2015 Chevrolet Malibu
Problems, recalls and owner-reported issues
Engine is the leading concern among 270 owner complaints filed for this model year. This is the 19th highest complaint count among 26 Malibu model years with reports.
Of the 2015 reports, 18 involved a crash and 9 involved a fire. 13 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Campaign 16V502000 on NHTSA.gov
Air bags, side/windowOct 16, 2015
General Motors LLC (GM) is recalling certain model year 2015 Buick LaCrosse, Cadillac XTS, Chevrolet Camaro, Equinox, Malibu, and GMC Terrain vehicles. The affected vehicles have front seat-mounted side impact air bags whose inflator may rupture upon its deployment.
In the event of a crash necessitating deployment of one or both of the side impact air bags, the air bag's inflator may rupture and the air bag may not properly inflate. The rupture could cause metal fragments to strike the vehicle occupants, potentially resulting in serious injury or death. Additionally, if the air bag does not properly inflate, the driver or passenger is at an increased risk of injury.
GM will notify owners, and dealers will replace the side impact air bag modules, free of charge. The recall began on October 19, 2015. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, or GMC customer service at 1-800-462-8782. GM's number for this recall is 01320.
Campaign 15V666000 on NHTSA.gov
Visibility, sun/moon roof assemblyMar 23, 2015
General Motors LLC (GM) is recalling certain model year 2013-2015 Chevrolet Malibu vehicles October 24, 2011, to March 5, 2015. In the affected vehicles, the Slide or Tilt switch for the roof panel may not be adequately recessed to prevent the switch from inadvertently being pressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 118, "Power-Operated Window, Partition, and Roof Panel Systems."
The Slide or Tilt roof panel switch may inadvertently be pressed and the roof panel may auto-close unexpectedly, increasing the risk of a pinch injury.
GM will notify owners, and dealers will update the Body Control Module (BCM) software to remove auto-close feature for certain switch positions, free of charge. The recall began April 21, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15176.
Campaign 15V164000 on NHTSA.gov
Representative owner complaints: engine
71 reports, newest first. Show all
Engine, Feb 28, 2022
Several times my vehicle has said Engine Power is Reduced (I have a photograph) then it says reducing speed to 35 etc. It reduces speed very quickly and continues to do so. It's a safety hazard and I've had to pull off the side of the road so that I don't cause an accident.
Electrical system, Engine, Jan 31, 2022
During the automatic start/stop function, the car stalls out after it stops itself. For example, I exited an interstate and came to a red stoplight. The car engaged the fuel saving system and shut down the engine. However, after I tried to press the gas to get the car to reengage, the car completely shut down requiring me to put the car in park on an exit ramp and re crank the car to get it to start again. Batteries were tested and no one can figure out what the problem is.
Vehicle speed control, Engine, Nov 30, 2021
On 11-11-21 my check engine light came on and message came up reducing engine power and also my speed was reduced. Stability track light came on. Took to shop they repaired but a week later same exact problems occurred. Took back to shop. So far hasn’t happened again. My husband Chevy equinox all of a sudden car does the same exact thing. The check engine light went off so he’s watching it
Engine, Nov 10, 2021
The contact owns a 2015 Chevrolet Malibu. The contact stated the vehicle failed to start without warning. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 82,496.
Vehicle speed control, Engine, Oct 31, 2021
P16cf dtc and check engine light after some engine noise and an incident where I was trying to accelerate around an obstacle but was unable to. The car bottomed out and would not accelerate until I took my foot off the gas and tried again more slowly. It's an issue with the intake solenoid rocker arm (oil control valve). The issue with this particular part was noted on earlier Malibu models but not mine. I have not taken it to the dealer yet as I am out of the power train warranty.
Engine and engine cooling, Sep 20, 2021
The contact owns a 2015 Chevrolet Malibu. The contact stated while driving at 60 MPH, the vehicle started jerking with the check engine warning light illuminated. The vehicle failed to accelerate properly while driving to the residence. The contact took the vehicle to the local dealer to be diagnosed. The contact was informed that the rocker arm oil flow control valve was inoperable and needed to be replaced. The local dealer replaced the part and the vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 91,500.
Electrical system, Engine, Fuel/propulsion system, Jun 15, 2021
This 2015 Chevy Malibu has been serviced over 10 ten times for a stalling/check engine issue(s). Sometimes the check engine light will activate after stalling and other times it will not. This vehicle has only had 1 owner since the initial purchase with on-star showing all the times/dates that a problem was detected and reported via email (on star). The dealership has had ample attempts to fix the issues with the vehicle, as well as private ASE certified mechanic/shop after the issues continued with this problem vehicle. This vehicle is a lemon, it is not dependable, and the stalling issues seem to be an on-going issue with GM Chevy Malibu. On 05/15/2021 while in Natick Massachusetts, I was almost rear-ended after my vehicle stalled in traffic and I could not get to the BDL. As quickly as the vehicle stopped working, I was able to restart the vehicle and move it out of the road. This problem can not be ignored or downplayed, someone will eventual get hurt or killed because their vehicle stalls without reason or warning. I need a dependable vehicle and do not have the luxury to run to the dealership multiple times for an on-going problem.
Power train, Engine, Fuel/propulsion system, May 11, 2021
2015 CHEVY MALIBU WITH 2.5L ENGINE WITH ROCKER ARM OIL CONTROL VALVE MALFUNCTIONING. CHECK ENGINE CAME ON THURSDAY MAY 6, 2021 AND HAD IT DIAGNOSED MONDAY MAY 10, 2021. 2014'S HAVE A RECALL, BUT 2015S DO NOT AND MY MECHANIC CAN'T EVEN FIND A GM PART TO FIX THIS.
Air bags, Vehicle speed control, Engine, Mar 2, 2021
WHEN TURNING LEFT FROM A STOP MY CAR ALL AT ONCE SAID ENGINE POWER REDUCED TO 25MPH, SERVICE AIRBAG, SERVICE STABILITRAC, AND SERVICE BRAKE ASSIST.
Electrical system, Electronic stability control (ESC), Engine, Sep 24, 2020
THE CAR STALLS OUT WHILE IN TRAFFIC AND/OR IMMEDIATELY REDUCE SPEED FLASHING-ENGINE REDUCE CODE ON THE DASH, MINES IN PARTICULAR HAS FLASHED SERVICE TRACTION AND REDUCE ENGINE POWER ON THE DASH, DIAGNOSTIC TESTING IS NOT GIVING ANY CODES FOR A SPECIFIC REASON FOR THIS ISSUE, SEEM TO BE SOMETHING UP WITH THE SENSORS AND ELECTRICAL SYSTEM ON THIS CAR- CAUSING MULTIPLE ISSUES TO HAPPEN ALL AT ONE TIME. CHEVY DEALER NOT VERY HELP- SUGGESTING TO FIX RANDOM PARTS AND THE ISSUE CONTINUES. DECIDED NOT TO DRIVE ON THE HIGHWAY, BUT DID DRIVE ON A BUSY STREET IN BALTIMORE COUNTY.
Engine, Sep 21, 2020
TL* THE CONTACT OWNS A 2015 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE AT A STOP LIGHT. THE CONTACT RAISED THE HOOD AND JIGGLED SOME UNKNOWN WIRES AND THE VEHICLE RESTARTED. THE CONTACT STATED THAT WHEN THE FAILURE OCCURRED THE FIRST TIME, IT WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE AN UNKNOWN SENSOR, ALTERNATOR, THE BATTERY, AND THE BATTERY CABLES WERE REPLACED HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT YET TAKEN TO A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000.
Engine, Jul 29, 2020
GM PART NUMBER 12633613 VVT REAR OIL CONTROL SOLENOID IS FAULTY CAUSING ENGINE JERKING. GM DOES NOT HAVE THIS PART AVAILABLE OR ANY AFTERMARKET PART, AND APPEARS TO HAVE STOPPED PRODUCING IT.
Power train, Engine, May 20, 2020
ON JANUARY 15TH. AT 08:26AM WHILE DRIVING TO WORK MY CHECK ENGINE LIGHT CAME ON. ON JANUARY 19TH. THE CAR WAS DROPPED FOR SERVICE AT WESTGATE CHEVROLET IN EDMONTON, AB. AFTER TWO WEEKS OF TESTING AND MULTIPLE PART CHANGES THE DEALER ESTABLISHED THAT MY CAR HAS A FAULTY "INTAKE OIL CONTROL VALVE". THIS IS A WELL KNOWN FAILURE OF THE GM ECOTEC 2.5 LKW ENGINE. GM HAS BEEN TRYING TO REDESIGN THE PART SINCE SEPTEMBER OF 2019. AS OF TODAY MAY 20TH, 2020 THE REPLACEMENT PART HAS STILL NOT BEEN MADE AVAILABLE AND MY CAR HAS BEEN SITTING AT THE DEALER FOR 4 MONTHS NOW. MULTIPLE OWNERS OF 2014 AND 15 MALIBU'S AND IMPALA'S ARE SUFFERING THE SAME FAITH. LATELY GM CORPORATE HAS NOT EVEN RETURNED E-MAILS FROM MY DEALER AS TO WHEN THE NEW PART WILL ME MADE AVAILABLE. THIS IS AN ABSOLUTELY UNACCEPTABLE BEHAVIOR ON PART OF GM. *TR
Electrical system, Electronic stability control (ESC), Engine, May 18, 2020
I OWN A 2015 CHEVROLET MALIBU LTZ AND I CAN BE DRIVING DOWN THE HIGHWAY AND THE 'SERVICE STABILITRACK' LIGHT WILL COME ON, THEN IT WILL SAY 'REDUCED ENGINE POWER'. I WILL HAVE TO PULL OVER, TURN CAR OFF, AND LET IT SIT FOR A MINUTE OR TWO, THEN CRANK BACK UP AND THOSE LIGHTS WILL GO OFF, BUT THE SERVICE ENGINE LIGHT WILL COME ON. SOMETIMES I HAVE TO DO THIS EVERY 5-10 MILES, DEPENDING ON THE DISTANCE OF MY DESTINATION, WHICH POSES A SAFETY ISSUE FOR ME, ESPECIALLY IF I'M TRAVELING AT NIGHT. THIS MOSTLY HAPPENS WHEN I'M DRIVING ON THE HIGHWAY. *TR
Engine, May 1, 2020
MY CHECK ENGINE LIGHT CAME ON TOWARDS THE BEGINNING OF DEC 2019. I TOOK IT TO A CHEVY DEALERSHIP WHO STATED IT WAS DUE TO THE ROCKER ARM OIL CONTROL VALVE AND THAT THEY NEEDED TO ORDER THE PART. I WAITED UNTIL FEB 2020 WITH NO UPDATE ON WHEN THE PART WOULD ARRIVE SO I TOOK MY MALIBU TO ANOTHER DEALERSHIP WHO STATED IT NEED THE SAME PART AND THAT IT SHOULD BE THERE WITHIN A WEEK. AS OF MAY 2020 MY CAR IS STILL AT THAT DEALERSHIP WITHOUT AN ESTIMATED DATE IN WHEN THE PART WILL BE AVAILABLE. I CALLED GM AND THE ONLY THING THEY CAN DO IS OFFER $2500 TOWARDS A NEW CAR.
Other or unspecified, Engine, Apr 27, 2020
I OWN A 2015 MALIBU LT 2.5L, I HAVE NOT BEEN ABLE TO PASS THE STATE REQUIRED INSPECTION DUE TO A FAULTY OIL CONTROL SOLENOID. (GM PART #12633613 OR GM PART # 19419980) I HAVE INCURRED OVER $1000 IN DIAGNOSTIC FEES AND TAKEN THE CAR TO THREE (3) DIFFERENT INDEPENDENT MECHANICS AND TWO (2) GM CERTIFIED PARTS DEALERS TRYING TO GET THIS PART REPLACED. GM IS NO LONGER MANUFACTURING AND REFERRING CUSTOMERS TO AFTERMARKET PARTS.(AFTERMARKET PART RECOMMENDED IS THE DORMAN 916-806) IN DOING RESEARCH TRYING TO FIND THIS PART IT SEEMS THIS SAME PART HAS MALFUNCTIONED ON EVERY 2014-2015 YEAR MODEL MALIBU AND IMPALA AND GM IS STILL NOT ISSUING A RECALL. I HAVE FILED CUSTOMER SERVICE INQUIRIES/COMPLAINTS WITH MULTIPLE DEALERSHIPS AND GM DIRECTLY. THIS IS AN EGREGIOUS EXAMPLE OF A MANUFACTURING DEFECT AND THEY ARE OFFERING NO ALTERNATIVE OTHER THAN BUYING A NEW CAR. THE CAR IS SHOWING A CODE ERROR P2646 (ROCKER ARM MALFUNCTION IN BANK 1 STUCK IN OFF POSITION). I HAVE BEEN ATTEMPTING TO RECTIFY THIS PROBLEM SINCE OCTOBER 2019, AND FILED THE OFFICIAL COMPLAINT WITH GM APRIL,2020. CASE # WITH GM 9-592-2813084
Vehicle speed control, Engine, Apr 22, 2020
THE CAR REDUCED SPEED WHILE MY WIFE AND GRANDS WHERE IN TRAFFIC ALMOST CAUSING AN ACCIDENT REDUCED TO 25 MPH ON HIGHWAY
Engine, Mar 28, 2020
RECEIVED A NOTIFICATION ON THE DASH, ENGINE LIGHT. TOOK IT TO GET CHECKED & IT'S THE ROCKER ARM CONTROL VALVE. I'VE BEEN WAITING ON THIS PART SINCE LAST YEAR. I'M NOT ABLE TO USE MY REMOTE STARTER AS A RESULT, & I'M NOT ABLE TO GET A PLATE STICKER BCZ THE CAR WON'T PASS EMISSIONS. I FEEL THIS WILL START TO MESS UP THE ENGINE, & GM IS SAYING THEY DON'T KNOW WHEN THE PART WILL BE AVAILABLE. I'M READING A LOT OF COMPLAINTS ABOUT THIS SAME ISSUE, & FEEL THERE NEEDS TO BE A RECALL!
Engine, Mar 10, 2020
TL* THE CONTACT OWNS A 2015 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, SEVERAL UNKNOWN WARNING LIGHTS ILLUMINATED AND THE VEHICLE STARTED TO VIBRATE ABNORMALLY. AN INDEPENDENT MECHANIC WAS CONTACTED AND THE CONTACT WAS INFORMED THAT THE ENGINE VARIABLE TIMING CONTROL VALVE NEEDED TO BE REPLACED. THE CONTACT WAS ADVISED THAT THE VEHICLE SHOULD NOT BE DRIVEN UNTIL REPAIRED. THE PART WAS ORDERED BUT WAS STILL ON BACK ORDER. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE MANUFACTURER OFFERED $2,500 TOWARDS THE PURCHASE OF A NEW VEHICLE. THE CONTACT DECLINED THE OFFER. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.
Electrical system, Other or unspecified, Engine, Feb 29, 2020
MY AUTO STOP CAME ON WHILE AT A STOP SIGN AND WHEN I RELEASED THE BRAKE MY CAR SHUT OFF AND WON'T START I TRIED JUMPING CAR IT STILL WON'T WORK. THE TOW COMPANY THAT TOWED MY CAR HAS TOLD ME ABOUT A RECALL ON AUTO STOP
Engine, Feb 23, 2020
MY CAR WAS DRIVING PERFECTLY FINE. IT HAD JUST PASSED THE ADMISSIONS TEST, AND EVERYTHING WAS FINE. I STARTED DRIVING MY CAR IN THE CITY LIMITS, AND WHILE AT A STOP LIGHT I SMELLED SMOKE. I THOUGHT IT WAS THE CAR BEHIND ME. AS I PULLED INTO A PARKING LOT I REALIZED THAT IT WAS MY CAR THAT WAS SMOKING. UPON LIFTING MY HOOD I SEEN OIL EVERYWHERE AND MY ENGINE WAS SMOKING. AN ALERT CAME ACROSS MY SCREEN URGING ME TO DECREASE SPEED AND ADD OIL. AFTER INVESTIGATING IT WAS TOLD TO ME THAT IT IS MY ENGINE VARIABLE TIMING OIL CONTROL VALVE, AND GM IS CURRENTLY NOT MAKING ANYMORE AND THIS PART IS SOLD OUT EVERYWHERE. I NEED THIS PART IN ORDER FOR MY CAR TO RUN!!!!!
Electronic stability control (ESC), Engine, Feb 22, 2020
MY CAR WAS DRIVING FINE THEN ALL OF A SUDDEN THE SERVICE STABILI TRACK LIGHT FLASHED ON MY SCREEN AND MY CHECK ENGINE LIGHT STARTED FLASHING BUT WENT OFF AFTER ABOUT 1 MINUTE . THE NEXT DAY WHILE ACCELERATING THE CAR STUTTERED AND FELT ALMOST LIKE I WAS DRIVING DOWN A ROAD WITH LITTLE RIVETS . ITS STOPPED AND AGAIN ALL THE LIGHTS DISSAPEARED. THIS MORNING AS SOON AS I STARTED MY CAR THE CHECK ENGINE LIGHT IS ON AND EVERY TIME I ACCELERATE IT STUTTERS AND FEELS AS IF I'M DRIVING DOWN A RIVETED ROAD .
Engine, Feb 21, 2020
MY VARIABLE VALVE TIMING SOLENOID WENT OUT ON MY CAR. THE PART NUMBER IS 12633613. IT HAS BEEN IN THE SHOP FOR 10 DAYS AND CHEVY HAS FAILED TO EVEN GIVE THE SHOP AN ETA ON THIS PART. NOT ONE CHEVY DEALER IN THE COUNTRY HAS THE PART. ABSOLUTELY HORRIBLE BUSINESS PRACTICE.
Engine, Feb 8, 2020
THE ROCKER ARM CONTROL VALVE HAS TO BE CHANGED ON MY CAR. GENERAL MOTORS AND CHEVEROLET CONTINUES TO SAY THEY DON'T KNOW WHEN THEY ARE GOING TO GET THE PART. MY CHECK LIGHT HAS BEEN ON AND I NEED THIS MATTER CORRECTED. I JUST WANT TO BE ABLE TO BUY THE PART AND GET IT FIXED. I HAVE BEEN WAITING SINCE NOVEMBER OF 2019. THE PART NUMBER IS 12633613.
Engine, Jan 28, 2020
I OWN A 2015 MALIBU THAT HAS A CHECK ENGINE LIGHT THAT IS ON. IT NEEDS A PART (#12633613) THAT HAS NOT BEEN PRODUCED BY GM SINCE AT LEAST LAST AUGUST WHEN MY CHECK ENGINE LIGHT FIRST CAME ON. CONSEQUENTLY MY CAR WILL NOT PASS INSPECTION SO I CANNOT GET LEGAL LICENSE PLATES. GM IS AWARE OF MY SITUATION. I HAVE BEEN ASSIGNED A CASE NUMBER [XXX]. MY CASE HAS BEEN 'ESCALATED'. I HAVE SPOKEN TO MY CASE MANAGER, [XXX], FOR A MONTH NOW AND THIS WEEK WAS TOLD I HAVE NEW CASE MANAGER, [XXX], WHO IS HIGHER UP THAN [XXX]. WELL TODAY [XXX] FROM GM CALLED. SHE HAD NO ANSWERS FOR ME ON THE CAR. THE ONLY POSITIVE POINT IS THAT SHE CALLED ME FROM DETROIT. SO IT LOOKS LIKE I FINALLY GOT TO SOMEONE AT HEADQUARTERS. 'SHE UNDERSTANDS WHY I AM UPSET', AND WISHES THERE WAS SOMETHING MORE SHE COULD DO FOR ME BUT UNFORTUNATELY ALL SHE COULD TELL ME WAS 'THAT MY CASE HAS BEEN ESCALATED.' ADDITIONALLY, SHE COULD NOT TELL ME MY PART WAS BEING PRODUCED. SHE COULD NOT GIVE ME ANY SIGN THAT GM PLANNED TO DO ANYTHING TO HELP RESOLVE MY PROBLEM. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR