2012 Chevrolet Malibu
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 906 owner complaints filed for this model year. This is the 11th highest complaint count among 26 Malibu model years with reports.
Of the 2012 reports, 50 involved a crash and 13 involved a fire. 35 people were injured.
What owners report most often
Recalls and investigations
Seat beltsMay 8, 2015
General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.
If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.
GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.
Campaign 15V269000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Representative owner complaints: electrical system
290 reports, newest first. Show all
Electrical system, Fuel/propulsion system, Sep 5, 2019
GOT THE CAR FEW MONTHS AGO , CAR ONE DAY WOULDN'T START COULDN'T FIGURE OUT FINALLY FIGURED IT OUT, THE FUSE BOX IN MY TRUCK I CAN HIT IT AND THEN MY CAR STARTED JUST FINE IT HAPPENS ALOT TO WHERE I GOTTA HIT THE FUSE BOX IN MY TRUCK TO GET MY CAR STARTED THOUGHT IT WAS THE CRANK SENSOR BUT NOPE IT HAS SOMETHING TO DO WITH THE FUSE BOX IN THE TRUCK & ALSO HEARD IT'S THE FUEL PUMP RELAY.
Electrical system, Fuel/propulsion system, Sep 3, 2019
I HAVE A 2012 CHEVY MALIBU LT AND AT RANDOM TIMES THE CAR WILL SHUT DOWN, WHILE DRIVING, WHILE BEING STATIONARY, AND SOMETIMES IT DON'T EVEN START WHEN IT'S BEEN OFF I TOOK IT TO MULTIPLE MECHANICS AND THEY COULDN'T DETECT ANY CODES OR SEEM TO FIND THE PROBLEM THEY CHANGED THE FUEL PUMP, THE FUEL PUMP RELAY, THE FUSE, THE ECM STARTER IGNITION COIL, BATTERY, ALTERNATOR AND THE CAR STILL DOESN'T START RANDOMLY I HAVE TO TURN THE CAR TO THE ON POSITION THEN OFF MORE THAN 30 TIMES AND WAIT UNTIL I HEAR THE FUEL PUMP ACTIVATE THEN I KNOW IT WILL START I HAVE HAD THE CAR CUT OFF ON ME ON THE FREEWAY, IN THE MIDDLE OF MALIK A TURN ON BUSY STREETS I'VE BEEN OUT AT FAMILY EVENTS AND WHEN I TRIED TO GO HOME THE CAR WOULDN'T START I NEED HELP
Electrical system, Seats, Engine, Aug 28, 2019
THE SERVICE ENGINE LIGHT HAS BEEN ON FOR 3 YEARS. CHEVY HAS BEEN UNABLE TO DIAGNOSE THE ISSUE DESPITE CHANGING OUT THE SENSORS AND CLEARING THE CODES. THIS EFFECTS THE REST OF THE ENGINE SETTINGS INCLUDING FUEL AS IT ADJUSTS THEM BASED ON A DEFAULT. THE RAIL SUPPORT FOR THE DRIVER'S SEAT HAS ALSO BROKEN LOOSE AND FALLEN DOWN WHICH MAKES THE VEHICLE UNSAFE TO DRIVE. THIS SEAT ISSUE WAS ONLY NOTICE EARLIER THIS YEAR.
Electrical system, Exterior lighting, Electronic stability control (ESC), Aug 22, 2019, crash
CFDL7KTJ TNN YNYBYNYMBYRCRCRCRCRCRYVNUJYCDDEYHYBDEVGYVTU62O6AFNTSJTANTAJATNRHDHRJRMSTMZVSG NO RAHSFJSYKTASGKYSKYWJWYJGSNTABRAGARHYSKTAJTANTKSYJFSMYSKTAJFANTQHETQRKYWKTANSGKYWHSGNFAHTWK6SRJTAJTSJWTJTWJ51U5WJTWJTWJTWJWTNWTNWTNTW
Electrical system, Electronic stability control (ESC), Fuel/propulsion system, Aug 19, 2019
MY CAR WILL RANDOMLY NOT START. I HAVE BOUGHT A BRAND NEW BATTERY. THAT WASN'T THE PROBLEM. A WEEK LATER, MY GEAR SHIFT WOULDN'T MOVE. I HAD TO STAY IN MY VEHICLE AND MISS AN APPOINTMENT BECAUSE OF THIS. I COULDN'T GET IT TO MOVE FROM DRIVE TO PARK. AFTER SEVERAL TRIES AND 30 MINUTES, IT FINALLY MOVED. IT'S GOTTEN STUCK A FEW TIMES TRYING TO MOVE IT FROM PARK TO DRIVE AS WELL. AND WHEN I'M DRIVING, THE EMERGENCY LIGHTS WILL RANDOMLY ILLUMINATE AND WIPERS WON'T WORK. I WAS DRIVING WHEN IT WAS POURING RAIN AND THE WIPERS WOULDN'T TURN ON WITH ALL EMERGENCY LIGHTS ILLUMINATED AS WELL. THIS CAN HAPPEN ANYTIME I'M ON A CITY STREET GOING FROM 25 TO 45 MPH. I HAVE HAD TO HAVE IT TOWED SEVERAL TIMES TO DIFFERENT SHOPS AND THEY CAN'T TELL ME WHAT'S WRONG.
Electrical system, Air bags, Aug 16, 2019
WHEN TURNING ON THE CAR AND WHEN DRIVING A MESSAGE COMES UP SAYING "SERVICE AIR BAG". THE CLOCK TURNS TO MILITARY TIME WITHOUT US CHANGING IT. SEAT BELTS SIGN COMES WHEN SEAT BELTS ARE BEING USED. POOR PERFORMANCE.
Electrical system, Other or unspecified, Fuel/propulsion system, Aug 13, 2019
MY CAR WON'T TURN OVER AFTER I TURN IT OFF SOMETIMES. SOMETIMES IT WILL BE MOST OTHER TIMES IT DOESN'T. THE BATTERY IS NEW, SPARK PLUGS ARE NEW, SENSORS ARE NEW. STARTER ISN'T THE PROBLEM. DON'T KNOW WHAT IT COULD BE? IT WAS STATIONARY WHEN THIS HAPPENS, WHEN I TRY TO TURN THE CAR BACK ON.
Electrical system, Aug 11, 2019
THE FUSE BOX IN TRUNK OF CAR HAS A SHORT IN THE WIRE AND IT IS CAUSING A BURNING SMELL. THE VEHICLE DOESN'T START HALF OF THE TIME AND WHEN IT DOES START, THE CAR WILL STALL OUT OR COMPLETELY SHUT DOWN WITHOUT WARNING. THIS IS UNSAFE ESPECIALLY IN TRAFFIC WITH THE KIDS.
Electrical system, Exterior lighting, Electronic stability control (ESC), Aug 10, 2019
AT 1ST MY CAR WOULDN'T CRANK EVERY SO OFTEN THEN STARTED GOING DRAG WHILE DRIVING I GOOGLED IT AND HAD TO BEAT ON FUSEBOX IN TRUNK OR WIGGLE WIRES SO HAD TO RUN WIRE STRAIGHT TO BATTERY TO FUEL PUMP. MY HEADLIGHTS ON DIM KEEP SHOOTING AND MY SPEAKERS WILL GO OUT SOMETIMES
Electrical system, Engine, Fuel/propulsion system, Jul 29, 2019
WAS DRIVING AND MY CAR STOPPED ACCELERATING. I PUSHED ON THE GAS AND IT WOULD NOT GO. I WAS ON THE FREE WAY AND ALMOST HAD AN ACCIDENT. ALSO CAR WOULD NO LONGER START AFTER STOPPED. WOULD ACT LIKE IT WAS GOING TO START AND DOES NOT. I'VE HAD SEVERAL TOES WITH MY CHILDREN IN THE VEHICLE. A HUGE SAFETY CONCERN.
Electrical system, Exterior lighting, Service brakes, Jul 29, 2019
TAKATA RECALL WHEN I'M DRIVING MY VEHICLE, THE HEADLIGHTS FLICKER AS IF I'M THE POLICE. I TOOK IT TO FIRESTONE AND THEY TOLD ME TO TAKE IT TO A DEALER THE CAR ONLY HAS 160,000+ AND IT JUST STARTED EVERY TIME I ACCELERATE OR DRIVE IT DOES THIS AND I'M AFRAID THAT I WILL EITHER GET PULLED OVER BY THE POLICE, HIT SOMEONE OR SOMEONE HITS ME OR/AND THE LIGHTS GO COMPLETELY OUT WHILE DRIVING AT NIGHT. IS THIS DUE BECAUSE WHENEVER YOU HAVE TO CHANGE THE BUILD, THE WHOLE BUMPER HAS TO COME OFF TO REPLACE IT? I LIKE MY CAR BUT THIS IS A SERIOUS ISSUE THAT NEEDS TO BE ADDRESSED. I SEE A LOT OF COMPLAINTS REGARDING THIS
Electrical system, Air bags, Seat belts, Jul 19, 2019
MY CAR WOULDN'T CRANK THEN IT WOULD CRANK. TILL I WAS DRIVING DOWN THE ROAD AND IT JUST DIED ON ME GOING AROUND A CURVE LOST CONTROL OF STEERING AND BRAKES THANK GOD I DIDN'T WRECK SO I GOT IN LINE AND RESEARCHED AND COME TO FIND OUT THAT IT WAS SOMETHING TO DO WITH FUEL PUMP RELAY CONNECTION TO FUEL PUMP RELAY BOX. THE WIRES AWARE TOO LITTLE VOLTAGE FOR THE FUEL PUMP AND BURNT WIRES TO FUEL PUMP RELAY BOX. I SEE THAT THERE ARE A LOT OF COMPLAINTS ON SAME CAR AS LINE. SO I'M FILING A COMPLAINT CUASE THIS IS VERY DANGEROUS.
Electrical system, Jul 15, 2019
2012 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO NHTSA SAFETY RECALL 14V-252. *LD THE CONSUMER STATED AFTER THE VEHICLE WAS REPAIRED UNDER THE RECALL, THE FAILURE RECURRED. * JS
Electrical system, Jul 13, 2019
I HAVE A 2012 CHEVY MALIBU AND SINCE NOVEMBER WE HAVE HAD HEADLIGHT PROBLEMS AND CHANGES BULBS AND GOT A NEW WIRE HARNESS AND WE STILL HAVE PROBLEMS WITH PASSENGER SIDE LOW BEAM LIGHT GOING OUT. IT IS A REAL PAIN CAUSE IT TAKES A BIT TO EVEN GET TO THE HEADLIGHT. HAVE TO TAKE THE BUMBER OFF AND REAL FRUSTRATING.
Electrical system, Exterior lighting, Jul 8, 2019
PASSENGER HEAD LIGHT HAS BEEN REPLACED SEVERAL TIMES IT KEEPS TURNING OFF. LIGHT BULB IS NOT BURNED. WHEN TAPING ON OR MOVING WIRES LIGHT GOES ON REPLACED WIRES AND STILL HAVING SAME ISSUE. VEHICLE CAN NOT BE DRIVEN AT NIGHT TIME. ALL THIS HAPPENS WHEN VEHICLE IS TURNED ON.
Power train, Electrical system, Electronic stability control (ESC), Jul 3, 2019
TAKATA RECALL WHEN MY VEHICLE STARTED HAVING ISSUES IT STARTED WITH LAGGING TO START I WOULD TURN THE KEY AND LITERALLY LET GO AND THEN IT WOULD START. NOW IT'S TO THE POINT WHERE IT DOESN'T ALWAYS WANT TO START . WHEN IT DOES MY SENSORS ARE ALL MESSED UP . FIRST TIME MY AIRBAG WARNING WAS COMING UP . NEXT MY SENSORS ON MY TIRES WERE NOT WORKING THEN I STARTED TO NOTICE WHEN I WAS DRIVING AND I WOULD STOP PUSHING THE GAS THE GAUGE WILL GO UP AND DOWN. THE LAST THING THAT HAPPENED WAS THE CHECK ENGINE CAME ON BUT TURNED OFF. I TRIED TO GET A DIAGNOSTICS DONE BUT OF COURSE NOTHING CAME OF IT . SO NOW MY CAR IS JUST SITTING IN MY GARAGE UNTIL I FIGURE IT OUT. BUT THERE ARE NO TYPE OF CHECK ENGINE LIGHT OR ANYTHING THAT COMES ON BEFORE THE CAR STARTS NOT FUNCTIONING PROPERLY
Electrical system, Exterior lighting, Electronic stability control (ESC), Jun 26, 2019
HEAD LIGHTS KEEP GOING OUT
Electrical system, Exterior lighting, Jun 24, 2019
I HAVE REPLACED MY LOW BEAMS 3 TIMES THIS YEAR. THE FIRST TIME I REAPLACED ALL THE BULBS. THE SECOND TIME I REAPLACED BOTH WIRING HARNESS AND BULBS. A MONTH AGO I REPLACED THE PASSENGER BULB AND NOW THE DRIVERS SIDE LOW BEAM IS OUT AGAIN. IT HAS COST ME ANYWHERE FROM $100-$200 EACH TIME TO DO THIS! I ALSO HAVE A PROBLEM WITH MY DASH TELLING ME SERVICE ESC, ESC OFF, AND SERVICE TRACTION. A RECALL IN 2014 ADDRESSES THIS ISSUE AND MY VIN SAYS THE RECALL HAS BEEN SERVICED BUT I AM STILL HAVING THIS ISSUE. IT HAPPENS WITH THE CAR IN PARK AND WHILE DRIVING. SOMETIMES IT STAYS ON FOR HOURS SOMETIMES MINUTES.
Electrical system, Exterior lighting, Jun 24, 2019
HEADLAMP HARNESS KEEPS BURNING CAUSING HEADLAMP TO FAIL TO ILLUMINATE. HAVE REPLACED MULTIPLE BULBS AS WELL AS BOTH HARNESSES WITHIN THE LAST 6 MONTHS AND AGAIN, HARNESS HAS BURNT AND MY LOW BEAM HEADLAMPS DO NOT WORK. READING SIMILAR COMPLAINTS, I BELIEVE IT HAS TO DO WITH THE DAYTIME RUNNING LIGHT FEATURE. I'VE NOTICED THE ISSUE BOTH WHEN THE VEHICLE IS MOVING AND WHEN IT'S STATIONARY. WHILE THERE HASN'T BEEN A FIRE AS A RESULT OF THIS ISSUE YET, I'M SURE IT'S JUST A MATTER OF TIME.
Electrical system, Jun 21, 2019
MY RIGHT SIDE LOW BEAM KEEPS GOING OUT. I HAVE REPLACED THE BULB 5 TIMES THIS YEAR. I'VE REPLACED THE WIRING HARNESSES FOR THE LIGHT BULB. I REALLY DON'T UNDERSTAND WHY THIS KEEPS FALLING
Electrical system, Jun 12, 2019
MY DRIVER SIDE LIGHT CONTINUES TO KEEP GOING OUT AFTER A COUPLE WEEKS AND THE BULB IS NOT BLOWING THIS IS A COMMON PROBLEM WITH THE CHEVY MALIBU DEFINITELY NEEDS TO BE RECALLED AND FIXED BECAUSE IF YOU DON'T HAVE HEADLIGHTS CAN CAUSE A BAD ACCIDENT. IF YOU HIT A BUMP IT GOES OUT. I WAS ON A BACK ROAD AT NIGHT AND BOTH LIGHTS WENT OUT ALMOST CAUSING ME TO CRASH
Electrical system, Exterior lighting, May 16, 2019
REPLACED LOW BEAM LIGHTS MULTIPLE TIMES, HAD THE WIRING HARNESS REPLACED DUE TO A SHORTAGE THAT WAS SUPPOSEDLY LEADING TO THE LOW BEAMS LIGHT BLOWING OUT CONSTANTLY. LOW BEAM LIGHTS STILL KEEP GOING OUT. ONGOING ISSUE
Electrical system, May 7, 2019
TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT THE SPEEDOMETER WAS FAULTY AND WOULD NOT DISPLAY THE CORRECT DATA. PAT O'BRIEN CHEVROLET (3880 PEARL RD, MEDINA, OH 44256, (330) 460-0718) DIAGNOSED THAT THE INSTRUMENT PANEL CLUSTER NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 77,100.
Electrical system, May 2, 2019
WITHOUT WARNING THE CLUSTER OF GAUGES START GOING CRAZY AND ALL WARNING LIGHTS ARE ILLUMINATED ON THE DASHBOARD. THE VEHICLE LOSES POWER STEERING AND VEHICLE SPEED WILL NOT EXCEED 20MPH. EVENTUALLY THE VEHICLE STALLS OUT.
Electrical system, Fuel/propulsion system, May 1, 2019
CAR WOULD TURN OVER BUT NOT CRANK. GO BACK A LITTLE LATER AND IT CRANK FINE. AFTER THIS HAPPENING SEVERAL TIMES HAD SOMEONE TAKE A LOOK AT IT AND THERE WAS NO CODES AND THE CAR WOULD CRANK FINE SO COULDN'T FIND THE PROBLEM. THEN WHEN I WAS OUT SOMEWHERE IT WOULD CRANK AND RUN SLUGGISH AND GO DEAD AND AFTER A WHILE IT WOULD CRANK AND RUN. GOT TO RESEARCHING IT AND PEOPLE HAVING SAME PROBLEM. SAID THAT YOU COULD WIGGLE FUEL PUMP RELAY AND IT WOULD CRANK. SURE ENOUGH TRIED THIS AND IT WORKED. I'M PRETTY SURE THIS IS SAME PROBLEM. AND ALSO IF YOU HAD BEEN RUNNING THE CAR AND IT WOULDNT CRANK THE FUEL PUMP RELAY WILL BE HOT WHICH SUGGEST THE WIRING AND OR FUSE BOX IS PROBLEM. PEOPLE TALK ABOUT REPLACING FUEL PUMP , FUSE BOX , AND CHEAP LOW GAUGE WIRING FROM FUEL PUMP TO FUSE BOX. NOW I'M TAKING TO MECHANIC TO TRY TO GET THIS FIXED BEFORE IT CATCHES FIRE AND SOMEONE GETS HURT . TRY TO GET FIXED AND BUY A HONDA OR ANYTHING EXCEPT GM.