2015 Forest River Shasta
Problems, recalls and owner-reported issues
Structure is the leading concern among 46 owner complaints filed for this model year. This is the highest complaint count among 3 Shasta model years with reports.
1 person was injured.
What owners report most often
Recalls and investigations
Equipment, other, labelsMay 22, 2015
Forest River, Inc. (Forest River) is recalling certain model year 2013-2015 Coachmen Shasta SHT27RL travel trailers manufactured May 7, 2013, to May 7, 2015. The affected trailers may have an incorrect gross vehicle weight rating (GVWR) information stated on the Federal Weight Tags. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Incorrect GVWR information on the label may lead the operator to load the trailer to an incorrect weight, increasing the risk of a vehicle crash.
Forest River will notify owners, and dealers will replace the incorrect label with a corrected label, free of charge. The recall began on June 23, 2015. Owners may contact Forest River customer service at 1-574-825-8717. Forest River's number for this recall is 53-05132015-0035.
Campaign 15V303000 on NHTSA.gov
Representative owner complaints: structure
18 reports, newest first. Show all
Structure, Nov 22, 2017
THE FRAME WELDS WERE INADEQUATE AND HAVE BROKEN AWAY ON THE FRONT PART OF THE TRAILER NEAR THE TONGUE. THE CENTER CROSS MEMBER BETWEEN THE TONGUE IS DANGLING. IT IS A 2015 SHASTA 1961 RE-ISSUE 16 FOOT TRAILER. IT IS CLEARLY AN EXAMPLE OF SHODDY WORKMANSHIP, AND IS DEFINITELY A DANGEROUS SAFETY ISSUE. I AM NOT SURE WHEN THIS HAPPENED. I ONLY BECAME AWARE OF THE PROBLEM AFTER OTHER OWNERS OF THIS SAME MODEL TRAILER BROUGHT THE PROBLEM TO LIGHT. THIS IS NOT THE FIRST SAFETY ISSUE WITH THESE TRAILERS
Structure, Other or unspecified, Oct 26, 2017
MOVEMENT OF FRAME AWAY FROM TRAILER BODY. MOVEMENT OF TRAILER TONGUE AWAY FROM BODY AND SEPARATION OF BENCHES IN FRONT OF TRAILER INTERIOR. LAG SCREWS SHEARED OFF IN FRONT OF TRAILER WHERE THEY GO HORIZONTALLY THROUGH FRONT BODY AND IN TO FRAME OF TRAILER. WELDS MISSING FROM FRONT FORK OF TRAILER. FORK WELDED ON ONE SIDE ONLY. HORIZONTAL MOVEMENT OF TRAILER TONGUE AND FORK FROM BODY WHEN ON JACK STANDS.
Suspension, Structure, Other or unspecified, Oct 15, 2017
THE 19' FOOT TRAVEL TRAILER HAS SEPARATION OF THE INSIDE WALL AT FLOOR AND DINETTE BENCH FROM THE FRAME.
Suspension, Structure, Apr 10, 2017
AFTER NUMEROUS PHONE CALLS AND EMAILS TO GET LAZY DAYS IN COLORADO TO COMPLETE REQUIRED AND AGREED UPON RECALL WORK DONE ON MY CAMPER, THEY CONTINUE TO FAIL TO DO SO. THEY USE STALL TACTICS TO DISCOURAGE ME FROM GETTING THE WORK DONE. MY CAMPER HAS BEEN SITTING ON THEIR LOT FOR 4 WEEKS NOW AND THEY STILL HAVE NOT ORDERED PARTS. THIS HAS BEEN GOING ON SINCE 2015 WHEN I BOUGHT THE CAMPER NEW FROM THEM. MY CAMPER WAS ON THEIR LOT FOR 5 MONTHS AT THAT TIME FOR RECALL WORK AND OTHER WORK. I DON?T NEED FREE STORAGE, I HAVE 5 ACRES AT MY HOUSE TO STORE IT ON. I HAVE CONTACTED THEM ON 12/14/16, 1/4/17, 1/7/17, 2/17/17, 2/15/17, 2/28/173/1/17, 4/3/17, 4/4/17, 4/6/17, 4/8/17. SOMETIMES I RECEIVE A RESPONSE SOMETIME I DO NOT. MY LAST REQUEST 4/6/17, WAS TO MEET PERSONALLY WITH MANAGERS TO GET AN UPDATE ON PARTS ORDERED AND WHEN I COULD EXPECT THE RECALL WORK ON MY CAMPER TO BE COMPLETED. I HAVE NOT RECEIVED A RESPONSE. I HAVE A MORE DETAILED LETTER, BUT IT GOES OVER YOUR CHARACTER COUNT LIMIT. RECALLS ARE FOR: 2015 FOREST RIVER SHASTA AIRFLYTE CAMPER TRAILER VIN #[XXX] RECALLS: NHTSA # 16V-218 NHTSA # 15V-552 NHTSA # 15V-553 NHTSA # 15V-369 FOREST RIVER TECHNICAL SERVICE BULLETIN- DOCUMENT CONTROL # 53-05112016-0191 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Structure, Other or unspecified, May 9, 2016
NHTSA RECALL NUMBER:15V553 I TOOK MY CAMPER IN FOR WINDOW RECALL WORK IT SAT FROM JAN TILL MID APRIL AND WAITED FOR THE WINDOWS TO COME IN TO BE REPLACED AND I WAS TOLD THEY ALL WERE REPLACED. THE CAMPER WAS PARKED AND I WHEN I OPENED THE WINDOWS TO LET SOME FRESH AIR IN THE CAMPER THE TOP WINDOW GLASS PULLED LOOSE FROM ITS ALUMINUM HINGE AND WAS DANGLING FROM THE MECHANISM THAT OPENS AND CLOSES THE WINDOW. I CONTACTED SHASTA WARRANTY DEPARTMENT ONCE THE WINDOW FELL OUT AND HE LOOKED UP MY CAMPERS REPAIR HISTORY AND THE ONLY WINDOWS THAT DIDN'T PASS INSPECTION AND HAD TO BE REPLACED WAS BACK WINDOW AND THE 2 UP FRONT. I WILL BE RETURNING FOR A WINDOW REPLACEMENT. SO IT LOOKS LIKE EVEN IF THE WINDOWS PASS THE INSPECTION THEY STILL CAN FALL OUT...
Structure, May 1, 2016
TRAILER ENTRY DOOR BECOMES JAMMED AND IS NOT ABLE TO BE OPENED FROM THE INSIDE OF THE TRAILER. THIS HAPPENED ON SEVERAL OCCASIONS. THIS POSES A SERIOUS SAFETY RISK FOR ANYONE THAT MIGHT BE TRAPPED INSIDE THE TRAILER.
Structure, May 1, 2016
THIS TRAILER WAS MISSING SUPPORT/BRACING FOR THE FRONT END. THIS ISSUE HAS BEEN LINKED TO COLLAPSING OF THE FRONT END OF THE TRAILER. AFTER BEING "FIXED" THERE IS DAYLIGHT COMING THROUGH THE FRONT END OF THE TRAILER. THE TWO WALL PIECES ARE ALSO PULLING APART. I HAVE RECEIVED NO RESPONSE FROM EMAIL TO FOREST RIVER OR THE DEALER/REPAIR SHOP ASKING THEM TO ADDRESS THIS PROBLEM.
Structure, Apr 11, 2016
THE FRONT END OF MY SHASTA IS SAGGING AND BUCKLING DUE TO BEING STRUCTURALLY COMPROMISED. IT HAS BEEN REPAIRED BY THE DEALER 3 TIMES. I WAS TOLD BY THE SERVICE DEPARTMENT THAT IT HAD BROKEN LAG BOLTS AND/OR DID NOT HAVE ENOUGH LAG BOLTS. THE FRONT PANEL IS LEANING ON AND TOUCHING THE PROPANE TANK. I AM CONCERNED ABOUT THE POSSIBILITY OF A LEAK OR EVEN WORSE IT BUCKLING CAUSING THE WORST CASE SCENARIO A FIRE OR EXPLOSION. I AM ALSO AWARE THAT I AM NOT THE ONLY OWNER THAT HAS THIS DEFECT AND CONCERN. I HAD A 550 MILE TRIP PLANNED FOR MAY 5 AND HAVE CANCELLED AND AM RENTING A CABIN BECAUSE I AM FEARFUL TO TOW IT THAT FAR. SAFETY IS MY NUMBER ONE CONCERN, AND I FEEL THAT THIS COMPROMISES THE SAFETY OF MYSELF, MY PASSENGERS, AND OTHER MOTORISTS.
Structure, Oct 22, 2015
TL* THE CONTACT OWNS A 2015 FOREST RIVER SHASTA. WHILE PARKED, THE ESCAPE WINDOW OF THE CAMPER TRAILER SUDDENLY DETACHED. THE TRAILER WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ADHESIVE USED FAILED. THE CAMPER WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Structure, Other or unspecified, Equipment adaptive/mobility, Aug 27, 2015
I WAS WASHING MY CAMPER AND I WAS CUT A FEW TIMES ON ROUGH METAL BURR WHERE THE METAL WAS CUT/BROKEN ON BUMPER, AND A PIECE OF METAL STICKING OUT OF MY WING OF MY CAMPER.. I WAS ABLE TO STOP THE BLEEDING AND DIDN'T GO TO THE DOCTOR...
Structure, Other or unspecified, Equipment adaptive/mobility, Aug 22, 2015
AFTER RETURNING MY CAMPER FOR MANY REPAIRS WHICH INCLUDES THE BACK WINDOW POPPING OPEN WHILE IN TRANSIT.. WE GET HOME FROM CAMPING AND SEE THE EMERGENCY BACK WINDOW LEVER ARM HANGING DOWN THE BACK OF THE CAMPER SO IT POPPED OPEN DOWN THE ROAD AGAIN! WE HAD ONE MORE CAMPING TRIP SO I CLOSED THE WINDOW AND I PUT A REUSABLE VELCRO STRAP AROUND THE WINDOW LEVER TO TRY AND KEEP IT CLOSED BUT WE WENT ON THE NEXT TRIP WE STOP TO GET GAS AND THE WINDOW WAS OPEN AGAIN SO I ADDED A TOTAL OF 3 STRAPS AND IT TEMPORARILY FIXED THE WINDOW TILL WE TOOK THE CAMPER BACK TO THE DEALERSHIP FOR THE 4TH TIME...
Structure, Other or unspecified, Equipment adaptive/mobility, Aug 22, 2015
WHEN MY DOOR GOT STUCK AND WOULD NOT OPEN THE SKIN OF THE DOOR ALSO CAME LOOSE AND I HAD TO STOP AND DUCT TAPE THE METAL TO THE DOOR SO IT WOULDN'T RIP OFF ALL THE WAY OFF OR FLOP AROUND WHILE IN TRANSIT
Structure, Other or unspecified, Aug 22, 2015
THE DAY BEFORE WE WERE TO LEAVE AND GO CAMPING I WAS LOADING CAMPING STUFF INTO THE CAMPER AND THE DOOR BECAME STUCK AND WOULD NOT OPEN IT WAS VERY HOT THAT DAY LUCKILY I WASN'T TRAPPED IN THE TRAILER BECAUSE I WAS HOME ALONE AND MY CELL PHONE WAS IN THE HOUSE! I NOW TRY TO MAKE SURE THE PHONE IS ON ME IF I'M TO BE IN THE CAMPER INCASE THAT EVER HAPPENS WHILE I'M INSIDE. SO INSTEAD OF LEAVING TO THE CAMPGROUND ON TIME WE HAD TO GO 45 MILES IN THE WRONG DIRECTION FOR THEM TO OPEN THE DOOR SO WE COULD USE THIS CAMPER. WE ARRIVED 9:30 AM AND IT TOOK TILL 5:30PM FOR THEM TO FIX IT.
Structure, Other or unspecified, Aug 22, 2015
WHEN I TOOK MY CAMPER BACK TO THE DEALERSHIP BECAUSE IT LEAKED THE DAY I BOUGHT IT, THE BACK WINDOW POPPED OPEN AND WAS FLAPPING ON THE WAY TO DEALERSHIP. IF IT WOULD HAVE BUSTED OR CAME LOOSE THAT COULD HAVE CAUSE A BAD ACCIDENT... RETURNED TO THE DEALERSHIP TO BE REPAIRED..
Structure, Tires, Aug 3, 2015
TL* THE CONTACT OWNS A 2015 FOREST RIVER SHASTA. THE CONTACT STATED THAT THE VEHICLE'S TIRE PRESSURE WAS NOT COMPATIBLE WITH THE MANUFACTURER REQUIREMENTS. IN ADDITION, THE WHEEL WELL WAS SPLIT OPEN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 1,500. THE VIN WAS NOT AVAILABLE.
Suspension, Structure, Equipment, May 29, 2015
TL* THE CONTACT OWNS A 2015 FOREST RIVER SHASTA. THE CONTACT STATED THAT THE WHILE DRIVING AT APPROXIMATELY 50 MPH, THE RV WAS BOUNCING WITHOUT WARNING. THE CONTACT PULLED OVER AND DISCOVERED THAT THE WHEEL WELL WAS FRACTURED. IN ADDITION, THE CONTACT STATED THAT THE ROOF OF THE RV WAS LEAKING. THE CONTACT ALSO STATED THAT THE EMERGENCY EXIT WINDOW OPENED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE WHEEL WELL NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 37. *BF
Structure, May 18, 2015
SHASTA MODEL 2015 AIRFLYTE 16 RE-ISSUE - REAR GLASS FOR EMERGENCY EXIT WINDOW FELL OUT. FORTUNATELY THE VEHICLE WAS NOT IN MOTION ON PUBLIC ROAD AT THE TIME.
Suspension, Structure, Latches/locks/linkages, Tires, Equipment, May 11, 2015
TL* THE CONTACT OWNS A 2015 FOREST RIVER SHASTA. THE CONTACT OBSERVED THAT THE SUSPENSION OF THE VEHICLE WAS LOW, WHICH RESULTED IN THE VEHICLE BEING LESS THAN AN INCH FROM BOTH OF THE SIDE TIRES. THE FAILURE RECURRED CONTINUOUSLY. THE RV WAS TAKEN TO A DEALER, WHERE IT WAS DIAGNOSED THAT THE VEHICLE NEEDED A SHACKLE INSTALLED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 84. THE CONSUMER STATED THE TIRES WERE UNSAFE AFTER LITTLE USE DUE TO THE SIDE OR TOP RUBBING ON THE COACH. THE DOOR LOCKS FAILED AND AS A RESULT, THE CONSUMER AND HER CHILDREN WERE LOCKED INSIDE. UPDATED 09/09/15. *JB THE GLUE ON THE WINDOWS FAILED AND THE GLASS BECAME LOOSE FROM THE FRAME. UPDATED 10/07/15. *JB