2009 Chevrolet Malibu
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,509 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 Malibu model years with reports.
Of the 2009 reports, 41 involved a crash and 9 involved a fire. 44 people were injured and 3 people died.
What owners report most often
Recalls and investigations
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Steering, electric power assist systemMar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Campaign 14V153000 on NHTSA.gov
Power train, automatic transmission, gear position indication (prndl)Sep 18, 2012
General Motors (GM) is recalling certain model year 2007-2010 Saturn Aura and model year 2008-2010 Chevrolet Malibu and Pontiac G6 vehicles, equipped with a 4-speed automatic transmission. On these vehicles, the tabs on the transmission shift cable end may fracture and separate.
If the tabs were to fracture and separate, the shift lever and the actual position of the transmission gear may not match. The driver would be able to move the shifter to 'PARK' and remove the ignition key, but the transmission gear may not be in 'PARK.' The vehicle may not be able to be restarted and the vehicle could roll away after the driver has exited the vehicle, resulting in a possible crash without prior warning.
GM will notify owners, and dealers will install a retainer over the cable end or replace the shift cable as necessary. This service will be performed free of charge. Notification to owners began on on November 9, 2012. Owners were instructed to not bring their vehicles for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Campaign 12V460000 on NHTSA.gov
Power train, automatic transmission, lever and linkage, column shiftMar 6, 2009
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".
THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.
Campaign 09V073000 on NHTSA.gov
Visibility, defroster/defogger/hvac systemDec 2, 2008
GM IS RECALLING 77 MY 2009 CHEVROLET MALIBU HYBRID VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEM." THE HEATING, VENTILATION, AND AIRCONDITIONING (HVAC) SYSTEM MAY BECOME INOPERATIVE. IF THIS WERE TO OCCUR, THE BLOWER WOULD NOT FUNCTION PROPERLY AND THE MODE SELECTOR WOULD REMAIN IN THE LAST KNOWN SETTING.
IF THE WINDSHIELD BEGAN TO FOG OR FROST, THERE MAY NOT BE ENOUGH AIRFLOW TO CLEAR THE WINDSHIELD, RESULTING IN REDUCED DRIVER VISIBILITY AND A POSSIBLE CRASH WITHOUT PRIOR WARNING.
DEALERS WILL REPROGRAM THE HVAC CONTROL HEAD MODULE. THE RECALL IS EXPECTED TO BEGIN ON DECEMBER 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Campaign 08V634000 on NHTSA.gov
Representative owner complaints: steering
768 reports, newest first. Show all
Steering, Mar 27, 2015
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 15 MPH, THE STEERING WHEEL SEIZED AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE STEERING SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 102,000.
Steering, Electronic stability control (ESC), Engine, Mar 24, 2015
I WAS DRIVING JUST A FEW BLOCKS FROM MY HOUSE WHEN I STOPPED AT A RED LIGHT. THE LIGHT TURNED GREEN SO I WENT TO GO. MY CAR THEN FLASHED A SERVICE ESC WARNING, THEN IT FLASHED ESC OFF & THEN FLASHED ENGINE POWER REDUCED. MY CHECK ENGINE LIGHT ALSO CAME ON AND HAS STAYED ON. MY CAR WOULDN'T EVEN GO OVER 10MPH, AND WAS SHAKING SO BAD I THOUGHT I WAS GOING TO LOSE CONTROL OF THE VEHICLE. THANK GOD I DIDN'T MAKE IT OUT OF TOWN. I JUST RECENTLY HAD MY CAR AT THE CHEVROLET AUTO SHOP TO HAVE MY TRANSMISSION COMPLETELY REBUILT AND FOR THE BRAKE LIGHT MALFUNCTION RECALL. THEN MY CAR ENDED UP BACK IN THE SHOP APPARENTLY FOR A BAD CADILLAC CONVERTER, WHICH I THINK REALLY WAS THIS PROBLEM ALL ALONG. I HAVE ONLY HAD THIS CAR FOR A YEAR, AND I AM BEYOND DISGUSTED WITH ALL THE PROBLEMS. I DON'T THINK I WILL BE PURCHASING ANOTHER VEHICLE FROM CHEVROLET, AS THEY JUST AREN'T GOOD CARS APPARENTLY. SIDE NOTE: I TAKE REALLY GOOD CARE OF MY VEHICLE AND DO ALL THE NORMAL SERVICE MAINT. ON TIME ETC SO THERE IS NO EXCUSE FOR THIS. IT'S JUST A BAD CAR! I HAVE A 2009 CHEVY MALIBU. *TR
Steering, Mar 24, 2015
TL*THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT THE POWER STEERING FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 82,000....UPDATED 05-26-15*BF UPDATED 7/6/2015*JS
Steering, Electronic stability control (ESC), Mar 24, 2015
WHILE DRIVING INTO A PARKING LOT MY POWER STEERING SUDDENLY QUIT WORKING AND THE SERVICE ESC AND POWER STEERING LIGHTS STARTED FLASHING. I LOOKED UP MY VIN TO SEE IF IT QUALIFIED FOR A RECALL BUT IT DIDN'T FIT UNDER RECALL #14V153000 EVEN THOUGH MY CAR WAS BUILT THE SAME YEAR AND SAME MODEL AND IS EXPERIENCING THE SAME ISSUES AS DESCRIBED IN THIS RECALL. THIS RECALL NEEDS TO BE EXPANDED TO INCLUDE MORE VEHICLE EXPERIENCING THE SAME PROBLEM. *TR
Steering, Mar 18, 2015
WHEN PULLING OUT OF MY DRIVEWAY, THE POWER STEERING JUST QUIT, ITS ELECTRIC POWER STEERING, MESSAGE CENTER INDICATES "POWER STEERING", "SERVICE ESC", THEN "ESC OFF" AND MY TRACTION CONTROL LIGHT COMES ON. OCCASIONALLY WHEN I FIRST START THE CAR THE POWER STEERING WILL WORK FOR A MINUTE OR TWO THEN GOES OUT AGAIN. I SEARCHED FOR RECALLS BUT THERE ARE NO OPEN RECALLS AT THIS TIME. ACCORDING TO A CHEVROLET MALIBU WEBSITE THERE IS A KNOWN PROBLEM WITH LOSS OF POWER STEERING WITH SOME 2009 MALIBUS. APPARENTLY MY BUILD DATE MISSED THE RECALL BY A MONTH. THEREFORE THIS DOES NOT SEEM TO BE A "WEAR PROBLEM". *TR
Steering, Mar 18, 2015
POWER STEERING SHUT OFF WHILE DRIVING. ALMOST LOST CONTROL ON THE HIGHWAY. SAW THAT THEIR WERE RECALL FOR OTHER GM VEHICLES SUFFERING FROM SAME PROBLEM. I WAS TOLD THAT MY VEHICLE WAS NOT ON RECALL. *TR
Steering, Mar 12, 2015
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 5 MPH, THE POWER STEERING AND THE ESC WARNING LIGHTS ILLUMINATED. THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE FAILURE WAS PERSISTENT. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
Steering, Mar 11, 2015
DRIVING DOWN THE HIGHWAY AROUND 60 MPH WHEN THE POWER STEERING ON MY '09 MALIBU FROZE. AN ESC NOTIFICATION CAME ON AND THEN ONE FOR POWER STEERING. MANAGED TO GET MY CAR OFF TO THE SIDE OF THE ROAD WHERE I TURNED MY CAR OFF AND THEN ON AGAIN TO RESET. THIS HAPPENED 6 MORE TIMES ON MY 10 MILE COMMUTE HOME. THIS HAD HAPPEN A FEW TIMES BEFORE BUT VERY INTERMITTENTLY. AFTER RESEARCHING THIS ISSUE ON-LINE I LEARNED THAT GM IS AWARE OF THIS PROBLEM AND ISSUED A RECALL NOTICE LAST YEAR BUT DOES NOT INCLUDE MY VIN (CONFIRMED WITH DEALER). BECAUSE MY VIN IS NOT COVERED THIS WILL BE AN OUT OF POCKET EXPENSE FOR ME THOUGH AS OTHERS HAVE SAID, IS THE SAME PROBLEM. THE DEALER SAID THAT THE ISSUE WITH MY CAR MAY NOT BE THE SAME AS THE ONES IN THE RECALL NOTICE BUT WILL NOT KNOW UNTIL I BRING IT IN. THERE MAY BE A POSSIBILITY THAT MY VIN WILL BE INCLUDED IN A SUBSEQUENT RECALL NOTICE AND IF IT IS I CAN BE REIMBURSED FOR THE EXPENSE. *TR
Steering, Mar 11, 2015
TL*THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE STEERING WHEEL STARTED SHAKING VIOLENTLY AS THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT AN UNKNOWN PART OF THE STEERING WHEEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14E044000 (STEERING). THE FAILURE MILEAGE WAS 68,000. THE VIN WAS NOT AVAILABLE.
Steering, Mar 10, 2015
TL*THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE STEERING WHEEL WAS DIFFICULT TO MANEUVER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE POWER STEERING POWER ASSIST SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.
Steering, Mar 10, 2015
DRIVING HOME FROM WORK, THE ESC LIGHT CAME ON THEN THE WHEEL MOVED LEFT TO RIGHT LIKE IT WAS DRIVING IT SELF. I PULLED OVER SHUT THE CAR OFF AND LOOKED TO SEE IF I HAD A FLAT TIRE, WHICH I DID NOT. I STARTED THE CAR BACK UP AND WENT TO DRIVE AWAY AND I HAD NO POWER STEERING. I DID CALL GM SERVICE 1-800-222-1020 AND WAS TOLD THEY WILL PROVIDE A FREE 1 HOUR DIAGNOSTICS, THEN I WOULD HAVE TO CALL BACK WITH MY REF# TO TALK ABOUT MY OPTIONS NOW THERE ARE OTHER CARS EFFECTED AND UNDER RECALL I THINK THEY NEED TO EXTEND THE RECALL. I HOPE THEY RESOLVE THIS PROBLEM... NOT AT MY COST *TR
Steering, Mar 9, 2015
TL*THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 5 MPH, THE STEERING WHEEL SEIZED AS THE POWER STEERING WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 109,000.
Steering, Mar 9, 2015
POWER STEERING STARTED FAILING AT LOW SPEEDS, WOULD HAVE TO REALLY CRANK WHEEL AND EVENTUALLY RESTART THE CAR. TOOK IT TO THE DEALERSHIP, WHERE THEY TOLD ME IT WAS A "THERMAL ERROR" FROM ME CRANKING THE WHEEL TOO MUCH (I DON'T TURN THE WHEEL ANY DIFFERENT THAT I DID THE LAST 4 YEARS WITH THE CAR). NOW ITS GOTTEN WORSE- EVERYTIME I TURN ON MY CAR THE WHEEL IS LOCKED, AND THE POWER STEERING AND SERVICE ESC LIGHTS COME ON. I HAVE TO RESTART, SOMETIMES A FEW TIMES, BEFORE I CAN DRIVE AGAIN. THE WHEEL ALSO MAKES LITTLE JERKS AND NOISES NOW WHEN I'M DRIVING AT ANY SPEED. I KNOW A TON OF MALIBUS HAVE BEEN RECALLED FOR POWER STEERING BUT APPARENTLY MY VIN NUMBER IS NOT INCLUDED IN THIS DESPITE THE PROBLEMS BEING IDENTICAL. *TR
Steering, Mar 9, 2015
TL*THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 65 MPH, THERE WAS A SUDDEN LOSS OF POWER STEERING AND THE WARNING LIGHT ILLUMINATED. THE STEERING WHEEL BECAME EXTREMELY DIFFICULT TO TURN EVEN WITH FORCE BEING APPLIED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO INFORMED THAT THE STEERING TORQUE SENSOR WOULD NEED TO BE REPLACED. THE VEHICLE WAS CURRENTLY BEING REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000. UPDATED 4/20/15*CN
Steering, Mar 9, 2015
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL SEIZED AND THE POWER STEERING SERVICE AND ESC WARNING INDICATORS ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER, WHERE IT WAS DIAGNOSED THAT THE TORQUE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 88,000.
Steering, Mar 8, 2015
WAS DRIVING ON HIGHWAY STEERING LOCK UP ON ME HAD TO PULL OVER MY SPEED WAS 65 COULD NOT STEER ALMOST GOT HIT BY AN 18 WHEELER. *TR
Steering, Electronic stability control (ESC), Mar 7, 2015
POWER STEERING WILL QUIT INTERMITTENTLY AND WILL ESC LIGHT WILL COME ON. STEERING IS VERY DIFFICULT AND COULD RESULT IN A ACCIDENT. *TR
Steering, Electronic stability control (ESC), Mar 6, 2015
I WAS DRIVING EAST ON COLONEL GLENN HIGHWAY IN DAYTON OH, WHEN THE ELECTRIC POWER STEERING WENT OUT. IT CAUSED THE CAR TO JERK AND CAUSED MY WIFE'S NECK TO STRAIN. I CAME HOME AND CHECKED AND LEARNED THAT CHEVROLET HAD A RECALL NOTICE FOR SOME 2009 MALIBUS, BUT OUR CAR WAS NOT INCLUDED. IT SEEMS STRANGE THAT CHEVROLET DID NOT INCLUDE ALL 2009 MALIBUS. *TR
Steering, Mar 6, 2015
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. WHILE DRIVING AT 15 MPH, THE STEERING WHEEL SEIZED AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE POWER STEERING SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.
Steering, Mar 5, 2015
TL*THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO APPLY FORCE TO THE STEERING WHEEL IN ORDER TO TURN THE VEHICLE. THE CONTACT STATED THAT CHECK POWER STEERING WAS DISPLAYED ACROSS THE MESSAGE BOARD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING) BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 135,000.
Steering, Mar 4, 2015
WHILE DRIVING MY 2009 CHEVY MALIBU ON THE HIGHWAY AT 60 MPH MY STEERING FAILED. THERE WAS A WARNING CHIME THEN THE SERVICE ESC/POWER STEERING LIGHT CAME ON AND THE STEERING WAS VERY HARD TO TURN. I WAS ABLE TO PULL ON TO THE SHOULDER. I SHUT THE CAR OFF FOR A FEW MINUTES THEN RESTARTED THE CAR AND THE STEERING WAS WORKING AGAIN. A FEW MILES DOWN THE ROAD IT HAPPENED AGAIN. THIS CONTINUED ALL WEEKEND. IT WAS VERY DANGEROUS DRIVING. I BROUGHT THE CAR TO THE DEALER ON MONDAY TO HAVE IT CHECKED. I WAS TOLD THEY FOUND A FAULTY STEERING COLUMN TORQUE SENSOR AND THE DEALER TOLD ME MY VEHICLE WAS NOT COVERED UNDER THE RECALL. NHTSA CAMPAIGN # 14V153000 BULLETIN 14116 STATES 2008-2009 CHEVY MALIBU BUILT FROM 3/1/08-6/2708 ARE COVERED MY CAR WAS BUILT 8/2008. SO IT WASN'T COVERED. THE BULLETIN SAYS TOR REPLACE THE TORQUE SENSOR ASSEMBLY. THE SAME PART THAT FAILED ON MY CAR. THE GM PART # IS 232310 SENSOR KIT IT COST $216 + $305 FOR LABOR + $149 FOR ALIGNMENT AND TAX FOR A TOTAL OF $746.29. WHICH I'M RESPONSIBLE FOR PAYING. GM IS RECALLING OVER 1.3 MILLION CAR BETWEEN 2005-2010 FOR THE SUDDEN LOSS OF ELECTRIC POWER STEERING (EPS) ASSIST. I BELIEVE ALL MODELS BETWEEN THOSE YEARS SHOULD BE INCLUDED IN THE RECALL. THIS IS A VERY DANGEROUS SITUATION. SOMEONE IS GOING TO GET HURT. I'M AFRAID TO LET MY DAUGHTER DRIVE THIS CAR.
Steering, Electrical system, Electronic stability control (ESC), Mar 3, 2015
ABRUPT POWER-STEERING FAILURE. THE STEERING WHEEL TURNS AND JERKS (SHUTTERS BACK AND FORTH) ON ITS OWN WHILE THE CAR IS AT REST AT A STOPLIGHT OR STOP SIGN. TOOK TO CHEVY DEALER AND THEY ADVISED ME THERE IS A RECALL FOR THIS ISSUE BUT MY VIN AND PART# ARE NOT INCLUDED AS OF NOW. DEALER TOLD ME IT IS DUE TO FAULTY POSITIONING SENSOR PART # 23232310 SENSOR KI. *TR
Steering, Mar 3, 2015
DRIVING DOWN INTERSTATE AND THE POWER STEERING JUST QUIT. FOUGHT IT ACROSS TWO LANES AND MANAGED TO PULL OFF TO SIDE OF ROAD I HAD NO POWER ASSIST AT ALL. TURNED THE ENGINE OFF WAITED A FEW MINUTES AND STARTED BACK UP POWER STEERING WAS FINE. DROVE FEW MILES DOWN INTERSTATE LOST THE POWER STEERING AGAIN. I COULD GET OFF ROAD TURN OFF CAR AND START BACK UP AND POWER STEERING WOULD WORK FOR WHILE MANAGED TO GET HOME AND HAVEN'T DRIVEN SINCE. I LOOKED UP AND FOUND THERE IS A RECALL ON CERTAIN 2009 MALIBU YOUR CAMPAIGN NUMBER 14V153000 AND MY CAR IS DOING EXACTLY WHAT THAT RECALL DESCRIBES BUT LOCAL CHEVY DEALER SAID THEY COULDN'T REPAIR UNDER THAT CAMPAIGN BECAUSE MY VIN NUMBER ([XXX] DOESN'T SHOW UP WITH A RECALL FOR POWER STEERING. DRIVING DOWN THE INTERSTATE AT 70 MPH AND HAVING YOU POWER STEERING GO OUT IS A MAJOR SAFETY CONCERN AND LIKE I SAID ITS EXACTLY WHAT YOUR CAMPAIGN DESCRIBES. PLEASE HELP INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Steering, Electronic stability control (ESC), Mar 2, 2015
WHILE DRIVING DOWN THE HIGHWAY AT 60MPH AT APPROXIMATELY 8PM ON FEB 26, MY STEERING WHEEL BEGAN TO VIBRATE AND THEN THE DRIVER INFO DISPLAY PANEL SHOWED POWER STEERING AND SERVICE ESC. I THEN LOST ALL POWER STEERING IN MY VEHICLE. THIS MADE IT EXTREMELY DIFFICULT TO STEER AND OPERATE SAFELY. LUCKILY I WAS ABLE TO GET THE VEHICLE OFF THE HIGHWAY SAFELY. THE NEXT DAY, I TOOK THE VEHICLE TO MY DEALER AND WAS TOLD THAT THE POWER STEERING TORQUE SENSOR NEEDS REPLACED. I DID RESEARCH AND DISCOVERED THAT A SIMILAR RECALL WAS ISSUED FOR THE ELECTRONIC POWER STEERING ON 2009 MALIBU'S , BUT MY VIN WAS NOT INCLUDED IN THE RECALL. I AM UNCLEAR AS TO WHY. I CONTACTED GM/CHEVROLET AND WAS TOLD I AM NOT COVERED AND AM NOW HOLDING A BILL FOR ALMOST $600. I WAS SHOCKED TO LEARN THAT MY VEHICLE WAS NOT COVERED. ADDITIONALLY, I WAS NOT EVEN AWARE THAT MY VEHICLE DID NOT HAVE HYDRAULIC POWER STEERING. *TR
Steering, Mar 2, 2015
TL* THE CONTACT OWNS A 2009 CHEVROLET MALIBU. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE EPS WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE TORQUE SENSOR ASSEMBLY FAILED AND NEEDED TO BE REPLACED. THE DEALER VERIFIED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). HOWEVER, THE CONTACT HAD EXPERIENCED THE SAME FAILURE AND REQUIRED THE EXACT REPAIR COVERED UNDER THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 91,000.