2006 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,385 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Malibu model years with reports.
Of the 2006 reports, 53 involved a crash and 7 involved a fire. 31 people were injured.
What owners report most often
Recalls and investigations
Steering, electric power assist systemFeb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Campaign 15V064000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Air bags, frontalOct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Campaign 06V417000 on NHTSA.gov
Equipment, other, labelsOct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 05V486000 on NHTSA.gov
Representative owner complaints: power train
60 reports, newest first. Show all
Steering, Power train, Service brakes, Aug 20, 2024
Sent the car to fix recalls and they said it has another problem and want to charge to fix the steering recall N140772 problem. They said is not free.... Do not know if the other recalls were repaired.
Power train, Engine, Feb 13, 2021
WAS DRIVING CAR AND THE ENGINE CUT OFF. REDUCED ENGINE POWER SHOWED ON MY RADIO AND TRACTION LIGHT CAME ON ON THE DASH. I HAVE TO PUT THE CAR IN PARK, TURN IGNITION OFF, WAIT A COUPLE OF MINUTES, THEN CRANK IT BACK UP TO DRIVE. THIS HAS HAPPENED SEVERAL TIMES. I HAVE NOTICED THAT IT HAPPENS WHEN IT IS RAINING OR HAS RAINED. WHEN THE ROADS ARE WET. IT HAS HAPPENED WHILE DRIVING AND WHEN STOPPING AT A TRAFFIC LIGHT OR STOP SIGN. IT HAS HAPPENED BOTH WHILE DRIVING AND BRAKING. C0242 - ENGINE CONTROL MODULE INDICATED TRACTION CONTROL MALFUNCTION IS THE CODE IT IS GIVING ME. THIS IS CAUSING MY GAS MILEAGE TO DROP TO AROUND 230-250 MILES PER TANK. WHEN I WAS GETTING ALMOST 400 PER TANK.
Steering, Service brakes, Hydraulic, Power train, Oct 28, 2020
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V252000 (SERVICE BRAKES, HYDRAULIC, ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL), 14V224000 (POWER TRAN), 15V064000 (STEERING) HOWEVER, THE PARTS TO DO THE RECALL REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS, THE POWER TRAIN, STABILE-TRACE CONTROL, EMERGENCY BRAKE INDICATOR, AND ABS WARNING LIGHTS WERE ILLUMINATED. THE BRAKE PEDAL BECAME HARD TO DEPRESS. THE CONTACT STATED THAT A FRIEND REPLACED THE BRAKE PADS HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED. SIERRA CHEVROLET (7850 U S 64, MEMPHIS, TN 38133, (901) 382-5644) WAS CONTACTED AND INFORMED THE CONTACT THAT AN APPOINTMENT WAS NEEDED TO BE SCHEDULED FOR THE FREE REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND A CASE WAS FILED. THERE WAS NO FURTHER ASSISTANCE PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 19,000. PARTS DISTRIBUTION DISCONNECT.*DT*JB
Power train, Electrical system, Engine, Oct 24, 2019
CAR RUNS FINE THEN WITHOUT WARNING IT WILL JUST DIE. DOES THIS WHILE DRIVING IN MOTION. IT IS CAR USED BY TWO NEW TEEN DRIVERS. IT IS VERY UNSAFE BECAUSE THEY DON'T HAVE A LOT OF DRIVING TIME. I LOOKED AT A LOT OF WIRING CONNECTIONS, CLEANED UP ALL GROUND CONNECTIONS WITH WIRE BRUSH, REPLACED TEMP SENSOR, CRANK POSITION SENSOR, BEEN GOING THRU AND FIXING BAD WIRING CONNECTIONS. REPLACED FUEL PUMP. AND FIXED BROKEN WIRES COMING OUT OF BODY THAT GO TO FUEL GAUGE.
Steering, Power train, Fuel/propulsion system, Jun 30, 2019
I WAS DRIVING TOWARDS RAYTOWN MISSOURI FOR A BIRTHDAY PARTY AND ASNI WAS DRIVING OVER A RAILROAD TRACK, MY CAR STARTEE MAKING NOISE AND ACTED AS IF IT DIDNT WANT TO GO. SO I LATER FOUND OUT THAT MY TRANSMISAION FLUID HAD LEAKED AND NOW THE TRANSMISSION CASE NEEDS TO BE REPLACED DUE TO THE TRACKS ON THE ROAD.
Steering, Power train, Mar 7, 2019
TAKATAT RECALL .. I WAS DRIVING MY CAR ON THE HIGHWAY AND MY STEERING WHEEL LOCKED WHEN I WAS DRIVEING I HAD MY FAMILY IN THE CAR WITH ME WE ALL COULD HAVE DIE LORD ME AND MY FAMILY IS HOMELESS WE NEED THIS CAR TO GET AROUND PLEACE HELPN US WITH THIS I WAS DRIVEING FROM EAST ST LOUIS IL TO WORK AT THE HOLLWOOD CASINO IN ST LOUIS MO WE SLEEP IN OUR CAR THATS WHY MY FAMILY WAS THERE WITH ME WHEN I WAS DRIVING WHEN IT WENT OUT AND THE STEERING WHEEL ALL SO SHAKES VERY BAD
Steering, Suspension, Power train, Apr 4, 2018
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO STEERING AND VEHICLE STALLING ISSUES. *SMD *JS
Power train, Nov 21, 2016
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. WHILE DRIVING AT AN UNKNOWN SPEED, THE FRONT OF THE VEHICLE CONSTANTLY SHOOK. THE VEHICLE INDEPENDENTLY SHIFTED GEARS AND THE POWER TRAIN WARNING INDICATOR ILLUMINATED. ON ANOTHER OCCASION, AFTER THE VEHICLE WAS STARTED, THE VEHICLE FAILED TO SHIFT OUT OF THE PARK POSITION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE GASKET FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 171,375.
Power train, Sep 29, 2016
ON 9-28-16, I PLACED THE VEHICLE IN REVERSE TO DEPART A PARKING SPACE, WHEN I TRIED TO PUT THE VEHICLE INTO DRIVE THE GEAR REMAINED IN REVERSE. THE TRANSMISSION SHIFT CABLE WAS REPLACED UNDER RECALL ON 03-27-15, FOR THE PREVIOUS 8 YEARS THE VEHICLE DID NOT HAVE A PROBLEM WITH THE SHIFT CABLE. THE SHIFT CABLE THAT WAS REPLACED UNDER RECALL HAS NOW FRACTURED.
Power train, Apr 14, 2016
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE VACUUMING OUT THE PARKED VEHICLE, THE CONTACT BUMPED THE GEARSHIFT AND THE VEHICLE STARTED MOVING. THE VEHICLE WAS ABLE TO BE STOPPED, BUT WAS NOT ABLE TO BE PLACED BACK IN THE PARK POSITION. THE VEHICLE HAD TO BE STARTED IN ORDER TO BE PLACED IN THE PARK POSITION. THE DEALER COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.
Steering, Power train, Mar 30, 2016
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE POWER STEERING WARNING LIGHT RANDOMLY FLASHED AND THE STEERING WHEEL WAS TIGHT EACH TIME THE FAILURE OCCURRED. THE DEALER AND THE MANUFACTURER INDICATED THAT THERE WAS A MANUFACTURER RECALL FOR THE VEHICLE AND PROVIDED NO REMEDY OR SOLUTION. THE CONTACT WAS ADVISED TO TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 15V064000 (STEERING), 14E044000 (STEERING), AND 14V153000 (STEERING). THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN). THE DEALER WAS TO SCHEDULE THE RECALL REPAIR. THE VEHICLE WAS TO BE TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION OF THE POWER STEERING FAILURE AND THE CONTACT WAS WAITING TO DETERMINE WHEN THE DEALER WOULD COMPLETE THE RECALL REPAIR. PARTS DISTRIBUTION DISCONNECT. THE APPROXIMATE FAILURE MILEAGE WAS 136,000.
Power train, Jan 6, 2016
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO TRANSMISSION SHIFT LEVER RECALL REPAIRS AND SEEKS REIMBURSEMENT. *SMD THE CONSUMER STATED AS HE WAS ATTEMPTING TO TURN INTO A BUSY INTERSECTION, THE VEHICLE BEGAN TO ROLL BACKWARDS AND HE HAD NO CONTROL OF THE VEHICLE, AT FIRST. HE WAS ABLE TO STOP THE VEHICLE BY APPLYING THE BRAKE. THERE WAS NO WARNING OF ANY TYPE. THE VEHICLE WAS TOWED TO THE DEALER. A DAY LATER, THE DEALER INFORMED THE CONSUMER THE VEHICLE NEEDED A NEW TRANSMISSION. AFTER THE CONSUMER PAID FOR A REBUILT TRANSMISSION, HE RECEIVED A RECALL NOTICE IN THE MAIL REGARDING THE TRANSMISSION. *JB
Power train, Electrical system, Nov 16, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER LAST YEAR FOR THREE MANUFACTURER RECALL REPAIRS, WHICH DID NOT REMEDY THE FAILURE. MONTHS AFTER THE VEHICLE WAS TAKEN TO THE DEALER, IT WOULD NOT SHIFT GEARS PROPERLY AND THE VEHICLE SHOOK AND VIBRATED RANDOMLY WITHOUT WARNING. THE CONTACT HAD TO APPLY FORCE TO THE BRAKE PEDAL AND, IF IT WERE RELEASED, THE VEHICLE WOULD RANDOMLY STALL. THE VEHICLE WAS TO BE TAKEN BACK TO THE DEALER FOR FURTHER INSPECTION AND DIAGNOSTIC TESTING TO DETERMINE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 1/19/16 LN *CN
Power train, Sep 29, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN) EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIR. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT PARTS WERE NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT WHEN ATTEMPTING TO ACCELERATE, THE VEHICLE WOULD HESITATE. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER COULD NOT DIAGNOSE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 134,652. UPDATED 11/25/15*LJ; UPDATED 4/1218*JB *TR
Steering, Power train, Vehicle speed control, Aug 14, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 40 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN RIGHT OR LEFT. ALL OF THE LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), 14V153000 (STEERING), AND 14V224000 (POWER TRAIN). THE PARTS NEEDED FOR THE REPAIR WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 228,178.
Power train, Jul 7, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Power train, Electrical system, Mar 4, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING AT APPROXIMATELY 45 MPH, THE VEHICLE STALLED. THE VEHICLE WAS PREVIOUSLY TAKEN TO THE DEALER, WHO REPLACED THE BCM SPACER AND THE TRANSMISSION SHIFTER BUT THE FAILURE RECURRED MONTHS LATER. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN), BUT THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Power train, Mar 2, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE THE CRUISE CONTROL WAS DEACTIVATED, THE VEHICLE DECELERATED WITHOUT WARNING. THE CONTACT WAS ABLE TO PLACE THE GEAR IN LOW AND DROVE THE VEHICLE HOME. THE TRANSMISSION REGAINED FUNCTION AFTER THE ENGINE WAS RESTARTED AND THE GEARS WERE SHIFTED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE OR DUPLICATE THE FAILURE. AFTER INSPECTING THE TRANSMISSION, THE TECHNICIAN ADVISED THAT THE TRANSMISSION WAS OPERATING AS NORMAL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 47,000.
Power train, Jan 22, 2015
TL*THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Power train, Jan 22, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN). THE CONTACT WAS UNABLE TO HAVE THE VEHICLE REPAIRED BECAUSE THE PARTS NEEDED FOR THE REPAIR WERE NOT READILY AVAILABLE. THE CONTACT BELIEVED THAT THE DEALER HAD EXCEEDED A REASONABLE AMOUNT OF TIME TO REPAIR THE DEFECTIVE COMPONENT. THE CONTACT HAD BEEN WAITING SINCE JULY 2014 TO HAVE THE VEHICLE REPAIRED. THE MANUFACTURER WAS ALSO CONTACTED BUT NEITHER THE DEALER NOR THE MANUFACTURER COULD PROVIDE AN ESTIMATED TIME IN WHICH THE VEHICLE WOULD RECEIVE THE RECALL REPAIRS. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Power train, Jan 14, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN). THE VEHICLE WAS TAKEN TO THE DEALER. HOWEVER, THE CONTACT WAS TURNED AWAY BECAUSE THE DEALER RAN OUT OF PARTS. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE CONTACT HAD NOT EXPERIENCE THE FAILURE.
Steering, Power train, Jan 12, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 15 MPH, THE POWER STEERING WARNING LIGHT ILLUMINATED AND THE POWER STEERING SEIZED. THE CONTACT STATED THAT THE VEHICLE SHIFTED FROM THE DRIVE POSITION TO THE NEUTRAL POSITION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.
Steering, Power train, Engine, Jan 12, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE STEERING WHEEL SEIZED AND EXCESSIVE FORCE ON THE STEERING WHEEL WAS REQUIRED. THE CONTACT ALSO STATED THAT THE ENGINE STALLED. THE TRANSMISSION FAILED TO SHIFT OUT OF PARK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 169,000.
Steering, Power train, Jan 9, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS THE STEERING WHEEL BECAME DIFFICULT TO TURN WITHOUT WARNING. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.
Steering, Power train, Dec 5, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT THE STEERING WHEEL SEIZED AND THERE WAS AN ABNORMAL CLICKING NOISE HEARD. THE VEHICLE WAS TAKEN TO THE DEALER, WHO REPAIRED THE VEHICLE UNDER NHTSA CAMPAIGN ID NUMBER: 14E044000 (STEERING). THE CONTACT STATED THAT THE RECALL REMEDY FAILED TO REPAIR THE VEHICLE DUE TO THE STEERING WHEEL BEING DIFFICULT TO MANEUVER. THE CONTACT ALSO RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 14V224000 (POWER TRAIN) BUT THE PART WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.