2006 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,385 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Malibu model years with reports.
Of the 2006 reports, 53 involved a crash and 7 involved a fire. 31 people were injured.
What owners report most often
Recalls and investigations
Steering, electric power assist systemFeb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Campaign 15V064000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Air bags, frontalOct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Campaign 06V417000 on NHTSA.gov
Equipment, other, labelsOct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 05V486000 on NHTSA.gov
Representative owner complaints: steering
1,017 reports, newest first. Show all
Steering, Aug 12, 2016
ELECTRIC POWER STEERING WARNING LAMP GOES IS ON, VERY HARD TO STEER CAR WHEN THIS OCCURS, I PULL OVER TO SIDE OF ROAD SHUT DOWN AND RESTART AND ALL IS OK FOR A DAY OR TWO. , HAD TORQUE ANGLE SENSOR RECALL DONE. I DRIVE ON THE HIGHWAY A LOT AND THIS IS VERY SCARY. I HAVE READ ONLINE THAT SOME OF THE MALIBU "S HAVE SAME SYMPTOMS MY CURRENT MILES ARE 58,000/ WILL BE TAKING IT TO A CHEVY DEALER TO DISCUSS THIS ''SAFETY '' ISSUE. SOME ONE MY FAMILY JUST HAD THE ELECTRIC ASSIST REPLACED FREE THRU FORD, FOR SIMILAR ISSUE. THIS WARNING LIGHT ON MY CHEVY MALIBU WILL APPEAR AT ALL DIFFERENT DRIVING , CITY. TURNING, HIGHWAY.
Steering, Jul 21, 2016
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 5 MPH AND ATTEMPTING TO MAKE A RIGHT TURN, A LOUD NOISE EMERGED FROM THE STEERING WHEEL. THE FAILURE OCCURRED DAILY FOR THE PAST YEAR EVERY TIME A TURN WAS MADE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE INTERMEDIATE SHAFT FAILED. THERE WERE NO RECALLS AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 178,000.
Steering, Jul 19, 2016
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE PARKING THE VEHICLE, THE STEERING WHEEL BECAME UNCONTROLLABLE AND LOOSE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 14E044000 (STEERING). THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.
Steering, Jul 12, 2016
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE MAKING A TURN AT AN UNKNOWN SPEED, THE ELECTRIC POWER STEERING FAILED AND THE STEERING WHEEL BECAME EXTREMELY DIFFICULT TO MANEUVER WITHOUT WARNING. THE CONTACT HAD TO USE EXCESSIVE FORCE TO TURN THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE STEERING SHAFT TORQUE SENSOR WAS REPLACED. THE CONTACT STATED THAT THE FAILURE OCCURRED AFTER THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 15V046000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,559.
Steering, Jul 7, 2016
THE STEERING GOES IN AND OUT. FEELS LIKE YOU HAVE VERY LITTLE CONTROL OF WHEEL WHILE DRIVING. WHEN ACCELERATING OR ENTERING HIGHER SPEEDS A DING GOES OFF. HAVE REPLACED STEERING COLUMN THROUGH DEALER. NEED TO REPLACE STEERING GEAR AND CONTROL MODULE. THIS SHOULD ALL BE COVERED CONSIDERING THESE PARTS PROBABLY ALL GO BAD HAVING A DEFECTIVE STEERING COLUMN TO BEGIN WITH. I DON'T FEEL SAFE AT ALL DRIVING MY CAR.
Steering, Jul 7, 2016
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO POWER STEERING FAILURE AFTER ELECTRIC POWER STEERING RECALL REPAIRS. *SMD THE CONSUMER STATED AFTER THE RECALL WAS PERFORMED, THE POWER STEERING FAILED. IT WORKED INTERMITTENTLY DEPENDING ON THE WEATHER; WHEN IT WAS COLD IT WORKED, BUT WHEN IT WAS HOT, IT DIDN'T WORK. WHEN THE CONSUMER RETURNED TO THE DEALER, THEY INFORMED HIM HE WOULD HAVE TO PAY $650 TO REPLACE A PART, THAT WAS NOT COVERED UNDER THE RECALL. *JB
Steering, Jun 22, 2016, crash
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 5 MPH, THE POWER STEERING SUDDENLY FAILED AND THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN. AS A RESULT, THE CONTACT CRASHED INTO ANOTHER VEHICLE. THE CONTACT SUSTAINED A LOWER BACK INJURY THAT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE WAS REPORT WAS FILED. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC WHO STATED THAT THE ELECTRONIC POWER STEERING FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 129,000. THE VIN WAS UNAVAILABLE.
Steering, Electrical system, Jun 13, 2016
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT UNKNOWN SPEEDS, THE STEERING WHEEL BECAME EXTREMELY DIFFICULT TO MANEUVER AS THE POWER STEERING WARNING LIGHT ILLUMINATED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 15V064000 (STEERING). HOWEVER, THE FAILURE RECURRED IMMEDIATELY AFTER LEAVING THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 113,000. UPDATED 08/17/16*LJ THE CONSUMER STATED ALL THE LIGHTS ON THE DASHBOARD FLASHED AND BELLS WENT OFF, WHILE LOSING POWER STEERING. UPON ACCELERATING. UPDATED 10/25/16.*JB
Steering, Suspension, Jun 2, 2016
HAD REPAIR DONE FOR STEERING RECALL IN 2015 BUT SOMETIMES POWER STILL GOES OUT OF STEERING WHEN TRYING TO PARALLEL PARK AND WHEN ACCELERATING ON FREEWAY. SUSPENSION: VIRTUALLY NO SHOCK ABSORPTION; RIDES VERY HARD.
Steering, May 31, 2016, crash
WHILE ON EXIT RAMP FROM ONE INTERSTATE TO ANOTHER INTERSTATE HIGHWAY DURING A VEER TO THE LEFT, CAR SUDDENLY VEERED RIGHT & CROSSED A LANE OF TRAFFIC HEADING FOR AN EMBANKMENT AT APPROXIMATELY 60 MPH. I SLAMMED ON THE BRAKES, UNABLE TO STEER, WHICH CAUSED MY CAR TO TURN 180 DEGREES AND SLID INTO THE EMBANKMENT. HAD I NOT DONE THE 180 DEGREE SPIN, I WOULD HAVE HIT THE EMBANKMENT HEAD ON, LIKELY BEING SERIOUSLY INJURED OR KILLED. THE RECALL REPAIR TOOK PLACE AND OBVIOUSLY FAILED. I WILL NEVER BE ABLE TO TRUST DRIVING IT AGAIN.
Steering, May 20, 2016
I HAD THE STEERING ASSIST RECALL 14V-153 PERFORMED ON MY CAR LAST YEAR, TODAY WHEN I MAKE TURNS I AM LOSING POWER STEERING AND I GET THE POWER STEERING MESSAGE ON THE INFORMATION SYSTEM. MY GUESS IS THE SAME PROBLEM IS BACK AGAIN.
Steering, May 9, 2016
THE ELECTRICAL POWER STEERING WORK WAS FIXED PRIOR TO THE RECALL, THEREFORE WAS COMPLETED BY A PRIVATE REPAIR SHOP. WHEN THE RECALL CAME OUT GM REIMBURSED ME FOR THE REPAIRS, HOWEVER NOW THE CAR HAS TO WARM UP FOR 10 MINUTES BEFORE POWER STEERING IS ABLE TO WORK AFTER IT SITS OF THE NIGHT. I CONTACT GM REGARDING THIS PROBLEM, BUT THEY SAID SINCE THE WORK WAS COMPLETED BY A PRIVATE REPAIR SHOP THERE WAS NOTHING THEY COULD DO MEANWHILE I HAVE TO LET IT WARM UP DAILY (EVEN AT 50 DEGREES +) AND IS GETTING PROGRESSIVELY WORSE.
Steering, Suspension, Apr 25, 2016, crash
I DID BUY THIS CAR USED, BUT UPON TEST DRIVE NOTHING WRONG. 5 MONTHS LATER I HAVE A CLICKING IN STEERING, AND RUBBING SOUND, AND AS I GO DOWN THE ROAD IT SOUNDS LIKE THE FRONT END IS FALLING OFF. SERIOUSLY NEED HELP ON FIXING THIS ISSUE.
Steering, Apr 18, 2016
WHEN ACCELERATING POWER STEERING ASSIST LOCKS MOMENTARILY MAKING UNSAFE DRIVING CONDITON. LET OFF PEDAL AND IT COMES BACK.DASHBOARD BELL ALSO DINGS WHEN THIS OCCURS. ALSO STEERING MAKES BINDING NOISE LIKE A LARGE RUBBER BAND BEING STRETCHED WHEN YOU TURN THE WHEEL BACK AND FORTH.
Steering, Apr 13, 2016
"TAKATA RECALL" I WAS PULLING OUT MY DRIVEWAY AND MY STEERING WHEEL LOCKED AND IT STARTED TWITCHING SO I HURRIED UP AND PUT MY CAR IN REVERSE BUT EVERYTHING STARTED TO BLANK AND THE CAR CUT OFF IN THE MIDDLE OF THE ROAD IN FRONT OF A CAR. THERE WAS TWO GUYS IN THE CAR THAT HELPED ME PUSH MY CAR BACK IN MY YARD. I LET MY CAR REST FOR ABOUT 2 HOURS AND WENT OUT AND TRIED TO MOVE IT BUT ONCE I CRANCKED THE CAR AND PUT IT IN GEAR THE WHEEL WAS STILL LOCKED LIKE...I CAN NOT FULLY TURN LEFT OR RIGHT ALL THE LIGHTS START TO BLANK AND THE WHOLE CAR SHUTS OFF.
Steering, Power train, Mar 30, 2016
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE POWER STEERING WARNING LIGHT RANDOMLY FLASHED AND THE STEERING WHEEL WAS TIGHT EACH TIME THE FAILURE OCCURRED. THE DEALER AND THE MANUFACTURER INDICATED THAT THERE WAS A MANUFACTURER RECALL FOR THE VEHICLE AND PROVIDED NO REMEDY OR SOLUTION. THE CONTACT WAS ADVISED TO TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 15V064000 (STEERING), 14E044000 (STEERING), AND 14V153000 (STEERING). THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN). THE DEALER WAS TO SCHEDULE THE RECALL REPAIR. THE VEHICLE WAS TO BE TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION OF THE POWER STEERING FAILURE AND THE CONTACT WAS WAITING TO DETERMINE WHEN THE DEALER WOULD COMPLETE THE RECALL REPAIR. PARTS DISTRIBUTION DISCONNECT. THE APPROXIMATE FAILURE MILEAGE WAS 136,000.
Steering, Electrical system, Mar 25, 2016
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 30 MPH, THE VEHICLE STALLED AND ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT CLUSTER. IN ADDITION, WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL SEIZED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE CONTACT WAS UNSURE ABOUT WHAT PART NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.
Steering, Feb 2, 2016
STEERING WHEEL STARTED SHAKING WHILE DRIVING IN A PARKING LOT. IT CONTINUED SHAKING EVEN WHEN CAR WAS COMPLETED STOPPED. HAD TO SHUT CAR OFF TO STOP THE STEERING WHEEL FROM SHAKING.
Steering, Jan 27, 2016
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING AT AN UNKNOWN SPEED, THE STEERING WHEEL SHOOK VIOLENTLY AND SEIZED. THE VEHICLE WAS SERVICED UNDER A MANUFACTURER RECALL WHERE THE TORQUE SENSOR ASSEMBLY AND EPS MOTOR CONTROLLER UNIT WAS REPLACED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 177,000.
Steering, Jan 20, 2016
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE TRAVELED OUT OF LANE INDEPENDENTLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN AND TORQUE SENOR ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED PRIOR TO THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN NUMBER: 15V064000 (STEERING); HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING MODULE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.
Steering, Jan 18, 2016
WHEN MAKING A LEFT TURN A CLUNKING NOISE HAPPENES.TOLD BY SERVICE CENTER ITS THE STEERING COLUMN.I CHECKED INTERNET AND FOUND MANY,MANY MANY PROBLEMS WITH THE CHEV MALIBU WITH THE STEERING COLUMN.THERE IS SOMETHING WRONG WITH THIS MODEL.COST ABOUT $500.00 TO FIX AND SOME PEOPLE HAVE THE PROBLEM HAPPEN AGAIN.
Steering, Electronic stability control (ESC), Jan 16, 2016
AT TIMES IT'S VERY HARD TO STEER, TURNING THE KEY TO START THE CAR AND THE ENGINE JUST CRANKS AND WHEN YOU LET THE KEY OFF THE ENGINE CONTINUES TO CRANK.
Steering, Dec 21, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT THE STEERING WHEEL SEIZED. THE CONTACT MENTIONED THAT THE STEERING COLUMN WAS TOO LOOSE NEARLY CAUSING THE CONTACT TO LOSE CONTROL OF THE VEHICLE, WHILE TURNING. IT WAS UNKNOWN IF THE VEHICLE WAS DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 53,000.
Steering, Electrical system, Other or unspecified, Dec 15, 2015
I BOUGHT THIS VEHICLE USED FROM PAUL CONTE CHEVROLET IN FREEPORT, NY AND IT HAD 3 RECALLS THAT WERE NOT FIXED BEFORE SELLING IT TO ME. NOW MY POWER STEERING SYSTEM MALFUNCTIONED TO THE POINT WHERE THE STEERING WHEEL WOULD TWITCH UNCONTROLLABLY AND THEN BECOME STIFF, MAKING IT VERY DIFFICULT AND DANGEROUS TO STEER. I ENDED UP PAYING FOR THE REPAIRS TO THE TUNE OF ALMOST $1700.00 TO REPLACE THE STEERING COLUMN AND STEERING MOTOR. AFTER DOING SOME RESEARCH, I FOUND THAT GM RECALLED MANY VEHICLES OF THE SAME YEAR, MAKE, AND MODEL AS MY CAR BUT FOR MY SPECIFIC VIN ONLY THE STEERING TORQUE SENSOR WAS RECALLED. I DID GET THE STEERING TORQUE SENSOR RECALL FIXED BUT MY STEERING WAS STILL MESSED UP. THIS RECALL DID NOT FIX MY VERY SERIOUS AND POTENTIALLY DANGEROUS ISSUE. IT WAS ONLY AFTER I AUTHORIZED THE STEERING COLUMN AND MOTOR REPAIRS THAT THE ISSUE WAS RESOLVED. GM CUSTOMER SERVICE IS SAYING THAT EVEN THOUGH I HAD THE SAME EXACT ISSUE AS THE GM RECALL FOR OTHER MALIBU'S, BECAUSE MY SPECIFIC VIN DID NOT FALL UNDER THE RECALL, I WILL NOT BE GETTING REIMBURSED. IT IS NOT RIGHT THAT GM BE ABLE TO GET AWAY WITH THIS. THIS SERIOUS STEERING ISSUE COULD HAVE CAUSED ME TO CRASH. I WOULD LIKE TO FILE A COMPLAINT AGAINST GM FOR FAILURE TO RECALL ALL VEHICLES THAT WERE AFFECTED BY THIS POWER STEERING ISSUE AND ALSO REQUEST THAT THEY REIMBURSE ME FOR FIXING AN ISSUE THAT SHOULD HAVE BEEN TAKEN CARE OF BEFORE I EVEN BOUGHT THE CAR. THE LINK BELOW WILL TAKE YOU TO THE OFFICIAL GM STATEMENT ON THIS POWER STEERING ISSUE. HTTP://MEDIA.GM.COM/MEDIA/US/EN/GM/VEHICLES.DETAIL.HTML/CONTENT/PAGES/NEWS/US/EN/2014/MAR/0331-POWER-STEERING.HTML
Steering, Dec 14, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT A LOW SPEED, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO APPLY FORCE TO THE STEERING WHEEL IN ORDER TO STEER THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHO REPAIRED THE VEHICLE UNDER NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING) HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A DEALER BUT HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 187,000.