2009 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,509 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 Malibu model years with reports.
Of the 2009 reports, 41 involved a crash and 9 involved a fire. 44 people were injured and 3 people died.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Power train, automatic transmission, gear position indication (prndl)Sep 18, 2012
General Motors (GM) is recalling certain model year 2007-2010 Saturn Aura and model year 2008-2010 Chevrolet Malibu and Pontiac G6 vehicles, equipped with a 4-speed automatic transmission. On these vehicles, the tabs on the transmission shift cable end may fracture and separate.
If the tabs were to fracture and separate, the shift lever and the actual position of the transmission gear may not match. The driver would be able to move the shifter to 'PARK' and remove the ignition key, but the transmission gear may not be in 'PARK.' The vehicle may not be able to be restarted and the vehicle could roll away after the driver has exited the vehicle, resulting in a possible crash without prior warning.
GM will notify owners, and dealers will install a retainer over the cable end or replace the shift cable as necessary. This service will be performed free of charge. Notification to owners began on on November 9, 2012. Owners were instructed to not bring their vehicles for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Campaign 12V460000 on NHTSA.gov
Power train, automatic transmission, lever and linkage, column shiftMar 6, 2009
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".
THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.
Campaign 09V073000 on NHTSA.gov
Visibility, defroster/defogger/hvac systemDec 2, 2008
GM IS RECALLING 77 MY 2009 CHEVROLET MALIBU HYBRID VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEM." THE HEATING, VENTILATION, AND AIRCONDITIONING (HVAC) SYSTEM MAY BECOME INOPERATIVE. IF THIS WERE TO OCCUR, THE BLOWER WOULD NOT FUNCTION PROPERLY AND THE MODE SELECTOR WOULD REMAIN IN THE LAST KNOWN SETTING.
IF THE WINDSHIELD BEGAN TO FOG OR FROST, THERE MAY NOT BE ENOUGH AIRFLOW TO CLEAR THE WINDSHIELD, RESULTING IN REDUCED DRIVER VISIBILITY AND A POSSIBLE CRASH WITHOUT PRIOR WARNING.
DEALERS WILL REPROGRAM THE HVAC CONTROL HEAD MODULE. THE RECALL IS EXPECTED TO BEGIN ON DECEMBER 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Campaign 08V634000 on NHTSA.gov
Representative owner complaints: electrical system
368 reports, newest first. Show all
Service brakes, Hydraulic, Electrical system, Electronic stability control (ESC), Traction control system, Apr 5, 2016
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A DEALER FOR A MANUFACTURER RECALL CONCERNING NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE CONTACT WAS NOT EXPERIENCING ANY FAILURES BEFORE THE RECALL REPAIR WAS PERFORMED BY THE DEALER. THE CONTACT STATED THAT THE ESC AND TRACTION CONTROL WARNING LIGHTS RANDOMLY ILLUMINATED. THE DEALER AND THE MANUFACTURER INDICATED THAT THE BRAKE LIGHT SENSOR SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO A DEALER AND AN INDEPENDENT MECHANIC FOR INSPECTION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Steering, Electrical system, Mar 28, 2016, crash
TL* THE CONTACT OWNED A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN AND THE VEHICLE ALSO STARTED DECELERATING WHILE THE ACCELERATOR PEDAL WAS BEING DEPRESSED. AS A RESULT, THE CONTACT WAS INVOLVED IN A CRASH BUT THE DETAILS WERE NOT AVAILABLE. THE CONTACT WAS ABLE TO GET THE VEHICLE PULLED TO THE SIDE OF THE ROAD AND SHUT IT DOWN. THE VEHICLE BECAME DIFFICULT TO RESTART. THE VEHICLE WAS DRIVEN A LITTLE FURTHER AND THE FAILURE RECURRED. THE VEHICLE WAS SHUT OFF AND WOULD NOT RESTART. THE VEHICLE WAS TOWED. THE VEHICLE WAS SIDE SWIPED BY ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THERE WAS NO POLICE REPORT FILED. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE WAS NOT DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 171,000.
Electrical system, Mar 16, 2016
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. WHILE DRIVING AT ANY SPEED, THE BRAKE LIGHT REMAINED ILLUMINATED, THE TRACTION CONTROL LIGHT ILLUMINATED, AND THE CRUISE CONTROL FAILED TO FUNCTION. IN ADDITION, THE INTERIOR LIGHTING WOULD GO FROM BRIGHT TO DIM AND THE DAYTIME RUNNING LAMPS ALSO FAILED TO ILLUMINATE. THE FAILURE RECURRED EVERYDAY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.
Electrical system, Feb 17, 2016
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. WHILE ATTEMPTING TO RESTART THE ENGINE, THE SECURITY SENSOR LIGHT ILLUMINATED AND THE ENGINE WOULD NOT RESTART. THE LIGHT DIMMED AFTER 5-10 MINUTES AND THE VEHICLE COULD NOT BE RESTARTED. THE CONTACT INDICATED THAT THE FAILURE WAS INTERMITTENT. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 167,000.
Electrical system, Feb 16, 2016
MY POWER LOCKS WANT TO UNLOCK & LOCK WHILE I AM OPERATING THE VEHICLE. I AM CONCERNED BECAUSE BECAUSE WITH GRANDCHILDREN IF THE DOORS MALFUNCTION AS THEY HAVE BEEN THEY CAN OPEN THE DOORS WHILE I AM DRIVING. THIS IS A PROBLEM WITH THESE PARTICULAR YEARS. ON CARCOMPLAINTS.COM 29 COMPLAINTS NOT A LOT HOWEVER IT IS A SAFETY HAZARD THAT NEEDS FIXING.
Steering, Electrical system, Electronic stability control (ESC), Jan 31, 2016
MY ELECTRIC STEERING PUMP SUDDENLY STOP WORKING YESTERDAY WHILE DRIVING ON STREET. TWO WARNING MESSAGES APPEARED ON EIC. " CHECK STEERING" "ESC OFF CHECK". I HAVE READ ON MANY FORUMS, BY CHEVY MALIBU OWNERS, HAVE COMPLAIN HAVING SAME ISSUE. I' M CONCERN FOR MY FAMILY SAFETY IF THIS STEERING PUMP FAILS AGAIN AT GREATER SPEED.
Electrical system, Other or unspecified, Electronic stability control (ESC), Jan 9, 2016
ENGINE POWER REDUCED AND CAR CRANKS BUT WONT START. IT ALSO SLOWED DOWN WHEN THAT ENGINE POWER REDUCED CAME ON ALMOST HAD AN ACCIDENT AND MY FAMILY WAS IN THE CAR.
Electrical system, Other or unspecified, Engine, Jan 3, 2016
THERE IS SOMETHING FAULTY IN THE SYSTEM WHICH IS CAUSING THE BATTERY TO BECOME COMPLETELY DRAINED IF THE CAR SITS 2/3 DAYS WITHOUT BEING STARTED. I HAVE REPLACED MY 3 TIMES AND STILL SOMETHING IN THE CAR IS CONTINUING TO DRAIN THE BATTERY. THERE IS HUNDREDS OF PEOPLE ALL OVER THE INTERNET THAT ARE HAVING THIS SAME ISSUE. NOT EVEN THE DEALERSHIP COULD FIX THE ISSUE. I AM NOT PHYSICALLY LEAVING ANYTHING ON IN THE CAR BUT IT CONTINUES TO KEEP DYING. THIS IS DEFINITELY A DEFECT WITH THIS CAR THAT NEEDS TO BE FIXED. MY CAR IS A 2009, AND IT HAS BEEN DYING 2011.
Electrical system, Dec 15, 2015
DOOR LOCKS RANDOMLY ENGAGE AND DISENGAGE WHILE DRIVING THEY MAY UNLOCK MAY NOT UNLOCK WHEN CAR IS NOT IN MOTION THEN RANDOMLY THEY LOCK AND UNLOCK WHILE THE CAR IS IN MOTION CONSTANTLY AT SLOW SPEED LESS OFTEN DURING HIGHWAY DRIVING THEY ENGAGE AND DISENGAGE CONSTANTLY MULTIPLE COMPLAINTS ON THE INTERNET INVOLVING THE SAME ISSUE ON THE SAME VEHICLE
Electrical system, Exterior lighting, Dec 10, 2015
HIGH MOUNTED BRAKE LIGHT RANDOMLY WORKS, SIMILAR TO PREVIOUS RECALL. CHEVY DEALER TRIES TO TELL ME LIGHT IS "FRIED" WHEN IT ACTUALLY WORKS, INTERMITTENTLY. GM HAS YET TO CONTACT ME ON WHETHER THEY WILL COVER THE COST
Electrical system, Dec 7, 2015
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT WHEN THE IGNITION KEY WAS TURNED TO THE START POSITION, THE VEHICLE FAILED TO START WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.
Electrical system, Exterior lighting, Nov 20, 2015
RT FRONT HEADLIGHT BECAME INOPERATIVE TOOK VEHICLE TO CHEVROLET DEALERSHIP FOR REPAIR MECHANIC FOUND HEADLIGHT CONNECTOR BURNED AND MELTED--LIGHT BULB CONNECTOR BURNED POSSIBILITY OF ELECTRICAL FIRE
Electrical system, Electronic stability control (ESC), Service brakes, Nov 11, 2015
THE BRAKE LIGHTS TO ILLUMINATE WITHOUT THE BRAKE PEDAL BEING PUSHED; THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE PEDAL IS PUSHED; DIFFICULTY DISENGAGING THE CRUISE CONTROL; AND DISABLEMENT OF CRASH AVOIDANCE FEATURES SUCH AS TRACTION CONTROL, ELECTRONIC STABILITY CONTROL, AND PANIC BRAKING ASSIST FEATURES. THIS OCCURS AFTER WE HAVE HAD THE WORK DONE THAT WAS FOR GM RECALL NUMBER 13036/NHTSA CAMPAIGN NUMBER: 14V252000 MULTIPLE TIMES.
Power train, Electrical system, Nov 9, 2015
WHILE DRIVING THE CAR AT 55 MPH IT STARTED JUMPING/SKIPPING WHILE I WAS DRIVING ON A 3 LANE HIGHWAY AND THEN IT JUST DIED. I COULDN'T GET IT IN REVERSE AND IT WOULDN'T SHIFT AT ALL. THE ELECTRICAL INFORMATION ON THE DASH WENT OUT AS WELL. I HAD TO ARRANGE A TOW. I'M BEING TOLD IT NEEDS A NEW TRANSMISSION AND THERE IS ELECTRICAL FAILURE AS WELL. THE CAR HAS 86,000 MILES ON IT AND HAS BEEN SERVICED ROUTINELY. HOW DOES A TRANSMISSION GO FROM WORKING TO DEAD IN SECONDS?
Electrical system, Nov 8, 2015
THE CENTER HIGH MOUNT STOP LIGHT WORKS AND THEN DOES NOT WORK AT TIMES. DEALER SAID 3 THIRD BRAKE LIGHT NEEDS REPLACED. LED BULB DOES LIGHT AT TIMES SO ITS NOT IN THE LED BUT SOMETHING UP IN LIGHT ASSEMBLY .
Steering, Electrical system, Engine, Oct 29, 2015
POWER STEERING ,TRACTION LIGHT, ENGINE POWER DOWN ALL COME ON AND CAR SHUT DOWN
Electrical system, Vehicle speed control, Electronic stability control (ESC), Oct 26, 2015
DRIVING AT 65 MPH ON THE INTERSTATE AND ESC LIGHT, CHECK ENGINE LIGHT, AND SECURITY LIGHT CAME ON. THE SPEEDOMETER NEEDLE AND THE FUEL GUAGE NEEDLE STARTED JUMPING SPORADICALLY AND THEN I LOST POWER FOR A MOMENT AND COULD NOT ACCELERATE. HAD TO COAST TO THE SIDE OF THE ROAD. VERY DANGEROUS SITUATION. TURNED THE CAR OFF AND RESTARTED, AND IT HAPPENED NUMEROUS MORE TIMES. HAD TO END UP HAVING IT TOWED. IT IS IN THE SHOP NOW, AND THEY HAVEN'T DETERMINED WHAT IS WRONG YET.
Electrical system, Exterior lighting, Service brakes, Oct 22, 2015
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. WHILE DRIVING AT ANY SPEED, THE BRAKE LIGHT ILLUMINATED WITHOUT THE BRAKE PEDAL BEING DEPRESSED. IN ADDITION, THE INSTRUMENT PANEL LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC STABILITY CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT INCLUDED IN A NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 82,997.
Electrical system, Visibility/wiper, Oct 19, 2015
**LOW BEAM ON PASSENGER SIDE OF VEHICLE** WHILE OFF - UNLOCKING WITH THE KEY FOB ILLUMINATES THE HEADLAMP (STATIONARY) WHILE ON - HEADLAMP DOES NOT WORK (STATIONARY & IN MOTION) IT WAS THOUGHT THAT THE BULB NEEDED TO BE REPLACED, SO IT WAS REPLACED, AND IT HAS NOT CORRECTED THE PROBLEM.
Electrical system, Exterior lighting, Oct 15, 2015
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. WHILE DRIVING AT VARIOUS SPEEDS, THE THIRD BRAKE LIGHT ILLUMINATED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE THIRD BRAKE LIGHT WIRING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000. ...UPDATED 02/19/16 *BF UPDATED 4/19/18*JB DEALERSHIP CLAIMS IT IS NOT PART OF RECALL, BUT THERE IS A RECALL FOR BRAKE LIGHT MALFUNCTION. UPDATED 4/19/18*JB *CN
Electrical system, Vehicle speed control, Oct 9, 2015
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ALL FOUR DOORS LOCKED AND UNLOCKED INDEPENDENTLY WHILE DRIVING. THE CONTACT REMOVED THE BATTERY OUT OF THE REMOTE, BUT THE FAILURE RECURRED MULTIPLE TIMES EVEN WHEN THE KEY WAS OUT OF THE IGNITION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT ALSO STATED WHILE DRIVING APPROXIMATELY 70 MPH, THE CRUISE CONTROL WAS ENGAGED, BUT DISENGAGED INDEPENDENTLY. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL); HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 72,000.
Electrical system, Exterior lighting, Electronic stability control (ESC), Oct 5, 2015, fire
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. WHILE DRIVING AT 30 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE FRONT PASSENGER SIDE HEAD LAMP. IN ADDITION, BOTH THE PASSENGER AND DRIVER SIDE HIGH AND LOW BEAM HEAD LAMPS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO A DEALER WHO DIAGNOSED THAT THE WIRING HARNESS AND THE HEAD LAMP ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE CONTACT ALSO STATED THAT WHILE AT A STOP LIGHT, "SERVICE ESC, SERVICE TRACTION. ESC OFF" WAS DISPLAYED ACROSS THE MESSAGE BOARD. THE ESC WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS UNKNOWN.
Electrical system, Oct 2, 2015
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STALLED AND WAS COASTED TO THE SIDE OF THE ROAD. AFTER RESTARTING, THE VEHICLE RESUMED NORMALLY. IN ADDITION, THE VEHICLE FAILED TO START UNTIL AFTER A FEW MOMENTS WHEN THE IGNITION KEY WAS TURNED TO THE ACCESSORY POSITION. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 21,000.
Electrical system, Oct 1, 2015
ELECTRIC DOOR LOCK ON THE REAR DRIVER SIDE DOOR DOES NOT WORK PROPERLY IN WARM OR HOT WEATHER. YOU CAN HEAR THE ACTUATOR TRYING, BUT IT WILL ONLY "PARTIALLY"L OCK/ UNLOCK THE DOOR OR NOT EVEN BUDGE THE INTERNAL MANUAL LEVER WHETHER THE REMOTE FOB OR INTERNAL CONTROL SWITCH IS USED. THINGS WORK FINE WHEN IT IS COLD. THIS IS DEFINITELY RELATED TO HEAT BECAUSE IN THE SPRING AND FALL THIS IS ONLY A PROBLEM WHEN THE SUN SHINES ON THE DRIVER'S SIDE OF THE CAR. FURTHERMORE, IN THE SUMMER THE LOCK WILL OFTEN WORK AFTER RUNNING THE A/C FOR 30 MINUTES OR SO. I THINK THIS PROBLEM STARTED WHEN THE CAR WAS 3-4 YEARS OLD. WE CAN USE THE KEY TO UNLOCK THE DOOR, AND IF WE USE THE REMOTE FOB FIRST, THE ALARM WON'T SOUND. JUST THE SAME, IT IS AGGRAVATING.
Electrical system, Exterior lighting, Service brakes, Sep 30, 2015
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. WHILE DRIVING AT APPROXIMATELY 35 MPH, THE REAR BRAKE LIGHTS ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT MENTIONED THAT THE BRAKE LIGHTS REMAINED ILLUMINATED AFTER THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.