2006 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,385 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Malibu model years with reports.
Of the 2006 reports, 53 involved a crash and 7 involved a fire. 31 people were injured.
What owners report most often
Recalls and investigations
Steering, electric power assist systemFeb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Campaign 15V064000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Air bags, frontalOct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Campaign 06V417000 on NHTSA.gov
Equipment, other, labelsOct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Campaign 05V486000 on NHTSA.gov
Representative owner complaints
1,385 reports, newest first.
Exterior lighting, Air bags, Service brakes, Dec 4, 2019
BRAKE LIGHTS ILLUMINATE WITHOUT THE BRAKE PEDAL BEING PUSHED; THE BRAKE LIGHTS DO NOT ILLUMINATE WHEN THE PEDAL IS PUSHED.; DIFFICULTY MOVING THE GEAR SHIFTER OUT OF THE "PARK" POSITIONS WITHOUT PUSHING THE BRAKE. GM SAYS THERE WAS NEVER A RECALL, BUT A SERVICE BULLETIN WAS ISSUED IN REGARDS TO THIS PROBLEM.
Steering, Nov 26, 2019
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE OPERATING THE VEHICLE, THE 'POWER STEERING FAILURE' MESSAGE DISPLAYED AND THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN IN EITHER DIRECTION. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE POWER STEERING SENSOR WAS FAULTY AND NEEDED TO BE REPLACED. THE CONTACT NOTIFIED THE MANUFACTURER OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS PREVIOUSLY SERVICED PER NHTSA CAMPAIGN NUMBER: 15V064000 (STEERING) IN MARCH OF 2015. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 119,500.
Steering, Nov 8, 2019
THE ELECTRONIC STEERING STOPS WORKING INTERMITTENTLY. THIS CAUSES THE CAR TO STEER VERY HARD AND IS DEFINITELY A SAFETY ISSUE. I'VE DONE SOME RESEARCH AND FOUND THAT THERE HAS BEEN RECALLS FOR THIS EXACT ISSUE. WHEN I ENTER MY VIN NUMBER OF COARSE IT ISN'T INCLUDED. THE PAST RECALLS NEED TO BE EXTENDED AS I SEE THERE ARE MANY OTHERS WITH THE SAME ISSUE AND FALL IN THE SAME CATEGORY. IT SHOULD NOT TAKE A FATALITY BEFORE THIS HAPPENS. GM KNOWS THEY HAVE A VERY BAD SAFETY ISSUE HERE AND SHOULD HELD ACCOUNTABLE FOR ALL THE VEHICLES EFFECTED, NOT JUST A PORTION. THIS PROBLEM OCCURS WHEN THE VEHICLE IS JUST STARTED AND WHILE TRAVELING DOWN THE HIGHWAY. THE CAR THEN HAS TO BE STOPPED, SHUT OFF AND RESTARTED FOR THE ISSUE TO CLEAR.
Power train, Electrical system, Engine, Oct 24, 2019
CAR RUNS FINE THEN WITHOUT WARNING IT WILL JUST DIE. DOES THIS WHILE DRIVING IN MOTION. IT IS CAR USED BY TWO NEW TEEN DRIVERS. IT IS VERY UNSAFE BECAUSE THEY DON'T HAVE A LOT OF DRIVING TIME. I LOOKED AT A LOT OF WIRING CONNECTIONS, CLEANED UP ALL GROUND CONNECTIONS WITH WIRE BRUSH, REPLACED TEMP SENSOR, CRANK POSITION SENSOR, BEEN GOING THRU AND FIXING BAD WIRING CONNECTIONS. REPLACED FUEL PUMP. AND FIXED BROKEN WIRES COMING OUT OF BODY THAT GO TO FUEL GAUGE.
Other or unspecified, Oct 7, 2019, fire
WHEN SLOWING DOWN ON HWY EXIT RAMP, CAR MADE THREE QUICK POPPING SOUNDS AND STARTED SMOKING. PULLED OFF ROAD AND MORE SMOKE CALLED 911. THE CAR DASH CAUGHT FIRE AND CAR INTERIOR BURNED BEFORE FIREFIGHTERS COULD PUT IT OUT. FIREFIGHTER SUGGESTED IT COULD BE A TRANSMISSION LINE? NEVER HAD ANY TRANSMISSION TROUBLE PREVIOUSLY.
Steering, Electrical system, Service brakes, Oct 7, 2019
WAS DRIVING ON CITY STREET APPROACHING AN INTERSECTION WHEN THE VEHICLE LOSS POWER, STEERING, AND ABS BRAKES
Steering, Sep 23, 2019
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 30 MPH AND MAKING A LEFT TURN, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT WAS ABLE TO PARK ON THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT CALLED DIMMITT CHEVROLET (LOCATED AT 25485 US HWY 19 N, CLEARWATER, FL 33763, (727) 608-1248) AND WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 160,000.
Engine, Sep 2, 2019
ANTIFREEZE LEAK WATER PUMP AND WATER INLET TUBE .
Steering, Aug 31, 2019
SUDDEN FAILURE OF POWER STEERING WHILE DRIVING. GM DEALERSHIP RAN DIAGNOSTIC TEST. DIAGNOSIS IS STEERING ASSIST MOTOR IS SHORTING INTERNALLY AND SHUTTING DOWN THE ASSIST. OCCASIONALLY, THE COMPUTER WILL SUCCESSFULLY RESET AND POWER STEERING WILL BE RESTORED FOR A SHORT WHILE UNTIL IT HAPPENS AGAIN. TECH CAUSE FROM DIAGNOSTIC TEST: SCAN CHECK, CODES C0550 (ECU PERF INTERNAL ELECTRICAL FAILURE), C0475 (ELECTRIC STEERING MOTOR CIRC.) BOTH CODES ARE HISTORY. CURRENT CODES WOULD BE INTERNAL PS MODULE MALFUNCTION. COMPLETED BY TECHNICIAN NUMBER: 0013. TEST DONE AT M.J. GOSS MOTOR CO., 1415 ADAMS AVE., LA GRANDE, OR 97850, PHONE: 541-663-4131
Steering, Aug 24, 2019
TAKATA RECALL I WAS DRIVING MY CAR AND ALL OF A SUDDEN STEERING WHEEL JUMPED UP AND THEN LOST THE POWER STEERING AND COULD BARELY TURN WHEEL AND I HEARD A DING AND IT TRIED TO DIE AND A BURST OF STEAM COMES ON WINDSHIELD. IT WILL SMELL LIKE IT'S REALLY HOT AND IT GETS A LITTLE HOT BUT NOT BAD
Steering, Aug 11, 2019
VEHICLE EXPERIENCING POWER STEERING DEFECT. RANDOMLY LOCKS UP THE STEERING WHEEL WHENEVER TRYING TO ACCELERATE OR TURNING.
Steering, Aug 5, 2019
2006 CHEVY MALIBU MAXX. POWER STEERING MESSAGE DISPLAYED ON RADIO SCREEN. WHEN THIS HAPPENED STEERING WHEEL WAS VERY HARD TO TURN. HAPPENED UPON STARTING VEHICLE, WHILE DRIVING AT ANY SPEED, AND DURING TURNS. THERE ARE RECALLS FOR THIS ISSUE FOR SAME YEAR, MAKE, AND MODEL, HOWEVER GM SAYS MINE VIN DIDN'T FALL WITHIN THE RECALL.
Steering, Aug 2, 2019
THE CAR JERKS VIOLENTLY WHEN ACCELERATING AND LOOSES POWER STEERING, ALL DASH LIGHTS COME ON THE BELLS DING THEN WHEN YOU LET OFF THE HAS IT STOPPED, VERY DANGEROUS.
Steering, Electrical system, Electronic stability control (ESC), Aug 2, 2019
OK STEERING IN THIS CAR WAS GOOD SEEN THAT IT HAD A RECALL BEFORE FOR THAT. ALSO WHEN I CALLED CHEVY THEY TOLD ME .BUT THAT'S MY MOST CONCERN AS SEEING AS MUCH I HAVE PUT INTO THIS CAR. IT'S WEIRD I LOOKED ON YOUR SITE BEFORE AND HAD RECALLS NOW IT DON'T. I JUST WANT TO SEE HOW TO GET IT FIXED WITH BRAKING MY POCKETS.
Steering, Jul 8, 2019
STEERING WHEEL OCCASIONALLY WILL LOCK UP BRIEFLY WHILE DRIVING.
Steering, Power train, Fuel/propulsion system, Jun 30, 2019
I WAS DRIVING TOWARDS RAYTOWN MISSOURI FOR A BIRTHDAY PARTY AND ASNI WAS DRIVING OVER A RAILROAD TRACK, MY CAR STARTEE MAKING NOISE AND ACTED AS IF IT DIDNT WANT TO GO. SO I LATER FOUND OUT THAT MY TRANSMISAION FLUID HAD LEAKED AND NOW THE TRANSMISSION CASE NEEDS TO BE REPLACED DUE TO THE TRACKS ON THE ROAD.
Steering, Electrical system, Other or unspecified, Jun 22, 2019
STEERING: ELECTRIC POWER ASSIST SYSTEM STEERING ELECTRONIC STABILITY CONTROL VEHICLE SPEED CONTROL: CRUISE CONTROL EXTERIOR LIGHTING: BRAKE LIGHTS ELECTRICAL SYSTEM: WIRING SERVICE BRAKES, HYDRAULIC: SWITCHES: BRAKE LIGHT STEERING: ELECTRIC POWER ASSIST SYSTEM POWER TRAIN: AUTOMATIC TRANSMISSION: LEVER AND LINKAGE: FLOOR SHIFT POWER TRAIN: AUTOMATIC TRANSMISSION
Steering, Jun 14, 2019
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT AS SOON AS THE VEHICLE WAS STARTED, A GRINDING NOISE BEGAN AND THE STEERING WHEEL SHOOK. THE STEERING VIBRATION CONTINUED PERMANENTLY WHILE THE VEHICLE WAS BEING DRIVEN. THE CONTACT STATED THAT THE FAILURE BEGAN EVER SINCE THE VEHICLE WAS PURCHASED IN OCTOBER OF 2018, BUT HAD BECOME WORSE OVER TIME. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Steering, Jun 13, 2019
THERE WAS A RECALL FOR ELECTRIC POWER STEERING MINE WAS TAKEN CARE OFF BEFORE I PURCHASED THE VEHICLE. HOWEVER, IT LOST ELECTRIC POWER STEERING AGAIN AND IS NO LONGER UNDER RECALL WARRANTY.
Steering, Electrical system, Vehicle speed control, May 29, 2019
SPEEDOMETER STOPS WORKING WHILE DRIVING, SECURITY LIGHT COMES ON, ENGINE IGNITION STOPS WORKING AND CAR DOESN'T TURN OVER OR START. THIS HAPPENS WHEN IN MOTION AND NOT IN MOTION.
Electrical system, Exterior lighting, Air bags, May 3, 2019
I WAS DRIVING IN DETROIT MI I WAS AT THE LIGHT WHEN MY MY CAR LIGHTS START BLINKING OFF AND ON AND MY AIR BAG POPPED OUT
Steering, Apr 30, 2019
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 20 MPH, THE STEERING WHEEL SEIZED THREE TIMES AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE CONTACT MENTIONED THAT THE VEHICLE WAS REPAIRED PER AN UNKNOWN NHTSA CAMPAIGN NUMBER REGARDING THE STEERING WHEEL. DYER CHEVROLET VERO BEACH (1000 US-1, VERO BEACH, FL 32960, (772) 617-4793) WAS CONTACTED AND INFORMED THE CONTACT TO BRING THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS ALREADY REPAIRED PER A RECALL FOR THE SAME FAILURE. THE MANUFACTURER ADVISED THE CONTACT TO TAKE THE VEHICLE TO A DEALER. THE FAILURE MILEAGE WAS 101,420. *DT
Steering, Apr 20, 2019
THERE WAS DIFFICULTY WITH THE POWER STEERING UNDER ALL DRIVING CONDITIONS. THE POWER STEERING INDICATOR LIGHT APPEARED WITHIN THE DRIVER INFORMATION CENTER. THE CURRENT MILEAGE AT THE TIME OF SERVICE WAS 144,961 MILES. ON PAGE 1 OF THE ATTACHED DOCUMENT, DEALER DIAGNOSTICS IDENTIFIED THE STEERING TORQUE SENSOR HAS AN INTERNAL FAILURE. ON PAGE 2, THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER RECALL AT 115,069 MILES, AND WOULD NOT BE REPLACED UNDER RECALL AT THIS TIME. THE PREVIOUS RECALL REPLACEMENT PART IS OBVIOUSLY DEFECTIVE WHEN, WITH LESS THAN 30,000 MILES SINCE RECALL REPLACEMENT, THE PART FAILED AGAIN. THE OWNER SHOULD BE REIMBURSED BY CHEVROLET FOR SUBSTANDARD RECALL REPLACEMENT WITH INADEQUATE PARTS. RECALL = N140116.
Steering, Apr 4, 2019
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING LOW SPEEDS, THE STEERING FAILED AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 15V064000 (STEERING), BUT THE FAILURE RECURRED. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC WHO STATED THAT THE POWER STEERING ASSIST NEEDED TO BE REPAIRED. A REPAIR APPOINTMENT WAS SCHEDULED WITH THE MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 137,000.
Steering, Mar 26, 2019
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING VARIOUS SPEEDS OR ACCELERATING FROM A STOP, THE STEERING LOST POWER AND THE POWER STEERING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO LYNN LAYTON CHEVROLET (256-274-6493, LOCATED AT 2416 US-31, DECATUR, AL 35601) WHERE IT WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 15V064000 (STEERING). THE CONTACT WAS INFORMED THAT THE RECALL REPAIR WAS PREVIOUSLY PERFORMED AND WOULD NOT BE COVERED AGAIN BY THE RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000.