2000 Dodge Durango
Problems, recalls and owner-reported issues
Suspension is the leading concern among 1,097 owner complaints filed for this model year. This is the 3rd highest complaint count among 25 Durango model years with reports.
Of the 2000 reports, 118 involved a crash and 26 involved a fire. 88 people were injured and 11 people died.
What owners report most often
Recalls and investigations
Suspension, front, hubOct 20, 2008
SKF IS RECALLING 2,805 HUB UNITS, PART NO. BR930361, SOLD AS A SERVICE PART FOR 1997-2004 DODGE DAKOTA VEHICLES AND 1999-2003 DODGE DURANGO VEHICLES EQUIPPED WITH 2-WHEEL DRIVE & REAR AXLE ABS. DUE TO A SPECIFICATION ERROR, THE ROTOR PILOT FOR THE HUB UNIT MAY BE TOO LONG. THIS RESULTS IN THE WHEEL TO NOT BE SEATED FULLY AGAINST THE HUB FLANGE FACE DURING MOUNTING.
IMPROPER SEATING OF THE WHEEL CAN RESULT IN EXCESSIVE VIBRATION, BRAKE ROTOR NOISE, DIFFICULTY REMOVING THE WHEEL AFTER INSTALLATION AND OPERATION OF THE VEHICLE, AND POSSIBLY WHEEL-END SEPARATION DURING VEHICLE OPERATION. SHOULD WHEEL-END SEPARATION OCCUR, THE DRIVER COULD LOOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH.
SKF WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE HUB UNITS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 5, 2008. OWNERS MAY CONTACT SKF VSM NORTH AMERICA CUSTOMER SERVICE AT 1-800-644-8999.
Campaign 08E064000 on NHTSA.gov
Engine and engine coolingMar 15, 2006
CERTAIN REPLACEMENT K&N FUEL PERFORMANCE KITS, P/NOS. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, AND 57-1530. ALSO, A SMALL PERCENTAGE OF THESE KITS WERE SOLD UNDER THE MOPAR PERFORMANCE PARTS BRAND NAME (P/NOS. P5007069 AND P5007070). ALL KITS WERE MANUFACTURED FROM APRIL 20, 1999, THROUGH SEPTEMBER 23, 2004. THESE ASSEMBLIES WERE MANUFACTURED AS REPLACEMENT EQUIPMENT FOR CERTAIN DODGE PICKUP TRUCKS AND SUVS. A SMALL PIECE OF MATERIAL FROM THE TUBE WALL COULD BE SUCKED INTO THE ENGINE THROTTLE BODY, WHICH COULD CAUSE THE THROTTLE TO BECOME JAMMED IN THE OPEN POSITION.
A JAMMED OPEN THROTTLE COULD CAUSE UNINTENDED ACCELERATION OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH OR INCREASED STOPING DISTANCES WHEN BRAKING.
K&N WILL PROVIDE OWNERS WITH A FREE REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS. THE RECALL BEGAN ON APRIL 20, 2006.
Campaign 06E024000 on NHTSA.gov
Suspension, front, control arm, upper ball jointDec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 04V596000 on NHTSA.gov
Air bagsMay 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 01V153000 on NHTSA.gov
Representative owner complaints: suspension
513 reports, newest first. Show all
Suspension, Oct 27, 2003
THERE WAS A SQUEAKING IN THE FRONT END. 9/02 THE SWAY BAR AND SWAY BAR BUSHINGS WERE REPLACED, ONLY 37,572 MILES ON IT. THE VEHICLE NOW SQUEEKS AGAIN IN THE FRONT END. IN ADDITION, WHILE DRIVING DOWN THE HIGHWAY, IT FEELS AS IF I'M DRIVING DOWN A BUMPY ROAD, THE FRONT TIRES ARE BOUNCING A LOT. BALL JOINTS? THIS IS A 2000 DODGE DURANGO THAT I BOUGHT BRAND NEW ON AUGUST 28, 2000. I WOULD LIKE TO SEE A RECALL ISSUED BY THE COMPANY TO FIX THIS PROBLEM.*AK
Suspension, Oct 27, 2003
HAD TO REPLACE ENTIRE FRONT-END ASSEMBLY ON 2000 DODGE DURANGO DUE TO PREMATURE WEAR.*AK
Suspension, Oct 27, 2003
2000 DODGE DURANGO RIGHT FRONT UPPER BALL JOINT FAILURE ONCE IN JULY 2002 2ND TIME JUNE 2003. *AK
Suspension, Oct 27, 2003
I JUST WATCHED THE EVENING NEWS AND THERE WAS AN INVESTIGATIVE REPORT ABOUT UPPER BALL JOINT PROBLEMS ON DODGE DURANGO 4X4'S. I HAVE THE FAILURE NOISE THAT THEY DESCRIBED AND I'M CONCERNED ABOUT FAILURE AT HIGH SPEED. I CALLED THE DEALER AND THERE IS NO RECALL AND I HAVE A FREIEND THAT JUST LOST A FRONT WHEEL ASSEMBLY DUE TO THIS FAILURE. THE COST TO REPAIR WAS $675 AND NOT COVERED BY DODGE. I AM CONCERENED FOR MY SAFETY! CAN YOU PROVIDE ANY INFORMATION? MY CAR HAS 37,000 MILES, JUST OUT OF WARRANTY.*AK
Suspension, Oct 26, 2003
FRONT BALL JOINT FAILED ON MY DURANGO AND THE TIRE COLLAPSED. *LA EA03-023
Steering, Suspension, Oct 24, 2003
I HAVE ALWAYS HAD PROBLEMS WITH MY DURANGO SINCE ABOUT 12,000 (NOW HAVE 68,000). REPLACEMENT OF BALL JOINTS, BRAKE CALIPERS, AND CONTINUOUS CHECKS FOR CLICKING AND VIBRATION FEELING IN THE STEERING COLUMN (MOSTLY WHEN TURNING LEFT). NOW I AM TOLD THAT I MUST INVEST $750. FOR A NEW POWER STEERING RACK. I DON'T MIND PAYING FOR NORMAL WEAR AND TEAR, BUT THIS HAS NOT BEEN RIGHT FROM THE START. I BELIEVE THERE IS SOMETHING DEFECTIVE WITH THE STEERING AND FRONT END. EACH TIME IT IS THE LEFT SIDE WITH THE PROBLEM. THIS JUST DOES NOT SEEM RIGHT. I HAVE ENJOYED MY DURANGO EXCEPT FOR THESE FRONT END PROBLEMS. I AM NOW TO THE POINT OF SELLING AT A LOSS SINCE I DO NOT FEEL SAFE DRIVING MY DURANGO. THE STEERING MAKES NOISES AND HAS A FUNNY RESPONSE TO THE TURNING PROCESS. COULD YOU PLEASE REVIEW CLOSER AT LEAST FOR THOSE WHO WILL STILL BE OWNING A DURANGO. *LA
Suspension, Oct 21, 2003
WHEN TURNING IN EITHER DIRECTION WITH MINOR ROAD IMPERFECTIONS, VEHICLE JUMPS AND PULLS TO THE OPPOSITE DIRECTION. ALSO A NOISE CAN BE HEARD COMING FROM THE REAR OF VEHICLE. CAUSE OF THE PROBLEM HAS NOT BEEN DETERMINED. *AK VEHICLE WOULD DRIFT DANGEROUSLY INTO OPPOSITE LANES WHEN SLIGHT ROAD BUMPS ARE PRESENT. CONSUMER STATED TIRE AND SUSPENSION SEEM TO BE BOUNCING MORE THAN NORMAL. TIRE PRESSURE WAS CHANGED FROM 31 PSI TO 40 PSI WITH NO IMPROVEMENT TO WHEEL BOUNCE. *PH *NLM
Suspension, Oct 12, 2003
VEHICLE EXPERIENCED BALL JOINT FAILURE.*MR THE CONSUMER WAS TOLD BY THE DEALERSHIP, THEY WERE UNABLE TO PERFORM AN ALIGNMENT BECAUSE OF THE WORN BALL JOINTS.*TS *JB
Suspension, Oct 12, 2003
WHILE DRIVING, THE UPPER BALL JOINT FAILED, WHICH CAUSED THE CONSUMER TO LOSE CONTROL OF THE VEHICLE. *JB THE UPPER AND LOWER BALL JOINTS ON BOTH SIDES WERE REPLACED. *TS *NLM
Suspension, Oct 9, 2003
PE 03-032: FRONT SUSPENSION: UPPER BALL JOINTS. THE UPPER BALL JOINTS WORE OUT PREMATURELY.*AK
Suspension, Oct 6, 2003
THE BALL JOINT HOLDING WHEEL ON VERTICAL AXLE FAILED CAUSING WHEEL TO TILT 45 DEGREES FROM A STRAIGHT ANGLE. LUCKILY THIS HAPPENED WHEN MY WIFE WAS LEAVING THE GROCERY PARKING LOT AND WAS NOT ON MAIN ROAD DRIVING HIGHER SPEED, OTHERWISE COULD HAVE BEEN FATAL. *JB EA03-023
Suspension, Oct 5, 2003
UPPER BALL JOINT FAILURE ON MY 2000 DODGE DURANGO. FOR A WHILE, WE WERE HEARING A POPPING NOISE WHEN WE WOULD PULL OUT OF THE DRIVEWAY. UPON INSPECTION, I COULD FIND NOTHING WRONG. THE PROBLEM GOT PROGRESSIVELY WORSE. I FINALLY FIGURED OUT IT WAS THE UPPER BALL JOINT BECAUSE I CAN GRAB THE TOP OF THE FRONT WHEEL AND MOVE IT BACK AND FORTH PERPENDICULAR ABOUT 1/8 INCH. I CAN LOOK AT THE UPPER BALL JOINT AND SEE THIS IS WHERE THE EXCESSIVE MOVEMENT IS COMING FROM. I'M GOING TO REPLACE THE BALL JOINT THIS WEEK. AS YOU CAN EXPECT, THIS IS THE LAST CHRYSLER VEHICLE THAT I PURCHASE. I HAVE THE ORIGINAL BALL JOINT FOR INSPECTION IF IT WOULD BE HELPFUL. *JB
Suspension, Tires, Oct 1, 2003, crash
CONSUMER COMPLAINED ABOUT FRONT SUSPENSION PROBLEM. THE FRONT LEFT TIRE COLLAPSED WHILE DRIVING AT 25 MPH AND CAUSED THE CONSUMER TO LOSE CONTROL OF THE VEHICLE. THE DRIVER WAS BADLY INJURED. THE MANUFACTURER WAS CONTACTED WHO INVESTIGATED THE CAUSE. *AK *JB
Suspension, Oct 1, 2003
THE UPPER BALL JOINTS EXPERIENCED PREMATURE FAILURE AND CAUSED THE FRONT END TO COLLAPSE. *AK *JB EA03-023
Suspension, Oct 1, 2003
THE VEHICLE EXPERIENCED FAILURE OF THE FRONT END AT 45000 MILES AND HAD TO HAVE THE UPPER/LOWER BALL JOINTS AND LOWER CONTROL ARM REPLACED. THE VEHICLE IS CURRENTLY EXPERIENCING PROBLEMS WITH THE FRONT END AGAIN. THE VEHICLE FEELS AS IF RIDING ON "CLOUDS" WHEN DRIVING, EVEN ON DRY PAVEMENT. CONSUMER DOES NOT HAVE COMPLETE CONTROL OF MOVEMENT WHEN DRIVING. WHILE DRIVING ON UNEVEN ROAD THE SUSPENSION FELT VERY LOOSE. *AK *NLM
Suspension, Sep 30, 2003
HAD TAKEN VEHICLE FOR ROUTINE CHECKAND MECHANIC INDICATED THAT FRONT UPPER BALL JOINTS WORE OUT COMPLETELY. BALL JOINTS WOULD NEED TO BE REPAIRED OR REPLACED.*AK
Suspension, Sep 29, 2003
SUSPENSION FRONT CONTROL ARM UPPER BALL JOINTS ON BOTH SIDES FRONT WORN OUT. MILEAGE AT TIME OF INCIDENT WAS 37,655. VEHICLE WAS TAKEN IN FOR NEW TIRES AT A LOCAL NTB WHEN THE PROBLEM WAS DISCOVERED.
Suspension, Sep 24, 2003
WHEEL BEARING WEARS OUT PREMATURELY, CAUSING HUB NUTS TO LOOSEN. *AK
Suspension, Sep 19, 2003
TODAY HAD TO HAVE NEW FRONT UPPER BALL JOINTS, PART#K7242CQ, APPLIED TO MY 2000 DODGE DURANGO. I WAS TOLD THAT THERE WAS AT LEAST 1400 BALL JOINTS ON BACK ORDER NATION WIDE AND THEY DID NOT KNOW WHEN THEY WOULD BE ABLE TO GET ANY IN. THANKS TO THE HARD WORK OF HUB TIRE IN ST. JOHNS MICHIGAN THEY FOUND TWO BALL JOINTS AT A CARQUEST STORE IN ST. JOHNS THAT WOULD FIT MY DURANGO, WE GOT LUCKY. THEY GOT THESE AND GOT THEM INSTALLED. MY DURANGO ONLY HAS 57,000 MILES ON IT AND THE RIGHT SIDE BALL JOINT WAS SO BAD THAT THEY WOULD NOT LET ME DRIVE IT HOME AS IT WAS THAT UNSAFE. WITH THERE BEING OVER 1400 BALL JOINTS ON A NATION WIDE BACK ORDER I THINK THERE IS A REAL BAD PROBLEM WITH THE BALL JOINTS AND THIS SERIOUS MATTER NEEDS TO BE LOOKED INTO. IF SOMEONE'S BALL JOINTS DO BREAK GOING DOWN THE ROAD THIS COULD CASE A SERIOUS IF NOT FATAL ACCIDENT. THANK YOU. *JB
Suspension, Sep 15, 2003
I HAVE A 2000 DURANGO SLT PLUS, I TOOK THE VEHICLE INTO THE LOCAL TIRE SHOP TO HAVE THE FRONT END ALIGNED BECAUSE OF EXCESSIVE TIRE WEAR. THE SERVICE DEPT STATED THEY WOULD NOT ALIGN THE VEHICLE BECAUSE OF THE CONDITION OF THE UPPER BALL JOINTS. THE TRUCK ONLY HAS 45,000 MILES ON IT. THEY ALSO STATED THEY WOULD NOT DRIVE IT UNTIL THEY ARE REPLACED.
Suspension, Sep 15, 2003
THE CONSUMER TOOK THE VEHICLE TO THE DEALERSHIP TO HAVE THE UPPER BALL JOINTS INSPECTED. THE DRIVER'S SIDE UPPER BALL JOINT EXPERIENCED PREMATURE WEAR. *AK *PH *JB
Suspension, Sep 15, 2003
PE 03-032 FRONT SUSPENSION UPPER BALL JOINT: VEHICLE EXPERIENCED COMPLETE UPPER BALL JOINT FAILURE, WHICH CAUSED WHEEL SEPARATION, ALMOST RESULTING IN LOSS OF CONTROL. *AK THE STEERING BECAME LOSE AND THE TIRE FELL FLAT TO THE GROUND. *PH *JB EA03-023
Suspension, Sep 15, 2003
CONSUMER STATED THE UPPER BALL JOINT EXPERIENCED PREMATURE WEAR. DEALER NOTIFIED.*AK WHILE GOING SLOWLY OVER A SPEED BUMP, THE RIGHT UPPER BALL JOINT BROKE, WHICH LEFT THE TIRE IN A 45 DEGREE ANGLE. CONSUMER LATER LEARNED THAT THE JOINT WASN'T PACKED PROPERLY WITH GREASE FROM THE FACTORY. BOTH BALL JOINTS WERE REPLACED AT NO COST TO THE CONSUMER. *PH *JB EA03-023
Suspension, Sep 12, 2003
PE 03-032, FRONT SUSPENSION UPPER BALL JOINT FAILURE: THE UPPER BALL JOINTS WORE OUT PREMATURELY. *AK *SCC *JB
Suspension, Sep 12, 2003
PE 03-032, FRONT SUSPENSION UPPER BALL JOINT FAILURE: THE UPPER BALL JOINTS PREMATURELY WORE OUT AND THE WHEEL SEPARATED. *AK THE FRONT END VIBRATED WHILE DRIVING. BOTH UPPER AND LOWER BALL JOINTS WERE DIAGNOSED AS BAD. *PH *JB EA03-023