2012 Dodge Durango
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 640 owner complaints filed for this model year. This is the 9th highest complaint count among 25 Durango model years with reports.
Of the 2012 reports, 17 involved a crash and 32 involved a fire. 16 people were injured.
What owners report most often
Recalls and investigations
Electrical systemNov 14, 2019
Chrysler (FCA US LLC) is recalling certain 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles equipped with a 3.6, 5.7, or 6.4 liter engine and previously recalled under NHTSA Recall 14V530 or 15V115. The fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without warning.
A vehicle stall increases the risk of a crash.
Chrysler (FCA US LLC) will replace the affected fuel pump relay and related wire harness. Interim notices informing owners of the safety risk were mailed beginning December 19, 2019. Vehicles that experience a fuel pump failure will receive an interim repair. Owners will receive a second notice when the final remedy becomes available. Owner notification letters were mailed on December 10, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V62.
Campaign 19V813000 on NHTSA.gov
Service brakesSep 18, 2017
Chrysler (FCA US LLC) is recalling certain 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles. The affected vehicles had brake booster shields installed under a previous campaign to prevent water from entering the brake booster and limiting braking ability. This recall is to verify that the brake booster shield installation was performed properly.
If the brake booster shield was not installed properly, the vehicle's braking ability may be reduced, increasing the risk of a crash.
Chrysler will notify owners, and dealers will inspect the brake booster shield, correcting the installation as necessary, free of charge. The recall began November10, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T59.
Campaign 17V572000 on NHTSA.gov
Electrical system, alternator/generator/regulatorJul 10, 2017
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Dodge Challenger, Dodge Charger, Chrysler 300, Dodge Durango, and 2012-2014 Jeep Grand Cherokee vehicles. The affected vehicles have electro-hydraulic power steering (EHPS) and are equipped with a 5.7L or a 3.6L engine and a 160, 180 or 220 amp alternator. In the affected vehicles, the alternator may suddenly fail.
If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash. There is also the possibility that the alternator may short circuit, increasing the risk of a fire.
Chrysler will notify owners, and dealers will inspect the alternator and depending on the part number, will replace the alternator, if necessary, free of charge. The recall began February 12, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T36.
Campaign 17V435000 on NHTSA.gov
Electrical system, wiringDec 28, 2015
Chrysler (FCA US LLC) is recalling certain model year 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured December 3, 2009, to September 1, 2012. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after having been remedied for a prior recall for the vanity lamp wiring. This recall is also addressing certain vehicles that have not been remedied under that prior recall.
The vanity lamp wiring may short, increasing the risk of a vehicle fire.
Chrysler will notify owners, and dealer will install clearance for sun visor wiring, protection from sharp edges, and replace the sun visor, free of charge. The recall began on July 28, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R71.
Campaign 15V879000 on NHTSA.gov
Electrical systemFeb 27, 2015
Chrysler (FCA US LLC) is recalling certain model year 2012-2013 Jeep Grand Cherokee vehicles manufactured September 17, 2010, to August 19, 2013, and equipped with a 3.6, 5.7 or 6.4 liter engine, and 2012-2013 Dodge Durango vehicles manufactured January 18, 2011, to August 19, 2013, and equipped with a 3.6 or 5.7 liter engine. In the affected vehicles, the fuel pump relay inside the Totally Integrated Power Module (TIPM-7) may fail, causing the vehicle to stall without warning.
A vehicle stall increases the risk of a crash.
Chrysler will notify owners, and dealers will replace the fuel pump relay with one external to the TIPM. The recall began on August 7, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R09. Note: This recall is an expansion of recall 14V-530. Note: This recall has been superseded by recall 19V813.
Campaign 15V115000 on NHTSA.gov
Electrical system, alternator/generator/regulatorOct 8, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Chrysler 300, Dodge Charger, Challenger, and Durango; and 2012-2014 Jeep Grand Cherokee vehicles manufactured April 22, 2010, to January 2, 2014, and equipped with a 3.6L engine and a 160 amp alternator. In the affected vehicles, the alternator may suddenly fail.
If the alternator fails, the vehicle may stall without warning, increasing the risk of a crash.
Chrysler has notified owners, and dealers will replace the alternator, free of charge. The recall began on February 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P60.
Campaign 14V634000 on NHTSA.gov
Electrical system, wiringJul 2, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Dodge Durango and Jeep Grand Cherokee vehicles manufactured January 5, 2010, through December 11, 2013. In the affected vehicles, the wiring for the vanity lamp in the sun visor may short circuit, after a service repair is performed.
If the vanity lamp wiring shorts, there is an increased risk of fire.
Chrysler will notify owners, and dealers will inspect and repair any damaged wiring, and install a new sun visor that properly routes the wire, free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P36.
Campaign 14V391000 on NHTSA.gov
Service brakesApr 1, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured from January 5, 2010, through September 8, 2013. The subject vehicles have a brake booster with a center shell that may corrode and allow water to get inside.
The water inside could freeze and limit the braking ability of the vehicle, increasing the risk of a crash.
Chrysler will notify owners, and dealers will add a water diverter shield to the booster after the booster has been tested to confirm it can hold an acceptable amount of vacuum pressure. If the booster inspection confirms an unacceptable loss of vacuum pressure, the booster will be replaced. Repairs will be made free of charge. The recall began on May 30, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is P14.
Campaign 14V154000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slipMar 4, 2014
Chrysler Group LLC (Chrysler) is recalling certain model year 2012-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured October 11, 2011, through October 1, 2012. Under certain braking events, the Ready Alert Braking System (RAB) may result in the driver experiencing a hard brake pedal feel.
If the driver experiences a hard brake pedal, the driver may not push the pedal as intended, lengthening the distance needed to stop the vehicle and increasing the risk of a crash.
Chrysler will notify owners, and dealers will update the ABS module software, free of charge. The recall began on April 3, 2014. Owners may contact Chrysler at 1-800-853-1403. Chrysler's number associated with this recall is P05.
Campaign 14V104000 on NHTSA.gov
Engine and engine coolingSep 29, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.
CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.
CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Campaign 11V487000 on NHTSA.gov
Representative owner complaints
640 reports, newest first.
Fuel/propulsion system, Apr 16, 2023
Vehicle has been recalled 2 separate times for fuel pump wiring harness which causes no start and possible stall. Vehicle is still having no start issues after being serviced for recall.
Steering, Electrical system, Other or unspecified, Apr 10, 2023
I’ll be driving down the road and my car just shuts off. Steering becomes tight, no engine lights come on radio is still playing no warning except driving down the road and all of a sudden you can’t steer. It’s very dangerous especially when it happens while you are driving around the curve with children in the car. My mechanic can’t tell me why this happens. No explanation. This has happen several times
Seats, Mar 21, 2023
The truck was in park and idling. We were not moving. There were no abnormal lights on the gage cluster. Out of knowwhere the head rest exploded forward and hit the back of my father-in-laws head. He is OK but it was a hard hit and left him sore. Luckily we were not driving on the freeway.
Engine, Jan 4, 2023, fire
While driving at various speeds, upon slowing down the vehicle stalled. This occurred 50+ times. This occurred while my family was in the vehicle on many occasions. Vehicle was serviced for fuel pump recall, however the stalling continued. My mechanic pointed out the ticking noise, referring to the manifold needing repair. Most recently, the car barely wanted to turn over. Struggling for almost 3 days, thankfully I just pulled into my driveway and turn the car off. Then something told me to try to start the vehicle…well that made something smoke in the motor? Repaired the alternator, battery, and starter. Two days later, check oil light comes on, Back to shop to tell me the cam shaft/lifers need to be replaced!!! Quoted $35-4000 if can find a cam shaft repair kit!!!
Engine, Dec 28, 2022
The contact owns a 2012 Dodge Durango. The contact stated that while driving at various speeds, the vehicle suddenly lost motive power and stalled without warning. The contact stated that after restarting the vehicle, the vehicle operated normally. The cause of the failure was not yet determined. The vehicle was taken to the local dealer to be serviced but no additional information was available. The manufacturer was not notified of the failure. The failure mileage was 171,000.
Power train, Electrical system, Engine, Dec 25, 2022
This family car had recall back in august fuel module for powertrain check engine light got it fix and few days later check engine turn on and has turned off since car slows down on freeway wont pick up speed and stall on me twice already with kids in car was going 65 and all sudden slow down wiuldnt pick up acceleration and turn off has run good since still having issues dealership says noting wrong with it
Electrical system, Nov 16, 2022
The contact owns a 2012 Dodge Durango. The contact stated while driving approximately 30 MPH, the battery warning light had illuminated, and the contact notices a burning plastic odor. The contact pulled over and opened the hood and saw black smoke coming from the alternator. The contact stated that he disconnected the negative battery cable; however, he stated that positive connector was extremely hot to the touch. The contact had the vehicle towed to an independent mechanic where it was diagnosed and determined that the battery, alternator, and the Engine Control Module (ECM) needed be replaced. The vehicle had not been repaired. The contact researched online and related the failure to NHTSA Campaign Number: 17V435000 (Electrical System). The manufacturer had been informed of the failure. The failure mileage was approximately 118,000.
Engine, Nov 14, 2022
The Engine seized due to rod bearing Chrysler has recall number 11V487000 it has never been done on my truck and is no showing
Electrical system, Nov 7, 2022
While driving, the ignition switch may fail and think that the key has been removed. This results in a total loss of power and the engine cutting off. The result is very limited steering and braking capability. This has happen to me more than 20 times in the pass 2 months. This problem still continues to happen even after changing the recent fuel pump recall on August 12, 2022. No check engine light on dash as well. This is my family vehicle and I do carry my children in this vehicle. We have been put in so many unsafe situations. This can cause an accident. This is a safety issue and should be recalled.
Electrical system, Sep 29, 2022
The contact owns a 2012 Dodge Durango. The contact received notification of NHTSA Campaign Number 19V813000 (Electrical System) however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that while starting the vehicle, the vehicle would start and then immediately stall. The contact stated that multiple attempts were needed to restart the vehicle. The contact was informed that the failure was related to the recall. The failure mileage was 150,000. Parts distribution disconnect.
Other or unspecified, Sep 27, 2022
Wireless Ignition Module (WIN Module) failed.
Power train, Sep 19, 2022
upon approach to a left turn yield, I attempted to accelerate into traffic when the automatic transmission failed into 4th gear ( transmission shift solenoid) and was unable to shift up or down through the gears and was unable to shift into the drive position. there were no other indications of failure prior to this point, I.E no engine or transmission warning lights. if there would have been oncoming traffic at the time of entry into the flow of traffic it may have caused a catastrophic rear end accident due to the vehicle inability to accelerate as usual. will have the vehicle serviced immediately. this has happened once before with the same vehicle approximately 2 years ago and the transmission shift solenoid was the issue and had been replaced by a local service center at the time.
Electrical system, Exterior lighting, Aug 30, 2022
My 2012 dodge durango sxt, rear turn signal stop flashing, front turn signal works, but not the rear .no turn signal or brakes lights
Electrical system, Service brakes, Aug 15, 2022
I just got a 2012 dodge durango 08/13/2022 I looked up the recalls on it and just trying to get it ixed if possible
Air bags, Seats, Aug 9, 2022
The headrest deployed under normal driving conditions. A quick google search shows I'm not the only one with this issue. Some have described this issue as the headrest "exploding" since it disengages in a very quick and forceful manner. Some Dodge Durango Models from 2011 - 2018 fall under recall "(X88) Active Head Restraint" but for some reason I'm being told my 2012 Dodge Durango does not fall under this same recall.
Electrical system, Aug 8, 2022
The contact owns a 2012 Dodge Durango. The contact stated that after stopping the vehicle, the vehicle lost motive power and stalled. The failure occurred approximately 60-seconds after stopping the vehicle. The vehicle was taken to the local dealer who was unable to determine the cause of the failure. The manufacturer was notified of the failure but no assistance was offered. The contact stated that the vehicle was previously serviced under NHTSA Campaign Number: 19V813000 (Electrical System) however, the vehicle experienced the failure listed in the recall. The failure mileage was 136,496.
Steering, Engine and engine cooling, Aug 3, 2022
The contact owns a 2012 Dodge Durango. The contact stated that while driving at various speeds, the vehicle lost motive power. The contact stated that the power steering became inoperable. There was no warning light illuminated. The A/C unit and the radio remained operational. The vehicle was taken to the local dealer on multiple occasions where it was diagnosed and determined that the computer module, crank sensor, and wiring bypass needed to be replaced. The vehicle was repaired but the failure recurred. The manufacturer was notified but no additional assistance was provided. The failure mileage was approximately 79,124.
Electrical system, Exterior lighting, Fuel/propulsion system, Apr 26, 2022
My 2012 Dodge Durango has been experiencing reaccering issues associated with the tipm and fuel pump relay. The truck will stall, hard crank or simply not crank at all; leaving me stranded sometimes. This electrical issue also affects the fog lights, front lights, brake lights and turn signals; causing them to not work; putting me in danger of a collision on the highway or city street. This tipm and fuel pump relay have been under several recalls over the past 8 years and Dodge actually lost a class action lawsuit in 2015 in reference to this issue. They were ordered to replace these parts free of charge; labeling the parts defective. See link to tipm/relay article here (https://www.classlawgroup.com/chrysler-totally-integrated-power-module-tipm-lawsuit/ and here https://topclassactions.com/lawsuit-settlements/closed-settlements/dodge-jeep-faulty-fuel-pump-class-action-settlement/ ) They’ve replaced both of these parts twice for me over the past 6 years. Now I am experiencing issues where the car won’t start for 20 minutes after I turn it off. The signal lights won't work correctly; and the foglights are totally inoperative. I’ve taken it back to the dealer for a diagnostic and also called the corporate office but no one wants to take accountability and acknowledge what the issue is. I have attempted to contact the lawyer who started the class action lawsuit to consult about this matter but he says he can't sue them again. I’m looking to see if I have any legal recourse or what my best course of action could be in order to hold Dodge accountable for replacing my tipm and fixing this defective part for good. Thanks! REPAIR TIMELINE: 2016 fuel pump relay 2017 Tipm 2018 Rewired the tipm, replace 2020, fuel pump relay - september 2022, fuel pump PS - I have a video of the dealer technician recording the issue with his mobile phone.
Engine, Apr 22, 2022
Engine light on, car was over a month for repair at Rairdon Dodge in Redmond, WA, paid over 5000 in repair, in the end they said can not be fixed needs a new engine. Engine light was on again after 49 miles , misfire cilinder 1, 3, 5 . And fuel pump again. Rairdon contacted Chrysler and nothing. Thanks
Electrical system, Engine, Fuel/propulsion system, Mar 31, 2022
Potential odometer rollback indicated per carfax, engine failure. Ohio department of public safety, bureau of motor vehicles did conduct a Ohio out of state vehicle inspection on 03/14/2022 @ BMV INVESTIGATIONS D-2@ 1583 Alum Creek Drive and inspector [XXX] has verified rollback. whereas she maybe reached at [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Engine and engine cooling, Mar 29, 2022
The contact owns a 2012 Dodge Durango. The contact stated while driving approximately 70 MPH, the vehicle started overheating. The contact pulled safely off the highway and turned the vehicle off and waited for nearly an hour before restarting the vehicle and driving back to her residence. The contact stated that the check engine warning light was illuminated. The contact had the vehicle towed to an independent mechanic who diagnosed the vehicle and determined that the thermostat needed to be replaced. The failure persisted. The thermostat and water pump were replaced by an independent mechanic. The vehicle continued experiencing the overheating failure. The vehicle was towed to a dealer where the thermostat and water pump were replaced a second time. The failure recurred. The manufacturer had been informed of the failure. The failure mileage was approximately 122,400.
Engine and engine cooling, Mar 25, 2022
The contact owns a 2012 Dodge Durango. The contact stated while driving approximately 25 MPH, the vehicle started lagging. The contact stated that the check engine warning light was illuminated. The contact parked the vehicle on the side of the road and noticed the engine coolant was low, but no leaks were found. The contact was able to drive to her residence. The contact stated coolant was added. The contact stated the coolant was low again shortly after filling the reservoir. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 140,000.
Steering, Electrical system, Seat belts, Feb 1, 2022
Unknown
Electrical system, Jan 31, 2022
The contact owns a 2012 Dodge Durango. The contact received notification of NHTSA Campaign Number: 19V813000 (Electrical System) however, the part to do the recall repair was unavailable. The contact called two local dealers and was informed that she would receive a call back whenever an appointment was available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Electrical system, Jan 11, 2022
The contact owns a 2012 Dodge Durango. The contact received notification of NHTSA Campaign Number: 19V813000 (Electrical System) however, the part to do the recall repair was unavailable. The vehicle was taken to the local dealer and it was confirmed that parts were not yet available. The contact was informed about the waiting list. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified however, no further assistance was provided. The contact had not experienced a failure. Parts distribution disconnect.