2012 Chevrolet Malibu
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 906 owner complaints filed for this model year. This is the 11th highest complaint count among 26 Malibu model years with reports.
Of the 2012 reports, 50 involved a crash and 13 involved a fire. 35 people were injured.
What owners report most often
Recalls and investigations
Seat beltsMay 8, 2015
General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.
If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.
GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.
Campaign 15V269000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Representative owner complaints: electrical system
290 reports, newest first. Show all
Electrical system, Jul 22, 2026
Electrical system problems that create unsafe driving conditions!! Vehicle has electrical glitches. Internal warning lights flicker on and off. Battery drains. Car randomly will not start. Multiple incidents. Car stalled on roadway without warning and would not crank. Luckily I was in a residential neighborhood with little to no traffic when this happened. I have had crank sensors replaced, fuel pump module replaced, fuses replaced and still problems occur. If this is a common issue with the 2012 Chevrolet Malibu, could you please issue a safety recall? Thank you
Electrical system, Mar 26, 2026
Rear defrost stopped working. Hasn't worked in years. I took it to GM, they had a print out of a kit that I had to purchase to repair. This stopped working back around 2016.
Electrical system, Exterior lighting, Vehicle speed control, Feb 22, 2026
Was driving home on the parkway and the headlights shut off on their own had to call for roadside assistance to get my vehicle home they will work on dim but brights will not work and if I drive for more than an hour and a half they will not work at all the speed sensor keeps going bad after having it replaced multiple times
Electrical system, Vehicle speed control, Electronic stability control (ESC), Jul 25, 2025
The contact owns a 2012 Chevrolet Malibu. The contact stated that while driving approximately 60 MPH and following a slight right turn on the highway, the ESC warning illuminated, and the vehicle slowed down without the brake pedal being depressed. The failure was intermittent but became a recurring failure. The contact stated that the vehicle also slowed down unintentionally while making a left or right turn at slow speeds. The contact stated that in the middle of the turn, the vehicle slowed to a stop without the brake pedal being depressed. The ESC warning light illuminated while the vehicle was still in drive(D) and running. The vehicle came to a stop, and the accelerator pedal was depressed, and the vehicle continued driving. The vehicle was taken to a local dealer and was diagnosed with PSCM failure. The vehicle was repaired; however, the failure reoccurred. The vehicle was not taken back to the dealer. The contact researched online and related the failure to NHTSA Campaign Number: 14V252000 (Electrical System, Exterior Lighting, Vehicle Speed Control, Electronic Stability Control (ESC). The manufacturer was not informed of the failure. The failure mileage was approximately 166,000.
Electrical system, Jun 1, 2025
Rear windowed defroster suddenly start working upon inspection the rear electrical block that's inside the trunk had melted in the fuse to the defroster had gotten stuck and went on pulling it out it broke and after looking up complaints it seems to be an issue with Malibu and it could cause a fire but GM is doing nothing about it you have to pay for it yourself they released a bulletin to bypass the block but you have to install a whole new block which costs hundreds of dollars
Electrical system, Exterior lighting, Jun 1, 2025
Passenger side headlamp burned out took off bumper to inspect and the wiring pigtail to the headlight has melted causing it to malfunction so now in order to make it work you have to disconnect the daytime running lights so that the melting stops this is supposedly happened to a lot of Malibu's why there isn't a recall on this fire hazard is beyond me and it is a safety issue cuz you can't use your daytime running lights any longer. This issue has not been reported because upon investigation it's been reported many times and nothing gets done about it you have to pay for it yourself. This will be the last GM product.
Steering, Electrical system, Wheels, Mar 26, 2025
The power steering assist has cause the steering wheel to move to its let by its self when not holding the steering wheel. I must hold the steering wheel firmly to keep it strait when driving. If i would let go the car will abruptly turn left and possibly drive off the road or hit a car, pedestrian, or whatever is in the way. It started with uncontrolled vibrating at a stand still motion. The car is 165,000 miles that's 15,000 miles from the recall. The car has been repaired a couple times I think only to have the same power steering assist internal parts break down and fail multiple times. I believe the amount of power (amps) the power steering assist draws is needed is to much and the system fails within a short time. The alternative hydraulic version on the V 6 doesn't put so much stress on the electrical system. This could be also why the headlights bulb sockets melt and why I see a 15 volt constant charge is being created from the charging system. Ruining the alternator and battery. Putting high levels of amps on the wiring. Leading to malfunctioning components that is filed for complaints. A major safety hazard for others. Fires and uncontrolled crash since the power steering assist moves the car into dangerous life threating crashes.
Electrical system, Exterior lighting, Visibility/wiper, Mar 8, 2025, fire
Passenger and or driver side low beam headlight continues to go out. Mechanic has found connector keeps burning out the socket. Light is burnt out on bott sides. but connector is shorting out. Fire and safety issue. This issue is on a lot of chevrolet malibus and needs a recall initiated to correct these issues. I keep getting pulled over due to need to us high beams and not having low beams. This is reoccurring and getting expensive to be done over and over.
Steering, Electrical system, Mar 4, 2025
Loss of power steering assist while driving. Safety issue puts driver and others at risk. Problem confirmed to be known by dealer service bulletin 15356. Special coverage has expired however many vehicles with issue still on the road. ESC light accompanies failure, restarting the vehicle resets system and allows function for short period until loss of steering while moving occurs again. Request GM extend the special coverage to all vehicles still in service or recall.
Electrical system, Jan 8, 2025
The contact owns a 2012 Chevrolet Malibu. The contact stated while driving at 40 MPH the traction warning illuminated. The contact stated that the ABS and the traction control were disabled. The contact stated that the failure was occurring at any speed. Additionally, the contact stated that the brake lights were randomly illuminating when he depressed the brake pedal. The contact stated that he had to depress the brake pedal with force for the brake lights to illuminate. The contact had taken the vehicle to an independent mechanic was diagnosed and determined that the vehicle needed to have all four brake pads and rotors replaced and two front tires replaced. The vehicle was repaired, however, the failure reoccurred. The manufacturer was not informed of the failure. The failure mileage was approximately 103,000.
Electrical system, Exterior lighting, Jan 7, 2025, fire
Passenger and or driver side low beam headlight continues to go out. Mechanic has found connector keeps burning out the socket. Light is fine but connector is shorting out. Fire and safety issue. This issue is on a lot of chevrolet malibu and needs a recall fix.
Electrical system, Seat belts, Other or unspecified, Oct 13, 2024
First, there is a problem with the transmission. The car will stall or stop abruptly while driving. Second, the automatic turn signals do not work. Third, the driver safety belt does tightly secure the driver.
Electrical system, Exterior lighting, Sep 16, 2024
The front exterior low beam bulbs / wiring harness keeps burning out. I have replaced them twice already and they have blown again. What is going on already a headache just to even get to the headlights, now have to spend MORE money to repair.
Electrical system, Exterior lighting, Aug 1, 2024
The headlights keep.going out. I've replaced everything amd it keeps happening and it's not easy to even get to the headlight. This is a hazard as my 16 year old drives this car. We fix it and then it's out all.over again. This has to be a recall as I've done some research and im.not the only one with this problem. We've been pulled over and we just explained our frustration and they've been nice enough to send us on our way.
Power train, Electrical system, Engine, Jul 13, 2024
For 4 years the car intermittently would turn on all warning lights, shake, become hard to steer and steer in unintended directions. We paid $1500 for the dealer to fix it and we still had the problem. Today, the car will drive less then a mile and die. When we start the car all warning lights come on, the vehicle vibrates and struggles to keep speed of 5 mph or so then will die.
Electrical system, Exterior lighting, Jul 12, 2024
Electrical problem causing the passenger side low beam to keep burning out. Fourth time in one year. Vehicle is available for inspection upon request. This issue causes a safety concern because you can be driving down the highway at night and all of a sudden you have no headlight.
Power train, Electrical system, Engine, Jun 10, 2024
Driving down the freeway and suddenly I get reduce engine power. I had to wait on the freeway until the car started up again
Electrical system, Fuel/propulsion system, Feb 19, 2024
Vehicle will intermittently not start, have to tap on trunk fuse box to get the Malibu to start, the wire is too small and burns up, can’t find anyone to replace it, is a big issue with this generation of Malibu. Vehicle has shut off while on highways and stoplights on MULTIPLE occasions
Electrical system, Exterior lighting, Feb 13, 2024
My brake lights constantly go out. My fuses keep blowing. Every time I try to adjust my mirrors the fuses blow for the mirrors and brake lights. Also my headlights keep blowing and the headlight harness has been changed and everything. It is very dangerous not having brake lights, or being able to adjust my mirrors.
Electrical system, Jan 29, 2024
The wiring to the fuel pump overheated and burned at the rear fuse box located in the trunk, melting the harness connector and charring the fuse box circuit board. This caused the vehicle to stop running. Luckily, it happened while idling and did not start a fire. This wire goes to the fuel tank and the fuse did not blow. The 30A fuse for the RR DEFOG was also burnt and not blown.There were no warnings or engine codes. After researching this online, it appears it is a common problem. This is the second time this happened. It also happened in 2017 with approximately 89,200 miles.
Electrical system, Exterior lighting, Oct 25, 2023
The brakes light keep going out they won’t blink the won’t turn on fuses are blowing
Electrical system, Aug 27, 2023
Since day one the ESC - Electronic Stability Control has constantly affected the performance of the car. The car is not able to reach its full power and causes sudden speed changes . This has happened for a long time with no fix
Steering, Electrical system, Jul 28, 2023
While I was making a right turn, I experienced a sudden loss of steering, the steering wheel became completely stiff and almost imposible to maneuver. The panel message was Service EPS and ESC off. According to information in this website, there was a special warranty extension, which expired on 2022, which covered this specific issue (the problem is related to the electric power steering assist (EPS), the steering column torque sensor or the EPS motor/controller). The special warranty code was 15356. I have taken my car to the dealership in the past for maintenance and other safety recalls, but I was not alerted about this very dangerous issue. I called GM today, and they said I was not alerted because this was not a recall but an extended warranty. This sounds like a lack of due diligence on GM´s end to address an issue that is extremely dangerous. I am now afraid to drive this car.
Electrical system, Exterior lighting, Jul 28, 2023, fire
Passenger headlight caught fire while driving
Electrical system, Exterior lighting, Jun 25, 2023
Passenger side low beam headlight wont work. Replace fuses relays and wiring harness. Ive read online where this is very common with these cars and even replacing the headlight assembky isnt a sure fix.