2011 Chevrolet Malibu
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 978 owner complaints filed for this model year. This is the 8th highest complaint count among 26 Malibu model years with reports.
Of the 2011 reports, 40 involved a crash and 17 involved a fire. 41 people were injured.
What owners report most often
Recalls and investigations
Air bags, frontal, driver side, inflator moduleJan 16, 2019
General Motors LLC (GM) is recalling certain 2010-2011 Chevrolet Malibu vehicles. In the event of a crash necessitating deployment of the driver frontal air bag, the air bag inflator may explode due to being overpressurized.
If the inflator explodes, sharp metal fragments may strike the driver or other occupants resulting in serious injury or death.
GM has notified owners, and dealers will replace the front driver air bag module, free of charge. The recall began February 25, 2019. Owners may contact GM customer service at 1-800-522-9559. GM's number for this recall is N182206630.
Campaign 19V019000 on NHTSA.gov
Seat beltsMay 8, 2015
General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.
If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.
GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.
Campaign 15V269000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Representative owner complaints
978 reports, newest first.
Steering, Nov 3, 2023
The contact owns a 2011 Chevrolet Malibu. The contact stated while driving 40 MPH, the steering wheel pulled to the left independently. The contact pulled to the side of the road and restarted the vehicle. The steering control warning light was illuminated after the vehicle was restarted. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the failure was due to a faulty electronic steering assist motor. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 91,000.
Steering, Oct 27, 2023
Torque sensor and my steering column and as I did research GM new that it was faulty
Exterior lighting, May 29, 2023
I purchased this 2011 Cheverolet Malibu brand new. A few years prior to me giving it to my daughter, I had to get the headlights replaced several times, one would go out a month or so after I had the other one fixed. I gave it to her in 2019 and lately every other week one or even BOTH of the front headlights have gone out. Also, the third brake lamp randomly goes out and now one of the rear brake lamps has gone out. There’s already over 100 complaints about these issues with this particular model but GM has yet to do a recall! WHY?? It’s clearly an issue with the vehicle and the fact that the ENTIRE front bumper has to come off to get to it is the dumbest thing I’ve ever seen!!! Headlights, of all things, randomly going out on a vehicle is not safe at all! There are people out here who have children in these faulty vehicles and clearly neither GM nor the NHTSA cares. What is it going to take for someone to do something about this, deaths???
Exterior lighting, Seat belts, May 15, 2023
Driverside Airbag light will come on with Service Airbag message. This does occasionally turn off but comes back for days or weeks at a time. Driver side seatbelt light will randomly come on and stay on or turn off. Both airbag and seatbelt light may be on at the same time. If they are all off or the airbag light turns off it's only for a day or two. Most of the time it will be the airbag light only that is on and tends to stay on longer than seatbelt light.
Electrical system, May 7, 2023
It started out as a minor intermittent problem, alerting that I need to service traction and service esc. When this problem occurs, the car hesitates to accelerate from stop. Problem has gotten to the point that the vehicle is trying to die when idling for more than a minute or so and is struggling to accelerate. From doing research, I have found that this problem is very common in this Make and Model, with years varying. This is an issue that needs to be addressed as many people have experienced this and filed complaints and are spending lots of money out of pocket to try to find the issue.
Steering, Apr 21, 2023
While driving, my vehicle will abruptly lose power steering and the wheel will lock up. I am unable to turn my steering wheel. I have to stop my vehicle and turn off the ignition in order to the power steering to work properly. This only last for a few minutes and then it will happen again. This is dangerous and I have had to pull over on the highway to stop and start my vehicle. This first happened in March 2023. Also, my vehicles shows a SVC notification on the dashboard. And the tire pressure sensor is always on even with inflated tires. Lastly, my auto start does not work.
Steering, Apr 9, 2023
Power steering keeps failing. Steering wheel shakes. Power steering light with the ESC Service light come on. If I turn the vehicle off and back on again, Sometimes the power steering will work again.
Exterior lighting, Vehicle speed control, Electronic stability control (ESC), Mar 21, 2023
The contact owns a 2011 Chevrolet Malibu. The vehicle was previously serviced under NHTSA Campaign Number: 14V252000 (Electrical System, Exterior Lighting, Vehicle Speed Control, Electronic Stability Control). The contact stated that on various occasions while driving at various speeds, the traction control and power steering disengaged independently as the "Reduced Engine Power" warning message was displayed and the vehicle decelerated to 10 MPH. The contact also stated that the brake lights flickered intermittently without depressing the brake pedal. The vehicle was taken to an independent mechanic, where it was diagnosed that the intake camshaft actuator, mass air flow, and manifold absolute pressure (MAP) sensors needed to be replaced. The vehicle was repaired; however, the failure recurred. The manufacturer was not made aware of the failure. The approximate failure mileage was 168,000.
Visibility/wiper, Mar 11, 2023
Sudden and complete loss of windshield wipers while on the interstate in a intense rain storm. Driving the vehicle became impossible and stopping on the shoulder was dangerous because other drivers were dealing with poor vision because of the intense rain and came close to hitting me several times. THIS IS A LIFE THREATENING CONDITION. My research found that this is not an isolated problem as multiple years and models (vans as well cars) are affected. The cause of the failure was caused by failure of the windshield wiper transmission, linkage and bushing that a part of or attached thereto.
Electrical system, Air bags, Mar 11, 2023
Air bag, supplemental restraint system failure caused by a faulty electrical connector under the driver's seat. GM is aware of this issue and may have issued a TSB. A recall and repair at GM's expense would be a better way to address this issue as some people might not be willing or able to pay for the one hundred plus dollars repair cost and continue to drive the car with repairing the supplemental restraint system.
Steering, Mar 2, 2023
The power steering light came on on my car after driving on the highway. Pulled over turn car off and on then sign went away. Two days later the power steering and esc light came on and then it went away. Took it to Holm dealership and they requested I change the outer tie rods and lower control arms. Made them changes and the power steering still twitches. This can be a deadly situation if this aint figure out. I don't feel like I should pay all these fees to try to figure the cause of this. Everything I read come up with this electrical power steering sensor.
Steering, Mar 2, 2023
The contact owns a 2011 Chevrolet Malibu. The contact stated while driving at an undisclosed speed, the vehicle inadvertently stopped without depressing the brake pedal. Additionally, the contact stated that while making a sharp left or right turn, the vehicle stalled. The contact was able to restart the vehicle. The power steering assist warning light, the check engine warning light, the ESC warning light, and the traction control warning light was illuminated. The vehicle was taken to Napa Auto Parts to be diagnosed. The contact was informed that the power steering pump needed to be replaced. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 200,000.
Seat belts, Feb 28, 2023
The contact owns a 2011 Chevrolet Malibu. The contact stated that the driver’s side seat belt lap strap had separated from the floor anchor bolt. The contact stated that the lap belt failed to properly restrain the driver while seated. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure and informed the contact that the vehicle was previously serviced under NHTSA Campaign Number: 15V269000 (Seat Belts). The contact stated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 66,800.
Steering, Structure, Feb 11, 2023
I have bought multiple Chevy Malibu manufactured in the 2008-2012 year range and I have experienced the same problems on all of them. The first one is almost everytime I remotely start the car and begin to drive the electric power steering feature goes out until I park the car and restart it. Another problem I’ve been experiencing is the the passenger door malfunctions and does not open from The inside or outside even though the locking system is working properly. Upon looking online I have also seen there’s been a good amount of people reporting the same problem
Steering, Feb 10, 2023
The contact owns a 2011 Chevrolet Malibu. The contact stated while driving 35 MPH, the steering wheel started to jerk. The contact stated that the electric stability control (ESC) off warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the electrical pump to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 179,000.
Steering, Electrical system, Feb 6, 2023
I was driving on 2/5/23 when my car started making a ding sound and the steering wheel locked up. This begin on 1/20/23. There has been 4 incidents with the steering locked while driving. Once results in someone almost getting hit on the side walk as I was turning in the back parking lot. Twice turning left on to my street and once driving around a curve almost hit another car in the other lane.
Steering, Jan 25, 2023
The contact owns a 2011 Chevrolet Malibu. The contact stated that upon starting the vehicle, the power steering assist intermittently failed to operate as needed. The contact also stated that the check engine warning light illuminated. The dealer was notified of the failure and informed him that a diagnostic test needed to be performed to determine the cause of the failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 135,000.
Steering, Jan 13, 2023
The contact owns a 2011 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. The contact self-diagnosed the vehicle as having a steering torque sensor failure. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 182,000.
Steering, Electrical system, Jan 10, 2023
2011 Malibu LS 2.4 power steering keeps going out. Service ESC and traction control keep coming on. Very dangerous
Power train, Electrical system, Wheels, Dec 29, 2022
to begin with CD player stopped working the service tire light stays on the seat adjuster went out this is used to support your back while driving while driving on a residential road the car would not go in drive. The car just suddenly stopped while in drive. It goes in reverse and stays in park but the other gears do not work. It was a good thing that I was on a residential road and not the freeway. I keep having to repair the headlights left and right they keep burning out for some reason. Gets frustrating. And I have been pulled over for a burned headlight but the officer was aware the the make and model of my car have defects with headlights. He didn't site me but said to get it fixed.
Steering, Electrical system, Dec 26, 2022
Power steering failed and locked up the steering wheel. Had to stop car mid road to restart car. Car no longer has any power steering. This is a very dangerous issue!
Steering, Nov 30, 2022
Power steering fails when driving. Upon restart of the vehicle, power steering comes back and will go off randomly at a later point. Symptom is felt more frequently at lower speeds and less often at high speeds, but still happens. My car is available upon request for inspection. My safety and other's safety was put at risk because it occurred a few times while driving on highways. The problem has not been reproduced or confirmed by a dealer or independent service center because I refuse to pay out of pocket for an issue that should be covered under a recall. However, a quick YouTube search will show that the symptom is wide spread and the public is not aware that it is a known issue to GM. There were no warning lamps, messages or other symptoms of the problem prior to the failure. Symptoms have been identified as part of a GM Special Coverage 15356. The issue is that mass dissemination of this information has not reached the public. Owners of this vehicle, who are now just experiencing this issue, are not included in the special coverage because it expired at 150,000 or May 10, 2021. As an active duty service member, if any letters were sent, they were delivered to my home address and not my physical address, therefore if any attempt was made to contact me or my family would have been futile. Just like many consumers, I only track recalls and not special coverages.
Power train, Engine, Nov 24, 2022, crash
My timing belt snapped which broke my gaskets and messed messed up my engine.
Exterior lighting, Sep 28, 2022
Headlights fail. I have had to replace my headlights several times. I have also had to replace the entire headlight assembly.
Steering, Sep 20, 2022
The contact owns a 2011 Chevrolet Malibu. The contact stated while driving at 5 MPH and making a turn, the steering wheel felt loose and unstable. There was no warning light illuminated. The contact stated that failure had been reoccurring increasingly. The contact associated the failure with NHTSA Campaign Number: 14E044000 (Steering). An unknown dealer was made aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 86,000.