2018 Chevrolet Malibu
Problems, recalls and owner-reported issues
Engine is the leading concern among 698 owner complaints filed for this model year. This is the 15th highest complaint count among 26 Malibu model years with reports.
Of the 2018 reports, 23 involved a crash and 4 involved a fire. 17 people were injured.
What owners report most often
Recalls and investigations
Seat belts, critical fastenersAug 20, 2021
General Motors, LLC (GM) is recalling certain 2016-2021 Chevrolet Malibu and 2019-2021 Cadillac XT4 vehicles. The rear seat belt retractors may be improperly secured with loose or missing fasteners.
An improperly secured seat belt retractor may not function properly in a crash, increasing the risk of injury.
Dealers will inspect and tighten the rear seat belt retractors, as necessary, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212333380.
Campaign 21V649000 on NHTSA.gov
Power train, automatic transmissionOct 29, 2020
General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Cruze and Buick LaCrosse, 2018-2020 Chevrolet Equinox, Chevrolet Traverse and GMC Terrain, 2018 Chevrolet Malibu, 2019-2020 Buick Encore, Buick Enclave, Cadillac XT4, Chevrolet Blazer and GMC Acadia, and 2020 Cadillac XT6 vehicles. The start/stop accumulator endcap may have missing bolts.
Missing bolts on the start-stop accumulator endcap could result in a transmission oil leak and may progress to a loss of propulsion, increasing the risk of a crash. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.
GM will notify owners, and dealers will inspect the start-stop transmission accumulator and replace it if any bolts are missing, free of charge. The recall began December 15, 2020. Owners may contact GMC customer service at 1-888-988-7267, Buick Customer service at 1-866-608-8080, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N202313440.
Campaign 20V668000 on NHTSA.gov
Electrical system, softwareSep 6, 2019
General Motors LLC (GM) is recalling certain 2018 Chevrolet Malibu vehicles equipped with 1.5L turbo engines. An error in the Engine Control Module (ECM) software may result in the fuel injectors being disabled.
Disabled fuel injectors would prevent the engine from starting and may cause a stall, increasing the risk of a crash.
GM will notify owners, and dealers will reprogram the ECM software, free of charge. The recall began October 16, 2019. Owners may contact GM customer service at 1-800-630-2438. GM's number for this recall is N192221960.
Campaign 19V642000 on NHTSA.gov
Service brakes, hydraulic, foundation components, disc, caliperAug 30, 2018
General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Equinox, Impala, Cruze, Volt and Bolt EV vehicles, GMC Terrain vehicles, Buick Lacrosse and Regal vehicles, Cadillac XTS and XTS Professional vehicles and 2018 Chevrolet Malibu vehicles. The rear brake caliper pistons may have an insufficient coating causing gas pockets to form, potentially reducing rear brake performance.
A reduction of braking performance can increase the risk of a crash.
GM will notify owners, and dealers will bleed the vehicle's brake system, free of charge. The recall began October 11, 2018. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18279.
Campaign 18V576000 on NHTSA.gov
Air bags, sensor, occupant classificationJun 14, 2018
General Motors LLC (GM) is recalling certain 2016-2018 Chevrolet Malibu vehicles. During servicing, a Passenger Presence System (PPS) may have been installed that was not correctly calibrated to the vehicle's seat type. As a result, the PPS may not properly identify an adult passenger from a child passenger in the front passenger seat, potentially causing the air bag to not deploy when it should, or causing the air bag to deploy when it shouldn't.
In the event of a crash, improper air bag deployment can increase the risk of injury.
GM will notify owners, and dealers will replace the front passenger PPS seat service kit, free of charge. The recall began August 7, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18208.
Campaign 18V400000 on NHTSA.gov
Fuel system, gasoline, delivery, fuel pumpMay 31, 2018
General Motors LLC (GM) is recalling certain 2015-2018 GMC Canyon, 2016-2017 Buick Envision, 2016-2018 Chevrolet Colorado and Malibu, 2017-2018 GMC Acadia, 2018 Buick LaCrosse, Cadillac ATS, Chevrolet Equinox, and GMC Terrain vehicles. The high pressure fuel pump may detach from its mounting flange, possibly resulting in the pump damaging the high pressure fuel line.
A damaged fuel line can create a fuel leak, increasing the risk of a fire.
GM will notify owners, and dealers will replace the high pressure fuel pump, and high pressure fuel pipe, free of charge. The recall began July 2, 2018. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18188.
Campaign 18V358000 on NHTSA.gov
Representative owner complaints: engine
284 reports, newest first. Show all
Engine, Aug 4, 2025
Engine Reduced Power Light on dash. Vehicle stalling
Engine, Aug 2, 2025
!Engine Power is Reduced
Fuel system, Gasoline, Electrical system, Engine, Jul 29, 2025
The contact owns a 2018 Chevrolet Malibu. The contact stated that the vehicle failed to start. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed with a failure of the battery and fuel pump. The contact was informed that the ground wire and fuel tank needed to be replaced. The dealer informed the contact about a recall on the malfunctioning ECM. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 50,206.
Electrical system, Engine, Fuel/propulsion system, Jun 14, 2025
I have searched the prior recalls and I’m having the same problem that were said to be fixed. I would like the car check again for the recalls that said to be fixed and checked for all reacalls . The car turns of unexpected without warning . At random times the low power mode is always on and when I push down in the pedal it doesn’t respond well at all . I have invested countless money into fixing issues with this car .
Engine and engine cooling, Engine, Jun 9, 2025
The contact owns a 2018 Chevrolet Malibu. The contact stated while driving at an undisclosed speed, the check engine and the turbo charger warning lights illuminated. The accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle was taken to an independent mechanic where it was diagnosed with turbo charger failure. The contact was informed that the turbo charger needed to be replaced. The vehicle was not repaired. The dealer was made aware of the failure but provided no assistance. The contact was instructed to schedule an appointment for diagnostic testing and provided the cost for the diagnostic test. The contact referenced an unknown recall; however, the VIN was not included. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 140,741.
Service brakes, Engine, Forward collision avoidance, May 1, 2025
loud knocking or banging noises, the check engine light turning on and/or other driving performance issues, such as reduced propulsion cranksaft
Engine, May 1, 2025
The contact owns a 2018 Chevrolet Malibu. The contact stated that the messages "Engine Power Reduced", "Shift to Park", and an unknown message were displayed intermittently. The contact stated that while her daughter was driving approximately 40 MPH and making a turn, the vehicle stalled. The driver was able to pull over to the side of the road. The vehicle failed to restart and was pushed to the residence. The vehicle was then towed to the dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired and was towed back to the residence. The manufacturer was not notified of the failure. The failure mileage was unknown.
Engine and engine cooling, Engine, Apr 30, 2025
The contact owns a 2018 Chevrolet Malibu. The contact stated that while driving at various speeds, several unknown warning lights were flashing on the instrument panel. The vehicle was taken to a dealer where a diagnostic test was performed, and the contact was informed that there was no oil in the vehicle. The contact refuted the mechanics findings and had the vehicle towed back to the residence. The contact then stated that while driving at 50 MPH, the vehicle lost power with the message "Engine Power Reduced" displayed. The contact pulled over to the shoulder and turned off the vehicle. After restarting the vehicle, the vehicle hesitated while depressing the accelerator pedal, and the failure reoccurred. Despite the failure, the contact was able to drive the vehicle back to the residence. The manufacturer was notified of the failure and the contact was informed that there was a warranty on the vehicle that covered the failure; however, the warranty had expired. The vehicle was not repaired. The failure mileage was approximately 141,000.
Power train, Engine, Fuel/propulsion system, Mar 31, 2025
I was going about 75 mph on the express way with one lane open due to construction. My car started losing power.I heard the chime and upon the dashboard were the words power reduced. My car slowed down in a matter of seconds to around 45 mph. A 18 wheeler was trailing behind me. I quickly jumped in the emergency lane to my right and took the next exit while riding the emergency lane. I shut the car off at the gas station, sat there for about 10 minutes, restarting my car helped temporarily. I was 3 hours away from home and had to drive back unknowingly if I will make it or not. I reached out to Chevrolet and was told to bring it in and leave it but they had no loaner cars for anyone at that time. I have replaced 2 sensors and now my start /stop has quit working. I spoke with 5 visitors at Chevrolet and we all were having the same issues. This is something ongoing according to my research on this particular vehicle and should be recalled asap.
Engine, Mar 4, 2025
The contact owns a 2018 Chevrolet Malibu. The contact stated that while the vehicle was parked, the contact noticed a gasoline odor coming from the vehicle. There was no warning light illuminated. The vehicle was towed to the dealer, where it was diagnosed that the injector seals had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 165,660.
Engine, Fuel system, Gasoline, Feb 19, 2025
The contact owns a 2018 Chevrolet Malibu. The contact stated that while on a trip and traveling at high altitudes, the check engine warning light was displayed on the instrument panel. The contact used a code reader which showed that the barometric pressure sensor was defective. Once the contact returned home, the mass air flow sensor was replaced. The following year while traveling in the same region at high altitude levels, the failure recurred. The contact also stated that the engine booster had started to fail due to ice accumulation in the charge air cooler (CAC), which restricted airflow. As a result of the failure, the vehicle failed to accelerate above 25 MPH. Upon investigation, the contact discovered Technical Service Bulletin No: 18-NA-069; which the contact linked to the failure. The dealer was notified of the failure, but the contact was informed that the vehicle was out of warranty. The manufacturer was also notified of the failure and referred the contact back to the dealer for assistance. The vehicle was not repaired. The failure mileage was approximately 76,000.
Fuel system, Gasoline, Electrical system, Engine, Feb 19, 2025
The contact owns a 2018 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The “Engine Power Reduced” message was displayed. The contact stated that the vehicle lost motive power. While driving 70 MPH, the vehicle decelerated to 45 MPH unintendedly. The vehicle was previously repaired under NHTSA Campaign Number: 19V642000 (ELECTRICAL SYSTEM, FUEL SYSTEM, GASOLINE, ENGINE). The local dealer was contacted and provided the contact with an estimate for a diagnostic test. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 186,000.
Power train, Electrical system, Engine, Jan 12, 2025
ENGINE POWER REDUCED light keeps coming on while driving and the car stalls and won't go over 20mph. Several repairs later and it is still happening almost daily. It has nearly caused an accident several times. This needs to be fixed and a recall for the issue needs to be issued by Chevy. With this many people experiencing this problem, why isn't Chevy obligated to address the issue?
Other or unspecified, Service brakes, Engine, Dec 20, 2024
I repeatedly get a “reduced power to engine” alert on my dash which causes my car to decelerate and I lose my power steering. This last time, the alert popped up on my dash, my car decelerated, and then my brakes would not work. I could not push the brake down to stop my car and ended up in a ditch. My brakes are now hard and I cannot start my car because of it. I have already had the recall for this issue fixed in the past but this will be the 3rd time I have brought my vehicle in for the same problem. I had diagnostic codes ran on my car soon after the accident happened and have attached the pictures to this form.
Electrical system, Electronic stability control (ESC), Engine, Dec 12, 2024
The contact owns a 2018 Chevrolet Malibu. The contact stated while coming to a complete stop, the engine auto Start/Stop system engaged, causing the engine to shut off; however, the electrical system then became inoperable. The contact stated that upon depressing the accelerator pedal to resume driving, the vehicle failed to respond as needed. Additionally, the contact stated that while coming to a stop, the vehicle failed to stop immediately and rolled to a stop. The stabili-trak and electronic stability control warning lights were illuminated. A message advising to open and to close the windows was displayed. The contact stated that the check engine warning light was illuminated. The vehicle was taken to AutoZone, where it was diagnosed that there were debris in the throttle. The contact was advised to drive at high speeds on the highway to correct the failure. The contact followed the instructions; however, the failure persisted. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 101,000.
Engine, Oct 1, 2024
Reduced engine power message pops up when I’m driving at 45 or lower speed. First time this happened was about 4 months ago, and couldn’t drive faster than 30 mph. After starting my vehicle a couple of times the message goes away. This reduced engine power message is almost a daily thing, but now it doesn’t affect my speed anymore, I can go at 65 mph and even with that warning light on.
Electrical system, Engine, Fuel/propulsion system, Sep 29, 2024
When parking it says shift to park even when I’m already in park. The dealer says it’s the shifter however after seeing numerous other vehicles with this issue I believe it’s electrical
Vehicle speed control, Service brakes, Engine, Aug 21, 2024
While driving th vehicle the component that ruptured was the vehicles vacuum brake booster pump which connected directly to the engine. The ruptured caused shards of metal to be launched into the engine resulting in no brake power and needs an engine swap. There was a recall on this model vehicle for the Pedal sensor malfunction that results in the cars engine going into a reduced power mode abruptly and suddenly while driving. This malfunction has occurred on this vehicle and I was not aware of this vehicle models recall history but it stated that the recall was successfully closed out in 2020. I purchased my 2018 Chevy Malibu in the year 2021 and the issue still persist. I am not confident that the recall on this vehicle was either fully completed or successfully fixed before purchasing. The car is now at the dealer and the repair team explains the vehicle needs a new engine. I questioned about the pedal sensor malfunction and asked if it was possible that this malfunction sending the vehicle into a reduced power mode so suddenly could have effected or cause wear and tear on brake booster pump connected to the engine. The dealers repair team wasn’t confident in saying it wasn’t possible. This is likely a design issue and if a recall was completed and I was sold a vehicle uninformed of this potential issue but the malfunction still persisted I do not believe I should have to cover the full cost of repairs for this chain of events. This malfunctioned put me at danger and if it had occurred while my wife and 3 children were in the car it could have been life threatening not only to us but the other drivers around as well. With the engine reduced you can’t accelerate and with the booster pump ruptures mid drive you lose all brake power. It is hard to understand the faulty design in this but I have read reviews that others have had the same issue so I do not believe I am alone in this.
Engine, Aug 8, 2024
Vehicle suddenly went into reduced engine power mode and nearly caused a crash. We pulled off to the side of the highway. Turned the car off and waited for about 5 minutes with our small children in the back seat. Restarted the car and check engine light remains on but the reduced engine power warning turned off. This just happened today and have not been to the dealership. Hoping Chevy recognizes this safety issue and issues a recall as many others have reported the same issue.
Fuel system, Gasoline, Electrical system, Engine, Aug 5, 2024
The contact owns a 2018 Chevrolet Malibu. The contact stated while driving approximately 60 MPH, the vehicle stalled. The contact stated there was no warning light illuminated. The contact stated that the vehicle was left on the side of the roadway. The contact called the dealer where the vehicle was purchased and was advised that he had to pay to have the vehicle towed. The vehicle was not taken to the dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact was aware of an open recall on the vehicle, NHTSA Campaign Number: 19V642000 (Electrical System, Fuel System, Gasoline, Engine). The failure mileage was unknown.
Power train, Engine, Jul 23, 2024
When putting my vehicle in park to turn off the car, a warning light comes on to put vehicle into park. The vehicle is already in park and am unable to turn off the vehicle. In order to turn off the engine I must repeatedly turn it on and off and hit the gear shifter multiple times. This problem is becoming more and more frequent. I see numerous other 2018 Malibus in the complaint section reporting the same issue. Come on Chevrolet fix this problem!
Electrical system, Other or unspecified, Engine, Jul 16, 2024
REDUCED POWER TO ENGINE . Previously had recall for this issue, which was replaced by Chevy service center. About a year later I had the same problem but had to pay out of pocket because there were no active recalls on the issue. As of today, I am receiving the same “REDUCED POWER TO ENGINE” error and check engine light keeps coming on. This happens randomly but frequently almost every single day. Error will shut off after restarting car and then happens again not long after. I’ve had this issue with multiple Chevy Malibus that I have owed and there is currently a class action lawsuit against GM for this exact issue.
Power train, Engine, Fuel/propulsion system, Jun 27, 2024
Car hesitant to crank, once the Start/ stop button is pushed, the car will start, run smooth for a second or two then start to shake and putter like it’s not getting fuel and loses it power and cuts off. I have to go through this process 5/6 times before the car will stay crunk. While driving Car will out the blue say reduced engine power and acts as if it does not want to pull or it is losing power! The car also has the eco saving feature where it cuts off at every stop and there is not an option be turned off and car is hesitant to start back up after it cuts off. Car is now starting to smoke from the tailpipe. The VVT intake and exhaust solienoids have oil getting into them and the PCV valve is about to crack open. The car throws codes like rich fuel intake, something to do with the catalytic system (in which I’ve put a brand new catalytic converter on the car and it did not solve the issue) it also throws codes about a throttle and cam sensors and a few more codes.. I see where there are recalls for the (same make, model,year, and engine size) but my cars VIN is not included with the recall! Can we please get this as I need my car and need this issue fixed as soon as possible as it is dangerous for me and my 2 year to travel in this vehicle.
Service brakes, Engine, Jun 17, 2024
Driving normal. Upon application of brakes, brake pedal became stiff and brakes did not function normal. Had to apply immense pressure to stop and it sounded like brakes kept locking up. Vacuum pump that supplies vacuum for engine with turbo to function, along with the brake booster to be able to apply normal braking power, was destroyed. The inside of the vacuum pump is in pieces and part of the bushing that connects into the engine was broken. Caused by faulty vacuum pump, or faulty cam shaft. If this had happened while in traffic, it is likely a crash would have happened. Damage caused to the vacuum pump resulted in metal pieces in the engine block as well.
Electrical system, Vehicle speed control, Engine, May 28, 2024
Since I got the car, if I let it go in auto stop, it has a hard time accelerating when I push the gas. It has gotten worse and now it has a hard time accelerating in general. When I push the gas it sounds really loud like it’s struggling to go. I realized this is a safety issue for me and others when my car wasn’t going at the light of a busy intersection, or when I’m getting onto a highway and my car isn’t picking up speed. This makes it scary for people already on the highway as Iam causing them to brake unexpectedly. Every time my check engine light comes on I take it to the dealership. It’s been taken in for repairs multiple times but this issue still keeps coming back.