2006 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,385 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Malibu model years with reports.
Of the 2006 reports, 53 involved a crash and 7 involved a fire. 31 people were injured.
What owners report most often
Recalls and investigations
Steering, electric power assist systemFeb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Campaign 15V064000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Air bags, frontalOct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Campaign 06V417000 on NHTSA.gov
Equipment, other, labelsOct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 05V486000 on NHTSA.gov
Representative owner complaints
1,385 reports, newest first.
Steering, Apr 25, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE POWER STEERING LIGHT ILLUMINATED THEN THE POWER STEERING FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 79,300.
Steering, Electrical system, Apr 23, 2014
CAR SHUTS OFF WHILE DRIVING AN STEERING IS HARD. *TR
Service brakes, Apr 22, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKES SEIZED WITHOUT WARNING. THE FAILURE RECURRED TWENTY TIMES. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 140,000. THE VIN WAS UNAVAILABLE.
Steering, Apr 22, 2014
WHILE MERGING ON TO A HIGHWAY, MY STEERING LOCKED UP AND MY SON, WHO WAS DRIVING, SUDDENLY COULDN'T STEER. FORTUNATELY, IT ONLY LASTED FOR A FEW SECONDS, AND IT CAME BACK. HAD IT NOT COME BACK, WE WOULD HAVE HAD A COLLISION WITH A SEMI-TRUCK THAT WAS RIGHT NEXT TO US. THIS IS NEVER HAPPENED PRIOR TO THIS AND NOT SINCE. MY LOCAL CHEVY DEALER ASSURES ME THAT THERE ARE NO RECALLS ON THIS MODEL, HOWEVER, HE ALSO COULDN'T TELL ME WHY SOMETHING LIKE THIS WOULD HAPPEN OR OFFER A SUGGESTION. PLEASE ADVISE. *TR
Fuel system, Gasoline, Apr 21, 2014
I SEE THAT THERE HAS BEEN A RECALL FOR CHEVY MALIBU 2004-2007 ON FUEL PUMPS WITH A PART NUMBER OF TU456. MY FUEL PUMP HAS NOT BEEN WORKING CORRECTLY, AND I AM NOT SURE IF THIS WAS PART OF THE RECALL OR NOT. I AM HOPING THIS IS ONE OF THE VEHICLES THAT WAS IN THE RECALL, SO NOTHING HAPPENS TO ME OR MY FAMILY WHILE DRIVING DOWN THE ROAD. IF SO I WOULD LIKE SOMEONE TO FIX THIS AS IN CHEVY FIXING THIS PROBLEM. THANK YOU. *TR
Steering, Fuel system, Gasoline, Apr 20, 2014
SOON AFTER I PURCHASED THIS CAR I STARTED HAVING PROBLEMS WITH THE POWER STEERING SYSTEM. IN MANY OCCASIONS WHEN I START THE ENGINE THE POWER STEERING DOES NOT WORK. I CANNOT MOVE THE STEERING WHEEL. I TURN THE ENGINE OFF, WAIT A FEW SECONDS AND START THE ENGINE AGAIN, AND THE POWER STEERING WORKS. I HAVE HAD THIS PROBLEMS AT LEAST 15 OR 20 TIMES SINCE I PURCHASED THE CAR IN JANUARY 9, 2012. IT HAS NEVER HAPPENED WITH THE CAR MOVING. ALSO WHEN I MOVE THE STEERING WHEEL FROM ONE SIDE TO THE OTHER THE POWER STEERING ALERT LIGHT COMES ON AND OFF AND I HEAR A CLUNK NOISE THAT I CAN FEEL IN THE STEERING WHEEL. IT IS LIKE IF SOMETHING IS LOOSE IN THE STEERING SYSTEM. I CHECKED THE RACK AND PINION IN SEVERAL OCCASIONS AND FOUND IT HAD THE SCREWS THAT HOLD IT TO THE FRAME LOOSE. I TIGHTENED THEM BUT THE NOISE DOES NOT GO AWAY. I DRIVE THIS CAR WITH CAUTION AND FEAR BECAUSE OF THE POWER STEERING PROBLEM AND THE NOISE IN THE STEERING SYSTEM. THIS MONTH (APRIL 2014) I STARTED HAVING PROBLEMS WITH THE FUEL LEVEL SENDING UNIT. SOMETIMES IT MARKS FULL AND OTHERS EMPTY WITH GAS IN THE TANK. AT THE SAME TIME THE CHECK ENGINE LIGHT COMES ON AND OFF. *TR
Steering, Suspension, Apr 20, 2014
I WAS DRIVING HOME FROM WORK ABOUT 12 MIDNIGHT,ON THE DAN RYAN EXPRESSWAY. THE TRAFFIC WAS HEAVY WITH LOTS OF TRUCK ON THE ROAD. I HEARD THREE BEEPS THEN A MESSAGE RAN ACROSS THE DASH CHECK POWER STEERING, BEFORE I COULD FINISH READING THE MESSAGE I HAD NO POWER STEERING. THE CAR STARTED TO DRIVING ROUGH VIBRATING VERY HARD TO CONTROL. I WAS ABOUT THREE LANE OVER FROM THE EXIT LANES.THANK THE LORD I'M STILL HERE. I SEEN A RECALL IN MARCH OF 2010 ON THE MONTE CARLO CALL AND INQUIRED ABOUT MY CAR TALKED WITH A MANAGER NAMED [XXX] FOR ABOUT TWO MONTHS NO CONTACT THEN WAS TOLD NOT A PART OF RECALL .REPAIR $1700 WEBB CHEVY. GENERAL MOTORS DOES NOT CARE ABOUT IT'S CONSUMERS AND SOMETHING NEEDS TO BE DONE THIS IS AN OUTRAGE. AND I WILL NEVER BUY ANOTHER GM. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Steering, Apr 19, 2014
I WAS MAKING A RIGHT HAND TURN ONTO A BUSY INTERSECTION AND STEERING WENT OUT I ENDED UP IN THE LANE OF ON COMING TRAFFIC TURNING IN A LEFT TURNING LANE IN OPPOSITE DIRECTION. THANK THE LORD NO ONE WAS IN THAT LANE. AND THE 2ND TIME 2 WEEKS LATER IT HAPPENED AGAIN WHEN I WAS TURNING INTO A EXXON STATION AND ALMOST HIT THE GAS PUMP.JUST GLAD MY BREAKS WORKED GOOD AND HAD BOTH HANDS ON THE WHEEL SINCE THE FIRST INCIDENT OCCURRED. WHEN WILL WE GET A NOTIFICATION ABOUT THE RECALL.. I HAVE NOT RECEIVED ANYTHING YET. IF NEED BE I WILL TAKE MORE STEPS BECAUSE THIS NEEDS TO BE FIXED AND I AM NOT PAYING FOR IT. I CALLED THE PLACE WHERE I BOUGHT THE CAR AND THEY GAVE ME A NUMBER TO CALL AND I DID AND I WAS TOLD TO WAIT UNTIL I GOT RECALL CARD IN THE MAIL AND HAVE NOT SEEN ANYTHING YET......THAT WAS A MONTH AGO. *TR
Steering, Electrical system, Apr 18, 2014
I HAVE TAKEN MY CAR TO SIERRA CHEVROLET IN SOUTHFIELD, MI WHERE IT WAS PURCHASED IN 10/13, SINCE PURCHASING ON 3 DIFFERENT OCCASIONS IN 5 MONTHS FOR LOSS OF POWER STEERING AND ALL SYSTEMS ON DASHBOARD DROP TO ZERO (0), GAS, SPEEDOMETER AND RPM'S. I WAS FIRST CHARGED $125 (DEALER CLAIMED THEY WOULD SPLIT COST) WHICH DIDN'T FIX PROBLEM. NOW THEY ARE TRYING TO CHARGE ME $430 TO REPLACE A MODULE WITH NO GUARANTEE THIS WILL FIX PROBLEM. I AM BEING REPEATEDLY TOLD MY CAR DOES NOT FALL UNDER THE RECALL. I HAVE A COPY OF LETTER FROM NHTSA TO GENERAL MOTORS DATED 3/31/14 IDENTIFYING SAFETY RECALL OF POWER STEERING AS WELL GM'S LETTER TO DEALERSHIPS DATED 3/31/14 REFERRED TO AS BULLETIN # 14116 WHICH STATES DEALERS ARE TO REPLACE TORQUE SYSTEM IN MODELS 2004-2006 MALIBU. *TR
Power train, Apr 17, 2014
MY PROBLEM STARTED AROUND THE END OF FEBRUARY AND THE PROBLEM IS GETTING WORST. I HAVE A NOISES THAT COMES FROM MY STEERING WHEEL, DRIVING ANY SPEED, AND MAKING COMPLETE TURNS AT ANYTIME IT WILL JUST GO OUT. SOME TIMES IT STARTS WHEN I GO OUT TO START MY CAR UP AND THE MESSAGE BORAD SAYS CHECK POWER STEERING, WHICH MAKING IT VERY HARD TO MAKE TURNS. I CALLED THE DEALERSHIP AND THEY SAID THE KNOW ABOUT RECALL, BUT SAID I HAVE TO WAIT FOR A NOTICE BECAUSE IT'S NOT ALL 2006 CHEVROLET MALIBU'S.
Steering, Other or unspecified, Apr 15, 2014
I PURCHASED A USED CAR ON 3/8/2014-RETURNED VECHILE ON 3/13/2014 FOR SERVICE DUE TO EXCESSIVE PULLING TO THE LEFT WHILE DRIVING AND CHECK ENGINE LIGHT CAME; IT WAS INSPECTED ON 2/28/2014; SINCE THAT TIME, I HAD RETURN 3 TIMES FOR THE PULLING AND 2 TIMES FOR THE CHECK ENGINE LIGHT AGAIN TO BE REPARIED.. THE MILEAGE ON THE CAR FOR THE CHECK ENGINE WAS AS FOLLOWS FOR THE CODE P0605 AND EVAP MONITOR NOT READY AND MALFUNCTION INDICATOR LIGHT CODE 61,737 , 61,804, -DEALER CLAIMED IT WAS REPARIED BUT CONTINUED TO COME ON- 62,355 62,594 - THE CODE WAS FOR THE EVAP MONITOR AND I NO LONGER WENT TO DEALER SINCE THE MANAGER, CHRIS, OF THE SERVICE DEPARTMENT SAID IF I WAS GOING TO REPORT THE PROBLEMS TO MOTOR VEHICLE OR ATTORNEY GENERAL THEY WOULD NO LONGER SERVICE IT.(ALL AMERICAN FORD-[XXX], KINGSTON NY) I BROUGHT IT TO HAVILAND AUTO REPAIR ([XXX] HYDE PARK, NY)BEFORE AND AFTER THE SERVICING FROM ALONG WITH MONROE MUFFLER FOR ESTIMATE ON THE PULLING TO THE LEFT AND THE CHECK ENGINE LIGHT. A FOUR WHEEL ALIGNMENT HAD BEEN COMPLETE AND IT STILL PULLS AND THE LIGHT CONTINUES TO COME ON AFTER SO MANY MILES; DUE TO EXCESSIVE PULLING, THE TIRES WIL WEAR EASILY AND AT HIGHER SPEEDS-50 + IT IS WORK TO KEEP IT SWAYING... 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *TT
Steering, Apr 15, 2014
IT STARTED IN JAN, AND GETTING WORST, JUST DRIVING ANY SPEED, COULD BE COMPLETING TURNS, ANYTIME IT JUST GOES OUT. TOOK TO DEALER, THEY KNOW ABOUT RECALL, SAID WE HAVE TO WAIT FOR OUR NOTICE. BECAUSE IT'S NOT ALL 2006 CARS.....IT'S HAPPENING TO OUR CAR! HOW MUCH LONGER BEFORE WE RECEIVE NOTIFICATION? ALSO WHAT IF WE DON'T RECEIVE NOTIFICATION . SHOULD WE JUST GET LEGAL HELP, TO GET THIS RECTIFIED AND FIXED NOW BEFORE AN ACCIDENT OCCURS, BEFORE SOMEONE GETS HURT! SORRY IF THIS ISN'T WHAT THIS IS FOR, JUST GETTING RUN AROUND AND VERY FRUSTRATED AND AFRAID THAT AN ACCIDENT WILL HAPPEN! *TT
Steering, Air bags, Apr 14, 2014
THE CAR AIRBAG LIGHT IS ON BECAUSE OF THE CLOCK SPRING AND THE STEERING IS INTERMITTENTLY WORKING OTHER MALIBUS AND CARS ARE UNDER RECALL FOR STEERING BUT MINE IS NOT AND IS NOT BEING COVERED BY CHEVY VERY DANGEROUS TO DRIVE HARD STEERING AT LOW SPEEDS AND PROBLEM WITH STEERING COLUMN. *JS
Exterior lighting, Apr 14, 2014
BRAKE LIGHTS COMING ON WITHOUT DEPRESSING BRAKE PEDAL WHEN DRIVING CAR. *JS
Wheels, Apr 10, 2014
ON THREE DIFFERENT OCCASIONS I HAVE HAD TO HAVE THE ORIGINAL RIMS REPLACED OR STRAIGHTENED AFTER NORMAL USE. THE REPAIR SHOP INFORMED ME THAT THE RIMS HAD MOST LIKELY BEEN BENT FROM HITTING A POTHOLE OR RAILROAD TRACKS. NO EXCESSIVE SPEED OR HAZARDOUS ROAD CONDITIONS, OR OFF ROAD CONDITIONS HAVE BEEN EXPERIENCED BY THE VEHICLE. YET, DURING NORMAL WEAR AND USAGE THE ORIGINAL RIMS ON THE VEHICLE EASILY BEND CAUSING THE CAR TO SHAKE AND THE TIRES TO WEAR UNEVENLY. *TR
Steering, Fuel system, Gasoline, Apr 9, 2014, crash
WAS AND THE STEERING WHEEL LOCKED UP WHILE IT WAS RAINING CAR STOPPED AND GOT FLOODED UNDER THE UNDER PASS COULDN'T MOVE THE CAR MOTOR WOULDN'T START ARE ANYTHING WE HAD TO GET RESCUED OUT OF THE CAR DUE TO THE POWER. *TR
Engine, Apr 6, 2014
I FILED A COMPLAINT LAST YEAR IN REFERENCE TO THE RANDOM STOPPING ISSUE ON MY 2006 CHEVY MALIBU. ALTHOUGH SEVERAL VEHICLES HAVE BEEN RECALLED, THE MALIBU'S AND IMPALAS HAVE BEEN OVERLOOKED AS THEY HAVE THE SAME ISSUES AS THE OTHER RECALLED VEHICLES. I HAVE A VEHICLE THAT IS A LITERAL DEATHTRAP AND THE CHEVY SERVICE DEPARTMENT HAS ADVISED ME THAT THEY CANNOT DIAGNOSE THE VEHICLE. IF YOU REVIEW THE VARIOUS CAR FORUMS, THE RANDOM STOPPING ISSUE IS A COMMON PROBLEM WITH ALL CHEVY VEHICLES MAKE IN THIS TIMEFRAME. THE DEALERSHIPS OFFER LITTLE ASSISTANCE IN RESOLVING THE ISSUES IF NO CODE IS GENERATED. THE VEHICLES ARE ENGINEERED TO STOP IN THE EVENT OF ALMOST ANY MINOR ISSUE WITH THE VEHICLE. I AM A SINGLE PARENT THAT PURCHASED THIS CAR FOR MY DAUGHTER IN COLLEGE. SHE HAS COME HOME IN TEARS MANY TIMES DUE TO THE VEHICLE STOPPING ON HER WITH NO WARNING AND ALMOST BEING HIT SEVERAL TIMES. I HAVE SPENT ALMOST $1500 TRYING TO DETERMINE THE ISSUE THAT CHEVY COULD NOT DIAGNOSE. I HAD TO PURCHASE ANOTHER VEHICLE FOR MY DAUGHTER WHILE THE MALIBU IS LITERALLY USELESS AND SITS ON MY DRIVEWAY. I WOULD HATE TO EVEN GIVE IT AWAY KNOWING OF THIS ISSUE. IF I SELL THIS VEHICLE TO SOMEONE ELSE, I AM SELLING A DEATHTRAP THAT COULD CAUSE ANOTHER FAMILY A MAJOR TRAGEDY. I FILED ANOTHER COMPLAINT WITH GM AND WAS JUST TOLD AGAIN LAST WEEK THAT THEY VEHICLE CANNOT BE DIAGNOSED. THEY WENT BY THE INFORMATION FROM THE FIRST DIAGNOSTIC AND DID NOT EVEN ATTEMPT TO LOOK AT IT AGAIN. PLEASE ENCOURAGE GM TO DO THE RIGHT THING AND RECALL THESE VEHICLES OR BUY THEM BACK AS THEY ARE USELESS DEATHTRAPS. THERE IS NO SUCH THING AS NOT BEING ABLE TO DIAGNOSE A VEHICLE. THEY ARE MERELY HIDING BEHIND MORE DEFECTS THAT THEY ARE UNWILLING TO DISCLOSE. *TR
Steering, Apr 5, 2014
I HAVE BEEN HAVING ISSUES WITH MY WHEEL SINCE 2008. I TOOK MY CAR TO MULTIPLE CHEVY DEALERSHIPS AND WAS INFORMED THAT THERE WAS NOT AN ISSUE. FAST FORWARD TO 2013 AS I WAS MAKING A TURN MY POWER STEERING COMPLETELY WENT OUT AND I HAD TO LET THE CAR GLIDE MY CAR INTO THE SIDE WALK AS THE WHEEL STOPPED WORKING COMPLETELY. I HAVE CONTACTED GM CUSTOMER SERVICE AND WAS INFORMED THAT THERE IS NOT A PROBLEM AND I WOULD STILL HAVE TO COME OUT OF MY POCKET IN ORDER TO GET THIS CAR FIXED BUT I FOUND ONLINE THOUSANDS OF PEOPLE HAVING THE SAME ISSUE AS MY CAR. I WANT GM TO ACKNOWLEDGE THAT THERE IS A POWER STEERING ISSUE WITH 2006 CHEVY MALIBU'S AND FIX THE PROBLEM AND ISSUE A RECALL ON THESE CARS. *TR
Steering, Apr 3, 2014
SEVERAL TIMES OVER THE LAST 6-8 MONTHS, I WAS DRIVING MY CHEVROLET MALIBU 2006 LT AND THE CAR DIED AND MY POWER STEERING WENT OUT WITHOUT WARNING. THE SENSOR CAME ON THAT SAYS "POWER STEERING." IT SEEMS LIKE EVERY TIME THAT IT HAPPENED, I WAS MAKING A LEFT HAND TURN. SINCE I WAS TURNING LEFT IN THE MIDDLE OF AN INTERSECTION, I WAS NOT DRIVING FAST AT ALL. I BELIEVE I HAD MY GRANDCHILDREN IN THE CAR ON AT LEAST ONE OF THESE OCCASIONS. I COULD NOT CONTROL THE STEERING AT ALL. MY CAR ENDED UP WITH THE FRONT IN THE MIDDLE OF THE INTERSECTION FACING THE ONCOMING TRAFFIC BECAUSE YOU CANNOT COMPLETE THE TURN WHEN THIS HAPPENS. I THOUGHT IT MUST BE THAT IT NEEDED POWER STEERING FLUID. BUT MY HUSBAND CHECKED IT AND HE SAID IT DOES NOT NEED POWER STEERING FLUID. WHEN I HEARD ABOUT THE GM RECALL YESTERDAY, I IMMEDIATELY CALLED A CHEVY DEALER AND THEY SAID MY CAR VIN IS NOT INCLUDED IN THE RECALL. I THEN CHECKED GM'S WEBSITE AND PUT MY VIN IN AND IT SAID THAT MY CAR IS NOT CURRENTLY INCLUDED IN THE RECALL. THIS SOUNDS VERY WRONG TO ME. I THINK THE NHTSA SHOULD CLOSELY SCRUTINIZE THE LT MODELS OF THE CHEVROLET MALIBU 2006 AS I AM CONCERNED THAT THEY HAVE THE SAME OR SIMILAR DEFECT. THANK YOU FOR LOOKING INTO THIS. I AM AFRAID TO DRIVE THE CAR NOW. I AM NOW USING ONLY A SINGLE KEY WITHOUT THE FOB AS THE NHTSA CONSUMER ALERT ON YOUR WEBSITE STATES TO DO. WHEN IT HAPPENED TO ME BEFORE, I ALWAYS HAD THE FOB AND TWO ADDITIONAL KEYS ON THE KEY CHAIN ALONG WITH THE CAR KEY. THANK YOU VERY MUCH FOR YOUR ASSISTANCE. I APPRECIATE YOUR LOOKING INTO THIS. *TR
Steering, Vehicle speed control, Service brakes, Apr 2, 2014, crash
DRIVING FROM SCHOOL SAW A CAR AHEAD PERSON HAD TURN SIGNAL ON TO GO LEFT. TOOK FOOT OFF GAS WENT TO BRAKE AND TURN WHEEL COULD NOT DO EITHER. THE CAR WAS TOTALED. *TR
Steering, Apr 2, 2014
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 40 MPH ON A RAMP, THE STEERING WHEEL BECAME VERY TIGHT AND THE CONTACT HAD TO USE EXTREME FORCE TO MOVE THE VEHICLE OFF THE ROADWAY. THE CONTACT SHUT OFF AND RESTARTED THE VEHICLE AND IT RESUMED NORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BUT THEY WERE UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.
Service brakes, Apr 1, 2014
BRAKES LIGHTS WORK INTERMITTENTLY. WHILE APPLYING BRAKES, THE LIGHTS WILL TURN OFF. THE LIGHTS WILL FLASH ON AND OFF WHILE DRIVING. THIS HAPPENED INTERMITTENTLY, REGARDLESS OF SPEED. PREVIOUS OWNER WAS REAR ENDED WITH MOTORIST STATING THE BRAKE LIGHTS WERE NOT WORKING. WHILE DRIVING ON THE HIGHWAY IN STOP AND GO TRAFFIC, I WAS NEARLY REAR ENDED. AT THAT POINT I TOOK THE CAR TO MY MECHANIC WHO NOTIFIED ME OF THE SPECIAL BULLETIN THAT WAS POSTED REGARDING THIS ISSUE. I WAS VERY DISAPPOINTED THAT CHEVROLET WOULD NOT OFFER TO FIX THE KNOWN SAFETY ISSUE AT NO CHARGE. THEY CHARGED $150.00 FOR A SIMPLE FIX. *TR
Vehicle speed control, Service brakes, Engine, Apr 1, 2014
I WAS DRIVING MY VEHICLE ON THE FREEWAY IN LUNCH HOUR TRAFFIC. AS I EXITED THE FREEWAY TO CHANGE TO A CONNECTING FREEWAY, THE ENGINE SHUT OFF HALF WAY ALONG THE EXCHANGE RAMP. AT THAT POINT I NOTICED THAT I HAD POOR BREAKAGE AND NO POWER STEERING. LUCKY, I WAS ABLE TO COAST OVER AND STOP IN THE EMERGENCY LANE MID RAMP, PUT THE CAR IN PARK, RESTART THE VEHICLE, AND DRIVE OFF WITHOUT INDECENT. IT WAS UNSETTLING TO SAY THE LEAST. *TR
Steering, Apr 1, 2014
OKAY I PROCEEDED TO MY CAR THIS PARTICULAR MORNING AND WHEN I STARTED THE CAR THE STEERING WHEEL WAS LOCKED. I HAD TO TURN THE CAR OFF, PULL THE COLUMN TOWARD ME WHILE TURNING THE CAR AND THE WHEEL WAS UNLOCKED. ONCE I STARTED TO DRIVE I NOTICED THAT THE WHEEL WAS SHAKING AND MAKING NOISES. THE NOISE BECAME LOUDER WHENEVER I TRIED TO PICK UP SPEED. YOU REALLY NOTICE THE SHAKING AT ABOUT 35 TO 40 MILES PER HOUR. I TRIED TROUBLESHOOTING AND WAS TOLD BY MECHANIC TO CHANGE MY TIRES AND GET AN ALIGNMENT. I DID THAT AND THAT RESOLVED NOTHING. I DON'T DRIVE THE CAR PAST 50 MPH BUT I AM ACTUALLY SCARED WHILE DRIVING. WELL I TOOK THE CAR TO THE DEALER YESTERDAY AND THEY INFORMED ME THAT THE CONTROL MODULE FOR THE STEERING IS FRIED. THE COST WOULD BE 918.00. THIS MORNING I WAKE TO TAKE THE CAR TO ANOTHER SHOP TO HAVE A DINGING NOISE COME ON THE WHEEL LOCK UP WHILE I WAS DRIVING. THE WHEEL IS REAL STIFF AND I MANAGED TO MAKE IT BACK TO MY HOUSE. I LOOKED INTO THE RECALL OF THE CHEVY MALIBUS WITH GM AND WAS INFORMED THAT THE RECALL DOESN'T COVER THE MOTOR. I AM REALLY FRUSTRATED AND UPSET AND I AM LOOKING AT JUST GETTING RID OF THIS HEADACHE FOR REAL. *TR
Electrical system, Mar 31, 2014
MY VEHICLE PERIODICALLY STALLS DURING OPERATION. I HAVE NOTICED THIS OCCURRENCE FOR THE LAST YEAR OR SO. I HAVE NOT EXPERIENCED ANY INJURIES OR ACCIDENTS AS A RESULT OF THIS. HOWEVER, I AM READING THAT THERE MAY BE ISSUES WITH IGNITION SWITCHES OF THIS PARTICULAR MAKE AND MODEL. *TR