2014 Chevrolet Malibu
Problems, recalls and owner-reported issues
Engine is the leading concern among 363 owner complaints filed for this model year. This is the 18th highest complaint count among 26 Malibu model years with reports.
Of the 2014 reports, 19 involved a crash and 8 involved a fire. 17 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Campaign 16V502000 on NHTSA.gov
Visibility, sun/moon roof assemblyMar 23, 2015
General Motors LLC (GM) is recalling certain model year 2013-2015 Chevrolet Malibu vehicles October 24, 2011, to March 5, 2015. In the affected vehicles, the Slide or Tilt switch for the roof panel may not be adequately recessed to prevent the switch from inadvertently being pressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 118, "Power-Operated Window, Partition, and Roof Panel Systems."
The Slide or Tilt roof panel switch may inadvertently be pressed and the roof panel may auto-close unexpectedly, increasing the risk of a pinch injury.
GM will notify owners, and dealers will update the Body Control Module (BCM) software to remove auto-close feature for certain switch positions, free of charge. The recall began April 21, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15176.
Campaign 15V164000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuumMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Malibu vehicles manufactured June 12, 2013, through May 2, 2014, and equipped with a 2.5L engine with the auto stop/start option. The affected vehicles may experience a complete loss of brake vacuum assist, disabling the hydraulic boost assist. As such, these vehicles do not comply with Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."
If the hydraulic boost assist is disabled, slowing or stopping the vehicle will require additional brake pedal effort and a lengthened stopping distance. Both of these effects increase the risk of a crash.
GM will notify owners, and dealers will update the electronic brake control module software, free of charge. The recall began on July 3, 2014. Owners may contact General Motors customer service at 1-800-222-1020. General Motors number for this recall is 14201.
Campaign 14V247000 on NHTSA.gov
Service brakes, hydraulic, foundation components, discMay 8, 2014
General Motors LLC (GM) is recalling certain model year 2014 Buick Lacrosse vehicles manufactured January 29, 2014, through March 31, 2014 and 2014 Chevrolet Malibu vehicles manufactured February 7, 2014, through March 31, 2014, and equipped with 17 inch front brake rotors. The affected vehicles may have had brake rotors intended for the rear of the car accidentally installed on the front. The rear rotors, while the same diameter, are thinner and may result in a front brake pad detaching from the caliper.
If a brake pad detaches from caliper, there may be a sudden reduction in braking, lengthening the distance required to stop the vehicle and increasing the risk of a crash.
GM will notify owners, and dealers will inspect the front brake rotors, and install the correct rotors with new brake pads, as necessary, free of charge. The recall began on June 20, 2014. Owners may contact General Motors customer service at 1-800-521-7300 (Buick) or 1-800-222-1020 (Chevrolet). GM's number for this recall is 14128.
Campaign 14V240000 on NHTSA.gov
Power train, automatic transmissionFeb 21, 2014
General Motors LLC (GM) is recalling certain model year 2014 Buick Regal, LaCrosse, Verano, and Enclave, and Chevrolet Impala, Malibu, Cruze, and Traverse, and GMC Acadia vehicles equipped with automatic transmissions. In the affected vehicles, the transmission shift cable adjuster may disengage from the transmission shift lever. As such, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect." They also fail to conform to FMVSS number 114, "Theft Protection and Rollaway Prevention."
If a vehicle's shift cable disengages from the transmission shift lever, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the driver may be able to shift the lever to the "PARK" position, but the vehicle transmission may not be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
General Motors will notify owners, and dealers will inspect and replace any affected transmission shift cable adjusters, free of charge. The recall began on April 10, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Buick owners at 1-800-521-7300, and GMC owners at 1-800-462-8782. General Motors' number associated with this recall is 14048.
Campaign 14V092000 on NHTSA.gov
Visibility, defroster/defogger/hvac systemNov 13, 2013
General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Malibu vehicles manufactured June 12, 2013, through November 5, 2013. The heating, ventilation, and air conditioning (HVAC) control in these vehicles may intermittently become inoperable when the vehicle is started, preventing the windshield defroster from working. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 103, "Windshield Defrosting and Defogging Systems."
The inability to turn on the windshield defroster may decrease the driver's visibility thereby increasing the risk of a crash.
GM will notify owners, and dealers will update the electronic climate control module software, free of charge. The recall began during December 2013. Owners may contact GM at 1-800-521-7300. GM's recall campaign number is 13380.
Campaign 13V567000 on NHTSA.gov
Representative owner complaints: engine
129 reports, newest first. Show all
Power train, Vehicle speed control, Engine, Dec 2, 2020
THIS HAS HAPPENED TWICE NOW, ONCE FOR MY WIFE AND THE SECOND TIME I WAS DRIVING. BOTH INCIDENTS HAPPENED WHILE IN MOTION ON THE HIGHWAY AND THE VEHICLE DISPLAY SHOWED REDUCED ENGINE POWER AND THE VEHICLE DE-RATED AND SLOWED AUTOMATICALLY ON THE HIGHWAY. THE CHECK ENGINE LIGHT DISPLAYED AND AFTER CONNECTING A CODE READER TO THE OBD AND CODE P2138 WAS LOGGED WHICH IS POTENTIALLY A FAULTY THROTTLE POSITION SENSOR/ FOOT GAS PEDAL. I REPLACED THE THROTTLE POSITION SENSOR CLEARED THE STORED CODE AND A COUPLE WEEKS LATER THE VEHICLE AGAIN WENT INTO LIMP MODE AND DE-RATED ON HIGHWAY. THE CHECK ENGINE LIGHT CAME ON AND THE SAME CODE P2138 WAS LOGGED INDICATING VOLTAGE DIFFERENCE BETWEEN APP SENSOR 1 AND APP SENSOR 2 OF THE THROTTLE POSITIONING SENSOR. AFTER FURTHER RESEARCH ON LINE I FOUND THAT A GM SERVICE BULLETIN WAS ISSUED FOR POTENTIAL MOISTURE INTRUSION OF THE CONNECTORS FROM THE THROTTLE POSITION SENSOR TO THE ECM. (SEE ATTACHED) IT SEEMS LIKE MY VEHICLE IS EXPERIENCING MOISTURE IN THE CONNECTORS AS BOTH INCIDENTS HAPPENED WITHIN MINUTES OF TAKING THE VEHICLE THROUGH AN AUTOMATIC CAR WASH. IN MY OPINION THIS IS A SAFETY CONCERN FOR THIS MODEL VEHICLE TO DE-RATE AND SLOW DOWN SUDDENLY AT HIGHWAY SPEEDS WITH CARS FOLLOWING BEHIND AND HAS BEEN A KNOWN ISSUE BY GM AND SHOULD HAVE A RECALL ISSUED.
Engine, Nov 3, 2020
CAME TO A STOP AT A STOP LIGHT AUTO STOP CAME ON. WHEN LET OFF THE BRAKE THE AUTO START DID NOT START. IT TRIED TO THEN COMPLETELY SHUT OFF. HAD TO PUT CAR IN PARK AND TURN THE KEY TO GET IT TO START. I WAS IN RIGHT LANE TRYING TO TURN. THE FIRST TIME IT HAPPENED IT WOULD NOT START WITH TURNING THE KEY UNTIL THE SECOND TIME TURNING THE KEY. THIS HAPPENED 5 TIMES ON MY WAY HOME. WAS ALMOST REAR ENDED. WHILE IT WOULD NOT START AT 2 STOPS CARS THOUGHT I WAS GOING TO MOVE AND I COULDN'T. AUTO STOP AND START WAS COMING ON AT ALMOST EVERY STOP THIS MORNING AND MY HUSBAND MADE A COMMENT ABOUT HOW THAT WAS STRANGE AND IT SHOULD NOT DO IT. YESTERDAY WE JUST REPLACED THE INTAKE AND EXHAUST SEANOID.
Engine, Oct 6, 2020
FOR A FEW YEARS AFTER PURCHASING MY VEHICLE I NOTICED SOMETIMES IT WOULD STUTTER OR THROTTLE AND SURGE WHILE DRIVING, BUT EVERY TIME I TOOK IT TO THE DEALER THEY WERE "UNABLE TO DUPLICATE" THE PROBLEM. NOW THE SOURCE OF THE PROBLEM I BELIEVE IS ERROR CODE P16D0, BUT THERE IS NO RECALL ON THIS PART THAT IS MENTIONED IN THIS CODE. GENERAL MOTORS SHOULD COMPENSATE VEHICLE PURCHASERS WHO HAVE RUN INTO THIS ISSUE.
Engine, Oct 6, 2020
2014 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO DEFECTIVE ROCKER ARM OIL CONTROL VALVE. CONSUMER IS ALSO SEEKING REIMBURSEMENT FOR OUT OF POCKET COSTS RELATED TO REPAIRS. *LD THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING THE RECALL REPAIR. THE MANUFACTURER ADVISED THE PART NECESSARY TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONSUMER HAD THE VEHICLE REPAIRED WITH AFTERMARKET EQUIPMENT AS SUGGESTED BY THE MANUFACTURER. THE CONSUMER REQUESTED TO BE REIMBURSED FOR THE COST OF REPAIRS. *JS
Electrical system, Engine, Fuel/propulsion system, Oct 5, 2020
THE CHECK ENGINE LIGHT WON'T GO OFF AND THERE'S ONLY 78000 MILES. THE AUTO STOP ISN'T WORKING. THE TRACKING LIGHT WON'T GO OF AND THE ABS LIGHT WONT GO OFF
Engine, Sep 21, 2020
WHEN I STOP AT A STOP SIGN OR RED LIGHT, MY CAR GO INTO AUTO STOP. WHEN I PRESS ON THE GAS TO GO, THE CAR SHUT OFF. AFTER MONTHS OF THIS I JUST UNDERSTOOD WHAT WAS REALLY GOING ON. NO CHECK ENGINE LIGHT IS ON. THIS IS HARD TO DETECT. NOT EVEN THE DEALERSHIP FOUND THIS OUT. MY AUTO SOUND GUY EXPLAINED THIS TO ME NOW I CAN EXPLAIN THIS TO THE DEALERSHIP . THIS SHOULD BE A RECALL . THIS IS DANGEROUS. WHY DID CHEVROLET PUT THIS OPTION IN CARS.
Power train, Engine, Fuel/propulsion system, Jul 20, 2020
ON 7/5/20 THE VEHICLE WAS IN MOTION GOING DOWN THE HIGHWAY AND THE HIGH PRESSURE FUEL PUMP MOUNTED ON THE ENGINE BROKE LOSE, DROPPED INTO THE ENGINE AND TORE APART THE ENGINE. WAS TOWED AND FIXED BY CLOSEST GM DEALERSHIP (DEERY BROTHERS, WEST BURLINGTON, IA). THERE IS A RECALL FOR A BAD WELD ON THE HIGH PRESSURE FUEL PUMP FOR 2016-2018 MALIBU'S RESULTING IN THE EXACT ISSUE I HAD ON MY 2014. THE DEALERSHIP SAID GM, CHEVROLET AND THE DEALERSHIP (WHICH IS A GM CERTIFIED DEALERSHIP WHERE I BOUGHT THE CAR CERTIFIED PRE-OWNED IN 2018) SAID THEY ALL BARED NO RESPONSIBILITY FOR THE ISSUE. I PAID $3,128 FOR THE REPAIR ON 7/17/20. TWO DAYS AFTER BRINGING MY CAR HOME, THERE IS AN OIL LEAK THAT WAS NEVER THERE BEFORE. THE DEALERSHIP SAYS THIS IS A HOLE IN THE OIL PAN, AND AGAIN IS MY RESPONSIBILITY TO PAY FOR IN FULL TO BE FIXED. I RECEIVED A LETTER FROM CHEVROLET ON 7/16/20 SAYING THERE IS A RECALL FOR MY VIN # FOR AN OIL PRESSURE VALVE. INCORRECT OIL PRESSURE COULD HAVE CAUSED THE HIGH PRESSURE FUEL PUMP TO EXPLODE CAUSING THE ISSUE ON 7/9/20. I DO NOT BELIEVE THAT BETWEEN THE TWO RECALLS ISSUED BY CHEVROLET FOR MY CAR MODEL I SHOULD BE RESPONSIBLE FOR THE FULL WEIGHT OF THE REPAIRS ON A CAR THAT WAS PURCHASED CERTIFIED PRE-OWNED WITH A WARRANTY TWO YEARS PRIOR, NOT TO MENTION I'VE HAD ALL REGULAR SERVICES DONE IN A TIMELY MATTER AT THE SAME DEALERSHIP, THAT HAS UNDER 90,000 MILES AND IS ONLY SIX YEARS OLD. THERE IS NO REASON FOR SUCH EXTENSIVE ENGINE DAMAGE TO SUCH A NEW CAR WITH NO PREVIOUS ISSUES.
Electrical system, Other or unspecified, Engine, Jun 28, 2020
THE VEHICLE STOPS WHILE IN MOTION AND IN DRIVING GEAR THEN WHEEL LOCK UP. MAKING IT UNABLE TO PROCEED TO TURN OR DRIVE. THIS DOES NOT MATTER IF ON HIGHWAY OR PUBLIC STREET. HAD TO HAVE CAR TOWED TO COTTMANS AND THE MECHANIC STATED THAT THIS ISSUE IS KNOWN AND WAS COVERED BY MANUFACTURERS UNDER CODES P0011 AND P2646. YOUR ASSISTANCE IS NEEDED WITH RESOLVING THIS MATTER AS MY CAR IS NOT DRIVEABLE.
Engine, Fuel/propulsion system, Jun 27, 2020
WHILE DRIVING THE VEHICLE IT MADE A NOISE THEN SOUNDED LIKE A MOTORCYCLE. THE VEHICLE COULDN'T MAINTAIN SPEED OF MORE THAN 18 MPH. LIMPED THE VEHICLE A FEW MILES HOME AND IT WAS LEAKING ENGINE OIL ONTO THE GROUND. THERE IS OIL PUDDLED UP BETWEEN THE TRANSMISSION AND ENGINE AREA. *TR
Engine, Jun 22, 2020
MY CAR HAS BEEN IN NEED A GM PART FOR ALMOST EIGHT MONTHS. THE PART # IS 12633613. I HAVE SPOKEN WITH CHEVY REPRESENTATIVES OVER A DOZEN TIMES. DESPITE DISCONTINUING THE ENGINE THAT REQUIRES THIS PART AND THE MANY COMPLAINTS AND PEOPLE WHO CAN'T OPERATE THEIR VEHICLES WITH THIS ENGINE, CHEVY/GENERAL MOTORS REFUSES TO DO A RECALL. THE FAULTY PART CAUSES CARS TO JERK AND SHUT OFF IN THE MIDDLE OF THE ROAD. BEFORE REALIZING THE CAR WASN'T FULLY OPERABLE, I WAS ALMOST HIT DUE TO MY INABILITY TO MOVE FORWARD. I HAVE INVESTED IN CHEVY AND I HAVE TAKEN GREAT CARE OF MY CAR. ONE SMALL SOLENOID ROCKER ARM SHOULD NOT KEEP ME FROM ENJOYING THE VEHICLE I HAVE PURCHASED. ASIDE FROM THE THOUSANDS OF DOLLARS LOSS FROM THE CAR ITSELF, I SPENT HUNDREDS AND THOUSANDS OF DOLLARS ON TRANSPORTATION ALTERNATIVES. I NEED SOME REMEDY IN THIS CASE AS CHEVY WILL NOT ADMIT THE PART HAS BEEN DISCONTINUED (ALTHOUGH A REPRESENTATIVE DID ADMIT TO THIS) DESPITE THEIR STATED REQUIREMENT OF PRODUCING OR MAKING AVAILABLE COMPARABLE PARTS FOR AT LEAST 10 YEARS. I NEED HELP AND I HOPE CHEVY IS HELD ACCOUNTABLE FOR THESE WILLFUL CONSUMER VIOLATIONS. *TR
Engine, Jun 8, 2020
TL* THE CONTACT OWNS A 2014 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITH THE SERVICE STABILI-TRAC AND REDUCED ENGINE POWER WARNING MESSAGES DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY DIAGNOSED THE VEHICLE WITH A DEFECTIVE VVT (VARIABLE VALVE TIMING) SENSOR. THE MECHANIC RECOMMENDED THAT BOTH VVT (VARIABLE VALVE TIMING) SENSORS BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE PERSISTED. THE CONTACT THEN TOOK THE VEHICLE TO SECOND INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE WITH AN ENGINE MISFIRE. THE VEHICLE WAS NOT REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 107,000.
Electronic stability control (ESC), Engine, Jun 8, 2020
CHECK ENGINE LIGHT ON AND CHECK STABILIZERTRAK AND REDUCED ENGINE SPEED DIAGNOSTIC TEST SAYS MISFIRE AND VVT SENSORS REPLACED EVERYTHING STILL ON CAR LOST ALL SPEED AND POWER ON HIGHWAY. *TR
Engine, Fuel/propulsion system, May 6, 2020
THE ENGINE VARIABLE TIMING OIL CONTROL VALVE IS MALFUNCTIONING AS I HAVE SEEN WITH THOUSANDS OF OTHERS ON THE INTERNET. GM IS NO LONGER MAKING THE PART. I WAS DRIVING MY CAR ON A HIGHWAY AND THE CHECK ENGINE LIGHT CAME ON. THE CAR DROVE NORMALLY, BUT WHEN I ATTEMPTED TO ACCELERATE TO MERGE ONTO ANOTHER HIGHWAY, THE CAR SEEMINGLY STOPPED ACCELERATING EVEN WITH MY FOOT ON THE GAS. THE CAR WAS STUCK WITH NO PROPULSION FOR A FEW SECONDS BEFORE I COULD ACCELERATE AGAIN. THE CAR NOW ONLY SLOWLY ACCELERATES, OR DIES IF I TRY TO ACCELERATE QUICKLY. MY FUEL ECONOMY HAS BEEN WORSE AND ACCORDING TO REPORTS THE EMISSIONS OF THE CAR ARE WORSE. NO ACTION IS BEING TAKEN BY GM TO FIX THIS ISSUE. *TR
Engine, Fuel/propulsion system, Apr 21, 2020
I PURCHASED MY CHEVY MALIBU BRAND NEW ALL MAINTENANCE HAS BEEN DONE AS RECOMMENDED MY THE DEALERSHIP NOW PART #12633613 HAS WENT OUT AND I HAVE BEEN TOLD BY THE DEALERSHIP AND GENERAL MOTORS THAT THE PART IS NOT AVAILABLE FOR PURCHASE MEANWHILE I AM LEFT WITH A CAR THAT CAN NOT BE DROVE
Engine, Apr 15, 2020
REQUEST #282669 COMPLAINT15 APRIL, 2020 TRACKING # 11321107 THE FOLLOWING COMPLAINT REFERENCES MY 2014 CHEVY MALIBU, ECOTEC 2.5L DOHC ENGINE, VIN #[XXX]. PURCHASED 9/15/2014 FROM GEORGE HAHAS CHEVROLET IN WILDWOOD, FL. THE VEHICLE IS CURRENTLY UNDER EXTENDED WARRANTY WITH ~23,300 MILES ON IT. IN OCTOBER 2019, THE VEHICLE BEGAN RUNNING ROUGH AT 20-25 MILES PER HOUR (ODOMETER: ~21,000) AND THE VEHICLE ENGINE LIGHT TURNED ON. THE ENGINE GAS MILEAGE ALSO DECREASED. I TOOK IT IN FOR REPAIR AND WAS TOLD THAT THE ROCKER ARM VALVE NEEDED TO BE REPLACED (UNDER WARRANTY). IN ADDITION, THE ENGINE WOULD NEED TO BE CLEANED DUE TO THE EXCESSIVE CARBON BUILD UP DUE TO THE MALFUNCTIONING PART. THIS CLEAN-UP WAS NOT UNDER WARRANTY, EVEN THOUGH IT WAS CAUSED BY A DEFECTIVE WARRANTED PART. I WAS TOLD IT WAS SAFE TO DRIVE THE CAR UNTIL THE ENGINE LIGHT BEGAN TO FLASH. AT THAT POINT I WAS TO PULL TO THE SIDE OF THE ROAD AND HAVE THE VEHICLE TOWED AS IT WOULD NO LONGER BE DRIVABLE. THIS REPAIR WAS ATTEMPTED DURING THE GM WORKER STRIKE AND THE PART WAS NOT AVAILABLE. AFTER THE STRIKE, I WAS INFORMED THAT THE PART WAS NOT AVAILABLE FROM GM OR ANY AFTERMARKET MANUFACTURER. AFTER WAITING UNTIL THE END OF THE YEAR, I AGAIN CONTACTED NAHAS CHEVROLET AND WAS TOLD THAT THE PART WAS NOT AVAILABLE, AND GM HAD NO PLANS TO PRODUCE IT. FURTHER, A WARRANTED PART WAS NOT AVAILABLE FROM ANY MANUFACTURER. I WAS ALSO INFORMED THAT OVER 20 VEHICLES AT THIS SINGLE DEALERSHIP NEEDED THIS SAME PART. ON MARCH 2, 2020 I CONTACTED GM CONSUMER SERVICES (CASE # 9-5847264087). THEY INFORMED ME THAT THEY WERE INFORMED THAT GM HAD NO PLANS TO MAKE THIS PART AND KNEW OF NO AFTERMARKET MANUFACTURER WHO COULD SUPPLY A WARRANTED PART. THEY TOLD ME OF THREE UNWARRANTED MANUFACTURERS, BUT IF THE PART EVER CAUSED FURTHER DAMAGE TO THE VEHICLE, THE REPAIRS WOULD NOT BE UNDER WARRANTY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Engine, Apr 14, 2020
TL* THE CONTACT OWNS A 2014 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 20-25 MPH, THE VEHICLE HESITATED WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO GEORGE NAHAS CHEVROLET (4135 FL-44, WILDWOOD, FL 34785, (352) 504-4538) WHO INFORMED THEM THAT THE REPAIR FOR THE ROCKER ARM VALVE WAS COVERED UNDER WARRANTY, HOWEVER, THE PARTS FOR THE REPAIR WERE UNAVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE PARTS WERE NO LONGER BEING MANUFACTURED. THE CONTACT WAS ALSO INFORMED THAT A THIRD-PARTY PART WAS NOT COVERED UNDER WARRANTY. THE MANUFACTURER OPENED A CASE. THE APPROXIMATE FAILURE MILEAGE WAS 21,000.*DT*TP
Engine, Mar 26, 2020
DRIVABILITY ISSUES DUE TO INTAKE ROCKER ARM OIL CONTROL VALVE. VEHICLE OCCASIONALLY SURGES WHILE DRIVING AND MISFIRES DUE TO A FAULTY ROCKER ARM ASSEMBLY CURRENTLY NOT PRODUCED BY GM.
Electrical system, Other or unspecified, Engine, Mar 17, 2020
WHEN I COME TO A FULL STOP AT A RED LIGHT OR STOP SIGN, WHEN MY CAR TRIES TO USE THE AUTO STOP FEATURE THE MAJORITY OF THE TIME IT FAILS TO START BACK ON WHICH CAUSES IT TO FULLY TURN OFF WHILE THE KEY IS STILL TURNED AND THE CAR IS IN DRIVE AS IF THE CAR WAS STILL DRIVING. I DON'T KNOW WHAT THIS PROBLEM IS NOR DO I KNOW WHAT'S CAUSING IT. I CHANGED MY SPARK PLUGS THINKING THAT MIGHT OF BEEN THE PROBLEM BUT IT STILL CONTINUES TO DO THE SAME MALFUNCTION. PLEASE HELP.
Engine, Mar 15, 2020
THE VEHICLE HAS SUDDEN LOSS OF POWER DUE TO THE FAILURE OF THE INTAKE ROCKER ARM VVT OIL CONTROL VALVE. GM HAS HALTED PRODUCTION ON THIS PART WITH NO VIABLE SOLUTION OR REPLACEMENT OPTION. GM P#12633613. THIS ISSUE HAS HAPPENED MULTIPLE TIMES IN THE PAST 6 MONTHS
Engine, Mar 14, 2020
THE ENGINE LIGHT CAME ON. TOOK IT TO MY MECHANIC. HE TOLD ME THAT THE VALVE ROCKER ARM OIL CONTROL IS BAD. HE TOLD ME I AM THE 9TH IN THE QUE JUST FROM LANSING AREA AND THE PART IS BACK ORDERED SINCE AUGUST 2019. HE ORDERED THE PART FROM SHAHEEN CHEVROLET. I CALLED THE GM HELP LINE. INITIALLY THEY WERE VERY HELPFUL BUT LATER THEY CALLED ME AND SAID THEY CAN'T DO ANY THING. THE CAR IS STANDING OUTSIDE ON THE ROAD AND I AM PAYING THE INSURANCE AND JUST PAID THE REGISTRATION. THE DEFECTIVE PART NUMBERS ARE 12633613 AND 12634467 (GASKET + PART). GM CASE NUMBER IS 9-5813783154. THE PERSON WHO TOOK MY CALL WAS THANNA AND THE DATE I CALLED WAS 2/13/2020.
Engine, Mar 11, 2020
CHEVROLET DID A TERRIBLE JOB CREATING A ENGINE THEN DISCONTINUING PARTS TO IT. THE ROCKER ARM OIL CONTROL VALVE IS A KNOWN FAILURE POINT ON THIS VEHICLE AND THEY DISCONTINUED IT.
Engine, Mar 11, 2020
I BEEN TRYING TO ORDER PART 916806 THIS I'VE BEEN NEEDING IT FOR A WHILE A VARIABLE VALVE TIMING SOLENOID I FEEL LIKE I BEEN RIPPED OFF BECAUSE NO ONE BEEN ABLE TO GET THIS PART HAS THIS PART BEEN REPLACE AS ANOTHER PART WHAT AM I TO DO I NEED MY CAR. I CAN'T GET MY ADMISSION DONE TO GET MY PLATES
Engine, Mar 7, 2020
I HAVE BEEN WAITING ON THE INTAKE ROCKER ARM CONTROL VALVE SINCE DECEMBER 2019. APPARENTLY GM HAS DISCONTINUED THIS PART FOR MALIBUS AND IMPALAS. THEY ARE SAYING IT IS ON BACK ORDER. I AM STILL PAYING ON MY VEHICLE AND THIS SHOULD BE APART OF A RECALL. THERE IS THOUSANDS OF US THAT IS WAITING ON THIS PART AND THIS IS SO UNFAIR. I AM TERRIFIED THAT SOMETHING ELSE IS GOING TO HAPPEN TO MY ENGINE IF THIS IS NOT FIXED SOON.
Other or unspecified, Engine, Mar 1, 2020
THE CHECK ENGINE LIGHT CAME ON AND THE CODE READER SHOWED THAT THE VARIABLE TIMING SOLENOID NEEDS TO BE REPLACED. AFTER SEARCHING FOR A REPLACEMENT PART, I KEEP GETTING TOLD THAT THIS MAKE/MODEL CONSISTENTLY HAS THIS PROBLEM. THE ENGINE LIGHT COMES ON, THE CAR LOSES POWER AND SEEMS TO HAVE A TUGGING FEEL WHEN DRIVING ESPECIALLY WHEN ACCELERATING. THIS HAPPENS BOTH WITH IN TOWN DRIVING AND FREEWAY DRIVING. HAPPENS AT ANY SPEED.
Engine, Feb 27, 2020
TL* THE CONTACT OWNS A 2014 CHEVROLET MALIBU. WHILE DRIVING 30-40 MPH, THE VEHICLE HESITATED AND STALLED AND RESTARTED INDEPENDENTLY. THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THE ROCKER ARM CONTROL OIL VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS THEN TAKEN TO WHITE-ALLEN CHEVROLET PARTS (442 N MAIN ST, DAYTON, OH 45405 (937) 222-3701) WHERE IT WAS ALSO DIAGNOSED THAT THE ROCKER ARM CONTROL OIL VALVE NEEDED TO BE REPLACED HOWEVER, THE PARTS WERE ON BACK ORDER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 46,000.