2000 Dodge Durango
Problems, recalls and owner-reported issues
Suspension is the leading concern among 1,097 owner complaints filed for this model year. This is the 3rd highest complaint count among 25 Durango model years with reports.
Of the 2000 reports, 118 involved a crash and 26 involved a fire. 88 people were injured and 11 people died.
What owners report most often
Recalls and investigations
Suspension, front, hubOct 20, 2008
SKF IS RECALLING 2,805 HUB UNITS, PART NO. BR930361, SOLD AS A SERVICE PART FOR 1997-2004 DODGE DAKOTA VEHICLES AND 1999-2003 DODGE DURANGO VEHICLES EQUIPPED WITH 2-WHEEL DRIVE & REAR AXLE ABS. DUE TO A SPECIFICATION ERROR, THE ROTOR PILOT FOR THE HUB UNIT MAY BE TOO LONG. THIS RESULTS IN THE WHEEL TO NOT BE SEATED FULLY AGAINST THE HUB FLANGE FACE DURING MOUNTING.
IMPROPER SEATING OF THE WHEEL CAN RESULT IN EXCESSIVE VIBRATION, BRAKE ROTOR NOISE, DIFFICULTY REMOVING THE WHEEL AFTER INSTALLATION AND OPERATION OF THE VEHICLE, AND POSSIBLY WHEEL-END SEPARATION DURING VEHICLE OPERATION. SHOULD WHEEL-END SEPARATION OCCUR, THE DRIVER COULD LOOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH.
SKF WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE HUB UNITS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 5, 2008. OWNERS MAY CONTACT SKF VSM NORTH AMERICA CUSTOMER SERVICE AT 1-800-644-8999.
Campaign 08E064000 on NHTSA.gov
Engine and engine coolingMar 15, 2006
CERTAIN REPLACEMENT K&N FUEL PERFORMANCE KITS, P/NOS. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, AND 57-1530. ALSO, A SMALL PERCENTAGE OF THESE KITS WERE SOLD UNDER THE MOPAR PERFORMANCE PARTS BRAND NAME (P/NOS. P5007069 AND P5007070). ALL KITS WERE MANUFACTURED FROM APRIL 20, 1999, THROUGH SEPTEMBER 23, 2004. THESE ASSEMBLIES WERE MANUFACTURED AS REPLACEMENT EQUIPMENT FOR CERTAIN DODGE PICKUP TRUCKS AND SUVS. A SMALL PIECE OF MATERIAL FROM THE TUBE WALL COULD BE SUCKED INTO THE ENGINE THROTTLE BODY, WHICH COULD CAUSE THE THROTTLE TO BECOME JAMMED IN THE OPEN POSITION.
A JAMMED OPEN THROTTLE COULD CAUSE UNINTENDED ACCELERATION OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH OR INCREASED STOPING DISTANCES WHEN BRAKING.
K&N WILL PROVIDE OWNERS WITH A FREE REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS. THE RECALL BEGAN ON APRIL 20, 2006.
Campaign 06E024000 on NHTSA.gov
Suspension, front, control arm, upper ball jointDec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 04V596000 on NHTSA.gov
Air bagsMay 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 01V153000 on NHTSA.gov
Representative owner complaints: suspension
513 reports, newest first. Show all
Suspension, Jul 15, 2004
WHILE DRIVING 10 MPH, THE CONSUMER HEARD A LOUD POPPING NOISE COMING FROM THE FRONT OF THE VEHICLE. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND PULLED OVER. THE CONSUMER, WHO WAS A MECHANIC, INSPECTED THE VEHICLE AND NOTICED THAT THE UPPER FRONT BALL JOINT NEEDED TO BE REPLACED DUE TO WORN OUT PARTS. *AK AFTER THE REMOVAL OF THE RIGHT SIDE UPPER BALL JOINTS, THEY APPEARED TO HAVE NEVER BEEN LUBED AT THE ASSEMBLY LINE. *SC *JB
Steering, Suspension, Jul 15, 2004
WHILE DRIVING, THE CONSUMER HEARD NOISES COMING FROM THE FRONT OF THE VEHICLE. THE CONSUMER TOOK THE VEHICLE TO THE DEALER FOR INSPECTION AND TR MECHANIC DETERMINED THAT BOTH UPPER BALL JOINTS FAILED. *AK THERE WAS NO WARNING. THE UPPER BALL JOINT SEPARATED UNDER NORMAL CONDITIONS. THERE WAS DAMAGE IN THE LEFT FRONT SUSPENSION, STEERING GEAR, CONTROL ARM, AND THE AXLE SHAFT WERE ALL REPLACED. *SC *JB
Suspension, Jul 12, 2004
BOTH FRONT HUBS ARE BAD CAUSING BOTH TIRES TO WOBBLE AND SWAY ON TURNS. TIRES ARE NOW WORN OUT COMPLETELY ON INSIDE. *LA
Suspension, Jul 8, 2004
UPPER AND LOWER BALL JOINTS FAILED INSPECTION. MY CAR HAS ONLY 36,000 MILES. THERE HAS NEVER BEEN ANY INDICATION THAT THERE WAS A PROBLEM WITH MY CAR(IN OPPOSITON TO CHRYSLER'S CLAIM THAT OWNERS WILL BE ABLE TO TELL). *AK
Suspension, Jul 7, 2004
UPPER AND LOWER SUSPENSION BALL JOINTS ARE OUT OF SPECIFICATION AND PREMATURE WEARING. DEALER INFORMS ME THIS IS A FREQUENT AND RECURRING PROBLEM WITH DURANGOS AND CAN LEAD TO SERIOUS FRONT END LOSS OF VEHICLE CONTROL. IF THE DEALER SAYS THIS IS A RECURRING PROBLEM, HOW CAN THIS NOT BE A RECALL ITEM?*AK
Suspension, Jun 29, 2004
WHILE VEHICLE WAS GOING THROUGH STATE INSPECTION TECHNICIAN NOTICED THAT ONE OF THE WHEELS WAS WOBBLY, AND TECHNICIAN DETERMINED THAT THE BALL JOINTS NEEDED TO BE REPLACED. *AK
Suspension, Jun 29, 2004
DURING A VEHICLE INSPECTION, THE INSPECTOR FOUND THAT THE UPPER AND LOWER BALL JOINTS WERE WORN OUT. THE UPPER AND LOWER BALL JOINTS WERE REPLACED. *AK *SC *JB
Suspension, Jun 24, 2004
WHILE DRIVING AT 20 MPH, THE CONSUMER STOPPED AT A STOP SIGN. THE CONSUMER MADE A LEFT TURN AND THE RIGHT FRONT WHEEL SEPARATED FROM THE AXLE. A MECHANIC DETERMINED THAT THE UPPER AND LOWER BALL JOINTS NEEDED TO BE REPLACED. *AK *SC *JB
Suspension, Jun 23, 2004
WHILE HAVING VEHICLE SERVICED TECHNICIAN DETERMINED THAT UPPER AND LOWER BALL JOINTS NEEDED TO BE REPLACED. *AK
Suspension, Jun 17, 2004
PURCHASED MY SLIGHTLY USED DURANGO IN JUNE 2003. IMMEDIATELY FELT THE STEERING WAS "LOOSE". TOOK IT TO THE DEALERSHIP ON SEVERAL OCCASIONS AND THEY SAID THERE WERE NO PROBLEMS THEY COULD SEE. HAD MY CAR INSPECTED 11 MONTHS LATER AND IT FAILED B/C THE LEFT BALL JOINT WAS BAD. LUCKILY, I HAD PURCHASED THE EXTENDED WARRANTY OR IT WOULD'VE BEEN A HEFTY FEE TO REPLACE. IT'S BEEN 1 MONTH SINCE THAT REPLACEMENT AND STILL CAN'T CONTROL THE STEERING WHEN GOING OVER BUMPS IN THE ROAD OR TURNING. I'M TAKING MY DURANGO BACK TO THE DEALERSHIP ON SATURDAY FOR THEM TO TAKE ANOTHER LOOK TO SEE IF MAYBE THERE ARE MORE BALL JOINTS OR SOMETHING ELSE WRONG WITH THE STEERING. *JB
Suspension, Jun 16, 2004, crash
WHILE PULLING OUT OF A PARKING LOT THE FRONT SUSPENSION BROKE ON THE DRIVER'S SIDE. THIS CAUSED THE FRONT DRIVER'S SIDE RIM TO BREAK, THE WHEEL TO TURN OUTWARDS, AND TIRE WENT FLAT. THIS RESULTED IN THE VEHICLE HITTING A POLE. THIS MAY HAVE BEEN CAUSED BY BALL JOINT FAILURE. *AK
Suspension, Jun 14, 2004
WHILE DRIVING AT ANY SPEED CONSUMER HEARD A LOUD NOISE COMING FROM THE FRONT END. INDEPENDENT MECHANIC INFORMED CONSUMER THAT FRONT LOWER ARM BALL JOINT AND UPPER ARM BALL JOINT WORE OUT, AND NEEDED TO BE REPLACED. *AK
Suspension, Jun 13, 2004
2000 DODGE DURANGO BALL JOINT FAILURE. 49,000 MILES ON IT AND THE BALL JOINTS NEED REPLACING. CHRYSLER NEEDS TO RECALL THESE AND FIX THEM. *AK
Suspension, Jun 3, 2004
AT 38000 MILES CONSUMER REPLACED PASSENGER AND DRIVER SIDE UPPER AND LOWER BALL JOINTS. AT 84000 MILES TECHNICIAN INDICATED NEEDED TO BE REPLACE ALL FOUR BALL JOINTS. *NM
Suspension, Jun 2, 2004
BALL JOINTS. UPON ROUTINE MAINTENANCE AND REPORTS OF FAILURES ON THE DODGE DURANGOS I RECENTLY CHECK THE FRONT SUSPENSION ON MY PERSONAL VEHICLE TO FIND THREE OF THE FOUR BALL JOINTS WITH EXTENSIVE WEAR. ONE TO THE POINT WHERE SEPARATION IS POSSIBLE. BEING IN THE REPAIR AND MAINTENANCE INDUSTRY FOR OVER 25 YEARS I FIND DODGES RESPONSE TO THIS MATTER NOT TO BE COMPLETELY CORRECT. DODGE CLAIMS A FRONT END NOISE SHOULD BE HEARD AND THAT SEPARATION WILL ONLY OCCUR WITH SHARP HARD TURNS IS NOT ALWAYS THE CASE. THEY CLAIM THE DESIGN OF THE CONTROL ARMS MAKE IT ALMOST IMPOSSIBLE TO SEPARATE WOULD ONLY HOLD TRUE IF SPRING PRESSURE WAS APPLIED ON THE UPPER CONTROL ARM, WHICH IT HAS NONE. THEY CLAIM THAT WATER WASHES THE LUBRICANT OUT OF THE JOINT. IF THE JOINT HAD BEEN PRODUCED PROPERLY WATER SHOULD NOT BE ABLE TO ENTER THE JOINT, IF THE JOINT WAS ABLE TO BE LUBRICATED IT WOULD REDUCE THIS PROBLEM, AS WEAR IS FROM LACK OF LUBRICANT MORE THAN WATER. I FEEL LIKE THE COST OF REPAIRS TO THESE VEHICLES SHOULD NOT BE THE CONSUMERS, BUT THE MANUFACTURES RESPONSIBILITYS AS IT IS APPARENT THEY HAVE THE PROBLEM AND IS HOLDING THE BLIND EYE TO IT. ONCE THE JOINTS ARE REPLACED THEY WILL BE AVAILABLE. *AK
Suspension, May 24, 2004
WHILE DRIVING A POPPING NOISE WAS HEARD COMING FROM THE FRONT. CONSUMER DROVE THE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED BOTH FRONTAL UPPER AND LOWER BALL JOINTS NEEDED TO BE REPLACED DUE TO CORROSION. *AK
Suspension, May 17, 2004
WHILE DRIVING CONSUMER HEARD A POPPING NOISE COMING FROM THE REAR, AND VEHICLE VIBRATED UNCONTROLLABLY. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND PULLED OVER. CONSUMER NOTICED THAT THE PASSENGER FRONT TIRE FELT OFF. VEHICLE WAS TOWED HOME. THE FRONT PASSENGER UPPER BALL JOINT BROKE. *AK
Suspension, May 17, 2004
I HAVE HAD TO RECENTLY REPLACE THE WHOLE FRONT SUSPENSION ON MY 2000 DODGE DURANGO NOT LIMITED TO THE BALL JOINTS. ALL BALL JOINTS, BOTH UPPER AND LOWER, PLUS THE CONTROL ARMS, AND FRONT SHOCKS HAD TO BE REPLACED. THE TOTAL REPAIR BILL WAS $1200.00 TO REPAIR THIS PROBLEM, AND DUE TO THIS I WILL PROBABLY NEVER BUY A DODGE PRODUCT AGAIN. *AK
Suspension, May 12, 2004
HEARD SQEAKING IN THE FRONT END FOR THE PAST YEAR. BROUGHT IN VEHICLE TO DEALER TODAY 5/12/04 FOR NEW TIRES AND BRAKES. WHEN CART WAS HOISTED ON LIFT FRON RIGHT TIRE FELL OFF DUE TO BALL JOINT SEPERATION AND FAILURE. DEALER STAED FRONT LEFT WAS ALSO BAD
Suspension, May 11, 2004
THE CONSUMER HEARD A NOISE IN THE FRONT OF THE TRUCK. THE CONSUMER BELIEVED THAT THE PROBLEM MAY HAVE BEEN THE BALL JOINTS. AFTER THE CONSUMER HAD BEEN LOOKING ON THE WEB TO FIND A POSSIBLE SOURCE OF NOISE AND RESEARCHED THE BALL JOINTS WHICH HE UNEXPECTEDLY FOUND TO BE SEALED AND UNABLE TO LUBRICATE. THE CONSUMER SPOKE WITH A DEALER ABOUT THE NOISE. THE CONSUMER HAD NOT TAKEN THE VEHICLE TO THE DEALER. *JB THE VEHICLE EXPERIENCED UNEVEN TIRE WEAR. *SC *JB
Suspension, May 10, 2004
SHAKING WHEN DRIVING AT ALL SPEEDS. TOOK VEHICLE INTO DEALERSHIP. UPPER AND LOWER BALL JOINTS BAD, LOOSE TIE ROD ENDS,SWAY BAR BUSINGS GONE BAD. PAID TO HAVE DEALERSHIP FIX VEHICLE DUE TO NO RECALL ISSUED. *LA
Suspension, Apr 30, 2004
I WAS MAKING A LEFT HAND TURN ACROSS 2 LANES OF TRAFFIC INTO A PARKING LOT. THERE WAS A SMALL DIP AT THE ENTRANCE AND THEN THE AREA LEVELED OFF. I WAS GOING ABOUT 10MPH AND AS MY FRONT END CAME OUT OF THE DIP, THE FRONT RIGHT SIDE OF MY VEHICLE COLLAPSED. I WAS TOWED TO THE DEALER. AFTER THE DAMAGE SURVEY WAS COMPLETE, I WAS TOLD THE BALL JOINT HAD FAILED. THERE WAS EXTENSIVE DAMAGE TO THE WHEEL, AXEL, BRAKES AND BALL JOINT. THE BALL JOINTS WERE PREVIOUSLY INSPECTED IN JAN 2004. I WAS TOLD BY THE DEALER THAT THEY WERE FINE. *LA
Suspension, Apr 29, 2004
THE VEHICLE'S LOWER BALL JOINTS FAIL WITHOUT WARNING. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM THE CONSUMER HAD REPLACED THE UPPER AND LOWER BALL JOINT 6 MONTHS PRIOR TO THE SECOND FAILURE. THE LOWER BALL JOINTS WERE SO BAD THAT THE ONE ON THE DRIVER'S SIDE WAS ABOUT TO FALL OFF. THE CONSUMER FEELS THESE NEED TO BE RECALLED. *NM
Suspension, Apr 29, 2004
CONSUMER STATES THAT UPPER BALL JOINT IS WEARING PREMATURELY. DEALER NOTIFIED.*AK THE DEALER REPLACED THE UPPER AND LOWER BALL JOINTS. *NM
Suspension, Apr 26, 2004
UPPER CONTROL ARMS NEEDED TO BE REPLACED. *PH THE CONSUMER COMPLAINED ABOUT FRONT END NOISES SHORTLY AFTER THE VEHICLE WAS PURCHASED. *JB