2020 Forest River Flagstaff
Problems, recalls and owner-reported issues
Tires is the leading concern among 11 owner complaints filed for this model year. This is the highest complaint count among 9 Flagstaff model years with reports.
1 person was injured.
What owners report most often
Recalls and investigations
TiresNov 19, 2019
Forest River, Inc. (Forest River) is recalling certain 2020 Rockwood RLF8298KS and Flagstaff FLF8529RLS recreational trailers. Due to improper tire clearance, the tire may contact the steel chassis outrigger, possibly resulting in tire failure.
Tire failure can cause a loss of vehicle control, increasing the risk of a crash.
Forest River will notify owners, and dealers will install a new outrigger to achieve the proper tire clearance, and damaged tires will be replaced, free of charge. The recall began December 10, 2019. Owners may contact Forest River customer service at 1-574-642-8954. Forest River's number for this recall is 10C-1116.
Campaign 19V827000 on NHTSA.gov
Trailer hitches, fifth wheel assemblyAug 2, 2019
Forest River, Inc. (Forest River) is recalling certain 2019-2020 Flagstaff and Cherokee Arctic Wolf recreational trailers equipped with MORyde Orbital or You Turn Rubber Pin Box Wedge Kits. The pin boxes may have been equipped with bolts 1-3/4" in length when they should be equipped with 2" long bolts.
The incorrect bolts may allow the rotating pin box to rotate in two places, increasing the risk of a crash.
Forest River will notify owners, and dealers will inspect the bolts and replace them as necessary, free of charge. The recall began August 27, 2019. Owners may contact MORyde customer service at 1-574-293-1581 or Forest River customer service at 1-574-642-8954 (Flagstaff) or 1-260-499-2100 (Cherokee). Forest River's number for this recall is 51-1065.
Campaign 19V570000 on NHTSA.gov
Representative owner complaints: other or unspecified
4 reports, newest first. Show all
Other or unspecified, Apr 14, 2024
The structure supporting the fresh water tank is insufficient to carry the weight when full of water. The 36 inch long support bars sag ~2 inches when the tank is full, and the tank itself sags another 1.5 inches between the bars. There have been numerous accounts of these tanks detaching and falling out while travelling on the highway, posing a risk to other drivers.
Other or unspecified, Structure, Equipment, Jun 21, 2023
The fabric side wall failed to keep my daughter safe as she slept in the camper. She fell out of the camper onto the hard, cold ground while she was sound asleep. She could have been seriously injured. The Velcro on the fabric was secured to the camper frame.
Other or unspecified, Dec 30, 2022
The RV came with a heated mattress which I would often used to pre-heat the mattress before going to bed. On 11/23/2022, I turned the mattress heater on level 4 & went out of the camper. After about an hour, the smoke alarm went off & I came into the camper to find a very strong toxic odor. I found the smell was coming from the mattress & immediately turned off the heater. Upon further investigation, I saw a burn hole in the bedding & discovered the mattress smoldering. I feel fortunate that I was not sleeping with the mattress heater on when this occurred & fear the various alternative situations this may have caused. I have notified the RV dealer, as well as the RV, mattress & heating control manufacturers. They have responded but have not notified me as to a resolution or further investigation. The mattress, bedding & the heater control unit are available for inspection. I have made no contact with the fire or police department or my insurance company as I discovered the smoldering mattress before it actually caught fire.
Other or unspecified, Apr 20, 2021
TIRES ARE PREMATURELY CRACKING AND POSE A SAFETY ISSUE BECAUSE THEY MAY FAIL AND BLOWOUT AT HIGH SPEED. CONDITIONS EXIST ON ALL FOUR TIRES. ALL TIRES SHOW SIDEWALL CRACKS AND SEPARATION CRACKS WHERE TREAD MEETS THE SIDEWALL.