2006 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,385 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Malibu model years with reports.
Of the 2006 reports, 53 involved a crash and 7 involved a fire. 31 people were injured.
What owners report most often
Recalls and investigations
Steering, electric power assist systemFeb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Campaign 15V064000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Air bags, frontalOct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Campaign 06V417000 on NHTSA.gov
Equipment, other, labelsOct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 05V486000 on NHTSA.gov
Representative owner complaints: service brakes
92 reports, newest first. Show all
Service brakes, Hydraulic, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Apr 13, 2015
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO BODY CONTROL MODULE CONNECTION SYSTEM RECALL NOTICE AND CUSTOMER REIMBURSEMENT REQUESTS FORM ISSUES. *SMD
Steering, Air bags, Service brakes, Apr 11, 2015, crash
I WAS ON 44 JUST TURNED ON 41 NO CARS ON LEFT OR RIGHT NONE BEHIND PROCEEDING ACROSS TRAFFIC LIGHT OTHER PARTY WAS MAKING A RIGHT TURN I WAS STOPPING BRAKES ANKLE WAS FRACTURED AND WE HAD A HEAD ON COLISION. *TR
Vehicle speed control, Service brakes, Jan 16, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING AT APPROXIMATELY 5 MPH, THE BRAKE PEDAL WAS APPLIED BUT THE VEHICLE FAILED TO STOP. AS A RESULT, THE CONTACT CRASHED THE VEHICLE INTO A MEDIAN IN ORDER TO STOP. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRICAL STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL) HOWEVER, THE PART WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Service brakes, Air, Jan 6, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED UNDER THE RECALL. THE VEHICLE FAILED TO PASS INSPECTION DUE TO A SERVICE BRAKE LAMP MALFUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.
Vehicle speed control, Electronic stability control (ESC), Service brakes, Dec 17, 2014
END OF JULY 2014, EARLY MORNING, WHILE DRIVING 70MPH ON THE INTERSTATE WITH CLEAR DRY CONDITIONS, MY BRAKES BEGAN TO PULSE ON THEIR OWN AND THE TRACTION CONTROL LIGHT BEGAN LIGHTING UP IN CORRESPONDENCE WITH THE BRAKE PULSE.. THE CRUISE CONTROL SHUT ITSELF OFF. THE CHECK ENGINE LIGHT AND BRAKE LIGHT CAME ON REMAIN ON AND CRUISE CONTROL NO LONGER WORKS. THIS CONTINUES TO HAPPEN THROUGHOUT THE ENTIRETY OF MY 60MILE ONE WAY DAILY DRIVE. I WAS NOTIFIED OF RECALL13036 WHICH INCLUDES ALL OF THESE ISSUES., I TOOK THE VEHICLE IN FOR A SCHEDULED SERVICE FOR THIS 12/12/14. AFTER WAITING MORE THAN 2 HOURS TO GET MY VEHICLE BACK (WITHOUT THE RECALL WORK BEING DONE), I RESCHEDULED FOR 12/16/14. AFTER COMPLETING THE RECALL WORK THE VEHICLE WAS RETURNED TO ME WITH ALL ERROR CODES CLEARED. LESS THAN 3 MILES DOWN THE ROAD, ALL OF THE ISSUES RETURNED. NO CRUISE CONTROL, PULSING BRAKES AND T/C LIGHT, CHECK ENGINE LIGHT AND BRAKE LIGHT CAME ON AND REMAIN ON. I CONTACTED THE DEALERSHIP AND THEY TOLD ME THAT THEY SIMPLY ADDED LUBRICANT TO CONNECTIONS AND THAT ALL OF THESE ISSUES ARE NOT ASSOCIATED WITH THE RECALL. I READ THE RECALL NOTICE TO THEM, IT CLEARLY STATES ALL OF THESE ISSUES ARE RELATED TO THE RECALL. THE DEALERSHIP (PETE HARKNESS/MORRISON,IL) RECOMMENDS THAT I BRING IT BACK IN AGAIN AND PAY $90.00 FOR A DIAGNOSTIC CHECK AND THEN I WILL NEED TO PAY FOR ANY REPAIRS NEEDED. *TR
Service brakes, Hydraulic, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Oct 8, 2014
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO RECALL NOTICES. *TGW THE CONSUMER STATED TWO DAYS AFTER THE FIRST RECALL REPAIR, BECAUSE THE REPAIR WAS NOT FULLY COMPLETED, DUE TO LACK OF PARTS, SHE EXPERIENCED TWO EPISODES WHICH SHE DEEMED UNSAFE. WHILE SITTING WITH HER FOOT ON THE BRAKE, AND THE VEHICLE IN DRIVE, SHE SUDDENLY FELT A SLIGHT SHIFT, AS IF THE VEHICLE WAS TRYING TO MOVE FORWARD, WHICH IT DID, WITHOUT ANY WARNING. THE VEHICLE BUMPED A CAR IN FRONT OF HER. THE CONSUMER REFERENCED RECALL # 14V252000. *JB
Service brakes, Hydraulic, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Oct 2, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR THE RECALL REPAIR AND WAS LATER INFORMED THAT THE PART WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 11/20/14*LJ UPDATED 8/12/2015 *JS
Service brakes, Hydraulic, Power train, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Oct 1, 2014
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO TORQUE SENSOR ASSEMBLY; WIRING HARNESS TO THE BCM OR MAG BEAM AND TRANSMISSION SHIFT CABLE THAT MAY FRACTURE AT ANY TIME. *TGW THE CONSUMER WAS INFORMED, THE PARTS WERE NOT AVAILABLE. *JB
Steering, Service brakes, Sep 22, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V1153000 (STEERING). HOWEVER, THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 10/28/2014*LJ UPDATED 4/22/2015 *JS
Steering, Service brakes, Sep 15, 2014, crash
AS I AM MAKING A RIGHT TURN ON AIRLINE STREET I FELT IT WAS A TIGHT TURN FROM THE BEGINNING & REALLY DON'T THINK NOTHING OF IT, AS I CONTINUE DRIVING AT ABOUT 15\20 PER HOUR I WAS TRYING TO MAKE A RIGHT MOVE TO THE RIGHT LANE & ONCE AGAIN MY STEERING WHEEL WAS TIGHT SO I WAS FORCE TO USE MY BRAKES WHICH I TRIED REPEATEDLY BUT WAS ENABLE TO STOP AT THAT SAME MOMENT THERE WAS A STRONG HIT TO MY REAR BUMPER BY A COMMERCIAL TRUCK WHICH END UP BEING A HIT AND RUN FROM THE COMMERCIAL TRUCK. *TR
Service brakes, Sep 15, 2014
I WORRY THAT SOMETHING WILL HAPPEN, MY DAUGHTER AND HER 2 LITTLE GIRLS USE THIS CAR WITH FAULTY BRAKE USAGE. PLEASE HELP WITH THIS REPAIR BEFORE THEY ARE IN AN ACCIDENT. THANK YOU.... THIS IS A RECALL BUT I AM NOT GETTING ANYWHERE. *TR
Steering, Service brakes, Hydraulic, Power train, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Sep 11, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED RECALL NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBERS: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), 14V153000 (STEERING), AND 14V224000 (POWER TRAIN). THE PARTS NEEDED TO PERFORM THE RECALL REPAIRS WERE UNAVAILABLE. THE DEALER WAS UNCERTAIN WHEN THE PARTS WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Service brakes, Hydraulic, Electrical system, Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Sep 8, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL); HOWEVER, THE PARTS NEEDED TO REPAIR THE VEHICLE WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Steering, Fuel system, Gasoline, Electrical system, Vehicle speed control, Seats, Electronic stability control (ESC), Service brakes, Sep 5, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE LIGHTS WOULD WORK INTERMITTENTLY. THE CONTACT REPLACED THE BRAKE LIGHTS ON NUMEROUS OCCASIONS. THE INDEPENDENT MECHANIC REPAIRED THE WIRING HARNESS BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE BCM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED UNDER CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM , ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL) THE REMEDY FAILED TO RECTIFY THE FAILURE. ADDITIONALLY, THE CONTACT ALSO STATED THAT THE HEATED SEAT FUNCTION FAILED AND THE POWER STEERING SEIZED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE APPROXIMATE FAILURE MILEAGE WAS 60,000...UPDATED 10/01/14 *BF THE CONSUMER STATED THE FUEL TANK WOULD SHOW 1/8 OF A TANK, BUT IN ACTUALITY THE TANK WAS EMPTY.
Vehicle speed control, Electronic stability control (ESC), Service brakes, Sep 2, 2014
NO PHYSICAL INCIDENTS HAVE TAKEN PLACE AS OF YET, HOWEVER WHEN ASKING ABOUT PART BEING REPLACE FOR MY TWO RECALLS I GET NOTHING BUT ATTITUDE AND "I DON'T KNOW" ANSWERS. MY RECALLS ARE ON THE TRANSMISSION SHIFT CABLE, BODY CONTROL MODULE, BRAKE APPLY SENSOR AND ELECTRONIC STABILITY CONTROL. I STILL MAKE CAR PAYMENTS, SINGLE MOTHER WITH A TODDLER IN THE VEHICLE AND ALL I GET IS AN " I DON'T KNOW" WHEN OUR SAFETY IS IN QUESTION. IF I COULD AFFORD A RENTAL I WOULD GET ONE AND KEEP THE CAR PARKED, HOWEVER A RENTAL IS LIKE ANOTHER CAR PAYMENT....WHERE DO I GO FROM HERE? *TR
Steering, Air bags, Service brakes, Aug 30, 2014, crash
WAS DRIVING AND SAW A DEER IN THE ROAD. WHEN I PRESSED THE BRAKES THEY LOCKED AND THEN THE PEDAL WENT TO THE FLOOR AS IF THE BRAKES WENT OUT. AT THAT TIME THE STEERING WAS DIFFICULT. THE VEHICLE WENT THROUGH A FIELD THROUGH 2 FENCES AND OVER A DITCH BEFORE COMING TO A STOP. THE ENGINE DID NOT SHUT OFF. THERE WAS MAJOR FRONT END DAMAGE, FROM THE FENCE POSTS, AND THE AIR BAGS NEVER DEPLOYED. THE VEHICLE WAS DECLARED A TOTAL LOSS DUE TO THE DAMAGE. *TR
Steering, Power train, Service brakes, Aug 24, 2014
HELLO, I CONTACTED YOUR NATIONAL SERVICE LINE AND THEY REFERRED ME TO JACK WILSON CHEVROLET IN SAINT AUGUSTINE. WE HAVE HAD THREE RECALLS ON THIS VEHICLE AND NO RESOLUTION ON ANY OF THEM. VIN# [XXX] 2006 CHEVROLET MALIBU MAXX 65000 MILES STEERING ISSUE, TOOK TO A DEALER SHIP IN JACKSONVILLE, FL., THEY TOLD ME IT WAS A BRAKE ISSUE. HAD THE FRONT BRAKES REPLACED AND STILL HAVE THE ISSUE AND CHARGED ME 60.00 FOR A WRONG DIAGNOSIS. RECEIVED LETTER ON 7-18-2014, RECALL #13036, NO PARTS AVAILABLE AND DO NOT KNOW WHEN THEY WILL BE AT THIS TIME. RECEIVED LETTER ON 8-11-2014, RECALL #14152, NO PARTS AVAILABLE AND DO NOT KNOW WHEN THE WILL BE AT THIS TIME. THE NATIONAL CUSTOMER SERVICE CENTER CALLED JACK WILSON AND SET UP FOR ME TO GO AND HAVE THEM INSPECT RECALL ITEMS AND LET ME KNOW THAT THERE WAS NO EMINENT DANGER. I WENT TO JACK WILSON AND SPOKE WITH THE SERVICE PERSON [XXX] WHICH DID NOT HAVE THE INSPECTION DONE. SHE WAS WILLING TO INSPECT THE STEERING ISSUE WHICH SHE SAID WAS NOT A RECALL ISSUE BY TURNING THE STEERING WHEEL BACK AND FORTH AND DID NOT HAVE A CERTIFIED TECHNICIAN EVEN LOOK AT THE CAR. THIS CAR IS MY MOTHER'S ONLY CAR, SHE IS 84 AND DOING WELL UNTIL SHE GOT THESE RECALL LETTERS. SHE DOES NOT FEEL SAFE TO DRIVE THIS CAR AND NO ONE CAN TELL ME WHEN THE PARTS WILL BE AVAILABLE FOR THE REPAIRS TO BE COMPLETED. [XXX] I AM CONTACTING GM FIRST WITH THIS AS YOU REQUESTED. PLEASE HELP US WITH THIS MATTER, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Power train, Service brakes, Aug 18, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT SHE ATTEMPTED TO HAVE HER VEHICLE REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN) AND NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM , ELECTRONIC STABILITY CONTROL , EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC , VEHICLE SPEED CONTROL) BUT WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Vehicle speed control, Electronic stability control (ESC), Service brakes, Aug 17, 2014
I HAVE RECEIVED TWO RECALL NOTICES IN THE PAST TWO MONTHS, ONE FOR THE ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL; AND THE OTHER FOR THE TRANSMISSION SHIFT CABLE, WHICH MAY FRACTURE AT ANY TIME. BOTH NOTICES INFORMED ME THAT THE DEALER WOULD PERFORM REPAIRS AT NO COST, BUT THAT PARTS ARE NOT CURRENTLY AVAILABLE. AM I TO CONTINUE DRIVING MY DEFECTIVE CAR AND HOPE THAT I WON'T GET INTO AN ACCIDENT CAUSED BY THE ABOVE PROBLEMS? I AM VERY LOW INCOME AND CAN'T AFFORD TO RENT A CAR. *TR
Fuel system, Gasoline, Power train, Service brakes, Aug 13, 2014
I WAS UN ABLE TO GET MY CAR FROM PARK TO DRIVE. I HAD TO PULL EXTREMELY HARD ON THE SHIFTER TO GET IT TO MOVE. *TR
Fuel system, Gasoline, Electrical system, Service brakes, Aug 11, 2014
ON 5/07/2014 I GOT IN MY CAR THAT MORNING TO TAKE MY 4 CHILDREN TO SCHOOL THE CAR STARTED AND DIED 3 TIMES. WHEN IT FINALLY DID START I COULDN'T GET IT OUT OF PARK! WHILE ON THE WAY TO SCHOOL I WAS NEARLY HIT FROM BEHIND BECAUSE MY BRAKES LIGHTS FAILED TO FUNCTION! THE PROBLEMS HAVE GOTTEN WORSE DAILY SINCE THEN. WHEN I WOULD DRIVE THE CAR IT WOULD TAKE OFF ON ITS ON, THE CRUISE CONTROL NO LONGER FUNCTIONS, I HAVE TO TRY AT THE MINIMUM OF 7 TIMES TO GET IT TO CRANK!! NOW IT IS VERY UNSAFE FOR ME TO DRIVE I CAN'T EVEN TAKE MY CHILDREN TO SCHOOL MY NEIGHBOR HAS TO TAKE THEM AND PICK THEM UP! I WAS FINALLY SENT A RECALL LETTER THE LAST DAY OF JULY 2014. IN THIS RECALL ARE ALL THE PROBLEMS I AM HAVING. THEY SAY WHEN CALLED THAT THEY DO NOT KNOW WHEN THE PARTS TO FIX IT WILL BECOME AVAILABLE. WHAT AM I TO DO? I HAVE A CAR I AM PAYING FOR AND CAN NOT DRIVE!! I CAN'T AFFORD TO GO BUY A DIFFERENT CAR. I TOLD THEM SINCE THEY HAD NO IDEA WHEN PARTS WOULD BE IN TO JUST REPLACE MY CAR AND THE ANSWER WAS NO!! THEY ALSO WANT ME TO PAY TO HAVE IT INSPECTED. THIS IS THEIR FAULT NOT MINE I SHOULD NOT HAVE TO PAY FOR ANYTHING!!! *TR
Steering, Service brakes, Fuel/propulsion system, Jul 28, 2014
AFTER FINDING OUT THAT THERE ARE RECALLS FOR MY CAR PER DOT.GOV, I SCHEDULED AN APPOINTMENT FOR REPAIRS WITH VANDERGRIFF CHEVROLET IN ARLINGTON FOR 7-21-14. I REQUESTED THAT THEY REPAIR THE PARTS UNDER RECALL AND ISSUE A REFUND FOR THE AMOUNT I PAID PREVIOUSLY FOR REPAIR TO POWER STEERING ON MY VEHICLE. I WAS TOLD THAT SOMEONE WOULD BE IN TOUCH WITH ME. WHEN I DID NOT GET CONTACTED, I RETURNED TO THE SERVICE DEPARTMENT TO SPEAK WITH A TECHNICIAN IN REGARD TO MY SERVICE REQUEST. ONCE AGAIN, AS PREVIOUSLY, I WAS TOLD THAT THERE ARE NO RECALLS ON MY CAR. WHEN I DIRECTED THE TECHNICIAN TO THE INFORMATION RELEASED BY THE DEPT. OF TRANSPORTATION, HE STATED THAT GM SENT OUT ADDITIONAL RECALL LETTERS TO RECALL THE ORIGINAL RECALL NOTICES BECAUSE THEY WERE ISSUED IN ERROR, AND THAT THERE ARE NONE IN EFFECT FOR MY VEHICLE. NO REPAIRS WERE DONE. *JS
Electrical system, Vehicle speed control, Service brakes, Jul 22, 2014
BOUGHT CAR NEW 2/06. ONCE HOME AND DRIVING I NOTICED AN ELECTRICAL ISSUES CONSISTING OF RADIO INTERFERENCE WHEN USING ANY ELECTRICAL BUTTONS IN CAR, SUCH AS WINDOWS, AND MY CHARGING OUTLETS IN THE CAR BLOW FUSES WHEN USED. WHEN I TURN MY AIR OR HEAT ON MY BRAKE PEDAL DROPS DOWN AT LEAST 2 IF SITTING AT LIGHT. IF DRIVING AND I TURN ON MY AIR, THE CAR LUNGES FORWARD. THIS IS AT A CRITICAL LEVEL NOW. I TOOK INTO THEIR DEALERSHIP FROM THE FIRST MONTH I PURCHASED THE CAR UNTIL MARCH OF 2007. NO ONE COULD FIX THE ELECTRICAL ISSUE AND DEALERSHIP COULD NOT SUPPLY ME WITH EVEN THE PAPERWORK TO SHOW ME WHAT THEY RESEARCHED WHILE IT SAT THERE FOR OVER 4 DAYS. PROBLEM IS NOW DEADLY AND I NEED THIS ELECTRICAL ISSUE FIXED. I RECEIVED NOTICE OF RECALL 13036 BUT NOTHING CONCERNING THE PROBLEM WITH THE BRAKE PETAL AND ACCELERATION I HAVE HAD SINCE PURCHASE. CONTACTED DEALERSHIP TO GET (LEMON) REPLACED AND THEY SAID, TOUGH LUCK. PURCHASED AS IS... *TR
Steering, Fuel system, Gasoline, Service brakes, Jul 21, 2014
BEGINNING IN 2010 I HAD TO REPLACE THE BRAKES ON MY CAR MULTIPLE TIMES. TO DATE I HAVE REPLACED BRAKE PADS, DRUMS, AND LINES 5 DIFFERENT TIMES. MY BRAKES SEEM TO WEAR EASILY AND FREQUENTLY SCREECH. BEGINNING IN 2013 AFTER FILLING MY CAR WITH GAS MY "LOW FUEL" INDICATOR DINGS AND MY FUEL GAUGE SHOWS EMPTY. THIS HAPPENS EVERY TIME I FILL MY CAR WITH GAS. I HAVE RECEIVED A RECALL NOTICE REGARDING POWER STEERING. ON TWO SEPARATE OCCASIONS I HAVE EXPERIENCED MY POWER STEERING GOING OUT AND I AM FORCED TO PULL OVER AND TURN OFF MY CAR AND TURN IT BACK ON FOR THE CAR TO WORK PROPERLY. I HAVE CONTACTED GM REGARDING THE RECALL NOTICE AND I HAVE BEEN ADVISED THAT NO PARTS ARE AVAILABLE AND THEY WILL NOT PROVIDE ME WITH A RENTAL VEHICLE AND EXPECT ME TO CONTINUE TO DRIVE THE VEHICLE "UNTIL THE PARTS ARE AVAILABLE". THEY WILL NOT PROVIDE ME WITH A TIMELINE AND HAVE BEEN UNRESPONSIVE TO MY OTHER COMPLAINTS REGARDING THE VEHICLE. *TR
Engine and engine cooling, Fuel system, Gasoline, Service brakes, Jul 21, 2014
MY CAR STALLS AND YOU CAN SMELL GAS. IT HASN'T BEEN WORKING IN THREE WEEKS NOW. *TR