2016 Chevrolet Malibu
Problems, recalls and owner-reported issues
Engine is the leading concern among 861 owner complaints filed for this model year. This is the 12th highest complaint count among 26 Malibu model years with reports.
Of the 2016 reports, 24 involved a crash and 2 involved a fire. 17 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Seat belts, critical fastenersAug 20, 2021
General Motors, LLC (GM) is recalling certain 2016-2021 Chevrolet Malibu and 2019-2021 Cadillac XT4 vehicles. The rear seat belt retractors may be improperly secured with loose or missing fasteners.
An improperly secured seat belt retractor may not function properly in a crash, increasing the risk of injury.
Dealers will inspect and tighten the rear seat belt retractors, as necessary, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212333380.
Campaign 21V649000 on NHTSA.gov
Air bags, sensor, occupant classificationJun 14, 2018
General Motors LLC (GM) is recalling certain 2016-2018 Chevrolet Malibu vehicles. During servicing, a Passenger Presence System (PPS) may have been installed that was not correctly calibrated to the vehicle's seat type. As a result, the PPS may not properly identify an adult passenger from a child passenger in the front passenger seat, potentially causing the air bag to not deploy when it should, or causing the air bag to deploy when it shouldn't.
In the event of a crash, improper air bag deployment can increase the risk of injury.
GM will notify owners, and dealers will replace the front passenger PPS seat service kit, free of charge. The recall began August 7, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18208.
Campaign 18V400000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpMay 31, 2018
General Motors LLC (GM) is recalling certain 2015-2018 GMC Canyon, 2016-2017 Buick Envision, 2016-2018 Chevrolet Colorado and Malibu, 2017-2018 GMC Acadia, 2018 Buick LaCrosse, Cadillac ATS, Chevrolet Equinox, and GMC Terrain vehicles. The high pressure fuel pump may detach from its mounting flange, possibly resulting in the pump damaging the high pressure fuel line.
A damaged fuel line can create a fuel leak, increasing the risk of a fire.
GM will notify owners, and dealers will replace the high pressure fuel pump, and high pressure fuel pipe, free of charge. The recall began July 2, 2018. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18188.
Campaign 18V358000 on NHTSA.gov
Air bags, side/windowOct 26, 2016
General Motors LLC (GM) is recalling certain model year 2016 Chevrolet Malibu vehicles manufactured November 18, 2015, to June 7, 2016. The fabric of the side-impact air bag cushion may tear during deployment.
If the air bag tears during deployment, the air bag may not perform as designed, increasing the risk of injury in the event of a crash.
GM will notify owners, and dealers will inspect and, as necessary, replace the air bag module, free of charge. The recall began October 27, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 16079.
Campaign 16V781000 on NHTSA.gov
Electrical system, ignitionJul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Campaign 16V502000 on NHTSA.gov
Electronic stability control (ESC)May 5, 2016
General Motors LLC (GM) is recalling certain model year 2016 Chevrolet Malibu vehicles manufactured March 7, 2016, through March 12, 2016. The memory chip in the electronic brake control module (EBCM) may fail and cause the loss of electronically controlled brake systems including anti-lock brakes (ABS) and electronic stability control (ESC). As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
If the EBCM fails the primary braking system will still function, however, the loss of ABS and ESC increase the risk of a crash.
GM will notify owners, and dealers will install a replacement EBCM, free of charge. The recall began on June 17, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020). GM's number for this recall is 39440.
Campaign 16V272000 on NHTSA.gov
Air bags, side/windowMar 11, 2016
General Motors LLC (GM) is recalling certain 2016 Malibu vehicles manufactured February 16, 2016, to March 5, 2016. The two weld studs that mount the front and rear side impact air bags may fracture and separate from the air bag during deployment. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) No. 214, "Side Impact Protection."
Fractured weld studs may allow the side air bag to move out of position during deployment, increasing the risk of injury.
GM will notify owners, and dealers will replace the side air bag modules, free of charge. The recall began on April 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 31820.
Campaign 16V151000 on NHTSA.gov
Air bags, frontalMar 2, 2016
General Motors LLC (GM) is recalling certain model year 2016 Chevrolet Colorado vehicles manufactured January 19, 2016, to February 2, 2016, Chevrolet Malibu vehicles manufactured January 9, 2016, to January 26, 2016, and 2016 GMC Canyon vehicles manufactured January 21, 2016, to February 4, 2016. The driver frontal air bag may improperly inflate during second-stage deployment in the event of a high speed crash.
An improperly inflated air bag increases the risk of injury.
GM will notify owners, and dealers will replace the driver side frontal air bag module, free of charge. The recall began on April 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is 28030.
Campaign 16V125000 on NHTSA.gov
Electrical system, softwareFeb 11, 2016
Genera Motors LLC (GM) is recalling certain model year 2016 Chevrolet Camaro, Malibu, Silverado and GMC Sierra vehicles. The radio may intermittently fail to provide an audio warning when the key has been left in the ignition and the door is opened or when the driver does not fasten their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standards (FMVSS) number 114, "Theft Protection", and/or 208, "Occupant Crash Protection."
An unbelted driver is at a greater risk of injury in a crash.
GM will notify owners, and dealers will update the radio software, free of charge. The recall began on March 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 15808.
Campaign 16V084000 on NHTSA.gov
Representative owner complaints: vehicle speed control
158 reports, newest first. Show all
Power train, Electrical system, Vehicle speed control, Jan 2, 2026
I am reporting a recurring safety defect related to GM’s known “Shift to Park” issue. My vehicle displays a “Shift to Park” warning even when the vehicle is already in park, preventing the car from shutting off properly and creating a safety risk. This issue has been widely reported and associated with GM recalls and service bulletins. GM previously repaired this issue once while my vehicle was under warranty, acknowledging it as a known defect. The same defect has now reoccurred after the warranty period expired. GM is refusing to repair it again, despite the issue being recall-related and tied to a known defective design rather than wear and tear. This defect affects safe vehicle operation, risks battery drain, rollaway hazards, and driver distraction. I believe this is an unresolved safety defect that should be covered regardless of warranty status.
Vehicle speed control, Dec 4, 2025
UNKNOWN While I'm driving my car will lose power and go into reduced engine power mode and slows me down to a crawl. I've almost been hit in the back many times for to this. The coffee is P2138
Vehicle speed control, Nov 19, 2025
Check engine light comes on and dash says reduced engine power
Electrical system, Vehicle speed control, Engine, Oct 22, 2025
The engine power reduced came light came on along with service stability trac. The car would stall after going into auto stop and just shut off. In certain instances it would shutoff when slowed down enough. It was brought in for service where the turbo charge solenoid starter and catalytic converter annd alternator all were replaced due to the turbo braking into pieces and being lodged into the converter and engine. Less than a week later the car returned to stalling at the auto stop feature. When brought in for service it was linked to the alternator and engine control module and mass air flow sensor. The car was then serviced again six months later for the alternator again. Now the car is once again stuck in engine power reduced with no direct codes linked to the problem and the starter was replaced and now the engine is remaining in limp mode. The car has stalled multiple times on not only at stop lights but on the highway and while turning at busy intersections causing traffic jams and even a side collision. The engine light as remained on since the day I got the car.
Electrical system, Vehicle speed control, Engine, Jul 8, 2025, crash
Engine power reduced defect, causing affected models to lose power while driving at highway speeds. My son’s was driving 55 mph and then all of sudden the car decelerated to 20 mph in minutes before his 2016 Malibu stalled on [XXX]. Unfortunately the car did not make it to the emergency lane and as a result a SUV hit his car killing my daughter who was 33 weeks pregnant. The baby survived with lifelong injuries. Despite this recall, GM failed to notify vehicle owners, including the owner of the vehicle involved in the fatal accident on [XXX], in Dallas, Texas, resulting in my daughter’s death. This defect has been found in several 2016 Malibus, prompting a class action lawsuit against GM. Plaintiffs in the class action lawsuit reported having to restart their vehicles or replace faulty accelerator pedal position sensors to address the issue. GM's failure to notify vehicle owners of the safety recall constitutes negligence and gross negligence. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Fuel system, Gasoline, Vehicle speed control, Jun 9, 2025
The contact owns a 2016 Chevrolet Malibu. The contact stated while driving on several occasions at various speeds, the check engine warning light illuminated, and the vehicle lost power. Additionally, the message “Engine Power Reduced" was displayed. The vehicle was taken to an independent mechanic and was diagnosed and determined that the throttle body sensor needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 107,000.
Vehicle speed control, Other or unspecified, Engine, Feb 21, 2025
Happened around 46000 miles after receiving a recall notice in the mail about the pedal positioning sensor causing a reduced engine power signal, and immediately reducing speeds on the interstate. Local Chevy dealership replaced. Fast-forward 80K miles and the same incident is happening, however likely not going to be covered by GM. Same message, same code being detected.
Power train, Vehicle speed control, Engine, Feb 9, 2025
Car showing warning : engine power reduced Car decelerate unexpectedly Car won’t accelerate past 20 mph intermittently - when putting car in park, car won’t recognize when in the park positioned and shows warning : shift to park
Power train, Electrical system, Vehicle speed control, May 26, 2024
On may 23,2024 I was on a very busy highway going 66. All of a sudden my 2016 malibu lt aburtely slowed to 27 miles an hour and two warnings lights came on 1 -engine power is reduced 2 - speed reduced to 27 I barely avoided getting hit by two semi trucks, as well as a car. The car is available for inspection on request. An independent service person confirmed it was indeed a defective electron control and acceleration peddle position sensor. How very irresponsible of you not to put out a recall on the 2016-2018 models knowing very well of the many class action law suits that have arrived from this issue. I probably can guarantee none of you own a Malibu. How very incredious it is that you put people lives in danger knowing that there was issues with the problem. Unbelievable. I almost got killed because of the lack of responsibility because you dint make a recall.
Power train, Vehicle speed control, Engine, May 23, 2024
Vehicle check Engine light on, showing "Reduced Engine Power." Vehicle still able to be driven, but will not accelerate with any proper pace or power. Cannot get above 3000 RPM without losing power, has put me in two dangerous situations in the last two days that almost made me lose my life. On highway, trying to accelerate to match traffic speeds, lose power and had to dive to the emergency lane to not get plowed by a truck. Today, was city driving, at a red light, could not accelerate and had to dive to a crawl the vehicle into a turn lane where I ended up sitting for about 10 minutes till the engine offered enough power to keep driving. By all information I can find online, it seems it is similar to the issues presented by others online and might tie into "Special Coverage N182188250 Loss of Continuity within Accelerator Pedal Position Sensor Circuit" that I found here: [XXX] , this issue has been going for about 3 weeks to a month and is only getting worse. I did stop at McCarthy Chevrolet of Overland Park to have codes run about on [XXX], the codes showing do not show in the above link...codes: U1502, U0422, P06DE, C0760...those all present on the paper as "Current." I have not had it diagnosed yet, planning to, service is just so expensive. I have had the car in my car for 1 year and 1 month, purchased from MAX Motors in Harrisonville, Mo. Reporting here as I also saw online that others are facing the same symptoms, and that there is a suit that might be addressing these issues: [XXX] Every time the car is turned on, the warning mentioned above shows. See picture attached. Does not matter what type of driving or set "speed limit" issues show. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Vehicle speed control, May 23, 2024
Out of nowhere, a notification pops up and it says “engine speed reduced” and all of a sudden you can feel the car losing speed. Took the vehicle to the dealership multiple times and either they always say it’s a fuel injection problem or they have no idea what’s causing it but when they perform that service on the vehicle, it still happens. Dealership even told me once that my car computer system needed to be updated and once updated I wouldn’t have the issue and I still have the issue. Each time the engine speed is reduced, a notification pops up that the StabiliTrak needs to be serviced. My safety and life is at risk because I’m going 65 mph down the interstate and all of sudden my engine speed is reduced like I’m not in the middle of traffic with cars going at speeds between 60-75 mph. I almost got ran over by an 18 wheeler because of the engine speed reduction. I had to swerve hard to the side of the road and risk flipping or crashing to get off the road so I wouldn’t be hit
Steering, Vehicle speed control, Other or unspecified, May 18, 2024
When driving the car it will stop mid drive and slow to 20MPH. The car has broken down in the middle of the road on multiple occasions. It has locked me in the car where I am unable to get out. On one occasion the battery was dead and the car had locked me out. I had to have someone unlock it. The next day the car was fine with no signs of issues. The car has been taken to multiple mechanics and no one knows the issue. Car doesn’t throw any codes or show any symptoms of issues.
Vehicle speed control, Other or unspecified, Engine, May 3, 2024
While traveling at normal speed (55-60MPH) Engine Power Reduced message pops up and car will not accelerate until I pull over, turn it off, then back on after a period of time. Message is beginning to come up frequently. Occurred 3 times this morning on the way to work.
Vehicle speed control, Apr 1, 2024
Our 2016 Chevy Malibu Hybrid intermittently began alerting of "Reduced Engine Power" and the accelerator would not allow the vehicle to accelerate. This happened twice, once on a busy highway that caused rapid deceleration of the vehicle. We brought the vehicle to the mechanic and there were a bunch of codes related to the accelerator position sensor. With parts and labor $415 to fix. Upon researching, there are a bunch of reports on car forums related to this. I believe there have been previous reports to the NHTSA. This problem needs to be fixed and a recall issued to have Chevy replace the Accelerator Position Sensor before someone gets hurt or killed. Once I pick up the vehicle, I will upload the invoice and see if I can get specific code numbers.
Engine and engine cooling, Vehicle speed control, Mar 26, 2024
The contact owns a 2016 Chevrolet Malibu. The contact stated that while driving approximately 70 MPH, the vehicle decelerated to 20 MPH with the "Engine, Reduced Power" message had displayed. After restarting the vehicle, the check engine warning light illuminated, and the vehicle was driving rough. The vehicle was later taken to an independent mechanic. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 143,000.
Vehicle speed control, Jan 16, 2024
While driving at a fast pace a hazard message pops up on dash that states engine power reduced and the car goes slow unable to accelerate past 20 mph. It doesn’t happen all the time but it’s been happening quite frequently and it’s dangerous. I’m assuming there has something to do with the speed and or fuel function. The vehicle has not been inspected. I am willing to bring it for inspection if needed. I feel like this is a malfunction and I’m requesting this to be fixed.
Vehicle speed control, Engine, Fuel/propulsion system, Nov 25, 2023
I was driving about 70mph on a highway trying to pass a semi-truck. As I signaled right blinker to merge back into the right lane, the speed reduced to 40mph without notice. I then seen a notification on the dashboard saying "Engine Power Reduced". The car would not accelerate fast enough to clear the truck therefore almost causing a collision of 2 semi-trucks and myself. I was forced to drive off road to help avoid the collision. My fiancé was in the passenger seat when this happened on 11/25/2023. He then began telling me this happened to him a few months prior but he didn't mention it because it resolved itself. This was actually the 3rd time it had happened in this car over the last 2 years. I spoke to the chevy dealership about it the first time I experienced this and they advised that it had not been made a safety recall at that time yet, but the technician who helped me said his son experienced the same thing and it was becoming quite common. It still has not been recalled but there is currently a class action lawsuit because of this. I feel this is very dangerous and what I considered to be reliable transportation, is no longer the case for my family after this experience. This needs to be recalled immediately before people lose lives. Especially since the parts were Manufactured incorrectly and Chevrolet had knowledge prior to releasing 2016-2018 vehicles.
Electrical system, Vehicle speed control, Engine, Nov 9, 2023
My 2016 Chevy Malibu that does not have many miles on it is shifting into, Reduced Engine Power Mode. When this comes on I cannot accelerate up to speeds and can only go about 25 MPH. It is dangerous that my car can go from highway speeds to this slow. I have had 0 issues before this started happening and other Malibus have been recalled for this same issue.
Power train, Electrical system, Vehicle speed control, Oct 16, 2023
I'm having a problem with the car going into park. When it's in park, the doors will not lock in the vehicle will Just drain the battery.
Power train, Vehicle speed control, Engine, Oct 1, 2023
Acceleration to the engine malfunction no power to engine going excessive speeds on interstate failure light appeared car shut off one stopped car turn right back on. I’ve reported this incident of the last two years to the dealership GMC to 2016 Chevy Malibu that has already had this instance back in 2019 and now has occurred at once again mileage since the last engine was replaced is 10,000 miles on the new engine
Vehicle speed control, Engine, Jul 5, 2023
When driving the car and when stopping at either a stop sign or stop light, turning a corner the car will lose power and will not go for at least 10-15 seconds. when letting the brakes go and pressing the gas pedal the car does not move, pressing all the way on the gas pedal the car will take about 10-15 seconds before moving. It’s like the engine lose power and the car will not accelerate.
Vehicle speed control, Engine, Jun 20, 2023
Lights that alert inside the vehicle at random times but more often in the last few months are: stability trek, power steering reduced and check engine. Acceleration decreased/reduced after being idle. This prompts serious danger for myself and children when there is no power being given to the car when sitting in traffic. Multiple mechanics have diagnosed the issue. Dealership gives me the run around and isn't specific with detail if check light engine goes off.
Vehicle speed control, Engine, Jan 21, 2023
Car loses speed from 60mph to 15mph while driving. Engine Reduce Power light comes on after the fact. This is very dangerous when driving on a busy highway/interstate.
Vehicle speed control, Jan 16, 2023
Code 2138 accelerator sensor popped up yesterday. After researching, I found out this is a common concern with Chevrolet Malibus for 2016. I'm sure you are well aware of this by now so I want to know what my options are at this point. Thank you.
Vehicle speed control, Service brakes, Dec 12, 2022
Had car looked and i was told that the break box is defective