2007 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 992 owner complaints filed for this model year. This is the 7th highest complaint count among 26 Malibu model years with reports.
Of the 2007 reports, 37 involved a crash and 2 involved a fire. 34 people were injured.
What owners report most often
Recalls and investigations
Steering, electric power assist systemFeb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Campaign 15V064000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Representative owner complaints: electrical system
114 reports, newest first. Show all
Steering, Power train, Electrical system, Jul 23, 2014
THE POWER STEERING ASSIST SUDDENLY QUIT SEVERAL TIMES WHILE DRIVING; BOTH AT FREEWAY SPEED AND WHILE EXITING THE FREEWAY AT ABOUT 15 MPH. WHEN THE POWER STEERING FAILS THE STEERING COLUMN WOULD MAKE A CLICKING SOUND, SOMETIMES THERE WOULD BE A CHIME AND THE BATTERY LIGHT INDICATOR ON THE DASH. ONLY ONE TIME THE CENTER CONSOLE DISPLAYED "POWER STEERING." WE NARROWLY AVOIDED A CRASH WHILE GOING AROUND A CURVE IN THE FREEWAY. THE LOSS OF POWER ASSIST REQUIRED EXERTING MORE FORCE THAN NORMAL TO AVOID COLLIDING WITH THE DIVIDER. WHEN THE POWER STEERING RE-ENGAGED WITHOUT WARNING WE SWERVED TOWARDS A TRUCK IN THE ADJACENT LANE. WE TOOK IT TO THE NEAREST DEALER WHO SAID IT'S A FAULTY IGNITION COIL CAUSING A SHORT IN THE POWER STEERING. COST QUOTED WAS $500 TO FIX IN ADDITION TO $450 FOR THE SHIFTER CABLE THAT ALSO WENT OUT. *TR
Steering, Electrical system, Jul 17, 2014
TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS AN INTERMITTENT LOSS OF POWER STEERING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 174,000.. UPDATED 09/02/14*LJ THE CONSUMER STATED THE STEERING TIGHTENS UP AND WANTS TO TURN ON THE ACCELERATION AND LOSS OF POWER OCCURS. AT THIS TIME, A CLICKING SOUND COULD BE HEARD FROM THE STEERING COLUMN. THE BATTERY LIGHT FLASHED FROM THE STEERING COLUMN. THE BATTERY LIGHT FLASHED ON AND OFF AT TIMES WITH A DINGING SOUND. UPDATED 11/4/2014 *JS
Electrical system, Vehicle speed control, Service brakes, Jul 14, 2014
THE BRAKE LIGHTS COME ON WHILE DRIVING WITHOUT PRESSING BRAKE PEDAL. WHEN BRAKE PEDAL IS PRESSED, BRAKE LIGHTS GO OFF. FIRST NOTICED THIS BECAUSE CRUISE CONTROL WOULD NOT SET. TOOK IT IN FOR REPAIRS AT LOCAL DEALERSHIP. THEY FOUND THE STOPLAMP SWITCH TO BE FAULTY AND REPLACED. THREE DAYS LATER, BRAKE LIGHTS ARE ON AGAIN WITHOUT PRESSING BRAKE PEDAL. TOOK IT IN AGAIN. THIS TIME THEY FOUND A BULLETIN ON PROBLEM AND APPLIED DIELECTRIC GREASE TO THE BCM CONNECTORS. WITHIN A MONTH, THE PROBLEM OCCURRED AGAIN INTERMITTENTLY, BUT DID NOT TAKE IN. SINCE MAY 2014, BRAKE LIGHTS ARE ALMOST ALWAYS ON WHILE DRIVING EVEN THOUGH BRAKE PEDAL NOT PRESSED. LOOKED UP SIMILAR PROBLEMS ON SAFERCAR.GOV AND FOUND RECALL NOTICE ON VEHICLE. CALLED GM, GAVE THEM MY VIN AND GM RECALL NUMBER (13036) AND THEY SAID THAT MY VEHICLE WAS NOT INCLUDED IN THE RECALL BECAUSE THEY COULD NOT FIND ANY DOCUMENTED PROBLEMS IN MY SERVICE HISTORY AND I SHOULD GO TO LOCAL DEALERSHIP TO HAVE ELECTRICAL DIAGNOSTIC TEST DONE. WENT BACK TO DEALERSHIP AND SHOWED THEM PRINTED COPY OF RECALL FROM SAFERCAR.GOV AND RELAYED CONVERSATION WITH GM. DEALERSHIP STATED, AFTER AN AFTERNOON WITH CAR, THAT RECALL NUMBER DID NOT EXIST AND THEY COULD NOT FIND ANY ACTIVE RECALLS FOR MY CAR. I ASKED ABOUT THE SERVICE RECORD AND HOW COME THE 2012 SERVICES WERE NOT INCLUDED, THEY SAID THAT IT WAS ONLY ELECTRICAL AND NOT REALLY SIGNIFICANT SO THEY DID NOT TO DOCUMENT IT. THEY ALSO STATED THAT BECAUSE SAFERCAR.GOV IS NOT GM, THEY COULD NOT BELIEVE ITS RELIABILITY. AFTER A LONG CONVERSATION, I ASKED IF THERE WAS A RECALL ON THE MALIBUS IN GENERAL, THEY SAID THEY DID NOT KNOW UNLESS THEY HAD SPECIFIC VIN. DEALERSHIP APPLIED DIELECTRIC GREASE TO BCM CONNECTORS. FRUSTRATED AT NOT GETTING ANSWER, DID OWN RESEARCH AND FOUND RECALL NUMBERS (103652, 103653, 103654) AND A SERVICE BULLETIN (SB-08-05-22-009A) ON THE PROBLEM WITHIN 30 MINUTES. *TR
Steering, Electrical system, Jun 21, 2014
WHILE TURNING ONTO A FREEWAY ON-RAMP THE POWER STEERING FAILED ENTIRELY FOR SEVERAL SECONDS AND A CLICKING SOUND SIMILAR TO WHEN THE TURN SIGNAL COMES ON CAME FROM THE STEERING COLUMN. AFTER TRAVELING ABOUT 100 METERS, THE POWER STEERING CAME BACK ON CAUSING US TO OVER-CORRECT AND NARROWLY MISS THE BARRIERS. *TR
Fuel system, Gasoline, Electrical system, Jun 5, 2014
FUEL GAUGE AN FUEL TANK READER HAS NOT WORKED SINCE WE BOUGHT IN 2007. *TR
Electrical system, Jun 4, 2014
TL- THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT STATED THAT SHE WOULD LIKE TO BE REIMBURSED FOR WORK THAT WAS ALREADY DONE ON HER VEHICLE. REFERRED CONTACT TO CHEVROLET MANUFACTURER. LNC
Fuel system, Gasoline, Electrical system, Engine, Jun 2, 2014
SINCE PURCHASING MY CAR IN AUGUST 2013, I HAVE HAD TO MAKE THREE FAIRLY COSTLY REPAIRS. EACH TIME THE MECHANIC TOLD ME THIS WAS A "KNOWN PROBLEM" FOR CHEVROLETS. THE FIRST WAS THE INTAKE VALVE. I HADN'T EXPERIENCED PROBLEMS BUT TOOK THE CAR IN FOR WHAT I THOUGHT WAS A SQUEALING BELT. THE SQUEALING TURNED OUT TO BE THE WATER PUMP. SINCE THAT WAS SECONDARY IN IMPORTANCE TO THE INTAKE VALVE, I HAD THAT REPLACED FIRST. FOLLOWED BY THE WATER PUMP A COUPLE OF MONTHS LATER. THEN ABOUT A MONTH AGO, I WAS OUT OF TOWN AND MY CAR SUDDENLY WOULD NOT SHIFT INTO PARK OR REVERSE. IT WAS A WORN AND STRETCHED SHIFTER CABLE. HOWEVER GM SAYS MY CAR IS NOT PART OF THE RECALL. *TR
Electrical system, Exterior lighting, Vehicle speed control, Service brakes, May 28, 2014
MY BRAKE LIGHTS GO ON AFTER ABOUT 7 SECONDS WHEN I AM DRIVING AND NOT TOUCHING THE BRAKES. THE BRAKE LIGHTS GO OFF WHEN I APPLY THE BRAKES AND THEN GO BACK ON WHEN I AM STOPPED. THIS IS VERY DANGEROUS AND WHEN I ENTERED MY VIN IT DOES NOT SHOW UP ON THE RECALL LIST. I ALSO HAVE THE ISSUES WITH POWER STEERING GOING OUT AND HAVE ALSO HAD TO REPLACE THE SHIFT CABLE LAST FALL WHEN I COULD NOT PUT THE CAR IN PARK- IT WAS RIPPED IN HALF. CRUISE CONTROL STOPPED WORKING YEARS AGO. POWER MIRRORS DO NOT WORK. CHECK AIR BAG REMINDER GOES ON RANDOMLY. THIS CAR IS A PIECE OF GARBAGE AND VERY UNSAFE. *TR
Steering, Electrical system, May 19, 2014
TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 55 MPH, THE POWER STEERING FAILED AND THE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND DEACTIVATED THE ENGINE. ONCE RESTARTED, THE VEHICLE OPERATED NORMALLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT A PART ASSOCIATED WITH THE POWER STEERING NEEDED TO BE REPLACED. THE IGNITION SWITCH WAS ALSO DEFECTIVE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000. UPDATED 09/02/14*LJ THE CONSUMER STATED WHILE ATTEMPTING TO AVOID A POTHOLE THE STEERING BECAME DIFFICULT TO MANEUVER. THE TIRE HIT THE POTHOLE AND BROKE THE HUB CAP. THE CONSUMER PULLED A MUSCLE IN THE RIGHT ARM. THE CONSUMER DID SEEK CARE WITH A PHYSICIAN. THE VEHICLE'S IGNITION BEGAN TO FAIL MAKING IT DIFFICULT TO START UP. THE VEHICLE MAY OR MAY NOT HAVE BEEN INCLUDED IN A RECALL. UPDATED 09/16/2014 *JS
Electrical system, Fuel/propulsion system, May 15, 2014
THE FUEL SENDING DEVISE KEEPS GOING BAD AND SHOWS AN EMPTY TANK THEN COMES BACK ON. *TR
Electrical system, May 12, 2014
2007 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL. *SMD THE CONSUMER STATED WHEN HE TURNED OFF THE IGNITION, THE VEHICLE CONTINUED TO IDLE. THE IGNITION SWITCH AND RELAY WERE REPLACED. *JB THE CONSUMER STATED THE IGNITION SWITCH, WAS REPLACED BEFORE THE RECALL WAS ANNOUNCED. HE BELIEVED THE REPLACEMENT SWITCH WAS DEFECTIVE. UPDATED 10/28/14
Electrical system, May 5, 2014
TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TOWED TO THE DEALER WHO REPLACED THE IGNITION SWITCH. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.
Steering, Electrical system, Fuel/propulsion system, Apr 28, 2014
THE POWER STEERING HAD GONE OUT REPEATEDLY AT DIFFERENT TIMES, BOTH WHILE DRIVING AND NOT. IT WOULD COME BACK ON AT TIMES AND NOW FOR THE LAST 5 MONTHS HAS BEEN OUT COMPLETELY AND IS A DANGER TO DRIVE. IT IS MY ONLY VEHICLE AND I DRIVE 3 CHILDREN AROUND REGULARLY. IT IS NEARLY IMPOSSIBLE FOR SOMEONE OF MY STRENGTH AND SIZE TO DRIVE. I FEAR IT IS A MATTER OF TIME BEFORE WE HAVE AN ACCIDENT. I WAS ABSOLUTELY AMAZED TO SEE THERE WAS NOT A RECALL ON MY MAKE AND YEAR BUT EVERY OTHER YEAR MALIBU. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR UPDATED 10/21/2014 *JS
Electrical system, Air bags, Apr 25, 2014
TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT STATED THAT THE HORN FAILED TO FUNCTION AND THE AIR BAG LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE BODY CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE AND VIN WAS NOT AVAILABLE.
Steering, Electrical system, Apr 4, 2014
TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT STATED THAT THE KEY FAILED TO RELEASE FROM THE IGNITION. THE CONTACT ALSO MENTIONED THAT THE STEERING WHEEL SEIZED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. THE DEALER REPLACED THE STEERING COLUMN MOTOR AND SENSOR SEVERAL TIMES, HOWEVER, THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 28,000 AND THE CURRENT MILEAGE WAS 190,000.
Steering, Electrical system, Apr 1, 2014
TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT STATED THAT THE POWER STEERING ASSIST FAILED WITH THE ILLUMINATION OF THE POWER STEERING WARNING LIGHT. THE CONTACT STATED THAT THE STEERING WHEEL BECAME HARD TO TURN. THE ELECTRONIC POWER STEERING ASSIST WAS PREVIOUSLY REPLACED HOWEVER THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 89,000 AND THE CURRENT MILEAGE WAS 149,000. UPDATED 05/19/14*LJ THE STEERING WHEEL POSITIONING SENSOR NEEDED TO BE REPLACED.
Fuel system, Gasoline, Electrical system, Service brakes, Mar 31, 2014
I NOTICE MY WIRES SMOKE SOME TIMES WHEN I DRIVE, AND WHEN I PUT MY FOOT ON THE BRAKES I HAVE TO DO IT MORE THAN TWO TIMES AND I HAD THAT FIXED IN FEBRUARY 2013. MY FUEL PUMP WENT OUT AND I REPLACED IT( ONFEBRUARY 15, 2014). JUST ABOUT A WEEK AFTER GETTING MY CAR FIXED IT SEEMS TO HESITATE WHEN I PUT MY FOOT ON THE ACCELERATOR. I TOOK IT TO GET IT LOOKED AT AND NO ONE COULD FIND ANYTHING WRONG AND IT IS YET DOING THIS. *TR
Steering, Electrical system, Mar 21, 2014
MY STEERING WHEEL PULSATE WHENEVER IT FEELS LIKE IT. MY STEERING WHEEL LOCKS UP WHILE I AM DRIVING. I HAVE TO TURN MY CAR OFF AND THEN TURN IT BACK ON IN ORDER TO HAVE POWER STEERING. I HAVE SPENT MONEY FOR ROTORS RESURFACED, ALIGNMENT, AND TIE RODS. I AM WORRIED ABOUT THIS SITUATION CAUSING AN ACCIDENT. I HAVE TAKEN IT TO DEALER WHERE I WAS INFORMED THERE WAS NOTHING WRONG. THERE ARE A TON OF COMPLAINTS. *TR
Steering, Electrical system, Jan 2, 2014
RANDOMLY LOSING POWER STEERING. HAPPENED ONCE BRIEFLY IN AUGUST 2013. TOOK IT FOR A DIAGNOSTIC TEST IMMEDIATELY AFTER THIS INCIDENT AND WAS TOLD NOTHING WAS WRONG. STARTED HAPPENING ON 12/7/13 AND HASN'T STOPPED. I HAD THE CAR LOOKED AT BY A MECHANIC ON 12/10/13 WHO DISASSEMBLED THE STEERING COLUMN/DASHBOARD, ETC. AND WAS TOLD THAT NOTHING IS WRONG. ON 12/16/13, IT WAS TAKEN TO ANOTHER MECHANIC, WHO TEST DROVE IT AND RAN ANOTHER DIAGNOSTIC TEST AND ONCE AGAIN TOLD ME NOTHING IS WRONG AND TO PICK UP MY CAR. SINCE THEN, I HAVE BEEN RANDOMLY LOSING THE POWER ALMOST DAILY TO MULTIPLE TIMES DAILY. I COMMUTE APPROX. 30 MILES TO AND FROM WORK AND HAVE HAD TO DRIVE WITH NO POWER STEERING AT HIGH RATES OF SPEED. TO MAKE IT WORSE, THE WEATHER HAS BEEN VERY BAD THE PAST WEEK SO I HAVE BEEN A NERVOUS WRECK NOT KNOWING WHEN THE POWER STEERING IS GOING TO GO OUT. WITHIN THE PAST YEAR, BOTH MY AIRBAG AND DOOR AJAR WARNINGS HAVE COME ON RANDOMLY WHEN I HAVE NO DOOR AJAR. I WASN'T AS CONCERNED SINCE THEY ARE NOT AN IMMEDIATE DANGER. WHEN I LOSE POWER STEERING THE CAR DOES "DING" AND "POWER STEERING" FLASHES ON MY AUDIO SYSTEM. IF I AM ABLE TO(NOT ON THE FREEWAY)THEN I PULL OVER, TURN THE CAR OFF AND THEN BACK ON. SOMETIMES THIS CORRECTS THE PROBLEM AND SOMETIMES IT DOES NOT. SOMETIMES IT WILL GO AWHILE WITHOUT THIS HAPPENING AND SOMETIMES IT HAPPENS MULTIPLE TIMES IN A ROW. I AM PLANNING ON TAKING IT TO A LOCAL DEALERSHIP THIS WEEKEND AND HOPING I DON'T GET INTO AN ACCIDENT IN THE MEANTIME. WHEN I JUST SPOKE TO THE DEALERSHIP THE GENTLEMAN ON THE PHONE SAID THAT THIS IS A COMMON PROBLEM AND HE KNOWS THERE ARE SOME RECALLS. FROM WHAT I CAN SEE THERE ARE RECALLS ON EVERY YEAR SURROUNDING MINE. THIS IS EXTREMELY DANGEROUS AND SOMETHING NEEDS TO BE DONE. I HOPE THE DEALERSHIP IS ABLE TO CORRECT THE PROBLEM AND I DON'T END UP SPENDING HUNDREDS OF DOLLARS AND THIS IS STILL GOING TO HAPPEN. *TR
Electrical system, Exterior lighting, Vehicle speed control, Nov 22, 2013
IN 2012, I WAS HAVING ISSUES WITH THE CRUISE CONTROL DISENGAGING AND REFUSING TO RE-ENGAGE. I NOTICED THAT THE BRAKE LIGHTS WOULD BE LIT WITHOUT THE BRAKES BEING ACTIVATED, AS LONG AS THE VEHICLE WAS NOT IN "PARK" (AUTOMATIC TRANSMISSION). THE CHEVROLET DEALER APPLIED DIELECTRIC GREASE TO A CONNECTOR IN NOVEMBER 2012, AND THE PROBLEM WENT AWAY. THE PROBLEM REAPPEARED THIS YEAR (2013), INCLUDING AN INSTANCE WHEN THE BRAKE LIGHTS DID NOT LIGHT WHEN THE BRAKES WERE ACTIVATED! THE DEALER CHARGED ME OVER $250 IN PARTS AND OVER $300 IN LABOR TO REPLACE TWO PARTS. ON MY WAY TO THE DEALER, I SAW ANOTHER MALIBU WITH THE SAME BODY DESIGN WITH THE SAME PROBLEM. THIS IS OBVIOUSLY A DESIGN, PART, OR MANUFACTURING DEFECT, AND I SHOULD NOT HAVE TO PAY TO FIX A FAULTY DESIGN, REPLACE A FAULTY PART, OR DUE TO POOR MANUFACTURING. *TR
Electrical system, Vehicle speed control, Service brakes, Nov 21, 2013
THE BRAKE LIGHTS COME ON AND DO NOT SHUT OFF (THIS IS AN INTERMITTENT PROBLEM BUT HAS GRADUALLY WORSENED TO THE POINT WHERE IT IS HAPPENING ALMOST ALL OF THE TIME NOW). ALSO, THE CRUISE CONTROL DOES NOT WORK AND AT TIMES IT IS DIFFICULT SHIFTING OUT OF PARK. WE HAVE BROUGHT THE CAR TO TWO DIFFERENT CHEVY DEALERSHIPS TWICE EACH, AND TO A PRIVATE MECHANIC TWICE (FOR A TOTAL OF 6 SERVICE TRIPS). DESPITE SPENDING SEVERAL HUNDRED DOLLARS, NONE OF THEM HAVE FIXED THE PROBLEM. SOMEONE ALMOST HIT ME FROM BEHIND A COUPLE WEEKS AGO BECAUSE MY BRAKE LIGHTS DID NOT CHANGE - HE FOLLOWED ME TO A GAS STATION AND YELLED AT ME! IT IS SO BAD NOW THAT WE DON'T DARE DRIVE THE CAR FOR SAFETY REASONS, AND CANNOT SELL IT FOR THE SAME REASON. MY GIRLFRIEND BOUGHT THIS CAR WHEN IT WAS BRAND NEW AND IT IS NOT ONLY UNSAFE AND DANGEROUS, BUT UNBELEIVEABLY FRUSTRATING THAT THEY JUST KEEP CHARGING US MORE MONEY BUT DON'T FIX THE PROBLEM. *TR
Steering, Electrical system, Nov 21, 2013
I WAS DRIVING MY 2007 MALIBU AND TURNING A CORNER WHEN THE POWER STEERING WENT OUT. LUCKILY I WAS IN AN AREA WITH NO OTHER VEHICLES AT THE TIME. I WAS ABLE TO GET THE VEHICLE HOME, WHEN I STARTED IT AGAIN THE POWER STEERING WAS WORKING. THIS SEEMS TO BE A COMMON PROBLEM WITH THIS MAKE AND MODEL FROM WHAT I HAVE READ. THE POWER STEERING GOES OUT WHILE DRIVING AND COMES BACK ON AFTER RESTARTING THE CAR. THE ISSUE RECURS WITHOUT WARNING. IT IS VERY DANGEROUS AND COULD CAUSE A SERIOUS ACCIDENT. THERE SHOULD BE A RECALL ON THE 2007 FOR THIS KNOWN ISSUE. *TR
Electrical system, Traction control system, Engine, Oct 30, 2013
2007 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO DRIVER DOOR LOCK MALFUNCTION CAUSED BY POOR WIRE CONNECTION AND CONSUMER SEEKS REIMBURSEMENT FOR REPAIRS. *SMD THE CONSUMER STATED WHILE DRIVING, THE TIRE TRACTION LIGHT ILLUMINATED AND HE WAS UNABLE TO TURN IT OFF, AND THEN THE CHECK ENGINE LIGHT ILLUMINATED. HE WAS ALSO UNABLE TO USE THE SPEED CONTROL SETTING, DURING THAT TIME. WHEN HE ARRIVED HOME, HE WAS UNABLE TO GET OUT OF THE VEHICLE, BECAUSE THE DRIVER DOOR AUTO LOCK WOULDN'T OPERATE PROPERLY. TWO DAYS LATER, WHEN HE PUT THE VEHICLE INTO DRIVE, THE DRIVER SIDE DOOR DIDN'T LOCK AUTOMATICALLY, BUT ALL THE OTHER LOCKS WORKED PROPERLY. THE DEALER INFORMED THE CONSUMER THE HARNESS CAME LOOSE AND IT CAUSED THE WIRING UNDER THE DRIVER'S SEAT TO CHAFF AND EXPOSE THE WIRING WHICH THEN TOUCHED EACH OTHER AND CAUSED THE MALFUNCTION. HE FURTHER ADVISED THAT, AS PART OF THE REPAIR, THE HARNESS AND WIRING WERE MOVED OVER FROM ITS ORIGINAL LOCATION SO THAT THE PROBLEM WOULD NEVER OCCUR AGAIN.
Steering, Electrical system, Sep 18, 2013
I WAS GETTING READY TO LEAVE MY HOUSE IN MY 2007 CHEVY MALIBU AND WHEN I WENT TO TURN MY WHEEL TO GET OUT OF MY DRIVEWAY I COULD NOT TURN IT. I PULLED BACK IN THE DRIVEWAY AND TRIED AGAIN, SAME THING. WE HAD A FRIEND COME OVER WITH A DIAGNOSTIC AND IT WAS THE ELECTRICAL POWER STEERING. FROM READING ALL OF THE OTHER NUMEROUS COMMENTS, I AM SURPRISED THERE IS NOT A RECALL ON THIS ISSUE. HOPING GM DOES SOMETHING ABOUT THIS.
Electrical system, Air bags, Seat belts, Jul 31, 2013
THE BUCKLE FOR THE PASSENGER SIDE SEAT BELT STOP WORKING ON MY 2007 CHEVY MALIBU, AIRBAG LIGHT ON FOR NO REASON , I LOCK THE CAR COME BACK ALL DOORS ARE UNLOCKED. *TR