2006 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,385 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Malibu model years with reports.
Of the 2006 reports, 53 involved a crash and 7 involved a fire. 31 people were injured.
What owners report most often
Recalls and investigations
Steering, electric power assist systemFeb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Campaign 15V064000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Air bags, frontalOct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Campaign 06V417000 on NHTSA.gov
Equipment, other, labelsOct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 05V486000 on NHTSA.gov
Representative owner complaints: steering
1,017 reports, newest first. Show all
Steering, Nov 24, 2015
2006 CHEVROLET MALIBU MAXX. CONSUMER WRITES IN REGARDS TO DISSATISFACTION ON HOW RECALL #14116 HAS BEEN HANDLED. *SMD THE CONSUMER STATED UPON COMPLETION OF THE RECALL, SHE CONTINUED TO EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST.*JB
Steering, Nov 9, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING), BUT THE REMEDY DID NOT CORRECT THE FAILURE. UPON MAKING A LEFT OR RIGHT TURN, THE STEERING WHEEL DID NOT TURN AND THE CONTACT HAD TO APPLY FORCE TO TURN THE STEERING WHEEL. THE DEALER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 96,000.
Steering, Nov 8, 2015
WHEN MY WIFE TURNED RIGHT THE STEERING WHEEL LOCKED UP AND LIGHTS ON DASHBOARD STARTED FLASHING IT SCARED MY WIFE
Steering, Nov 6, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 25 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER AND THE POWER STEERING WARNING LIGHT ILLUMINATED. IN ADDITION, WHILE MAKING A LEFT OR RIGHT TURN, THERE WAS AN ABNORMAL SOUND COMING FROM THE STEERING COLUMN. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING ASSIST MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000.
Steering, Oct 27, 2015
THE STEERING WHEEL WILL GET HARD TO TURN USUALLY WHEN I AM IN THE PROCESS OF CHANGING LANES ON THE INTERSTATE AND ACCELERATING. SOMETIMES AN ALARM WILL COME ON AND A LIGHT WILL COME ON FOR A FEW SECONDS AND THEN GO OFF. HERE LATELY THE ALARM IS NOT COMING ON. IT IS GETTING WERE IT IS HAPPENING MORE OFTEN, AT LEAST A COUPLE TIMES A WEEK NOW. MOST OF MY DRIVING IS DONE ON THE INTERSTATE AND IT IS SCARY BECAUSE I NEVER KNOW IF I CAN TRUST MY CAR WHEN MERGING ONTO THE INTERSTATE.
Steering, Oct 27, 2015
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO POWER STEERING MALFUNCTION WHILE DRIVING. *SMD THE CONSUMER STATED WHILE DRIVING, THE STEERING WHEEL LOCKED UP AND THE CONSUMER WAS UNABLE TO STEER THE WHEEL RIGHT OR LEFT. THE VEHICLE WAS TOWED TO THE DEALER, WHERE THE STEERING COLUMN ASSEMBLY WAS REPLACED AT A COST OF $ 703.90. THE CONSUMER SUBMITTED SENT IN A RECALL FOR THE STEERING. *JB
Steering, Oct 10, 2015
BEFORE I SEEN IT WAS IN HERE, MY INTERMEDIATE SHAFT WENT OUT ON MY CAR, AND I REPLACED IT. I SAW THE RECALL IN HERE AND CALLED DORMAN TO HAVE THEM REIMBURSE ME 258.00 FOR THE PART, BUT THEY SAID THAT THEIR NOT RESPONSIBLE TO REPLACE THE PART AS YOUR INF0RMATION IN HERE STATES, SO WHO IS IN CHARGE? I HAVE PROOF I HAD TO REPLACE IT AND CAN DISCLOSE THE INFORMATION. I JUST WANT THE 258.00 I PAID TO REPLACE IT. MY VEHICLE WAS MOVING WHEN I HEARD THE NOISE AS I WOULD STEER TO THE RIGHT MORE THAN THE LEFT BUT BOTH SIDES MADE NOISE.
Steering, Oct 7, 2015
WHILE DRIVING ON THE FREEWAY, THE STEERING WHEEL LOCKED FOR A MOMENT; THEN, IT WENT BACK TO NORMAL. WHEN THIS HAPPENED, THE SIGNAL LIGHT SOUNDED, BUT THE SIGNAL LIGHT WERE NOT ON. THIS HAS HAPPENED TO MY HUSBAND AND I, COUPLE OF TIMES' I AM SCARED TO DRIVE MY CAR. I CALLED CHEVROLET (DEALER) THEY DID NOT KNOW WHAT IT IS. I CALLED A FRIEND OF MINE; HE'S A MECHANIC AND TOLD ME THAT HE DID NOT KNOW EITHER. THANK YOU *TR
Steering, Oct 4, 2015
LOSS OF STEERING CONTROL WHILE DRIVING ON EXPRESSWAY AT 50+MPH. DIFFICULT TO MAINTAIN CONTROL. ABLE TO SLOW DOWN AND EXIT FREEWAY. DEALER WAS CLOSE BY SO LEFT ON LOT OVERNIGHT. CHECK ENGINE LIGHT ALSO HAD COME ON. DEALER REPORTED FOUND CODE C0550 WHEN RUNNING DIAGNOSTICS. DEALER INFORMED THE P/S CONTROL MODULE NEEDED REPLACED. INFORMED WAS NOT COVERED UNDER A CURRENT RECALL. DEALER HAD VEHICLE FOR OVER 1 WEEK BECAUSE FIRST UNIT DID NOT FIX THE PROBLEM. SEARCH REVEALS SAME ISSUE AS IN BULLETIN 14118 FOR MODEL YEAR 2008 MALIBU.
Steering, Sep 25, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT, THERE WAS A POPPING NOISE COMING FROM THE STEERING WHEEL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 91,000.
Steering, Sep 23, 2015
WHEN TURN TO THE LEFT. THE STEER WHEEL LOCKS UP AND YOU HEAR 4 CHIMES. IS THERE A RECALL OR CAN THIS BE FIXED? THANKS [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *JB
Steering, Sep 21, 2015
WHILE DRIVING, I LOSE CONTROL OF POWER STEERING FOR A BRIEF TIME. POWER STEERING FLASHES ON MY CONSOLE RIGHT BEFORE THIS OCCURS. THE FIRST TIME, I ALMOST COLLIDED WITH AN 18 WHEELER WHILE MAKING A LEFT TURN. UPON GOING TO THE DEALER, I WAS ADVISED IT IS MY MALIBU'S ELECTRIC POWER STEERING ASSIST MOTOR. THIS PART IS COVERED UNDER THE 2008 MALIBU RECALL AND CERTAINLY SHOULD HAVE BEEN INCLUDED IN THE 06! THIS IS A GRAVE SAFETY ISSUE THAT MANY ARE EXPERIENCING.
Steering, Sep 17, 2015, crash
AFTER (2-3) RECALLS ON STEERING, AFTER STEERING SENSORS REPLACED ALSO, VEHICLE OKAY FOR ABOUT A MONTH, THEN BACK TO SAME STEERING LOSS ISSUES. LOSS OF POWER STEERING AND RUMBLING OF THE STEERING COLUMN, TO THE POINT IT FEELS LIKE THE COLUMN AND A TIRE IS GOING TO FALL OFF ! MY FIRST INCIDENT STARTED BACK IN 2013-14, TOTAL STEERING LOSS AND HIT A GUIDE RAIL CAUSING DRIVER FRONT FENDER DAMAGE. AFTER SEVERAL RECALL REPAIRS, VEHICLE STILL RECREATES SAME DANGEROUS FAILING STEERING SITUATION ! MY FAMILY IS SCARED TO DEATH TO DRIVE THIS VEHICLE ANYMORE, ITS AN ACCIDENT JUST WAITING TO HAPPEN, OVER AND OVER AGAIN. THIS IS A TOTAL COLUMN PROBLEM IN THESE 2006 MALIBU'S, NOT JUST SENSORS, SWITCHES, ETC. THESE STEERING COLUMNS NEED REPLACED. ACCIDENTS ARE INEVITABLE IF NOT ADDRESSED TOTALLY. SHAME ON GM FOR TRYING TO PIECE THIS PROBLEM OUT AS CHEAPLY AS POSSIBLE. CONCERNED, TED MEIXELSBERGER
Steering, Sep 8, 2015
VEHICLE TAKEN TO BLOOMSBURG PA. CHEVY DEALERSHIP FOR BULLETIN 14116. EPS MOTOR CONTROLLER WAS NOT REPLACED AS PER RECALL STATES TO REPLACE. REPEATED CALLS AND VISITS TO DEALERSHIP HAS YIELDED NO RESULTS. THERE INVOICE AFTER SAID REPAIRS WHERE MADE, CLEARLY SHOWS THAT JUST SENSOR ASSEMBLY WAS REPLACED.
Steering, Sep 4, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 10 TO 15 MPH, THE STEERING WHEEL SEIZED MOMENTARILY WHEN MAKING A LEFT TURN. THE CONTACT COULD NOT CONTROL THE STEERING WHEEL. THE FAILURE RECURRED NUMEROUS TIMES. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.
Steering, Aug 31, 2015
MY CAR MAKES CREAKING NOISES WHEN TURNING RIGHT. I HAD TWO OPINIONS AND BOTH SAID INTERMEDIATE DRIVE SHAFT. I HAD IT FIXED BUT IF ITS A RECALL CAN I GET REIMBURST TO PAY DOWN MY CREDIT CARD?
Steering, Aug 28, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING THE VEHICLE AND MAKING A RIGHT TURN, THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE POWER STEERING ASSIST NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT, IMMEDIATELY AFTER RETRIEVING THE VEHICLE, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO INDICATED THAT THE POWER STEERING MOTOR FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 170,000.
Steering, Aug 20, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING AT VARIOUS SPEEDS MAKING EITHER A LEFT OR RIGHT TURN, A CLICKING NOISE EMITTED FROM THE STEERING WHEEL AND THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE FAILURE RECURRED ON SEVERAL OCCASIONS AND APPEARED TO OCCUR IN WET WEATHER. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 15V064000 (STEERING). THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE STEERING SHAFT WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 36,521.
Steering, Electronic stability control (ESC), Service brakes, Aug 18, 2015
I HAVE HAD PROBLEMS WITH MY POWER STEERING OVER THE YEARS. BUT THIS WAS THE WORST IT HAS EVER BEEN. I WAS DRIVING 55 MPH ON THE HIGHWAY. THE ROADS WERE CLEAR ON THIS SPRING DAY. MY TRACTION CONTROL, BRAKE LIGHT AND CHECK ENGINE LIGHT CAME ON. THEN THE POWER STEERING WAS CHIMING AND THE ALERT CAME ON FOR THAT WHICH EFFECTED MY POWER STEERING. THE INSTRUMENT CLUSTER WAS FLASHING ON AND OFF ALONG WITH THE GAUGES NOT WORKING CORRECTLY. THEN THE INSTRUMENT CLUSTER WENT COMPLETELY OUT. SO THE INSTRUMENT CLUSTER WAS REPLACED. A COUPLE OF WEEKS LATER, THIS ALL REPEATED AGAIN. SO THIS TIME THE IGNITION WAS REPLACED. AFTER ALL THAT, THE POWER STEERING STILL CHIMES AND ALERTS STILL COME ON WHICH MAKES IT HARDER TO STEER. THEN I HAVE TO STOP THE CAR, TURN IT OFF, WAIT AND RESTART IT. THEN IT IS FINE FOR A WHILE. MY MECHANIC SAYS THE ONLY CODE THAT SHOWS UP IS FOR THE 14772 RECALL. BUT MY CAR IS NOT PART OF THAT RECALL SINCE IT WAS MANUFACTURED IN JANUARY OF 2006. PLEASE DO SOME RESEARCH AND EXPAND THE CURRENT RECALL TO INCLUDE ALL 2006-2007 CHEVROLET MALIBU AND MALIBU MAXX VEHICLES. REPAIRS NEED TO BE DONE ON THESE VEHICLES ASAP TO ANY FATAL OR POTENTIAL CRASHES.
Steering, Aug 17, 2015
VEHICLE STEERING DOES NOT FULLY RESPOND WHEN ENTERING TURNS, CURVES IN THE ROAD AT TIMES. THIS IS A INTERMITTENT PROBLEM, BUT MORE TIMES THAN NOT. CHEVROLET DEALER DIAGNOSIS IS FAULTY POWER ASSIST MOTOR, MODULE STEERING GEAR AND INTERMEDIATE SHAFT. MY INQUIRES ON WHY THESE MAJOR COMPONENTS HAD FAILED HAVE GONE UNANSWERED. ANY HELP IN THIS MATTER IS GREATLY APPRECIATED. DO HAVE ALL DOCUMENTATION. SIGN, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB
Steering, Power train, Vehicle speed control, Aug 14, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 40 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN RIGHT OR LEFT. ALL OF THE LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), 14V153000 (STEERING), AND 14V224000 (POWER TRAIN). THE PARTS NEEDED FOR THE REPAIR WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 228,178.
Steering, Electronic stability control (ESC), Aug 7, 2015
WHEN I ACCELERATE QUICKLY TO ENTER TRAFFIC, MERGE WITH TRAFFIC OR PASS A CAR (GOING 25 - 50 MPH), I HEAR DING, DING, DING WARMING BELL AND THE STEERING WHEEL PULLS TO THE RIGHT AND MOMENTARILY BECOMES LOCKED. I GRAB IT WITH BOTH HANDS AND LET OFF THE GAS AND IT RECOVERS. IT IS TOTALLY UNMANAGEABLE FOR THOSE MOMENTS AND VERY ALARMING. I HAVE HAD MY CAR IN FOUR DIFFERENT TIMES SINCE NOV, 2011 FOR POWER STEERING PROBLEMS/RECALLS. THIS CURRENT PROBLEM IS A SAFETY FACTOR!!!! UPDATED 09/15/15*LJ.....UPDATED 10/01/15*BF THE CONSUMER STATED THE STEERING COLUMN AND COLUMN SENSOR WERE REPLACED TWICE. UPDATED 10/13/15. *JB *CN
Steering, Aug 3, 2015
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE ATTEMPTING TO ACCELERATE FROM A COMPLETE STOP, THE STEERING WHEEL EMITTED A GRINDING NOISE WHILE TURNING. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE STEERING WHEEL INTERMEDIATE STEERING SHAFT AND THE POWER STEERING GEAR BINDING WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 152,000.
Steering, Jul 31, 2015
WHILE DRIVING, WHEN YOU ACCELERATE, THE STEERING WHEEL LOCKS UP AND YOU CAN'T STEER THE CAR, LOSING ALL CONTROL. IT LOCKS UP FOR A SECOND OR TWO. THIS CAR WAS RECALLED FOR THE STEERING AND MANY OTHER ISSUES, AND WE TOOK IT IN TO BUNNIN CHEVROLET IN CULVER CITY, CA FOR THE REPAIRS. THEY REPAIRED IT UNDER THE RECALL, BUT IT DID NOT FIX THE PROBLEM. THE STEERING STILL LOCKS UP AND IT WILL DO IT MULTIPLE TIMES IN ONE DRIVING SESSION.
Steering, Jul 29, 2015
I HAVE WAITED 3 YEARS FOR A RECALL FOR MY STEERING PROBLEM WHICH STARTED 08-2012 WITH 75,000 MILES. ON 03/13/15 I TOOK MY CAR IN FOR RECALL #14116 WITH 95,000 MILES. THE FIX FAILED COMPLETELY. ON 07/07/15 WITH 98,800 MILES I RETURNED TO THE CHEV DEALER FOR A DIAGNOSTIC. WHICH COST ME $108.00. RECEIVED A CALL FROM DEALER, AFTER ROAD TEST AND DIAGNOSTIC, COULD NOT FIND A PROBLEM. NEXT DAY I TOOK THE MECHANIC FOR A TEST DRIVE AND HE SAW THE PROBLEM. ALERT CHIMES, POWER STEERING DISPLAYED ON THE DIC AND LOSS OF POWER STEERING. AFTER TALKING WITH CHEVROLET TECH SUPPORT THERE BEST GUESS WAS A FAILING POWER STEERING CONTROL MODULE. AND WANTED $650.00 PLUS THE $108.00 I PAID FOR THE DIAGNOSTIC WITH NO GUARANTEE THAT IT WOULD FIX THE PROBLEM, MAY NEED OTHER REPAIRS. I DECLINED. I DID MORE REACH AND FOUND TECHNICAL SERVICE BULLETIN # 10183A, SPECIAL COVERAGE PROGRAM. 10 YEAR OR 150,000 MILE WARRANTY ON THE STEERING COLUMN ASSEMBLY. RETURNED TO DEALER ON 07/13/15, 98,800 MILES AND HAD STEERING COLUMN ASSEMBLY REPLACED UNDER THE WARRANTY. NO CHANGE, THE PROBLEM STILL EXIST. MORE REACH FOUND ALL VEHICLES THAT HAVE RECALL #14116 DONE FAILED TO WORK. 99% WERE TOLD BY THE CHEV. DEALERSHIP LIKE ME THAT THE POWER STEERING CONTROL MODULE FAILING. I'AM REQUESTING THAT NHTSA ADD THE PART TO THE RECALL LIST OR MAKE CHEVROLET DO SOMETHING TO FIX THE PROBLEM IN LESS THAN ANOTHER 10 YEARS. HAVE CONTACTED CHEVROLET CUSTOMER ASSISTANCE CENTER NO REPLY AFTER 3 BUSINESS DAYS.