2012 Chevrolet Malibu
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 906 owner complaints filed for this model year. This is the 11th highest complaint count among 26 Malibu model years with reports.
Of the 2012 reports, 50 involved a crash and 13 involved a fire. 35 people were injured.
What owners report most often
Recalls and investigations
Seat beltsMay 8, 2015
General Motors LLC (GM) is recalling certain model year 2011-2012 Chevrolet Malibu vehicles manufactured April 8, 2010, to October 11, 2012. In the affected vehicles, the flexible steel cables that connect the seat belts to the vehicle at the outside of the driver seat and the front passenger seat may be bent from being sat on while entering the vehicle. This repeated bending may result in the cable breaking.
If the cable breaks, the seat occupant may not be properly restrained in the event of a crash, increasing their risk of injury.
GM will notify owners, and dealers will replace the outboard lap anchor mounting bracket and inspect the flexible steel cable, replacing it as necessary, free of charge. The recall began on November 16, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15031.
Campaign 15V269000 on NHTSA.gov
SteeringJul 21, 2014
Dorman Products, Inc. (Dorman) is recalling certain replacement intermediate steering shafts sold under the Dorman, OE Solutions, and Solutions brand names, part numbers 425-167, 2425167, and 7-3074, for installation on 2004-2012 Chevrolet Malibu, 2005-2010 Pontiac G6, and 2007-2009 Saturn Aura vehicles. The affected steering shafts may have a yoke that inadequately supports the u-joint bearing resulting in a premature failure.
A joint bearing that fails prematurely may cause separation of the u-joint resulting in a complete loss of steering control, increasing the risk of a crash.
Dorman will notify owners, and dealers will refund the purchase price or replace the steering shafts, free of charge. The recall began in September 2014. Owners may contact Dorman customer service at 1-800-523-2492.
Campaign 14E044000 on NHTSA.gov
Electrical system, wiringMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Any of the above failure conditions increases the risk of a crash.
GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Campaign 14V252000 on NHTSA.gov
Representative owner complaints
906 reports, newest first.
Vehicle speed control, Electronic stability control (ESC), Aug 27, 2019
THIS HAS HAPPENED MULTIPLE TIMES WHILE DRIVING DOWN THE INTERSTATE. THE CRUISE CONTROL IS BEING USED AND WHEN YOU GO TO APPLY THE BRAKES THE CAR DOES NOT SLOW DOWN BUT REVS THE MOTOR UP AND WILL NOT LET YOU SLOW DOWN. IT IS FRIGHTENING TO HAVE THIS HAPPEN. IF YOU TAP THE BRAKES BUT DOESN'T ALWAYS WORK OR HIT THE CRUISE OFF BUTTON IT WILL FINALLY STOP. THIS COULD BE PUTTING US IN A REALLY BAD SITUATION IF YOU CANT GET IT STOPPED. ALSO THE ESC LIGHT COMES ON FOR NO REASON WHILE DRIVING ON DRY ROADS. I CALLED MY CHEVY DEALER AND WAS TOLD THE RECALL 13036 WAS ALREADY DONE IN AUG 2014 IF THIS IS THE SAME ISSUE AS RECALL. IF SO IT DID NOT TAKE CARE OF THE PROBLEM AND NEEDS TO BE TAKEN CARE OF BEFORE IT COSTS SOMEONE THEIR LIFE.
Exterior lighting, Aug 26, 2019
PASSENGER SIDE HEADLIGHT( LOW BEAM) CONTINUES TO GO OUT AFTER BEING REPLACED SEVERAL TIMES IN A SHORT AMOUNT OF TIME, 2-3 WEEKS.
Electrical system, Exterior lighting, Electronic stability control (ESC), Aug 22, 2019, crash
CFDL7KTJ TNN YNYBYNYMBYRCRCRCRCRCRYVNUJYCDDEYHYBDEVGYVTU62O6AFNTSJTANTAJATNRHDHRJRMSTMZVSG NO RAHSFJSYKTASGKYSKYWJWYJGSNTABRAGARHYSKTAJTANTKSYJFSMYSKTAJFANTQHETQRKYWKTANSGKYWHSGNFAHTWK6SRJTAJTSJWTJTWJ51U5WJTWJTWJTWJWTNWTNWTNTW
Electronic stability control (ESC), Engine, Aug 20, 2019
ONE DAY, DRIVING ON A FREEWAY MY CAR ALL OF A SUDDEN ACCELERATED OUT OF NOWHERE, THEN ON THE DASH SHOWED 'SERVICE ESC' THEN IMMEDIATELY AFTER 'REDUCED ENGINE POWER' AND SHUT OFF. IT WOULD NOT TURN BACK ON AND I WAS ON THE MIDDLE OF THE FREEWAY. I HAD TO HAVE IT TOWED TO A NEARBY SHOP WHILE I WAITED FOR HOURS TO GET THE THROTTLE BODY REPLACED- TOTAL OF $560 AND MY CAR WORKED FOR THE NEXT TWO DAYS THEN DID THE SAME THING, THIS TIME I WAS ON A SIDE STREET SO IT WAS MOSTLY JUST ANNOYING. THIS HAS HAPPENED MORE TIMES THAN I CAN COUNT SINCE I'VE HAD THIS CAR (FOR 6 MONTHS) AND CHEVY DEALERSHIPS WON'T DO ANYTHING WITHOUT CHARGING ME A TON OF MONEY AND I'VE READ HUNDREDS OF OTHER COMPLAINTS ABOUT THE SAME EXACT ISSUE I'M HAVING ONLINE, IN THEIR TESTIMONIES, THEY'VE GOTTEN MULTIPLE THINGS 'FIXED' BECAUSE OF THE CODE THAT SHOWS UP, BUT THEN DAYS LATER IT'S THE SAME FOR EVERY SINGLE ONE, IT REVERTS BACK TO THE ORIGINAL PROBLEM. THIS IS UNACCEPTABLE OF CHEVROLET, AND I'M VERY UPSET THAT I PERSONALLY HAVE PUT SO MUCH MONEY, NOT TO MENTION EVERYONE ELSE THAT HAS, INTO A SEEMINGLY UNSOLVABLE PROBLEM, CAUSED BY A MISTAKE ON CHEVROLET'S PART. PLEASE DO SOMETHING, THANK YOU.
Electrical system, Electronic stability control (ESC), Fuel/propulsion system, Aug 19, 2019
MY CAR WILL RANDOMLY NOT START. I HAVE BOUGHT A BRAND NEW BATTERY. THAT WASN'T THE PROBLEM. A WEEK LATER, MY GEAR SHIFT WOULDN'T MOVE. I HAD TO STAY IN MY VEHICLE AND MISS AN APPOINTMENT BECAUSE OF THIS. I COULDN'T GET IT TO MOVE FROM DRIVE TO PARK. AFTER SEVERAL TRIES AND 30 MINUTES, IT FINALLY MOVED. IT'S GOTTEN STUCK A FEW TIMES TRYING TO MOVE IT FROM PARK TO DRIVE AS WELL. AND WHEN I'M DRIVING, THE EMERGENCY LIGHTS WILL RANDOMLY ILLUMINATE AND WIPERS WON'T WORK. I WAS DRIVING WHEN IT WAS POURING RAIN AND THE WIPERS WOULDN'T TURN ON WITH ALL EMERGENCY LIGHTS ILLUMINATED AS WELL. THIS CAN HAPPEN ANYTIME I'M ON A CITY STREET GOING FROM 25 TO 45 MPH. I HAVE HAD TO HAVE IT TOWED SEVERAL TIMES TO DIFFERENT SHOPS AND THEY CAN'T TELL ME WHAT'S WRONG.
Steering, Aug 17, 2019
MY POWER STEERING WENT OUT AS I WAS EXITING THE HIGHWAY AT A BEND AND WHILE I WAS TURNING TO BEGIN DRIVING ON THE CITY STREETS. I HAD MY 2 MONTH OLD DAUGHTER AND 6 YEAR OLD SON WITH ME AT THE TIME THIS HAPPENED WHICH FRIGHTENED ME TREMENDOUSLY.
Electrical system, Air bags, Aug 16, 2019
WHEN TURNING ON THE CAR AND WHEN DRIVING A MESSAGE COMES UP SAYING "SERVICE AIR BAG". THE CLOCK TURNS TO MILITARY TIME WITHOUT US CHANGING IT. SEAT BELTS SIGN COMES WHEN SEAT BELTS ARE BEING USED. POOR PERFORMANCE.
Electrical system, Other or unspecified, Fuel/propulsion system, Aug 13, 2019
MY CAR WON'T TURN OVER AFTER I TURN IT OFF SOMETIMES. SOMETIMES IT WILL BE MOST OTHER TIMES IT DOESN'T. THE BATTERY IS NEW, SPARK PLUGS ARE NEW, SENSORS ARE NEW. STARTER ISN'T THE PROBLEM. DON'T KNOW WHAT IT COULD BE? IT WAS STATIONARY WHEN THIS HAPPENS, WHEN I TRY TO TURN THE CAR BACK ON.
Air bags, Other or unspecified, Aug 12, 2019
ANTITHEFT SYSTEM IS CAUSING MY CAR NOT TO START. I HAVE CONTACT GM THEY ARE NOT WILLING TO HELP. I RESEARCH ONLINE LINE WHERE CHEVROLET KNOWS ABOUT THE ISSUE BUT WANT CUSTOMER TO FIX THE PROBLEM THEMSELVES. I WAS STRANDED FOR 4 HOURS IN THE HOUSTON HEAT WITH MY KIDS. THE CAR WILL STOP IN TRAFFIC AS WELL
Electrical system, Aug 11, 2019
THE FUSE BOX IN TRUNK OF CAR HAS A SHORT IN THE WIRE AND IT IS CAUSING A BURNING SMELL. THE VEHICLE DOESN'T START HALF OF THE TIME AND WHEN IT DOES START, THE CAR WILL STALL OUT OR COMPLETELY SHUT DOWN WITHOUT WARNING. THIS IS UNSAFE ESPECIALLY IN TRAFFIC WITH THE KIDS.
Exterior lighting, Aug 11, 2019
MY 2012 CHEVY MALIBU PASSENGER HEADLIGHT HAS GONE OUT 4 TIMES IN A YEAR AND A HALF. IT IS REDICULOUS THAT IT COSTS A MINIMUM OF 80.00 TO HAVE THIS WORK DONE AND IT IS A SAFETY HAZARD BECAUSE THE OWNER CANNOT PERFORM THE BULB REPLACEMENT WITHOUT REMOVING THE ENTIRE FRONT OF THE CAR.
Electrical system, Exterior lighting, Electronic stability control (ESC), Aug 10, 2019
AT 1ST MY CAR WOULDN'T CRANK EVERY SO OFTEN THEN STARTED GOING DRAG WHILE DRIVING I GOOGLED IT AND HAD TO BEAT ON FUSEBOX IN TRUNK OR WIGGLE WIRES SO HAD TO RUN WIRE STRAIGHT TO BATTERY TO FUEL PUMP. MY HEADLIGHTS ON DIM KEEP SHOOTING AND MY SPEAKERS WILL GO OUT SOMETIMES
Power train, Service brakes, Hydraulic, Engine, Aug 2, 2019
TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. WHILE DRIVING 70 MPH, THE VEHICLE EXPERIENCED ACCELERATION FAILURE AND STALLED. IN ADDITION, THE GEAR HAD A DIFFICULT TIME SHIFTING FROM PARK INTO REVERSE OR DRIVE WHEN ATTEMPTING TO MOVE OUT OF A PARKED POSITION. THE VEHICLE WAS TAKEN TO BERGSTROM CHEVROLET OF MADISON (1345 APPLEGATE RD, MADISON, WI 53713, (608) 271-2212) WHERE IT WAS DIAGNOSED THAT THE BODY CONTROL MODULE AND AN ELECTRIC BRAKE CONTROL MODULE NEEDED TO BE INSTALLED. IN ADDITION, A REAR PASSENGER SIDE WHEEL SPEED SENSOR ALTERNATOR CIRCUIT NEEDED TO BE INSTALLED. THE VEHICLE REMAINED AT THE DEALER SINCE JULY 16, 2019 AND THE CONTACT WAS INFORMED THAT THE REPAIR WOULD COST $2,700. THE MANUFACTURER PROVIDED A CASE NUMBER AND REFERRED THE CONTACT TO A MANAGER. THE CONTACT HAD NOT YET SPOKEN WITH THE MANAGER. THE CONTACT WAS TRYING TO FIND OUT WHAT REPAIRS WERE COMPLETED BY THE PREVIOUS OWNER AND WAS CONCERNED THAT THE REPAIRS WERE NOT DONE PROPERLY. THE DEALER COULD NOT PROVIDE A SERVICE REPAIR HISTORY FOR THE VEHICLE. THE FAILURE MILEAGE WAS UNKNOWN.
Visibility/wiper, Jul 29, 2019
2012 CHEVY MALIBU, WINDSHIELD WIPER TRANSMISSION I WAS DRIVING ON THE HIGHWAY TODAY, DURING A RAINSTORM, WHEN THE WIPERS FAILED TO OPERATE WHILE DRIVING 70 MPH ON MI 696. I WAS ON A 4 LANE HIGHWAY AND COULD NOT SEE AT ALL DO TO THE FAILED WIPER TRANSMISSION BUSHING. THIS NOT ONLY PUT MYSELF IN DANGER BUT OTHER DRIVERS AS WELL. I COULD NOT SEE AT ALL AND CAUSED MANY OTHER DRIVERS TO SWERVE OUT OF THEIR LANES AT 70 MPH. PLASTIC BUSHINGS ARE USED ON THE WIPER TRANSMISSION (LINKAGE) WHICH HAS BEEN A COMMONLY REPORTED EVENT. THIS IS A DESIGN FLAW WHICH IS CAUSING THE WIPERS TO FAIL, MAKING VISIBILITY DURING INCLEMENT WEATHER IMPOSSIBLE. THIS IS A SAFETY HAZARD. GM ONLY OFFERS A REPLACEMENT WIPER TRANSMISSION WITH THE SAME PLASTIC BUSHINGS THAT KEEP FAILING. THIS IS A DESIGN FLAW THAT WOULD HAVE A MINIMAL COST IF THEY USED METAL BUSHINGS. THIS PLASTIC BUSHING MAY EVENTUALLY KILL SOMEONE FROM FAILED WIPER USAGE.
Electrical system, Engine, Fuel/propulsion system, Jul 29, 2019
WAS DRIVING AND MY CAR STOPPED ACCELERATING. I PUSHED ON THE GAS AND IT WOULD NOT GO. I WAS ON THE FREE WAY AND ALMOST HAD AN ACCIDENT. ALSO CAR WOULD NO LONGER START AFTER STOPPED. WOULD ACT LIKE IT WAS GOING TO START AND DOES NOT. I'VE HAD SEVERAL TOES WITH MY CHILDREN IN THE VEHICLE. A HUGE SAFETY CONCERN.
Electrical system, Exterior lighting, Service brakes, Jul 29, 2019
TAKATA RECALL WHEN I'M DRIVING MY VEHICLE, THE HEADLIGHTS FLICKER AS IF I'M THE POLICE. I TOOK IT TO FIRESTONE AND THEY TOLD ME TO TAKE IT TO A DEALER THE CAR ONLY HAS 160,000+ AND IT JUST STARTED EVERY TIME I ACCELERATE OR DRIVE IT DOES THIS AND I'M AFRAID THAT I WILL EITHER GET PULLED OVER BY THE POLICE, HIT SOMEONE OR SOMEONE HITS ME OR/AND THE LIGHTS GO COMPLETELY OUT WHILE DRIVING AT NIGHT. IS THIS DUE BECAUSE WHENEVER YOU HAVE TO CHANGE THE BUILD, THE WHOLE BUMPER HAS TO COME OFF TO REPLACE IT? I LIKE MY CAR BUT THIS IS A SERIOUS ISSUE THAT NEEDS TO BE ADDRESSED. I SEE A LOT OF COMPLAINTS REGARDING THIS
Structure, Electronic stability control (ESC), Engine, Jul 27, 2019
TAKATA RECALL IT CONSTANTLY SHAKES AND MY CAR IS CONSTANTLY PULLING AND RANDOM CODES POP UP ALL THE TIME . NOT TO MENTION IT'S A 2012 AND IT'S RUSTING MAJORLY. I AM DRIVING WHEN MY CAR SEEMS TO BE MISSING A BEAT IT WANTS TO JERK ON ME LIKE IT WANTS TO STOP RUNNING. I WAS ON A CITY STREET IT HAPPENS A LOT .
Electrical system, Air bags, Seat belts, Jul 19, 2019
MY CAR WOULDN'T CRANK THEN IT WOULD CRANK. TILL I WAS DRIVING DOWN THE ROAD AND IT JUST DIED ON ME GOING AROUND A CURVE LOST CONTROL OF STEERING AND BRAKES THANK GOD I DIDN'T WRECK SO I GOT IN LINE AND RESEARCHED AND COME TO FIND OUT THAT IT WAS SOMETHING TO DO WITH FUEL PUMP RELAY CONNECTION TO FUEL PUMP RELAY BOX. THE WIRES AWARE TOO LITTLE VOLTAGE FOR THE FUEL PUMP AND BURNT WIRES TO FUEL PUMP RELAY BOX. I SEE THAT THERE ARE A LOT OF COMPLAINTS ON SAME CAR AS LINE. SO I'M FILING A COMPLAINT CUASE THIS IS VERY DANGEROUS.
Exterior lighting, Visibility/wiper, Jul 15, 2019
I HAVE A 2012 CHEVY MALIBU. THUS IS MY EVERYDAY VEHICLE AND WHEN I HAVE HEADLIGHT PROBLEMS IT IS VERY FRUSTRATING. WE HAVE HAD THE BUMPER OFF THIS CAR MULTIPLE TIMES WHICH IS A REAL PAIN. WE HAVE CHANGED HEADLIGHTS, WIRING HARNESS AND EVEN UNDOING THE BATTERY. THE PASSENGER LIGHT COMES ON FOR A BIT THEM WILL GO OFF AND NOT COME BACK ON. I HAVE A LOAN ON THIS CAR AND CAN'T EVEN GET RID OF IT CAUSE I CAN'T KEEP THE LIGHTS ON. WORSE CHEVY CAR I HAVE EVER OWNED. I HAVE BEEN PULLED OVER FOR IT BEING OUT AND HOW AM I SUPPOSED TO EXPLAIN IT. READING THE REVIEWS OF THIS CAR ONLINE I AM NOT THE ONLY PERSON THAT HAS HEADLIGHT PROBLEMS.
Electrical system, Jul 15, 2019
2012 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO NHTSA SAFETY RECALL 14V-252. *LD THE CONSUMER STATED AFTER THE VEHICLE WAS REPAIRED UNDER THE RECALL, THE FAILURE RECURRED. * JS
Steering, Seats, Jul 14, 2019
MY 2012 MALIBU 1LT HAS SOME OF THE SAME ISSUES THE RECALLS ARE FOR BUT MY SPECIFIC VIN NUMBER ISN'T INCLUDED IN THE RECALLS. MY DRIVER SEAT MOVES WHEN SITTING IN IT AND I NEED A RACK-AND-PINION. I'M ALSO HAVING ISSUES WITH A 'ROUGH' IDLE AND WHEN I PUT IT IN PARK THE RPM'S DIE DOWN BETWEEN 1&0 AND THE CAR ACTS LIKE IT'S TRYING TO CUT OFF.
Electrical system, Jul 13, 2019
I HAVE A 2012 CHEVY MALIBU AND SINCE NOVEMBER WE HAVE HAD HEADLIGHT PROBLEMS AND CHANGES BULBS AND GOT A NEW WIRE HARNESS AND WE STILL HAVE PROBLEMS WITH PASSENGER SIDE LOW BEAM LIGHT GOING OUT. IT IS A REAL PAIN CAUSE IT TAKES A BIT TO EVEN GET TO THE HEADLIGHT. HAVE TO TAKE THE BUMBER OFF AND REAL FRUSTRATING.
Air bags, Jul 11, 2019
AIR BAGS LIGHT KEEP COMING ON HAD A RECALL TO HAVE IT REPLACE BEFORE BUT LIGHT CAME BACK ON
Electrical system, Exterior lighting, Jul 8, 2019
PASSENGER HEAD LIGHT HAS BEEN REPLACED SEVERAL TIMES IT KEEPS TURNING OFF. LIGHT BULB IS NOT BURNED. WHEN TAPING ON OR MOVING WIRES LIGHT GOES ON REPLACED WIRES AND STILL HAVING SAME ISSUE. VEHICLE CAN NOT BE DRIVEN AT NIGHT TIME. ALL THIS HAPPENS WHEN VEHICLE IS TURNED ON.
Exterior lighting, Jul 6, 2019
LEFT LOW BEAM KEEPS GOING OUT AND BULB NOT BURNT OUT. REPLACED 3X IN THE PASSED YEAR