2007 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 992 owner complaints filed for this model year. This is the 7th highest complaint count among 26 Malibu model years with reports.
Of the 2007 reports, 37 involved a crash and 2 involved a fire. 34 people were injured.
What owners report most often
Recalls and investigations
Steering, electric power assist systemFeb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
Campaign 15V064000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Power train, automatic transmissionApr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Campaign 14V224000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpFeb 28, 2011
TI AUTOMOTIVE IS RECALLING CERTAIN FUEL PUMPS, PART NUMBERS TU456 AND TU303, SOLD UNDER VARIOUS BRAND NAMES AS AFTERMARKET AND REPLACEMENT EQUIPMENT FOR THE MOTOR VEHICLES LISTED ABOVE. THE DEFECTIVE FUEL PUMP MAY SEIZE, STOPPING THE FUEL FLOW TO THE ENGINE CREATING A STALLING CONDITION.
A VEHICLE CRASH COULD OCCUR SHOULD THE ENGINE STALL WHILE IN USE.
TI AUTOMOTIVE WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE ANY DEFECTIVE FUEL PUMP WITH A NEW OR REWORKED FUEL PUMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 22, 2011. OWNERS MAY CONTACT TI AUTOMOTIVE AT 1-866-867-3759 OR LOG ON TO WWW.RECALLRESPONSE.COM.
Campaign 11E009000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Representative owner complaints: service brakes
51 reports, newest first. Show all
Service brakes, Aug 7, 2014
TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN ID NUMBER:14V252000 ( ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Suspension, Service brakes, Hydraulic, Traction control system, Aug 7, 2014
TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT STATED THAT THE TRACTION CONTROL AND ABS SENSORS ILLUMINATED INTERMITTENTLY. THE VEHICLE SWAYED AND THE SUSPENSION WAS UNSTABLE. AN INDEPENDENT MECHANIC WAS UNABLE TO DUPLICATE THE FAILURES. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL); HOWEVER, THE PARTS NEEDED FOR THE REPAIR WERE UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED AND DID NOT KNOW WHEN THE PARTS WOULD ARRIVE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Electrical system, Vehicle speed control, Service brakes, Jul 14, 2014
THE BRAKE LIGHTS COME ON WHILE DRIVING WITHOUT PRESSING BRAKE PEDAL. WHEN BRAKE PEDAL IS PRESSED, BRAKE LIGHTS GO OFF. FIRST NOTICED THIS BECAUSE CRUISE CONTROL WOULD NOT SET. TOOK IT IN FOR REPAIRS AT LOCAL DEALERSHIP. THEY FOUND THE STOPLAMP SWITCH TO BE FAULTY AND REPLACED. THREE DAYS LATER, BRAKE LIGHTS ARE ON AGAIN WITHOUT PRESSING BRAKE PEDAL. TOOK IT IN AGAIN. THIS TIME THEY FOUND A BULLETIN ON PROBLEM AND APPLIED DIELECTRIC GREASE TO THE BCM CONNECTORS. WITHIN A MONTH, THE PROBLEM OCCURRED AGAIN INTERMITTENTLY, BUT DID NOT TAKE IN. SINCE MAY 2014, BRAKE LIGHTS ARE ALMOST ALWAYS ON WHILE DRIVING EVEN THOUGH BRAKE PEDAL NOT PRESSED. LOOKED UP SIMILAR PROBLEMS ON SAFERCAR.GOV AND FOUND RECALL NOTICE ON VEHICLE. CALLED GM, GAVE THEM MY VIN AND GM RECALL NUMBER (13036) AND THEY SAID THAT MY VEHICLE WAS NOT INCLUDED IN THE RECALL BECAUSE THEY COULD NOT FIND ANY DOCUMENTED PROBLEMS IN MY SERVICE HISTORY AND I SHOULD GO TO LOCAL DEALERSHIP TO HAVE ELECTRICAL DIAGNOSTIC TEST DONE. WENT BACK TO DEALERSHIP AND SHOWED THEM PRINTED COPY OF RECALL FROM SAFERCAR.GOV AND RELAYED CONVERSATION WITH GM. DEALERSHIP STATED, AFTER AN AFTERNOON WITH CAR, THAT RECALL NUMBER DID NOT EXIST AND THEY COULD NOT FIND ANY ACTIVE RECALLS FOR MY CAR. I ASKED ABOUT THE SERVICE RECORD AND HOW COME THE 2012 SERVICES WERE NOT INCLUDED, THEY SAID THAT IT WAS ONLY ELECTRICAL AND NOT REALLY SIGNIFICANT SO THEY DID NOT TO DOCUMENT IT. THEY ALSO STATED THAT BECAUSE SAFERCAR.GOV IS NOT GM, THEY COULD NOT BELIEVE ITS RELIABILITY. AFTER A LONG CONVERSATION, I ASKED IF THERE WAS A RECALL ON THE MALIBUS IN GENERAL, THEY SAID THEY DID NOT KNOW UNLESS THEY HAD SPECIFIC VIN. DEALERSHIP APPLIED DIELECTRIC GREASE TO BCM CONNECTORS. FRUSTRATED AT NOT GETTING ANSWER, DID OWN RESEARCH AND FOUND RECALL NUMBERS (103652, 103653, 103654) AND A SERVICE BULLETIN (SB-08-05-22-009A) ON THE PROBLEM WITHIN 30 MINUTES. *TR
Service brakes, Jul 14, 2014
THE BRAKES SHUDDER AND SHAKE THE CAR UNTIL YOU THINK IT IS GOING TO COME APART AS YOU APPLY THEM AT ANY SPEED. THIS CAR USED TO BELONG TO MY BROTHER AND A SALESMAN DROVE IT AND WAS SCARED TO DEATH THE WHOLE TIME. IT HAS ABOUT 90,000 ON IT NOW AND HE GAVE IT TO ME TO TRY TO FIND OUT WHAT TO DO ABOUT IT. HE IS A MULTI-MILLIONAIRE AND DOESN'T HAVE TIME TO MONKEY WITH THIS STUFF. HE JUST BUYS MORE CARS IF HE NEEDS THEM. HE HAS SPENT MONEY TO TRY TO FIX THE ISSUE WITH REPAIR SHOPS, ROTORS, BRAKE PADS, YOU NAME IT. HE EVEN HAS A SPEED SHOP THAT HE HOLDS WORLD RECORDS PRODUCING FAST THINGS AND HAS A GREAT STAFF THAN CAN FIX ANYTHING ON EARTH. BUT THAT IS NOT HIS REAL BUSINESS. HE WOULDN'T SPEND ANYMORE TIME OR HAVE ANYONE ELSE TRY TO FIX IT ANYMORE UNTIL THE FACTORY OWNS UP TO WHAT IS GOING ON WITH IT. I WAS GOING TO LET MY DAUGHTER DRIVE IT BUT WITH A NEW BABY I CAN'T ALLOW THAT. IT IS EXTREMELY SCARY TO DRIVE AND I HAVE SINCE FOUND OUT THAT THIS WAS A WELL KNOWN PROBLEM. HE REALLY DIDN'T KNOW IT WAS THIS BAD. *TR
Service brakes, Jun 5, 2014
THE MAY 14 2014 RECALL ABOUT THE BCM ON CHEVY MALIBUS DOES NOT SUPPOSEDLY INCLUDE MY MODEL ACCORDING GM BUT I STARTED HAVING THAT PROBLEM THAT PROBLEM WITH THE BRAKE LIGHTS COMING ON WITHOUT HITTING THE BRAKES ATLEAST 2 YEARS AGO. *TR
Electrical system, Exterior lighting, Vehicle speed control, Service brakes, May 28, 2014
MY BRAKE LIGHTS GO ON AFTER ABOUT 7 SECONDS WHEN I AM DRIVING AND NOT TOUCHING THE BRAKES. THE BRAKE LIGHTS GO OFF WHEN I APPLY THE BRAKES AND THEN GO BACK ON WHEN I AM STOPPED. THIS IS VERY DANGEROUS AND WHEN I ENTERED MY VIN IT DOES NOT SHOW UP ON THE RECALL LIST. I ALSO HAVE THE ISSUES WITH POWER STEERING GOING OUT AND HAVE ALSO HAD TO REPLACE THE SHIFT CABLE LAST FALL WHEN I COULD NOT PUT THE CAR IN PARK- IT WAS RIPPED IN HALF. CRUISE CONTROL STOPPED WORKING YEARS AGO. POWER MIRRORS DO NOT WORK. CHECK AIR BAG REMINDER GOES ON RANDOMLY. THIS CAR IS A PIECE OF GARBAGE AND VERY UNSAFE. *TR
Steering, Service brakes, Hydraulic, Power train, May 27, 2014
WHEN TURNING LEFT OR RIGHT OR MERGING INTO TRAFFIC, THE STEERING WHEEL CLICKS AND GETS VERY HARD TO STEER LIKE IT'S PULLING TO THE SIDE, CAUSING ME TO OVERCORRECT BY STEERING IN THE OPPOSITE DIRECTION- IT FEELS LIKE I AM GOING TO LOSE CONTROL OF THE CAR AND IS VERY FRIGHTENING BUT THEN IT STOPS. IT HAS HAPPENED SEVERAL TIMES OVER THE YEARS BUT IS BECOMING MORE FREQUENT. I HAVE ENTERED MY VIN ON THE GM SITE BUT IT SAYS I AM NOT A PART OF THE RECALL. HOW IS THAT POSSIBLE WHEN I AM HAVING THE EXACT SAME PROBLEM? I AM ALSO HAVING THE PROBLEM WITH MY BRAKE LIGHTS- THEY GO ON WHEN I AM NOT BRAKING AND OFF WHEN I DO. I HAD TO REPLACE THE GEAR SHIFT LAST FALL BECAUSE IT BROKE AND MY CAR WOULD NOT STAY IN PARK. IS THERE ANYTHING I CAN DO IF I AM NOT ON THE RECALL LIST? THIS IS COMPLETELY UNSAFE- I WILL NEVER, EVER BUY A GM CAR AGAIN. *TR
Fuel system, Gasoline, Electrical system, Service brakes, Mar 31, 2014
I NOTICE MY WIRES SMOKE SOME TIMES WHEN I DRIVE, AND WHEN I PUT MY FOOT ON THE BRAKES I HAVE TO DO IT MORE THAN TWO TIMES AND I HAD THAT FIXED IN FEBRUARY 2013. MY FUEL PUMP WENT OUT AND I REPLACED IT( ONFEBRUARY 15, 2014). JUST ABOUT A WEEK AFTER GETTING MY CAR FIXED IT SEEMS TO HESITATE WHEN I PUT MY FOOT ON THE ACCELERATOR. I TOOK IT TO GET IT LOOKED AT AND NO ONE COULD FIND ANYTHING WRONG AND IT IS YET DOING THIS. *TR
Steering, Suspension, Service brakes, Jan 10, 2014
WHEN BRAKING FOR A STOP THE CAR SHUDDERS AND SHAKES. THE STEERING WHEEL VIBRATES AND THE SOUNDS ARE HORRIBLE. IT SOUNDS AS IF THE DASHBOARD IS GOING TO FALL OUT ON YOUR LAP. WE HAVE HAD THE BRAKES SERVICED ON MULTIPLE OCCASIONS (ROTORS REPLACED, TURNED) AND AT ONE TIME THE FRONT AXLE WAS REPLACED BEING SUSPECTED OF BEING BENT. (IT WASN'T. COST $1600.00+) THERE ARE MANY STORIES OF THIS OCCURRENCE ON THE INTERNET FORUMS AND NOTHING IS BEING DONE ABOUT IT BY THE MANUFACTURER. WE OWN CARS THAT ARE FREAKING SCARY TO DRIVE AND IMPOSSIBLE TO SELL. HAVING TO STOP IN AN EMERGENCY OR VERY QUICKLY MAY NOT EVEN BE POSSIBLE THE SHAKING IS SO VIOLENT. *TR
Electrical system, Vehicle speed control, Service brakes, Nov 21, 2013
THE BRAKE LIGHTS COME ON AND DO NOT SHUT OFF (THIS IS AN INTERMITTENT PROBLEM BUT HAS GRADUALLY WORSENED TO THE POINT WHERE IT IS HAPPENING ALMOST ALL OF THE TIME NOW). ALSO, THE CRUISE CONTROL DOES NOT WORK AND AT TIMES IT IS DIFFICULT SHIFTING OUT OF PARK. WE HAVE BROUGHT THE CAR TO TWO DIFFERENT CHEVY DEALERSHIPS TWICE EACH, AND TO A PRIVATE MECHANIC TWICE (FOR A TOTAL OF 6 SERVICE TRIPS). DESPITE SPENDING SEVERAL HUNDRED DOLLARS, NONE OF THEM HAVE FIXED THE PROBLEM. SOMEONE ALMOST HIT ME FROM BEHIND A COUPLE WEEKS AGO BECAUSE MY BRAKE LIGHTS DID NOT CHANGE - HE FOLLOWED ME TO A GAS STATION AND YELLED AT ME! IT IS SO BAD NOW THAT WE DON'T DARE DRIVE THE CAR FOR SAFETY REASONS, AND CANNOT SELL IT FOR THE SAME REASON. MY GIRLFRIEND BOUGHT THIS CAR WHEN IT WAS BRAND NEW AND IT IS NOT ONLY UNSAFE AND DANGEROUS, BUT UNBELEIVEABLY FRUSTRATING THAT THEY JUST KEEP CHARGING US MORE MONEY BUT DON'T FIX THE PROBLEM. *TR
Service brakes, Aug 19, 2013
TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT STATED THAT THE BRAKE LIGHTS WOULD TURN ON ALTHOUGH THE BRAKE WAS NOT ENGAGED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE BRAKE LIGHT SWITCH WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE REMEDY FAILED TO REPAIR THE ISSUE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 12,000 AND THE CURRENT MILEAGE WAS 97,000.
Exterior lighting, Service brakes, Jun 26, 2013
WHEN I HIT MY BRAKES THE BRAKE LIGHTS GO OFF AND COME ON FOR A MOMENT. WHEN I GET OFF THE BRAKES THE LIGHTS STAY ON. *TR
Electrical system, Vehicle speed control, Service brakes, Jun 1, 2013
THE BRAKE LIGHTS STAY ON WHILE DRIVING AND TURN OFF WHILE APPLYING THE BRAKES. CRUISE CONTROL DOES NOT ALWAYS WORK. CAR IS HARD TO PUT IN GEAR - YOU HAVE APPLY BRAKES HARD TO PUT THE CAR IN GEAR. *TR
Exterior lighting, Vehicle speed control, Service brakes, Mar 21, 2013
BRAKE LIGHTS ARE WORKING BACKWARDS! WHEN BRAKE PEDDLE IS PUSHED THE BREAK LIGHTS DO NOT COME ON. WHEN YOU ARE NOT PRESSING THE BREAK PEDDLE; THE BRAKE LIGHTS ARE ON. CRUISE CONTROL DOESN'T ENGAGE AND THE GEAR SHIFT IS VERY DIFFICULT TO MOVE INTO PLACE. OF COURSE THE BRAKE LIGHT SITUATION IS THE MOST HAZARDOUS!! AFTER MULTIPLE SHOP VISITS, ATTEMPTED FIXES AND EVEN A CALL TO GM; (WHICH THEY LIED ABOUT NEVER HAVING THIS ISSUE ON OTHER MAKES/MODEL/YEARS) THERE WAS A RECALL IN 2009 FOR MALIBU'S THAT HAD THIS EXACT ISSUE AND SUPPOSEDLY ALL GM DEALERSHIPS WERE TO KNOW HOW TO FIX THIS ISSUE SHOULD THIS "PROBLEM ARISE IN OTHER MODELS". OUT OF THE 5 DEALERS I CALLED EXPLAINING MY ISSUES NOT ONE KNEW HOW TO FIX THE PROBLEM. DID A LOT OF RESEARCH ON MY OWN AND EXPLAINED IT TO A DEALER OF HOW OTHERS HAD FIXED THE ISSUE. THAT WORKED AND FIXED EVERY ONE OF THE PROBLEMS I WAS HAVING. NOW, IN MARCH 2013 THE ISSUES ARE STARTING AGAIN. FIRST IT STARTS WITH THE GEAR SHIFT BEING VERY HARD TO SHIFT GEARS INTO PLACE. THEN THE CRUISE STOPS ENGAGING. HOPEFULLY THE BRAKE LIGHT ISSUE WONT HAPPEN AGAIN. *TR
Electrical system, Exterior lighting, Service brakes, Mar 14, 2013
I HAVE A 2007 CHEVY MALIBU AND AM HAVING PROBLEMS WITH MY BRAKE LIGHTS. CURRENTLY MY BRAKE LIGHTS DON'T ILLUMINATE WHEN I STEP ON THE BRAKE PEDAL, BUT WILL ILLUMNATE WHEN I TAKE MY FOOT OFF THE BRAKE PEDAL. SOMETIMES BRAKE LIGHTS WILL STAY ON DURING MY ENTIRE DRIVE WHETHER OR NOT I'M USING THE BRAKE PEDAL. HAPPENS RANDOMLY, WITH NO DISCERNABLE CAUSES. ARTICLE IN FOX NEWS DATED 3/13/2013 ( HTTP://WWW.FOXNEWS.COM/LEISURE/2013/03/13/BAD-BRAKE-LIGHTS-COULD-FORCE-RECALL-OVER-ONE-MILLION-GM-CARS/#IXZZ2NUS7QU5S ) INDICATES NHTSA IS ACTIVELY RESEARCHING POSSIBLE RECALLS, BUT CALLS TO MY DEALER AND GM CUSTOMER CARE WE OF NO USE. BOTH MY DEALER AND GM CUSTOMER CARE TOLD ME THERE WERE NO ACTIVE RECALLS, AND THAT I JUST NEED TO GET THE PROBLEM FIXED MYSELF AND THEN I COULD REQUEST REIMBURSEMENT AT A FUTURE DATE IF ANY RECALL DID HAPPEN. IT'S DISAPPOINTING THAT A COMPANY AS LARGE AS GM WOULDN'T PROACTIVELY HELP THEIR CUSTOMERS WHEN A KNOWN PROBLEM EXISTS IN A LARGE NUMBER OF VEHICLES. ALSO MENTIONED IN THIS ARTICLE WERE PROBLEMS CONCERNING THE CRUISE CONTROL. MY CRUISE CONTROL WILL RANDOMLY STOP WORKING, OR NOT EVEN ALLOW ME THE OPTION OF USING CRUISE. THIS IS NOT AS BIG OF A SAFETY CONCERN AS THE BRAKE LIGHT ISSUE, BUT AGAIN, MENTION OF THIS PROBLEM OCCURING IS ONE MORE REASON I BELIEVE GM SHOULD BE MORE PROACTIVE IN HELPING THEIR CUSTOMERS DEAL WITH THE SPECIFIC ISSUES AND CONCERNS ALREADY BEING ADDRESS/INVESTIGATED BY THE NHTSA. *TR
Service brakes, Hydraulic, Engine and engine cooling, Fuel system, Gasoline, Air bags, Seat belts, Mar 20, 2012
THE FOLLOWING CODES ARE ACTIVE; P0463 FUEL LEVEL SENSOR A CIRCUIT HIGH INPUT, B0561 ABS $43 SYS DISABLED AND C0561 SYS DISABLED ISSUES. THE FUEL GAUGE WAS FLUCTUATING, BUT HAS NOW STOPPED WORKING. THE SERVICE ENGINE SOON LIGHT CAME ON AND WILL NOT RESET TO OFF. THE SERVICE SEAT BELT WARNING MESSAGE CAME ON. THE PROBLEMS WERE INTERMITTENT PRIOR TO 50,000 MILES, BUT NOW, JUST AFTER 50,000 MILES NOTHING RESETS. I HAVE FOUND THAT THIS IS A COMMON PROBLEM AND THE REPAIRS ARE VERY EXPENSIVE, YET NOTHING HAS BEEN DONE TO CONVINCE GM TO RECALL AND MAKE REPAIRS. WE OWN A 2006 MALIBU WITH 35,000 MILES ON IT. NOW, I'M WORRIED THAT IT IS GOING TO HAVE THE SAME PROBLEM AS OUR 2007 MALIBU. AND, WHO WANTS TO FACE THOSE REPAIR BILLS! *KB
Steering, Suspension, Service brakes, Hydraulic, Power train, Dec 30, 2011
TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE WOULD EXHIBIT ABNORMAL NOISES WHEN STEERING AND DRIVING OVER BUMPS AT APPROXIMATELY 30 MPH. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE FRONT STABILIZER BAR WAS FAULTY AND THE FRONT CALIPERS WERE NOT PROPERLY RELEASING. THE CONTACT WAS ALSO INFORMED THAT THE FRONT CALIPERS WERE BURNED AND CREATING A FIRE HAZARD. IN ADDITION, THE CONTACT WAS INFORMED THAT THE MASTER CYLINDER MAY BE DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 35,000. UPDATED 03/05/12*LJ THE CONSUMER STATED WHITE SMOKE EMITTED FROM THE WHEELS AND BRAKE AREA. ALSO, THE VEHICLE WOULD NOT GO OVER 10 MPH. UPDATED 03/07/12
Steering, Suspension, Service brakes, Hydraulic, Sep 10, 2011
MID-JUNE, 2011:VEHICLE WAS MAKING A ROARING NOISE: THE RESULT WAS THAT THE FRONT WHEEL BEARINGS WERE BROKEN END OF AUGUST 2011: DIFFICULTY TURNING THE STEERING WHEEL ACCOMPANIED BY A LOUD GRINDING SOUND,THE RESULT WAS THAT THE STEERING SHAFT AND OUTER TIE ROD WERE BROKEN AND HAD TO BE REPLACED. SEPTEMBER 2011: EXTREME DIFFICULTY APPLYING BRAKES, ON OCCASION WOULD APPEAR NORMAL. HAD 3 BRAKE INSPECTIONS DONE WITHIN A WEEK AND A HALF PERIOD. WHEN BRAKES NO LONGER WOULD OPERATE , TIT WAS DETERMINED THAT THE MASTER CYLINDER NEEDED TO BE REPLACED.4. *TR
Vehicle speed control, Service brakes, Electric, Equipment, Dec 28, 2010
BRAKE LIGHT DO WITH CRUISE CONTROL SOMETHING LIKE....... CHEVROLET/PONTIAC/SATURN: INTERMITTENTLY BRAKE LIGHTS (STOP LAMPS) DO NOT FUNCTION CORRECTLY, EXTENDED TRAVEL TO SHIFT OUT OF PARK, CRUISE CONTROL INOPERATIVE, DTCS C0161/C0277 SET (PERFORM REPAIR AS OUTLINED). [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Steering, Suspension, Service brakes, Hydraulic, Jul 31, 2010
I HAVE A 2007 CHEVY MALIBU. I BOUGHT THE CAR 2 1/2 YRS. AGO. IT HAD 12,000 MILES ON IT AT THE TIME. WE WERE TOLD AT 33,000 MILES THAT IT NEEDED A NEW STEERING GEAR, WHICH WE DID, THEN AT 35,000 MILES A STRUT WAS REPLACED, THEN IN 2009 ANOTHER STEERING GEAR WAS PUT IN AND ALSO A FEW MONTHS LATER IT WAS YET AGAIN DOING THE SAME THING SO THEY GREASED IT..... NOW THEY SAY WE NEED A STEERING SHAFT PUT IN.....GM SHOULD RECALL ALL THESE VEHICLES.....I FOR ONE AM FILING A COMPLAINT WITH THE BBB AND WILL NEVER OWN A GM PRODUCT AGAIN....I AS WELL, WILL DO MY BEST TO DETER ANYONE I KNOW FROM OWNING A GM PRODUCT! *TR
Service brakes, Hydraulic, Jul 1, 2009, crash
TL*THE CONTACT OWNS A 2007 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT HAD TO APPLY EXCESSIVE FORCE TO THE BRAKE PEDAL. UNEXPECTEDLY, THE VEHICLE BEGAN TO FISHTAIL. THE DRIVER WAS ABLE TO GAIN CONTROL OF THE VEHICLE. WHENEVER THE BRAKES WERE APPLIED WITH EXCESSIVE FORCE, THE FAILURE WOULD RECUR. THE FAILURE RESULTED IN A CRASH ON ONE OCCASION. THE DRIVER SUSTAINED SEVERE INJURIES AND WAS TRANSPORTED TO THE HOSPITAL. THE AMBULANCE AND POLICE WERE CALLED TO THE SCENE AND A REPORT WAS FILED. THE VEHICLE WAS DAMAGED AND TOWED TO A BODY SHOP. THE CAUSE OF THE FAILURE HAS NOT YET BEEN DETERMINED. THE FAILURE MILEAGE WAS 52,000 AND THE CURRENT MILEAGE WAS UNAVAILABLE.
Service brakes, Hydraulic, Electronic stability control (ESC), Feb 11, 2009, crash
DRIVING 2007 CHEVROLET MALIBU WHEN ANOTHER VEHICLE PULLED OUT OF SIDE STREET PROCEEDED TO ENGAGE BRAKES AND VEHICLE SKIDDED OUT OF CONTROL CAUSING ACCIDENT. A B S FAILURE AND TRACTION CONTROL FAILURE CAUSING VEHICLE TO BE TOTAL LOSS. *TR
Service brakes, Hydraulic, Nov 16, 2008
WHEN APPLIED RIGHT FRONT BRAKE LOCKED UP AND LEFT SKID MARK 4 FEET LONG,NO OTHER BRAKE WHEEL LEFT ANY SKID MARK. IT SKIDDED WITH MY WIFE WHEN SHE HAD TO SLAM ON BRAKES ON NOVEMBER 15TH 2008 AROUND 7:45PM IT SLID SIDE WAYS ALMOST CAUSING A TERRIBLE WRECK. IT WAS ON DRY PAVEMENT SHE WAS TRAVELING AROUND 52-54 MPH,IT DID THIS BEFORE WITH ME DRIVING I ALMOST HIT A SPORT UTILITY VEHICLE WHO PULLED OUT OF A DRIVEWAY IN FRONT OF MY PATH. THE DEALER CHECKED IT BUT SAID THE COMPUTER SHOWED NOTHING WRONG WITH THE BRAKES. *TR
Service brakes, Hydraulic, Aug 30, 2008, crash
I WAS DRIVING A 2007 CHEVROLET MALIBU UNDERCOVER POLICE CAR. I WAS CHASING AN ARMED ROBBERY SUSPECT AND WAS DRIVING 53 MPH ACCORDING TO THE ACCIDENT INVESTIGATION. I LEFT SOLID DARK BLACK SKID MARKS FOR OVER A HUNDRED FEET PRIOR TO MY IMPACT. THE ANTI-LOCK BRAKES FAILED AND THERE WAS NO DISCERNIBLE DIFFERENCE BETWEEN THE VEHICLE I WAS DRIVING AN ONE NOT EQUIPPED WITH ANTI-LOCK BRAKES. AFTER ABOUT EIGHTY FEET OF SOLID SKID AND NO STEERING CONTROL, I WAS FORCED TO RELEASE THE BRAKE PEDDLE SLIGHTLY TO GAIN STEERING SO I WOULD NOT STRIKE THE CAR IN FRONT OF ME SQUARELY ON THE DRIVERS DOOR, POSSIBLY KILLING THE ELDERLY DRIVER, WHO RAN A STOP SIGN IN FRONT OF ME. I WAS KNOCKED UNCONSCIOUS AND AIR LIFTED TO THE HOSPITAL DUE TO MY INJURIES. *TR
Service brakes, Hydraulic, Equipment, Apr 9, 2007
PURCHASED CAR 5/06 ,RETURNED TO THE DEALER 30 DAYS LATER WITH WITH SEVERE BRAKE AND ROTOR DAMAGE. I HAVE SINCE THEN REPLACED THE BRAKES AND ROTORS 3 TIMES, AND MY CAR WAS A ANOTHER DEALER WHO FOUND THAT A CLAMP WAS LEFT ON THE BRAKE LINE WHICH CAUSED ALL OF THE DAMAGE. PURCHASING DEALER WAS NORM REEVES HONDA , HUNTINGTON BEACH,CA , AND SERVICING DEALER COMMUNITY CHEVROLET, BURBANK CA. THE PURCHASING DEALER WOULD NOT ASSIST ME WITH THE REPAIRS AFTER THE INITIAL REPAIR WHICH I SPLIT THE COST OF THE REPAIRS.*AK