2006 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,385 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Malibu model years with reports.
Of the 2006 reports, 53 involved a crash and 7 involved a fire. 31 people were injured.
What owners report most often
Recalls and investigations
Steering, electric power assist systemFeb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Campaign 15V064000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Air bags, frontalOct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Campaign 06V417000 on NHTSA.gov
Equipment, other, labelsOct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 05V486000 on NHTSA.gov
Representative owner complaints: electrical system
170 reports, newest first. Show all
Steering, Power train, Electrical system, May 31, 2010
I HAVE A 2006 CHEVY MALIBU THAT MY DAUGHTER DRIVES TO WORK 5 DAYS A WEEK. IT HAS APPROX. 76,000 MILES. I WENT AND DRIVE THE CAR ON THIS DATE AND NOTICE THE STEERING FLUID DISPLAY WAS ON THE RADIO DISPLAY. I ASKED MY DAUGHTER HOW LONG IS WAS ON THERE, SHE SAID APPROX. A WEEK. I CALLED THE GMC DEALER AND GOT AN APPOINTMENT ON THE THIRD OF MAY. THEY TOLD ME THAT I NEED A NEW STEERING COLUMN AND A SHAFT WHICH WOULD BE ABOUT $1000. THEY SAID WE COULD STILL DRIVE THE CAR THAT I WOULD ACTUALLY WOULD LOSE JUST THE POWER STEERING. ON MAY 10, I TOOK THE CAR IN AND GOT IT FIXED. $850 LATER IT IS FIXED. I HAVE NEVER HAD TO REPLACED A STEERING COLUMN ON ANY OF MY OTHER CARS, WHICH HAD OVER 95,000 MILES, THE TRANSMISSION WENT OUT ON THAT ONE. PLUS I TRIED TO REFILL THE STEERING FLUID, AND WHO KNOW THAT MY CAR HAD AN ELECTRIC POWER STEERING. SOMEONE SHOULD INFORM THE CONSUMER ON THIS. MY MAIN CONCERN WAS FOR MY DAUGHTER WHO DRIVES THIS CAR IN RUSH HOUR TRAFFIC. WHAT IF IT LOCKED UP? IT IS A THOUGHT I WOULD NOT WISH TO THINK OF! *TR
Steering, Electrical system, Apr 26, 2010
I WAS DRIVING ABOUT 5 MILES FROM MY HOME AND THE STEERING WENT OUT ON MY 2006 CHEVY MALIBU, AS I WAS ATTEMPTING TO MAKE A TURN. I HAD MY GRANDCHILD WITH ME I COULD HAVE CAUSED AN ACCIDENT I TURNED THE CAR OFF FOR 1 0 MIN. AND STARTED IT BACK UP. THE STEERING LIGHT WENT OFF BUT THE CAR DID THE SAME THING TWICE BEFORE GETTING HOME UNHURT. I NEED MY CAR FIXED . I CANNOT AFFORD IT. *TR
Steering, Electrical system, Mar 3, 2010
INCIDENT: FAILURE OF POWER STEERING ON 2006 CHEVROLET MALIBU 1) A WEEK LEADING UP THE EVENT, I RETURNED FROM VACATION TO FIND "CHECK POWER STEERING" LIT UP ON MY MESSAGE CENTER, HOWEVER, POWER STEERING WAS STILL AVAILABLE. THIS OCCURRED ON A PARTICULARLY COLD MORNING, AFTER A COLD FEW WEEKS. THE CHEVROLET DEALERSHIP TOLD ME NOTHING WAS WRONG (BY PHONE). I CONTINUED DRIVING THE VEHICLE WITHOUT RECURRENCE OF THE WARNING MESSAGE. 2) ON ANOTHER PARTICULARLY COLD MORNING, I DROVE THE VEHICLE TO A LOCAL GAS STATION, FILLED UP, AND DROVE APPROXIMATELY TWO CAR LENGTHS WHEN THE POWER STEERING FAILED, THE STEERING WHEEL BECAME DIFFICULT TO MOVE, AND THE "CHECK POWER STEERING" MESSAGE DISPLAYED. I APPLIED THE BREAKS, STOPPING THE VEHICLE. 3) I HAD READ ABOUT THE FAILURE ONLINE, AND THE FIX SEEMED TO BE A RESTART OF THE ELECTRICAL SYSTEM. I TURNED OFF THE VEHICLE, AND RESTARTED THE ENGINE. THE POWER STEERING WAS RESTORED, AND I HAVE DRIVEN IT SINCE WITHOUT INCIDENT. *TR
Electrical system, Feb 4, 2010
OVER THE LAST FEW MONTHS MY CAR HAS HAD A HARD TIME STARTING EVERY ONCE IN A WHILE. TODAY WHEN I GOT HOME FROM WORK I TURNED IT TO THE ACC POSITION WHILE I WAS ON THE PHONE, ABOUT 2 MINUTES LATER I NOTICED THE ANTI THEFT LIGHT COME ON AND MY LIGHTS WENT DIM. I TRIED TO TURN IT BACK ON BUT IT WOULD NOT START. THE ANTI THEFT LIGHT STARTED BLINKING AND MY LOCKS ON THE DOORS WERE LOCKING AND UNLOCKING REPEATEDLY. I COULD HEAR CLICKING IN MY DOOR, UNDER THE HOOD, AND IN THE BACK OF MY CAR SOMEWHERE. I READ ONLINE AND FOUND A DISTURBING NUMBER OF PEOPLE WHO HAVE ALSO HAD THIS PROBLEM, THEY SEEMED TO HAVE A FIX OF KEEPING IT ON THE ACC POSITION UNTIL THE LIGHT WENT OFF, TURN IT OFF AND LEAVE IT OFF FOR A FEW MINUTES AND THEN IT SHOULD WORK! I TRIED IT.... IT DIDN'T WORK. IT JUST WENT CRAZY AGAIN WITH THE FLASHING LIGHT AND CLICKING NOISES. ITS BEEN 5 HOURS AND I STILL CAN NOT TURN ON MY CAR. THE WINDOW IS STUCK OPEN AND I CAN NOT GO TO WORK!!! *TR
Steering, Electrical system, Dec 13, 2009
POWER STEERING GOES OUT WHEN I ACCELERATE AND THE READING ON MY RADIO SAYS POWER STEERING AND THE ALARM IS ACTIVATED AS WELL TO LET ME KNOW THERE IS A PROBLEM. WHEN I TAKE MY FOOT OFF OF THE GAS, I GET MY POWER STEERING BACK. THIS HAPPENS REGULARLY. *TR
Steering, Electrical system, Aug 28, 2009
STEERING WHEEL LOCKS UP WHILE DRIVING - HAPPENS AT RANDOM - AT ALL DIFFERENT TIMES. DEALER ACTED LIKE IT WAS NO BIG DEAL AND OF COURSE THEY WANT ME TO PAY FOR IT WHEN I HAVE NOW FOUND OUT THAT I AM NOT THE ONLY ONE COMPLAINING ABOUT THIS PROBLEM. IT IS DANGEROUS, AND IT COULD CAUSE FATALITY. SOME KIND OF NEW STEERING SYSTEM - GM BETTER IDEA - PROBABLY BECAUSE IT IS CHEAPER!!! *TR
Electrical system, Exterior lighting, Aug 10, 2009
TL*THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE AT A COMPLETE STOP, THE CONTACT WAS INFORMED BY ANOTHER MOTORIST THAT HER BRAKE LIGHTS WERE ILLUMINATING EVEN WHEN SHE WAS NOT BRAKING. IN ADDITION, THE BRAKE LIGHTS WOULD NOT ILLUMINATE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT A COMPUTER CHIP WAS FAILING, WHICH CAUSED THE MALFUNCTION. THE VEHICLE WAS REPAIRED AT THE COST OF $250. A YEAR LATER, THE FAILURE RECURRED. THE CONTACT IS IN THE PROCESS OF TAKING THE VEHICLE TO THE DEALER FOR INSPECTION AND NOTIFYING THE MANUFACTURER. THE FAILURE MILEAGE WAS 35,900 AND CURRENT MILEAGE WAS 72,000.
Electrical system, Mar 13, 2009, fire
TL*THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING LESS THAN 60 MPH, THE CONTACT NOTICED THAT THE RADIO WAS MAKING UNKNOWN SQUEAKING NOISES. SHE SMELLED SOMETHING BURNING AND NOTICED IN HER REARVIEW MIRROR THAT FLAMES WERE PRESENT IN THE REAR INTERIOR SPEAKERS. SHE PULLED OFF THE ROAD AND CALLED THE POLICE AND FIRE DEPARTMENTS. THE FIRE WAS EXTINGUISHED, BUT THE FIRE DEPARTMENT COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE INSURANCE COMPANY STATED THAT THE PAPER USED TO MAKE THE SPEAKER GREW TOO HOT AND CAUSED THE FIRE. NO MODIFICATIONS HAD BEEN MADE TO THE MANUFACTURER'S SPEAKERS. THE INSURANCE COMPANY ATTEMPTED TO HAVE THE REPAIRS PERFORMED ON THE VEHICLE, BUT TO NO AVAIL. THE VEHICLE WAS DESTROYED. THE FAILURE MILEAGE WAS 59,301.
Steering, Electrical system, Feb 26, 2009
THE ELECTRIC POWER ASSIST PERIODICALLY FAILS. IT FAILS WHEN YOU CRANK YOUR CAR AND WILL NOT OPERATE CORRECTLY UNTIL YOU SHUT THE CAR DOWN AND RESTART. *TR
Fuel system, Other, Electrical system, Feb 25, 2009
INITIALLY SOMETIMES MY CAR WOULD CRANK UP THEN DIE OUT SECONDS LATER NOW ITS HAPPENING QUITE OFTEN AND MOST TIMES WON'T CRANK UP NOW. THIS HAS CAUSED ME TO BE LATE AND DOCKED FROM WORK. I'VE BROUGHT THE CAR IN 5 TO 6 TIMES THE LAST TIME IN 2/2009 THEY SAID THEY PUT IN A NEW FUEL PUMP CYLINDER BUT TWO DAYS LATER I'D THE SAME PROBLEM AGAIN. *TR
Electrical system, Feb 5, 2009, crash
TL*THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 15 MPH ON BLACK ICE, THE VEHICLE STRUCK A GUARD RAIL HEAD-ON. THERE WERE NO INJURIES. THE BODY SHOP REPAIRED THE VEHICLE AND, A WEEK LATER, THE CONTACT NOTICED THAT THE ENGINE REMAINS ON EVEN WHEN THE KEY IS NOT IN THE IGNITION. THE DEALER STATED THAT THE ISSUE WAS DUE TO THE BODY CONTROL MODULE, WHICH WAS LOCATED UNDERNEATH THE DASHBOARD. THE INSURANCE COMPANY AND MANUFACTURER STATED THAT THE FAILURE WOULD NOT BE COVERED. THE CONTACT BELIEVES THAT THE FAILURE WAS DUE TO A MANUFACTURER DEFECT, NOT THE CRASH. THE VEHICLE HAS NOT YET BEEN REPAIRED FOR THE IGNITION FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 91,000.
Steering, Electrical system, Oct 22, 2008
2006 CHEVROLET MALIBU POWER STEERING ILLUMINATES ON DASH(RADIO) , 2005 MODELS WERE A RECALL AND IT KEEPS COMING ON AND SOMETIMES LOSE OF STEERING WHEN STARTED. IT HAS 43,000 MILES AND NOT ON WARRANTY BECAUSE STEERING COLUMN IS NOT COVERED , ITS A PROBLEM NATIONWIDE AS I RESEARCHED. I COULD POTENTIALLY BE DANGEROUS WHEN DRIVING AROUND TURNS IF LOSS OF POWER. I BOUGHT IT USED BUT WAS FINE UNTIL 2 MONTHS AFTER. *TR
Engine and engine cooling, Fuel system, Gasoline, Electrical system, Jul 25, 2008
TL*THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE ATTEMPTING TO START THE VEHICLE. THE DEALER PERFORMED AN OIL CHANGE AND STATED THAT A FUEL INJECTION THROTTLE BODY, FUEL INJECTOR KIT, AND DOUBLE CLEAN WERE NEEDED; HOWEVER,THIS HAD BEEN DONE A MONTH AGO. THE CONTACT WAS ALSO INFORMED THAT THE CALIBRATION WAS OUTDATED. WHEN ENTERING THE VEHICLE, THE CLOCK SOMETIMES NEEDS TO BE RESET. THE FAILURE MILEAGE WAS 5,000 AND CURRENT MILEAGE WAS 48,000. UPDATED 09/10/08. *LJ UPDATED 09/12/08 *JB
Steering, Electrical system, Jun 2, 2008
WHILE PASSING ANOTHER CAR, ACCELERATING AROUND A CURVE, OR TAKING OFF FROM A STOP. THE ELECTRONIC POWER STEERING SHUTS DOWN LEAVING YOU FIGHTING A STEERING WHEEL THAT ALMOST FEELS LOCKED. I WAS TOLD THAT THERE WAS A BULLETIN OUT ON THE COIL PACK . THAT IT IS SPIKING A VOLTAGE ABOVE 16 VOLTS AND AS A SAFETY FEATURE IT SHUTS DOWN THE ELECTRONIC STEERING TO PROTECT IT. IT MIGHT PROTECT THE STEERING FROM THE ELECTRIC SURGE, BUT IT HAS ALMOST CAUSED A WRECK ON A COUPLE OF OCCASIONS. LUCKILY I WAS ABLE TO FIGHT THE DEAD STEERING WHEEL WHERE IF I WAS A SMALLER MALE/ FEMALE THERE WOULD BE A CHANCE THAT I COULDN'T. *TR
Electrical system, May 8, 2008
TL*THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT COULD HEAR THE LOCKS OPENING AND CLOSING DURING HEAVY RAINSTORMS. THE VEHICLE WOULD NOT START UNLESS IT WAS JUMP STARTED. THE FAILURE HAS OCCURRED ON FOUR OCCASIONS DURING HEAVY RAINSTORMS, THUNDERSTORMS, AND/OR LIGHTNING. THE VEHICLE WAS DIAGNOSED AND CONFIRMED THAT THE STARTER, ALTERNATOR, AND BATTERY WERE NOT THE CAUSES OF THE FAILURE. THE VEHICLE CAME STANDARD WITH AN AUTO START FEATURE AT THE TIME OF PURCHASE. A MECHANIC DIAGNOSED THE FAILURE AND REPLACED THE COMPUTER MODULE; HOWEVER, THE FAILURE CONTINUED. THE MOST RECENT FAILURE OCCURRED ON MAY 1, 2008. THE CONTACT WAS RESPONSIBLE FOR PAYING $2,200 FOR THE REPAIRS. HE FILED COMPLAINT NUMBER 71-625205218 WITH THE MANUFACTURER. SPEED WAS NOT A FACTOR. THE FAILURE MILEAGE WAS 23,000 AND CURRENT MILEAGE WAS 47,700.
Electrical system, May 22, 2007
TL*THE CONTACT OWNS A 2006 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT THE ANTI-THEFT SYSTEM AUTOMATICALLY SHUTS ITSELF DOWN AS WELL AS THE ENGINE. THE LIGHT ILLUMINATES AND ONCE THE VEHICLE SHUTS OFF, SHE MUST LEAVE THE IGNITION IN THE ON POSITION BEFORE IT CAN RESTART. THE FAILURE HAS OCCURRED SEVERAL TIMES AND THE CONTACT HAS HAD TO WAIT TEN MINUTES OR MORE FOR THE VEHICLE TO RESTART. THE MANUFACTURER'S MANUAL DOES NOT STATE HOW TO STOP THIS FAILURE. THIS FAILURE SHOULD ONLY OCCUR WHEN SOMEONE IS ATTEMPTING TO STEAL THE VEHICLE, BUT ALWAYS OCCURS WHILE THE CONTACT IS DRIVING. SHE PAID OVER $700 TO REPAIR THE VEHICLE AND SIX MONTHS LATER, THE FAILURE RECURRED. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 38,000 AND FAILURE MILEAGE WAS 35,000.
Electrical system, Mar 30, 2007
3/30/2007. 2006 CHEVY MALIBU. CONTACT STATES THE DRIVERS INFO CENTER CAN NOT BE READ IN DAYLIGHT. *MC *JB
Electrical system, Mar 19, 2007
FROM DAY ONE WHEN I PURCHASED MY VEHICLE 2006 CHEVY MALIBU EVERY NOW AND THEN WHEN YOU TURN THE KEY TO START THE CAR IT DOES NOTHING THEN LET UP AND TURN THE IGNITION AGAIN AND IT STARTS FINE THERE IS NO RYME OR RYTHM IT JUST DOES IT WHENEVER ALSO THE CD PLAYER EJECTS THE CD SAYING CHECK CD IT DOES THIS ALOT IN THE SUMMER WHEN IT GETS REAL HOT OUTSIDE MAKING IT HARD TO LISTEN TO A CD I HAVE HAD CHEVY LOOK AT IT SEVERAL TIMES WITH NOTHING GETTING RESOLVED I WAS TOLD THAT SINCE ITS NOT ACTING UP AT THE TIME WHEN THEY LOOK AT IT THEN THEY CANT DIAGNOSE THE PEOBLEM
Electrical system, Oct 6, 2006
DT*: THE CONTACT STATED WHILE TURNING THE IGNITION, THE VEHICLE CONTINUED TO CRANK. THE VEHICLE MUST BE TURNED OFF. THE VEHICLE WAS INSPECTED BY THE DEALERSHIP, BUT A REMEDY WAS UNAVAILABLE.
Electrical system, Jul 19, 2006
DT*: THE CONTACT STATED THE VEHICLE'S INSTRUMENT PANEL ON THE DASHBOARD HAS 12 SAFETY MESSAGES THAT DOES NOT ILLUMINATE BRIGHT ENOUGH DURING THE DAY SUCH AS THE BRAKE FLUIDS, GAS CAP, DOOR LATCHES, ENGINE DISABLED, TAILGATE, POWER STEERING AND AIR BAGS TO NAME A FEW. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT ALL THE VEHICLE'S INSTRUMENT PANELS HAVE THE SAME LIGHT INTENSITY FOR ILLUMINATION.