHEVROLET SHOP HAS REPLACED PARTS, STILL CAN NOT FIND OUT WHY IT SHUT OFF. IF THIS HAS HAPPEN TO OTHERS THAT HAS A MALIBU, PLEASE HELP, WITH SUGGESTION ON WHAT THE CHEVY HOUSE CAN DO TO HELP ME OUT. THANKS *TR
Electrical system, Jun 24, 2014, fire
THE DRIVER DROVE INTO HER DRIVE WAY FROM A SHORT DRIVE. WHEN SHE PARKED IN HER DRIVEWAY, SHE NOTICED SMOKE COMING FROM THE UNDER THE DASH BOARD. SHE EXITED THE VEHICLE, RAN INTO HER HOME TO TELL HER MOTHER. WHEN THEY RAN BACK OUTSIDE, THE VEHICLE WAS ENGULFED IN FLAMES. THEY CALLED THE FIRE DEPARTMENT IMMEDIATELY THEREAFTER. THE FIRE MARSHAL CONDUCTED AN INVESTIGATION AS TO THE CAUSE OF THE FIRE AND HE CONCLUDED THAT THE FIRE COMBUSTED FROM WITHIN THE VEHICLE, LIKELY ELECTRICAL. NO ONE WAS INJURED HOWEVER, THE VEHICLE IS TOTALED AND THE DRIVEWAY IS STAINED FROM THE SMOKE AND FIRE. *TR
Electrical system, Exterior lighting, Service brakes, Jun 23, 2014
BRAKE LIGHTS STAY ON WHEN DRIVING, BUT DO NOT COME ON WHEN APPLYING THE BRAKES. *TR
Steering, Electrical system, Jun 17, 2014
ON SEVERAL OCCASIONS MY CAR HAS LOST POWER STEERING NEARLY CAUSING A WRECK. THIS IS A DANGER AND NEEDS TO BE FIXED BUT I WAS TOLD I WOULD BE MAILED NOTICE ON APRIL 28 . I AM VERY CONCERNED FOR THE SAFETY OF MY CHILD AS WELL AS OTHER PEOPLE ON THE ROADWAYS. MY CAR ALSO RANDOMLY LOSES BATTERY POWER.. I ASSUME THIS IS ELECTRICAL. *TR